Upload
ivan-valentic
View
1.354
Download
177
Embed Size (px)
DESCRIPTION
electro schematic wiring diagram man tga russian
Citation preview
Highline (TGA)
HIGHLINE (TGA)
: 02.02 -------- -------------------------------------------------------------
-----------
A100 A143 ECAS A148 / A302 2 A317
,
A407 A408 A486 A574 MMI
( -) A635 Truck-Gate F125
,
F366 ECAM/ECAS/ ( 15) F398 ,
( 15) F412 ,
( 30) K467 S192
S193
S329
S472 ECAS I/II S483 /
/
S747 ECAS ,
S790 ECAS / NLA/VLA
X200 (MAN-cats) X744 - -
X1535 - - X1642
X1644
X1757 16006 X1809 - ECAS ( 15) X1825 31000 X1826 31000 X1833 16000 X1835 58000 X1836 58000 X2541 21-.
Page 1 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e58590
S252
S266 ECAS / NLA/VLA
S267 ECAS,
31000 X2542 21-
58000 X2544 21-
- X3186 -
Page 2 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e58590
ZBR2 (TGL/TGM/TGA) 1 4
ZBR2 (TGL/TGM/TGA) 1 4 : 02.04
A100 A302 () -------- -------------------------------------------------------------------
-----
A F243 ZBR2 F244 ZBR2 ( 30) F245 ZBR2 ( 30-2) F246 ZBR2 ( 15) -------- -------------------------------------------------------------------
-----
B A317
,
G102 1 M102 Q101 50 Q105
, (A100 30)
S104
S407
X317 ABS -------- -------------------------------------------------------------------
-----
C B101 1
B102 2
B103 1 B139 B371 1
B433 B434 B468 4
B502 3
M103 S198 S199
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e59532
ZBR2 (TGL/TGM/TGA) 2 4
ZBR2 (TGL/TGM/TGA) 2 4 : 02.04
A100 A302 -------- -------------------------------------------------------------
-----------
D A474
/ E112 E113 E194 E195 E280 E281 H111 H162 H371
K102 K106 K116 K171 , 15 K250 K609
K678
TRS K718
M103
M131 M175 Q101 R214
HGS S224 S483
/ /
S502
V188 8
V636 15 -
Y100
-------- -------------------------------------------------------------
-----------
D E110 E111 E122 E123 E127 () E128 () E268
Page 1 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e59794
E269 -------- -------------------------------------------------------------
-----------
E G102 1
Page 2 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e59794
ZBR2 (TGL/TGM/TGA) 3 4
ZBR2 (TGL/TGM/TGA) 3 4 : 02.04
A100 A302 -------- -------------------------------------------------------------
-----------
F A451 RL A452
LL B103 1 G102 1 X200 -------- -------------------------------------------------------------
-----------
G
B509
-------- -------------------------------------------------------------
-----------
H
A465 A466 M131 S108
( , )
S109
S111 V646 -
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e60165
ZBR2 (TGL/TGM/TGA) 4 4
ZBR2 (TGL/TGM/TGA) 4 4 : 02.04
A100 A302 A403 -------- -------------------------------------------------------------
-----------
I
E108 E109 E114 E115 E116 E117 E118 E119 E124
E125
E210 1. E211 1. E212 2. E213 2. F106
F117
F118
F371 FFR 30 F372 FFR 15
H120
H121 H122 H123 H124 H125 K102 K116 R100 1
R101 2
S483
/ /
S502
V716
V717
X1586 1
X1587 2
X317 ABS -------- -------------------------------------------------------------
-----------
J
Page 1 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e60345
H112 H113
M117
M118
-------- -------------------------------------------------------------
-----------
K - KWP 2000 X200 -------- -------------------------------------------------------------
-----------
L CAN
Page 2 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e60345
04.01
A100 A302 2 A407 A474 /
A480 , BEHR B203 /
- () B393
() F397
/ F125 K718
R106 S123 " /
" S544 AC S545 "REHEAT" S546
S547
X200 (MAN-cats)
X1560 K718, K.. X1754 59104 X1822 X1823
