Akai Lct3285ta

AKAI

SERVICE MANUAL

Model: LCT3285TA

1. Safety Instructions………………...………………………………………………….1~2 2. Trouble Shooting manual of LCD…………………………………………………….3~5 3. Block Diagram….…………………………………………………………………….6 4. Circuit diagram……………………………………………………………………….7~31 5. Basic Operation & Circuit Description………………………………………………32~34 6. Main IC Information…………………………………………………………………35~73 7. Panel Information……………………………………………………………………74~106 8. Explored View………………………………………………………………………107 9. Spare Pare List………………………………………………………………………108~109 10. Software Upgrade……………………………………………………………………110~116

This manual is the latest at the time of printing, and does not include the modification which may be made after the printing, by the constant improvement of product.

- 2 -

I. Safety Instructions

PRECAUTIONS DURING SERVICING1. In addition to safety, other parts and assemblies are

speci fied for conformance with such regulations asthose applying to spurious radiation. These mustalso be replaced only with specified replacements.

Examples: RF converters, tuner units, antennaselection switches, RF cables, noise-blockingcapacitors, noise-blocking filters, etc.

2. Use specified internal Wiring. Note especially:1) Wires covered with PVC tubing2) Double insulated wires

3) High voltage leads3. Use specified insulating materials for hazardous

live parts. Note especially:

1) Insulating Tape2) PVC tubing3) Spacers (insu lating barriers)

4) Insulating sheets for transistors5) Plastic screws for fixing micro switches

4. When replacing AC primary side components

(transformers, power cords, noise blockingcapacitors, e tc.), wrap ends of wires securely aboutthe terminals before soldering.

5. Make sure that wires do not contact heat generatingparts (heat sinks, oxide metal fi lm resistors, fusible

resistors, etc.)6. Check if replaced wires do not contact sharply edged

or po inted parts.

7. Make sure that foreign objects (screws, solderdroplets, etc.) do not remain inside the set.

MAKE YOUR CONTRIBUTION TO PROTECT THEENVIRONMENT

Used batteries wi th the ISO symbol

for recycling as well as smallaccumulators (rechargeable batteries), mini-batteries(cells) and starter batteries should not be thrown

into the garbage can.Please leave them at an appropriate depot.

WARNING:

Before servicing this TV receiver, read the X-RAYRADIATION PRECAUTION, SAFETY INSTRUCTIONand PRODUCT SAFETY NOTICE.

X-RAY RADIATION PRECAUTION1. Excessively high can produce potentially hazardous

X-RAY RADIATION. To avoid such hazards, the highvoltage must not exceed the speci fied limit. Thenormal va lue of the high voltage of this TV receiver

is 27 KV at zero bean current (minimum brightness).The high voltage must not exceed 30 KV under anycircumstances. Each time when a receiver requires

servicing, the high voltage should be checked. Thereading of the high voltage is recommended to berecorded as a part o f the service record, It is

important to use an accurate and reliable highvoltage meter.

2. The only source of X-RAY RADIATION in this TV

receiver is the picture tube. For continued X-RAYRADIATION protection, the replacement tube must beexactly the same type as specified in the parts list.

3. Some parts in this TV receiver have special safetyrelated characteristics for X-RADIATION protection.For continued safety, the parts rep lacement should

be under taken only after referring the PRODUCTSAFETY NOTICE.

SAFETY INSTRUCTIONThe service should not be attempted by anyoneunfamiliar with the necessary instructions on th is TV

receiver. The fo llowing are the necessary instructionsto be observed before servicing.

1. An isolation transformer should be connected in the

power line between the receiver and the AC linewhen a service is performed on the primary of theconverter transformer of the set.

2. Comply wi th all caution and safety related providedon the back of the cabinet, inside the cabinet, on thechassis or p icture tube.

3. To avoid a shock hazard, always discharge thepicture tube's anode to the chassis ground beforeremoving the anode cap.

The l ightn ing flash wi th arrowhead symbol ,within an equilatera l triangle, is intended to alertthe user to the presence of uninsulated “ dangerousvoltage” within the product’ s enclosure that maybe of sufficient magnitude to consti tute a risk ofelectric shock to persons.

The exclamation po int wi thin an equi latera ltriangle is intended to a lert the user to thepresence of important operating and maintenance(s erv ici ng) in str uct io ns in the l i ter atu reaccompanying the appliance.

CAUTION: TO REDUCE THE RISK OF ELECTRICSHOCK, DO NOT REMOVE COVER (OR BACK). NOUSER-SERVICEABLE PARTS INSIDE. REFERSERVICING TO QUALIFIED SERVICE PERSONNELONLY.

CAUTION

RISK OF ELECTRIC SHOCKDO NOT OPEN

1／116

PRODUCT SAFETY NOTICE

Many e lectrical and mechanica l parts in this TV

receiver have special safety-related characteristics.These characteristics are offer passed unnoticed byvisual spection and the protection afforded by them

cannot necessari ly be obta ined by using replacementcomponents rates for a higher voltage, wattage, etc.The replacement parts which have these special

safety characteristics are identified by marks onthe schematic diagram and on the parts l ist.Before replacing any of these components, read the

parts list in this manual carefully. The use ofsubstitute replacement parts which do not have thesame safety characteristics as speci fied in the parts

list may create shock, fire, X-RAY RADIATION orother hazards.

Good earth groundsuch as the wat erp ipe, c onduc t or ,etc.

Place this probeon eac h e x -pos ed met al licpart

AC VOLTMETER

AC Leakage Current Check

4. Completely discharge the high potential voltage of the

picture tube before handling. The picture tube is avacuum and if broken, the glass will explode.

5. When rep lacing a MAIN PCB in the cabinet, always

be certain that all protective are installed properlysuch as control knobs, adjustment covers or shie lds,barriers, iso lation resistor networks etc.

6. When servicing is required, observe the original leaddressing. Extra precaution should be given to assurecorrect lead dressing in the high voltage area.

7. Keep wires away from high voltage or high temperature components.

8. Before returning the set to the customer, always

perform an AC leakage current check on the exposedmeta llic parts of the cabinet, such as antennas,terminals, screwheads, meta l overlay, control shafts,

etc., to be sure the set is safe to operate withoutdanger of electrica l shock. Plug the AC line corddirectly to the AC outlet (do not use a line iso lation

transformer during th is check). Use an AC voltmeterhaving 5K ohms volt sensitivity or more in thefollowing manner.

Connect a 1.5K ohm 10 watt resistor paralleled by a0.15µF AC type capacitor, between a good earthground (water pipe, conductor etc.,) and the exposed

metallic parts, one at a time.Measure the AC vol tage across the combination ofthe 1.5K ohm resistor and 0.15 uF capacitor. Reverse

the AC p lug at the AC outlet and repeat the ACvoltage measurements for each exposed metallicpart.

The measured voltage must not exceed 0.3V RMS.This corresponds to 0.5mA AC. Any value exceedingthis limit constitutes a potential shock hazard and

must be corrected immediately.The resistance measurement should be donebetween accessible exposed metal parts and power

cord plug prongs with the power switch "ON". Theresistance should be more than 6M ohms.

2／116

1. Do not power on.1.1 Please check AC cable if connect to AC plug.

Is true the connector don’t connect to AC plug. Please connect it.

2.2 Please check AC cable if connect to AC power.

Is true the AC cable don’t connect to AC power. Please connect it.

3.3 Please check power board of fuse if broken.

If the F1 fuse is broken, Please pull out the AC cable from AC power. Please check AC L

power and AC N ground by multimeter, The read number is infinite, the fuse is broke. then

look up power board if not burn out place. Is true it. Please change power board or be changed

power board.

2. The power on switch of green extinguish.2.1 The power of led(indicator light) is red light, To touch power on key when indicator light

wink.

Is true that the power DC output have somewhere short circuit.

Please check connector J39,J31 .If not connector direction is wrong.

Or the mainboard somewhere of power short circuit.

3／116

3.The power is normal work ,but don’t backlight.3.1 The indicator light work normal (green light ).

Please check Main board of transistor Q18 collect if not has +5v voltage.

Is true Q18 collect hasn’t +5v ,To check Q18 if fail. Or to check Q18 of base if not low.

(Low is working, high don’t work).

Please refer to attached sheet A circuit diagram.

3.2 Please check backlight of connector if not it direction is wrong or the connector of wire

compositor direction is wrong.

3.3 To check connector panel of voltage is +24v. It’s true .Then to check of the first pin if it

have +5V voltage, It’s true , than to check power board of +24v voltage ,It’s true. The panel

of backlight board is fail. The change panel of backlight board.

Please refer to attached sheet B Panel of datasheet.

4.The screen don’t have picture But have backlight.

4.1 To check to panel of voltage ,To check main board of bead L69 and L57 connect if not

OK.Then check the L69 and L57 of voltage is +12v( 27 inch panel voltage is +5v, To check

L68 and L56) . Next to check fuse F1 and connector J10 if not is +12v(27 inch panel voltage

is +5v). If isn’t please check power board of connector CON5 if has +12v( 27 inch panel

voltage is +5v).

4.2To check to main board +12 V voltage. To check to main board IC U35 of the first pin if

4／116

+5v voltage ,It’s fail. It’s low (close 0 v) working.

The circuit diagram follow down:


5.The remote control don’t be control.6.1 The check batteries of remote control if it run out of .

6.2 To check main board of connecter J21 of wire connect fastness and the connecter of

wire open.


6.The sound don’t output.7.1 To check main board +24v voltage of connector J8 ,It’s true not +24v voltage. Then to

to check power main +24v fail .


7.The DTV don’t detect .7.1 To check mainboard of connecter J24 and DTV mainboard of connector HA1 of

FCC wire if no connect fastness.

Please refer to attached sheet C of DTV circuit diagram.

5／116

MT5351MPEG Decoder

MT5111DTV Demodulator

X6965DSAW Filter

TD1336Digital Tuner

Flash32mb

OpticalOutput

DDR256M

DDR256M

MT8202

ADC &

Scaler &

LVDS Transfer

74L VC245A X424 bit RGB Switch

MT8293HDMI Receiver

HDMI

YPbPr1

YPbPr2(Option)

VGA

AV

S-Video

Audio X2

Audio X3

QS3VH257Switch(Option)

HEF4052Switch WM8776

AudioADC&DAC

To panel

Flash8M/16M

DDR128M

DDR128M

R2S15102Class DAmplifier

POWER BOARD5VStandby 5V12V9V24VA (For Class D)24V (For LCD Panel)

Max232Level Shift

RS232Socket

Speaker

LCD panel

Relay

Analog Tuner

MAIN BOARD

DTV BOARD

NJRC4558Audio Buffer

AudioOutput

6／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

8202UP3_1

SCL

SDA

URST#

GPIO4

8202UP3_1

URST#

GPIO4

+5V/+6V

9VV

SYSROMWPSCL

SDA

9V

9VV

VS_ON

RELAY_ON

LVDSVDD

9VV

VCC

12V12V

12V

9VV

RELAY_ON

VS_ON

12V +12V

+12V

+5V/+6V VCC

URST#

9VV

VCC +5V/+6V

GPIO14

GPIO14

GPIO19

GPIO19

GPIO2

GPIO2

9VV9VV 9V

9V

9V

LVDSVDD

SYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWRSYS_PWR

AD

D1

5VSB

SB33A

5VSB

5VSB

SB33B

SB33B

5VSB

SB33B

SB33B

+5V/+6V

+12V

+12V

VCC

5VSB

SB33B

5VSB

5VSB

8202UP3_1 3

SDA 9,14

SCL 9,14

URST# 3

GPIO4 3

9V 7,9,14

12V 12,13

RELAY_ON 12

VS_ON 12

GPIO14 3,13

GPIO19 3,13

GPIO2 3,12

LVDSGND 2,3,4

Title

Size Document Number Rev

Date: SheetChecked:

INDEX / POWER / RESET / EEPROM

1C

1 17Thursday, April 13, 2006

AKAI_MT8202_27US_LVDS_V0.0

KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:


1C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:


1C



KAWA Confidential

<Designer>

<Checker>

9. WM8776 & VIDEO BYPASS

2. LDO

SYSTEM EEPROM

12. LVDS OUT13. BACK LIGHT / KEYPAD

Rev DateP#History


5. DDR MEMORY & FLASHNew 2005/11/22

H : WP DISABLEL : WP ENABLE

8202UP3_1 HIGH :POWER OFF8202UP3_1 LOW :POWER ON

3. MT8202E PBGA388

1. INDEX / POWER / RESET / EEPROM

4. MT8202 DECOUPLING

6. MT5351 INTERFACE

8. DAUGHTER BOARD IN

11 . VGA & PC AUDIO IN

POWER ON RESET# CIRCUIT

POWER DOWN RESET# CIRCUIT

10. AUDIO / VIDEO IN CIRCUIT

FROM POWER BOARD

MT8202E (PBGA388) LCDTV BOARD 4 LAYERS FOR AKAI

AKAI_MT8202_27US_HDMI_LVDS_V0.0

17.AUDIO Amplifier

14. TUNER IN15. AV IN16. AUDIO IN

7. HDMI MT8293

ADD HDMI / VIDEO /AUDIO CONNECTOR INPUT IN

HI = > POWER ONLO = > POWER OFF

1

32

Q442N3904SOT23/SMD/NC


CB1

0.1uF

CB1

0.1uF

FB2 FB/NCFB2 FB/NC

C41uFC41uF

1

32

Q452N3904Q452N3904

R77922K R77922K

R9

1k/NC

R9

1k/NC R10

4.7K

R10

4.7K

CB30.1uFCB30.1uF

R337 10R337 10

+CE2

100uF/16v

+CE2

100uF/16v

2 23 34 45 5

99887766

11

H2HOLE/GND

H2HOLE/GND

R63710KR63710K

123456789

1011

J6

11x1DIP11/P2.54

J6

11x1DIP11/P2.54

CB20.1uF/NC

CB20.1uF/NC

CB5

0.1uF

CB5

0.1uF

R64510KR64510K

1234567

J23DIP7/W/H/P2.54J23DIP7/W/H/P2.54

GN

D1

RE

SE

T2

VC

C3

U1

LM809SOT-23/SMD/NC

U1

LM809SOT-23/SMD/NC

1

32

Q21

2N3904SOT23/SMD

Q21

2N3904SOT23/SMD

R1510K/NCR1510K/NC

1

32

Q42N3904SOT23/SMD

Q42N3904SOT23/SMD +

CE1220uF/16v +

CE1220uF/16v

D23

1N4001/SMD

=

DIODE SMD/NC

D23

1N4001/SMD

=

DIODE SMD/NC

R14 10KR14 10K

D26

1N4001/SMD

D26

1N4001/SMD

R63810KR63810K

+CE3100uF/16v/NC

+CE3100uF/16v/NC

R2360/NCR2360/NC

D25

1N4001/SMD

D25

1N4001/SMD

12345678910

R. ANGLE

J7

DIP10/W/H/P2.54

R. ANGLE

J7

DIP10/W/H/P2.54

R1320KR1320K

S1 1G1 2S2 3G2 4D25 D26 D17 D18

U62

IRF7316SOIC8/SMD

U62

IRF7316SOIC8/SMD

FB40 FB/NCFB40 FB/NCD21N4148

D21N4148

+ CE410uF/25v

+ CE410uF/25v

D11N4148/SMD

D11N4148/SMD

CB40.1uF/NCCB40.1uF/NC

R3380

R3380

FB42 FB/NCFB42 FB/NC

NC1NC2NC3GND4 SDA 5SCL 6WP 7VCC 8

U2

EEPROM 24C16SOP8/SMD

U2

EEPROM 24C16SOP8/SMD

VD

IS4

IN1 OUT 2

GND 3

U61 KA278RA05/NC TO-220F-4LU61 KA278RA05/NC TO-220F-4L


C17520pFC17520pF

+CE144

220uF/16v

+CE144

220uF/16v

R744

470

R744

470

R847kR847k


1

3 2

Q20

2N3904

Q20

2N3904

R37NCR37NC

+CE145470uF/16v

+CE145470uF/16v

2 23 34 45 5

99887766

11

H1HOLE/GND

H1HOLE/GND

+ CE6100uF/16v.NC

+ CE6100uF/16v.NC

R225

10/NC

R225

10/NC

R676

10K/NC

R676

10K/NC

R7780 R7780

R22 NCR22 NC

R675 100R675 100

1

32

Q192N3904SOT23/SMD

Q192N3904SOT23/SMD

2 23 34 45 5

99887766

11

H4HOLE/GND

H4HOLE/GND

+ CE12100uF/10vC22UF25V/D5H11

+ CE12100uF/10vC22UF25V/D5H11

R11

100k/NC

R11

100k/NC

CB200.1uFCB200.1uF

R6390

R6390

CB150.1uFCB150.1uF

+

CE110

47uF/16v

+

CE110

47uF/16v

C1541000pF/NC

C1541000pF/NC

C681

1uF/NC

C681

1uF/NC

CB2070.1uFCB2070.1uF

C17620pF

C17620pF

R7770/NC R7770/NC

R674 100R674 100

R340

4.7k

R340

4.7k

C1531000pF/NC

C1531000pF/NC

R77522kR77522k

FB3 FB/NCFB3 FB/NC

D24

1N4001/SMD

D24

1N4001/SMD

2 23 34 45 5

99887766

11

H3HOLE/GND

H3HOLE/GND


R32410KR32410K

R52NCR52NC

R77610kR77610k

R33910kR33910k


R57 1KR57 1K

R63510k/NCR63510k/NC

7／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

ADCV18A

VFE_GND1

VFE_GND

LVDS_GND

VFE_GND1

ASB33AASB18A

AV18AAV33A

AV33A

SB18ASB18SB33A

LVDS_GND

DV18A

LVDS_GND

LVDS_GND

LVDS_GND

LVDS_GND

DACVDD

LVDS_GND

SB18

VFE_GND

SB33

ADCV33A

DV33B

ASB33A

SB18ASB33A

ASB18A

AV18AAV33A

DV18A

DV33A

VCC

SB33

SB33B

5VSB

ADCV18A

DACVDD

VCC

VFE_GND1 3,4,8,11

VFE_GND 3,4,8,11

LVDS_GND 3,4,12

Title


Date: SheetChecked:

LDO1C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

LDO1C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

LDO1C



KAWA Confidential

<Designer>

<Checker>

Power ON alive source

1.25x(1+180/300)=1.99V

1.25x(1+62/110)=1.95V

change 2/16

L46 FBL46 FB

L48 FBL48 FB

+ CE103470uF/16v

+ CE103470uF/16v

+CE18220uF/16v

+CE18220uF/16v

L7 FBL7 FB

CB170.1uFCB170.1uF

+ CE82100uF/16v

+ CE82100uF/16v

CB210.1uFCB210.1uF

CB80.1uFCB80.1uF

L51 FBL51 FB

AD

J/G

ND

1

OUT 2IN3

U37 AZ1117/adj

SOT223/SMD

U37 AZ1117/adj

SOT223/SMD

L42

FB

L42

FB

+ CE9100uF/16v

+ CE9100uF/16v

+ CE108220uF/16v

+ CE108220uF/16v

+ CE10100uF/16v

+ CE10100uF/16v

L4 FBL4 FB

+ CE109

220uF/16v

+ CE109

220uF/16v

CB180.1uFCB180.1uF

+ CE7100uF/16v

+ CE7100uF/16v

+ CE78100uF/16v

+ CE78100uF/16v

AD

J/G

ND

1

OUT 2IN3

U11

AZ1117-3.3VSOT223/SMD

U11

AZ1117-3.3VSOT223/SMD

+ CE17220uF/16v

+ CE17220uF/16v

CB230.1uFCB230.1uF

L49 FB/NCL49 FB/NC

L8 FBL8 FB

+ CE14100uF/16v

+ CE14100uF/16v

L43 FB/1206L43 FB/1206

CB70.1uFCB70.1uF

+ CE13100uF/16v

+ CE13100uF/16v

CB189

0.1uF

CB189

0.1uF

R773

110 1%

R773

110 1%

L6 FBL6 FB

CB90.1uFCB90.1uF

R326180 1%R326180 1%


+ CE104470uF/16v

+ CE104470uF/16v

R77462 1%R77462 1%

AD

J/G

ND

1

OUT 2IN3

U4 AZ1117/adj

SOT223/SMD

U4 AZ1117/adj

SOT223/SMD

+ CE11100uF/16v

+ CE11100uF/16v

L47 FBL47 FB

L50 FBL50 FB

CB187

0.1uF

CB187

0.1uF

CB22

0.1uF

CB22

0.1uF

+ CE81

100uF/16v

+ CE81

100uF/16v

L10 FBL10 FB

+ CE20

220uF/16v

+ CE20

220uF/16v

AD

J/G

ND

1

OUT 2IN3

U7AZ1117-3.3V

SOT223/SMD

U7AZ1117-3.3V

SOT223/SMD

+ CE21220uF/16v

+ CE21220uF/16v

L5 FBL5 FB

+CE8

100uF/16v

+CE8

100uF/16v

+ CE80100uF/16v

+ CE80100uF/16v

+ CE79100uF/16v

+ CE79100uF/16v

AD

J/G

ND

1

OUT 2IN3

U3AZ1117-3.3V

SOT223/SMD

U3AZ1117-3.3V

SOT223/SMD


+CE15220uF/16v

+CE15220uF/16v

CB100.1uFCB100.1uF

AD

J/G

ND

1

OUT 2IN3

U8 AZ1117-1.8VSOT223/SMD

U8 AZ1117-1.8VSOT223/SMD

R325

300 1%

R325

300 1%CB24

0.1uF

CB24

0.1uF

8／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

AADCVSS

VFE_GND1

AOSDATA3

DV18A

DV33A

AUDIO_GND

REFPREFN

SB33A

GREEN+GREEN-BLUE+BLUE-

RED+

VGASOG

RED-

VGAHSYNC#VGAVSYNC#

SB33B

AVICMCVBS1CVBS2

CVBS0

SY0

SC1

SC0SY1

PWM2VREFDACFS

VFE_GND

SB18A

IOSCLIOSDA

8202UP3_4

LVDS_GND

8202UP3_5

SDA_8202

ICE

PR1+

SOY1

Y1+

PB1+

PR1-

Y1-

PB1-

LVDDC

LVDDBSCL_8202

TESTP4TESTN4

TESTP3TESTN3

TESTP2

TXDRXD

AADCVDD

ADCVDD

AVDD_VAD0

VPLLVDD2

ADACVDD

AVDD_VFE0

LVDDA

VPLLVDD1

PLLVDD2

AVDD_VAD1

PLLVDD3

AVDD_VFE1

DACVDDC

DACVDDB

DACVDDA

XTALVDD

PLLVDD1

AOSDATA0

PR0-SOY0

PB0+

Y0+

PR0+

Y0-

PB0-

DEDE

SVMCVBS3

GND

IR

HDMISD0

CCIR_V6

AOSDATA2

HDMIHSYNCHDMIVSYNC

HDMIDEHDMIODCK

8202UP3_0

GPIO13

URST#

IOWR#F_OE#IOCE#

8202UP3_1

RXD1TXD1

AP[0..7]AN[0..6]

CLK1-CLK1+

RXDTXD

SCL_8202

27MHZ

HDMISD2HDMISD1

HDMISD3

F_A21

VCLK

SCL1SDA1

GPIO10

CCIR_V7

GPIO19

INT0#

GPIO3

HDMICEN

FCMDFDAT

FCLK

SCL_8202SDA_8202

A_CLK

A_DQM[0..1]A_BA[0..1]

A_WE#

A_CKEA_CLK#

A_DQ[0..31]

A_RA[0..11]

A_CAS#

A_DQS[0..3]

A_CS#A_RAS#

F_A[8..20]F_D[0..7]

VREF

ADC_IN0

AOLRCK

AOMCLK

ADIN

AOBCLK

AOSDATA1

MPX1MPX2

PWM0PWM1

IOA[0..7]

VI[0..23]

GPIO2

GPIO4GPIO7

GPIO9

GPIO11GPIO12

GPIO15GPIO16GPIO17GPIO18

DV25ASDV25A

CCIR_V5

ARAL

DE_SOG

HDMIBCLKHDMILRCK

HDMIMCLK

GPIO8

SDA_8202

GPIO1

ADC_IN4

GPIO0

CCIR_VCLK

CCIR_V4

SDA0SCL0CCIR_V[0..3]

GN

D

VFE_

GN

D1

TEST

N1

VFE_

GN

D

VI12

DV25A

F_A1

1

DV2

5A

VPLLVDD1

PLLVDD3

A_CLK#

A_DQ31

ALE

ADC_IN3

F_D3

F_A9

A_RA9

A_RA7

XTALO

PLLVDD1

AUD

IO_G

ND

CC

IR_V

3

CC

IR_V

1

HD

MIB

CLK

VI4

HDMIVSYNC

DE_SOG

GN

D

CLK1+

A_DQS3

XTALVDD

DACVDDB

AP1

SDV25A

GPI

O15

FCLK

SB33A

GN

D

8202UP3_0

CVB

S0

SY0

PB1-

PR0+

GND

VI0

HDMIHSYNC

A_CLK

DACVDDC

LVDS_GND

F_A2

1

CLK2-

AN6

PLLVDD2

A_RA3

A_D

Q10

A_D

Q4

LVDS_GND

XTALI

IOCE#

IOA7

GPI

O1

AP4

VCLK

SDA1

ACEN

T

REF

P

Y1-

SOY1

Y0+

VI9

AOLR

CK

DV25A

A_D

Q3

IOA2

DV18A

GND

AN1

VPLLVDD2

LVDS_GND

A_DQM1

PWM2VREF

F_A1

8

GPI

O8

CVB

S2

VFE_

GN

D1

AVD

D_V

AD1

PR1-

PR0-

PB0-

BLU

E-

F_A13

GND

A_D

Q11

A_WE#

A_DQS2

DACVDDA

ADCVDD

F_D4

A_DQ19

F_A17

DV1

8A

VFE_

GN

D1

GND

GND

AVD

D_V

FE0

HD

MIL

RC

K

VI7

A_D

Q6

A_BA0

A_RA0

A_D

QS1

LVDDC

A_DQ24

GR

EEN

-

IOA1

INT0

#U

RD

#

A_DQ16

AP2

XTALI

GN

D

GN

D

TEST

P3

AAD

CVS

S

Y0-

TEST

P1

RED

+

VGAH

SYN

C#

GN

D

HD

MIS

D3

HD

MIS

D1

VI23

VI17

VI8

VI3

HDMIDE

FCM

D

F_D6

SB18A

CLK2+

F_A15

TXD

1

IOA3

A_RA6

A_RA8

AN7

VFE_

GN

D

GND

AAD

CVD

D

CVB

S3

SOY0

CC

IR_V

6

VI18

VI16VI15

VI6

A_DQ17

IOW

R#

AN3

GR

EEN

+

IOSC

L

A_D

Q8

A_DQ18

LVDS_GND

XTALO

LVDDA

AN5

ADC_IN2

F_D1

GN

D GPI

O3

A_RA5

RXD

GN

D

AAD

CVS

S

SDA0

HD

MIS

D0

VI19

HDMIODCK

VI2

27MHZ

GPI

O12

DACFS

A_D

Q5

A_D

Q0

A_DQ14

A_DQ21

ADC_IN1

GND

F_A1

9

SB33

A

F_A16

GPI

O10

GPI

O9

GND

HSYNC

F_A1

2

VFE_

GN

D1

AN4

LVDDB

TEST

N3

AL

DV1

8A

DV3

3A

VI14

A_DQ13

8202UP3_1

ICE

ADC_IN0

PWM1

GN

DIOSD

A

GPI

O4

AOBC

LK

DE

GN

D

GND

RED

-

SCL0

CC

IR_V

0

HD

MIM

CLK

VI22

VI11

VI5

A_BA1

GPI

O2

A_RA11

TESTN4

AP3

A_D

Q2

DV2

5A

GPIO19

A_DQ23

TESTP4

G

IOA6

AOSD

ATA0

ADIN

ADIN

ADIN

ADIN

ADIN

ADIN

AP6

GNDGND

GND

TEST

P2 SY1

SC1

BLU

E+

VI13

DV18A

A_D

QM

0

GPI

O11

A_CKE

CLK1-

A_RA2D

V33A

A_CAS#

A_RA10

A_DQ30

B

F_D0

AOSD

ATA2

GN

DUR

ST#

DV25A

A_RA4

F_D7

AOM

CLK

VFE_GND

TXD1

LVD

S_G

ND

MPX

1

PR1+

PB0+

VGAS

OG

CC

IR_V

2

LVDS_GND

A_DQ25

A_DQ28SDV25A

F_D5

GPI

O14

GPI

O0

TXD

RXD1

VFE_

GN

D1

GND

CC

IR_V

5

VI1

F_A1

0

AN2

SVM

A_D

Q1

GND

VREF

GN

D

A_D

Q7

DV33A

GND

AP0

ADC_IN4

SB18A

IOA5

GND

GPI

O7

AOSD

ATA3

IR

IOA0

VFE_

GN

D

REF

N

VFE_

GN

D1

SC0

VGAV

SYN

C#

GN

D

VI20

GNDVI10

HDMICEN

A_RAS#

GND

A_D

QS0

A_D

Q9

A_D

Q12

LVDS_GND

SDV25A

A_DQ22

F_OE#

F_A2

0

AP5

LVDS_GND

AR

MPX

2

CVB

S1

Y1+

CC

IR_V

4

CC

IR_V

CLK

VI21

FDAT

8202UP3_5

GPI

O17

A_DQ27

LVDS_GND

LVDS_GND

GN

D

GND

A_RA1

A_CS#

DV18A

A_DQ20

PWM0

AN0

F_D2

F_A14

IOA4

GPI

O16

DV1

8AR

XD1

GN

D

LVDS_GND

GN

D

GND

TEST

N2

PB1+

AVD

D_V

FE1

SCL1

HD

MIS

D2

GPI

O18

LVDS_GND

LVDS_GND

A_DQ15

A_DQ26

A_DQ29

F_A8

AOSD

ATA1

R

CC

IR_V

7

SCAR

T_FB

AVD

D_V

AD0

AVIC

M

DACVREF

AP7

VSYNC

ADAC

VDD

VFE_

GN

D

8202

UP3

_4

GPI

O13

UW

R#

GPIO14

ADIN

SB33A

SB33B

SB18A

DV18A

DV33A

SB33B

SB33B

SB33B

SB33B

SB33B

SB33B

SB33B

AADCVSS 4,10

VFE_GND1 2,4,8,11

REFP 4REFN 4

AVICM 4PWM2VREF 4DACFS 4

RED- 11

BLUE+ 11

GREEN+ 11

BLUE- 11

RED+ 11

VGASOG 11

GREEN- 11

VGAHSYNC# 11VGAVSYNC# 11

CVBS2 10CVBS1 10CVBS0 10

SY0 10SC0 10SY1 10SC1 10

SOY1 10

Y1+ 10

PB1- 10PR1+ 10

PB1+ 10Y1- 10

PR1- 10

PB0- 10PB0+ 10

Y0+ 10

PR0- 10

Y0- 10

PR0+ 10

SOY0 10

LVDDA 4

AVDD_VFE0 4

ADACVDD 4

ADCVDD 4

XTALVDD 4

PLLVDD1 4

AVDD_VAD0 4

PLLVDD2 4

DACVDDA 4

VPLLVDD1 4

VPLLVDD2 4

PLLVDD3 4

AVDD_VAD1 4

AADCVDD 4

AVDD_VFE1 4

DACVDDC 4

VFE_GND 2,4,8,11LVDS_GND 2,4,12

DACVDDB 4

AUDIO_GND 4,10

LVDDC 4

LVDDB 4

TESTP4 4TESTN4 4

TESTP3 4TESTN3 4

TESTP2 9

IR 13,15

HDMISD0 6,7

HDMIHSYNC 6,7HDMIVSYNC 6,7

HDMIODCK 6,7HDMIDE 6,7

GPIO13 13

URST# 1

IOCE# 5

IOWR# 5F_OE# 5

RXD1 7TXD1 7

AP[0..7] 12AN[0..6] 12CLK1+ 12CLK1- 12

8202UP3_0 138202UP3_1 1

RXD 7,11TXD 7,11

27MHZ 6

CCIR_V6 7

HDMISD1 6HDMISD2 6HDMISD3 6

GPIO10 13

SDA1 7SCL1 7

CCIR_V7 8

INT0# 6

GPIO3 7

HDMICEN 6

FCLK 12FCMD 12

VCLK 13

FDAT 12SCL_8202 6,9,12SDA_8202 6,9,12

AOSDATA2 16

ADC_IN0 8

GPIO2 1,12

GPIO4 1GPIO7 9

F_A21 13

GPIO9 17

GPIO11 8GPIO12 13

GPIO15 8GPIO16 8GPIO17 8GPIO18 8

DV25A 5SDV25A 5

CCIR_V5 8

SCL_8202 6,9,12SDA_8202 6,9,12

A_CKE 5

A_CAS# 5

A_DQS[0..3] 5

A_CLK 5

A_WE# 5

A_BA[0..1] 5A_RA[0..11] 5

VREF 5

A_CS# 5

A_DQ[0..31] 5

A_RAS# 5

A_DQM[0..1] 5

A_CLK# 5

F_D[0..7] 5F_A[8..20] 5

GPIO19 1,13

AR 9

AOBCLK 9,16AOMCLK 9,16

ADIN 9AOLRCK 9,16

AL 9

AOSDATA1 9

PWM0 13PWM1 13

IOA[0..7] 5

DE_SOG 6

VI[0..23] 6,7

MPX2 10MPX1 10

HDMIMCLK 6,7HDMIBCLK 6,7HDMILRCK 6,7

GPIO8 17

GPIO1 15

ADC_IN4 14

GPIO0 12

CCIR_VCLK 12

CCIR_V4 12

SDA0 7SCL0 7CCIR_V[0..3] 6,8,13

GPIO14 1,13

Title


Date: SheetChecked:

