View
215
Download
0
Category
Preview:
Citation preview
8/12/2019 312-09 Zaman
1/10
440
Vol. 28, 2010, No. 5: 440449 Czech J. Food Sci.
Occurrence of Biogenic Amines and Amines Degrading
Bacteria in Fish Sauce
M Z ZAMAN1, F A BAKAR1, J SELAMAT1
and J BAKAR2
1Department of Food Science and 2Department of Food Technology, Faculty of Food Science
and Technology, Universiti Putra Malaysia, Serdang, Selangor, Malaysia
Abstract
Z M.Z., B F.A., S J., BJ. . (2010): Occurrence of biogenic amines and aminesdegrading bacteria in fish sauce. Czech J. Food Sci., 28: 440449.
he contents of biogenic amines histamine, putrescine, and cadaverine in fish sauce were determined and the bacte-
ria isolated from the samples were evaluated for their amines degradation activity. Five fish sauce samples contained
62.5393.3 ppm of histamine, 5.6242.8 ppm of putrescine, and 187.1704 .7 ppm of cadaverine. hirty three bacterial
isolates produced all three amines, seven isolates produced one or two amines, and one isolate did not produce any
amine in differential agar media. Since the strains that produced amines were not supposed to degrade them, only
eight isolates were further identified and evaluated for their amines degrading capability. Bacillus amyloliquefaciens
FS-05 and Staphylococcus carnosusFS-19 degraded histamine up to 59.9% and 29.1% from its initial concentration,respectively. Staphylococcus intermediusFS-20 and Bacillus subtilis FS-12 degraded putrescine and cadaverine up to
30.4% and 28.9%, respectively. Most isolates tolerated the salt concentration of up to 15% and temperature of up to 45C.
he current study provided new information on biogenic amines degrading bacteria, isolated from high-salt-content
food products. he amines degradation activity of the bacteria is considered as strain rather than species specific.
Keywords: fish sauce; biogenic amines; amines degradation; Bacillus amyloliquefaciens; Staphylococcus carnosus
Biogenic amines are low molecular weight basicnitrogenous compounds occurring in many foods,
mainly due to the amino acids decarboxylationactivities of certain microbes (H et al. 1994;K & K 1998). heir presence is undesir-able because it can result in toxicological effectsto consumers such as hypertension, headache,diarrhea, rash, and localised inflammation wheningested in excessive amounts (H et al. 1994;S 1996). Biogenic amines are widely pres-ent in food products, especially fermented foodssuch as fish sauce, cheese, beer, and sauerkraut(H et al. 1994; S 1996). Fish sauce
is a popular fermented fish product used as acondiment in Southeast Asia. It is considered an
important source of dietary proteins and aminoacids. It contains about 20 g/l of nitrogen 80% of
which is in the form of amino acids (S etal .1996). Despite its nutritional value, severalauthors reported the presence in fish sauce ofhigh levels of biogenic amines predominated byhistamine, putrescine, cadaverine, and tyramine(M et al.2002; S et al.2002; C et al.2006; et al.2006). yramine was present atlower levels and was occasionally found in consider-able amounts in some samples (S et al. 2002;C et al. 2006; S et al. 2009). Other aminessuch as phenylethylamine, spermine, spermidine,and agmatine are considered as trace amines infish sauce (M et al.2002; S et al.2002;
8/12/2019 312-09 Zaman
2/10
441
Czech J. Food Sci. Vol. 28, 2010, No. 5: 440449
et al.2006). Histamine is considered as themost active amine and is related to almost allfood amines poisoning incidences. Furthermore,the occurrence of putrescine and cadaverine canpotentiate and enhance the toxicity of histamine(S 1996). Unfortunately, it is very dif ficultto remove amines from food products once theyare formed, even with the heat treatment such asautoclaving (L et al.1992).
