Tarifa PaviFlex 2016

I n s t a l l a t i o n g u i d e

A e r o b i cF i t n e s sP a v i G o mE c o F l e xM a t 0 3 0S t r e t c h i n gT a t a m iP a v i J u n i o rI n d i v i d u a l M a t sP A C K S / J u n i o r / M A X

Z o n n a xT u r F l e xL e d F l e x

C o l o u r sG u a r a n t e e

2016

2016

Manufactured 100% in SpainWith the highest quality standards and the most accurate quality controls in order to ensure its performance we recommend to follow this guide for installation and maintenance.Installation ground / surfaceThe surface where the paving is going to be installed must be plain, clean and dry to avoid any intervals when assembling the pieces together.Sun exposureThe areas exposed to a higher level of sun exposure can suffer changes such as loss of sheen. The floor must be protected to avoid tiles to get a temperature higher than 40ºC.Our products expand and contracts depending on the temperature, so as a general norm, when installing the tiles, a margin must be left between the tiles, and the walls and pillars, so it allows the right expansion and contraction of the floor.Control procedureTiles received properly packed and no bulk is damaged.Tiles remain in the room at least 24 hours prior to the installation so they get the room temperature.Surface of the room is clean, plain and dry.Start placing the tiles from the center of the room, going outwards in a radial order.Use a rubber hammer to help locking the puzzle zip.Adjust the tiles in the ending areas leaving a margin (free gap) between the walls or pillars and the tiles. This free gap will allow the tiles to expand when absorbing the impacts.Check the areas exposed to a higher level of sun exposu-re (areas located by a window) and somehow protect the tiles to get a temperature above 40ºC.Clean the paviflex floor with a wet mop and normal soup.Maintain the floor daily just with a mop and regularly with normal soup and water.Place the equipment on paviflex and enjoy.

2 3

4CENTRE

567

8

I N S T A L L A T I O N G U I D E

Su diseño aumenta la sensación de equilibrio y su perfecta elasticidad absorbe los impactos contra el suelo reduciendo el cansancio y el riesgo de lesiones por saltos o caídas.

The elasticity of Paviflex Aerobic absorbs the impact, stabilising the bounce or reverberation from jumping or falling, and thereby reducing the feeling of fatigue and the risk of injury. It enables us to exercise with all the necessary strength and balance required, allowing the joints to move perfectly.

Diseñado para actividades supervisadas: aerobic, step, dance, cardiobox,...Designed for supervised activities: aerobics, step, dance, cardiobox

MM AEROBICS Solido / Solid

V Veteado / Veined

Mb Marmoleado / Marble

Mb Metalizado / Metallic

ORO VIEJO / OLD GOLDBRONCE / BRONZE

PLATA / SILVERORO / GOLD

Consultar por colores personalizados*Ask for personalized coloursImitación madera y otros efectos veteados*Wood imitation. And other veined effect colours.

WENGUÉ*

V

GRIS MARMOLEADO* / MARBLE GREY

Mb

HAYA*

V

CASTAÑO / CASTANYO*

V

VERDE / GREEN

VIOLETA / VIOLET VOLCAN / BROWN

AZUL CELESTE / LIGHTBLUE PIOLIN / YELLOW

IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY

COLORES / COLOURS

BLANCO MARMOLEADO* / MARBLE WHITE

Mb

Mt Mt

MtMt

ESPECIFICACIONES TÉCNICAS / TECHNICAL SPECIFICATIONS

ACABADO / FINISH : 4 lados puzzle / 4 sides puzzle tiles

GROSOR / THICKNESS: 10 mm.

TAMAÑO LOSA / SIZE SHEET: 100x100 cm.

PESO LOSA / WEIGHT SHEET: 3,500 Kg/m2.

SUPERFICIE / SURFACE AREA: Waterproof Non Bacteria.