MT8202E PBGA3881C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

MT8202E PBGA3881C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

MT8202E PBGA3881C



KAWA Confidential

<Designer>

<Checker>

8202UP3_5 FOR S/W SDA8202UP3_4 FOR S/W SCL

RS-232

TP46TP46

A5PC9

DV

DD

18U

4R

XD

M3

TXD

M4

AO

MC

LKM

1

WR

#K

1

VSYNCOB6HSYNCOA6GPIOC6GPIOD6A17C3IOA0C2AD7C4

A6PC10

A7ND12

VREFB16

A2PA10

A4PC8

DVDD33AD5

LVSSCA14

DVSS25 R13

RA8 AF10RA7 AC11RA6 AD11

DQ16 AC12

RA5 AE11RA4 AF11

DQ19 AF12

RA9 AE10

DVDD25_CLK AC7

RD

#K

2

IOA

3D

3

INT0

L1P

RS

T#L2

UP

3_4

L3IR

L4

AO

BC

KN

1LI

NN

4D

VS

S18

M11

AO

SD

ATA

0/G

PIO

P1

AO

SD

ATA

1/G

PIO

P2

AO

SD

ATA

2/G

PIO

P3

AO

SD

ATA

3/G

PIO

P4

DV

SS

33N

12G

PIO

0/A

OS

DA

TA4

R1

GP

IO3

R4

GP

IO1/

AO

SD

ATA

5R

2

FCIC

LK/G

PIO

T1

GP

IO4

T4G

PIO

5/TX

DU

1G

PIO

6/R

XD

U2

DV

DD

18U

3G

PIO

7V

1

GP

IO9

V3

GP

IO8

V2

GP

IO10

V4

GP

IO13

W3

GP

IO14

W4

GP

IO15

Y1

GP

IO16

Y2

DVSS18L12

HIG

HA

1F3

DV

SS

18M

12

IOA

20F2

A16D2

IOA

6H

2IO

A5

H3

DV

DD

33A

H4

IOA

4G

1

DVDD18AK3

IOA

18G

3

IOA1C1

IOOE#B5

AD3B3

HIGHA6E4

HIG

HA

0G

2IO

A7

H1

IOCS#A5

AD0A4

HIGHA7D1

AD2A3

AD4A2 AD5B2

IOA

19G

4

AD1B4

SD

AA

A1

ADCVDDD18

BA18

ADIN4/GPIOD20

XTALIA21

DQ22 AE13

PWM2VREFC18

GN

T26

ADIN3/GPIOC20ADIN2/GPIOB20

PLLVSS3A23

CK2PC11 DQ29 AC16DVDD25OPT AC15

DQ28 AD16

DVDD25OPT AC14

DVDD25OPT AD15

DQ26 AF16DVSS25 T14

DQ25 AE15DQ24 AD14

DQM1 AE14

IOA

LEJ1

A0PA8

A1PA9 LVDDCB13

DACVDDBD16

DACVDDAC16 GA17

DACVSSBC17

A7PC12

VPLLVDD2A13

TP4A15

A5ND9

A1NB9

LVDDAD13

XTALVDDA22XTALOA20

ADIN1/GPIOC19

DACVSSAD19

DVSS18 R14DQS2 AF14DQ23 AF13

DQ21 AD13DVSS25 T13

GPIOD7 DVDD18AK4

A0NB8

PLLVSS2B22

GPIO/PWM0 AD17DVDD33I AC17

DQ30 AF17

DQ20 AC13

DQ31 AE17

DQ18 AE12

DQ

4A

C1

DQ

7A

C4

DV

DD

25A

D5

DQ

S1

AE

1D

Q8

AF1

SC

LA

A2

RWE# AE5DQ15 AF4DQ14 AE4

DQ

12A

F3D

VS

S18

R12

DQ

11A

E3

DQ

10A

F2

GP

T25

RV

RE

FA

D3

DV

SS

18P

12

DVDD18 AC8

RA10 AF7

RCS# AF6

DVSS25 R11CAS# AF5

DQ

2A

B3

DQ

1A

B2

DQ

0A

B1

RA1 AE8RA0 AD8

DV

DD

33A

A4

RCLKB AF9

RA2 AF8RA3 AD9DVSS25 T11

DV

SS

25N

11

BA0 AD7

GPIO/PWM1 AC18

PLLVDD2C21

PLLVDD3B21

XTALVSSA19ADCVSSD21

ADIN0/GPIOB19

SVMB18

LVSSBB14 A3NB12

RB17

A3PA12

A6ND10

CK2ND11

VPLLVSSD14 VPLLVDD1D15 TN4B15

DQ

5A

C2

IOA

21F1

DVSS33L11

LVSSAC14

A2NB10

CK1NB11

DACVSSCD17

DACVDDCC15

HIG

HA

2F4

AD6B1

IOW

R#

J2

DQ17 AD12

DVDD18 AC9

DQ27 AE16

DQS3 AF15

RA11 AD10

RCLK AE9

CKE AC10

DQ

9A

E2

DQ

S0

AD

1

DV

DD

25A

C5

GP

IO11

W1

GP

IO17

Y3

GP

IO2

R3

FCIC

MD

/GP

IOT2

IOA

2D

4

UP3_5C7

HIGHA5E3

DVSS18 T12

DQ

3A

B4

FSA16

CK1PA11

DVDD25 AC6

BA1 AE7

RAS# AE6

ICE

M2

UP3_1B7

HIG

HA

3E

1

AO

LRC

KN

3

DQ

M0

AD

2

DQ

6A

C3

DV

SS

25P

11

GP

IO18

Y4

FCID

AT/

GP

IOT3

DVDD25 AD6

GP

IO12

W2

DQ13 AD4

OUT_27MHZ/GPIO AD18DE_SOG/GPIO AE18CEN_DVI/GPIO AF18VSYNC_DVI AF19HSYNC_DVI AD19DE_DVI AC19VI0 AF20VI1 AE20

VI2 AD20

VI5 AD21

VI3 AF21VCLK_DVI AE19VI4 AE21

VI7 AF22VI6 AC21

DVDD18 AC22

VI8 AE22VI9 AD22DVSS33I R15VI10 AF23DVSS18 T15VI11 AE23VI12 AD23VI13 AF24VI14 AE24VI15 AD24VI16 AF25

VI1

7A

F26

VI1

8A

E25

VI1

9A

E26

DV

DD

33A

C20

VI2

0A

D25

DV

DD

18A

C23

VI2

1A

D26

VI2

2A

C25

VI2

3A

C26

HD

MIM

CLK

/GP

IOA

B26

HD

MIB

CLK

/GP

IOA

B25

HD

MIL

RC

K/G

PIO

AC

24H

DM

ISD

0/G

PIO

AA

25H

DM

ISD

1/G

PIO

AA

26H

DM

ISD

2/G

PIO

AA

23H

DM

ISD

3/G

PIO

AA

24

SC

L1A

B24

DV

SS

33T1

6C

CIR

_VC

LK/G

PIO

W23

CC

IR_V

0/G

PIO

Y26

CC

IR_V

1/G

PIO

Y25

CC

IR_V

2/G

PIO

Y24

CC

IR_V

3/G

PIO

Y23

DV

SS

18R

16C

CIR

_V4/

GP

IOW

26C

CIR

_V5/

GP

IOW

25C

CIR

_V6/

GP

IOW

24C

CIR

_V7/

GP

IOV

24S

DA

0V

23S

CL0

U23

FAS

T_B

LAN

KU

24H

SY

NC

V26

VS

YN

CV

25A

VS

S_V

FE1

N24

BP

U25

BN

U26

SO

GT2

4

RP

R25

RN

R26

AV

DD

_VFE

1R

23TN

1R

24TP

1P

23A

VS

S_V

AD

1M

24S

OY

0P

24Y

0PP

25Y

0NP

26P

B0P

N25

PB

0NN

26P

R0P

M25

PR

0NM

26S

OY

1L2

4Y

1PL2

5Y

1NL2

6P

B1P

K25

PB

1NK

26P

R1P

J25

PR

1NJ2

6A

VD

D_V

AD

1L2

3S

C1

G26

SY

1G

25S

C0

F26

SY

0F2

5A

VS

S_V

FE0

H23

AV

SS

_VA

D0

G23

RE

FNG

24

CV

BS

1D

25C

VB

S0

D26

AV

DD

_VFE

0J2

3C

VB

S3

E26

CV

BS

2E

25

RE

FPF2

4A

VD

D_V

AD

0F2

3A

AD

CV

DD

E24

SIF

B26

AF

C26

AA

DC

VS

SD

24TN

2C

25TP

2B

25A

DA

CV

DD

C24

AC

EN

T/A

OS

DA

T2B

24A

VIC

MA

24A

R/A

OS

DA

T1A

26A

L/A

OS

DA

T0A

25A

DA

CV

SS

D23

TP3

C23

TN3

D22

PLLVDD1C22

LVDDBC13

UP3_0A7

PLL

VS

S1

B23

A4ND8

SD

A1

AB

23

DGND/BALL P13DGND/BALL N16DGND/BALL N15DGND/BALL N14DGND/BALL N13DGND/BALL M16

DGND/BALL P16DGND/BALL P15DGND/BALL P14

NC BALLA1NC BALLC5NC BALLJ3NC BALLJ4

AA

DC

VS

SE

23V

FE_G

ND

1H

24V

FE_G

ND

1H

25V

FE_G

ND

1H

26V

FE_G

ND

1K

23V

FE_G

ND

M23

VFE

_GN

DN

23

NC BALLAA3

DG

ND

/BA

LLM

15

DG

ND

/BA

LLL1

6

DG

ND

/BA

LLL1

3

HIG

HA

4E

2

DG

ND

/BA

LLM

13

DG

ND

/BA

LLL1

4D

GN

D/B

ALL

L15

DG

ND

/BA

LLM

14

NC BALL J24NC BALL K24NC BALL T23

NC BALLN2

MT8202SOCKET

U12

MT8202BGA388/SMD

MT8202SOCKET

U12

MT8202BGA388/SMD

R220

10KR

22010K

TP45TP45

TP51TP51

1234

J4

4x1 W/HOUSINGDIP4/W/H/P2.0

J4


C122pFC122pF

R49 0/NCR49 0/NC

R341 10KR341 10K

TP43TP43

TP23TP23

R434 10KR434 10K

R353

10KR

35310K

R87

10KR

8710K

TP9TP9

R3910kR3910k

R342 10KR342 10K

TP5TP5

R88

10KR

8810K

TP50TP50

R47 0R47 0

TP47TP47

R3510kR3510k

TP52TP52

TP49TP49

CB135

NC

CB135

NC

R89

10KR

8910K

R86

10KR

8610K

TP80TP80

R1014.7KR1014.7K

TP10TP10

TP13TP13

R32

310

KR

323

10K

R3610kR3610k

TP6TP6

TP8TP8

TP3TP3

R1034.7KR1034.7K

Y1

27MHz

Y1

27MHz

R364 10K/NCR364 10K/NC

TP48TP48

R48 0R48 0

R351 1kR351 1k

R50 0/NCR50 0/NC

TP12TP12

R4010kR4010k

R745NCR745NC

TP7TP7R34 820kR34 820k

R673 10K/NCR673 10K/NC

R441 10KR441 10K

TP4TP4TP2TP2

R221

10KR

22110K

C227pFC227pF

TP31TP31

9／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

AADCVSS

VFE_GND1

LVDS_GND

DACVDDA

DACVDDB

DACVDDC

XTALVDD

ADCVDD

TESTP3

REFPREFN

REFN

VFE_GND1

VFE_GND1

AADCVSS

REFP

TESTP4TESTN4

PWM2VREF

ADACVDD

AADCVDD

AVICM

AVDD_VFE0

LVDS_GND

AVDD_VAD0

AVDD_VFE1

AVDD_VAD1

PLLVDD1

PLLVDD2

PLLVDD3

VPLLVDD1

VPLLVDD2

AUDIO_GND

VFE_GND

LVDS_GND

AADCVSS

AUDIO_GND

LVDS_GND

LVDS_GND

LVDS_GND

ADCVDD

LVDS_GND

PWM2VREF

PLLVDD1

LVDS_GND

PLLVDD1

LVDS_GND

LVDS_GND

VPLLVDD1

VPLLVDD1TESTP4

TESTN4

LVDDA

LVDDB

LVDDC

LVDDC

SB18A

LVDS_GND

LVDS_GND

LVDS_GND

AVDD_VFE0

AVDD_VAD0

AADCVDD

ADACVDD

VPLLVDD2

LVDDA

AVDD_VAD1

AVDD_VFE1

PLLVDD1

PLLVDD2

PLLVDD3

XTALVDD

VPLLVDD1

DACVDDA

DACVDDB

DACVDDC

LVDS_GND

LVDS_GND

LVDS_GND

VFE_GND

VFE_GND1

TESTP3TESTN3

AADCVSS

AUDIO_GND

DACFS

LVDS_GND

AVICM

LVDS_GND

LVDS_GND

LVDDB

LVDS_GND

LVDS_GND

VFE_GND1

VFE_GND1

VFE_GND

VFE_GND

TESTN3

AUDIO_GND

LVDS_GND

DACFS

LVDS_GND

AADCVSS

AUDIO_GND

ASB18A

ASB33A

ADCV33A

ADCV33A

ADCV33A

ASB18A

AV18A

AV33A

ADCV18A

SB18A

DV18A

AV33A

5VSB

DV33A

DACVDD

SB33A

AADCVSS 3,10

VFE_GND1 2,3,8,11

REFP 3REFN 3

TESTP4 3TESTN4 3

VFE_GND 2,3,8,11

LVDS_GND 2,3,12

AUDIO_GND 3,10

LVDDC 3

AVDD_VFE0 3

AVDD_VAD0 3

AADCVDD 3

ADACVDD 3

VPLLVDD2 3

LVDDA 3

AVDD_VAD1 3

AVDD_VFE1 3

PLLVDD1 3

PLLVDD2 3

PLLVDD3 3

XTALVDD 3

VPLLVDD1 3

DACVDDA 3

DACVDDB 3

DACVDDC 3

TESTP3 3TESTN3 3

LVDDB 3

PWM2VREF 3

ADCVDD 3

AVICM 3

DACFS 3

AADCVSS 3,10

Title


Date: SheetChecked:

MT8202 DECOUPLING1C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

MT8202 DECOUPLING1C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

MT8202 DECOUPLING1C



KAWA Confidential

<Designer>

<Checker>

NORMAL VIDEO DAC POWER

STANDBY ANALOG POWER

MT8202 DIGITAL POWER & DECOUPLING

NORMAL AUDIO ADC / DAC POWER

NORMAL VIDEO ADC POWER

NORMAL ANALOG POWER

NORMAL VIDEO DAC POWER

PUT ON NEARLY BGA

+ CE2610uF/10V

+ CE2610uF/10V

CB550.1uFCB550.1uF

CB450.1uFCB450.1uF

R46 49.9 1%R46 49.9 1%

+ CE34470uF/16V

+ CE34470uF/16V

CB570.1uFCB570.1uF

C4910uF/10vC0805/SMD


+ CE2910uF/10V

+ CE2910uF/10V

CB460.1uFCB460.1uF

C201uFC201uF

C114.7uFC114.7uF

C310uF/10vC0805/SMD

C310uF/10vC0805/SMD

+ CE3010uF/10V

+ CE3010uF/10V

FB6 FBBEAD/SMD/0603FB6 FBBEAD/SMD/0603

L3 FBL3 FB

+ CE2410uF/10V

+ CE2410uF/10V

C290.01uFC290.01uF

FB15 FBFB15 FB

R45 49.9 1%R45 49.9 1%

L13 FBL13 FB

C254.7uFC254.7uF

CB340.1uFCB340.1uF

+ CE2710uF/10V

+ CE2710uF/10V

CB470.1uFCB470.1uF

C101uFC101uF

C74.7uFC74.7uF

CB320.1uFCB320.1uF

R44 49.9 1%R44 49.9 1%

+ CE36470uF/16V

+ CE36470uF/16V

+ CE3210uF/10V

+ CE3210uF/10V

CB390.1uFCB390.1uF

C184.7uFC184.7uF

CB590.1uFCB590.1uF

CB260.1uFCB260.1uF

FB7 FBFB7 FB

CB580.1uFCB580.1uF

C80.1uFC0603/SMD

C80.1uFC0603/SMD

FB9 FBFB9 FB

CB270.1uFCB270.1uF



CB300.1uFCB300.1uF

C343300pFC343300pF

CB540.1uFCB540.1uF

C54.7uFC54.7uF

L15 150uHL/IND/DIP/P10.0


C323300pFC323300pF

CB490.1uFCB490.1uF

FB13 FBFB13 FB

CB400.1uFCB400.1uF

CB520.1uFCB520.1uF

C224.7uFC224.7uF

C234.7uFC234.7uF

+ CE37220uF/16v

+ CE37220uF/16v

C1730.1uFC1730.1uF

CB311uFCB311uF

CB370.1uFCB370.1uF

R43 49.9 1%R43 49.9 1%

CB381uFCB381uF

C271uFC271uF

CB410.1uFCB410.1uF

C164.7uFC164.7uF

CB600.1uFCB600.1uF

CB480.1uFCB480.1uF

CB280.1uFCB280.1uF

C61uFC61uF


C194.7uFC194.7uF

CB431uFCB431uF

CB290.1uFCB290.1uF

C134.7uFC134.7uF



C264.7uFC264.7uF

CB351uFCB351uF

FB4 FBFB4 FB


C303300pFC303300pF



C333300pFC333300pF

FB1 FBFB1 FB

CB500.1uFCB500.1uF

CB420.1uFCB420.1uF

CB530.1uFCB530.1uF

C313300pFC313300pF

C214.7uFC214.7uF

CB560.1uFCB560.1uF

C1740.01uFC1740.01uF

+ CE2547uF/16V

+ CE2547uF/16V


+ CE2810uF/10V

+ CE2810uF/10V

+ CE3310uF/10V

+ CE3310uF/10V

CB440.1uFCB440.1uF

C154.7uFC154.7uF

C174.7uFC174.7uF

CB610.1uFCB610.1uF

CB360.1uFCB360.1uF

L12 FBL12 FB

FB11 FBFB11 FB

C281uFC281uF

C94.7uFC94.7uF

+ CE38220uF/16v

+ CE38220uF/16v

CB510.1uFCB510.1uF

CB250.1uFCB250.1uF

CB330.1uFCB330.1uF

C141uFC141uF

R42820R42820

L2 FBL2 FB

C244.7uFC244.7uF

+ CE3510uF/10V

+ CE3510uF/10V

10／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

A_CKE

A_DQM1

DV25B

A_RA10

DV25A

A_BA1

F_D7F_A9

A_BA0

F_A10

F_A8

F_D5

F_A17

IOA7 F_D6IOA6IOA5

F_A19

F_A13

F_D4

F_A16

FLASHVCC

F_D2

F_A14

F_A12

F_D0

F_A20

F_A18

F_D1

F_D3

IOCE#

IOA3IOA2

IOWR#

IOA0

IOA4

F_OE#

IOA1

F_A11

D_DQ12

D_DQ14D_DQ13

D_DQ0

D_DQ3

D_DQ1D_DQ2

D_DQ7

D_DQ4

D_DQ6

D_DQ8

D_DQ11

D_DQ5

D_DQ10D_DQ9

D_RAS#

D_DQ15

D_DQ4

D_DQ3D_DQ2D_DQ1D_DQ0

A_RA2A_RA1

A_DQ4

A_DQ1

A_DQ3

A_DQ10

A_DQ0

A_DQ5

A_DQ9

A_DQ6

A_DQ2

A_DQ11

A_DQ19

A_DQ7

A_DQ8

A_DQ17

A_DQ25

A_DQ14

A_DQ16

A_DQ21

A_DQ13

A_DQ26

A_DQ24

A_DQ15

A_DQ20

A_DQ12

A_DQ22A_DQ23

A_DQ18

A_DQ30

A_DQ27

A_DQ29A_DQ28

A_DQ31

D_RA8

D_RA11

IOWR#F_OE#IOCE#

F_A[8..20]

DV25B

DV25A

D_DQM1

D_WE#

D_CAS#

D_DQM0

A_RA0

A_RA3

F_D[0..7]IOA[0..7]

D_RA3D_RA2

D_RA0D_RA1

D_DQS0

D_DQS2

D_DQS3

D_CS#

D_CAS#

D_BA1

D_RAS#

D_WE#

D_BA0

D_RA3

D_RA1D_RA0

D_RA2

D_RA9

D_RA4

D1V25

D_RA10

D_RA11

DV25B

A_CLK

D_CLK#D_CLK

D_DQS1

D_CLK

F_A15

SDV25A

D_DQ16

D_RA6

D_DQM0

D_DQ13

D1V25

D_DQM1

D1V25

D1V25

D_DQ6

D_RA7

D_RA5

D_DQ26

D_RA8

D_DQ27

D_DQ31

VREF

D_DQ28

D_DQ10

D_RA6

D_DQ9

D_DQ8

D_CKE

D_DQS3

D_DQ17

D_DQ23

D_DQ18D_DQ19

D_DQ21D_DQ22

D_DQ27

D_DQ25D_DQ26

D_DQ16

D_DQ29D_DQ30

D_DQ20

D_DQ31

D_DQ28

D_CLK

D_CLK

D_CLK#

D_CLK#

D_CLK#

A_RA8A_RA9A_RA11

VREF

D_DQ31D_DQ30

D_DQ28

A_DQS[0..3]

D_DQ29

A_RA4A_RA5

A_RA7A_RA6

D_RA7D_RA4D_RA5

D_RA6

VREF

DV25A

A_RA[0..11]

A_RAS#

A_CAS#A_WE#A_CS# D_CS#

D_RAS#

D_WE#D_CAS#

D1V25

D_RA2D_RA1D_RA0

D_RA3

D_DQS2

D_DQM0

A_DQS0

D_DQS3

D_DQS0

D_RA9D_RA8

A_DQS2

A_DQS3

D_RA10

D_RA11

A_BA[0..1]

D_BA1

D_DQ24

D_RA6

D_BA0

D_CKE

D_DQM1

A_DQS1 D_DQS1

D_CLK

A_CLK# D_CLK#

D_RA5

D_RA7

D_DQ17

D_RA4

D_DQ24

D_DQ20

D_DQ22

D_DQ23

D_DQ25

D_DQ18 D_DQ29

D_DQ19

D_DQS0

D_DQ16

D_DQ30

D_DQM1

D_DQS1

D_DQ21

D_CKED_CS#

D_WE#D_CAS#

D_DQS2

D_BA0

D_CLK

D_DQM0D_CLK#

D_BA1

D_RA3

D_RA8

D_RA2 D_RA5

D_RA0

D_RA11

D_RA1

D_RA10

D_DQ2

D_RA4

D_RA7

D_RA9

D_DQ1

D_DQ3

D_DQ0

D_DQ6

D_DQ15

D_DQ5

D_DQ14

D_DQ12

D_DQ13

D_DQ11

D_DQ7

A_CLK

D_RA9

D_RA10

D_BA1

D_BA0

D_CS#D_RAS#

A_CLK#A_CKE

D_DQ11

D_DQ8D_DQ9D_DQ10

A_CS#A_RAS#

A_WE#A_CAS#

D_DQ18D_DQ17

A_DQM[0..1]

D_DQ19

A_DQ[0..31]

D_DQ26D_DQ27

D_DQ25

VREFD1V25

D_DQ24

VREF

DV25ASDV25A

D_DQ7

D_DQ5D_DQ4

D_DQ14

D_DQ12

D_DQ15

D_DQ23

D_DQ20

D_DQ22D_DQ21

A_DQM0

VREF

SDV25 SDV25A DV25B

D1V25

VREF

SB33B

SB33B

SB33B

SB33B

DV25B

DV25B

D1V25

D1V25

DV25B

DV25B DV25B

DV25B

VCCVREF

DV25B

DV25A

DV25A

A_RA[0..11] 3A_BA[0..1] 3

A_CLK 3

A_RAS# 3

A_CKE 3A_CS# 3

A_WE# 3A_CAS# 3

A_DQM[0..1] 3A_DQ[0..31] 3

IOA[0..7] 3F_D[0..7] 3

A_DQS[0..3] 3

VREF 3

A_CLK# 3

IOCE# 3

IOWR# 3F_OE# 3

F_A[8..20] 3

DV25A 3SDV25A 3

Title


Date: SheetChecked:

DDR MEMORY & FLASH1C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:




KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:




KAWA Confidential

<Designer>

<Checker>

CLOSE TO 8202 PIN

TSOP 48 PIN

PUT ON NEARLY BGA

VREF DECOUPLING

12345678

RN20

75x4

RN20

75x4

CB970.1uFCB970.1uF

C423300pFC423300pF

CB700.1uFCB700.1uF

R77 75R77 75

+ CE4147uF/16v

+ CE4147uF/16v

R84 22R84 22

12345678

RN18

75x4

RN18

75x4

+ CE46

220uF/16v

+ CE46

220uF/16v

R71 22R71 22

CB121

0.1uF

CB121

0.1uF

C473300pFC473300pF

1 23 45 67 8

RN22

75x4

RN22

75x4

1 23 45 67 8

RN10

47x4

RN10

47x4


1 23 45 67 8

RN4

22x4

RN4

22x4

R83 75R83 75

+ CE44

220uF/16v

+ CE44

220uF/16v

C453300pFC453300pF

1 23 45 67 8

RN21

47x4

RN21

47x4


+ CE45

220uF/16v

+ CE45

220uF/16v

CB780.1uFCB780.1uF

R68 47R68 47


R76 22R76 22

CB770.1uFCB770.1uF

CB830.1uFCB830.1uF

CB120

0.1uF

CB120

0.1uF

R81 75R81 75

R69 47R69 47

C433300pFC433300pFCB93

0.1uF

CB93

0.1uF

1 23 45 67 8

RN8

47x4

RN8

47x4

R78 22R78 22

1 23 45 67 8

RN6

22x4

RN6

22x4

CB950.1uFCB950.1uF

C403300pFC403300pF

R72 75R72 75


CB127

0.1uF

CB127

0.1uF

C553300pFC553300pF

CB990.1uFCB990.1uF


CB920.1uFCB920.1uF

CB820.1uFCB820.1uF

CB124

0.1uF

CB124

0.1uF

R80 22R80 22

+ CE47

220uF/16v

+ CE47

220uF/16v

CB110

0.1uF

CB110

0.1uF

R75 75R75 75

1 23 45 67 8

RN15

75x4

RN15

75x4

CB910.1uFCB910.1uF

CB760.1uFCB760.1uF

L16 FBL16 FB

1 23 45 67 8

RN24

75x4

RN24

75x4

CB125

0.1uF

CB125

0.1uF

R82 22R82 22

CB660.1uFCB660.1uF

1 23 45 67 8

RN14

75x4

RN14

75x4

CB114

0.1uF

CB114

0.1uF

1 23 45 67 8

RN16

47x4

RN16

47x4

1 23 45 67 8

RN3

75x4

RN3

75x4

R327 100/NCR327 100/NC

+ CE39

270uF/16v OS-CON/NCC220UF16V/D6H11

+ CE39

270uF/16v OS-CON/NCC220UF16V/D6H11

12345678

RN5

75x4

RN5

75x4


CB119

0.1uF

CB119

0.1uF

+ CE42220uF/16v

+ CE42220uF/16v

CB840.1uFCB840.1uF

CB860.1uFCB860.1uF

R67 47R67 47


CB690.1uFCB690.1uF

SD2 GND1

VSENSE3VREF4 VDDQ 5AVIN 6PVIN 7VTT 8

U20

IC LP2996 DDR Termination SOP8

U20

IC LP2996 DDR Termination SOP8

+ CE48

220uF/16v

+ CE48

220uF/16v

R64 22R64 22

CB940.1uFCB940.1uF

CB112

0.1uF

CB112

0.1uF

C413300pFC413300pF

CB680.1uFCB680.1uF

CB117

0.1uF

CB117

0.1uF

IN3

AD

J/G

ND

1

OUT 2

U21LT1084-2.5 TO-252-3

TO-252-3/SMDU21LT1084-2.5 TO-252-3

TO-252-3/SMDCB122

0.1uF

CB122

0.1uF

1 23 45 67 8

RN11

47x4

RN11

47x4

CB64

0.1uF

CB64

0.1uF

12345678

RN7

75x4

RN7

75x4

CB129

0.1uF

CB129

0.1uF C5610uF/10vC0805/SMD


+ CE40

220uF/16v

+ CE40

220uF/16v

R70 75R70 75

C443300pFC443300pF

R66 47R66 47

CB750.1uFCB750.1uF

R85 75R85 75

R63

10k

R63

10k

CB880.1uFCB880.1uF

R61

10k

R61

10k

1 23 45 67 8

RN23

75x4

RN23

75x4

TP40TP40

CB960.1uFCB960.1uF


CB720.1uFCB720.1uF

R73 22R73 22

CB890.1uFCB890.1uF

VDD1DQ02VDDQ3DQ14DQ25VSSQ6DQ37DQ48VDDQ9DQ510DQ611VSSQ12DQ713NC14VDDQ15LDQS16NC17VDD18DNU19LDM20WE21CAS22RAS23CS24NC25BA026BA127A10/AP28A029A130A231A332VDD33