15 X2541 21-
31000 X2544 21- -
Y114 Y117
-------- -------------------------------------------------------------------
------------
1 2 3 4 5 / 6 7
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?p=d0e13508
( 1 2)
( 1 2) 04.01
A , ,
-------- -------------------------------------------------------------
-------------------------------------
A100 A302 2 A474
/ B393
() F397
/ K718
S123 " /
" S544 AC
S545 "REHEAT" S546
S547
X1560 K718, K.. X1754 59104 X1822 X1823
15 X2541 21-
31000 Y117
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e13792
( 2 2)
( 2 2) 04.01
A - B , C , BEHR -------- -------------------------------------------------------------
------------------
A100 A302 2 A474
/ A480 ,
BEHR B203 /
- ()
X1551 /EDC/ II
X1822 X1823
15
X1835 58000 X1838 58300 X2544 21-
- Y114 -------- -------------------------------------------------------------
------------------
1 2 3 / 4 5 6 7
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e13967
Schnellbersicht EDC 7 C32
SCHNELLBERSICHT EDC 7 C32
A302 Zentraler Bordrechner A403 Fahrzeugfhrungsrechner A407 Instrumentierung A410 Fahrpedal A429 Tempomatschalter A435 Steuergert EDC A437 Dauerbrems-Tippschalter B104 ldrucksensor B123 Temperatursensor Ladeluft B124 Temperatursensor Khlflssigkeit B377 Kraftstoffdrucksensor B487 Raildrucksensor B488 Drehzahlsensor Kurbelwelle
(Drehzahlinkrementsensor) B489 Drehzahlsensor Nockenwelle
(Drehzahlsegmentsensor) B561 Temperatursensor Abgas (entfllt bei D08-
Motoren mit OBD1) B623 Ladedrucksensor/Temperatursensor B673 Wegsensor E-AGR-Steller B683 Abgasrelativdrucksensor F163 Sicherung Motorregulierung (Kl. 30) F236 Sicherung Motorregulierung (Kl. 15) F355 Hauptsicherung 30-2 H296 Kontrollleuchte EDC
H374 Kontrollleuchte Luftfilter verschmutzt M100 Starter Q101 Zndanlassschalter R134 Widerstandsgruppe R283 Abschlusswiderstand HD-OBD-CAN X200 Diagnosesteckdose X669 Steckverbindung Startsperre X1559 Steckverbindung Motor/EDC/Getriebe IV X1966 Steckverbindung Zndschloss X1983 Gewindebolzen M6 (MP-Kasten) X2544 Potentialverteiler 21-pol. K-Leitung X2549 Steckverbindung IMR (Starter) Y332 Zumesseinheit ZME (Proportionalventil
Kraftstoff MProp) Y341 Injektor 1. Zylinder Y342 Injektor 2. Zylinder Y343 Injektor 3. Zylinder Y344 Injektor 4. Zylinder Y345 Injektor 5. Zylinder Y346 Injektor 6. Zylinder Y458 Proportionalventil E-AGR Y460 Druckluftabschaltventil ZDR Zwischendrehzahl-Schnittstelle
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?p=d0e38557
EDC 7 Common Rail AdBlue ( 1 5)
EDC 7 COMMON RAIL ADBLUE ( 1 5) : 05.2005
A B
C 1 + 2 D 3 + 4 E 5 + 6 F
1 ----- -----------------------------------------------------------
A100 A302 2 A435 EDC
B487 B633 1
( AdBlue) Y332
Y341 1- Y342 2- Y343 3- Y344 4- Y345 5- Y346 6-
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?p=d0e14170
MAN TGA 410 TGA [2000 - 2008]
A21 Speed pilot
A72 Speed recorder
A95 ECU
B156 Inductive position sensor 1
B163 Inductive position sensor
B22 Coolant temperature sensor
B36 Fuel temperature sensor
B38 Injector needle lift sensor
B39 Accelerator pedal sensor
B79 MAP-sensor
F- Fuse
G15 CAN BUS SAE J1708
G16 CAN BUS SAE J1939
H11 ECU lamp
K95 Relay
K96 Relay
R11 Resistor
S14 Brake pedal switch
S15 Clutch switch
S68 Engine brake switch
X11 Diagnostic connector
X15 Cable screen
Y147 Injection quantity regulator
Y148 Fuel adjustment sensor
Y149 Injection timing valve
Y43 Shut off valve
Troubleshooting-data
TGA 410Model: Motor: D 2866 LF 28 / Bosch MS5
Component: From: To: Condition: Value Measured:Pic.
