Upload
others
View
7
Download
0
Embed Size (px)
Citation preview
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 1 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
ViewSonic Corporation
DPX704WH/BK/RW - Digital Photo Frame
Engineering Specification
Document # SPEC_DPX704WH/BK/RW
Revision # 2.0
Date: June 18, 2008
Approved
ViewSonic Corporation Mustek
Date Date
ViewSonic
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 2 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
New Products Development Department
SPECIFICATION APPROVAL & VERIFICATION
Originating date: 2008/6/18 Total Attachments: 0
Sr. Product Engineer: ________________________ Date: _____________
Nick Lee
Director of DTV BU: ______________________ Date: _____________
Thomas Hung
Mustek Sign Off: Date:
Signed Name
Print Name
Title
Mustek Sign Off: Date: Signed Name
Print Name
Title
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 3 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
TABLE OF CONTENTS
1 REVISION HISTORY...................................................................................................4
2 DISCLAIMER...............................................................................................................5
3 CONFIDENTIALITY.....................................................................................................5
4 TRADEMARKS ...........................................................................................................5
5 INTRODUCTION .........................................................................................................6
6 THE INTENT OF THIS DOCUMENT...........................................................................6
7 RELATED DOCUMENTS............................................................................................6
8 GENERAL REQUIREMENTS......................................................................................7
9 STANDARD TEST CONDITIONS ...............................................................................9
10 INPUT SIGNAL INTERFACE ......................................................................................9
11 INPUT SIGNAL CHARACTERISTICS ......................................................................10
12 POWER .....................................................................................................................13
13 LCD PANEL ..............................................................................................................14
14 KEY COMPONENTS.................................................................................................14
15 CONTROLS AND INDICATORS...............................................................................15
16 IMAGE PERFORMANCE ..........................................................................................17
17 AUDIO SUBSYSTEM................................................................................................18
18 STARTUP SCREEN..................................................................................................18
19 VS OSD SETTING.....................................................................................................18
20 ENVIRONMENTAL....................................................................................................21
21 PACKAGING.............................................................................................................22
22 MECHANICAL...........................................................................................................23
23 MANUALS AND DOCUMENTATION .......................................................................24
24 REGULATORY AND SAFETY:.................................................................................24
25 RELIABILITY (MTBF) ...............................................................................................25
26 REMOTE CONTROL.................................................................................................25
27 LABEL.......................................................................................................................27
28 SHIPPING..................................................................................................................30
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 4 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
1 Revision History
Date Revision Changes and additions By
03/06/08 0.1 1. Initial draft Nick Lee 03/17/08 0.2 2. Spec. updated and add label information Nick Lee
03/18/08 0.3 3. Spec. updated Nick Lee
03/19/08 0.4 4. Spec. updated Nick Lee 03/21/08 1.0 1.0 Release Nick Lee
06/18/08 2.0 2.0 Release: Increase the part for DPX704BK, and DPC804BK Nick Lee
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 5 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
2 DISCLAIMER ViewSonic Corporation shall not be liable for technical or editorial errors or omissions contained herein; nor for the incidental or consequential damages resulting from the furnishing, performance, or use of this material ViewSonic Corporation reserves the right to change any or all specifications without notice. Information in this document may change without notice.
3 CONFIDENTIALITY All material contained within this document is proprietary information and the sole property of ViewSonic Corporation, 381 Brea Canyon Rd, Walnut, California, USA. No part of this document may be copied, reproduced, or transmitted by any means, for any purpose without prior written permission from ViewSonic Corporation
4 TRADEMARKS
Product or corporate names may be trademarks or registered trademarks of their respective companies and are used herein for identification and to the owner’s benefit, without intent to infringe. ViewSonic is a registered trademark of ViewSonic Corporation. VESA is a registered trademark of the Video Electronics Standards Association. DPMS is a trademark of the Video Electronics Standards Association. DDC is a trademark of the Video Electronics Standards Association. Copyright © ViewSonic Corporation, 2008 All rights reserved.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 6 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
5 INTRODUCTION
The Digital Photo Frame is function for digital image data storage and photo slide show on product screen by TFT LCD.
DPX704 Industrial Design
6 THE INTENT OF THIS DOCUMENT This document is intended to be a detailed “System Level” specification that details the system, performance, and configuration of the entire system. In case of specification conflict with multiple ViewSonic specification, the specification of the component or system shall override this specification.