VSS 66DQ15 65VSSQ 64DQ14 63DQ13 62

VDDQ 61DQ12 60DQ11 59VSSQ 58DQ10 57DQ9 56

VDDQ 55DQ8 54

NC 53VSSQ 52UDQS 51

NC 50VREF 49

VSS 48UDM 47

CK 46CK 45

CKE 44NC 43

A12 42A11 41A9 40A8 39A7 38A6 37A5 36A4 35

VSS 34

8M x 16DDR

U19

HY5DU281622ET-5 8Mx16 TSOP(II)-66/SMD

8M x 16DDR

U19



CB900.1uFCB900.1uF

CB730.1uFCB730.1uF

VDD1DQ02VDDQ3DQ14DQ25VSSQ6DQ37DQ48VDDQ9DQ510DQ611VSSQ12DQ713NC14VDDQ15LDQS16NC17VDD18DNU19LDM20WE21CAS22RAS23CS24NC25BA026BA127A10/AP28A029A130A231A332VDD33

VSS 66DQ15 65VSSQ 64DQ14 63DQ13 62

VDDQ 61DQ12 60DQ11 59VSSQ 58DQ10 57DQ9 56

VDDQ 55DQ8 54

NC 53VSSQ 52UDQS 51

NC 50VREF 49

VSS 48UDM 47

CK 46CK 45

CKE 44NC 43

A12 42A11 41A9 40A8 39A7 38A6 37A5 36A4 35

VSS 34

8M x 16DDR

U18


8M x 16DDR

U18


CB123

0.1uF

CB123

0.1uF

CB111

0.1uF

CB111

0.1uF

CB118

0.1uF

CB118

0.1uF

CB810.1uFCB810.1uF

CB670.1uFCB670.1uF

CB740.1uFCB740.1uF

CB113

0.1uF

CB113

0.1uF

CB790.1uFCB790.1uF

CB870.1uFCB870.1uF

R329 100/NCR329 100/NC

CB650.1uFCB650.1uF

R74 4.7kR74 4.7k

CB116

0.1uF

CB116

0.1uF

A025A124A223A322A421A520A619A718A88

A199

OE28

BYTE 47

A18 16

D0 29D1 31D2 33D3 35

A97

CE26

D4 38D5 40D6 42D7 44D8 30D9 32

A2010

D11 36D12 39D13 41D14 43D15 45

VCC 37

GND1 27WE11

RY/BY15

D10 34

GND2 46

A106

A124 A115

A133A142A151A1648A1717 NC 13

RESET12

WP/ACC 14

U17

29LV160

U17

29LV160

R328 100/NCR328 100/NC

CB1070.1uFCB1070.1uFR79 75R79 75

1 23 45 67 8

RN9

75x4

RN9

75x4

1 23 45 67 8

RN13

47x4

RN13

47x4

L17 FBL17 FB

R620R620

CB980.1uFCB980.1uF

1 23 45 67 8

RN12

75x4

RN12

75x4

CB800.1uFCB800.1uF

1 23 45 67 8

RN19

47x4

RN19

47x4C463300pFC463300pF

1 23 45 67 8

RN2

22x4

RN2

22x4

CB128

0.1uF

CB128

0.1uF

C543300pFC543300pF

R65 75R65 75

CB126

0.1uF

CB126

0.1uF

1 23 45 67 8

RN25

22x4

RN25

22x4

1 23 45 67 8

RN17

47x4

RN17

47x4

CB710.1uFCB710.1uF

CB850.1uFCB850.1uF


11／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

CI2CA

VCC18

PVCC

CLOCK+

HDMILRCK

VI13

IOVCC

HD

MIR

ST#

DATA1-

VI12

AVCC

DDC_SCL

VI22

DDC_SDA

HDMIODCKHDMIHSYNC

XTLO

VCC

18

DATA2-

AVCC

HDMIODCK

VI4

CLOCK+

VCC18

VCC

18

VI14

HD

MIS

D1

DATA0+

DATA2+IOVCC

27MHZ

HDMIBCLK

VI21

XTLI

HD

CP_

SDA

VCC18

IOVCC

HDMIDE

HDMISD3

SCL_8202

9993_SCL

VI18

HDMIVSYNC

VCC

18

HD

MIS

D0

VCC18

KWP

IOVCC

VI20

IOVC

C

CC

IR_V

3

AVCC

DE_SOG

HD

CP_

SCL

DATA0-

AVCC

VCC18

HDMISD2

HDMISD0

VI17

VI15

PVCC

HDMISD1

INT0#

VI1

PLUGPWR

IOVC

C

HD

MIB

CLK

DATA1+

PLUGPWR

IOVCC

HDMICEN

SDA_8202

9993_SDASCL_8202

IOVC

C

IOVC

C

9993_SCL

DE_SOG

DDC_SCL

IOVC

C

HD

MIC

EN

REG

VCC

HD

MIM

CLK

CI2CA

DDC_SDA

VI[0..23]

HDMIMCLK

VI16

VI19

HDMIHSYNCHDMIVSYNC

VI7

CCIR_V1

HD

MIS

D3

VCC

18

HD

MIL

RC

K

27MHZ

SDA_8202CLOCK-

OSC

_IN

CLOCK-

VI10

VI8

REGVCC

VI9

DATA1+

HDMIDE

DATA2+

VI2VI3

IOVCC

VI23

VCC18

VI11

VI5VI6

DATA0+

DATA2-

DATA0-

VI0

HD

MIS

D2

DATA1-

INT0#

HDMIRST#

VCC18

AVCC

DDC_SDADDC_SCL

XTLI XTLO

HDMICAB

HDMI_PLUGPWR

AVCC

AVCC

AVCC

AVCC

9993_SDA

KWP

HDCP_SDAHDCP_SCL

CCIR_V1CCIR_V3

CVBS_OUTSPDIF

SPD

IF

CVBS_OUT

HDMI_PLUGPWR

HDMI_PLUGPWR

DV33B

DV33B DV33BAVCC

DV33B

SB33B

DV33B

HDMI_PLUGPWRVCC

DV33B DV33B

DE_SOG 3HDMIVSYNC 3,7

SCL_8202 3,9,12SDA_8202 3,9,12

HDMIMCLK 3,7

HDMICEN 3

HDMISD2 3

HDMIODCK 3,7

HDMISD0 3,7

INT0# 3

HDMIDE 3,7

HDMISD1 3

HDMIBCLK 3,7

HDMIHSYNC 3,7

HDMISD3 3

VI[0..23] 3,7

HDMILRCK 3,7

27MHZ 3

CCIR_V1 3CCIR_V3 3

CVBS_OUT 9,15

Title


Date: SheetChecked:

HDMI INPUT MT82931C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

HDMI INPUT MT82931C



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

HDMI INPUT MT82931C



KAWA Confidential

<Designer>

<Checker>

WHEN USE HDMI COAXOUT,C127 CHANGE 0 RES

ADD HDMI COAXOUT

R686 R/NCR686 R/NC

R698 0R698 0

L78

FB

L78

FB

C683

33pF

C683

33pF

CB217

0.1uF

CB217

0.1uF


U51

EEPROM 24C04/CODE

U51

EEPROM 24C04/CODE


R699 0R699 0

C618

1000PF

C618

1000PF

CB229

0.1uF

CB229

0.1uF

C6261000PFC6261000PF

12D7 DIODE EGA-0603D7 DIODE EGA-0603

TP59TP59

R789

100

R789

100

+ CE610

100uF/16v

+ CE610

100uF/16v


L79 FBL79 FB

R709 47kR709 47k

R690

1K

R690

1K

C624

1000PF

C624

1000PF

12345678

RN27 33x4RN27 33x4

C682

0.1uF

C682

0.1uF

C622

1000PF

C622

1000PF

C619

1000PF

C619

1000PF

12345678

RN29 33x4RN29 33x4

R711 0/NCR711 0/NC


12345678

RN32

33x4

RN32

33x4

L85

FB

L85

FB

123456789

10111213141516171819

222120

23

P1

HDMIHDMI TYPE-A

P1

HDMIHDMI TYPE-A

TP62TP62

TP64TP64


TP77TP77

TP71TP71

C6201000PFC6201000PF

CB212

0.1uF

CB212

0.1uF

CV

CC

1866

CG

ND

1865

CGND18 126

RX2+63

IOG

ND

3330

CVCC18 112

RX2-62 AVCC61

AGND64

AVCC57

AGND60

AGND56 RX0+55 RX0-54

AGND52 RXC+51 RXC-50 AVCC49

QE11 108

SD

173

SP

DIF

70

IOG

ND

3378

QE10 109

MC

LK79

CI2CA38

IOGND33 118

XTA

LVC

C86

RE

GV

CC

87

IOV

CC

3368

QE4 117

MU

TE67

EXT_RES48

CVCC1845

IOG

ND

3369

IOVCC33 107

IOGND33 97

QE3 121IOVCC33 120

CGND18 113

IOGND33 106

QE7 114QE6 115

QE8 111

QE5 116

QE1 123

RX1-58RX1+59

QE9 110

WS

75S

CK

76

HSYNC 128

VS

YN

C1

DE 127

CE

N2

SO

G_I

N3

OS

C_I

N4

NC

5

IOV

CC

337

IOG

ND

336

NC

8K

WP

9K

SD

A10

CG

ND

1813

ODCK 119

CV

CC

1812

GP

IO13

16

KS

CL

11

GP

IO14

15

GP

IO12

17

GP

IO11

20G

PIO

1021

GP

IO9

22

IOV

CC

3319

IOG

ND

3318

GP

IO8

23

GP

IO7

26G

PIO

627

GP

IO5

28G

PIO

429

GP

IO3

32

CV

CC

1824

CG

ND

1825

CGND1837 CVCC1836

GPIO233GPIO134GPIO035

INT

91

RE

SE

T#89

TES

T88

SC

DT

90

QE2 122

SD

371

SD

272

IOVCC33 98

PGND46PVCC47

GP

IO15

14

IOV

CC

3331

AVCC53

CSDA39CSCL40DSDA41DSCL42CEC43PWR5V44

SD

074

IOV

CC

3377

CG

ND

1880

CV

CC

1881

AU

DP

VC

C18

82A

UD

PG

ND

83X

TALO

UT

84X

TALI

N85

QE

2392

QE

2293

QE

2194

QE

2095

QE

1996

QE18 99QE17 100QE16 101QE15 102QE14 103QE13 104QE12 105

QE0 124CVCC18 125

ePad/GND G1

MT8293

U25MT8293

LQFP128/SMD/8293

MT8293

U25MT8293

LQFP128/SMD/8293

L84

FB

L84

FB

CB210

0.1uF

CB210

0.1uF

R6924.7KR6924.7K

+CE613

10uF/16v

+CE613

10uF/16v

L83 FBL83 FB

TP79TP79

C623

1000PF

C623

1000PF

R70347kR70347k

TP74TP74

R710

1M/NC

R710

1M/NC

+ CE612

47uF/16v

+ CE612

47uF/16v

R696

4.7K/NC

R696

4.7K/NC

12345678

RN30 33x4RN30 33x4 C631

1000PF

C631

1000PF



U50

EEPROM 24C04/CODE

U50

EEPROM 24C04/CODE

S1 1

G1 2

D23 S2 4

G25

D16

U34

UPA672T

U34

UPA672T

R708 0/NCR708 0/NC

R74610KR74610K

R95 0R95 0

CB221

0.1uF

CB221

0.1uF

CB226

0.1uF

CB226

0.1uF

L81

FB

L81

FB

CB219

0.1uF

CB219

0.1uF

+CE614

10uF/16v

+CE614

10uF/16v

12345678

RN26 33x4RN26 33x4

CB234

0.1uF

CB234

0.1uF

CB218

0.1uF

CB218

0.1uF

C6111000pFC6111000pF

CB224

0.1uF

CB224

0.1uF

12345678

RN28 33x4RN28 33x4

R695

0

R695

0

+CE609

10uF/16v

+CE609

10uF/16v

CB227

0.1uF

CB227

0.1uF

C615

1000PF

C615

1000PF

TP65TP65

TP69TP69

CB232

0.1uF

CB232

0.1uF


C632

0.1uF

C632

0.1uF

CB214

0.1uF

CB214

0.1uF

CB225

0.1uF

CB225

0.1uF

CB223

0.1uF

CB223

0.1uF

TP76TP76

C627

1000PF

C627

1000PF

TP63TP63

D68

1N4148/NC

D68

1N4148/NC

TP58TP58

C629

1000PF

C629

1000PF

AD

J/G

ND

1

OUT 2IN3

U48 AZ1117-1.8

SOT223/SMD

U48 AZ1117-1.8

SOT223/SMD

CB216

0.1uF

CB216

0.1uF

C633

0.01uF

C633

0.01uF


R687 0R687 0

+ CE611

47uF/16v

+ CE611

47uF/16v

R70447kR70447k

TP68TP68

C621

1000PF

C621

1000PF

TP60TP60

12

D15

DIODE EGA-0603

D15

DIODE EGA-0603R691

4.7K

R691

4.7K

C630

1000PF

C630

1000PF

CB220

0.1uF

CB220

0.1uF

C628

1000PF

C628

1000PF

TP61TP61

1

32

Q362N3904SOT23/SMD

Q362N3904SOT23/SMD

C6121000pFC6121000pF

R6934.7kR6934.7k

CB222

0.1uF

CB222

0.1uF

L82

FB

L82

FB

C63518pF/NCC63518pF/NC

R707 0R707 0

R700 0R700 0

TP70TP70

C625

1000PF

C625

1000PF

CB215

0.1uF

CB215

0.1uF

C63418pF/NC

C63418pF/NC

R688 0R688 0


12345678

RN31 33x4RN31 33x4

TP73TP73


Y2

27MHz/NC

CRYS/49US/P4.88

Y2

27MHz/NC

CRYS/49US/P4.88

TP72TP72

CB231

0.1uF

CB231

0.1uF

C617

1000PF

C617

1000PF

12

D16

DIODE EGA-0603

D16

DIODE EGA-0603

L80

FB

L80

FB

D17 1N4148D17 1N4148

CB230

0.1uF

CB230

0.1uF

R701 0R701 0

R74710KR74710K

CB228

0.1uF

CB228

0.1uF

R790

100

R790

100

C6131000pFC6131000pF

CB213

0.1uF

CB213

0.1uF

CB233

0.1uF

CB233

0.1uF

C614

1000PF

C614

1000PF

TP75TP75

TP66TP66

C616

1000PF

C616

1000PF

123

J13

DIP3/W/H/P2.0

J13

DIP3/W/H/P2.0

R689 0R689 0

TP67TP67


12／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

VI[0..23]

HDMIDE

HDMIHSYNCHDMIVSYNC

HDMIODCK

SCL1SDA1

HDMISD0

HDMIBCLKHDMILRCK

HDMIMCLK

RXD1TXD1

RXDTXD

GPIO3

SCL1SDA1

TXDRXD

READY#

9V

V5V

CCIR_V6GPIO3

V5V

V9V

HDMIMCLKHDMIBCLK

VI0VI1VI2VI3

VI4VI5VI6VI7

VI8VI9VI10VI11

VI16VI17VI18VI19

VI12VI13VI14VI15

VI20VI21VI22VI23

HDMIHSYNCHDMIVSYNCHDMIDEHDMIODCK

TXD1RXD1

SDA0SCL0

SCL0SDA0

CCIR_V6

REQUEST#READY#

REQUEST#

HDMILRCKHDMISD0DATA0

LRCK LRCKDATA0

9V

GND

V9V

VCC V5V

9V V9V

SB33B

SB33B

SB33BSB33B

VCC

9V

SB33B

VCC

DV33B

SB33B

VI[0..23] 3,6

HDMIDE 3,6

HDMIHSYNC 3,6HDMIODCK 3,6

HDMIVSYNC 3,6

SCL1 3SDA1 3

HDMIMCLK 3,6HDMIBCLK 3,6HDMILRCK 3,6HDMISD0 3,6

RXD1 3TXD1 3

RXD 3,11TXD 3,11

CCIR_V6 3GPIO3 3

SDA0 3SCL0 3

9V 1,9,14

Title


Date: SheetChecked:

MT5351 INTERFACE1B



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

MT5351 INTERFACE1B



KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:

MT5351 INTERFACE1B



KAWA Confidential

<Designer>

<Checker>

FOR MT5351 INTERFACE

TXD:MT5351 Transmit

RXD1:MT5351& MT8205 CommunicationTXD1:MT5351& MT8205 Communication

RXD:MT5351 Receiver

Trace width of 12V>30milTrace width of 5V >40mil

LO = > DTV BOARD POWER OFFHI = > DTV BOARD POWER ON

DTV POWER CONTROL

change 2/16

R363

1K/NC

R363

1K/NC

R786 0/NCR786 0/NC

GND 10VCC 20DIR1

A0 9A1 8A2 7

OE19

B718

A3 6

A4 5A5 4A6 3A7 2

B011 B112 B213 B314

B415 B516 B617

U31 74LVC245AU31 74LVC245A

R222 0/NCR222 0/NC

R35810kR35810k

R230 0/NCR230 0/NC R228 0R228 0

R787 0/NCR787 0/NC


R64210kR64210k

GND 10VCC 20DIR1

A0 9A1 8A2 7

OE19

B718

A3 6

A4 5A5 4A6 3A7 2

B011 B112 B213 B314

B415 B516 B617

U32 74LVC245AU32 74LVC245A

R4 0R4 0

R362

1K/NC

R362

1K/NC

1234567

J1

7x1DIP7/P2.0/NC

J1

7x1DIP7/P2.0/NC

R788 0/NCR788 0/NC

C6011uF/NCC6011uF/NC

R3 0R3 0

R355 0/NCR355 0/NCR210KR210K

+CE143

220uF/16v/NC

+CE143

220uF/16v/NC

C6021uF/NCC6021uF/NC

R354 0/NCR354 0/NC


R356 0R356 0

GND 10VCC 20DIR1

A0 9A1 8A2 7

OE19

B718

A3 6

A4 5A5 4A6 3A7 2

B011 B112 B213 B314

B415 B516 B617

U30 74LVC245AU30 74LVC245A

R110KR110K

R36010k/NC

R36010k/NC

R35910kR35910k

1

32



+CE142

220uF/16v/NC

+CE142

220uF/16v/NC

R357 0R357 0




GND 10VCC 20DIR1

A0 9A1 8A2 7

OE19

B718

A3 6

A4 5A5 4A6 3A7 2

B011 B112 B213 B314

B415 B516 B617

U33 74LVC245AU33 74LVC245A

R36110k/NC

R36110k/NC


1

32

Q222N3904

SOT23/SMD

Q222N3904

SOT23/SMD

123456789

1011121314151617181920212223242526272829303132333435363738394041424344454647484950

J24

CON50

J24

CON50

1

32

Q232N3904

SOT23/SMD

Q232N3904

SOT23/SMD

R229 0R229 0

R643

0/NC

R643

0/NC

S1 1G1 2S2 3G2 4D25 D26 D17 D18

U45

IRF7316SOp8/SMD

U45

IRF7316SOp8/SMD

13／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

Y2_INB

CR2_GNDB

Y2_GNDB

AV_R

AV_L

CB2_GNDBY3_GNDB

Y3_INB

CR3_GNDB

CB3_GNDB

CB3_INB

CRQ_GND

CBQ_GND

CR2_INB

CB2_INB

CR2_INB CRQYQY2_INB

CBQ

CRQYQ

CBQCB2_INB

CR3_INB

CCIR_V7

AV1_R

AV1_L

+3.3V

5V

GPIO17

GPIO15

GPIO18

GPIO11

5V

5V

AV1_R

SW1S2

SW1S2

CCIR_V5

SW1S1

SY_R

SY_L

AV1_L

AV2_R

AV2_L

AADCVSS

CR3_INB

CR2_INB

Y2_INB

Y3_INB

CB2_INB

CB3_INBCB3_GNDB

Y2_GNDB

CR3_GNDB

CR2_GNDB

CB2_GNDB

Y3_GNDB

CCIR_V5

VFE_GND

GPIO17GPIO18

GPIO15

CRQ_GND

AV1_L

SY_RSY_L

AV1_R

AV2_RAV2_L

GPIO11CCIR_V7

CCIR_V0

SW1S1

GPIO16

AV_R

CBQ

YQ_GND

YQ

CBQ_GND

CRQ

AV_L

YQ_GND

GPIO16

9V

ADC_IN0

ADC_IN0

AV_RAV_L

CCIR_V0

SB33B

VCC DV33B

VCC

VCC

VCC

VCC

SB33B

+3.3V

SWV9SWV9

SWV9

SWV9

SWV9

SWV9

SWV9

SWV9

SWV9

SB33B SB33B

VCC

SB33B

5VSB

AADCVSS 3,4,10

Y3_INB 15

CR3_INB 15

CB3_INB 15Y3_GNDB 15

CB3_GNDB 15

CR3_GNDB 15

Y2_INB 15

CR2_INB 15

CB2_INB 15Y2_GNDB 10,15

CR2_GNDB 10,15

CB2_GNDB 10,15

CCIR_V5 3

GPIO15 3

GPIO17 3GPIO18 3VFE_GND 2,3,4,11

CRQ_GND 10

AV1_R 15AV1_L 15AV2_R 15AV2_L 15

SY_L 15SY_R 15

GPIO11 3CCIR_V7 3

GPIO16 3

AV_L 9

CBQ 10

CBQ_GND 10

AV_R 9

YQ_GND 10

YQ 10

CRQ 10

9V 1,7,9,14

ADC_IN0 3CCIR_V0 3

Title


Date: SheetChecked:AKAI_MT8202_27US_LVDS_V0.0 1C


DAUGHTER BOARD IN

KAWA Confidential

<Designer>

<Checker>

Title




DAUGHTER BOARD IN

KAWA Confidential

<Designer>

<Checker>

Title




DAUGHTER BOARD IN

KAWA Confidential

<Designer>

<Checker>

HI = > DVD BOARD POWER ON

LO = > DVD BOARD POWER OFF

GPIO FOR USB CONTORL

DVD POWER CONTROL

INPUT

OUTPUT +

CE118

22uF/25v

+

CE118

22uF/25v

+

CE115

22uF/25v

+

CE115

22uF/25v

L55FBL55FB

R383 0/NCR383 0/NC

L71 FB/NCL71 FB/NC

I1B6

I0A2I1A3

S1

YA4I0B5

YB7GND8

I0D 14E# 15

I1D 13

I0C 11YD 12

VCC 16

I1C 10YC 9

U39

QS3VH257TSSOP16/SMD

U39

QS3VH257TSSOP16/SMD

R373100kR373100k

R443 0/NCR443 0/NC

R36810K

R36810K

R627 0/NCR627 0/NC

12345678

J32

DIP8/W/H/P2.0

J32

DIP8/W/H/P2.0

L76 FB/NCL76 FB/NC

R447 0/NCR447 0/NC

1

32


Q282N3904SOT23/SMD/NCR4510/NC R4510/NC

R440 0/NCR440 0/NC

R381100kR381100k

C1581000pF/NCC1581000pF/NC

R438 0/NCR438 0/NC

C1561000pF/NCC1561000pF/NC

R442 0/NCR442 0/NC

+CE60722uF/25v

+CE60722uF/25v

L75 FB/NCL75 FB/NC

R716100KR716100K

R71847KR71847K

+CE141

220uF/16v/NC

+CE141

220uF/16v/NC

R371 0/NCR371 0/NC

R378100kR378100k

+ CE153470uF/16v /NC

+ CE153470uF/16v /NC

R380100kR380100k

123456

J31

DIP6/W/H/P2.54

J31

DIP6/W/H/P2.54

R446 0/NCR446 0/NC

R72110KR72110K

+ CE154220uF/16v/NC

+ CE154220uF/16v/NCR450

10kR45010k


R61310K/NC

R61310K/NC

R724 10KR724 10KR717100KR717100K1

32 Q37

2N3904SOT23/SMD

Q372N3904SOT23/SMD



R382 0/NCR382 0/NC

R714100KR714100K

3X11

0X12

2Y2

0Y1

1Y5 Y 31X14

A10B9

X 13

3Y4VEE 7

INH 6

VCC 16

VSS 8

2X15

U52

HEF4052SOP16/SMD

U52

HEF4052SOP16/SMD

R374100KR374100K


+

CE155

22uF/25v

+

CE155

22uF/25v

R723

10K

R723

10K

+

CE116

22uF/25v

+

CE116

22uF/25v

L72 FB/NCL72 FB/NC

C195

1uF/NC

C195

1uF/NC

R370 0/NCR370 0/NC

R20 0/NCR20 0/NC


R72047KR72047K

L74 FB/NCL74 FB/NC

L52FBL52FB

R445 0/NCR445 0/NC

+

CE117

22uF/25v

+

CE117

22uF/25v

R372100kR372100k

C1551000pF/NCC1551000pF/NC

R377100kR377100k

S1 1G1 2S2 3G2 4D25 D26 D17 D18

U44

IRF7316SOp8/SMD

U44

IRF7316SOp8/SMD

R369 0/NCR369 0/NC

+

CE156

22uF/25v

+

CE156

22uF/25v

C1571000pF/NCC1571000pF/NC

R21 0R21 0

+ CE60822uF/25v

+ CE60822uF/25v

R431 0/NCR431 0/NC

R715100KR715100K

R439 0/NCR439 0/NC

1

32 Q38

2N3904SOT23/SMD

Q382N3904SOT23/SMD

R375100KR375100K

R726 10KR726 10K

AD

J/G

ND

1

OUT 2IN3

U47

AZ1117-3.3VSOT223/SMD/NC

U47

AZ1117-3.3VSOT223/SMD/NC

R448 0/NCR448 0/NC


L73 FB/NCL73 FB/NC

R444 0/NCR444 0/NC

14／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

AOBCLK

AOMCLK

ADIN

AOBCLK

AOLRCKAOLRCK

SDA_8202

SCL1

4

SCL14

SDA14

COD_VOUTL

COD_VOUTR AUSPR

AUSPL

CODHPOUTRAOLRCK

HPVDD

DV33B

DVD

D

HPVDD

AOLR

CK

HPVDD_

SCL_8202

COD_VOUTRCOD_VOUTL

SDA1

4

HPV

DD

VMIDDAC

VMIDADCVMIDADC

CODHPOUTL

VGAL_IN

VGAR_IN

YPBPR1_R

YPBPR1_L

YPBPR2_L

YPBPR2_R

AV_R

AV_L

YPBPR3_L

YPBPR3_R

AVCVBSO

AVCVBSOTESTP2

AVL_OUTAL

ARAVR_OUT

DVDD

A_MUTE

OP1VREF

OP1VREF

MU

SCL_8202

SDA_8202SDA

SCL

AOSDATA1

TESTP2

AOLRCKADIN

AOMCLKAOBCLK

YPBPR1_LYPBPR1_R

SDA_8202SCL_8202

SDASCL

CVBS_OUT

YPBPR2_LYPBPR2_R

YPBPR3_LYPBPR3_R

AV_RAV_L

ARAL

GPIO7

AUSPLAUSPR

MU

AVL_OUTAVR_OUT

VGAR_INVGAL_IN

AVL_OUT1

AVL_OUT1

GPIO7

AVR_OUT1AVR_OUT1

A_MUTE9V

CVBS_OUT

MU

ADCREFPADCREFPADCREFPADCREFPADCREFPADCREFPADCREFPADCREFP

AOSDATA1AOSDATA1AOSDATA1AOSDATA1

AOMCLK

STBY

SB33B

VCC

DV33B

HPVDD

VCC

VCC

OPA1V9

OPA1V9

SB33B

OP1VREF

OP1VREF

9VOPA1V9

DVDD

9VVCC

OP1VREF

SB33B

VCC

SB33B

HPVDD

CVBS_OUT 6,15

AOSDATA1 3

SDA 1,14SCL 1,14

AOMCLK 3,16AOBCLK 3,16

ADIN 3AOLRCK 3,16

YPBPR1_L 15YPBPR1_R 15

SCL_8202 3,6,12SDA_8202 3,6,12

TESTP2 3

YPBPR2_R 15YPBPR2_L 15YPBPR3_R 15YPBPR3_L 15

AV_R 8AV_L 8

AVL_OUT 15AVR_OUT 15

AL 3AR 3

GPIO7 3

AUSPR 16AUSPL 16

MU 16

VGAR_IN 11VGAL_IN 11

A_MUTE 179V 1,7,14

Title



9 17Saturday, April 22, 2006

M8776 & VIDEO BYPASS

KAWA Confidential

<Designer>

<Checker>

Title





KAWA Confidential

<Designer>

<Checker>

Title





KAWA Confidential

<Designer>

<Checker>

INPUT

BYPASS VIDEO OUTPUT

BYPASS AUDIO OUTPUT

H : MUTEL : ENABLE

AUDIO BYPASS MUTE

OUTPUT

*

**

*

*

**

*

*

*

*

* *

*

*

REMARKS: * FOR LCDTV

LCDTVR232 CB132R233 CB133R227 CB131R234 CB134R666 C134 CE139C152 CE140Q27 CE138R226

22 22 22 2256pF 56pF 56pF 22 56pF 24K NC NC NC NC NC NC

*

+

CE14810uF/25V

+

CE14810uF/25V

R22733R22733

+C181

10uF/25v

+C181

10uF/25v

R403 100R403 100

+CE13810uF/16v

+CE13810uF/16v

+

CE121 10uF/25v

+

CE121 10uF/25v

R6772KR6772K

+

CE135

10uF/25v

+

CE135

10uF/25v

+

CE133

10uF/25V

+

CE133

10uF/25V

C1341uFC1341uF

R650100R650100



R752100R752100

CB630.1uFCB630.1uF

1

32

Q292N3904SOT23/SMD

Q292N3904SOT23/SMD

+ CE13110uF/25v

+ CE13110uF/25v

R25247KR25247K

+

CE122 10uF/25v

+

CE122 10uF/25v

+

CE124 10uF/25v

+

CE124 10uF/25v

1 2D5 1N4148D5 1N4148

+ CE1610uF/25v

+ CE1610uF/25v

R652 0R652 0

R632

470

R632

470

R648 10KR648 10K

CB13233pF/NCCB13233pF/NC

+

CE13210uF/25v

+

CE13210uF/25v

R407 10kR407 10k

C1521uFC1521uF

C605150pFC605150pF

L70 22L70 22

TP54TP54

+

CE126 10uF/25v

+

CE126 10uF/25v

R408 10kR408 10k

1

32

Q342N3906Q342N3906

R409 10kR409 10k

R750100R750100


+

CE15010uF/25V

+

CE15010uF/25V

R24610K/NCR246

10K/NC

C184100pFC184100pF

R653 10KR653 10K

TP53TP53


+

CE125 10uF/25v

+

CE125 10uF/25v



R655100R655100

+

CE139

2.2uF/50v

+

CE139

2.2uF/50v

L64

FB

L64

FB

1

32

QF1

MOSFET N SN7002SOT23/SMD

QF1


R651 39KR651 39K

R51 0/NCR51 0/NC

+

CE123 10uF/25v

+

CE123 10uF/25v R404 10kR404 10k

L65 FBL65 FB

R226 33R226 33

R654 5.1KR654 5.1K

12

D61N4148D61N4148

C606820pFC606820pF

R663

0

R663

0

CB201

0.1uF

CB201

0.1uF

L114 FB/NCL114 FB/NC

+ CE12710uF/25v

+ CE12710uF/25v

R223 47KR223 47K

+CE13447uF/16v

+CE13447uF/16v

+CE1910uF/25v

+CE1910uF/25v

R41 0/NCR41 0/NCR7512K

R7512K

R42947KR42947K

CB620.1uFCB620.1uF

+

CE128 10uF/25v

+

CE128 10uF/25v

R644

470

R644

470

R59 0R59 0R428 0/NCR428 0/NC

R23333

R23333

1

32

QF2


QF2


+

CE140 470uF/16V

+

CE140 470uF/16V

+

CE129 10uF/25v

+

CE129 10uF/25v

5

67

84

+

-

U46B

NJM4558 OPA

+

-

U46B

NJM4558 OPA

R649 5.1KR649 5.1K

C604820pFC604820pF


C187 10uF/10vC187 10uF/10v

R234

33

R234

33

12

D4

1N4148

D4

1N4148

R411 10kR411 10k

+

CE149

10uF/25vC100UF16V/D6H11

+

CE149

10uF/25vC100UF16V/D6H11

R40

55.