DENSIDAD / DENSITY: UNE 53526 320-340Kg/m3

DUREZA / HARDNESS: UNE 53130 DUREZA / SHORE A:67-72

RESISTENCIA FUEGO: ES 13501-1 Efl: BAJO PEDIDOFIRE REACTION ES 13501-1 Efl: ON DEMMAND

MATERIAL: EVA.(Exento de PVC y sustancias halogenuras tóxicas) (Exempt from PVCand toxic halogenous substances)

AB D

C E

10101010101010101010

Losa / TilePerfil / EdgeEsquina / CornerP.Cuña / WedgeE.Cuña / W.CornerLosa / TilePerfil / EdgeEsquina / CornerP.Cuña / WedgeE.Cuña / W.Corner

10010012

1003010010012

10030

1001212303010012123030

36,23 €9,24 €6,09 €

20,95 €14,02 €39,85 €10,13 €6,67 €

23,05 €15,44 €

SSSSS

V/Mb/MtV/Mb/MtV/Mb/MtV/Mb/MtV/Mb/Mt

ABCDEABCDE

36,23€

39,85€

Thickness SizeNameNOMBRE ESPESOR TAMAÑO €/losa Color€/m2

Colour€/tile €/sqm

Ideal para las salas de maquinaria ligera. Totalmente preparado para absorber los ruidos y los impactos bruscos, protegiendo el suelo de roturas y desperfectos

Diseñado para Fitness y maquinaria ligera.Specially designed for fitness and soft machine rooms.

MMMM

Excellent properties of shock, noise and vibration absorption The ideal flooring for fitness. In the areas where the weights may be dropped, it protects the floor from cracking and breaking.

AB D

E

S Solido / Solid

V Veteado / Veined



ORO VIEJO / OLD GOLDBRONCE / BRONZE

PLATA / SILVERORO / GOLD


WENGUÉ*

V


Mb

HAYA*

V


V

VERDE / GREEN



IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY

COLORES / COLOURS


Mb

Mt Mt

MtMt



GROSOR / THICKNESS: 10 / 15 mm.

TAMAÑO LOSA / SIZE SHEET: 92X92 / 100x100 cm.

PESO LOSA / WEIGHT SHEET: 3,900 / 4.900 Kg/m2.


DENSIDAD / DENSITY: UNE 53526 340 / 400Kg/m3




C

10101010101010101010

15151515151515151515



92921292309292129230

10010012

10030

10010012

10030

92121230309212123030

10012123030

10012123030

SSSSS

V/MbV/MbV/MbV/MbV/Mb

SSSSS

V/MbV/MbV/MbV/MbV/Mb

32,80 €9,89 €6,52 €

22,42 €15,00 €36,08 €10,88 €7,17 €

24,66 €16,50 €

46,04 €11,54 €7,72 €

27,41 €18,17 €

50,64 €12,71 €8,51 €

30,14 €20,00 €

38,80 €

42,65 €

46,04 €

50,64 €

ABCDEABCDE

ABCDEABCDE



Diseñado para maquinaria pesada, peso libre y entrenamiento funcional.Specially designed for heavy use, freeweights and functional training.

A B

C

MM MM





PESO LOSA / WEIGHT SHEET: 8.000 Kg/m2.


DENSIDAD / DENSITY: UNE 53526 1.450 Kg/m3

DUREZA / HARDNESS: UNE 53130 DUREZA / SHORE A:75/68


MATERIAL: RUBBER.

New rubber floor designed and developed thinking in the highest perfomance requirements for training. Give us excellent properties, its surface is highly resistant for heavy machinery, knocks from weights, heels, furniture and others. It is non slip.

Novedoso pavimento diseñado exclusivamente para el mejor rendimiento, el más exigente. Gracias a sus propiedades de antideslizamiento aporta excelentes resultados en el entrenamiento. Por su bidensidad es muy resistente a las marcas producidas por golpes, disminuyendo a la vez las vibraciones y los ruidos.