Biogenic amines are physiologically degradedthrough oxidative deamination catalysed by aminesoxidase by the following reaction: R-CH
2-NH-R' +
O2
+ H2OR-CHO + H2N-R' + H2O2 (M
et al.1979; I et al.1993; Y et al.1993). Monoamine and diamine oxidases are ubiq-uitous and play an important role in the metabo-
lism of amines in human, plant, and animal cells.Furthermore, these enzymes have also been foundin some bacterial strains. Monoamine oxidasewas found in some strains ofEnterobacter iaceaefamily such asKlebsiella,Enterobacter,Eschericia,Salmonella, Serratia, and Proteus (M etal .1979). I et al. (1993) reported that
Micrococcus rubenspossesses putrescine oxidase.Some strains of the food fermenting microorgan-isms such asMicrococcus sp. andBrevibacteriumlinensexhibit the ability to degrade histamine
and tyramine, while the strains of Lactobacil lusplantarum,Lactobacillus sake,Lactobacillus pen-tosus, and Pediococcus acidilact ici only degradehistamine (L et al.1998). M- et al.(2000) also found that some strainsof Staphylococcus xylosusisolated from artisanalfermented sausages had a remarkable ability todegrade histamine and tyramine. Since the lastfew years, the potential role of microorganismspossessing amines oxidase activity has become ofa particular interest in the prevention or reduc-tion of biogenic amines accumulation in food
products, especially fermented food. Land H (1998) reported that MicrococcusvariansLH 1540 decreased a huge amount oftyramine during ripening of fermented sausages.Reduction of histamine and tyramine accumula-tion in salted and fermented anchovy was reportedwhen Staphylococcus xylosushad been applied asthe protective culture (M & H 2009). heformation of tyramine, putrescine, and cadaverinein sauerkraut was significantly suppressed by theinoculation withLactobacillus plantarum(K
et al. 2000). However, no literature data are knownon the degradation of biogenic amines by bacteria
from fish sauce. Hence, the purpose of this researchwas to isolate bacteria from fish sauce and exam-ine their amino acid decarboxylation activity. heselected isolates were examined for their abilityto degrade amines, namely histamine, putrescine,and cadaverine. Biogenic amines content in fishsauce was also determined. he finding of thisresearch was expected to provide some informa-tion on amines degrading bacteria originated fromhigh-salt-content products such as fish sauce.
MATERIAL AND METHODS
Fish sauce sample s. Five fish sauce sampleswere obtained from different traditional factories
in umpat, Kelantan, Malaysia. he samples weretransported for analysis in sealed glass bottles atambient temperature to the Laboratory of FoodSafety and Quality, Faculty of Food Science andechnology, Universiti Putra Malaysia. All sampleswere made from anchovy and were fermented withsea salt for 6 months (2 samples) and 12 months(3 samples) at ambient temperature. he starterculture or proteolytic enzymes were not appliedduring the samples fermentation. he samples wereused for microbiological analysis immediately after
their arrival in the laboratory and the rest werestored at 4C prior to chemical analysis.Determination of pH value and salt content.
he pH value of fish sauce was determined by directmeasurement with an electronic pH meter (Mettleroledo 8603, Schwerzenbach, Switzerland). hesalt content of each sample was determined witha salt meter (Atago ES-421, okyo, Japan) afterten fold dilution.
Analysis, isolation, and identification of bacte-
ria. he samples (25 ml) were mixed with 225 ml ofpeptone water containing 0.85% of sodium chloride
and then homogenised in stomacher bag (Bagmixer400, Model L, Interscience, Paris, France) for 2 min-utes. Further, ten fold dilutions were made and then100 l of each dilution was spread onto agar plates.Aerobic plate count agar and skim milk agar, bothsupplemented with 3% of sodium chloride, wereused to determine total aerobic and proteolyticbacteria count in fish sauce, respectively. he bacte-rial colonies were counted after the plates incuba-tion at 37C for 48 hours. he bacterial numberswere then expressed as log colony forming unit
(CFU)/ml. o isolate bacteria from fish sauce, eachsample (25 ml) was separately added to 225 ml of
8/12/2019 312-09 Zaman
3/10
442
Vol. 28, 2010, No. 5: 440449 Czech J. Food Sci.
trypticase soy broth (Merck, Darmstadt, Germany)supplemented with 3% of sodium chloride in 500 mlflask. he flasks were then shaken (100 rpm) inan incubator (Infors, Bottmingen, Switzerland) at37C for 24 hours. he cultures were spread ontrypticase soy agar plates supplemented with 3% ofsodium chloride and were then incubated at 37Cfor 48 hours. he bacterial colonies that developedon the plates were picked based on their coloniesappearance and subsequently streaked on freshtrypticase soy agar plates until pure isolates wereobtained. he isolates were then screened for theirdecarboxylase activity toward histidine, ornithine,and lysine (Sigma-Aldrich, St. Louis, USA) in dif-ferential medium proposed by J and N- (1989). he colour change of the medium
surrounding the bacterial colonies from yellow topurple indicated that the particular bacteria coulddecarboxylase amino acids. Based on the results,the isolates which did not possess the three aminoacid decarboxylase activities were selected for thebiogenic amines degradation studies. hese isolateswere identified using Gen III Microlog IdentificationSystem (Hayward, USA). he bacterial culture andidentification procedure were performed followingfrom the manufacturers instruction.