1KR

405

5.1K

CB193

0.1uF

CB193

0.1uF

R399 10kR399 10k

R4131kR4131k

R402 10kR402 10k

R668 470R668 470

1 2D3 1N4148D3 1N4148

R398 10kR398 10k

R414

10k

R414

10k

+

CE151470uF/16V

+

CE151470uF/16V

R42724KR42724K

+

CE11910uF/25v

+

CE11910uF/25v

R7491KR7491K

R400 10kR400 10k

C186 10uF/10vC186 10uF/10v

R647 0R647 0

1

32

Q302N3904SOT23/SMD

Q302N3904SOT23/SMD

R662

NC

R662

NC

R748 68R748 68

3

21

84

+

-

U46A

NJM4558 OPA

+

-

U46A

NJM4558 OPA

R66622kR66622k

+CE5

10uF/25v

+CE5

10uF/25v

1

32

Q272SD2653K

Q272SD2653K

R412 10kR412 10k

1

32

Q12N3904/NC

Q12N3904/NC

R646 39KR646 39K


+ CE13010uF/25v

+ CE13010uF/25v

R415

10k

R415

10k

R401 100R401 100

R23233

R23233

R40

65.

1KR

406

5.1K

R2354K7/NCR2354K7/NC

R43075 1%R43075 1%


AIN2L1AIN1R2AIN1L3DACBCLK4DACMCLK5DIN6DACLRC7ZFLAGR8ZFLAGL9ADCBCLK10ADCMCLK11DOUT12

AD

CLR

C13

DG

ND

14D

VD

D15

MO

DE

16C

E17

DI

18C

L19

HP

OU

TL20

HP

GN

D21

HP

VD

D22

HP

OU

TR23

NC

24

NC 25VOUTL 26VOUTR 27VMIDDAC 28DACREFN 29DACREFP 30AUXR 31AUXL 32VMIDADC 33ADCREFGND 34ADCREFP 35AVDD 36

AG

ND

37A

INV

GR

38A

INO

PR

39A

INV

GL

40A

INO

PL

41A

IN5R

42A

IN5L

43A

IN4R

44A

IN4L

45A

IN3R

46A

IN3L

47A

IN2R

48U41

WM8776

U41

WM8776

+CE77

220uF/16v

+CE77

220uF/16v

+

CE12010uF/25v+

CE12010uF/25v

C603150pFC603150pF

+CE152100uF/16V

+CE152100uF/16V

C12

1uF

C12

1uF

+

CE147

10uF/25vC100UF16V/D6H11

+

CE147

10uF/25vC100UF16V/D6H11R631

1.5KR6311.5K

C183100pFC183100pF

R426 0R426 0

R41033R41033

15／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

Y0+

CB1_INB

CR1_GNDB

CR1_INB

Y1_INB

Y0-

CB1_GNDB

CBQ_GND

YQ

YQ_GND

Y1_GNDB

CRQ

CRQ_GND

CBQ PB0+

PB0-

PR0+

PR0-

Y1+

Y1-

PB1+

PB1-

PR1+

PR1-

SOY1SOY0

SOY1

SOY0

CB1_INBCB1_GNDB

CRQCBQ

Y1_INBY1_GNDBCR1_INBCR1_GNDB

AF MPX2

SIF MPX1

MPX1

MPX2

YQ_GND

SC_0_GND

YQ

SY1

SY0

SC1

SC0

CBQ_GND

CVBS0CVBS1CVBS2

PR1+

SOY1

Y1+

PB1+

PR1-

Y1-

PB1-

PR0-SOY0

PB0+

Y0+

PR0+

Y0-

PB0-

AADCVSS

AADCVSS

CVBS_2

TV_GNDCVBS_0

AFSIF

CVBS1_GNDCVBS_1

CVBS2_GND

SY_0SY_0_GND

SY_1SY_1_GNDSC_1SC_1_GND

SC_0

CRQ_GND

AADCVSS

TV_GND

SC0

CVBS_0 CVBS0

CVBS1_GND

CVBS2

CVBS1

SY_0_GND

SC1

SC_1_GND

SY_1_GND

SC_0_GND

SY0

CVBS2_GND

SC_0

SY1

CVBS_1

CVBS_2

SY_0

SY_1

SC_1

SOY0 3SOY1 3

Y1_INB 15Y1_GNDB 8,15CR1_INB 15CR1_GNDB 8,15CB1_INB 15CB1_GNDB 8,15CBQ 8CRQ 8

SC_0_GND 15

YQ 8YQ_GND 8CBQ_GND 8CRQ_GND 8

SY1 3

SY0 3

SC1 3

SC0 3

CVBS0 3CVBS1 3CVBS2 3

MPX2 3

MPX1 3

SOY1 3

Y1+ 3

PB1- 3PR1+ 3

PB1+ 3Y1- 3

PR1- 3

PB0- 3PB0+ 3

Y0+ 3

PR0- 3

Y0- 3

PR0+ 3

SOY0 3

AADCVSS 3,4

SY_1_GND 15

SIF 14AF 14

TV_GND 14CVBS_0 14

CVBS_2 15

CVBS_1 15CVBS1_GND 15

CVBS2_GND 15SY_1 15

SY_0 15SY_0_GND 15

SC_1 15SC_1_GND 15

SC_0 15

Title




AUDIO / VIDEO IN CIRCUIT

KAWA Confidential

<Designer>

<Checker>

Title





KAWA Confidential

<Designer>

<Checker>

Title





KAWA Confidential

<Designer>

<Checker>

TO MT8202

FROM AV BOARD

FROM Tuner

THIS PAGE NEARLY IC

C110 47nFC110 47nF

C135330pFC135330pF

C148 100nFC148 100nF

C122 100nFC122 100nF

C128330pFC128330pF

R55 0R55 0

R218 68R218 68

C139 10nFC139 10nF

C481.8pFC481.8pF

C146 100nFC146 100nF

C113330pFC113330pF

R197 0R197 0

R219 100R219 100

C141 100nFC141 100nFR214 68R214 68

R213 100R213 100

R217 100R217 100

C14415pFC14415pF

C137 100nFC137 100nF

C136 4.7nFC136 4.7nF

R198 0R198 0

C120330pFC120330pF

C14715pFC14715pF

C114330pFC114330pF

C12315pFC12315pF

C112 4.7nFC112 4.7nF

C140 100nFC140 100nF

C13015pFC13015pF

C14315pFC14315pF

R211 68R211 68R201 0R201 0

C115 100nFC115 100nF

C14215pFC14215pF

C117 47nFC117 47nF

R199 68R199 68

C13815pFC13815pF

C132 47nFC132 47nF

C121330pFC121330pF

C111 47nFC111 47nF

R205 0R205 0

R216 39KR216 39K

C11615pFC11615pF

R424 0R424 0

R215 39KR215 39K

R200 0R200 0

R209 0R209 0

R56 0R56 0

C118 47nFC118 47nF

C119 100nFC119 100nF

C145 100nFC145 100nF

C189330pFC189330pF

R212 8.2KR212 8.2K

C133 100nFC133 100nF

C129 100nFC129 100nFR207 68R207 68

C126 100nFC126 100nF

C125 47nFC125 47nF

R203 68R203 68

R202 100R202 100

C188 47nFC188 47nFR206 100R206 100

+CE70 47uF/16V+CE70 47uF/16V

R210 100R210 100

16／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

VFE_GND

RED

RED_GND

RXDTXD

GREEN+GREEN-BLUE+BLUE-VGASOG

RED-

VGAHSYNC#VGAVSYNC#

VGASDA_IN

RED_GND

VGASCL_IN

GRN_GND

BLUE

GREEN

RED

VSYNC#

HSYNC#BLU_GND

VGASCL

VGA_PLUGPWR

TXD

VGA_PLUGPWR

VGASDA

VGASDA

RXD

VGAVSYNC#

VFE_GND

VGAHSYNC#

VSYNC#

GRN_GND

BLU_GND

RED+

RED-

GREEN-

BLUE+

BLUE-

GREEN+

VGASOG

GREEN

BLUE

VGAR_INVGAL_IN

VGAR_IN

VGAL_IN

VGASCL

RSRXD

RSRXD

RXD

RSTXD

RSTXD

TXD

TXD

RXD

RED

RED_GND

RED+

GREEN

GRN_GND

BLU_GND

BLUE

VGASDA_IN

VGASCL_IN

HSYNC#

VGAR_IN VGAL_IN

VCC

VGA_PLUGPWR

VGA_PLUGPWR

VGA_PLUGPWR

SB33B

5VSB

5VSB

VCC

VCC

VCC

VGA_PLUGPWR

VGA_PLUGPWR

VCC

VCC

VFE_GND 2,3,4,8

RXD 3,7TXD 3,7

RED- 3

BLUE+ 3

GREEN+ 3

BLUE- 3

RED+ 3

VGASOG 3

GREEN- 3

VGAHSYNC# 3VGAVSYNC# 3

VGAR_IN 9VGAL_IN 9

Title


Date: SheetChecked:

AKAI_MT8202_27US_LVDS_V0.0 1C


VGA IN & PC AUDIO IN

KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:




KAWA Confidential

<Designer>

<Checker>

Title


Date: SheetChecked:




KAWA Confidential

<Designer>

<Checker>

L : WP DISABLEH : WP ENABLE

NEARLY VGA CONVGA INNEARLY 8202

VGA/DVI AUDIO INPUT

change

change 2/16

R140 100R140 100

R737 0R737 0

1 3

2

D75DIODE SMD BAV99

D75DIODE SMD BAV99

1 3

2

D72DIODE SMD BAV99

D72DIODE SMD BAV99

C172220pFC172220pF

L29 2.2uHL29 2.2uH

1 3

2

D76

DIODE SMD BAV99

D76

DIODE SMD BAV99

C6410.1uFC6410.1uF

R15947KR15947K

C642 0.1uFC642 0.1uF

1 3

2

D69DIODE SMD BAV99D69DIODE SMD BAV99

1 3

2

D71DIODE SMD BAV99

D71DIODE SMD BAV99

C639 0.1uFC639 0.1uF

C638 0.1uFC638 0.1uF

R138 68R138 68

R738 0R738 0

C87 10nFC87 10nF

C885pFC885pF

R154

2K

R154

2K

R333 510R333 510

R132 68R132 68

C168NCC168NC

C89 10nFC89 10nF

C167NCC167NC

C90 4.7nFC90 4.7nF

C1005pFC1005pF

R134 100R134 100

R266 1.5KR266 1.5K

R730NCR730NC

10K/NC10K/NC

FB160FB160

C171220pFC171220pF

R136 0R136 0

R150

2K

R150

2K

R1IN13R2IN8T1IN11T2IN10

C+1C1-3C2+4C2-5V+2V-6

R1OUT 12R2OUT 9T1OUT 14T2OUT 7

VCC 16

GND 15

U54

MAX3232

U54

MAX3232

R16 0R16 0

R73275R73275

R15847KR15847K

R735

75

R735

75

R267 1.5KR267 1.5K

C94 10nFC94 10nF

C63620pFC63620pF

R12 0/NCR12 0/NC

C975pFC975pF

R7430R7430

C98 10nFC98 10nF

C1020.1uFC1020.1uF

1

3

2

R

LP2

RCA1X2 AV2-8.4-13P

R

LP2

RCA1X2 AV2-8.4-13P

R148 100R148 100

R416 100R416 100


U53

EEPROM 24C02

U53

EEPROM 24C02R73610KR73610K

FB170FB170

R6 0R6 0

FB180FB180

1617

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

P9D-SUB15 FEMALEDSUB15/DIP/F

P9D-SUB15 FEMALEDSUB15/DIP/F

D631N4148/NCD631N4148/NCD21

1N4148D211N4148

C93 10nFC93 10nF

C91 10nFC91 10nF

CB2350.1uF

CB2350.1uF

R5 0/NCR5 0/NC

R146 68R146 68

R435 0R435 0

C925pFC925pF

13

2


R436 0R436 0

L30 2.2uHL30 2.2uH

R437 0R437 0

1 3

2

D77DIODE SMD BAV99

D77DIODE SMD BAV99

R72975R72975

C63720pFC63720pF

R74110KR74110K

13

2


R332 510R332 510

R73910KR73910K

1 3

2

D74

DIODE SMD BAV99

D74

DIODE SMD BAV99

R417 100R417 100

C640 0.1uFC640 0.1uF

17／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

Gate2

AP[0..7]AN[0..6]LVDS_GND

LVDS_GND

LVDS_GND

LVDS_GND

GPIO2

CLK1+CLK1-

AN0AP0AN1AP1

AP2AN2

CLK1-CLK1+AN3

AP5

AP3

Gate1

AP4AN4

AN5

GPIO2

AP6CPUGO

AP7SEL_AP7_IRQ

PDPGO

FDAT

ADD1AN6

GPIO0

DISPEN_PDWN_READY

SCL_P

SDA_P

SB33B

FCLK

SCL_PSDA_P

SCL_8202SDA_8202

SDA_8202

GPIO0

FCMD

ADD2

FCLK

ADD1

CCIR_VCLK

CCIR_V4

CCIR_V4CCIR_VCLK

LVDSVDD

SCL_8202

12V

RELAY_ONVS_ON

FDAT

ADD2

FCMD

RELAY_ON

VS_ON

LVDSVDD

VCC

VCC12V

SB33B

5VSB

5VSB

5VSB SB33B

SB33B

SB33B

SB33B

SB33B

5VSB

5VSB

SB33B

12V

LVDS_GND 2,3,4

AP[0..7] 3AN[0..6] 3

CLK1+ 3CLK1- 3

GPIO2 1,3

FCLK 3FCMD 3FDAT 3SCL_8202 3,6,9SDA_8202 3,6,9

GPIO0 3

CCIR_VCLK 3CCIR_V4 3

12V 1,13

RELAY_ON 1VS_ON 1

LVDSGND 2,3,4

Title




LVDS OUT

KAWA Confidential

<Designer>

<Checker>

Title




LVDS OUT

KAWA Confidential

<Designer>

<Checker>

Title




LVDS OUT

KAWA Confidential

<Designer>

<Checker>

LO = > LVDS POWER OFF

HI = > LVDS POWER ON

LVDS OUT(Include PDP and 32' LCD LVDS interface)

USE WHEN LG V6

USE WHEN LG V6FHP USE

CPUGO /PDPGO :INPUT TO PDPIRQ /READY :PDP INPUT TO MT8202


R1020/NCR1020/NC

R99

10K/NC

R99

10K/NC

R934.7k/NCR934.7k/NC

+CE95220uF/16v/NC+CE95220uF/16v/NC

R1810K/NCR1810K/NC

123456789

101112131415161718192021222324252627282930

J10

FI-SE30P-HFLVDS/30P/P1.25/S

J10

FI-SE30P-HFLVDS/30P/P1.25/S

R27 0/NCR27 0/NC

R108 0R108 0

L56 FB/NCL56 FB/NC

R2874.7k/NC

R2874.7k/NC

R112

10K

R112

10K

R334.7kR334.7k

R1000/NCR1000/NC

R92 100R92 100

R944.7kR944.7k

R91 100R91 100

R1710K/NCR1710K/NC

1

32



S1 1G1 2S2 3G2 4D25 D26 D17 D18

U35

IRF7316SOIC8/SMD

U35

IRF7316SOIC8/SMD

R30 0/NCR30 0/NC

R1064.7kR1064.7k

R109 0R109 0

R248 1kR248 1k

R1910K/NCR1910K/NC

R28 0/NCR28 0/NC

L69 FB/NCL69 FB/NC

R2244.7k/NC

R2244.7k/NC

R29 0/NCR29 0/NC

R1074.7kR1074.7k

+ CE96220uF/16v/NC

+ CE96220uF/16v/NC

R42522k/NC

R42522k/NC

+ CE94330uF/25vC330UF25V/D8H14

+ CE94330uF/25vC330UF25V/D8H14

L68 FB/NCL68 FB/NC

R296

1k/NC

R296

1k/NC

R26 0/NCR26 0/NC

+ CE107220uF/16v/NC

+ CE107220uF/16v/NC

R2510KR2510K

R2601kR2601k

1

32

Q132N3904Q132N3904

R28810k/NC

R28810k/NC

F1

4A/16V/NC

F1

4A/16V/NC

R29422k/NC

R29422k/NC

13

2Q12

2N3904/NCQ12

2N3904/NC

R31 0/NCR31 0/NC

R7 0R7 0

R5422K/NCR5422K/NC

R1040 R1040

R2571k/NCR2571k/NC

R98

10K/NC

R98

10K/NC

R2410KR2410K

R5322K/NC

R5322K/NC

R60

0/NC

R60

0/NC


R110

10K

R110

10K

R250

1k/NC

R250

1k/NC

1

32Q39

2N3904SOT23/SMD

Q39

2N3904SOT23/SMD

L57 FB/NCL57 FB/NC

R2310KR2310K

R105 0R105 0

R65610KR65610K

R90 0R90 0

R3210kR3210k

18／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

PWM1

BL_ON/OFF

Dimming

8202UP3_0

CH+CH-

GPIO13VOL-MENUTV/AV

POW

PWM0

LED_GRE

IRR

PWM0

IR

PWM1

8202UP3_0

GPIO19

LED_REDVCLK

VCLK

VOL+GPIO10

GPIO12

GPIO14F_A21

GPIO19

F_A21

IR

CH-

VOL-

8202UP3_0

TV/AV

POW

IRRLED_REDLED_GRE

MENU

VOL+

CH+

12V

12V

GPIO14

CCIR_V2 CH-

GPIO10

GPIO12

GPIO13

GPIO14

CCIR_V2

SB33B

SB33B

5VSB

VCC

VCC

SB33B

SB33B

VCC

5VSB

12V

SB33B

IR 3,15

8202UP3_0 3

PWM0 3

PWM1 3

GPIO19 1,3

VCLK 3

F_A21 3

12V 1,12

GPIO14 1,3

GPIO10 3

GPIO12 3

GPIO13 3

GPIO14 1,3

CCIR_V2 3

Title


Date: SheetChecked:AKAI_MT8202_27US_LVDS_V0.0 1B


BACK LIGHT / KEYPAD

KAWA Confidential

<Designer>

<Checker>

Title




BACK LIGHT / KEYPAD

KAWA Confidential

<Designer>

<Checker>

Title




BACK LIGHT / KEYPAD

KAWA Confidential

<Designer>

<Checker>

BACK LIGHT CIRCUIT

KEYPAD

ADC KEY & GPIO KEY KEYPAD

C99 1000pFC99 1000pF

1

32

Q322N3904SOT23/SMD

Q322N3904SOT23/SMD

R389

10K

R389

10K

1

32

Q172N3904/NCQ172N3904/NC

C39 1000pFC39 1000pF


C52 1000pFC52 1000pFC124 1000pFC124 1000pF

R305

10k/NC

R305

10k/NC

C53 1000pFC53 1000pF

R384

10K

R384

10K

R11110KR11110K

L58 FBL58 FB

123456789

10111213

J21

13x1DIP13/P2.0

J21

13x1DIP13/P2.0

L59 FBL59 FB

R660 510R660 510

FB41

FB

FB41

FB

C35 1000pFC35 1000pF


R394 10KR394 10K

R385

10K

R385

10K

C36 1000pFC36 1000pF

D805.6V/NC D805.6V/NC

C37 1000pFC37 1000pF

L61 FBL61 FBL62 FB/NCL62 FB/NCL63 FBL63 FB

R386

10K

R386

10K

L60 FBL60 FB C38 1000pFC38 1000pF

R387

10K

R387

10K


R316

4.7k/NC

R316

4.7k/NC

R306100k/NC R306100k/NC

R658 4.7KR658 4.7K

R388

10K

R388

10K

R30410KR30410K

123

J15

CON3/NC

J15

CON3/NC

C101 1000pFC101 1000pF

R659 510R659 510

CB1851uF/NCCB1851uF/NC

R753 OR753 O

R308

4.7k/NC

R308

4.7k/NC

R65710KR0603/SMD

R65710KR0603/SMD

1

32

Q182N3904/NCQ182N3904/NC

R395 0R395 0

C106 1000pFC106 1000pF

19／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

SIF

SIF1_IN

VS_TUNER

VS_IF

TU_AV TU_CVBS

TV_GND

SCLSDA

SWV9

AF1_IN

VS_TUNER

SIF1_IN

TU_AV

VS_IF

CVBS_0

AF1_IN AF

AFSIF

TV_GND

ADC_IN4

AFC

AFC

SCL

SDA

ADC_IN4

9V

TU_VCC

TU_AVTV_GNDSIF1_INAF1_IN

AFCSDASCL

9V

SIFAF

CVBS_0TV_GNDSCLSDA

TU_VCC

TU_VCC

CVBS_0

SIF_9V

SWV99V

VCC

TU_VCC

TU_VCC

SIF_9V

SDA 1,9SCL 1,9

AF 10SIF 10

CVBS_0 10TV_GND 10

ADC_IN4 39V 1,7,9

Title


Date: SheetChecked:AKAI_MT8202_27US_LVDS_V0.0 1Custom


TUNER IN

KAWA Confidential

<Designer>

<Checker>

Title




TUNER IN

KAWA Confidential

<Designer>

<Checker>

Title




TUNER IN

KAWA Confidential

<Designer>

<Checker>

Title


Date: Sheet of

<Doc> <RevCode>

<Title>

Custom


Title


Date: Sheet of

<Doc> <RevCode>

<Title>

Custom


Title


Date: Sheet of

<Doc> <RevCode>

<Title>

Custom


ADD

IFADDRESS

C0TUNER

84FQ1236 : NTSCFQ1216 : PAL

TUNER SIF1NTSC 4.5MHz BPF

加散热片，尺寸与atsc Board 相同

560pF 1.2uH 560pF 1.2uH

2.2uH

R42171.5R42171.5

GN

D1

21G

ND

222

VS

_TU

NE

R3

SC

L4

AS

6S

DA

5

2nd

SIF

OU

T11

NC

9N

C10

CV

BS

12

GN

D3

23G

ND

424

AF

/MP

X14

VS

_IF

13

NC

1B

T2

AFC

7N

C8

TU1

FQ1236-MK3

TU1

FQ1236-MK3

C646

10nF

C646

10nF

R4221.8KR4221.8K

C649820pFC649820pF

+ CE630220uF/16V

+ CE630220uF/16V


R180 0/NCR180 0/NC


FB21

47

FB21

47

+ CE635220uF/10V

+ CE635220uF/10V

+ CE625470uF/16V

+ CE625470uF/16V

R419220R419220

R42010R42010

FB14 BEAD/SMD/1206 NCFB14 BEAD/SMD/1206 NC

12345678

J16

8x1DIP8/P2.0

J16

8x1DIP8/P2.0


C650820pFC650820pF

L881.5uHL881.5uH

R231 100R231 100

L89 470uH

L/IND/SMD/SLF7032

L89 470uH

L/IND/SMD/SLF7032

C67520pFC67520pF

+CE626 33uF/16V+CE626 33uF/16V

R4231KR4231K

R208 100R208 100

1

32

Q402N3904SOT23/SMD

Q402N3904SOT23/SMD

FB12 BEAD/SMD/1206 NCFB12 BEAD/SMD/1206 NC

C67620pFC67620pF

FB200FB200

+ CE61710uF/25vC10UF25V/D4H5

+ CE61710uF/25vC10UF25V/D4H5

+ CE618220uF/10V

+ CE618220uF/10V

L91 470uH

L/IND/SMD/SLF7032

L91 470uH

L/IND/SMD/SLF7032

AD

J/G

ND

1

OUT 2IN3

U59

7805TO220/DIP

U59

7805TO220/DIP

R317 18R317 18


123456789

1011

J9

DIP11/W/H/P2.0

J9

DIP11/W/H/P2.0

R58 0R58 0L93 2.2uH

L/IND/SMD/0805

L93 2.2uH

L/IND/SMD/0805

C645 10nFC645 10nF

FB19

BEAD/SMD/1210

3.3uH/22uHFB19

BEAD/SMD/1210

3.3uH/22uHC6471000pF/27pFC6471000pF/27pF

R31856R31856

C648 10nFC648 10nF

FB22 FBFB22 FB

C657330pFC657330pF

C651NCC651NC

R418 0R418 0

R179R/NCR179R/NC


L871.5uH

L871.5uH

C19120pFC19120pF

C656330pFC656330pF

R178R/NCR178R/NC

+ CE634+ CE634

+ CE620470uF/16V

+ CE620470uF/16V

+ CE62947uF/16V

+ CE62947uF/16V

20／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

CR2_INB

CVBS_2

Y_GND

PB_GND

YPBPR1_L

YPBPR1_R

PR_GND

Y1_IN

PR1_IN

PB1_IN

Y2_IN

PB2_IN

PR2_IN

YPBPR2_L

YPBPR2_R

GNDA

GNDA

YPBPR2_RYPBPR2_R

YPBPR2_L

SY_RSY_R

SY_L

SY_0SY0_IN SC_0SC0_IN

AV2_IN

AV1_LAV1_L

AV1_RAV1_R

CVBS_1

CVBS_2

AVL_OUTAVR_OUT

SY0_INSC0_IN

SC1_IN

AV2_INCVBS2_GND

SC_0_GND

AV1_IN

CR3_INB

Y2_INB Y3_INB

CB2_INB CB3_INB

CB3_GNDB

Y2_GNDB

CR3_GNDBCR2_GNDB

Y3_GNDB

CR3_INB

CR2_INB

Y2_INB

Y3_INB

CB2_INB

CB3_INBCB3_GNDB

Y2_GNDB

CR3_GNDB

CR2_GNDB

CB2_GNDB

Y3_GNDB

Y1_GNDB

CR1_INB

CB1_INB

CR1_GNDB

CVBS_OUT

CVBS_OUT AVL_OUT AVR_OUT

AV1_R

AV1_L

AV2_RAV2_L

AV1_R

AV1_L

SY_R

SY_L

AV2_R

SY_RSY_L

CVBS_1

Y1_INB

Y1_INBY1_GNDBCB1_INBCB1_GNDBCR1_INBCR1_GNDB

CVBS1_GND

CVBS2_GND

SC_0_GND

SY_0SY_0_GND

SY_1SY_1_GNDSC_1SC_1_GND

SC_0

GNDAGNDV

YPBPR1_LYPBPR1_R

YPBPR2_LYPBPR2_R

YPBPR3_RYPBPR3_L

YPBPR1_LYPBPR1_L

PR3_INPR3_GNDY3_INY3_GNDPB3_INPB3_GND

YPBPR3_R

YPBPR3_LDVD_IR

GNDA

IR

GPIO1

DVD_IR

IRGPIO1

SC_1_GND

SY_0_GND

SY_0_GND

SC_0_GND

CVBS1_GND

AV2_R

AV2_LAV2_L

AV2_L

SY1_INSY_1_GND

SY_1

SY_1_GND

SC_1SC1_IN

SC_1_GND

AVR_OUT

AVL_OUT

CVBS_OUT

SPOUTR

SPOUTR

CB2_GNDBCB1_GNDB

PR1_IN

PR_GND

PB_GND

PB1_IN

Y1_IN

Y_GND

Y2_IN

PB2_IN

PB_GND

Y_GND

PR2_IN

PR_GND

PR3_IN

PB3_IN

PB3_GND

Y3_IN

Y3_GND

YPBPR1_RYPBPR1_R

AV1_IN

CVBS1_GND

SY1_IN

CVBS2_GND

PR3_GND

CVBS_OUT

YPBPR3_R

YPBPR3_L

SB33B

VCC

VCC

VCC

VCC VCC

VCC

VCC VCC

VCC

VCC

VCC

VCC

VCC

VCC

VCC

VCC

VCC

CVBS_1 10

CVBS_2 10

AVR_OUT 9AVL_OUT 9CVBS_OUT 6,9AV1_R 8AV1_L 8AV2_R 8AV2_L 8

SY_L 8SY_R 8

Y3_INB 8

CR3_INB 8

CB3_INB 8Y3_GNDB 8

CB3_GNDB 8

CR3_GNDB 8

Y2_INB 8

CR2_INB 8

CB2_INB 8Y2_GNDB 8,10

CR2_GNDB 8,10

CB2_GNDB 8,10

Y1_INB 10Y1_GNDB 8,10CB1_INB 10CB1_GNDB 8,10CR1_INB 10CR1_GNDB 8,10

CVBS1_GND 10

CVBS2_GND 10

SC_0_GND 10

SY_1_GND 10SY_1 10

SY_0 10SY_0_GND 10

SC_1 10SC_1_GND 10

SC_0 10

YPBPR1_L 9YPBPR1_R 9YPBPR2_R 9YPBPR2_L 9YPBPR3_R 9YPBPR3_L 9

IR 3,13GPIO1 3

SPOUTR 16

Title




AV INKAWA Confidential <Designer>

<Checker>

Title





<Checker>

Title





<Checker>

RED/PR

BLU/PB

GEN/Y

YPBPR1 / 2 INPUT.

YPBPR 3 INPUT.

YPBPR VIDEO IN.

YPBPR AUDIO IN.

AV /YC VIDEO IN

AV VIDEO/AUDIO OUT.