S Solido / Solid

V Veteado / Veined



WENGUÉ*

V


Mb

HAYA*

V


V

VERDE / GREEN



IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY

COLORES / COLOURS


Mb

53,16 €

59,36 €

53,16 €30,30 €15,95 €

62,04 €

68,25 €

ABC

SSS

V/MbV/MbV/Mb

SSS

V/MbV/MbV/Mb

Losa / TilePerfil / EdgeEsquina / Corner

100555

10012

1001212

59,36 €33,84 €17,81 €

ABC


555

10010012

1001212

62,04 €35,36 €18,61 €

ABC


100777

10012

1001212

68,25 €38,90 €20,48 €

ABC


777

10010012

1001212



GRIS / GREY NEGRO / BLACK

TERRA / BROWN

MM

MM

7

2016





PESO LOSA / WEIGHT SHEET: 8.000 Kg/m2 / 11.400 Kg/m2


DENSIDAD / DENSITY: UNE 53526 1.450 Kg/m3

DUREZA / HARDNESS: UNE 53130 DUREZA / SHORE A:75/68


MATERIAL: RUBBER.

New rubber floor extremely resistant and durable for heavy use. It is made of recycled Pavigom tiles. Non slip and waterproof. Non making floor. Surface highly resistant for heavy machinery, free weights and others.

Novedoso pavimento extremadamente resistente y de gran duración para un uso continuado. Esta fabricado con losas de Pavigom reciclado lo que le confiere propiedades óptimas para un uso intensivo. Es antideslizante y muy resistente a las marcas producidas por golpes, disminuyendo a la vez vibraciones y ruidos. Pavimento recomendado para maquinaria pesada y cualquier otro ejercicio.

COLORES / COLOURS

Diseñado para maquinaria pesada, peso libre y entrenamiento funcional.Specially designed for heavy use, freeweights and functional training.

A B

C

32,80 €

39,90 €

32,80 €18,70 €9,84 €

ABC

SSS

SSS


100777

10012

1001212

39,90 €22,74 €11,97 €

ABC


100101010

10012

1001212



MAT030MM

GRIS / GREYNEGRO / BLACK

COLORES / COLOURS

New rubber floor with button base designed and developed thinking in the highest performance requirements for people and machines. Gives us excellent properties, its surface is highly resistant for heavy machinery, knocks from weights, heels, furniture and others. Also this floor provides excellent acoustic isolation properties.

A

S

2016




TAMAÑO LOSA / SIZE SHEET: 115x180 / 105x188 cm.



DENSIDAD / DENSITY: UNE 53526 300Kg/m3

DUREZA / HARDNESS: UNE 53130 DUREZA / SHORE A:70



Pensado y desarrollado para aportar el mejor rendimiento gracias a su base de botones, que absorbe los continuos impactos de pesas y maquinaria aislando al mismo tiempo acústicamente de ruidos y vibraciones.

Ideal para crossfit y cualquier ejercicio exigente.For crossfit and more.

Grosor de 30mm con base de botones que permite un aislamiento acústico óptimo.Extra thickness with buttons base for areas requiring acoustic isolation.

S Sólido / Solid

Consultar otros colores sólidos*Ask for other solid colours

Losa / TileLosa / Tile

RugosoBuffalo

115105

180188

SS

3030

130,00 €131,86 €

62,80 €66,80 €



Diseñado para ejercicios aeróbicos sin maquinaria.For body mind, pilates, yoga, stretching, and all activities requiring floor exercises

MM

Due to its texture, thickness and impermeability, this flooring is designed to provide the level of relaxation and comfort that this type of exercises require. It can also be used for any other type of floor activity (pilates, yoga,...)

Su textura, grosor e impermeabilidad proporcionan la relajación y el confort que requieren las actividades más suaves.




TAMAÑO LOSA / SIZE SHEET: 100X100 cm.



DENSIDAD / DENSITY: UNE 53526 120Kg/m3




VERDE / GREEN



IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY

COLORES / COLOURS

S Solido / Solid

AB D

EC

10010012

10030

10012123030

35,18 €8,98 €5,88 €

18,64 €12,13 €

SSSSS

35,18 €



Losa / TilePerfil / EdgeEsquina / CornerP.Cuña / WedgeE.Cuña / W.Corner

ABCDE

TATAMI

MM

MM

Diseñado para artes marciales:, karate, taekwondo, kickboxing, judo, aikido,...Designed for martial arts exercises, karate, taekwondo, kickboxing, judo, aikido,...