Bi og en ic am in es de grada tio n by ba ct er ial
isolates. Biogenic amines degradation test wascarried out according to the method developedby L et al.(1998). An overnight cultureof each isolate was harvested, washed with 0.05Mphosphate buffer (pH 7), and the cell pellet wasresuspended in 0.05M phosphate buffer supple-mented with 100 ppm of histamine, putrescine, andcadaverine (Merck, Darmstadt, Germany). he cellsuspension (20 ml) adjusted to a concentration of107cells/ml was incubated in a 100 ml f lask for 24 hat 37C, under shaking at 150 rpm. he sampleswere then taken and added to an equal amount
of 1M HCl (Merck, Darmstadt, Germany). hemixture was boiled for 10 minutes and centrifuged(Sigma 3-18K, Sartorius, Gettingen, Germany) at9000 g for 10 minutes. he supernatant was frozenat 20C prior to biogenic amines analysis.
Screening for the tolerance to various ranges
of the environmental factors. A trypticase soybroth medium was used in this series of studies.An overnight culture of each isolate was usedas an inoculum from which cells were obtainedby centrifugation and were then resuspended in
10 ml of 0.85% saline. 100 l of each cell suspen-sion was inoculated into individual bottles. he
temperatures tested were 30C, 37C, 45C, 50C,and 55C, the concentrations of NaCl were 0%,5%, 7%, 10%, and 15%, and the pH values testedwere 5, 6, 7, 8, and 9. o achieve the desired pH
value, the medium was adjusted with 1M HCl or1M NaOH. he bottles were then incubated for48 h at a specific temperature or at 37C for thetest of pH and salt concentration. At the end ofthe incubation, the turbidity in each bottle wasconsidered as the growth indication.
Determination of biogenic amines . Biogenicamines in the samples were determined using HPLCaccording to the method proposed by H etal. (1997) and modified by O et al.(2002).Briefly, the fish sauce samples were transferredto 50 ml centrifuge tubes and homogenised with
20 ml of 6% trichloroacetic acid (Merck, Darm-stadt, Germany) for 3 minutes. he homogenateswere centrifuged at 10 000 g for 10 min at 4C)and filtered through Whatman paper No. 1. hefiltrates were then placed in a volumetric flask and6% trichloroacetic acid was added to a final volumeof 50 ml. A series of mixed standard amine solutionswere also prepared to obtain the standard curve foreach amine. o 1 ml of standard amine solution andeach sample, 1 ml of 2M sodium hydroxide (Merck,Darmstadt, Germany) was added, followed by 10 l
of benzoyl chloride (Merck, Darmstadt, Germany).he solution was mixed using a vortex mixer andthen allowed to stand at 30C for 40 minutes. hebenzoylation was then stopped by adding 2 ml ofsaturated NaCl solution, and the mixture was ex-tracted with 3 ml of diethyl ether (Merck, Darmstadt,Germany). After centrifugation, the upper layer wastransferred into a tube and evaporated to drynessin a stream of nitrogen. he residue was then dis-solved in 1 ml of acetonitrile (Merck, Darmstadt,Germany). HPLC determination was performedwith a Waters 600 controller and a pump, a Waters
in-line degasser, a Waters 2996 photodiode arraydetector, and Empower 2 Software. A SunfireMC
18, 5 m, 150 4.0 mm column (Waters, Milford,
USA) was used with water and acetonitrile as themobile phase set for linear gradient at the flow rateof 1 ml/minute. he sample volume injected was20 l and it was monitored at the wavelength of254 nm. he detection limits for histamine, putres-cine, and cadaverine were 0.16 ppm, 0.09 ppm, and0.07 ppm, respectively. he quantification limitsfor histamine, putrescine, and cadaverine were
0.53 ppm, 0.31 ppm, and 0.24 ppm, respectively.
8/12/2019 312-09 Zaman
4/10
443
Czech J. Food Sci. Vol. 28, 2010, No. 5: 440449
Statistical analysis. he significance of dif-ference was determined by using the analysis of
vari ance (ANOVA). he comparison of meanswas carried out with Duncans multiple rangetests (DMR). Pearsons correlation test was ap-plied to determine the relationship between the
variables in the samples . All statistical analyseswere performed using the Statistical Package forSocial Sciences, SPSS Version 16.0 for Windows(SPSS Inc., Chicago, USA). he value of P < 0.05was used to indicate significant deviations.
