TC500 Service Manual

- 1 -

Contents General……………………………………………………………………………2

Brief Introduction………………………………………………………………..3

Software Description…………………………………………………………..5

Circuit Description……………………………………………………………..9

CPU Pins…………………………………………………………………………13

TC-500(U) Part List 1………………………………………………………….15

TC-500(V) Part List 1………………………………………………………….27

Adjustment Description……………………………………………………….39

Disassembly and Assembly………………………………………………..43

Exploded View………………………………………………………………..46

Part List 2……………………………………………………………………….47

Packing…………………………………………………………………………..48

PC Board View………………………………………………………………….49

Block Diagram…………………………………………………………………..53

Schematic Diagram…………………………………………………………..54

Specifications…………………………………………………………………56

TC-500 Service Manual

－ 2 －

General

Manual Scope This manual is intended for use by experienced technicians familiar with similar types of communication equipment. It contains all service information required for the equipment and is current as of the publication date.

User Safety Information

The following precautions are recommended for personnel safety: DO NOT transmit until all RF connectors are verified secure and any open connectors are

properly terminated. SHUT OFF and do not operate this equipment near electrical blasting caps or in an explosive

atmosphere. When in vehicles with an airbag, do not place a portable radio in the area over an airbag or in the

airbag deployment area. Do not expose the radio to direct sunlight for a long time nor place it close to a heating source. Do not use any portable radio with a damaged antenna. If a damaged antenna comes into contact

with your skin, a minor burn may result. When transmitting with a portable radio, hold the radio in a vertical position with its microphone

about 5 centimeters away from your mouth. If you wear a portable radio on your body, be sure to keep the antenna at least 2.5 centimeters

away from your head or body when transmitting. This equipment should be serviced by qualified technicians only.


－ 3 －

Brief Introduction

12 3 4

56

7

8 9

10

11

12

13

1. Antenna 2. LED indicator

The light will glow red during transmission. The light will glow green during receiving. During transmission, the light flashes red when the battery voltage is low.

3. Channel selector knob Turn the channel selector knob to select from channels 1-16 (Channel 16 can be programmed by your dealer as scan function).

4. Power/Volume control knob Rotate the Power/Volume Knob clockwise until a “click” is heard to turn the radio on, fully counter clockwise until a “click” is heard to turn the radio off. When the radio is on, turn the knob to adjust volume.

5. PTT key Press and hold PTT key to talk, release to receive.

6. Monitor key In receive mode, long press (above 2 seconds) Monitor key to monitor activity on the current channel.

7. Microphone


－ 4 －

8. Speaker 9. External jack

Remove the jack cover and insert an earphone; or insert programming cable into the jack to programme the radio via programming software.

10. Battery 11. Belt clip

Used to clip radio on your belt. 12. Battery latch

Used to fasten and remove the battery. 13. Charging connectors

Connect the charging connectors with that on the charger to begin charging.


－ 5 －

Software Specification Radio Feature Description

1. Use channel selector knob to choose from 15+1(Scan) channels 2. Monitor 3. CTCSS/CDCSS

Non-standard Model (Other): 38+83 groups 4. Channel Spacing

12.5KHz/25KHz Narrow/wide Optional 5. Channel Scan (Priority channel and scan revert channel available) 6. Battery Save feature (Dealer programmable) 7. Time-out Timer (TOT) 8. High/low Power Switch 9. Squelch Level Control (9 levels) 10. Low Battery Alert 11. Model Set Mode 12. PC Programming and Adjusting Mode 13. User Wired Clone Mode 14. Factory Wired Clone Mode 15. Manual Adjust Mode

Radio Modes 1. User Mode:

User mode is conventional communication mode. Turn the power on while disconnecting the two SELF points, the

radio enters user mode. (Refer to “TC-500 Owner’s Manual” for details about operation in this mode.)

2. Model Set Mode (1) If the radio is standard model, short out the two MS2 points on PCB and then operate following the steps (3) (5) and

(6). If the radio is non-standard model, please disconnect the two MS2 points on PCB and then operate the

following steps.

(2) To select MS1 (See the initial data table) according to the radio model, if MS1 is 1, short out the two MS1 points on

PCB and continue the following operation. If not, disconnect the two MS1 points and continue.

(3) Short out the two SELF points on PCB and then turn the power on. Two beeps sound.

(4) Turn channel selector knob to the corresponding position (1-11) according to the radio model (Refer to the initial

data table).

(5) Press PTT key while holding down MONI key to set the model. Channel data and settings are initialized (Refer to

the initial data table).

(6) Turn off the power and then disconnect the two SELF points on PCB to complete the model setting.

For example, MS1 of TC-500-U (450.000~469.995MHz) is 0 (See the initial data table). Its number is 7. It is

unnecessary to short out MS1 and MS2. To initialize its model and channel data, you can operate as following:


－ 6 －

(1) Short out the two SELF points on PCB;

(2) Turn on the power and turn the channel selector knob to the position 7;

(3) Press PTT key while holding down MONI key;

(4) After data reset, turn off the power, disconnect the two SELF points and restart the power to use the radio.