7 RELATED DOCUMENTS
(For REFERENCE ONLY) The following specifications are related to this product, and further detail each subsystem. The “Latest” version as determined by filename, version number shall be considered gospel.
# TITLE
1 CPT 7” WVGA TFT LCD panel specification, spec. # CLAA070LC02CW
2 Main chip specification, spec. # Amlogic 6213D
3 128MB Flash memory specification, spec. # HY27UF081.pdf
4 ViewSonic Packaging Specification, V1.7, spec # VSC-PACK-SPEC-003
5 ViewSonic Pallet Load & Packaging Specication, spec # PALLET_SPEC
6 ViewSonic Molded Plastic Part Specification, spec # VSCMPPSPEC001, Revision #1.2
7 ViewSonic Molded Bezel Graphics Spec, spec # VSC_S_299
8 ViewSonic LABEL, BARCODE SPEC, 1.H, spec # VSC_DWG_158
9 ViewSonic Engineering Change Procedure, spec # VSC_PRO_ECR-ECN
10 ViewSonic Product Quality Acceptance Criteria, spec # VSC-QCXXX-V0.9
11 Signed CLAA070LC02CW - 3 sides acceptance panel specification
14 Gravity sensor specification, spec. # NTE SV-200DF
15 128Mb SDRAM memory specification, spec. # Z2V28S20/30/40BTP
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 7 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
8 GENERAL REQUIREMENTS
8.1 SYSTEM DEFINITION
The “SYSTEM” shall be defined as everything the user cans directly ‘touch’, or behavior which can be directly ‘observed’ and measured. Components / Modules / Systems internal to the system are beyond the scope of the “System” and instead are covered by their respective individual specification.
8.2 GENERAL CONFIGURATION / PROJECT ASSIGNMENTS
This specification defines the configuration and performance requirements for the following products
Product Name (Model) DPX704WH DPX704BK DPX704WH
Frame Color White White White
Carry Region VSA, VSE, VSI VSA, VSE, VSI VSA, VSE, VSI
Model Number VS12207 VS12207 VS12207
UPC Code 76690731521 9 76690732182 1 76690732651 2
Serial Number Format R13 YYWWxxxxx R2N YYWWxxxxx R3U YYWWxxxxx
USB Vendor ID 0543 (Hex) 0543 (Hex) 0543 (Hex)
USB Product ID 21C3 (Hex) 21C3 (Hex) 21C3 (Hex)
Compliance
FCC, ETL, CE, CB, BSMI, C-Tick, GOST,
PSE, CCC
FCC, ETL, CE, CB, BSMI, C-Tick, GOST,
PSE, CCC
FCC, ETL, CE, CB, BSMI, C-Tick, GOST,
PSE, CCC
Origin Made in China Made in China Made in China
Region Packaging VSI VSA VSE
OSD Language
English, French, German, Spanish, Italian, Portuguese, Dutch, Russian, T-
Chinese, S-Chinese
English, French, German, Spanish, Italian, Portuguese, Dutch, Russian, T-
Chinese, S-Chinese
English, French, German, Spanish, Italian, Portuguese, Dutch, Russian, T-
Chinese, S-Chinese
Safety logo on label
FCC, ETL, CE, CB, BSMI, C-Tick, GOST,
PSE, CCC
FCC, ETL, CE, CB, BSMI, C-Tick, GOST,
PSE, CCC
FCC, ETL, CE, CB, BSMI, C-Tick, GOST,
PSE, CCC
QSG
English, French, Spanish, T-Chinese,
Korean
English, French, Spanish, T-Chinese,
Korean
English, French, German, Italian,
Spanish, Russian
Firmware version
DPX704WH, VS1a.A01, 2008/03/21 Or later
DPX704WH, VS1a.A01, 2008/03/21 Or later
DPX704WH, VS1a.A01, 2008/03/21 Or later
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 8 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
8.3 PRODUCT DEFINITION
TOP LEVEL ASSEMBLY: STANDARD
CONFIGURATION
The Top Level Assembly shall consist of : 1. ViewSonic Digital Photo Frame 2. Cable Package
a. AC/DC Power Adaptor 1.8M x 1 (VSA & VSI) * b. Universal (100V~240V) Power Adaptor x 1 (with EU & UK head for
VSE) 3. Quick Start Guide (English, French, Spanish, German, Italian, Russian,
Korean and Traditional Chinese) *Applicable power cord is shipped with the DPF to the point of destination.