RESULT AND DISCUSSION
he values of the pH, salt content, aerobic plate
count (APC), and proteolytic bacteria count infish sauces are presented in able 1. he level ofpH and salt content in all samples ranged from4.8% to 5.7%, and 15.6% to 25.7%, respectively.he results were about in the same range withseveral fish sauces from different countries oforigin as reported by P et al.(2001). he dif-ferences in the salt content between the sampleswere mainly due to the different ratios of fish andsalt applied by manufacturers at the beginning offermentation. It was proved that salt content was
not much changed in the course of fermentation(D et al.2006). L etal.(2001) stated that Malaysian fish sauce pro-ducers use the fish to salt ratio of 35:1. hisratio complies with he Malaysian Food Act 1983and Regulation 1985 which require fish sauce tocontain not less than 15% of salt (A2004). he high salt concentration can preventthe growth of spoilage microorganisms such as
Es cherichiasp., Serratiasp., Ps eudomona ssp.,
and Clostridium sp. in fish sauce (Let al.2001). In general, significant correlationswere found between the pH value, salt content,aerobic plate count, proteolytic bacteria count,and biogenic amines content (able 2). he resultshowed that the levels of biogenic amines in fishsauces depended on other related variables such asaerobic and proteolytic bacteria counts. A correla-tion between aerobic bacteria count and amines,namely putrescine, cadaverine, and tyramine,was also found in other products (V et al.2005). However, no significant correlation wasobserved between putrescine and salt (r= 0.459,
P= 0.085) and histamine and pH (r= 0.501, P=0.057), in agreement with the correlation previ-ously found in fermented fish products in aiwan
( et al.2006).Figure 1 shows the biogenic amines contents in
fish sauce samples. Histamine content ranged from62.5 ppm to 393.3 ppm. Putrescine and cadaver-ine contents ranged from 5.6 ppm to 242.8 ppmand 187.1 ppm to 704.6 ppm, respectively. It wasreported that the highest histamine, putrescine,and cadaverine contents in fish sauce were 1220,1257, and 1429 ppm, respectively (Z et al.2009). Histamine content in all samples exceeded50 ppm, the defect level imposed by the US FDA.
However, none of the samples exceeded the levelof 500 ppm, that is the amount which could behazardous for the consumer health. Fish sauce Bhad a higher content of histamine as comparedto all other samples. his could be attributed tothe higher contents of aerobic and proteolyticbacteria in the particular sample. Biogenic aminesaccumulation in fish products results mainly fromdecarboxylation activity of bacteria toward freeamino acids (B et al.1990). Proteolytic bacteria
able 1. Te value of pH, salt content, aerobic plate count and proteolytic bacteria count of fish sauce
Fish sauce pH Salt content (%)Aerobic plate count Proteolytic bacteria
(log CFU/ml)
A 5.4 0.1c 25.7 0.3c 5.02 0.1a 3.63 0.1a
B 5.7 0.1d 25.3 0.5c 5.53 0.5b 3.97 0.1b
C 5.1 0.1b 18.8 0.3b 4.97 0.1a 3.62 0.2a
D 5.3 0.1c 19.1 0.1b 5.18 0.1ab 3.76 0.1a
E 4.8 0.2a 15.6 0.8a 4.92 0.2a 3.65 0.2a
Te numbers represent mean SD of three replications. Values followed with same letters within a column are not signifi-
cantly different in Duncans multiple range test (P < 0.05)
8/12/2019 312-09 Zaman
5/10
444
Vol. 28, 2010, No. 5: 440449 Czech J. Food Sci.
play an important role in releasing amino acidsfrom the protein ti ssues offering the substratefor decarboxylation activity by amines producingbacteria. Pearsons correlation analysis of the data
revealed a good positive relationship betweenthe aerobic and proteolytic bacteria counts andbiogenic amines contents. Putrescine content inall samples was considered to be in a lower rangeexcept for sample B (242.8 ppm), particularly whencompared to the previous report on Korean fishsauce (C et al.2006). his could be due to the
low presence of putrescine producing bacteriaduring the fermentation of the samples. Unlike ofputrescine, most of samples have a high contentof cadaverine, the level reaching 704.6 ppm in
sample B. Cadaverine content normally increasesduring fish sauce fermentation because more lysine(precursor of cadaverine) is released from the pro-tein complex of fish. P et al. (2001) reportedthat lysine as well as histidine, aspartate, glutamateand alanine, was dominant in most of fish saucesamples. he presence of bacteria capable to de-
able 2. Correlation between biogenic amines content, salt, pH value, aerobic plate count (APC) and proteolyticbacteria