AV /YC AUDIO IN


R2621.5KR2621.5K

1

234

56

K1

K2

RW W

RP5

RCA2X2 AV4-8.4-13P

RW W

RP5

RCA2X2 AV4-8.4-13P


R164100KR164100K

R153NCR153NC

C7147pFC7147pF

FB310FB310

12

J14


J14


C107220pFC107220pF

C95NCC95NC

C84220pFC84220pF

FB290FB290

C5747pFC5747pF

12345678910

R. ANGLE

J40

R. ANGLE

J40

C7047pFC7047pF


R165NCR165NC

FB230FB230

C162NCC162NC

L101 1.8uHL101 1.8uH

R13375R13375

C5847pFC5847pF

C6047pFC6047pF

C105220pFC105220pF


L96 1.8uHL96 1.8uH

1 3

2

D102DIODE SMD BAV99

D102DIODE SMD BAV99

FB270FB270

L103 0L103 0

R16947KR16947K

R167 0R167 0

R11456R11456

FB320FB320

R258

NC

R258

NC

C104220pFC104220pF

R2611.5KR2611.5K1

234

56

K1

K2

RW W

R

P12

RCA2X2 AV4-8.4-13P

RW W

R

P12

RCA2X2 AV4-8.4-13P

L109 0L109 0

R121 0R121 0

1 3

2

D96SOT23/SMDD96SOT23/SMD

L99 1.8uHL99 1.8uH

C161NCC161NC

L102 0L102 0

C177NCC177NC

R2401.5KR2401.5K


R15175R15175

R14347KR14347K

R256

NC

R256

NC

C6947pFC6947pF


FB340FB340

R12275R12275

R11875R11875

C131NCC131NC

1 3

2

D22DIODE SMD BAV99

D22DIODE SMD BAV99



C160NCC160NC

R17210kR17210k

1 3

2

D90DIODE SMD BAV99

D90DIODE SMD BAV99

R145100KR145100K

R245

1.5K

R245

1.5K


R168 0R168 0

R14975R14975

C159NCC159NC


FB280FB280

L97 1.8uHL97 1.8uH

1

234

56

K1

K2

RW W

R

P14

RCA2X2 AV4-8.4-13P

RW W

R

P14

RCA2X2 AV4-8.4-13P

1 3

2

D107

DIODE SMD BAV99

D107

DIODE SMD BAV99L107 0L107 0

R265NCR265NC

R113 18R113 18

R243

1.5K

R243

1.5K


1 3

2

D109DIODE SMD BAV99

D109DIODE SMD BAV99

1 3

2

D108DIODE SMD BAV99

D108DIODE SMD BAV99

R264NCR264NC

C82220pFC82220pF

R117 0R117 0

C109100pFC109100pF

1 3

2D103

DIODE SMD BAV99D103

DIODE SMD BAV99

1 3

2 D81

DIODE SMD BAV99

D81

DIODE SMD BAV99

1 3

2

D105DIODE SMD BAV99

D105DIODE SMD BAV99

FB260FB260

R129 0R129 0

1 3

2

D89D89


R162 0R162 0

R13575R13575

C6247pFC6247pF

R13775R13775

C166NCC166NC

C7447pFC7447pF

C83220pFC83220pF

12

34

5

67

G G

C Y

P4S-VIDEO + RCADASW-02

G G

C Y

P4S-VIDEO + RCADASW-02

R2591.5KR2591.5K

L105 0L105 0

FB330FB330

1 3

2

D106DIODE SMD BAV99

D106DIODE SMD BAV99

L98 1.8uHL98 1.8uH

R161 0R161 0


R13075R13075

R127 0R127 0

L106 0L106 0

R115 0R115 0

R14247KR14247K

FB300FB300

FB250FB250

R141100KR141100K

L108 0L108 0

C85NCC85NC

C6147pFC6147pF

R12875R12875

C165NCC165NC

R14775R14775

C103220pFC103220pF

R119 0R119 0

1

234

567

89

P13

RCA2X3 AV6-8.4-13P

P13

RCA2X3 AV6-8.4-13P


R131 0R131 0

R144NCR144NC

R163100KR163100K

R152NCR152NC


C5947pFC5947pF

R123 0R123 0

FB360FB360

R173

4.7K

R173

4.7K

C127 0.1uFC127 0.1uF

FB370FB370

1

23

Q422N3904SOT23/SMD

Q422N3904SOT23/SMD

R12075R12075


R11675R11675

C81220pFC81220pF

FB240FB240

C163NCC163NC

C96NCC96NC

C7247pFC7247pF

R12475R12475

1 3

2

D85

DIODE SMD BAV99

D85

DIODE SMD BAV99

R2631.5KR2631.5K

1 3

2

D86D86

1 3

2

D104

DIODE SMD BAV99

D104

DIODE SMD BAV99

FB350FB350

1 3

2

D82D82

L100 1.8uHL100 1.8uH

L104 0L104 0

C86NCC86NC

R17110kR17110k

123456789

J37

9x1DIP9/P2.0

J37

9x1DIP9/P2.0

C7347pFC7347pF

R125 18R125 18

R12656R12656

R244

1.5K

R244

1.5K

L110 0L110 0

R16647KR16647KC164

NCC164NC

R160 0R160 0



21／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

MU

OP1VREF

AUSP

MU

DACVA

OP1VREF

AOLRCK

AOMCLKAOBCLK

DACVA

AUSP

AUSPLL

AOLRCKAOBCLKAOSDATA2

AOMCLK

AOSDATA2

SPOUTR

SPOUTR

OPVREFOPOUTR

OPVREF

AUSPLOPOUTL

AUSPLAUSPR

OPOUTLOPOUTR

A_MUTE

AUSPR

OPA1V9

VCC

OPA1V9

OP1VREF

OP1VREF

OP1VREF

OPA1V9OP1VREF

OPA1V9OP1VREF

MU 9

AOBCLK 3,9AOMCLK 3,9

AOLRCK 3,9

AOSDATA2 3

SPOUTR 15AUSPR 9AUSPL 9

OPOUTL 17OPOUTR 17

A_MUTE 9,17

Title




SUB WOOFERKAWA Confidential <Designer>

<Checker>

Title





<Checker>

Title





<Checker>

GPIO14 : NO USEGPIO13 : HDMI Hot Plug Detect

GPIO19 : KEPAD CH-

ERO0/UP3_0 :KEYPAD POWER

GPIO DECRIPTION

GPIO5/TXD : 2nd UART FOR MT5351GPIO4 : EEPROM WRITE PROTECT

GPIO2 : LVDS POWER SW

UP3_5 : SW SDAUP3_4 : SW SCL

ERO1/UP3_1 : MAIN POWER SWITCH

GPIO7 : AUDIO BYPASS MUTE CONTROL

GPIO9 : AUDIO MUTE

GPIO6/RXD : 2nd UART FOR MT5351

GPIO3 : DTV POWER CONTROL

CCIR_V5 : AUDIO SWITCHCCIR_V6 : RESET DTV

GPIO12 : AV SWITCH

CCIR_V7 : YPBPR VIDEO SWITCH

GPIO11 : DVD POWER CONTROL

GPIO[15..18] : FOR DVD CONTROL

OUT_27Mhz/GPIO : HDMI CRYSTAL

GPIO/PWM0 : DIMMINGGPIO/PWM1 : BACKLIGHT ON/OFF

SDA1 : TO MT5351 I/F REQUEST

GPIO1 : NO USE

SCL1 : TO MT5351 I/F READY

CCIR_V[0-3] : KEYPAD

DE/GPIO : DVD IR

VCLK : KEPAD CH+

F_A21 : KEYPAD(LED RED)

ADCIN4:FOR TUNER AFC

ADCIN0 : KEYPAD

GPIO8 : SPEAKER SWITCH

GPIO10 : Indicates active video at HDMI port

GPIO0 : PDP USECCIR_V4 : PDP USECCIR_CLK : PDP USE

ADCIN3:PDP 5VD DETECT

R241

100

R241

100

R772

100

R772

100

+ CE9710uF/25V

+ CE9710uF/25V

+

CE75

22uF/10v

+

CE75

22uF/10v

R97 33R97 33

R194 33R194 33

+ CE9810uF/25v

+ CE9810uF/25v

C679220pFC679220pF

1

32 Q41

2SD2653KQ412SD2653K

FB38 FBFB38 FB

R177 100R177 100

SDATA1DEM#/SCLK2LRCK3MCLK4 AOUTR 5AGND 6VA 7AOUTL 8

U55

CS4334 2-CH AUDIO DACSOP8/SMD

U55

CS4334 2-CH AUDIO DACSOP8/SMD


R182 0/NCR182 0/NC

+

CE636

22uF/10v

+

CE636

22uF/10v

+ CE16910uF/25V

+ CE16910uF/25V

5

67

84

+

- U56B

NJM4558 OPA

+

- U56B

NJM4558 OPA

R181 0/NCR181 0/NC

C660220pFC660220pF

C677220pFC677220pF

R770 100R770 100

C6591uFC6591uF

R768 10KR768 10K

R767 20KR767 20K

+

CE170

10uF/10V

+

CE170

10uF/10V

R756 100R756 100


R765 100R765 100

R769 5.1KR769 5.1K

C6802200pFC6802200pF

+

CE171 10uF/10V

+

CE171 10uF/10V

R762 20KR762 20K

R763 10KR763 10K

R196 10KR196 10K

R764 5.1KR764 5.1K

R96 33R96 33

C6782200pFC6782200pF

5

67

84

+

-

U60B

NJM4558 OPA

+

-

U60B

NJM4558 OPA

C6612200pFC6612200pF

+

CE637

22uF/10v

+

CE637

22uF/10v

R174 10KR174 10K

R175 20KR175 20K

R176 5.1KR176 5.1K

+

CE638

22uF/10v+

CE638

22uF/10v

3

21

84

+

-

U60A

NJM4558 OPA

+

-

U60A

NJM4558 OPA

R195 33R195 33

3

21

84

+

-

U56A

NJM4558 OPA

+

-

U56A

NJM4558 OPA

22／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

GPIO9

VD

VD

AUSPLAUSPR

ROUT

EXTR EXTL

VD

GPIO8

GPIO8

LOUT

A_MUTE

ROUT EXTR

EXTLLOUT

AMP-GNDAMP-GNDAMP-GNDAMP-GNDAMP-GNDAMP-GND

AMP-GND

GPIO9

A_MUTE

OPOUTLOPOUTR

INTL

VCC

MUTE_RES

MUTE_RES

INTR

EXTR

EXTLAMP-GND

ROUT

INTR

LOUT

INTL

VCC

VD

OPOUTR

OPOUTL

SB33B

5VSB

VCC

GPIO9 3AUSPR 9,16AUSPL 9,16

GPIO8 3

A_MUTE 9

OPOUTL 16OPOUTR 16

Title




AUDIO Amplifier

KAWA Confidential

<Designer>

<Checker>

Title




AUDIO Amplifier

KAWA Confidential

<Designer>

<Checker>

Title




AUDIO Amplifier

KAWA Confidential

<Designer>

<Checker>

GPIO8: SPEAKER SWITCH(INTERNAL OR EXTERNAL

MUTE

DEL R759 R262 Q11 16/2

change 2/16

LCDTVR780 R187 R760 CB16 CB19 CE22NC 51K 2.2K NC NC NC

*

*

*

REMARKS:

**

*

* FOR LCDTV

+ CE1682.2uF/50v + CE1682.2uF/50v

R38 1KR38 1K

C6671uFC6671uF

123

J8

3x1DIP3/P2.54

J8

3x1DIP3/P2.54

1

3

4

2

L18

#C3H-A0028L-A

L18

#C3H-A0028L-A

R18533KR18533K

R2373.3KR2373.3K

L112BEAD/15UH/DIPL112BEAD/15UH/DIP

3

1

2

4

L115#C3B-A0619

L04A

L115#C3B-A0619

L04A

D19

1N41

48/N

C

D19

1N41

48/N

C

D64

1N4148

D64

1N4148

+CE16710uF/35v

+CE16710uF/35v

R183 10KR183 10K

R19047K

R19047K

C6700.1uF

C6700.1uF

C669 3pFC669 3pF

3

1

2

4

L20ACM3225-102-2P

L20ACM3225-102-2P

C6711uFC671

1uF

R24

2

1K/

NC

2W

R24

2

1K/

NC

2W

D62

D300DIODE SMD ZENER 33V

D62


D18

SMD

4.7

V

D18

SMD

4.7

V

D65SR260/NC

D65SR260/NC

+

CE1661000uF/35v

+

CE1661000uF/35v

R2380/NCR2380/NC

R7830

R7830

R758 0/NCR758 0/NC

L1170L1170

+ CE1612.2uF/50v + CE1612.2uF/50v

R1550R1550

3

1

2

4

L21ACM3225-102-2P

L2.5X3.5

L21ACM3225-102-2P

L2.5X3.5

R2971.5K/NC

R2971.5K/NC

R7820

R7820

R18847KR18847K

R781 0R781 0

C6680.047uFC6680.047uF

+

CE1

593.

3uF/

50v+

CE1

593.

3uF/

50v

R2390/NCR2390/NC

R780 0R780 0

C6740.1uFC6740.1uF

+

CE1621000uF/35v

+

CE1621000uF/35v

R17010KR17010K

CB140.1uFCB140.1uF

C6630.1uF

C6630.1uF

C6641uFC6641uF

R18747KR18747K

+

CE1651000uF/35v

+

CE1651000uF/35v

CB120.1uFCB120.1uF

R184 10KR184 10K

R7604.7kR7604.7k

C6650.1uFC6650.1uF

R18947KR18947K

R192 150KR192 150K

1

32

Q432N3904Q432N3904

R139 3.3KR139 3.3K

1

4

3

2

L19

#C3H-A0028L-A

L19

#C3H-A0028L-A

CB190.1uFCB190.1uF

R7840

R7840

1

32

Q152N3904Q152N3904


CB130.1uFCB130.1uF

C662 3pFC662 3pF

R759 4.7KR759 4.7K

R1560/NCR1560/NC

R1861KR1861K

L111BEAD/15UH/DIP

L111BEAD/15UH/DIP

CB160.1uFCB160.1uF

R191150KR191150K

12345

J12


J12


+CE163

10uF/35v

+CE163

10uF/35v

C6730.1uFC6730.1uF

R785

0

R785

0

+

CE16010uF/35v

+

CE16010uF/35v

D61


D61


R193 150KR193 150K

R1570R1570

+

CE222200uF/35v

+

CE222200uF/35v

OUT1 1

VD12

STBY3

IN15 PWM1 4

CBIAS6

ROSC7

GND8

AVDD9

PROT10

OUT2 15

VD214

MUTEL 13

PWM2 12

IN211

VS1 20

HB1 19

DVDD18

HB2 17

VS2 16

U57 R2S15102NPU57 R2S15102NP

R757 0/NCR757 0/NC

+

CE1572200uF/35v

+

CE1572200uF/35v

9 911 1113 1344

8866

11 16 16

U58

G6A-234

U58

G6A-234

12

J11


J11


1234 R

.A.

J39

4x1 W/HOUSING R.A.DIP4/WH/P2.54/R

R.A.

J39

4x1 W/HOUSING R.A.DIP4/WH/P2.54/R

R761 1kR761 1k

23／116

A

A

B

B

C

C

D

D

E

E

4 4

3 3

2 2

1 1

DV33+5V+12V

VOR[0..7]VOG[0..7]VOB[0..7]VOPCLKVOHSYNCVOVSYNCVODE

U2TXU2RX

U0RXU0TX

AO1MCLKAO1LRCKAO1BCK

REQUEST#READY#

ORESET#

ASPDIF

ASPDIF

AO1SDATA0

AUD_CTRL

AO1LRCKAO1SDATA0

AO1BCKAO1MCLK

AUD_CTRL

VOR1

VOG3

VOR3

VOB4

VOG2

VOG7

VOB5

U0RX

VOB7

VOB1

U2TX

VOR4

VOG1

READY#

VOG6

REQUEST#

GND

VOB0

VOB3

VOR7

VOG0

VOB6

ORESET#

U2RX

VOB2

U0TX

VOR0

VOR5

VOG4

VOR6

VOG5

VOR2

VODEVOPCLK

VOVSYNCVOHSYNC

AO1MCLK

AO1SDATA0

AO1BCKAO1LRCK

GND

ASPDIF

+5V

+12V

+5V

DV33

DV33

+5V

DV332,5,6,8

GND2,3,4,5,6,7,8

+5V2,6+12V2

VOR[0..7]5VOG[0..7]5VOB[0..7]5VOPCLK5VOHSYNC5,8VOVSYNC5,8VODE5

U2TX5,8U2RX5,8

U0RX5,8U0TX5,8

AO1MCLK5

AO1BCK5AO1LRCK5

AO1SDATA05

REQUEST#5READY#5

ORESET#4,5,8

ASPDIF5

ASPDIF5

AUD_CTRL5

Title

Size Document Number R ev

Date: Sheet o f

MT5351RA-V2 1Custom

1 8Monday, February 20, 2006

INDEX

MediaTek Confidential

TwinSon Chan

Rev DATEP#History

RA-V1 INITIAL VERSION 2005/06/15

DEVICETYPENAME

POWER +12VPOWER +5V

POWER +5VPOWER +3V3POWER +1V8POWER +3V3POWER +3V3POWER +2V5POWER +1V2

+12V+5V

+5V_tunerDV33_DMDV18DV33AV33DV25DV12

POWER SUPPLYPOWER SUPPLY

TUNER POWERMT5111 POWERMT5111 POWERMT5351 POWERMT5351 ANALOG POWERMT5351 DDR POWERMT5351 POWER

GLOBAL SIGNAL01. INDEX AND INTERFACE02. POWER03. TUNER04. MT5111 ASIC05. MT5351 ASIC06. MT5351 PERIPHERAL07. DDR MEMORY08. NOR FLASH / JTAG / UART

GND GROUND GROUND

MT5111 / MT5351 REFERENCE DESIGN - 4 LAYERSMT5351RA-V2

NS : NON-STUFF

DIGITAL VIDEO OUTPUT

UART (RS232)

DIGITAL AUDIO INTERFACE

SPDIF CIRCUIT

RA-V2 ADDED AUDIO SWITCH / REFINE POWER CIRCUIT 2005/07/14

POWER INPUT FROM MAIN BOARD

DIGITAL OUTPUT

+3.3V

RN3

33x4 RN0603/SMD

7 85 63 41 2

R2 75

CB20.1uFC0603/SMD

CB1420.1uFC0603/SMD

RN10

33x4 RN0603/SMD

7 85 63 41 2

RN8

33x4 RN0603/SMD

7 85 63 41 2

L2 FBBEAD/SMD/1206

RN6

33x4 RN0603/SMD

7 85 63 41 2

CB10.1uFC0603/SMD

D1SOT23/SMD

1 3

2

FB1

FBBEAD/SMD/0603

R3 75

R4

33R0603/SMD

R50 75

RN7

33x4 RN0603/SMD

7 85 63 41 2

RN9

33x4 RN0603/SMD

7 85 63 41 2

RN5

33x4 RN0603/SMD

7 85 63 41 2

J1


12345678

R49 75

RN4

33x4 RN0603/SMD

7 85 63 41 2

U1

NC/IDTQS3VH257TSSOP16/P0.65/SMD

IA02IB05IC011ID014

IA13IB16IC110ID113 GND 8

VCC 16

OE15 S1 YA 4YB 7YC 9YD 12

+ CE2220uF/16vC220UF16V/D6H11

+ CE1220uF/16vC220UF16V/D6H11

RN1

33x4 RN0603/SMD

7 85 63 41 2

P1S/PDIF OUTRCA/SPDIF/5P/DIP

G1 VCC2 IN3 K1

4K

25

66

G7

88

99

BO

TT

OM

HA1

HEADER 50 SMD0.5 BOTTOMH50S/P0.5

123456789

1011121314151617181920212223242526272829303132333435363738394041424344454647484950

L19 FB

L1 FBBEAD/SMD/1206

R14.7KR0603/SMD

24／116

A

A

B

B

C

C

D

D

E

E

4 4

3 3

2 2

1 1

GND

+5V

AV33

DV33

DV25DV12

+5V_TUNERDV33_DMDV18

+12V

DV25

AV33

+5V DV25

DV33 DV12

+5V DV33_DM

DV33_DMDV18

+12V

DV33

+5V DV33

+5V_TUNER+5V

+5V

+5V_TUNER

+5V_TUNER

GND1,3,4,5,6,7,8

+5V1,6

AV335,6

DV331,5,6,8

DV255,6,7DV125,6

+5V_TUNER3,4DV33_DM4DV184

+12V1

Title


Date: Sheet o f

MT5351RA-V2 1Custom


POWER


TwinSon Chan

GLOBAL SIGNAL

POWER SUPPLY +2V5 FOR MT5351 AND DDR

1.25 x (1+0/100) = 1.25V

POWER SUPPLY +1V2 FOR MT5351

1.25 x (1+100/100) = 2.5V

POWER SUPPLY +3V3 FOR MT5351 (ANALOG)

1.25 x (1+180/110) = 3.3V


1.25 x (1+120/270) = 1.8V


POWER SUPPLY +5V FOR TUNER

1.25 x (1+180/110) = 3.3V


9V

Compatible With U6

CB15010uFC0805/SMD

+ CE3220uF/16vC220UF16V/D6H11

CB50.1uFC0603/SMD

+ CE7220uF/16vC220UF16V/D6H11

R9270R0603/SMD

+ CE13220uF/16vC220UF16V/D6H11

+ CE9220uF/16vC220UF16V/D6H11

R7110 R0603/SMD

R10100R0603/SMD

+ CE30470uF/16v/NCC220UF16V/D6H11

+ CE10220uF/16vC220UF16V/D6H11

R5110 R0603/SMD

U5

AP1084 ADJ TO263SOT263/SMD

ADJ/

GN

D1

OUT 2IN3

L4

FBBEAD/SMD/0805

+ CE6220uF/16vC220UF16V/D6H11

U6

AZ1117/adjSOT223/SMD

ADJ/

GN

D1

OUT 2IN3

CB90.1uFC0603/SMD

U4


ADJ/

GN

D1

OUT 2IN3

U2


ADJ/

GN

D1

OUT 2IN3

+ CE16220uF/16vC220UF16V/D6H11

CB60.1uFC0603/SMD

CB1460.1uF/NCC0603/SMD

L33

FB

CPL-0302

U21

MP2105/NC

IN4

GN

D2

EN1 SW 3FB 5

L6

FBBEAD/SMD/0805

U3

AP1084/TO220-DIP/5VTO220/DIP

ADJ

1

IN3 OUT 2

VOUT 4

+ CE32220uF/16v

+ CE31470uF/16v/NCC220UF16V/D6H11

R140R0603/SMD

R11120R0603/SMD

+ CE5220uF/16vC220UF16V/D6H11

L17FB BEAD/SMD/0805

CB1570.1uF

CB15110uFC0805/SMD

L9

FBBEAD/SMD/0805

R6180 R0603/SMD

+ CE8220uF/16vC220UF16V/D6H11

CB100.1uFC0603/SMD

+ CE12220uF/16vC220UF16V/D6H11

L32

FBBEAD/SMD/1206

J7


1234

R112499kR0603/SMD

+ CE14220uF/16vC220UF16V/D6H11

CB150.1uFC0603/SMD

+ CE4220uF/16vC220UF16V/D6H11

R8180 R0603/SMD

R12100R0603/SMD

CB1470.1uF/NCC0603/SMD

CB160.1uFC0603/SMD

CB30.1uFC0603/SMD

CB120.1uFC0603/SMD

R113249kR0603/SMD

CB70.1uFC0603/SMD

L8

FBBEAD/SMD/0805

L18

FB

BEAD/SMD/0805

+ CE15220uF/16vC220UF16V/D6H11

CB40.1uFC0603/SMD

L7

FBBEAD/SMD/0805

L5

FBBEAD/SMD/0805

CB130.1uFC0603/SMD

R13100R0603/SMD

L3

FBBEAD/SMD/0805

CB80.1uFC0603/SMD

U7


ADJ/

GN

D1

OUT 2IN3

CB140.1uFC0603/SMD

25／116

A

A

B

B

C

C

D

D

E

E

4 4

3 3

2 2

1 1

GND

+5V_TUNER

RF_AGC

2nd_IF-

2nd_IF+

TUNER_SDAO

IF_AGC

RF_AGCIF_AGC

2nd_IF-2nd_IF+

TUNER_SCLO

TUNER_SCLOTUNER_SDAO

+5V_TUNER

+5V_TUNER

+5V_TUNER

+5V_TUNER

GND1,2,4,5,6,7,8

+5V_TUNER2,4

RF_AGC4IF_AGC4

2nd_IF-42nd_IF+4

TUNER_SCLO4TUNER_SDAO4

Title


Date: Sheet o f

MT5351RA-V2 1Custom


TUNER


TwinSon Chan

GLOBAL SIGNAL

TUNER INTERFACE

ROUTE SYMMETRICALLYIF SAW FILTER AND AMPLIFIER

R1510KR0603/SMD

R19 100 R0603/SMD

C61uFC0603/SMD

L10

FBBEAD/SMD/0805

CB180.1uFC0603/SMD

C71uFC0603/SMD

L12NSL/IND/SMD/0805

+ CE1810uF/16vC10UF16V/D5H11

R22510/1%R0603/SMD

R17 NS R0603/SMD

R21510/1%R0603/SMD

R18 100 R0603/SMD

R1610KR0603/SMD

U9

PORT SAW FILTER X6965D SIP5KSIP5K/DIP

IN+1IN-2

GND3

OUT+ 5OUT- 4

+ CE1710uF/16vC10UF16V/D5H11

U8

PORT TUNER TD1336/FGHP

GND TH1GND TH2

GND TH3GND TH4

Outdoor PS 1VS_splitter_+5V 2

OOB_OP 3NC 4

RF_AGC 5NC 6AS 7

SCL 8SDA 9

NC 10VS_Tuner_+5V 11

Broad_IF_OP 12IF_AGC 13

Narrow_IF_OP1 14Narrow_IF_OP2 15

C41nFC0603/SMD

C50.1uFC0603/SMD

R234.7KR0603/SMD

U10

upc3218TSSOP8/SMD

VCC_+5V1IN_12IN_23VAGC4 GND 5OUT_2 6OUT_1 7GND 8

CB170.1uFC0603/SMD

L11

FBBEAD/SMD/0805

R204.7KR0603/SMDC3

10nFC0603/SMD

C810nFC0603/SMD

26／116

A

A

B

B

C

C

D

D

E

E

4 4

3 3

2 2

1 1

DV18

GND

DV33_DM

RF_AGCIF_AGC

2nd_IF-2nd_IF+

TS1ERROR

TS1SYNCTS1VALID

TS1DATA[0..7]

OSCL_MSTOSDA_MST

TS1CLK

+5V_TUNER

TUNER_SDAO

TUNER_SCLO

TUNER_SDA1

TUNER_SCL1

ORESET#

TUNER_SCLOTUNER_SDAO

DV

DD

33

DV

DD

18

DVDD33

XTAL2

ORESET#

TS1DATA0

TS1D

ATA6

AVDD33

DV

DD

18

AV

DD

33

VCMEXT

DVDD33

IF_AGCIF_AGCIF_AGC

TS1SYNC

ADVDD33_1

REFBOT

DV

DD

18

AV

DD

33

TS1D

ATA7

DV

DD

33

DVDD18

TS1DATA2TS1DATA1

2nd_IF+

REFTOP

MT5

111_

IF_A

GC

DVDD33

TS1ERROR

OSDA_MST

AVDD33

AVDD33

TUN

ER

_SD

A

DVDD18

AVDD3

TS1D

ATA4

TS1VALID

AVDD33

TU

NE

R_S

CL

RF_AGCRF_AGCRF_AGC

AVDD33

DVDD18

MT5111_IF_AGC

XTAL1

DV

DD

18

DV

DD

33

AV

DD

5

TS1CLK

MT5

111_

RF_

AG

C

DV

DD

33

TS1DATA3

MT5111_RF_AGC

TS1D

ATA5

2nd_IF-

AD

VD

D33

_2

IF_AGCIF_AGCIF_AGC

OSCL_MST

TUNER_SDA1

TUNER_SCL

TUNER_SDA

TUNER_SCL1

DVDD33

DV18

DV33_DM

AVDD33DV33_DM AVDD33

DVDD18 DVDD18AVDD33 AVDD3

AVDD33 AVDD5

AVDD33 ADVDD33_1

AVDD33 ADVDD33_2

DVDD33

DVDD18

DVDD33

DV33_DM+5V_TUNER

DV182

GND1,2,3,5,6,7,8

DV33_DM2

RF_AGC3IF_AGC3

2nd_IF-32nd_IF+3

TS1ERROR5

TS1SYNC5TS1VALID5

TS1DATA[0..7]5

OSDA_MST6OSCL_MST6

TS1CLK5

+5V_TUNER2,3

ORESET#1,5,8

TUNER_SCLO3TUNER_SDAO3

Title


Date: Sheet o f

MT5351RA-V2 1C


MT5111 ASIC


TwinSon Chan

GLOBAL SIGNAL

Digital 3.3V Bypass Caps

Analog 3.3V Bypass Caps

Digital 1.8V Bypass Caps

TUNER INTERFACE

TS INPUT

Close to MT5111

SIF LEVEL SHIFTER

R25

4.7

KR

0603

/SM

D

C1047nFC0603/SMD

CB260.1uFC0603/SMD

L13NS/220nHL/IND/SMD/0805

CB350.1uFC0603/SMD

CB250.1uFC0603/SMD

C15 0.1uFC0603/SMD

R261KR0603/SMD

FB5

FBBEAD/SMD/0603

L15FB

BEAD/SMD/0805

CB410.1uFC0603/SMD

C180.1uFC0603/SMD

C1610uF/10vC0805/SMDC17 0.1uF

C0603/SMD

+ CE2010uF/16vC10UF16V/D5H11

CB340.1uFC0603/SMD

C2018pFC0603/SMD

CB380.1uFC0603/SMD

CB360.1uFC0603/SMD

R314.7KR0603/SMD

C131uFC0603/SMD

QF2

2N7002N-MOSFET2

13

RN12

33x4RN0603/SMD

1 23 45 67 8

CB320.1uFC0603/SMD

CB240.1uFC0603/SMD

C111uFC0603/SMD

CB230.1uFC0603/SMD

RN1333x4RN0603/SMD

12

34

56

78

R324.7KR0603/SMD

CB300.1uFC0603/SMD

R3410R0603/SMD

FB6

FBBEAD/SMD/0603

CB220.1uFC0603/SMD

QF1

2N7002N-MOSFET2

13

CB310.1uFC0603/SMD

CB830.1uFC0603/SMD

FB3

FBBEAD/SMD/0603

+ CE2110uF/16vC10UF16V/D5H11

C947nFC0603/SMD

CB390.1uFC0603/SMD

CB270.1uFC0603/SMD

CB190.1uFC0603/SMD

R2910KR0603/SMD

R27

4.7

KR

0603

/SM

D

C12NS/47pFC0603/SMD

FB2

FBBEAD/SMD/0603

C14 0.1uFC0603/SMD

CB210.1uFC0603/SMD

CB280.1uFC0603/SMD

L14FB

BEAD/SMD/0805CB200.1uFC0603/SMD

RN11

33x4RN0603/SMD

1 23 45 67 8

R3010KR0603/SMD

R3310

R0603/SMD

MT

51

11

AE

10

0-

LQ

FP

U11MT5111AE

NC

1N

C2

AV

DD

3N

C4

NC

5N

C6

AV

SS

7N

C8

NC

9A

VD

D10

AV

SS

11A

VD

D12

NC

13N

C14

AD

VD

D33

15D

GN

D16

DV

DD

3317

DV

DD

1818

DG

ND

19N

C20

NC

21TS

_DA

TA7

22TS

_DA

TA6

23TS

_DA

TA5

24TS

_DA

TA4

25

DVDD33 26DGND 27TS_DATA3 28TS_DATA2 29DVDD18 30DGND 31TS_DATA1 32TS_DATA0 33TS_SYNC 34DVDD33 35DGND 36TS_CLK 37TS_VAL 38TS_ERR 39DVDD18 40DGND 41DVDD33 42DGND33 43HOST_DATA 44DVDD18 45DGND 46HOST_CLK 47RESET_ 48NC 49NC 50