This flooring is completely impermeable to water or perspiration. It protects against falls, absorbs impact and gradually returns the energy generated, enabling a high level of fluidity of movement. Depending on the type of martial art to be practised, we will choose between two different tatami thicknesses: 20 mm (Karate, Taekwondo, Kickboxing…) and 30mm (Judo, Aikido…)

Protege las caídas, absorbe los impactos, retorna la energía generada y permite la agilidad en los movimientos. Es totalmente impermeable.





PESO LOSA / WEIGHT SHEET: 2.500 / 3.900 Kg/m2


DENSIDAD / DENSITY: UNE 53526 120 / 110 Kg/m3

DUREZA / HARDNESS: UNE 53130 DUREZA / SHORE A:40-45 / A45-50


AB D

C D E


VERDE / GREEN



IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY

COLORES / COLOURS

S Solido / Solid

2020202020

3030303030

10010012

10030

10010012

10030

10012123030

10012123030

35,18 €8,98 €5,88 €

18,64 €12,13 €

40,58 €10,55 €6,83 €

26,20 €18,64 €

aaaaSSSSS

SSSSS

35,18 €

40,58 €


*Losa / Tile*Perfil / Edge*Esquina / Corner*P.Cuña / Wedge*E.Cuña / W.Corner

ABCDE

ABCDE



* Superficie Burbujas / Piel Buble surface / leather

MM

AZUL / BLUE AZUL CELESTE / LIGTHBLUE

NARANJA / ORANGE PIOLIN/ YELLOW

ROJO / RED VERDE / GREEN

S S

S S

S S

Diseñado para las actividades de niños: guarderías, psicomotricidad, ludotecas,...Designed for children’s activities areas: nursery, psychomotor activities, toy libraries,...

Specially designed to help children's development at every stage, acting as a kind of «safety net» and allowing children to freely develop their motor skills. Its surface and its bright colours stimulate the senses. vIt is completely waterproof and acts as heat insulation to protect the child from direct contact with the floor, both against cold as well as dirt.

Pensado especialmente para ayudar al perfecto desarrollo del niño y sus actividades psicomotoras. Su superficie y sus llamativos colores fomentan la creatividad y la estimulación de los sentidos. Además, actúa como quitamiedos ante las caídas. Es totalmente impermeable y aislante térmico, protegiendo al niño del frío suelo y la suciedad.





PESO LOSA / WEIGHT SHEET: 2.600 Kg/m2


DENSIDAD / DENSITY: UNE 53526 130 Kg/m3


SEGURIDAD/ SECURITY: UNE EN 1177


AB D

C D E

S Solido / Solid

COLORES / COLOURS

10010012

10030

10012123030

35,18 €8,98 €5,88 €

18,64 €12,13 €

SSSSS

35,18 €ABCDE




Specially designed for individual floor exercises.Especialmente diseñado para actividades de suelo individuales.

INDIVIDUAL

140x60 160x60

AZUL / BLUE GAVIOTA / GREY

NARANJA / ORANGE ROJO / RED

VERDE / GREEN VIOLETA / VIOLET

VOLCAN / BROWN NEGRO / BLACK

S S

S S

S S

S S

The comfort of Paviflex Mats makes them our most valuable companion when it comes to individual floor exercises, whether in supervised sit-up classes or for stretching at the end of our sports activity.The excellent quality of Paviflex Mats awards the gym a guarantee of durability and resistance. Specific hangers to facilitate storage are available.


ACABADO / FINISH : 4 lados recto / 4 Straight Sides


TAMAÑO LOSA / SIZE SHEET: 140x60 / 160x60 cm.