Putrescine Cadaverine Histamine Salt APCProteolytic
bacteria pH
Putrescine 1.000
Cadaverine 0.981** (0.000) 1.000
Histamine 0.923** (0.000) 0.923** (0.000) 1.000
Salt 0.459 (0.085) 0.613* (0.015) 0.571* (0.026) 1.000
APC 0.715** (0.003) 0.764** (0.001) 0.720** (0.002) 0.640* (0.010) 1.000Proteolyticbacteria
0.774** (0.001) 0.833** (0.000) 0.742** (0.002) 0.643** (0.010) 0.610* (0.016) 1.000
pH 0.586* (0.022) 0.689** (0.004) 0.501 (0.057) 0.755** (0.001) 0.555* (0.032) 0.629* (0.012) 1.000
Pearson correlationP-value: *significant at the 0.05 level; **significant at the 0.01 level
a
d
b bc
a
c
a
b
ab
a
c
a
bab
0
100
200
300
400
500
600
700
800
A B C D E
Fishsauces
Concentration(ppm)
Putrescine
Cadaverine
Histamine
Figure 1. Biogenic amines content in fish sauce samples. Bars represent standard deviation of three replicates. Te samecolor histogram marked with same letters are not significantly different in Duncans multiple range test (P< 0.05)
c
b
8/12/2019 312-09 Zaman
6/10
445
Czech J. Food Sci. Vol. 28, 2010, No. 5: 440449
carboxylase lysine will result in the accumulationof cadaverine in the product. Putrescine and cadav-erine are potentiators of histamine toxicity as theyinhibit the histamine-metabolising enzyme in thesmall intestine (S 1996; L & O2000). Hence, the high content of both amines inthe presence of even a small amount of histamine
could possibly alter histamine toxicity.Forty one bacterial isolates were obtained fromfish sauce samples. All were tested and found to begram positive, 33 cocci and 8 rod shaped bacteria.All isolates were qualitatively tested for their amino
acid decarboxylase activity toward histidine, or-nithine, and lysine. hirty three isolates exhibitedthe ability to produce all tested amines in qualita-tive medium. wo isolates produced two amines,five isolates produced one amine, and one isolatedid not produce any amine (able 3). he abilityof bacteria to produce more than one amine hadbeen revealed by many studies. D et al.(2000) suggested that attention must be given tobiogenic amines production when selecting bacteriafor starter culture. Moreover, L et al.(1998) suggested that strains possessing amino aciddecarboxylase activity might not degrade biogenicamines. It is quite difficult to find bacteria withoutany amino acid decarboxylase activity involved infood fermentation, particularly in the products
with a high protein content such as fish sauce.herefore, the isolates which did not produce allthe three amines were further screened for theirability to degrade amines and tolerance to severalenvironmental conditions.
able 3 shows that all isolates had the abilityto degrade the amines tested, although with dif-ferent efficiencies. Histamine is the most activeamine and abundant in fish sauce and other fishproducts. Hence, the isolates that exhibited a highhistamine degradation activity were of particular
interest.Bacillus amyloliquefaciensFS-05 exhib-ited a significantly higher potential to degradehistamine than other isolates (able 4). hese rodshaped bacteria degrade histamine to about 59.9%of its initial content within 24 h, while the other
able 3. Amino acids degradation by bacteria isolated
from fish sauce
Code and identity of isolates
Amino acidsdegradation
His Orn Lys
FS-05 Bacillus amyloliquefaciens + +
FS-12 Bacillus subtilis + +
FS-13 Bacillus humi +
FS-14 Bacillus amyloliquefaciens +
FS-19 Staphylococcus carnosus
FS-20 Staphylococcus intermedius +
FS-22 Staphylococcus condiment +
FS-25 Staphylococcus carnosus +
His histidine, histamine precursor; Orn ornithine, pu-
trescine precursor; Lys lysine, cadaverine precursor
able 4. Biogenic amines degradation by bacteria isolated from fish sauce after incubation in 0.05M phosphate buffersupplemented with 100 ppm of amines for 24 h at 37C
Bacterialisolates
Histamine Putrescine Cadaverine
ppm degradation (%) ppm degradation (%) ppm degradation (%)
FS-05 40.1 6.8 59.9c 92.5 2.6 7.5ab 73.6 2.7 26.4b
FS-12 65.8 3.3 34.2b 70.3 5.2 29.7 c 71.1 9.6 28.9b
FS-13 67.2 5.7 32.8b 85.2 5.5 14.8b 76.1 8.2 23.9b
FS-14 73.4 9.3 26.6b 69.7 6.3 30.0c 77.7 13.9 22.3b
FS-19 70.9 4.3 29.1b 92.1 3.8 7.8ab 91.6 3.6 8.4 a
FS-20 89.1 1.2 10.8a 69.6 5.1 30.4c 71.9 3.8 28.0b
FS-22 72.6 9.4 27.4b 95.6 1.3 4.4a 93.2 2.4 6.8a
FS-25 95.1 3.9 4.9a 86.1 1.2 13.9b 92.6 2.6 7.4a
Te numbers represent mean SD of three replications. Values followed with same letters within a column are not signifi-cantly different in Duncans multiple range test (P < 0.05)
8/12/2019 312-09 Zaman
7/10
446
Vol. 28, 2010, No. 5: 440449 Czech J. Food Sci.