DV

DD

1875

DG

ND

74R

F_A

GC

73IF

_AG

C72

DG

ND

71D

VD

D33

70TU

NE

R_C

LK69

TUN

ER

_DA

TA68

SA

167

SA

066

DG

ND

65D

VD

D18

64D

GN

D63

AN

TIF

62D

GN

D61

DV

DD

3360

NC

59N

C58

NC

57D

GN

D56

DV

DD

1855

NC

54N

C53

DV

DD

3352

DG

ND

51

AVSS100 AVDD99 AVSS98 XTAL197 XTAL296 AVSS95 AVSS94 AVDD93 AVDD92 AVDD91 AVDD1890 AVSS89 REFTOP88 VCMEXT87 REFBOT86 AVSS85 NC84 AVDD83 IN+82 IN-81 AVDD80 AVSS79 NC78 NC77 ADVDD3376

R241KR0603/SMD

L16FB

BEAD/SMD/0805CB370.1uFC0603/SMD

CB330.1uFC0603/SMD

Y125MHz

CRYS/DIP/SMD

FB4

FBBEAD/SMD/0603

C1918pFC0603/SMD

CB290.1uFC0603/SMD

R281MR0603/SMD

CB400.1uFC0603/SMD

+ CE1910uF/16vC10UF16V/D5H11

27／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

JTRST#JTDIJTMSJTCKJRTCKJTDO

READY#

DV12

POWE#

POCE0#POOE0#

RDQ[0..31]RDQS[0..3]RDQM[0..3]RA[0..13]

RCLK0#RCS#RRAS#RCAS#RWE#RCKE

RBA[0..1]

RCLK1RCLK1#

RCLK0

PDA[0..22]PDD[0..7]

U2TXU2RX

U1RXU1TX

U0RXU0TX

AO1MCLKAO1LRCKAO1BCK

ASPDIF

OSCL0OSDA0

DV25DV33

RVREF

OXTALIOXTALO

DVDDKP

FS

CAPVPLL

RV

RE

F

CAPVGND

AVDDRKP

AVDD_APLL0AVDD_APLL1

AVDDBGKP

AVDD_DMPLL1AVDD_VPLL

AVDDYKP

AVDD_DMPLL0

APLLCAP1APLLCAP0

ATP1ATP2

OPWM0

REQUEST#ORESET#

VCXO0

TS1CLKTS1ERROR

TS1SYNCTS1VALID

TS1DATA[0..7]

VOR[0..7]VOG[0..7]VOB[0..7]VOPCLKVOHSYNCVOVSYNCVODE

AO1SDATA0

U2CTS

OIRI

AUD_CTRL

AV

DD

_VP

LL

RA

7

RA

2

RD

QM

0

JTDO

VOR7

GR TS1D

ATA

0

PD

A1

AV

DD

YK

P

RC

LK1

RC

KE

RR

AS

#R

CA

S#

RD

Q13

VOB4

TS1E

RR

OR

PD

A18

PD

A14

PD

A2

RD

QM

3

RD

Q19

RA

13

RD

Q1

DONE

OIRI

VOPCLK

VOG7

VOB5

U2CTS

VCXO0

OP

WM

0

TS1D

ATA

3

PD

A22

OXT

ALO

RD

Q30

RD

Q20

RB

A0

RD

Q10

RC

LK0

VOR0

VOG1

AO1BCK

U1RX

U0TX

OSCL0

TS1D

ATA

7

TS1D

ATA

4

PD

A9

AV

DD

_AP

LL1

RA

6

VOR6

PD

A0

AV

DD

BG

KP

RD

QM

2

RA

11

RD

Q6

JRTCK

VOB3

ASPDIF

OSDA0

PD

D3

TS1D

ATA

1

PD

A17

AV

DD

_AP

LL0

RD

Q18

RA

12

RW

E#

RD

Q0

VOG6

PD

D0

TS1D

ATA

2

PD

A21

RD

Q29

RD

Q25

RA

5

RD

Q9

VODE

VOG0

POCE0#

PD

D1

AP

LLC

AP

1

TS1D

ATA

6

PD

A8

PD

A6

PD

A5

RD

Q26

RD

Q23

RD

Q16

RA

0

RC

S#

VOR5

AO1LRCK

U1TX

RA

9

RA

4

RA

1

RD

QS

1

RD

QS

0

RD

Q5

VOR1

VOB2

AO1SDATA0

PD

D2

AP

LLC

AP

0

FS PD

A16 GND

RD

Q17

RD

Q15

JTCKJTMSJTDI

VOR2

VOG5

AO1MCLK

U2RX

VCXO1

PD

A20

CA

PV

GN

D

RD

Q28

RD

Q24

RD

Q8

RD

Q3

RC

LK0#

JTRST#

VOVSYNC

VOB7

TS1D

ATA

5

PD

A7

PD

A4

DV

DD

KP

RA

10

RD

Q12

VOR4

VOG3

PD

D6

TS1V

ALI

D

PD

A13

AV

DD

_DM

PLL

1

OXT

ALI

ATP1

RC

LK1#

RA

8

RA

3

RD

QM

1

RD

Q7

RD

Q4

ORESET#

VOB1

POOE0#

POWE#

PD

D7

PD

D4

TS1C

LK

AV

DD

RK

P

AV

DD

_DM

PLL

0

RD

Q14

READY#REQUEST#

VOG4

CA

PV

PLL

B PD

A19

PD

A15

RD

Q27

RD

QS

3

RD

Q2

VOHSYNC

VOB6

AUD_CTRL

U2TX

U0RX

TS1S

YN

C

PD

A11

PD

A3

ATP2

RD

Q31

RD

QS

2

RD

Q21

RB

A1

RD

Q11

VOR3

VOG2

VOB0

TUNER_SW

PD

D5

PD

A12

PD

A10

RD

Q22

RBG

DV33

DV25

DV12

DV33

DV12

JTRST#8JTDI8JTMS8JTCK8JRTCK8JTDO8

GND1,2,3,4,6,7,8

DV122,6

POCE0#8POOE0#8POWE#8

RDQ[0..31]7RDQS[0..3]7RDQM[0..3]7RA[0..13]7

RCLK07RCLK0#7RCS#7RRAS#7RCAS#7RWE#7RCKE7

RBA[0..1]7

RCLK17RCLK1#7

PDA[0..22]8PDD[0..7]8

U2TX1,8U2RX1,8

U1RX8U1TX8

U0RX1,8U0TX1,8

READY#1

AO1MCLK1

AO1BCK1AO1LRCK1

AO1SDATA01

ASPDIF1

OPWM06

OSCL06OSDA06

DV252,6,7DV331,2,6,8

RVREF6

OXTALI6OXTALO6

DVDDKP6

FS6

CAPVPLL6CAPVGND6

AVDDRKP2,6

AVDD_APLL02,6AVDD_APLL12,6

AVDDBGKP2,6

AVDD_DMPLL12,6AVDD_VPLL2,6

AVDDYKP2,6

AVDD_DMPLL02,6

APLLCAP16APLLCAP06

ATP16ATP26

REQUEST#1ORESET#1,4,8

VCXO06

TS1CLK4TS1ERROR4

TS1SYNC4TS1VALID4

TS1DATA[0..7]4

VOR[0..7]1VOG[0..7]1VOB[0..7]1VOPCLK1VOHSYNC1,8VOVSYNC1,8VODE1

U2CTS6

OIRI6

AUD_CTRL1

R8B8G8

Title


Date: Sheet o f

MT5351RA-V2 1Custom


MT5351 ASIC


TwinSon Chan

JTAG PORT

GLOBAL SIGNAL

DDR MEMORY

FLASH INTERFACE

UART (RS232)

AUDIO INTERFACE

ANALOG PART

TEST PURPOSE

TS INPUT

DIGITAL VIDEO OUTPUT

Add by Ada

R36330R0603/SMD

TP6TUNER_SWTP/SMD/D1.0

C1180.1uFC0603/SMD

TP5IRTP/SMD/D1.0

TP2IOB_Y5TP/SMD/D1.0

MT5351

U14

MT5351BGA471/SMD

PD

CD

2#A

14P

DIO

IS16

#A

15

PD

A0

B24

PD

A1

A24

PD

A2

D23

PD

A3

C23

PD

A4

B23

PD

A5

A23

PD

A6

D22

PD

A7

C22

PD

A8

B22

PD

A9

A22

PD

A10

D21

PD

A11

C21

PD

A12

B21

PD

A13

A21

PD

A14

D20

PD

A15

C20

PD

A16

B20

PD

A17

A20

PD

A18

D19

PD

A19

C19

PD

A20

B19

PD

A21

A19

PD

A22

D18

PD

A23

C18

PD

A24

B18

PD

A25

A18

PD

CE

1#D

17P

DC

E2#

C17

PD

OE

#B

17P

DIO

RD

#A

17PD

IOW

R#

D16

PD

WE

#C

16P

DIR

EQ

#B

16P

DR

ES

ET

A16

PD

WA

IT#

D15

PD

INP

AC

K#

C15

PD

RE

G#

B15

PD

EN

PO

DB

14

T0C

LKC

14T0

SY

NC

D14

T0V

ALI

DA

13T0

DA

TA0

B13

T0D

ATA

1C

13T0

DA

TA2

D13

T0D

ATA

3A

12T0

DA

TA4

B12

T0D

ATA

5C

12T0

DA

TA6

D12

T0D

ATA

7A

11T1

CLK

B11

T1S

YN

CC

11T1

VA

LID

D11

T1D

ATA

0A

10T1

DA

TA1

B10

T1D

ATA

2C

10T1

DA

TA3

D10

T1D

ATA

4A

9T1

DA

TA5

B9

T1D

ATA

6C

9T1

DA

TA7

D9

OP

WM

0D

8

OR

TCV

DD

D7

OR

TCO

B8

OR

TCI

A8

OP

WM

1C

8

OR

TCV

SS

C7

FSA

6

CIN

_Y0

A7

IOR

_Y6

B3

IOB

_Y5

A3

IOG

_Y4

C4

IOX

_Y3

B4

IOY

_Y2

A4

IOC

_Y1

C5

CA

PV

PLL

D5

AP

LLC

AP

1D

4A

PLL

CA

P0

E4

AG

ND

L11

AG

ND

L12

AG

ND

L13

AG

ND

M11

AG

ND

M12

AG

ND

M13

AG

ND

N11

AG

ND

N12

AG

ND

N13

PD

D0

A27

PD

D1

B26

PD

D2

A26

PD

D3

C25

PD

D4

B25

PD

D5

A25

PD

D6

D24

PD

D7

C24

PD

CD

1#A

28

CV

DD

M5

CV

DD

N5

CV

DD

U5

CV

DD

E10

CV

DD

E19

CV

DD

M24

CV

DD

N24

CV

DD

U24

CV

DD

AE

14C

VD

DA

E15

IOVDDP5IOVDDR1IOVDDR2IOVDDR3IOVDDR4IOVDDR5IOVDDT5IOVDDE11IOVDDE12IOVDDE13IOVDDE14IOVDDE15IOVDDE16IOVDDE17IOVDDE18IOVDDP24IOVDDR24IOVDDR25IOVDDR26IOVDDR27IOVDDR28IOVDDT24

POWE# B27POCE0# B28POOE0# C26POCE1# C27POOE1# C28POCE2# D25POOE2# D26

OSDA0E1OSCL0F4OSDA1E3OSCL1E2

U0TXF3U0RXF2U1TXF1U1RXG4U2TXG3U2RXG2U2CTSG1U2RTSH4

AO1SDATA3H3AO1SDATA2H2AO1SDATA1H1AO1SDATA0J4AO1LRCKJ3AO1BCKJ2AO1MCLKJ1AO2SDATA0K1AO2LRCKK2AO2BCKK3AO2MCLKK4ASPDIFL3ASPDIF2L4

VOB0L2VOB1L1VOB2M4VOB3M3VOB4M2VOB5M1VOB6N4VOB7N3VOG0N2VOG1N1VOG2P4VOG3P3VOG4P2VOG5P1VOG6T1VOG7T2VOR0T3VOR1T4VOR2U1VOR3U2VOR4U3VOR5U4VOR6V1VOR7V2VOPCLKV3VOHSYNCV4VOVSYNCW1VODEW2

JTRST#W3JTDIW4JTMSY1JTCKY2JRTCKY3JTDOY4

GNDL14GNDL15GNDL16GNDL17GNDL18GNDM14GNDM15GNDM16GNDM17GNDM18GNDN14GNDN15GNDN16GNDN17GNDN18GNDP11GNDP12GNDP13GNDP14GNDP15GNDP16GNDP17GNDP18GNDR11GNDR12GNDR13GNDR14GNDR15GNDR16GNDR17GNDR18

PARB# D27PARE# D28PACE# E25PACLE E26PAALE E27

PAWE# E28

ELREQ F25ECLK F26

ECNTL0 F27ECNTL1 F28EDATA0 G25EDATA1 G26EDATA2 G27EDATA3 G28EDATA4 H25EDATA5 H26EDATA6 H27EDATA7 H28

ELPS J25ELINKON J26

ORESET# J27OIRI J28

OIRO K25

ICS1# K26ICS0# K27

IDA2 K28IDA0 L25IDA1 L26

IINTRQ L27IDMACK# L28

IIORDY M25IDIOR# M26IDIOW# M27

IDMARQ M28IDD15 N25

IDD0 N26IDD14 N27

IDD1 N28IDD13 P25

IDD2 P26IDD12 P27

IDD3 P28IDD11 T28

IDD4 T27IDD10 T26

IDD5 T25IDD9 U28IDD6 U27IDD8 U26IDD7 U25

IRESET# V28

DDETECT V27DCLK V26

DCMD V25DDATA0 W28DDATA1 W27DDATA2 W26DDATA3 W25

MDETECT Y28MCLK Y27

MBS Y26MDATA0 Y25MDATA1 AA28MDATA2 AA27MDATA3 AA26

STSCLK AA25STSDOUT AB28

STSDIN AB27SPWRSEL AB26SDETECT AB25

SCMDVCC AC28SRST AC27SCLK AC26

SDATA AC25

GND T11GND T12GND T13GND T14GND T15GND T16GND T17GND T18GND U11GND U12GND U13GND U14GND U15GND U16GND U17GND U18GND V11GND V12GND V13GND V14GND V15GND V16GND V17GND V18

DV

RE

F2A

E8

DV

RE

F0A

E9

DV

RE

F1A

E20

DV

RE

F3A

E21

RD

Q32

AA

1R

DQ

33A

A2

RD

Q34

AA

3R

DQ

35A

B1

RD

Q36

AB

2R

DQ

37A

B3

RD

Q38

AC

1R

DQ

39A

C2

RD

QS

4A

C3

RD

QM

4A

D1

RD

QM

5A

D2

RD

QS

5A

D3

RD

Q40

AE

1R

DQ

41A

E2

RD

Q42

AE

3R

DQ

43A

F1R

DQ

44A

F2R

DQ

45A

F3R

DQ

46A

G1

RD

Q47

AG

2R

CLK

0A

H1

RC

LK0#

AH

2R

DQ

0A

H3

RD

Q1

AG

3R

DQ

2A

H4

RD

Q3

AG

4R

DQ

4A

F4R

DQ

5A

H5

RD

Q6

AG

5R

DQ

7A

F5R

DQ

S0

AH

6R

DQ

M0

AG

6R

DQ

M1

AF6

RD

QS

1A

H7

RD

Q8

AG

7R

DQ

9A

F7R

DQ

10A

H8

RD

Q11

AG

8R

DQ

12A

F8R

DQ

13A

H9

RD

Q14

AG

9R

DQ

15A

F9R

WE

#A

H10

RC

AS

#A

G10

RR

AS

#A

F10

RC

S#

AH

11R

BA

0A

G11

RB

A1

AF1

1R

A10

AH

12R

A0

AG

12R

A1

AF1

2R

A2

AH

13R

A3

AG

13R

A4

AF1

3R

A5

AH

14R

A6

AG

14R

A7

AF1

4R

A8

AH

15R

A9

AG

15R

A11

AF1

5R

A12

AH

16R

A13

AG

16R

CK

EA

F16

RD

Q16

AH

17R

DQ

17A

G17

RD

Q18

AF1

7R

DQ

19A

H18

RD

Q20

AG

18R

DQ

21A

F18

RD

Q22

AH

19R

DQ

23A

G19

RD

QS

2A

F19

RD

QM

2A

H20

RD

QM

3A

G20

RD

QS

3A

F20

RD

Q24

AH

21R

DQ

25A

G21

RD

Q26

AF2

1R

DQ

27A

H22

RD

Q28

AG

22R

DQ

29A

F22

RD

Q30

AH

23R

DQ

31A

G23

RC

LK1

AF2

3R

CLK

1#A

H24

RD

Q48

AG

24R

DQ

49A

F24

RD

Q50

AH

25R

DQ

51A

G25

RD

Q52

AF2

5R

DQ

53A

H26

RD

Q54

AG

26R

DQ

55A

H27

RD

QS

6A

H28

RD

QM

6A

G28

RD

QM

7A

G27

RD

QS

7A

F28

RD

Q56

AF2

7R

DQ

57A

F26

RD

Q58

AE

28R

DQ

59A

E27

RD

Q60

AE

26R

DQ

61A

D28

RD

Q62

AD

27R

DQ

63A

D26

RV

DD

AA

4R

VD

DA

B4

RV

DD

AC

4R

VD

DA

D4

RV

DD

AE

4R

VD

DA

E5

RV

DD

AE

6R

VD

DA

E7

RV

DD

AE

10R

VD

DA

E11

RV

DD

AE

12R

VD

DA

E13

RV

DD

AE

16R

VD

DA

E17

RV

DD

AE

18R

VD

DA

E19

RV

DD

AE

22R

VD

DA

E23

RV

DD

AE

24R

VD

DA

E25

RV

DD

AD

25

ATP

1D

2A

VD

D_A

PLL

0C

2A

VD

D_A

PLL

1B

1A

VD

D_V

PLL

A1

AV

DD

_DM

PLL

0C

1

AV

DD

RK

PC

3

AV

DD

YK

PB

5A

VD

DB

GK

PB

6

DA

CV

RE

FB

7

DV

DD

KP

C6

OX

TALO

A2

OX

TALI

B2

NC

A5

NC

D6

AV

DD

_DM

PLL

1D

3

ATP

2D

1

CA

PV

GN

DE

5

+ CE2247uF/16vC10UF16V/D5H11

TP4VCXO1TP/SMD/D1.0

TP3IOG_Y4TP/SMD/D1.0

R354.7KR0603/SMD

LED1LED DIP2.54LED/DIP/P2.54

C1160.1uFC0603/SMD

TP1IOR_Y6TP/SMD/D1.0

C1170.1uFC0603/SMD

28／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

RVREF

GND

OXTALIOXTALO

OPWM0

OXTALO

OXTALI

MEM_VREF

FS

APLLCAP1 APLLCAP0

DV25

DV33

DV12

AVDDBGKP

AVDDYKP

AVDDRKP

AVDD_DMPLL0

AVDD_DMPLL1

AVDD_VPLL

AVDD_APLL1

AVDD_APLL0

MEM_VREF RVREF

CAPVPLLAV33

DVDDKP

FS

CAPVPLL

APLLCAP1APLLCAP0

ATP1ATP2

AVDDRKP

AVDD_APLL0AVDD_APLL1

AVDDBGKP

AVDD_DMPLL1AVDD_VPLL

AVDDYKP

AVDD_DMPLL0

CAPVGND

ATP1 ATP2

OSCL_MST

OSDA_MSTOSDA0

OSCL0

OSCL_MSTOSDA_MST

OPWM0

OSCL_MSTOSDA_MST

OSCL0OSDA0

VCXO0

VCXO0

CAPVGND

OXTALIU2CTS

U2CTS

OIRI

OIRI

+5V

DV25

DV12

DV33

DV33

DVDDKPAV33

AV33 AV33

DV12

DV33

DV33

DV33

+5V

GND1,2,3,4,5,7,8

DV252,5,7

RVREF5

OXTALI5OXTALO5

OPWM05

MEM_VREF7

DV331,2,5,8

DV122,5

AV332,5

DVDDKP5

FS5

CAPVPLL5

APLLCAP15APLLCAP05

ATP15ATP25

AVDDRKP2,5

AVDD_APLL02,5AVDD_APLL12,5

AVDDBGKP2,5

AVDD_DMPLL12,5AVDD_VPLL2,5

AVDDYKP2,5

AVDD_DMPLL02,5

CAPVGND5

OSDA_MST4OSCL_MST4

OSCL05OSDA05

VCXO05

U2CTS5

OIRI5

+5V1,2

Title


Date: Sheet o f

MT5351RA-V2 1Custom


MT5351 PERIPHERAL


TwinSon Chan

GLOBAL SIGNAL

LEFT SIDE BOTTOM SIDE

LEFT SIDE RIGHT SIDE

LEFT SIDE RIGHT SIDE TOP SIDE

TOP SIDE BOTTOM SIDE

ANALOG PART

MT5351 SYSTEM EEPROM

CB760.1uFC0603/SMD

R454.7KR0603/SMD

CB880.1uFC0603/SMD

C1400.1uFC0603/SMD

C22NS/20pFC0603/SMD


C1830.1uFC0603/SMD

C1850.1uFC0603/SMD

CB444.7uFC0805/SMD

CB504.7uFC0805/SMD

CB720.1uFC0603/SMD

R44NS/10R0603/SMD

CB750.1uFC0603/SMD


C1040.1uFC0603/SMD

X1

VCXO FR270003OSC/6P/SMD/7X5

CVIN1

TRI-STATE2

GND3 OUT 4

NC 5

VDD 6

C1840.1uFC0603/SMD

JP1

JP2/DIP/P2.542x1

1 2

R38NS/10MR0603/SMD

C1280.1uFC0603/SMD

CB670.1uFC0603/SMD

CB574.7uFC0805/SMD

R40NS/50R0603/SMD

CB710.1uFC0603/SMD

R39NS/10R0603/SMD

C251500pFC0603/SMD

IR1

IRNS/IR

1 2 3

CB740.1uFC0603/SMD

R4310R0603/SMD

C1290.1uFC0603/SMD

R47100R0603/SMD

OSC1NS/74.25MHzOSC/SMD/A

VCC4 OUT 3

GND 2NC1

FB7

FBBEAD/SMD/0603

CB660.1uFC0603/SMD

CB770.1uFC0603/SMD

CB850.1uFC0603/SMD

R464.7KR0603/SMD

CB900.1uFC0603/SMD

CB870.1uFC0603/SMD

CB700.1uFC0603/SMD

R41NS/50R0603/SMD

Y2

NS/27MHzCRYS/DIP/SMD

CB530.1uFC0603/SMD

C10110uF/10vC0805/SMD

C1384.7uFC0805/SMD

C2610nFC0603/SMD

CB480.1uFC0603/SMD

CB520.1uFC0603/SMD

U13

EEPROM 24C16/NCSOP8/SMD


R48100R0603/SMD

R428.2KR0603/SMD

R37NS/560R0603/SMD

C2847pFC0603/SMD

CB540.1uFC0603/SMD

CB690.1uFC0603/SMD

CB810.1uFC0603/SMD

CB890.1uFC0603/SMD

C241500pFC0603/SMD

CB450.1uFC0603/SMD

C1860.1uFC0603/SMD

CB420.1uFC0603/SMD

TP7CAPVGNDTP/SMD/D1.0

CB784.7uFC0805/SMD

CB820.1uFC0603/SMD

CB510.1uFC0603/SMD

CB790.1uFC0603/SMD

CB650.1uFC0603/SMD

CB680.1uFC0603/SMD

C271nFC0603/SMD

C1790.1uFC0603/SMD

CB490.1uFC0603/SMD

CB860.1uFC0603/SMD

C21NS/20pFC0603/SMD

CB460.1uFC0603/SMD

CB474.7uFC0805/SMD

CB730.1uFC0603/SMD

CB430.1uFC0603/SMD

CB800.1uFC0603/SMD

C23

5600pFC0603/SMD

L31

FBL0603/SMD

29／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

DV25

G ND

MEM_VREFMEM_ADDR6MEM_ADDR5MEM_ADDR4

MEM_DQ0

MEM_ADDR6MEM_ADDR5MEM_ADDR4

MEM_DQ16 MEM_DQ31

MEM_DQ17 MEM_DQ30MEM_DQ18

MEM_DQ19MEM_DQ20

MEM_DQ21MEM_DQ22

MEM_DQ23

MEM_DQS2

MEM_WE#MEM_DQM2

MEM_CAS#

MEM_CS#MEM_RAS#

MEM_BA0MEM_BA1MEM_ADDR10MEM_ADDR0MEM_ADDR1MEM_ADDR2MEM_ADDR3

MEM_DQ29

MEM_DQ28MEM_DQ27

MEM_DQ26MEM_DQ25

MEM_DQ24

MEM_DQS3

MEM_DQM3MEM_CLKB#MEM_CLKBMEM_CLKEN

MEM_ADDR12MEM_ADDR11MEM_ADDR9MEM_ADDR8MEM_ADDR7

MEM_DQ15

MEM_DQ1 MEM_DQ14MEM_DQ2

MEM_DQ3MEM_DQ4

MEM_DQ5MEM_DQ6

MEM_DQ7

MEM_DQS0

MEM_WE#MEM_DQM0

MEM_CAS#

MEM_CS#MEM_RAS#

MEM_BA0MEM_BA1MEM_ADDR10MEM_ADDR0MEM_ADDR1MEM_ADDR2MEM_ADDR3

MEM_DQ13

MEM_DQ12MEM_DQ11

MEM_DQ10MEM_DQ9

MEM_DQ8

MEM_DQS1

MEM_DQM1MEM_CLKA#MEM_CLKAMEM_CLKEN

MEM_ADDR12MEM_ADDR11MEM_ADDR9MEM_ADDR8MEM_ADDR7

MEM_DQ6

MEM_DQ14

MEM_DQ23

MEM_DQ12

MEM_DQ17

MEM_DQ1

MEM_DQ20

MEM_DQ22

MEM_DQ26

MEM_DQ3MEM_DQ4

MEM_DQ29

MEM_DQ0

MEM_DQ28

MEM_DQ19

MEM_DQ31

MEM_DQ13

MEM_DQ25

MEM_DQ21

MEM_DQ11

MEM_DQ8

MEM_DQ10MEM_DQ9

MEM_DQ2

MEM_DQ5

MEM_DQ24

MEM_DQ18

MEM_DQ7

MEM_DQ15

MEM_DQ30

MEM_DQ27

MEM_DQ16

RDQ[0..31]RDQS[0..3]RDQM[0..3]RA[0..13]

RCLK0RCLK0#RCS#RRAS#RCAS#RWE#RCKE

RBA[0..1]

RCLK1RCLK1#

MEM_DQS0MEM_DQM0MEM_DQM1MEM_DQS1

MEM_DQS2MEM_DQM2MEM_DQM3MEM_DQS3

RDQM1RDQS1

RDQS0RDQM0

RDQ0RDQ1RDQ2RDQ3RDQ4RDQ5

RDQ7

RDQS2RDQM2RDQM3RDQS3

RDQ8RDQ9RDQ10RDQ11RDQ12

RDQ14

RDQ17RDQ18RDQ19RDQ20RDQ21RDQ22RDQ23

RDQ16

RDQ15

RDQ24RDQ25RDQ26RDQ27RDQ28RDQ29RDQ30RDQ31

MEM_CLKA

MEM_CLKA#

RCLK0

RCLK0#

MEM_CLKB

MEM_CLKB#

RCLK1

RCLK1#

MEM_VREF

MEM_VREFMEM_VREFMEM_ADDR13 MEM_ADDR13

DV25

RA0 MEM_ADDR0

MEM_ADDR8

MEM_ADDR7

MEM_ADDR2

MEM_ADDR4

MEM_ADDR5

RA1

RA2

MEM_ADDR1

MEM_ADDR3

MEM_ADDR6

RA3

RA4

RA5RA6

RA7

RA13 MEM_ADDR13

MEM_ADDR9RA9

MEM_ADDR12

RA11

RCKE

MEM_ADDR10

RA12

MEM_ADDR11

MEM_CLKEN

MEM_CAS#MEM_CS#MEM_BA0

MEM_WE#

MEM_RAS#

RWE#RCAS#

RRAS#MEM_BA1

RCS#RBA0

RBA1

RA10MEM_ADDR0

MEM_ADDR12

MEM_ADDR10

MEM_ADDR11

MEM_CLKEN

MEM_ADDR2MEM_ADDR1

MEM_ADDR13

MEM_CS#

MEM_ADDR7

MEM_ADDR3

MEM_CAS#

MEM_ADDR4

MEM_WE#

MEM_ADDR5

MEM_ADDR9

MEM_ADDR6

MEM_ADDR8

MEM_BA1MEM_BA0

MEM_RAS#

RA8

RDQ6

RDQ13

DV25 DV25 DV25 DV25

DV25

DV25

+1V25_DDR

+1V25_DDR

+1V25_DDR+1V25_DDR

+1V25_DDR

DV25

+1V25_DDR

+1V25_DDR

GND1,2,3,4,5,6,8

DV252,5,6

MEM_VREF6

RDQ[0..31]5RDQS[0..3]5RDQM[0..3]5RA[0..13]5

RCLK05RCLK0#5RCS#5RRAS#5RCAS#5RWE#5RCKE5

RBA[0..1]5

RCLK15RCLK1#5

Title

Size Document Number R e v

Date: Sheet o f

MT5351RA-V2 1Custom


DDR MEMORY


TwinSon Chan

GLOBAL SIGNAL

EQUAL LINE LENGTH

BYPASS CAP. FOR DDR

BYPASS CAP. FOR TERMINATOR(EVERY 2 RESISTOR PUT 1 BYPASS CAP.)