PESO LOSA / WEIGHT SHEET: 900 Kg/m2


DENSIDAD / DENSITY: UNE 53526 100 Kg/m3

DUREZA / HARDNESS: UNE 53130 DUREZA / SHORE A: 30-35


Proporcionan tal comodidad que son el mejor compañero para los ejercicios individuales en el suelo y los estiramientos. Muy resistentes e impermeables y de fácil almacenamiento en sus colgadores

S Solido / Solid

COLORES / COLOURS

991919

MediumLargeMediumLargeMats wall hanger*

140160140160

60606060

16,30 €16,80 €24,70 €25,20 €12,81 €

SSSS

*Capacidad/Capacity: 10uds



ledFL

EXPack de 8 piezas de 50x50, conformando 2 metros cuadrados, para proteger el suelo de las marcas de una maquina fitness y para reducir las vibraciones de la misma.

8 pieces pack, 2 square meters of PaviFlex Gym Flooring to protect the floor and reduce vibrations of the fitness machine.

MM

S Solido / Solid

V Veteado / Veined



BRONCE / BRONZE

ORO / GOLDWENGUÉ*

V


Mb

HAYA*

V


V

VERDE / GREEN



IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY

COLORES / COLOURS


Mb

Mt

PLATA / SILVER

Mt

ORO VIEJO / OLD GOLDMt

Mt

Diseñado para proteger el suelo y reducir las vibraciones de maquinaria fitness.Designed to protect the floor and reduce vibrations of fitness machines.

NameNombre Color

ColourPrecioPrice

SV/Mb

MAXPACKMAXPACK

68,00 €74,80 €

2meters

1 meter

COLO

URS

JUNIORMM

9 pieces of 50x50cm of padded floor PaviFlex Junior. It protects the child while playing, reduces the risk of falling. It has thermal isolation properties, it is non slip and antibacterial, resistant and water proo. Really easy to install and uninstall.

Contiene 9 piezas de 50x50cms e suelo acolchado PaviFlex Junior. Protege a los niños en su juego, disminuye el riesgo de caídas, aísla del frío y del calor, es antideslizante y antibacterias, resistente e impermeable, y de muy facil montaje y desmontaje.

AZUL / BLUE AZUL CELESTE / LIGTHBLUE

NARANJA / ORANGE PIOLIN/ YELLOW

ROJO / RED VERDE / GREEN

S S

S S

S S

COLORES / COLOURS

S Solido / Solid

Es un elemento de protección y de aislamiento del suelo para niños.Junior is the floor for kids

NameNombre Color

ColourPrecioPrice

SJUNIORPACK 61,95 €

1,5 meters

1,5 meters

COLO

URS

LAD

DER

SPRI

NT

TRA

CK

HOO

PS

MET

RE

COMPASS

HEXAGON HANDS&FEET POSITIONING

JUMPS

PULLINGDISTANCE

standard

Send us your ideas and we will produce your designs.Functional training areas and customized flooring.

Realizamos cualquier diseño adaptado a tus necesidades.Zonas de entrenamiento funcional y suelo personalizado.

*CÉSPED / GRASS

*Consultar por colores personalizados*Ask for personalized colours

Es la solución óptima para todo tipo de entrenamiento.TurFlex is the best solution for all type of training.

Designed for intensive training and use of heavy equipment. TurFlex is UV resistant. We can customize TurFlex as per your request, always offering a real aspect of natural grass with a really easy installation system. We have added a FOAM base for impact absorption and vibration reduction. TurfFlex is an original alternative to take the floor of your gym to the next level.

Diseñado para el entrenamiento intensivo y la utilización de materiales pesados. Es personalizable 100%, tiene aspecto de césped natural y una instalación sencilla. Incorpora una base de FOAM para amortiguar los impactos y absorber las vibraciones. Es una alternativa original para llevar el suelo de tu gimnasio a otro nivel.

COLORES / COLOURS

TURFLEX1622

16221622

100100100100

100100100100

33,50 €43,50 €66,70 €93,25 €

StandardStandardCustomizedCustomized

Thickness SizeNameNOMBRE ESPESOR TAMAÑO €/losa

€/tile

ledFL

EXLedFlex is a new way of highlighting the floor of your gym. We have inserted Led lights on the floor, with a really easy interlock system and just a wire to plug on.Choose your mood and decide the colour of your room ambient with just a click. Choose your music and the lights will be synchronized with the rhythm. Enhace the training ambient.