cultures have a lower activity in degrading thisamine. he Bacill i isolated from fish sauce suchas Bacillu s amyloliquefaciens , Bacillu s subtilis,
Bacillus megaterium, andBacillus licheniformisarewell known for their protein degradation activity(F et al.2008). Little is known about the aminedegradation activity of the bacteria belonging tothis genus. In agreement with our results, otherstudies foundBacillus sp. LMG 21002 andBacil-lus megateriumKL-197 isolated from fish sauce
to contain histamine degrading enzymes (K &K 2006). M and H (2009) also describedhistamine degrading enzymes in some strains of
Bacillus coagulans. Histamine degradation activitywas also found in isolates identified as Staphy-lococcus. Staphylococcus condimentFS-22 andStaphylococcus carnosusFS-19 reduced histaminecontent to about 27.4% and 29.1%, respectively.he species of Staphylococcus , common bacteriaisolated from fish sauce, play an important rolein the protein degradation and flavour or aroma
development ( 1991; U & L1996; L et al. 2001; F et al.
2004; Y et al. 2007). Some speciesare known as amines producing bacteria, whileothers are known as amine degrading bacteria.M et al.(2000) observed in their studythat strains of Staphylococcus xylosushad a highability to degrade histamine in a buffer system,degrading up to 100% of histamine. In contrastwith our findings, L et al.(1998) re-ported that strains of Staphylococcus carnosusdidnot possess histamine degradation activity. his
result suggested that amines degradation activitywas not species but strains specific. In additionto histamine degradation activity, we also foundthat the isolates tested in our study had the abilityto degrade putrescine and cadaverine. Bacillusamyloliquefaciens FS-14 andBacillus subtilisFS-12reduced putrescine and cadaverine contents to30.0% and 28.9%, respectively. StaphylococcusintermediusFS-20 degraded 30.4% and 28.0% ofputrescine and cadaverine, respectively. his maybe of further interest since only little informationexists on putrescine and cadaverine degradingbacteria. he activity to degrade putrescine was
able 5. olerance of the bacterial isolates to ranges of temperature, NaCl concentration, and pH
Environmental factorsIsolates
FS-05 FS-12 FS-13 FS-14 FS-19 FS-20 FS-22 FS-25
emperature (C), SB + 5% NaCl, incubated for 48 h30 + + + + + + + +
37 + + + + + + + +
45 + + + + + +
50 + +
55
NaCl concentration (%), SB, incubated at 37C for 48 h
0 + + + + + + + +
5 + + + + + + + +
7 + + + + + + + +
10 + + + + + + + +
15 + + - + + + + -
pH, SB + 5% NaCl, incubated at 37 C for 48 h
5 + + - - + + + +
6 + + + + + + + +
7 + + + + + + + +
8 + + + + + + + +
9 + + - - + + + +
+ indicate growth; indicate no growth
8/12/2019 312-09 Zaman
8/10
447
Czech J. Food Sci. Vol. 28, 2010, No. 5: 440449
also found in other bacteria such asMicrococcusrubens (I et al. 1993).
he isolates could grow in the temperature rangebetween 30C and 50C, but none could with-stand 55C (able 5). Six isolates could grow at45C, although only Bacillus subtilisFS-12 and
Bacillus amyloliquefaciensFS-14 could grow attemperatures of up to 50C. However, most iso-lates could grow at the temperatures preferablefor fish sauce fermentation, generally between35C and 45C (L et al.2001). Mostisolates also tolerated pH range suitable for fishsauce (able 5). P et al.(2001) found in theirresearch that the average pH value of fish saucefrom various countries ranged from 4.9 to 6.1.Regarding the salt tolerance, most isolates could
grow in media with salt concentration of up to 15%except forBacillus humi FS-13 and Staphylococ-cus carnosusFS-25 (able 5). Bacteria will losetheir turgor pressure when cultivated in a highsalt concentration medium which leads to the cellphysiology and metabolism disturbance (L etal. 1998). Some bacteria overcome this effect byregulating the osmotic pressure between the insideand outside of the cell (K 1987). his traitwas found in halotolerant and halophilic bacteriawhich could grow at the salt concentration of up
to 5% and more than 12% of salt, respectively(F & W 1988). Hence, the find-ings of this research confirmed that most bacteriaisolated from fish sauce which exhibited aminesdegradation activity should belong to halotolerantor halophilic groups. However, amines degradationactivity of the bacteria in a buffer system wouldprobably be not the same in complex substances.M and H (2009) reported that Staphylo-coccus xylosusNo. 0538 showed a lower activityin complex substances as compared to the buffersystem. hey found that the bacteria reduced
16% of overall biogenic amines when applied asstarter culture in salted and fermented anchovy.herefore, the isolates should be further examinedin food systems such as those applying fish saucefermentation.