8.4 MASS PRODUCTION RELEASE
Mass Production Approval Mass Production (MP) shall not begin until ViewSonic has issued a signed Mass Production Release Document.
Component Approvals All exterior plastic components, screen printed components, labels, shipping cartons, protective foam, diskettes, CD-ROMs, and printed material require approval from ViewSonic prior to MP Release.
Product Unit Serialization The S/N for each unit is unique and must provide tracability. For each product unit produced it is required that the S/N loaded on the units EDID (electronic S/N) code must agree with the information on Rating Label and the UPC label affixed on the Carton Box.
Demonstrated Reliability Prior to Mass Production Release, it is required that demonstrated MTBF to be greater than 50K hours using a combination of DVT and PVT units after the test reached to 20K hours, the finished good can be shipped out. A minimum of n=5 units is required for this test.
8.5 CHANGE CONTROL
Engineering Change Orders ALL Engineering changes to the product, regardless of how minor, shall be approved in writing by ViewSonic and processed per the current change control procedure. There are no exceptions to this rule, unless an emergency situation exists, thereby requiring VS verbal approval then followed by official document approval.
8.6 SERVICE
Documentation / Service Manual
Bills of Material, RSPL (Recommend Spare Parts List), Schematics, Service Manual, and Assembly Drawings shall be provided within one month of Mass Production Release. Vendor shall provide in depth Service Training of the product and coordinate agreed schedule prior to MP release.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 9 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
9 STANDARD TEST CONDITIONS
Warm Up Period 30 Minute Warm-Up
Ambient Light Dark room for Optical Test
Ambient Conditions Ambient Temp = 25°C, Humidity = 60% Image Size Full screen window for brightness and contrast measurement
Input Signal Source N.A.
Input Signal Timing N.A.
Brightness Controls Be adjusted by user (UI)
Test Patterns “Display Mate” (or equivalent) Flat White, Blue, Green, Red Color Bar Gray Scale
Viewing Distance 35 cm
Instrumentation CA210 or equivalent Additional or Other Equipment is acceptable, Providing, agreed “Conversion” Tables have been worked out in advance of any such measurement.
10 INPUT SIGNAL INTERFACE Input Signal Interface Slot1, Slot2, USB interface
Slot1 • CF (Type I&II)
Slot2 • SD, SDHC, MMC, xD, MS and MS Pro USB Interface • USB 2.0 (Slave)
Compatible File Format Photo:
• JPEG: JPEG Baseline (4:4:4/4:2:2/4:2:0), W/O Progressive JPEG
• BMP: MS Windows V3.1/4/8/16/24 uncompressed Bitmap Note: There is a limitation of file size. The width of BMP must be bigger than 16 pixels and the height must be bigger than 12 pixels. The file size must be smaller than 4 MB file. Audio & Video:
Video Audio
M-JPEG (Up to VGA) MP3,
MPEG1 (.dat/.mpeg/.mpg)
Divx 3/4 (.avi) MPEG4
Xvid (.avi)
Maximum Compatible File Size
• JPEG: 8000x8000 pixels
• BMP: 1024x1024 pixels Photo Capacity: Thumbnail mode: 4000 photos (Maximum) Slideshow mode: 4000 photos (Maximum)
• M-JPEG: Up to VGA (640x480 pixels), 2.8Mbps
• MPEG1: Up to CIF (352x288 pixels), 1.5Mbps
• MP4 (Divx): Up to D1 (720X480 pixels), 2.8Mbps, MPEG4 SP only
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 10 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
11 INPUT SIGNAL CHARACTERISTICS CF
Format Type I & II
Standard CF+ and Compact Flash Specification Revision 2.01 True IDE-Mode
Operation Voltage / Current 3.3V/150mA
Frequency MDMA Mode 2/PIO Mode 4 – 16.6MB/s (Burst)
Compatible Transmission Speed Compatible with 150X for RIDATA
Compatible Card Size 8GB max.