LedFlex es una nueva manera de potenciar el suelo de tu gimnasio. Fácil instalación de puzzle, y fácil conexionado de LED’s con un único cable a conectar a la corriente eléctrica.Mejora el ambiente de entrenamiento. Elige un estado de ánimo, decide el color de la sala y la música y las luces se encargarán de acompañarte para un entrenamiento óptimo.

LIGHT UPYOUR FLOOR

COLO

URSAEROBIC FITNESS PAVIGOM ECOFLEX STRETCHING TATAMI JUNIORMAT030

WENGUÉ*

V


Mb

HAYA*

V


V

VERDE / GREEN

VIOLETA / VIOLET

VOLCAN / BROWN

AZUL CELESTE / LIGHTBLUE

PIOLIN / YELLOW

NARANJA / ORANGE

IBIZA / BEIGE

AZUL / BLUE

NEGRO / BLACK

ROJO / RED

GAVIOTA / GREY


Mb

ORO / GOLD

Mt

PLATA / SILVER

Mt

ORO VIEJO / OLD GOLDMt

BRONCE / BRONZEMt

GRIS / GREY

TERRA / BROWN

NEGRO / BLACK

COLO

URS GUARANTEE

The guarantee would be only valid against the manufactures defects and only under the guarantee conditions enclosed. There is a 2 years guarantee starting from the date of the sale and only if the handling, installation and terms of use are followed.For the guarantee to be valid, any manufacturers defect must be communicated in writing within 30 days from the receipt of the merchandise.Handling and receipt of the merchandise:The merchandise must not be exposed directly to the sun or rain or to a temperature over 40ºC.Before the installation of the merchandise the manufacturers must be advised of any defects on the sheet surface.The duty of the manufacturers would be to replace the damaged sheets which could have a slight variation in colour or sheen on their surface.HOW TO INSTALLInstallation grounds:The surface / ground where the paving is going to be installed must be completely smooth to avoid any intervals when assembling the pieces together.Temperature:The paving cannot be exposed to a temperature over 40oC.Sun exposure:The areas exposed to a higher level of sun exposure can suffer changes such as loss of sheen, etc.In the case that the installation is located by a window or any other area where the sun exposure would affect the paving, it must somehow be protected to avoid the sheets to get to a temperature higher than 40 oC.Our products are all indoor products; outdoors they could suffer changes in colour or malformation.This product expands and contracts depending on the temperature; the sheet is made with a composition of Rubber and Vinyl Acetate which results in a micro cellular product.As a general norm, when installing the paving, a margin must be left between the wall and the sheet which would allow theexpansion and contraction of the paving, this margin would depend on grounds m2 ( about 2mm per lineal metre) If the margin is not taken into consideration with the expansion and contraction the floor could raise up.Assembling orderThe easiest way to make sure that the installation is carried out correctly would be starting with the middle sheets going outwards from there in a cross shape filling up the areas in a radial order.To adjust the sheets in the end areas or those located against a wall or pillar, a cutting line must be marked then making a small incision with a knife going over it several times.TERMS OF USEPaviflex Pavimento is a product with exclusive application to sport activities, which can only be walked on with sports footwear, with rubber soles except for Paviflex Tatami for Martial Arts and Stretching which we must have bear feet.Paviflex Junior is a paving which only use is in children playgrounds which feet must always be bear.Paviflex Tatami & Paviflex Junior will not be resistant to any structures or machinery.The guarantee would be voided when the precautionary measures are not complied such as using the wrong footwear, using abrasive piercing products, using it for other different things which they are not designed for.Special care should be taken not to unload heavy merchandise with sharp ends which could mark and possibly break it notrecovering its original condition.CLEANING AND MAINTENANCEThe cleaning of the paving would be carried out using cold soapy water, using a clean mop free of residues, not using brushes or files which can scratch the surface of it.

Documents

Tarifa PaviFlex 2016