. .. Connector seen from ECU side .
. .. Measurements taken withconnector removed
.
53 13Coolant temperature sensor Ignition from 20C 1300 - 3600ohm
53 13Coolant temperature sensor Ignition from 80C 230 - 460ohm
9 11Fuel adjustment sensor Ignition off 18 - 25 ohm10 11Fuel adjustment sensor Ignition off 18 - 25 ohm34 13Fuel temperature sensor Ignition off 20 C fuel 1300 - 3600
ohm22 17Inductive position sensor Ignition off 500 - 1000
ohm21 13Inductive position sensor 1 Ignition off 500 - 1000
ohm2 15Injection quantity regulator Ignition off 0,55 - 1,5
ohm1 15Injection quantity regulator Ignition off 0,55 - 1,5
ohm3 15Injection timing valve Ignition off 1,2 - 2 ohm32 17Injector needle lift sensor Ignition off 90 - 130 ohm14 19Shut off valve Ignition off 10 - 48 ohm
MAN TGA 410 TGA [2000 - 2008]
A95 ECU
B156 Inductive position sensor 1
B163 Inductive position sensor
B169 Fuel pressure sensor
B170 Oil pressure sensor
B22 Coolant temperature sensor
B23 Air temperature sensor
B36 Fuel temperature sensor
B38 Injector needle lift sensor
B79 MAP-sensor
F- Fuse
G16 CAN BUS SAE J1939
K96 Relay
M19 Starter-Signal
Y147 Injection quantity regulator
Y148 Fuel adjustment sensor
Y149 Injection timing valve
Y160 EGR valve
Troubleshooting-data
TGA 410Model: Motor: D 2866 LF 28 / Bosch MS6.1
Component: From: To: Condition: Value Measured:Pic.
. .. Connector seen from ECU side .
. .. Measurements taken withconnector removed
.
A4 A10Air temperature sensor Ignition from 20C airtemperature
2350 - 2650ohm
A4 A10Air temperature sensor Ignition from 40C airtemperature
800 - 1000ohm
A5 A22Coolant temperature sensor Ignition from 20C 2350 - 2650ohm
A5 A22Coolant temperature sensor Ignition from 80C 310 - 335ohm
A34 A35Fuel adjustment sensor Ignition off 18 - 24 ohmA33 A35Fuel adjustment sensor Ignition off 18 - 24 ohmA6 A11Fuel temperature sensor Ignition off 20 C fuel 2350 - 2650
ohmA6 A11Fuel temperature sensor Ignition off 40 C fuel 800 - 1000
ohmA14 A2Inductive position sensor Ignition off 1000 - 1500
ohmA1 A13Inductive position sensor 1 Ignition off 1000 - 1500
ohmA26 A28Injection quantity regulator Ignition off 0,55 - 0,90
ohmA25 A27Injection quantity regulator Ignition off 0,55 - 0,90
ohmA24 A3Injection timing valve Ignition off 0,5 - 1,55
ohmA29 A15Injector needle lift sensor Ignition off 65 - 160 ohm
MAN TGA 410 TGA [2000 - 2008]
MAN TGA 410 TGA [2000 - 2008]
? Explanation
1H Regulation module 1. Axle R
1V Regulation module 1. Axle L
A89 Vehicle control unit
A90 EBS ECU
B Regulation module rearaxle
F- Fuse
G14 CAN BUS ISO 11992
G16 CAN BUS SAE J1939
R38 Brake signal transmitter
S56 ASR switch
X11 Diagnostic connector
X32 Collector plug
X33 Trailer brake connection
Y204 Regulation module trailer
Troubleshooting-data
TGA 410Model: Motor: D 2866 LF 28 / 1999- EBS 4S-4M 4x2
Component: From: To: Condition: Value Measured:Pic.