Connector CF (male) x 1
Pin Assignments for 29 pin CF Connector CF_D[15:0], CF_CS_N[1:0], CF_A[2:0], CF_IOW_N, CF_IOR_N, CF_INTRQ, CF_IORDY, CF_DMARQ, CF_DMACK, CF_RST_N and CF_CD_N
MMC
Format 1-bit MMC/4-bit MMC
Standard The MultiMedia Card System Specification Version 4.0
Operation Voltage / Current 2.7V to 3.6V
Frequency 52MHz for High-Speed and 20MHz for Normal
Compatible Transmission Speed 200X for A-Data
Compatible Card Size 1GB max. Connector Four in One Card Reader Socket
Pin Assignments for 7 pin MMC Connector 1.CS 2.Din 3.VSS1 4.VDD 5.CLK 6.VSS2 7.Dout xD
Format Standard, H and M-Type
Standard xD-Picture Card Card Specification Version 1.20
Operation Voltage / Current 3.0V to 3.6V/40mA(Max)
Frequency 12.5MB/s (Burst Due to 80ns Timing)
Compatible Transmission Speed
Standard Below 64MB : R-1.3MB/s and W-5MB/s
Standard Exceed 64MB : R-3MB/s and W-5MB/s
M-Type : R-2.5MB/s and W-4MB/s
H-Type : R-4MB/s and W-5MB/s
Compatible Card Size 2GB max. Connector Four in One Card Reader Socket
Pin Assignments for 16 pin MMC Connector XD_RB_N, XD_RE_N, XD_CE_N, XD_CLE, XD_ALE,
XD_WE_N, XD_WP_N, XD_D[7:0] and XD_CD_N
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 11 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
MS
Format MS/MS Duo
Standard Memory Stick Standard
Operation Voltage / Current 3.3V/100mA(Max)
Frequency 20MHz
Compatible Transmission Speed 10MB/s (Burst at Peak)
Compatible Card Size 4GB max.
Connector Four in One Card Reader Socket
Pin Assignments for 7 pin MMC Connector MS_SCLK, MS_BS, MS_D[3:0] and MS_INS MS Pro
Format MS Pro/MS Pro Duo
Standard Memory Stick Standard
Operation Voltage / Current 3.3V/100mA(Max)
Frequency 40MHz
Compatible Transmission Speed 20MB/s (Burst at Peak)
Compatible Card Size 4GB Connector Four in One Card Reader Socket
Pin Assignments for 7 pin MMC Connector MS_SCLK, MS_BS, MS_D[3:0] and MS_INS SD
Format SDHC
Standard SD Specification Version 2.00
Operation Voltage / Current 2.0V to 3.6V/100mA(Max)
Frequency 25MHz for Normal and 50MHz for High-Speed
Compatible Transmission Speed 150X for RIDATA
Compatible Card Size 4GB
Connector Four in One Card Reader Socket
Pin Assignments for 9 pin SD Connector 1.Det/D03 2.CMD 3.VSS 4.VDD 5.CLK 6. VSS 7.D00 8.D01
9.D02
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 12 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
USB
Format USB 2.0 Device
Standard USB 2.0 Specification Revision 1.0a
Operation Voltage / Current 5V/500mA
Frequency 480Mbit/s
Compatible Transmission Speed 60MB/s (device) 1.5MB/s(host)
Connector Mini-AB USB A type
Pin Assignments for 4 pin Connector 1.Vbus 2.D+ 3.D- 4.GND Detection Time for all inputs
5 Seconds (Max) for start screen 5 Seconds (Max) 3 Second (Typ) for recognized resolutions.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 13 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
12 POWER
12.1 Power Supply
Input Voltage Range AC Adapter
Input : 100 ~ 240VAC Wide Range (Auto Switching) Output:12VDC
Input Frequency Range 50/60Hz
Inrush Current (Cold Start) < 80A @ 240VAC
Short Circuit Protection Secondary outputs can be shorted without damage
Efficiency 70% min. at 100VAC to 240 VAC Rated Load
Leakage Current <0.25mA
Operation Standby Power Dissipation
Adapter Typical: 4W Maximum: 10W
Maximum: 4W at 240Vac
Fuse AC adapter only :1A 250V
Power Supply Cold Start Shall start and function properly when under full load, with all combinations of input voltage, input frequency, and operating temperature.
Power Supply Transient Immunity
Shall be able to withstand EN 55022 CLASS B with no damage.