CONCLUSION
Histamine content in fish sauce samples exceededthe defect level of 50 ppm designed by US FDA.
he product was still considered as probably safesince the consumption of fish sauce mainly as
condiment might not lead to an excessive intakeof this amine. However, the presence of high levelsof amines in fish sauce showed that the productlacked necessary hygiene during fermentation. hefindings of this research indicated that, within thebacterial flora of fish sauce, most of bacteria pos-sessed the potential to produce biogenic amines,particularly histamine, putrescine, and cadaverinewhile others, however, were able to degrade thosethree amines. he strains of genera Bacillus andStaphylococcus found in this research were ableto degrade one or more of the amines. It may bealso concluded that amines degradation activitywas rather strain than species specific. he aminesoxidase activity as well as safety of these bacteriacan be considered as the criteria for the selection
of the bacteria used to reduce amine accumulationin fish sauce and other related product.
R e f e r e n c e s
A (2004): Food Act and Regulations, Allamendments up to April, 2004 Act 28. MDC Publisher
Sdn. Bhd., Kuala Lumpur: 120125.B B., D C., J H.M.L.J. , H V
J.H.J. (1990): Occurrence and formation of biologically
active amines in foods . International Journal of FoodMicrobiology, 11: 7384.C .Y., H G.H., B K.N., S Y.W., J M.R.,
L C.H., K S.H., K D.B., K S.B. (2006): Evalu-ation of biogenic amine in Korean commercial fer-
mented foods. Korean Journal of Food Science andechnology, 38: 730737.
D M.L.N.E. , N M.J.R., R F.M.,H J.H., W W. (2000): Biogenic amine
formation and degradation by potential fish silagestarter microorganisms. International Journal of FoodMicrobiology, 57: 107114.
D S., B S., V W.,K H. (2006): he influence of storage con-ditions of tuna viscera before fermentation on the
chemical, physical and microbiological changes in fishsauce during fermentation. Bioresource echnology,
97: 20322040.F W.C., W D.C. (1988): Food Microbiol-
ogy. 4thEd. McGraw-Hill, Inc., New York: 5455.F X.., Y S.G., K S.M. (2008): Characterization
of a salt tolerant acid protease produces by Bacillusmegaterium KLP-98 and its potential as a fermenta-
tion starter for the manufacture of fish sauce. Journalof Food Biochemistry, 32: 279298.
8/12/2019 312-09 Zaman
9/10
448
Vol. 28, 2010, No. 5: 440449 Czech J. Food Sci.
F K., S M., K K., W S.
(2004): Characterization of Staphylococcussp. impli-cated for improvement of fish sauce odor. Fisheries
Science, 70: 916923.H A., B ., S L.S., H
W. (1994): Biogenic amines and their production bymicroorganisms in food. rends in Food Science and
echnology, 5: 4249.H D.F., C S.H., S C.Y., C .J. (1997):
High performance liquid chromatographic deter-mination of biogenic amines in fish implicated in
food poisoning. Journal of Chromatography B, 693 :2330.
I H., H S., B . (1993): Pu-trescine oxidase of Micrococcus rube ns : primary
structure and Esche richia col i. Journal of General
Microbiology, 139: 425432.J H.M.L.J., N M.D. (1989): Detection,
growth and amine producing capacity of lactobacilli
in cheese. Applied and Environmental Microbiology,
62: 23562360.
K P., J., K M., P . (2000):he effect of lactic acid bacteria inoculants on biogenic
amines formation in sauerkraut. Food Chemistry, 70:355359.
K E.R. (1987): Bioenergetics of lactic acid bacte-ria: cytoplasmic pH and osmotolerance. FEMS Micro-
biology Reviews, 46: 233244.K M.W., K Y.M. (2006): Isolation and identifica-
tion of histamine degrading bacteria from Kwamegi.Korean Journal of Life Science, 16: 120125.
K M., K P. (1998): Biogenic amines in foodsand their roles in human nutrition. Czech Journal of
Food Sciences, 16: 151159.L L., O J. (2000): Histamine fish poisoning
revisited. International Journal of Food Microbiology,58: 137.