. .. Connector seen from wire side .
. .. Measurements taken withconnector installed
.
A10 Batt. -Battery (earth) Ignition on 0 - 1 VA12 Batt. -Battery (earth) Ignition on 0 - 1 VD3 A10Trailer brake connection Ignition on 2 ~ 16 VD1 A10Trailer brake connection Ignition on 2 ~ 16 VA6 A10ASR switch Ignition on 18 - 24 VA6 A10ASR switch Ignition on, switch activated 0 VA8 A12Battery (possitive) Ignition off 22 - 28 VB2 B3Brake signal transmitter Ignition on 4,55 - 5,45 VB3 A10Brake signal transmitter Ignition on 0 VB4 B3Brake signal transmitter Ignition on 0,3 - 4,5 VB7 B3Brake signal transmitter Ignition on 0,3 - 4,5 VA13 A10Diagnostic connector Ignition on 0 - 5 VA7 A10Ignition Ignition on 22 - 28 VA7 A10Ignition Ignition off 0 VC5 A10Regulation module 1. Axle L Ignition on 0 ~ 3 VC11 A10Regulation module 1. Axle L Ignition on 22 - 28 VC2 A10Regulation module 1. Axle L Ignition on 0 VC8 A10Regulation module 1. Axle L Ignition on 2 ~ 5 VC6 A10Regulation module 1. Axle R Ignition on 0 ~ 3 VC3 A10Regulation module 1. Axle R Ignition on 0 VC9 A10Regulation module 1. Axle R Ignition on 2 ~ 5 VC12 A10Regulation module 1. Axle R Ignition on 22 - 28 VD10 A10Regulation module rearaxle Ignition on 2 ~ 5 VD13 A10Regulation module rearaxle Ignition on 22 - 28 VD4 A10Regulation module rearaxle Ignition on 0 VD7 A10Regulation module rearaxle Ignition on 0 ~ 3 VD12 A10Regulation module trailer Ignition on 2 ~ 5 VD15 A10Regulation module trailer Ignition on 22 - 28 VD6 A10Regulation module trailer Ignition on 0 VD9 A10Regulation module trailer Ignition on 0 ~ 3 VA1 A10Vehicle control unit Ignition on 0 ~ 3 VA3 A10Vehicle control unit Ignition on 2 ~ 5 V
MAN TGA 410 TGA [2000 - 2008]
MAN TGA 410 TGA [2000 - 2008]
? Explanation
1H Regulation module 1. Axle R
1V Regulation module 1. Axle L
A89 Vehicle control unit
A90 EBS ECU
B2-3 Regulation module 2.-3. Axle
F- Fuse
G14 CAN BUS ISO 11992
G16 CAN BUS SAE J1939
R38 Brake signal transmitter
S56 ASR switch
X11 Diagnostic connector
X32 Collector plug
X33 Trailer brake connection
Y204 Regulation module trailer
Troubleshooting-data
TGA 410Model: Motor: D 2866 LF 28 / 1999- EBS 4S-4M 6x2 6x4
Component: From: To: Condition: Value Measured:Pic.
. .. Connector seen from wire side .
. .. Measurements taken withconnector installed
.