Power Supply Line Surge Immunity
1KV
Power Supply Missing Cycle Immunity
10ms typ
12.2 Power Interface
Power Connector US/ UK/ AU/ EU type
Power Cable Length 1.8 meters
Power Cable Color Black
Power Cable Types Wall Mount Type: - US: NEMA 1-15P - EU: EN50075 - UK: BS1363 - China: GB1002-96
* Applicable power cord is shipped with the unit to the point of destination
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 14 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
13 LCD PANEL ** For official specification, please refer to panel specification CPT Panel
Type CLAB070LC02CW
Number of Pixel 800 x 480
Pixel Pitch 0.1905 (H), 0.1905 (V) mm
Effective Display Area (without interchangeable frame) 152.4 (W) x 91.44(H) mm
Aspect Ratio 16:9
Surface Treatment Anti-Glare
Color Arrangement RGB stripe
Luminance 220 cd/m2 (Typ) 180 cd/m2 (Min)
Contrast 300:1 (Typ) 220:1 (Min)
Response Time Total = 20ms (Max)
Color Depth 262k colors
Viewing Angle
CR>10:1
(Typ): Vertical = 100°, Horizontal = 140°
(Min): Vertical = 80°, Horizontal = 120°
Color Coordinates
White: x = 0.295 ± 0.04; y = 0.329 ± 0.04
Red: x = 0.544 ± 0.04; y = 0.339 ± 0.04
Green: x = 0.330 ± 0.04; y = 0.575 ± 0.04
Blue: x = 0.154 ± 0.04; y = 0.130 ± 0.04 Backlight LED
Luminance Characteristic over Time (LED) 10,000Hrs = 50% cd/m2
Rated Life (LED) 10000 Hrs
14 Key Components
** For official specification, please refer to chipset maker’s engineering specification Processor Amlogic; AM6213D
SDRAM 128Mb
Flash Storage 128MB
Battery N/A
Gravity sensor NTE SV-200D
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 15 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
15 CONTROLS AND INDICATORS 15.1 CONTROL INTERFACE
Main Power Switch NA
Power Controls Power On/Off (Standby)
Panel LED N/A
Control Key
Power Power On / Off
Mode Display the mode bar
Pervious/Up
Next/Down
Stop/Exit Stop / Exit
Play/Ok Play / Ok
Reaction Time OSD must fully appear within 0.5s after pushing Button 1 times;But
the slideshow and slideshow+MP3 is based on the image size.
Remote control Distance:5M
Angle:±15∘
15.2 VIDEO CONTROLS
Control Type Digital with an OSD.
OSD Controls Language: English, French, German, Spanish, Italian, Portuguese, Dutch, Russian, T-Chinese, S-Chinese OSD Display (Top bar icon): Clark, Calendar, Photo, Music, Video, Music Slideshow, Browser, Setting
OSD firmware Version of PVT Unit
FW version: DPX704WH, VS1a.A01, 2008/03/21 Please send us ECR for VS approval, if you upgrade the firmware after MP.
Saving Settings The OSD shall save new settings when it times out, or when the user exits the OSD. There shall not be a separate save.