Remarks: The old data (frequency, CTCSS/CDCSS, channel function settings) will be changed once the model is set,

and part of functions will also be changed. Therefore, do not make this operation unless it’s very necessary, such as

changing the EEPROM, etc.

3. PC Programming Mode The following parameters can be set through programming software:

（1） Receive frequency and transmit frequency

（2） Receive signaling and transmit signaling

（3） Busy channel lockout

（4） Time-out timer

（5） Squelch level

（6） Battery save

（7） Audio alarm

（8） Monitor mode

（9） Scan mode

（10） Scan revert channel

（11） Priority scan channel

（12） N/W Model

（13） High/low power

（14） N/W setting

4. PC Adjusting Mode The following parameters can be set via PC programming software:

(1) Low battery alert level

(2) Squelch level 9

(3) Squelch level 3

(4) CTCSS deviation (wide)

(5) CDCSS deviation (wide)

(6) CTCSS deviation (narrow)

(7) CDCSS deviation (narrow)

5. Manual Adjust Mode If manual adjust mode is enabled, turn on the power while holding down PTT and MONI simultaneously, the radio enters

manual adjust mode after 2 seconds. Choose the adjusting items by turning the channel selector knob to CH1-CH7

position; use PTT (upwards) or MONI (downwards) to adjust (Note: MIC jack shouldn’t be connected with external cable

while adjusting), CH1-CH7 positions are defined as follows:

(1) Low battery alert level

(2) Squelch level 9


－ 7 －

(3) Squelch level 3

(4) CTCSS deviation (wide)

(5) CDCSS deviation (wide)

(6) CTCSS deviation (narrow)

(7) CDCSS deviation (narrow)

CH13-CH16 are used to adjust transmitter and receiver. Press PTT to transmit; release to receive. CH13-CH16 are

defined as follows:

(13) Center frequency (difference between transmit and receive frequency is 0.1MHz)

(14) Lowest frequency (difference between transmit and receive frequency is 0.1MHz)

(15) Highest frequency (difference between transmit and receive frequency is -0.075MHz)

(16) Center frequency: transmit with 250.3Hz CTCSS tone (difference between transmit and receive frequency is

0.1MHz)

Note: To enable or disable manual adjust mode: short out the two SELF points, turn on the power to enter model set mode. And then the manual adjust mode is enabled. Press [PTT], manual adjust mode is disabled. This mode is suggested to be disabled after the adjustment is completed.

6. User/Factory Wired Clone Mode Turn on the power while holding down MONI, the radio enters wired clone mode.

(1) If the two SELF points are disconnected, press MONI again to begin user wired clone and red LED blinks; When

cloning is completed, red LED goes out.

(2) If the two SELF points are short circuit, press MONI again to begin factory wired clone and red LED blinks; When

cloning is completed, red LED goes out.

Note: The difference between user wired clone mode and factory wired clone mode is that the latter is able to clone

tune parameters.


- 8 -

Initial data table

Note: For standard model, CTCSS is off in all channels after initialization.

1CH(Center) 2CH(Low) 3CH(High) 4CH 5CH 6CH 7CH 8CH 9-16CH MS1 Model

Frequency (MHz) IF (MHz) Tx

(MHz)

Rx

(MHz)

Tx

(MHz)

Rx

(MHz)

Tx

(MHz)

Rx

(MHz)

(MHz)

(MHz)

(MHz)

(MHz)

(MHz)

(MHz)

0 1 150.000~173.995 +21.4 162.000 162.100 150.000 150.100 173.975 173.900 162.500 162.550 162.600 162.550 162.650

0 2 136.000~149.995 +21.4 143.000 143.100 136.000 136.100 149.975 149.900 143.500 143.550 143.600 143.550 143.650

0 3 146.000~173.995 +21.4 160.000 160.100 146.000 146.100 173.975 173.900 160.500 160.550 160.600 160.550 160.650

0 4 144.000~147.995 +21.4 146.000 146.100 144.000 144.100 147.975 147.900 146.500 146.550 146.600 146.550 146.650

0 5 136.000~147.995 +21.4 142.000 142.100 136.000 136.100 147.975 147.900 142.500 142.550 142.600 142.550 142.650

0 6 136.000~173.995 +21.4 155.000 155.100 136.000 136.100 173.975 173.900 155.500 155.550 155.600 155.550 155.650

0 7 450.000~469.995 -21.4 460.000 460.100 450.000 450.100 469.975 469.900 460.300 460.350 460.400 460.350 460.450

0 8 400.000~419.995 -21.4 410.000 410.100 400.000 400.100 419.975 419.900 410.500 410.550 410.600 410.550 410.650