A10 Batt. -Battery (earth) Ignition on 0 - 1 VA12 Batt. -Battery (earth) Ignition on 0 - 1 VD3 A10Trailer brake connection Ignition on 2 ~ 16 VD1 A10Trailer brake connection Ignition on 2 ~ 16 VA6 A10ASR switch Ignition on 18 - 24 VA6 A10ASR switch Ignition on, switch activated 0 VA8 A12Battery (possitive) Ignition off 22 - 28 VB2 B3Brake signal transmitter Ignition on 4,55 - 5,45 VB3 A10Brake signal transmitter Ignition on 0 VB4 B3Brake signal transmitter Ignition on 0,3 - 4,5 VB7 B3Brake signal transmitter Ignition on 0,3 - 4,5 VA13 A10Diagnostic connector Ignition on 0 - 5 VA7 A10Ignition Ignition on 22 - 28 VA7 A10Ignition Ignition off 0 VC5 A10Regulation module 1. Axle L Ignition on 0 ~ 3 VC11 A10Regulation module 1. Axle L Ignition on 22 - 28 VC2 A10Regulation module 1. Axle L Ignition on 0 VC8 A10Regulation module 1. Axle L Ignition on 2 ~ 5 VC6 A10Regulation module 1. Axle R Ignition on 0 ~ 3 VC3 A10Regulation module 1. Axle R Ignition on 0 VC9 A10Regulation module 1. Axle R Ignition on 2 ~ 5 VC12 A10Regulation module 1. Axle R Ignition on 22 - 28 VD10 A10Regulation module 2.-3. Axle Ignition on 2 ~ 5 VD13 A10Regulation module 2.-3. Axle Ignition on 22 - 28 VD4 A10Regulation module 2.-3. Axle Ignition on 0 VD7 A10Regulation module 2.-3. Axle Ignition on 0 ~ 3 VD12 A10Regulation module trailer Ignition on 2 ~ 5 VD15 A10Regulation module trailer Ignition on 22 - 28 VD6 A10Regulation module trailer Ignition on 0 VD9 A10Regulation module trailer Ignition on 0 ~ 3 VA1 A10Vehicle control unit Ignition on 0 ~ 3 VA3 A10Vehicle control unit Ignition on 2 ~ 5 V
MAN TGA 410 TGA [2000 - 2008]
A33 CAN communication
A81 ECU
B114 Wheelspeed sensor 1 L
B115 Wheelspeed sensor 1 R
B116 Wheelspeed sensor 2 L
B117 Wheelspeed sensor 2 R
G12 Battery (earth)
H20 ABS indicator lamp
H27 Trailer ABS fault lamp
H28 Trailer ABS indicator lamp
K97 Relay
S12 Ignition
X11 Diagnostic connector
X14 Ground connection
X32 Collector plug
X33 Trailer brake connection
Y100 Control valve 2 L
Y101 Control valve 2 R
Y111 Engine brake solenoid valve
Y98 Control valve 1 L
Y99 Control valve 1R
Troubleshooting-data
TGA 410Model: Motor: D 2866 LF 28 / ABS 4 Channel
Component: From: To: Condition: Value Measured:Pic.
. .. Connector seen from ECU side .
. .. Measurements taken withconnector installed
.
A11 Batt. -Battery (earth) Ignition on 0 - 1 VA12 Batt. -Battery (earth) Ignition on 0 - 1 VA10 Batt. -Battery (earth) Ignition on 0 - 1 V. .. Measurements taken with
connector removed.