Other Features Brightness Adjustment Multi Language Alarm Clock Time & Date Show Calendar Auto Rotation Volume Full Screen Slideshow Sequence
Slideshow Effect
Slideshow Speed
Manually Rotate
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 16 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
Background Music
Playback Repeat
Copy & Delete Files
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 17 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
16 IMAGE PERFORMANCE
NOTE: ALL MEASUREMENTS TAKEN AT STANDARD TEST CONDITIONS
CPT Panel
Item Formula / Measurement Location Spec
Luminance (On screen performance)
Measured at center point of LCD 220 cd/m2 (Typ) 180 cd/m2 (Min)
Contrast Ratio (On screen performance)
Measured center point of LCD at white state / Measured center point of LCD at black state
300:1 (Typ) 220:1 (Min)
Color Coordinates (CIE x) *: White, Red, Blue, Green
CIE1931, measured at center point of LCD
W: 0.295 +/- 0.04; R: 0.544 +/- 0.04 G: 0.330 +/- 0.04; B: 0.154 +/- 0.04
Color Coordinates (CIE y) *: White, Red, Blue, Green
CIE1931, measured at center point of LCD W: 0.329 +/- 0.04; R: 0.339 +/- 0.04 G: 0.575 +/- 0.04; B: 0.130 +/- 0.04
Color Point – White CIE1931, measured at center point of LCD x = 0.295 ± 0.04
y = 0.329 ± 0.04
16.1 MISC IMAGE PERFORMANCE CHARACTERISTICS
Item Formula or Defect Spec
Jitter None Visible at 35 cm None
Video Artifacts Peaking, Ringing, Streaking, Sag or Smearing at 35 cm
None Visible
Video Skew Complimentary Color Transition Artifacts None Visible
Power Supply / Grounding Artifacts at 35 cm None Visible ** LCD panel defect specification will be addressed in signed LCD acceptance panel specification
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 18 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
17 AUDIO SUBSYSTEM Sound System 2 Mono Speakers
Speaker 1 Watts @ 8Ω
Audio Amplifier 2 Watts Max
Audio Signal Input Amplitude: 1.3 Vrms
Impedance: 8Ω
Frequency Response 700-20000Hz
Distortion
< 5 % (@ 1.5kHz) @ 1 Watts
18 Startup Screen
18.1 Flash Screen
Power Up Screen ViewSonic ‘ Birds On Branch Logo’(VSC provide Logo BMP file)
19 VS OSD SETTING
General Setting Menu:
Item Item Default Factory Reset
Date 0000/00/00 2008/01/01 2008/01/01 Clock
Setting Time 00:00 12H/24H 00:00 24H 00:00 24H
Date 2008/01/01 2008/01/01
Time 00:00 24H 00:00 24H
Ring 1 1 Alarm Clock
Mode off Off
Interval Fast Fast
Transition Bottom_Top Bottom_Top
Standard: DPF will keep the original photo aspect ratio
Photo Setting
Display Smart: DPF will stretch all the photos to fit the LCD display, except A. Portrait type photos in landscape display B. Landscape type photo in Portrait display C. Photo resolution smaller than panel resolution(800 x 480)
Smart Smart
Brightness 9 9
Contract 9 9 Display Setting
Saturation 9 9
Clock
Calendar
Photo
Startup Setting
Music
Photo Photo
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 19 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
Video
Slideshow with Music
Browser
English,
German,
French,
Italian,
Spanish,
Dutch,
Portuguese,
Russian,
Simply Chinese
Language
Traditional Chinese
English English
Default Setting Resort Default NO NO
Firmware FW version FW version FW version
Photo Menu:
Rotate Rotate 90 degrees with clock wise
Zoom Zoom the Photo with X2/X3/X4/X5
Previous Previous Photo
Next Next Photo
Play/Pause Slideshow Play/Pause
Stop Exit the Photo
Info Display photo information
Multiple list List photo with thumbnail mode by 4x 3 matrix.
Music Menu:
Previous Previous Song
Rewind Rewind the Song
Fast Forward Fast forward the Song
Forward Next Song
Play/Pause Play/Pause the Song
Stop Exit the Music
Info Display song information
Repeat mode Repeat All/Normal/Repeat One (Default: Repeat All)
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 20 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
Video Menu:
Previous Previous Video
Rewind Rewind the Video
Fast Forward Fast forward the Video
Forward Next Video
Play/Pause Play/Pause the Video
Stop Exit the Video
Zoom Zoom the Photo with X2/X3/X4
Info Display song information
Music Slideshow Menu:
Rotate Rotate 90 degrees with clock wise
Zoom Zoom the Photo with X2/X3/X4/X5
Previous Previous Photo
Next Next Photo
Play/Pause Slideshow Play/Pause
Stop Exit the Photo
Info Display photo information
Multiple list List photo with thumbnail mode by 4x 3 matrix.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 21 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
20 ENVIRONMENTAL
20.1 Environmental Conditions
Operating Temperature Range 32°F to 104°F (0°C to 40°C)
Storage Temperature -4°F to 140°F (-20°C to +60°C)
Operating Relative Humidity 0% to 90% Non-Condensing
Storage Relative Humidity 0% to 90% Non-Condensing
Operating Altitude 0 to + 10000 ft
Storage Altitude 0 to + 30000 ft
20.2 Cabinet Temperatures
Surface Metal 60°C max except screws & terminals.
Surface Plastic 60°C max except around ventilation.
Exhaust Air N.A.