DDR MEMORY

DDR#1 DDR#2

BYPASS CAP. FOR DIMM+1V25_DDR FOR DDR TERMINATORMEM_VREF FOR DDR AND MT5351 VREF

FOR DDR#1

FOR DDR#2

CLOSED TO MT5351 CLOSED TO DDR

CLOSED TO MT5351

CLOSED TO MT5351 CLOSED TO DDR

CLOSED TO DDR

ADD by Ada

R73 47

C1740.1uFC0603/SMD

R72 75

C1600.1uFC0603/SMD

C1410.1uFC0603/SMD

R80 75

C1440.1uFC0603/SMD

R10247R0603/SMD

R57 47R56 75

C1590.1uFC0603/SMD

RN20 47x4

1 23 45 67 8

R69 47

C1700.1uFC0603/SMD

RN14 22x4

1 23 45 67 8

R76 75

C1090.1uFC0603/SMD

R107100R0603/SMD

U18

16M x 16 DDR TSOP-66TSOP_0D65_22D6LX9D7W_66SP

VDD1DQ02VDDQ3DQ14DQ25VSSQ6DQ37DQ48VDDQ9DQ510DQ611VSSQ12DQ713NC14VDDQ15LDQS16NC17VDD18NC19LDM20WE21CAS22RAS23CS24NC25BS026BS127A10/AP28A029A130A231A332VDD33 VSS 34A4 35A5 36A6 37A7 38A8 39A9 40A11 41A12 42NC 43CKE 44CLK 45CLK 46UDM 47VSS 48VREF 49NC 50UDQS 51VSSQ 52NC 53DQ8 54VDDQ 55DQ9 56DQ10 57VSSQ 58DQ11 59DQ12 60VDDQ 61DQ13 62DQ14 63VSSQ 64DQ15 65VSS 66

C1610.1uFC0603/SMD

RN22 22x4

1 23 45 67 8

C1770.1uFC0603/SMD

RN32 47x4

1 23 45 67 8

R55 47

C1460.1uFC0603/SMD

U19

IC LP2996 DDR Termination SOP-8SOP8/SMD

GND1SD2VSENSE3VREF4 VDDQ 5AVIN 6PVIN 7VTT 8

C1800.1uFC0603/SMD

C1100.1uFC0603/SMD

U15

16M x 16 DDR TSOP-66TSOP_0D65_22D6LX9D7W_66SP

VDD1DQ02VDDQ3DQ14DQ25VSSQ6DQ37DQ48VDDQ9DQ510DQ611VSSQ12DQ713NC14VDDQ15LDQS16NC17VDD18NC19LDM20WE21CAS22RAS23CS24NC25BS026BS127A10/AP28A029A130A231A332VDD33 VSS 34A4 35A5 36A6 37A7 38A8 39A9 40A11 41A12 42NC 43CKE 44CLK 45CLK 46UDM 47VSS 48VREF 49NC 50UDQS 51VSSQ 52NC 53DQ8 54VDDQ 55DQ9 56DQ10 57VSSQ 58DQ11 59DQ12 60VDDQ 61DQ13 62DQ14 63VSSQ 64DQ15 65VSS 66

RN28 47x4

1 23 45 67 8

CB1330.1uFC0603/SMD

R74 75

+ CE29220uF/16vC220UF16V/D6H11

R67 22

C1620.1uFC0603/SMD

R103100R0603/SMD

CB950.1uFC0603/SMD

RN26 47x4

1 23 45 67 8

C1030.1uFC0603/SMD

C1470.1uFC0603/SMD

C1560.1uFC0603/SMD

+ CE2447uF/16v C47UF16V/D5H5

C1730.1uFC0603/SMD

RN19 75x4

1 23 45 67 8

R70 75

C1520.1uFC0603/SMD

C1670.1uFC0603/SMD

+ CE26220uF/16vC220UF16V/D6H11

C1420.1uFC0603/SMD

RN36 47x4

1 23 45 67 8

RN15 75x4

1 23 45 67 8

C1680.1uFC0603/SMD

R71 22

R63 22

+ CE28220uF/16vC220UF16V/D6H11

C1630.1uFC0603/SMD

C1110.1uFC0603/SMD

R10847R0603/SMD

RN17 75x4

1 23 45 67 8

RN29 75x4

1 23 45 67 8

C1760.1uFC0603/SMD

C1480.1uFC0603/SMD

R78 NS/75

RN25 75x4

1 23 45 67 8

R1044.7KR0603/SMD

R64 75

CB1260.1uFC0603/SMD

C1060.1uFC0603/SMD

C1540.1uFC0603/SMD

R77 22

R68 75

+ CE25220uF/16vC220UF16V/D6H11

R65 22

RN35 75x4

1 23 45 67 8

C1570.1uFC0603/SMD

C1820.1uFC0603/SMD

C1640.1uFC0603/SMD

R79 47

C1020.1uFC0603/SMD

C1450.1uFC0603/SMD

R62 75

C1050.1uFC0603/SMD

C1750.1uFC0603/SMD

R10647R0603/SMD

C1500.1uFC0603/SMD

C1070.1uFC0603/SMD

R61 47

+ CE23220uF/16vC220UF16V/D6H11

RN33 75x4

1 23 45 67 8

RN31 75x41 23 45 67 8

C1810.1uFC0603/SMD C155

0.1uFC0603/SMD

C1430.1uFC0603/SMD C172

0.1uFC0603/SMD

RN34 47x4

1 23 45 67 8

C1580.1uFC0603/SMD

C1650.1uFC0603/SMD

R60 75

RN24 47x4

1 23 45 67 8

R75 47

C1390.1uFC0603/SMD

C1710.1uFC0603/SMD

C1510.1uFC0603/SMD

CB910.1uFC0603/SMD

R59 47

CB1250.1uFC0603/SMD

C1530.1uFC0603/SMD

C1080.1uFC0603/SMD

RN18 22x4

1 23 45 67 8

RN16 47x4

1 23 45 67 8

R10547R0603/SMD

C1780.1uFC0603/SMD

RN27 75x4

1 23 45 67 8

RN23 75x4

1 23 45 67 8

RN37 75x4

1 23 45 67 8

C1690.1uFC0603/SMD

R58 75

R66 75

RN30 22x41 23 45 67 8

C1660.1uFC0603/SMD

RN21 75x4

1 23 45 67 8

30／116

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

DV33

ORESET#

PDA0

PDA20PDA19PDA18PDA17PDA16PDA15PDA14PDA13PDA12

PDA10PDA11

PDA9PDA8PDA7PDA6PDA5PDA4PDA3PDA2PDA1

PDA21PDA22POCE0#POOE0#POWE#

NOR_RST#

PDD0PDD1PDD2PDD3PDD4PDD5PDD6PDD7

NOR_WP#

ORESET#

ORESET#

NOR_RY_BY0#PDA[0..22]PDD[0..7]

POWE#

POCE0#POOE0#

GND

U1TXU1RX

JTRST#JTDIJTMSJTCKJRTCKJTDO

U2TXU2RX

U1RXU1TX

U0RXU0TX

JRTCKJTDO

JTAG_DBGACKJTAG_DBGRQ

JTMS

JTRST#JTDI

JTCK

TVTREF#1

+5V

U2TXU2RX

PDA1 PDA2PDA0

RBG

G

VOHSYNCVOVSYNC

VOHSYNCVOVSYNC

R

B

RSTXD

RSRXD

U0TXU0RX

GND GND

U0TX U0RX

DV33

DV33

DV33

DV33

DV33

DV33DV33

DV33

DV33

+5V +5V

GND1,2,3,4,5,6,7

DV331,2,5,6

ORESET#1,4,5

PDA[0..22]5PDD[0..7]5

POCE0#5POOE0#5POWE#5

JTRST#5JTDI5JTMS5JTCK5JRTCK5JTDO5

U2TX1,5U2RX1,5

U1RX5U1TX5

U0RX1,5U0TX1,5

+5V1,2,6

R5B5G5VOHSYNC1,5VOVSYNC1,5

Title


Date: Sheet o f

MT5351RA-V2 1Custom


NOR FLASH / JTAG / UART


TwinSon Chan

GLOBAL SIGNAL

FLASH INTERFACE

NOR FLASH #0JTAG PORT

UART (RS232)

FOR SOFTWARE LINK

CLI OUTPUT

SOFTWARE DEBUG PORT

TRAP CIRCUIT

R85NS/4.7KR0603/SMD

C32NS/10pFC0603/SMD

CB152 0.1uF

J3

10x2DIP10X2/W/H/IDE/P2.54

13579

1113151719

2468101214161820

R97 0 R0603/SMD

R984.7KR0603/SMD

R83NS/4.7KR0603/SMD

CB153 0.1uF

U22

MAX3232

R1IN13R2IN8T1IN11T2IN10

C+1C1-3C2+4C2-5V+2V-6

R1OUT 12R2OUT 9T1OUT 14T2OUT 7

VCC 16

GND 15

R84

0R0603/SMD

D3SOT23/SMD

1 3

2

J6

CON8

12345678

P2CONNECTOR DB9

594837261

RN381Kx4RN0603/SMD

12

34

56

78

R904.7KR0603/SMD

R954.7KR0603/SMD

R934.7KR0603/SMD

+ CE2710uF/16vC10UF16V/D5H11

J5


1234

CB156 0.1uF

R924.7KR0603/SMD

R894.7KR0603/SMD

U17

IC FLASH MX29LV320 32Mb TSOP-48TSOP48/SMD

A025A124A223A322A421A520A619A718A88

A2010

OE28

BYTE 47A1816

D0 29D1 31D2 33D3 35

A97

CE26

D4 38D5 40D6 42D7 44D8 30D9 32

WP/ACC 14

D11 36D12 39D13 41D14 43

D15/A-1 45

VCC 37

GND1 27WE11

A199

D10 34

GND2 46

A106

A124 A115

A133A142A151A1648A1717

A2113

RESET12

RY/BY 15

R1014.7KR0603/SMD

R96 0 R0603/SMD

R944.7KR0603/SMD

CB1450.1uFC0603/SMD

R994.7KR0603/SMD

R1004.7KR0603/SMD

CB154 0.1uF

J4


1234

D2SOT23/SMD

1 3

2

R874.7KR0603/SMD

R911KR0603/SMD

R82NS/4.7KR0603/SMD

R88

0R0603/SMD

CB1550.1uF

R86

NS/4.7KR0603/SMD

C3310pFC0603/SMD

FB9

FBBEAD/SMD/0603

31／116

Basic Operations & Circuit Description

MODULE There are 1 pcs panel and 5 pcs PCB including 3 pcs Extension PCB, 1 pcs Timming controller board and 1 pcs Back Light board in the Module.

SET There are 6 pcs PCBs including 1 pcs ATV Tuner board, 1 pcs keypad board, 1 pcs Remote Control Receiver board, 2 pcs L/R Speakers and 1 pcs Main(Video)board, 1 pcs ATSC board in the SET.

32／116

PCB funtion

1. Power :

(1). Input voltage: AC 120V, 60Hz.

(2). To provide power for PCBs.

2. Main board : To converter TV signals, S signals, AV signals, Y Pb/Cb Pr/Cr signals, DVI/HDMI signals and

D-SUB signals to digital ones and to transmit to Control board.

3. Control board : Dealing with the digital signal for output to panel.

4. Extension board : Output addressing signals.

5. ATV Tuner Board : To convert TV RF signal to video and SIF audio signal to Main board.

6. ATSC Board : Receiver and converter ATSC TV signal to transmit to main board.

33／116

PCB failure analysis

1. CONTROL : a. Abnormal noise on screen. b. No picture.

2. MAIN : a. Lacking color, Bad color scale.

b. No voice. (Make sure status: Mute / Internal, External speaker)

c. No picture but with signals output, OSD and back light.

d. Abnormal noise on screen.

3. POWER : NO picture, no power output.

4. Back Light : a. No picture.

b. Flash on screen.

c. Darker picture with signals.

5. ATV Tuner : a. No ATV Noise

b. No ATV signals

6. ATSC: a No ATSC TV signal

34／116

Main IC Specifications

- M13S128168A (ESMT) 2M x 16 Bit x 4 Banks Double Data Rate SDRAW - MT5111CE Single-Chip HDTV/CATV Demodulator - MT5351 MT5351 is a DTV Backend Decoder SOC which support flexible transport demux, HD MPEG-2 video decoder, MPEG1,2, MP3, AC3 audio decoder, HDTV encoder. MT5351 is powered by ARM 926EJ with 16K I-Cache and 16K D-Cache. It can support 64Mb to 1Gb DDR DRAM devices with configurable 32/64 bit data bus interface. - MT8202 MT8202G is a highly integrated Single-Chip for LCD TV supporting video input and output format up to HDTV. It includes 3D comb filter TV decoder to retrieve the best image from popular composite signals. - MT8293 HDMI PanelLink Cinema Receiver - R2S15102NP Digital Power Amplifier R2S15102NP - WM8776 24-bit, 192kHz Stereo CODEC with 5 Channel I/P Multiplexer

35／116

36／116

Allen

矩形

37／116

Allen

矩形

38／116

Allen

矩形

39／116

Allen

矩形

40／116

yd

矩形

Allen

矩形

41／116

Allen

矩形

42／116

Allen

矩形

43／116

Allen

矩形

44／116

Allen

矩形

Allen

矩形

45／116

Allen

矩形

Allen

矩形

46／116

Allen

矩形

Allen

矩形

47／116

Allen

矩形

Allen

矩形

48／116

Allen

矩形

Allen

矩形

49／116

Allen

矩形

Allen

矩形

50／116

Allen

矩形

Allen

矩形

51／116

Allen

矩形

Allen

矩形

52／116

Allen

矩形

Allen

矩形

53／116

Allen

矩形

Allen

矩形

54／116

Allen

矩形

Allen

矩形

55／116

Allen

矩形

Allen

矩形

56／116

Allen

矩形

Allen

矩形

57／116

Allen

矩形

Allen

矩形

58／116

Allen

矩形

Allen

矩形

59／116

yd

矩形

60／116

Allen

矩形

Allen

矩形

Digital Power Amplifier R2S15102NP10Wx2ch(SE)/20Wx1ch(BTL) Digital Audio Power Amplifier

1.Outline　　R2S15102NP is a Digital Power Amplifier IC developed for TV.　　R2S15102NP can realize maximum Power 10W × 2ch

(VD = 24V,THD = 10%, SE) at 8 Ω load.　 It is possible to replace from the conventional analog amplifier

system to the digital amplifier system easily.

2.Feature　High Output Power(THD=10%)without external Heat Sink

　　　　 (note) the thermal pad is soldered the thermal pad with　　　　the printed-circuit board directly.

Ｒｅｃｏｍｍａｎｄｅｄ Power Condition 　SE operation mode :10Wx2ch(VD=24V) at 8 Ω 　　BTL operation mode: 20Wx1ch(VD=18V) at 8 Ω

The RENESAS original circuits realize high power efficiency, low noise and low distortion characteristics.

　Pop sound Less　Built-in protection function

(Over Current, Over Temperature and Under Voltage)　Built-in Mute and Stand-by function

3.Operating Condition　Ｒｅｃｏｍｍａｎｄｅｄ　Power supply voltage : from 11V to 25V　Ｒｅｃｏｍｍａｎｄｅｄ　Speaker Impedance : from 4 to 8Ω

Ｆｉｇ．１　Package

20pin QFNBody : 6 x 6 mm

Lead pitch : 0.8 mm

１

２０

Under

Development

4.Block DiagramＦｉｇ．２　System Ｂｌｏｃｋ　Ｄｉａｇｒａｍ

ControlLogic

A

Oscillator

Under VoltageDetection

Over CurrentDetection

Over Temp.Detection

A

PWM1 PWM2

SE/BTLSelector

STBYL

IN1

MUTEL

CBIAS

IN2

ROSC

GNDPROT

DVDD

VREF

OUT1

HB1

VD1

VS1

OUT2

VD2

VS2

HB2

PWMGene.

PWMGene.

１

２０

２

３

４

５

６

７

８

９

１０

１１

１２

１３

１４

１５

１６

１７

１８

１９

61／116

Digital Power Amplifier R2S15102NP

５．Pin Configuration(Table.1)

VD214

WBTL operation hen this is connected to DVDD pin viathe resister, Reversed signal of OUT1 is output to OUT2.

Analog input #2(as same as IN1)

Power supply pin for power output stage #2－

Ground pin for power output stage #1－VS120Capacitor connection pin for bootstrap #1I/OHB119

Capacitor connection pin for bootstrapI/OHB217Built-in power supply pin for internal digital block.ODVDD18

Ground pin for power output stage #2－VS216Power Output pin #2OOUT215

Mute control pin. When this is “L”, it becomes mute status.IMUTEL13PWM input pin#2 ( for phase compensation)

SE operation

Protection Timer pin. At protection mode,the output becomes “L”-level.(The timing capacitor is connected)

Capacitor connection pin for analog block reference voltage source

GND pin for analog blockControl pin for PWM carrier frequency

A capacitor is connected so that it may not be influenced of power supply change(Ripple Filter).

Analog input #1. The gain is depended on the external resistance .

PWM input pin #1 ( for phase compensation)

Stand-by control pin. When this is “L”, circuit current is reduced.There is the pull-down resistor:50Kohm(typ.).

Power supply pin for power output stage #2Power Output pin #1

Description

I

II

O

I/O－

I

I/O

II

I－

OI/O

PWM2

IN2

PROT

VREF

GND

ROSC

CBIAS

IN1

PWM1

STBYL

VD1

OUT1

NAME

12

11

10

987

6

54

321

No.

62／116


６．Absolute Maximum Rating(Table.2)

-40～150Temperature rangeStorage temperatureTstg

/WWVV

Unit

-20～75150304.24027

Value

Temperature rangeMaJunction temperature ximum TemperatureSee Fig.3Ta = 25°C :See Fig.3HB1、HB2 pin voltageVD1,VD2 pin voltaMaximum VD Voltage ge

Condition

Operating ambient temperature

Thermal ResistancePower dispassionMaximum HB Voltage

Parameter

TaTj

θjaPd

HB maxVD maxSymbol

Fig.3 Thermal De-rating(on PCB: printed-circuit board ):Size 75mm x 75mm

2.5W

Without External Heat Sink(1)Double PCB copper planes(t=0.035mm) are needed and each size is almost 7５mm X 7５mm.　　(θｊａ＝３０／Ｗ,4layer PCB）

Pd

6.3W

With Infinite Heat Sinkthe ideal condition(θjc=12 /W)

1.6W1.0W

Without External Heat Sink(2)There is no copper plane and no thermal treatment.( 1layer PCB)

0

Under

Development

10.4W

4.2W

Ta75 15025

(NOTE)PCB pattern design for high effective thermal conductivity

(caution)There are side expositions of the die pad at corners of the package.(The die pad is grounded.)

Thermal Via

PCB

(1)The exposed die pad is directly soldered with the printed-circuit board pattern .

(2)Thermal Via

63／116

Digital Power Amplifier R2S15102NPConsideration about the PCB design

(1)PCB basic design (copper plane)<the best design : 4 layer PCB>

The Power dispassion at 10Wx2ch(SE) or 20Wx1ch(BTL) is estimated almost 2W. It has enough margin, designing the PCB at θja=30/W.

thermal via

<PCB size estimation >10Wx2ch: 75mm x 75mm

The exposed die pad is directly soldered with the printed-circuit board pattern .

GND planePCB Power plane

<the economy design : 2 layer PCB>

Thermal Via

Rich GND&Power line Area

AdditionalThermal Via

PCB

The GND&Power line total area size is also equal to the above GND&Power line total area size of the 4layer PCB.

<PCB size estimation >10Wx2ch: (75+α)mm x (75+α) mm

(2)PCB Thermal Pad

PCBThermal ViaThermal Pad

64／116


７．Recommended Operating condition(Table.3)

kHz600400300R=　33ｋΩCarrier Frequencyfosc

MAXTYP

0.8525

---

VVV

Unit

0211

MIN

STBYL、MUTELSTBControl voltage of high level YL、MUTELVD1,VD2 pin voltage

Condition

Control voltage of low level

Supply VoltageParameter

VLVHVD

Symbol

(note) ・ STBYL: High level:normal operation Low level:Stand-by ・ MUTEL:High level:normal operation Low level:Mute・ The carrier frequency can be changed by the resistance at Pin#.7 .

８．Electronic Characteristics(Table.4)

％-89TBDPo=20Wat BTLat SE

dB-80TBDMute AttenuationMutedB-50TBDdVD=100mVrms,f=100

HzRipple Rejection Ratio

PSRR

W-20TBDTHD=10%、VD=18V、RL=8Ω

at BTL

at SE

％-93TBDPo=10+10WPower Efficiency

Eff

uVrmDs

TB(100)-A-Weighted filterOutput Noise levelNo

％

W/ch-10TBDTHD=10%、VD=24V、RL=8Ω

Maximum output power

Pomax

TBD0.1-Po=1WTotal Harmonic Distortion

THD

A-6-Output over-currentProtection CurrentIPR-120-Thermal Shut-dawnRelease TemperatureTRL

-150-Thermal Shut-dawnProtection Temperature

TPR

uA10--Stand-bymATBD-TBDMUTE

MAX

TYPMIN

TBD

TBD

9.8

28

V

mA

Unit

TBD

TBD

VD under-voltage

No Signal

Condition

Detection Voltage

Circuit Current

Parameter

VDPR

IVD

Symbol(Unless otherwise noted, Ta=25°C, VD=24V, Carrier Frequency=400kHz, f=1kHz,SE operation)

65／116

Digital Power Amplifier R2S15102NP(note)“R for GND” ‘s arefor the evaluation only andnot needed actually.

９．Application Examples

Fig.4 　SE operation mode(10Wx2ch)

VD=+11～25V

STBYL

RO

SC

OUT1

HB

1VD1

VS1

IN1

MUTEL

CB

IAS

AV

DD

OUT2

VD2

VS2

PR

OT

HB

2

DV

DD

IN2

GN

D3

4

2

5

1

987 106

14

15

11

12

13

16171820 19

PWM2PWM1

0.47u10k10k

0.47u

10u

10u

22k

330u 330u

8Ω

R2S15102

10u

0.1u 0.1u

3p 150k 150k 3p

1u

STANDBY

IN1 IN2

47k

0.1u0.1u

0.1u 1000u

0.047u

R for GND(150k)

R for GND(47k)

R for GND(47k)

15uHVz=27～３０VVz=27～３０V

ExposedDie Pad

STBYL

RO

SC

OUT1

HB

1

VD1

VS1

IN1

MUTEL

CB

IAS

AV

DD

OUT2

VD2

VS2

PR

OT

HB

2

DV

DD

IN2

GN

D

3

4

2

5

1

987 106

14

15

11

12

13

16171820 19

PWM2PWM1

47k10k

0.47u

22k

8Ω

R2S15102

10u

0.1u 0.1u

3p 150k 150k 3p

STANDBY

47k

0.1u0.1u

0.1u 1000u

0.047u

R for GND(150k)

15uHVz=27～３０VVz=27～３０V

Fig.5 　BTL operation mode (20W)

ExposedDie Pad

0.1u

++

(note)This capacitance value depends onthe speaker peripheral circuit.

1k

1k

0.047u

1u1u15uH

8Ω

MUTE

VD=+11～25V0.047u

1u1u15uH

BTL Configuration

MUTEIN

0.1uR for GND(47k)

R for GND(150k)

10u 1u

10u

66／116


STBYL

RO

SC

OUT1H

B1

VD1

VS1

IN1

MUTEL

CB

IAS

AV

DD

OUT2

VD2

VS2

PR

OT

HB

2

DV

DD

IN2

GN

D

3

4

2

5

1

987 106

14

15

11

12

13

16171820 19

PWM2PWM1

47k

10u22k

8Ω

R2S15102

10u

0.1u 0.1u

3p 150k 150k 3p

STANDBY

47k

0.1u0.1u

0.1u 1000u

0.047u

R for GND(150k)

15uHVz=27～３０VVz=27～３０V

Fig.7 　BTL operation mode without output LPF coil

STBYL

RO

SC

OUT1

HB

1

VD1

VS1

IN1

MUTEL

CB

IAS

AV

DD

OUT2

VD2

VS2

PR

OT

HB

2

DV

DD

IN2

GN

D

3

4

2

5

1

987 106

14

15

11

12

13

16171820 19

PWM2PWM1

47k10k

0.47u

10u22k

8Ω

R2S15102

10u

0.1u 0.1u

3p 150k 150k 3p

STANDBY

47k

0.1u0.1u

0.1u 1000u

0.047u

R for GND(150k)

Vz=27～３０V

FB

FB

If this speaker lines is very short, the LPF coil is not needed.

PWMOutput(BTL)

(note)It may be need theinput Pre-LPF.

ExposedDie Pad

ExposedDie Pad

0.1u

1u

(note)“R for GND” ‘s arefor the evaluation only andnot needed actually.

(note)The audio mute function must bedone by PWM signal.

1k

1k

Fig.6 　BTL operation mode(20W) with PWM direct input

VD=+11～25V0.047u

1u1u15uH

BTL Configuration

MUTE10k

10u

VD=+11～25V0.047u

Vz=27～３０V４．７n４．７n

BTL Configuration

MUTEIN

0.1uR for GND(47k)

10u 1u

FB:Ferrite Beads

67／116

68／116

180192

矩形

69／116

Allen

矩形

Allen

矩形

180192

矩形

70／116

Allen

矩形

180192

矩形

71／116

Allen

矩形

180192

矩形

72／116

Allen

矩形

180192

矩形

73／116

Allen

矩形

180192

矩形

ACCEPTED BY：

APPROVED BY CHECKED BY PREPARED BY

CPT TFT-LCD CLAA320WA01 C

74／116

RECORD OF REVISIONS

Revision No. Date Page Description

Ver1.0 2005/8/29 all Preliminary specification was first issued.

3 Module Weight = 8000(Max)→8200(Max)

4

Input Voltage of Inverter =21.6 (Min)→ -0.3(Min) Input Voltage of Inverter =26.4 (Max)→27 (Max) Inverter Dimming=0 (Min)→ -0.3(Min) Inverter Dimming=5(Max)→5.5(Max) Backlight on Control Voltage=2(Min)→ -0.3(Min) Backlight on Control Voltage=5(Max)→5.5(Max)

5

LCD Power Supply Current—White=400(Typ.)→350(Typ.) LCD Power Supply Current—White= -- (Max)→400(Max) LCD Power Supply Current—Black=350(Typ.)→300(Typ.) LCD Power Supply Current—Black= --(Max)→400(Max) LCD Power Supply Current—RGB stripe=390(Typ.)→320(Typ.) LCD Power Supply Current—RGB stripe= --(Max)→400(Max)

8 Input Frequency of Inverter=60.5(Min)→61.5(Min) Input Frequency of Inverter=66.5(Max)→65.5(Max)

10 Pin 25=NC→DE/Sync

13

DCLK Freq.=68(Min)→62(Min) Horizontal Line Rate=43.2(Min)→37.1(Min) Horizontal Line Rate=48.5(Typ.)→48.6(Typ.) Horizontal Line Rate=53.3(Max)→56Max) Horizontal Effective Time= --(Min)→1366(Min) Horizontal Effective Time= --(Max)→1366(Max) Vertical Frame Rate=54.6(Min)→47(Min) Vertical Frame Rate=67.5(Max)→63(Max)

2005/9/28

22

Response Time Tr= 9(Typ.)→10(Typ.) Response Time Tr=16(Max)→17(Max) Response Time Tf= 7(Typ.)→6(Typ.) Response Time Tf=9(Max)→8(Max)

3 Module Weight = 8200(Max)→8300(Max)

Ver2.0

2005/10/13 8 Power Consumption=(115, Typ)→(120, Typ)

75／116

CONTENTS

No Item Page

1 OVERVIEW 3

2 ABSOLUTE MAXIMUM RATINGS 4

3 ELECTRICAL CHARACTERISTICS 5

4 INTERFACE PIN CONNECTION 10

5 INTERFACE TIMING 13

6 BLOCK DIAGRAM 18

7 MECHANICAL SPECIFICATION 19

8 OPTICAL CHARACTERISTICS 21

9 RELIABILITY TEST CONDITIONS 26

10 PACKAGING 27

11 HANDLING PRECAUTIONS FOR TFT-LCD MODULE 30

76／116

1. OVERVIEW

CLAA320WA01 is 32” color (80.04cm) TFT-LCD (Thin Film Transistor Liquid Crystal Display) module composed of LCD panel, LVDS driver ICs, control circuit, backlight, and inverter. By applying 8 bit digital data, 1366*768, 16.7 million-color images are displayed on the 32” diagonal screen. General specification are summarized in the following table:

1.1 GENERAL INFORMATION

ITEM SPECIFICATION

Display Area (mm) 697.68 (H) × 392.25 (V) (31.51 inch diagonal)

Number of Pixels 1366 (H) × 768 (V) 16:9

Pixel Pitch (mm) 0.51075 (H) × 0.51075 (V)

Color Pixel Arrangement RGB Vertical Strip

Display Mode Normally Black

Number of Colors 16.7M (8bit)

Surface Treatment Hard coating: 2H Anti-Clare + LR <less than 2% reflection.

Wide view tech. MVA

Viewing Angle CR 10≧ -85~85(H), --85~85(V)

Brightness (cd/m2) 550 (Typ.)

Total Module Power (W) 125

Module Size (mm) 743.0±1(W) × 447.0±1 (H) × 44.0±1 (D) (including inverter)

Module Weight (g) 8300 (Max)

1.2 MECHANICAL INFORMATION ITEM MIN TYP. MAX. UNIT

Horizontal (H) 742.0 743.0 744.0 mm

Vertical (V) 446.0 447.0 448.0 mm Module outline

dimension Depth (D) with inverter 43.0 44.0 45.0 mm

Module Weight -- -- 8300 g

77／116

2. ABSOLUTE MAXIMUM RATINGS

The following are maximun values which, if exceeded, may cause faulty operation or damage to the module.

ITEM SYMBOL MIN. MAX. UNIT REMARK Power Supply Voltage For LCD VCC - 0.3 15.0 V Input voltage of inverter VBL - 0.3 27 V Inverter dimming VDIM - 0.3 5.5 Vdc Backlight on control voltage VBLON - 0.3 5.5 Vdc

VESDt -100 100 V ESD

VESDc -8000 8000 V Operation Ambient Temperature Top 0 50 *1) *2) *3) *4)Storage Temperature Tstg -20 60 *1) *2) *3) *4)

[Note] *1) The relative temperature and humidity range are as below sketch.(90%RHMax / Ta 40 )≦ *2) The maximum wet bulb temperature 39≦ (Ta＞40 ) and without dewing. *3) If you use the product in a environment which over the definition of temperature and

humidity too long, and it will effect the result of visible inspection. *4) While the product operates in normal temperature range, the center surface of panel

should be under 60 . *5) Input voltage of the connector side in Inverter.

Humidity: Humidity 85%RH without cond≦ ensation.

Relative Humidity 90% (Ta 40 )≦ ≦ Wet Bulb Temperature 39≦ (Ta 40 )≧

90%

10 20 30 40 50 60 70 800 -20

10

20

30

40

50

60

Dr

0

y Bulb Temperature [C]

Wet Bulb Temperature [C]

Storage

Operation

Hum

idity

[(%

)RH

]

10%

40%

60%

78／116

3. ELECTRICAL CHARACTERISTICS

3.1 TFT-LCD MODULE Ta=25 ITEM SYMBOL MIN TYP MAX UNIT REMARK

LCD Power Supply Voltage VCC 11.4 12.0 12.6 V *1)

Ripple Voltage Vrpd -- -- 100 mVp-p VIN=+12.0V

Rush current Irush -- -- 8 A *2)

White -- 350 400

Black -- 300 400 LCD Power Supply Current

RGB stripe

ICC

-- 320 400

mA *3)

LCD power consumption Pc -- 6.48 9.7 W

High input voltage of LVDS VIN+ -- -- 100 mV

Low input voltage of LVDS VIN- 100 -- -- mV

Input common voltage of LVDS VCM -- 1.25 - V

Input terminal resist of LVDS RT -- 100 -- ohm

*4) *5)

[Note]

*1) The module should be always operated within above ranges. *2) Measure conditions:

DC

DC

+5V

R147k

R21k

VR147k

C11uF

C20.01uF

Q1 2SK1475 C3

1uF

FUSE

+15V

SW(High to low) (control signal)

Q2 2SK1470

VCC

LCD Module Input

1ms

GND

+12V

0.1Vcc

0.9Vcc

Vcc rising time is 1 ms

79／116

*3) The specified power supply current is under condition at Vcc=12V, Ta=25+/-2, fv=60Hz, whereas a power dissipation check pattern below is displayed.

a. White pattern b. Black pattern c. RGB Stripe pattern

*4) Power and Signal Sequence:

10%

90% 90%

10%

Power Supply(VCC：12V)

T1 T4

T2 T3

BL on

T5

Interface Signal(LVDS Data with H,Vsync

and DE)

Power Supply forBacklight

VCC：12V

T6

Power Sequence Table Value Parameter

Min Typ Max Unit

T1 1 --- 30 ms T2 0 --- 50 ms T3 0 --- 50 ms T4 2000 --- ms T5 110 --- ms T6 100 --- ms

Notes: Please avoid floating state of interface signal at invalid period. When the interface signal is invalid, be sure to pull down the power supply for LCD to 0V. Lamp power must be turn off after power supply for LCD interface signal valid.