C1 C3Control valve 1 L Ignition off 14 - 21 ohmC2 C3Control valve 1 L Ignition off 14 - 21 ohmC10 C12Control valve 1R Ignition off 14 - 21 ohmC11 C12Control valve 1R Ignition off 14 - 21 ohmD2 D3Control valve 2 L Ignition off 14 - 21 ohmD1 D3Control valve 2 L Ignition off 14 - 21 ohmD11 D12Control valve 2 L Ignition off 14 - 21 ohmD10 D12Control valve 2 R Ignition off 14 - 21 ohmA9 A10Ignition Ignition on 22 - 28 VA7 A10Ignition Ignition on 22 - 28 VA9 A10Ignition Ignition off 0 VA7 A10Ignition Ignition off 0 VA16 A7Relay Ignition off 215 - 395
ohmC5 C4Wheelspeed sensor 1 L Ignition off 900 - 2000
ohmC5 C4 1050Wheelspeed sensor 1 L Spin wheel at approx. 30 rpm min. 100 mV
ACC8 C7Wheelspeed sensor 1 R Ignition off 900 - 2000
ohmC8 C7 1050Wheelspeed sensor 1 R Spin wheel at approx. 30 rpm min. 100 mV
ACD5 D6Wheelspeed sensor 2 L Ignition off 900 - 2000
ohmD5 D6 1050Wheelspeed sensor 2 L Spin wheel at approx. 30 rpm min. 100 mV
ACD8 D9Wheelspeed sensor 2 R Ignition off 900 - 2000
ohmD8 D9 1050Wheelspeed sensor 2 R Spin wheel at approx. 30 rpm min. 100 mV
AC
1050
EDC 6.1
EDC 6.1
A302 () A403 A407 A410 A429 A435 EDC A437 -
B104 B123 B124
B125 B197 B198 B199 B200
B377 F163
(. 30) F236
(. 15) F355 30-2 H296 EDC H374
K170 K755 M100 Q101 R134 X200 MAN-cats (ISO -
) X669 X1549 /
X1559 EDC X1644 X1680 EDC (. 15) X1904 M6 ( MP) X1906 M6 ( MP) X1907 M6 ( MP) X1966 X1982 M5 ( MP) X1983 M6 ( MP) X1990 M5 ( MP) Y130 Y280 (AGR) ZDR
Page 1 of 1
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e34161
Baseline TGA)
BASELINE TGA)
: 03.01 -------- -------------------------------------------------------------
-----------
A100 A143 ECAS A302 2 A317
,
A407 A408 A486 F125
,
F366 ECAM/ECAS/ ( 15) F398 ,
( 15) F412 ,
( 30) K467 S192
S193 S252
S266 ECAS
/ NLA/VLA
S483 / /
S747 ECAS ,
S790 ECAS / NLA/VLA
X200 (MAN-cats) X744 - -
X1535 - - X1642
X1644
X1757 16006 X1809 - ECAS ( 15) X1825 31000 X1826 31000 X1833 16000 X1835 58000 X1836 58000 X1838 58300 X2541 21-.
31000 X2542 21-
Page 1 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e58266
S267 ECAS,
S329
S472 ECAS I/II
58000 X2544 21-
- X3186 -
Page 2 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e58266
EDC 7 Master/Slave D2840 LF25
EDC 7 MASTER/SLAVE D2840 LF25
A302 A403 A407 A410 A429 A435 EDC (Master) A437 -
A570 EDC II (Slave) B104 B123 B124
B125 B377 B487 B488
( )
B489 ( )
B514 II F163
(Master . 30) F236
(. 15) F355 30-2 F543 II
X200 X669 X1205 31000 X1559 /EDC/ IV X1966 X2417 CAN 3-
X2544 21-pol. K-
X3120 M6 .30
( ) X3121 M6 .30
( ) Y280 (AGR) Y332 ZME (
MProp)
Y341 1- X342 2- Y343 3- Y344 4- Y345 5- Y346 6- Y347 7- Y348 8- Y349 9- Y350 10- Y356 ZME II (
Page 1 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e79740
(Slave . 30) H296 EDC M100 Q101 R134
MProp) ZDR
* HD-OBD K-
3
Page 2 of 2
13.04.2009file://C:\MANWIS\XSLT\body.html?id=d0e79740