Screws and Terminals 60°C max.
Accessory Cables All the accessory cables that will accompany the unit are rated up to at least 45°C
20.3 Shock (Handling)
Unpackaged Drop Tests (all tests to be performed on a wooden table)
None (Packed drop test)
20.4 Gas
Exhaust from ventilation holes No noxious, corrosive or combustible gasses exhausted.
20.5 Electrostatic Discharge
Electrostatic Discharge 1. Operating and contact discharge applies voltage +/- 4KV (30 times). 2. Operating and air discharge applies voltage +/- 8KV (30 times). Judgment: No function failed after ESD Test.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 22 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
21 PACKAGING
21.1 Package Specifications
Ink The graphic & text ink printed on the package shall not be rubbed off after a suitable drying time.
Shipping Carton Type One Piece Construction
Carton Material Gift Box: Outer Box: B-flute 14kgs AB-flute 18kgs Vertical Flute Vertical Flute
Handle NA
356 (W) x179 (D)x 59 (H) (mm) Gift Carton Box
14.02 (W) x 7.05 (D) x 2.32 (H) (inch)
Q’ty in Box 6
380 (W) x 195 (D) x 375 (H) (mm) Outer Box Size
14.96 (W) x 7.68 (D) x 14.76 (H) (inch)
1200 (W) x 1000 (D) x 2031 (H) (mm) Pallet Size
47.24 (W) x 39.37 (D) x 79.96 (H)(inch)
Gross Weight Gift Box:: 730g (1.61 lbs) Outer Box: 4960g (10.93 lbs) Pallets: 387kg (853.19 lbx)
Stack Height 7
Pallet material Plywood
Loading Qty for each pallet 450 units
20’ Container Load Qty(ref.) 4500 units
40’ Container Load Qty(ref.) 9450 units
21.2 Vibration
Vibration Frequency 5 ~ 500Hz
Acceleration 2.09GRMS
Duration 2hrs
Test Time 0.5 hrs per axis (x, y, z)
Vibration Test Data Shall be submitted for approval to ViewSonic before Mass Production.
21.3 Drop
1 corner Six Face & 4 bottom edge
Height: 76cm
Drop Test Data Shall be submitted for approval to ViewSonic before Mass Production.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 23 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
22 MECHANICAL
Parameter Specification
Dimension (WxHxD) 220 mm x 172 mm x 41mm
(WxHxD; without stand)
Net Weight without stand 537 g
Net Weight with stand 665 g
Chassis Plastic Material Refer to Figure Product ID-1 & Figure Product ID-2
External Plastic Chassis
Components
Refer to Figure Product ID-1 & Figure Product ID-2
Exterior Chassis
Color/Texture/Details
Refer to Figure Product ID-1 & Figure Product ID-2
Chassis Component’s Color
Definition
Refer to Figure Product ID-1 & Figure Product ID-2
Rear Label A label identifying the product name, model/serial number and FCC
ID/Logo shall be placed into the rear label recess located on the rear panel
of the chassis.
Wall Mount N/A
Sample Sample of textured color chips, plastic material specification, and Material
Safety Data Sheets shall be submitted to ViewSonic prior to Mass
Production Release.
Product ID-1
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 24 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
Product ID-2
23 MANUALS AND DOCUMENTATION
23.1 Inserted Materials
CD Wizard, Quick Start Guide, Rear Label, and all other Inserted Material Samples
Samples of Rear Label and all other Inserted Materials will be provided to ViewSonic for approval before Mass Production.
23.2 Labels and Stickers
Rating label, UPC label, Caution label, and all other stickers not mentioned.
Samples of these Labels must be provided to ViewSonic for approval. Subject approval must be prior to Mass Production release.
24 REGULATORY AND SAFETY:
24.1 International
Regulatory filing should be made under the VS12207 Regulatory Filing
FCC, ETL, CE, CB, BSMI, C-Tick, GOST, PSE, CCC
Reports Submittal for VS Approval
Reports shall be submitted to VS all in the form of file copies unless otherwise approved by ViewSonic Corp. For other submittals such as NOM, TUV/S, and so on, VS submits to respective agency, vendor is required to support VS’s activities.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 25 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
25 RELIABILITY (MTBF)
Required MTBF Life
Demonstrated MTBF: 50K hours with normal room temperature 25. (After the
test reached to 20K hrs, the finished good can be shipped out.)