80／116

VCC-dip State: 1) When 9V VCC≦ ＜11.4 V, td 10 ms.≦ 2) VCC ＞ 11.4V, VCC-dip condition should also follow the VCC-turn-off condition.

td

9V 11.4V

VCC

*5) LVDS Signal Definition:

RT

VID = VIN+ – VIN-, VCM = ｜VCM+–VCM-｜,

VID = ｜VID+–VID-｜,

VID+ = ｜VIH+–VIH-｜,

VID- = ｜VIL+–VIL-｜,

VCM = ( VIN++VIN- ) / 2, VCM+ = ( VIH++VIH- ) / 2, VCM- =( VIL++VIL- ) / 2, VIN+: Positive Polarity differential DATA & CLK input VIN-: Negative Polarity differential DATA & CLK input

81／116

3.2 BACKLIGHT Ta=25 ITEM SYMBOL MIN TYP MAX UNIT REMARK

Lamp Voltage VL -- 1150 -- Vrms IL=5.0mA

Lamp Current IL 4.0 4.5 5.0 mArms *1) Lamp life time LT 50,000 -- -- hr *2)

Input voltage of inverter VBL 21.6 24 26.4 V *3)

IIN0 -- (4.8) -- *4) Input current of inverter

IIN (4.4) A

*5)

Input frequency of inverter FL 61.5 63.5 65.5 KHz *6)

Inverter dimming VDIM 0 -- 5 Vdc *7)

Inverter duty ratio -- 20 -- 100 % VDIM=5V(MAX.)

Inverter opening voltage Vopen 1900 -- -- Vrms

ON 2.0 -- 5 Backlight on /of control voltage OFF

VBLON 0 -- 0.8

V

BLW0 -- (120) -- W *4) Power consumption (Panel+ Backlight ) BLW -- (105) -- *5)

[Note] *1) Lamp Current measurement method (The current meter is connected to low voltage end)

Take the average of 16 CCFL’s lamp current as VDIM = 5V after power on for 30 min.

Inverter

12

12

12

12

12

12

12

HV(Blue)

HV(Blue)

HV(Blue)

HV(Blue)

HV(Blue)

HV(Blue)

HV(Blue)

HV(White)

HV(White)

HV(White)

HV(White)

HV(White)

HV(White)

HV(White)

LCD MODULE

A

A

A

A

A

A

A

A

A

A

A

A

A

A

12

HV(Blue)

HV(White)A

A

82／116

*2) Definition of the lamp life time:

When lamp luminance redue to 50% or lower than its initial value. *3) Ripple voltage that occur at the instant of power-on can’t exceed 30V. *4) 25°C; VDIM = 5V(MAX.), After power on for 5 seconds *5) 25°C; VDIM = 5V(MAX.), After power on for 30 minutes *6) Electrical and optical characterisitics color chromaticity is not included can maintain in a

range +/- 10% when the inverter operates within this frequency range.

*7) Brightness is the darkest when VDIM = 0V; Brightness is the brightest when VDIM = 5V.

83／116

4. INTERFACE PIN CONNECTION 4.1 Connector Part No.: 20389-030E(I-PEX), FI-X30SSL-HF(JAE), or compatible

Pin NO Symbol Description Note 1 VCC Power supply: +12V 2 VCC Power supply: +12V 3 GND Ground 4 GND Ground 5 RxIN0- Data- 6 RxIN0+ Data+ 7 GND Ground 8 RxIN1- Data- 9 RxIN1+ Data+

10 GND Ground 11 RxIN2- Data- 12 RxIN2+ Data+ 13 GND Ground 14 RxCLKIN- Clock- 15 RxCLKIN+ Clock+ 16 GND Ground 17 RxIN3- Data- 18 RxIN3+ Data+ 19 GND Ground 20 NC Reserved *1) 21 NC Reserved *1) 22 NC Reserved *1) 23 NC Reserved *1) 24 NC Reserved *1) 25 DE/Sync DE/Sync Option *3) 26 NC Reserved *1) 27 DMS LVDS Option *2) 28 NC Reserved *1) 29 NC Reserved *1) 30 GND Ground

*1) NC: Must let it open. *2) LVDS OPTION PIN (DMS):

DMS (Pin 27) LVDS format GND Non-JEIDA NC JEIDA

*3) DE / Sync:

DE/Syns (Pin 25) Mode NC DE

GND Sync

84／116

4.2 LVDS INTERFACE: LVDS RECEIVER: Tcon (LVDS Rx merged)

LVDS Pin JEIDA-DATA Non-JEIDA-DATATxIN/RxOUT0 R2 R0 TxIN/RxOUT1 R3 R1 TxIN/RxOUT2 R4 R2 TxIN/RxOUT3 R5 R3 TxIN/RxOUT4 R6 R4 TxIN/RxOUT6 R7 R5

TxOUT/RxIN0

TxIN/RxOUT7 G2 G0 TxIN/RxOUT8 G3 G1 TxIN/RxOUT9 G4 G2 TxIN/RxOUT12 G5 G3 TxIN/RxOUT13 G6 G4 TxIN/RxOUT14 G7 G5 TxIN/RxOUT15 B2 B0

TxOUT/RxIN1

TxIN/RxOUT18 B3 B1 TxIN/RxOUT19 B4 B2 TxIN/RxOUT20 B5 B3 TxIN/RxOUT21 B6 B4 TxIN/RxOUT22 B7 B5 TxIN/RxOUT24 Hsync Hsync TxIN/RxOUT25 Vsync Vsync

TxOUT/RxIN2

TxIN/RxOUT26 DENA DENA TxIN/RxOUT27 R0 R6 TxIN/RxOUT5 R1 R7 TxIN/RxOUT10 G0 G6 TxIN/RxOUT11 G1 G7 TxIN/RxOUT16 B0 B6 TxIN/RxOUT17 B1 B7

TxOUT/RxIN3

TxIN/RxOUT23 Reserved Reserved

85／116

4.3 INVERTER – CONNECTOR:

Connector (Receptacle): S14B-PH-SM3-TB (JST) or compatible Mating connector (Plug): PRH-14(JST) or compatible

Pin No. Symbol Description Note 1 VBL Supply Voltage 24V 2 VBL Supply Voltage 24V 3 VBL Supply Voltage 24V 4 VBL Supply Voltage 24V 5 VBL Supply Voltage 24V 6 GND Ground 7 GND Ground 8 GND Ground 9 GND Ground

10 GND Ground 11 NC NC (Test pin or else) 12 BLON ON/OFF Control (1) 13 VDIM 0V~5V (2) 14 GND GND

[Note]

*1) ON/ OFF control: ON=5V, OFF=0V; when this PIN is disconnecting with power, the Inverter is in OFF status.

*2) VDIM: MAX=5V, MIN=0V; when this PIN is disconnecting with power, the output status of Inverter is the same as VDIM＝0.

86／116

5. INTERFACE TIMING (DE only mode)

5.1 TIMING SPECIFICATION ITEM SYMBOL MIN. TYP. MAX. UNIT

Freq. fCLK 62 80 84 MHzDCLK

Cycle tCLK 14.7 12.5 11.9 ns

Line Rate fH 37.1 48.6 56 kHz

Horizontal Total Time tH 1575 1648 1936 tCLK

Horiaontal Effective Time tHA 1366 1366 1366 tCLK

Horizontal

Horizontal Blank Time tHB 209 282 570 tCLK

Frame Rate Fr 47 60 63 Hz Vertical

Total Time tV 790 810 888 tH

Vertical Effective Time tVA 768 768 768 tH

DENA

Vertical

Vertical Blank Time tVB 22 42 120 tH

Horizontal sync time tHsync --- 136 --- tCLK

Horizontal Horizontal Back porch tHBP --- 108 --- tCLK

Vertical sync time tVsync --- 5 --- tH

LCD Timing

Sync Mode

Vertical Vertical

Back porch tVBP --- 22 --- tH

[Note]

1).The best result of over-driving is in frame rate =60Hz.

87／116

5.2 TIMING CHART

a. Horizontal Timing

DCLK

DATA (R,G,B)

1 2 1365 1366 3 Invalid Data Invalid Data

tHA t HBP

First Data

Last Data

DENA

t HFP

Hsync

thsync thsync

tH=1/fH

b. Vertical Timing Chart

1 2 767 768 3 Invalid Data Invalid Data

t VFP t VBP

tvsync

tV=1/fV

tvsync

VAt

HD

LINE DATA DENA

Vsync

88／116

5.3 LVDS DATA MAPPING

a. None-JEIDA normal Specification

b. JEIDA Specification

B2 DENA Vsync HsyncB3 B3 B4 B5 B2

R1 R0 R4 R5 G0 R2 R3 R1 R0

G2 G1 B1 B0 G4 G5 G3 G2 G1

RXCLK

RXIN0

RXIN1

RXIN2

1CLK

DATA for current CLK cycle NEXT

RXIN3 R6 Preserve B7 B6 R7 R7 G6 G7 R6

PREVIOUS

B4 DENAB5 B5B6B7 B4

R3 R2 R6R7G2 R4R5 R3 R2

G4 G3 B3 B2 G6G7 G5 G4

RXCLK

RXIN1

RXIN2

1CLK

DATA for current CLK cycle NEXT

RXIN3 R0 Preserve B1 B0R1 R1G0G1 R0

PREVIOUS

VD HD

RXIN0

G3

8bit LSB: R0,G0,B0

Parallel TTL Data Inputs Mapped to LVDS outputs

89／116

5.4 LVDS INTERFACE 8bit LSB: R0, G0, B0 JEIDA: Parallel TTL Data Inputs Mapped to LVDS outputs

TRANSMITTER(THC63LVD823) INTERFACE CONNECTOR

PIN NO INPUT DATA HOST TFT_LCD TIMING CONTROLLER INPUT

51 TA0 R2

52 TA1 R3

54 TA2 R4

55 TA3 R5

56 TA4 R6

3 TA5 R7 (MSB)

4 TA6

TxOUT0+TxOUT0-

TA+ TA-

G2

6 TB0 G3

7 TB1 G4

11 TB2 G5

12 TB3 G6

14 TB4 G7 (MSB)

15 TB5 B2

19 TB6

TxOUT1+TxOUT1-

TB+ TB-

B3

20 TC0 B4

22 TC1 B5

23 TC2 B6

24 TC3 B7 (MSB)

27 TC4 Hsync

28 TC5 Vsync

30 TC6

TxOUT2+TxOUT2-

TC+ TC-

DENA

50 TD0 R0 (LSB)

2 TD1 R1

8 TD2 G0 (LSB)

10 TD3 G1

16 TD4 B0 (LSB)

18 TD5 B1

25 TD6

TxOUT3+TxOUT3-

TD+ TD-

Reserved

90／116

5.5 COLOR DATA ASSIGNMENT

[Note] 1) Definition of gray scale:

Color (n): n indicates gray scale level, higher n means brighter level. 2) Data: 1-High, 0-Low

91／116

5.6 DATA MAPPING

D( 1, 1) D( 2, 1) --- D( X, 1) --- D(1365, 1) D(1366, 1)

D( 1, 2) D( 2, 2) --- D( X, 2) --- D(1365, 2) D(1366, 2)

¦ ¦ + ¦ + ¦ ¦

D( 1, Y) D( 2, Y) --- D( X, Y) --- D(1365, Y) D(1366, Y)

¦ ¦ + ¦ + ¦ ¦

D( 1,767) D( 2,767) --- D( X,767) --- D(1365,767) D(1366,767))

D( 1,768) D( 2,768) --- D( X,768) --- D(1365,768) D(1366,768)

92／116

6. BLOCK DIAGRAM

CN2

CN3Backlight

INP

UT C

ON

NE

CTO

R

Timing

Controller

Gat

e D

river

Voltage Supply for Gray Levels

DC/DC

Converter

TFT-LCD Module

Source Driver

LCD Panel

1366 X 3 X 768

TA +/- TB +/-

TC +/- TD +/- TCLK +/-

Vin=12GND

BACKLIGHT UNIT

Lamp connector HV: BHR-02VS-1(JST)*8 or compatible Mating connector: SM02 (8.0)B-BHS-1-TB (JST) or compatible LV1: BHR-02VS-1(JST)*1 or compatible Mating connector: SM02 (8.0)B-BHS-1-TB (JST) or compatible

LV1

HV

93／116

7. MECHANICAL SPECIFICATION

7.1 FRONT SIDE ( include Inverter, if the dimension did not to eerance, please refer to the table.) [Unit: mm]

94／116

7.2 REAR SIDE ( include Inverter, if the dimension did not to eerance, please refer to the table.) [Unit: mm]

Pin

no:

30…

..1

Pin no:14….....1

95／116

8.OPTICAL CHARACTERISTICS Ta = 25°C, VCC=12V

ITEM SYMBOL CONDITION MIN. TYP. MAX. UNIT REMARKS

Contrast (CEN) CR θ=ψ﹦0°Point-5

700 1000 -- -- *1)*2)*3)

Central luminance Lwc θ=ψ﹦0° 450 550 -- cd/m2 *9)

5P Luminance

(AVG) Lw9 θ=ψ﹦0° -- 500 -- cd/m2 *2)*3) Luminance

Uniformity Lw θ=ψ﹦0° 75 -- -- % *2)*3)

tr θ=ψ﹦0° -- 10 (17) ms *3)*4) Response Time ( White – Black ) tf θ=ψ﹦0° 6 (8) ms *3)*4)

Response Time (Gray to gray average) trg, tfg 　 -- 10 (15) ms *5)

Image sticking tis 4 h -- -- (3) sec *6)

Horizontal ψ -80~80 -85~85 -- ° *2)*3) View angle

Vertical θ CR 10≧Point-5 -80~80 -85~85 -- ° *2)*3)

Crosstalk Ratio CMR θ=ψ﹦0° -- -- (1) % *3)*7)

Red Rx Ry TBD TBD TBD

Green Gx Gy TBD TBD TBD

Blue Bx By TBD TBD TBD

Color Chromaticity

White Wx Wy

θ=ψ﹦0°Point-5

TBD 0.283 0.297 TBD

-- *2)*3)

Color Temperature Tc -- 9300 -- K *3)

Color Gamut CG -- 75 -- % *8) [Note]

These items are measured using: BM-5A (TOPCON) View angle: EZ contrast XL-88, Response Time: Westar TRD-100 [ under the dark room condition (no ambient light).]

96／116

Definition of these measurement items is as follows: *1) Definition of Contrast Ratio:［These items are measured using BM-5A (TOPCON) under the

dark room condition (no ambient light).］

CR=ON (White) Luminance/OFF (Black) Luminance *2) Definition of Luminance, Luminance uniformity, Contrast, and the Deviation of Color

Coordinate:

Luminance and Contrast: To measure at the center position “5” on the screen (NO.5), see Figure.8-1 below.

Luminance uniformity: Lw (MAX) and Lw(MIN) are the maximum and minimum luminance value measure at the position “1~5” on the screen (NO.1~5), see Figure.8-1 and below show equation: ΔLw＝[ (Lw(MIN)) / Lw(MAX) ] × 100%

The Deviation of Color Coordinate: To measure at the position “1~5” on the screen (NO.1~5), see Figure.8-1 below.

1 2

5

3 4

(1,1)

192

384

576

341.5 683 1024.5

(1366,768)

Figure 8-1. Measurement Positions

97／116

*3) Definition of Viewing Angle ( θ, ψ ):

Figure 8-2. Definition of Viewing Angle

*4) Definition of Response Time ( White – Black )

Luminance

90%90%

10%tftr

White(255th)

Black(0)10%

Figure 8-3. Definition of Response Time ( White – Black )

*5) Definition of Response Time ( Gray to Gray, Average )

Luminance

90%90%

10%tfg trg

(Gray Scale Level)

(0~255th)

(0~255th) 10%

Figure 8-4. Definition of Response Time (Gray to Gray )

98／116

The driving signal time means the signal of gray level 0, 31, 63, 95, 127, 159, 191, 223, 255. Gray to gray average means the average switching time of gray level 0, 31, 63, 95, 127, 159, 191, 223, 255 to each other. The LCD module should be stabilized at given temperature for 1 hour to avoid abrupt temperature change during measuring. In order to stabilize the luminance, the measurement should be executed after lighting Backlight for 1 hour in a windless room.

*6) Image Sticking Test Method: Continuously display the test pattern shown in the figure below for specified time. To change the module frame to gray pattern ( gray 120 pattern ), and it’s displaying grade still under specfication.

‧ ‧ ‧ ‧ ‧

3 0 - P i x e l ‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧ ‧

‧ ‧ ‧ ‧ ‧

W h ite B l o c k( 2 5 6 G L )3 0 - P i x e l

B la c k B a c k g ro u n d( 0 G L ) 3 0 - P i x e l

Figure 8-5. The Pattern of Image Sticking Test

99／116

*7) Definition of Cross talk Ratio

CMR = MAX ( ( | ( LB1-LA ) / LC | ) × 100﹪, ( | (LB2 – LA ) / LC | ) × 100﹪ ) LA: Pattern A (Half-Tone pattern) Measure point Luminance LB1, LB2: Pattern B1, Pattern B2 Measure point Luminance LC: Pattern C (white pattern) Measure point Luminance

(1366,768)

(1195,384)

measurement point

(1024,576)

White

Gray127

Black

Gray 127

(0,0)

(683,672)

(171,384)

(341,192)

Pattern A

Pattern B1

Pattern B2

Pattern C

Gray 127 White

(683,96)

Figure 8-6. The Pattern of Cross talk Test

*8) Definition of Color Gamut: To measure RGB three sub-pixels color gamut coordinate at CIE coordinate chart from the center of module, to form a triangle area = ARGB. RGB three sub-pixels of NTSC at CIE coordinate chart to form a triangle area = NRGB.

ARGB

NRGB

CG = × 100

*9) Definition of Central luminance:

After lighting on the panel for 30 mins, then the Central luminance test proceeded. The definiton of TYP value is under status of Inverter Dimming Voltage=5V.

100／116

9.RELIABILITY TEST CONDITIONS 9.1 TEMPERATURE AND HUMIDITY

TEST ITEMS CONDITIONS

High Temperature Operation 50 ; 240hrs

High Temperature Storage 60 ; 240hrs High Temperature

High Humidity Operation 50 ; 90% RH; 240 hrs

(No condensation) Low Temperature Operation 0 ; 240 hrs

Low Temperature Storage -20 ; 240 hrs 9.2 SHOCK AND VIBRATION

ITEMS CONDITIONS

Shock (Non-Operation)

Shock level: 980m/s2 (100G) Waveform: half sinusoidal wave, 2ms Number of shocks: one shock input in each direction of three mutually perpendicular axes for a total of six shock inputs.

Vibration (Non-Operation)

Vibration level: 9.8m/s2 (1.0G) zero to peak Waveform: sinusoidal Frequency range: 10 to 300 Hz Frequency sweep rate: 0.5 octave/min Duration: one sweep from 10 to 300Hz in each of three mutually perpendicular axis (each x, y, z axis:10 min, total 30mins)

9.3 JUDGMENT STANDARD

The judgment of the above test should be made as follow: Pass: Normal display image with no obvious non-uniformity and no line defect.

Partial transformation of the module parts shall be ignored. Fail: No display, obvious non-uniformity, or line defects.

101／116

10. PACKAGING 10.1 PACKING SPECIFICATIONS

(1) 3 LCD TV modules/1 Box (2) Box dimensions: 975(L) x 375(W) x 562(H) (3) Weight: approximately 31.9kg (3 modules per box)

10.2 PACKING METHOD

Figure 1 and Figure 2 are the packing method.

Figure 1 Packing Method

EPE FOAM

32〞MODULE (3PCS)

CARTON

CARTON LABEL

EPE PAD BOTTOM

102／116

(1) Corner protector: L1125 x 50mm x 50mm (2) Pallet: L1000 x W1150 x H130mm (3) Bottom Cap: 1000 x W1150 x H130mm (4) Pallet Stack: 1000 xW1150 x H1250mm (5) Gross: 273kg

Fiqure2 packing method 總計 :6 箱 pallet:10kg

Fiqure2 packing method

Carton label

Figure 2 Packing Method

103／116

11. HANDLING PRECAUTIONS FOR TFT-LCD MODULE

Please pay attention to the followings in handling TFT-LCD products. 11.1 ASSEMBLY PRECAUTION

(1) Please use the mounting hole on the module side in installing and do not beading or wrenching

LCD in assembling. And please do not drop, bend or twist LCD module in handling.

(2) Please design display housing in accordance with the following guidelines.

• Housing case must be destined carefully and do not to put stresses on LCD all sides or wrench module. The stresses may cause non-uniformity even if there is no non-uniformity statically.

• Keep sufficient clearance between LCD module back surface and housing when the LCD module is mounted. Approximately 1.0 mm of the clearance in the design is recommended taking into account the tolerance of LCD module thickness and mounting structure height on the housing.

• When some parts, such as, FPC cable and ferrite plate, are installed underneath the LCD module, still sufficient clearance is required, such as 0.5mm. This clearance is, especially, to be reconsidered when the additional parts are implemented for EMI countermeasure.

• Design the inverter location and connector position carefully so as not to put stress on lamp cable.

• Keep sufficient clearance between LCD module and the other parts, such as inverter and speaker so as not to interface the LCD module. Approximately 1.0mm of the clearance in the design is recommended.

(3) Please do not push or scratch LCD panel surface with any-thing hard. And do not soil LCD panel surface by touching with bare hands. ( Polarizer film and surface of LCD panel are easy to be flawed.)

(4) Please do not press any parts on the rear side such as source TCP, gate TCP, control circuit board and FPC during handling the LCD module. If pressing rear part could not be avoided, handle the LCD module with care not to damage them.

(5) Please wipe out LCD panel surface with absorbent cotton or soft clothe in case of it being soiled.

(6) Please wipe out drops of adhesives like saliva and water on LCD panel surface immediately. They might damage to cause panel surface variation and color change.

(7) Please do not take a LCD module to pieces and reconstruct it. Resolving and reconstructing modules may cause them not to work well.

(8) Please do not touch metal frames with bare hands and soiled gloves. A color change of the metal frames can happen during a long preservation of soiled LCD modules.

104／116

(9) Please pay attention to handling lead wire of backlight so that it is not tugged in connecting with inverter.

11.2 OPERATING PRECAUTIONS (1) Please be sure to turn off the power supply before connecting and disconnecting signal

input cable.

(2) Please do not change variable resistance settings in LCD module. They are adjusted to the most suitable value. If they are changed, it might happen LCD does not satisfy the characteristics specification.

(1) Please consider that LCD backlight takes longer time to become stable of radiation characteristics in low temperature than in room temperature.

(2) A condensation might happen on the surface and inside of LCD module in case of sudden change of ambient temperature.

(3) Please pay attention to displaying the same pattern for a very long time. Image might stick on LCD. If then, time going on can make LCD work well.

(4) Please obey the same caution descriptions as ones that need to pay attention to ordinary electronic parts.

11.3 PRECAUTIONS WITH ELECTROSTATICS

(1) This LCD module use CMOS-IC on circuit board and TFT-LCD panel, and so it is easy to be affected by electrostatics. Please be careful with electrostatics by the way of your body connecting to the ground and so on.

(2) Please remove protection film very slowly on the surface of LCD module to prevent from electrostatics occurrence.

11.4 STORAGE PRECAUTIONS

(1) When you store LCD for a long time, it is recommended to keep the temperature between 0 ~40 without the exposure of sunlight and keep the humidity less than 90%RH.

(2) Please do not leave the LCD in the environment of high humidity and high temperature such as 60 90%RH.

(3) Please do not leave the LCD in the environment of low temperature(can not lower than -20).

11.5 SAFETY PRECAUTIONS

(1) When you waste LCD, it is recommended to crush damaged or unnecessary LCD into pieces and wash them off with solvents such as acetone and ethanol, which should later be burned.

(2) If any liquid leaks out of a damaged-glass cell and comes in contact with the hands, wash off thoroughly with soap and water.

105／116

11.6 OTHERS

(1) A strong incident light into LCD panel might cause display characteristics' changing inferior because of polarizer film, color filter, and other materials becoming inferior. Please do not expose LCD module direct sunlight Land strong UV rays.

(2) Please pay attention on the side of LCD module do not contact with other materials in preserving it alone.

(3) For the packaging box, please pay attention to the followings:

• Packaging box and inner case for LCD are designed to protect the LCD from the damage or scratching during transportation. Please do not open except picking LCD up from the box.

• Please do not pile them up more than 3 boxes. (They are not designed so.) And please do not turn over.

• Please handle packaging box with care not to give them sudden shock and vibrations. And also please do not throw them up.

• Packing box and inner case for LCD are made of cardboard. So please pay attention not to get them wet. (Such as keep them way the high humidity or wet place.)

106／116

107／116

!

"#$" %&'#($)"$*+$,-*./

"0 "$#$"#$ /1213 &( #$' "

0 $#,#$ 2.41/ &5$"'#( $ "

0 .6$"#$+"$

/.(1.1/1 $$"% %77 .8($%6%&51*'

*./2

" .

70 66".6$#$" 28(#($41/6 " .

0 66"6$"#$" ./2841/6 " .

+0 66"7"$#$" ./28 " .

60 $$#$#$"* 2.4/12 .* "

0 $##$"* 2.2 2 "

90 $+#$"#$"/* . ./2.2 2 / "

"$0 +9#7$"#$" /.(1./..*.. "

""0 66#""#$" 41 .8&(./:2 ' "

"0 $$#"7#$ 1841(1 "

"0 $$#"#$ 1841(211( "

"70 "$#"""7$7#$6* 182;""%3"7%3$<$74* "

"0 "$#7$#$6* 2;(4(7%3%3$<(( "

"+0 7#$#$", *,..41/15./$3"$3$<, "

"60 7#$#$", *,..41/ .8 "

"0 6#$"#$", (1.. , "

"90 7+#$#$" 15./1/2/ .8 "

$0 7+#2$2#$" ./(,..($* "

"0 7"#2$+#$" ,.;211(($ "

0 7"#$"#$" ,.21341/15./ "

0 7#2#$" ,.;1*./ "

70 7+#("""#$" (..( "

0 "#$$$#$" 4../$$33$<(( 7

+0 #7"$"#$" ( ;./ "

60 $#"$$$#" 422./5,./"$<$3<3"<((5,.*. 7

0 +#""9# ./1<2. "

90 +#7+$#$ 5/;2.;74 "

$0 69#7"$#$9 ./12/1.2.7" "

"0 69#7"$#$ 11442.;7" "

0 69#7"$#$" /1.*../,2.41/.7" "

0 69#6$9#$" 12..; "

108／116

!

70 69#$#$ 2.

0 9$#$"#$ 5//8/ "

+0 9#$"#$ ./1/( $ "

60 .7$7#"6$$9 1/"<(41/($ "

0 .7"#97$$9 5/.8"$

90 .7"#9"6 5/.8=#8+$ #/($ "

7$0 .7"#9"9 5/.8"$<41/($6%15./9*"* "

7"0 .7"#9"$ 5/.8",<9+# +$"$41/%6%

70 .7"#9" 5/.8=#8+$ #($ "

70 .7"#9+""9 5/.8<$>"*4 "

770 .7"#9+" 5/.8<777$$(((7*.(($ "

70 .7+"#$+7$ 5/.8<667$$((*2815./($41/6%% "

7+0 .7+"#$+7$7$ 5/.8<$"7<$<7$$((6$$((*././($ "

760 .76"#$$$$77 5/.5,.5/.41/1(21(1 .8") "

70 .76"#$$"$$ 5/.5,."<$$>$41/6% "

790 .7"$"#$6$$" 5,15(/##22#4/1 . "

$0 .7$"#"7$$" . ./1,("$5%86#"

"0 .7$#$"7$$" 5.../+1,("$5%8#"

0 .+$#$ 8%53;$5$""++36+$( "

0 .6$"#$"$$$ 2./8/$"<*?0

70 .6$"#$$$

2821/(.;(..("+941/""$#7$*1

"**7*$5

" .

0 67#$#$" 2.8$"511;151 ;*./ " .

+0 66"26$"#$" //..*.2841/6 " .

60 66" 6$"#$" .82841/6 " .

109／116

Software Upgrade

Process of update MT8202

Preparing : 1． Connect RS232-VGA download line, One connector is connected to VGA connect port of

Plasma TV ,while another side is connected to PC COM port. 2． Store the MtkTool into the PC .

Downloading : 3．Turn on AC power switch of the Plasma TV and then press the button “standby” of the remote

control . The image could be found on the screen of the Plasma TV while the color of the power indicator is green . (the mode of the Plasma TV will be standby mode if after turn on the main power switch only . )

4． Execute MTKtool and select the chipset as MT8202. (the software of MTKtool will be sent to your side)

5． Select current COM port. (please try to check the COM port of your PC).

110／116

6．Choose the bit rate as 115200. 7．Select the update binary by pressing browse button. For exemple,the binary file name is

PDP4210EA1_V09.bin. (this update firmware will be sent to your side)

8． Press Upgrade button and start update process.

111／116

9．The update process is successful as the progress bar is 100%. After the update process is ok,

112／116

turn off power and wait indicator light is off. Turn on power and TV can work.

Checking It is needed to check the version of the firmware for MT8202 which has been

download into the Plasma TV . Press Menu button of the remote control，following input “8202”of the remote

control and OSD menu for Factory Setting is appeared on the screen . Use the remote control and select the mode of Firmware Version and then enter the

mode of Firmware Version . It is easy to be found the version of the current firmware for MT8202 is as the following : “Factory ID : PDP4210EA1_VXX ”

Process of update MT5351AG

Preparing : 1．Connect RS232 download line, One connector is connected to RS232 connect port of Plasma

TV ，while another side is connected to PC COM port. 2． Store the MtkTool into the PC

Downloading : 3．Turn on AC power switch of the Plasma TV and then press the button “standby” of the remote

control . The image could be found on the screen of the Plasma TV while the color of the power indicator is green . (the mode of the Plasma TV will be standby mode if after turn on the main power switch only . )

4．Execute MTKtool and select the chipset as MT5351AG. (the software of MTKtool will be sent to your side)

113／116

5．Select current COM port. (please try to check the COM port of your PC).

6．Choose the bit rate as 115200. 7．Select the update binary by pressing browse button. For exemple,the binary file name is

114／116

XXXX_PDP4210EA1_000000XX_X_P.bin. (this update firmware will be sent to your side)

8．Press Upgrade button and start update process.

115／116

9． The update process is successful as the progress bar is 100%. After the update process is ok, turn off power and wait indicator light is off. Turn on power and TV can work.

Checking : It is needed to check the version of the firmware for MT5351AG which has been

download into the Plasma TV . Press Menu button of the remote control and the main OSD menu is appeared on

the screen . Use the remote control and select the DTV menu . following input “0000” (zero ,

zero , zero , zero) of the remote control .Then enter the mode of factory after input the digits .

It is easy to be found the version of the current firmware for MT5351AG is “PDP4210EA1 CLA_QAM_XXXXXX_XX”under the mode of factory .

116／116

Documents

Akai Lct3285ta