L R.G., H W.P. (1998): yramine deg-radation by micrococci during ripening of fermented
sausages. Meat Science, 49: 289296.L R.G., H M., H W.P. (1998):
Histamine and tyramine degradation by food ferment-ing microorganisms. International Journal of Food
Microbiology, 39: 110.L S.Q., A R.V., G P.K., H R.,
C V.L. (1998): Influence of reduced water activityon lactose metabolism by Lactococcus lactis subsp.
cremorisat different pH values. Applied and Environ-mental Microbiology, 64: 21112116.
L K., C Y.J., P J.W., D M.A.
(2001): Fish sauce products and manufacturing: a re-view. Food Reviews International, 17: 6588.
L J.B., B W., S L.A .J., B
M.M., R-B G., D P., E M.,G J.P., L A., R A., L M.,
G R. (1992): Biogenic amines in fishery prod-ucts: standardization methods within EC. In: H
H.H. (ed.): Quality Assurance in the Fish industry.Elsevier Science Publishers, Amsterdam: 427439.
M J.H., H H.J. (2009): Inhibition of biogenicamine formation in a salted and fermented anchovy
by Staphylococcus xylosusas a protective culture. FoodControl, 20: 796801.
M J.H., H H.K., O Y.J., K M.G., H H.J.(2002): Biogenic amines in jeotkals, Korean salted
and fermented fish products. Food Chemistry, 79 :239243.
M M., C M.A., G F., S
G. (2000): Biogenic amine formation and oxidationby Staphylococcus xylosus strains from artisanal fer-mented sausages. Letters in Applied Microbiology,
31: 228232.M Y., D N., H . (1979): Distribution
of membrane bound monoamine oxidase in bacte-ria. Applied and Environmental Microbiology, 38 :
565569.O F., K. D.A., Q P., O
Y.O. (2002): Biogenic amines formation in atlanticherring (Clupea harengus) stored under modified
atmosphere packaging using rapid HPLC method.International Journal of Food Science and echnol-
ogy, 37: 515522.P J.N., F Y., F E., ., W
., O S., S ., W K., A H.(2001): Chemical composition of fish sauce produced
in southeast and east asian countries. Journal of FoodComposition and Analysis, 14: 113-125.
S M., S B., H N.H., A A.S.M., SM.I. (2009): Determination of biogenic amines in se-
lected Malaysian food. Food Chemistry, 113 : 13561362.
S N.G., K ., A N. (1996): Ac-celerated fermentation process for the manufacture
of fish sauce using histidine. Journal of Food Science,61: 220225.
S A.R. (1996): Significance of biogenic aminesto food safety and human health. Food Research In-
ternational, 29: 675690.S R., P K., S H., B G.
(2002): Biogenic amines in fish and soy sauce. Euro-pean Food Research echnology, 215: 101107.
S., H Y., E ., K
M., K K. (1991): Identification of Staphylo-coccus carnosus strains from fermented fish and soy
8/12/2019 312-09 Zaman
10/10
449
Czech J. Food Sci. Vol. 28, 2010, No. 5: 440449
mash. Journal of General and Applied Microbiology,
37: 479494. Y.H., L C.H., C L.., L .M., W C.I.,
H D.F. (2006): Histamine contents of fermentedfish products in aiwan and isolation of histamine-
forming bacteria. Food Chemistry, 98: 6470.U M.N., L C.H. (1996): Isolation and identification
of Staphylococcussp. from Korean fermented fishproducts. Journal of Microbiology and Biotechnology,
6: 340346.V B.V., B F., S F.J.M., A A.,
H U., P P. (2005): Biogenic amines andpolyamines and total aerobic count during storage of
vacuum packaged porcine kidney, liver and spleen. FoodScience and echnology International, 11: 337344.
Y M., S M., I M., S H.,
M Y. (1993): Purification and characteriza-tion of monoamine oxidase from Klebsiella aero-genes . Journal of Fermentation and Bioengineering,
76: 289295.
Y J., R S., R N.(2007): Acceleration of hai fish sauce fermentation
using proteinases and bacterial starter cultures. Jour-nal of Food Science, 72: M282M290.
Z M.Z., A A.S., B F.A., SJ., B J. (2009): A review: microbiological, physi-
cochemical, and high impact of high level of biogenicamines in fish sauce. American Journal of Applied
Sciences, 6: 11991211.
Received for publication November 24, 2009
Accepted after corrections January 18, 2010
Corresponding author:
Assoc. Prof. Dr. F A B, Universiti Putra Malaysia, Faculty of Food Science and echnology,
Department of Food Science, 43400 Serdang, Selangor D.E., Malaysia
tel.: + 603 894 683 75, e-mail: fatim@putra.upm.edu.my
Recommended