Test conducted at either: 40°C +/- 5°C Panel, and backlight are excluded from MTBF testing
Thermal Test Plan and Procedures
The Thermal Test Plan and Procedures shall be submitted for ViewSonic review and approval prior to DVT
Thermal Test Results Thermal Test Results for DVT and PVT level product shall be submitted for ViewSonic review and approval
Life Test Plan and Procedures The Life Test Plan and Procedures shall be submitted for ViewSonic review and approval prior to DVT
Life Test Samples Life Test shall be conducted at least on 20 units
Left Test Failures Failed units may be repaired and used for further Life Test. Failures shall be noted in the test report
Life Test Sample ECN/ECO Upgrades
Units under test may be upgraded against an approved ECN/ECO. Hours of test after the upgrade shall be noted in the test report. Hours of test before the upgrade shall not be used in calculating total operating hours
Life Test Results
Demonstration MTBF test results for DVT or higher level product shall be submitted for ViewSonic approval no later than 90 days after Mass Production Release, with at least 1/3 of the required MTBF testing completed prior to Mass Production Release.
26 REMOTE control
26.1 IR Remote
Manufacturer P/N: SRC-T1000 (Viewsonic has no legal liability to use this remote control, such as patent…)
Transceivers The digital photo frame shall have IR Transceivers on the front (no rear) of the unit.
Distance Front: The IR Remote shall function within a distance of 5 meters in a 300LUX ambient light environment at the following angles: Front: At 5m minimum.
Horizontal: ±30° (degrees)
Vertical: ±30° (degrees)
Key Function Operation Each individual key function when selected provides positive selection of its prescribed operation. Pressing a selected key should not cause over scroll or jump to the next key function.
Working Frequency 455kHz
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 26 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
26.2 IR Remote Code
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 27 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
27 Label
27.1 ID Rating Label
27.2 S/N Barcode Definition:
For DPX704WH, QQQ will be R13.
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 28 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
27.3 UPC Label for Gift Box
(1) Model Name and its barcodes 128
(2) Appropriate 14 digit GTIN® (GLOBAL
TRADE ITEM NUMBER®) Information, as provided by
ViewSonic Engineer. (Add 2 zeroes before UPC code)
Barcode ITF-14 Code 2of 5 Interleaved (14 digits)
(6) 12 digit UPC information
provided by ViewSonic
Engineer.
Barcode UPC-A
(5) Manufacturing Date:
YYYY-MM-DD
(7) Manufacturing
Country (8) Region of the PO from:
M: U.S (VSA);
P: Asia Pacific (VSI);
E: Europe (VSE);
G: China (VSCN)
(9) Power adapter type
(4) Serial Number
(Format the same as
defined in Device
label S/N)
Barcode of S/N:
(3) Model Number
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 29 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
27.4 UPC Label for Outer Box
(1) Model Number (2) Unit Quantity in the carton
(6) 12 digit UPC
information provided by
ViewSonic Engineer.
Barcode UPC-A
(3) Serial Numbers of units contained in
the carton (format the same as defined
in Device label S/N)
Barcode 128
(8) Region of the PO from:
M: U.S (VSA);
P: Asia Pacific (VSI);
E: Europe (VSE);
G: China (VSCN)
(8) Power adapter type
(7) Manufacturing Country
(9) Manufacturing Date:
YYYY-MM-DD
(2) Appropriate 14 digit GTIN® (GLOBAL
TRADE ITEM NUMBER®) Information, as provided by
ViewSonic Engineer. (Add 2 zeroes before UPC code)
Barcode ITF-14 Code 2of 5 Interleaved (14 digits)
(1) Model Name
Barcode 128
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 30 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
28 Shipping
28.1 DPX 704WH Carton Artwork for Gift Box
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 31 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
28.2 DPX 704BK Carton Artwork for Gift Box
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 32 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
28.3 DPX 704RW Carton Artwork for Gift Box
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 33 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
28.4 DPX704 Carton Artwork for Outer Box
ViewSonic Corporation SPEC_DPX704 Rev 2.0
Page 34 of 34
COMPANY CONFIDENTIAL ViewSonic: _________ Mustek: _________
28.5 Shipping loading
Normal container pallet loading High container pallet loading