0 9 470.000~489.995 -21.4 480.000 480.100 470.000 470.100 489.975 489.900 480.500 480.550 480.600 480.550 480.650

0 10 490.000~511.995 -21.4 501.000 501.100 490.000 490.100 511.975 511.900 501.500 501.550 501.600 501.550 501.650

0 11 220.000~239.995 -21.4 230.000 230.100 220.000 220.100 239.975 239.900 230.500 230.550 230.600 230.550 230.650

1 1 240.000~259.995 -21.4 250.000 250.100 240.000 240.100 259.975 259.900 250.500 250.550 250.600 250.550 250.650

1 2 336.000~367.995 -21.4 352.000 352.100 336.000 336.100 367.975 367.900 352.500 352.550 352.600 352.550 352.650

1 3 368.000~395.995 -21.4 382.000 382.100 368.000 368.100 395.975 395.900 382.500 382.550 382.600 382.550 382.650

1 4 370.000~389.995 -21.4 380.000 380.100 370.000 370.100 389.975 389.900 380.500 380.550 380.600 380.550 380.650

1 5 350.000~369.995 -21.4 360.000 360.100 350.000 350.100 369.975 369.900 360.500 360.550 360.600 360.550 360.650

1 6 406.000~429.995 -21.4 418.000 418.100 406.000 406.100 429.975 429.900 418.500 418.550 418.600 418.550 418.650

1 7 400.000~429.995 -21.4 415.000 415.100 400.000 400.100 429.975 429.900 415.500 415.550 415.600 415.550 415.650

1 8 430.000~439.995 -21.4 435.000 435.100 430.000 430.100 439.975 439.900 435.500 435.550 435.600 435.550 435.650

1 9 438.000~449.995 -21.4 444.000 444.100 438.000 438.100 449.975 449.900 444.500 444.550 444.600 444.550 444.650

1 10 480.000~519.995 -21.4 500.000 500.100 480.000 480.100 519.975 519.900 500.500 500.550 500.600 500.550 500.650

1 11 441.000~451.000 -21.4 446.000 446.100 441.000 441.100 450.975 450.900 446.500 446.550 446.600 446.550 446.650

Standard 446.00625~446.09375 -21.4 446.00625 446.00625 446.01875 446.01875 446.03125 446.03125 446.04375 446.05625 446.06875 446.08125 446.09375

CH QT/DQT OFF OFF OFF OFF OFF OFF OFF 023 023 127.3 151.4


- 9 -

Circuit Description 1. Frequency Configuration

The receiver utilizes double conversion superheterodyne. The first IF is 21.4MHz and the second is 455KHz. The first local oscillator signal is supplied from PLL circuit. Frequency needed in the transmitter is supplied from PLL circuit. Figure 1 shows the frequency configuration.

Frequency Range: 400 MHz—420MHz 450 MHz—470MHz

136 MHz—150MHz 150 MHz—174MHz

Figure 1 frequency configuration

2. Receiver The receiver utilizes double conversion superheterodyne. 1) Front-end RF Amplifier

The input signal from antenna is amplified in RF amplifier (Q27) after passing through the receive/transmit switch circuit and a 3-stage LC band pass filter. The amplified signals are filtered by a band pass filter (a 3-stage LC BPF) to eliminate unwanted signals before they goes to the first frequency mixer.

Figure 2 receiver section configuration


- 10 -

2) The First Mixer The signal from RF amplifier is mixed with the first local oscillator signal from PLL frequency synthesizer in the first mixer (Q23) to generate a 21.4MHz first IF signal. The first IF signal is then fed through two monolithic crystal filters (XF1) to remove spurious signals from adjacent channels.

3) IF Amplifier The first IF signal is amplified in Q22 and then enters the IF process chip IC1. The signal is mixed with the second local oscillator signal in IC1 to create a 455KHz second IF signal. The second IF signal is then fed to a 455KHz ceramics filter (CF1) to eliminate unwanted signals before it is amplified and FM detected in IC1. 4) AF Amplifier The demodulated AF signal obtained from IC1 is amplified in IC7 (1/4), and then filtered by low pass filter Q19 and high pass filter Q20, and then de-emphasized by R130 and C156. The resulting AF signal passes through a volume control circuit and then is amplified to a sufficient level to drive the speaker by AF power amplifier (IC8). 5) Squelch Part of the AF signal from IC1 enters IC1 again, and the noise component is amplified and rectified by a filter and an amplifier to produce a DC voltage corresponding to the noise level. The DC signal from IC1 goes to the analog port of the microprocessor (IC11). IC11 determines whether to output sounds from the speaker by detecting whether the input voltage is higher or lower than preset value.

To output sounds from the speaker, IC11 sends a high level signal to the MUTE and AFCO lines and turns IC8 on through Q12.

DET

FM IF IC1

IF AMP

HPFAMP

IC7

AF LPF HPFDET

2 39 40 1

SW

Q12

SW

AF/PF AMP

IC7LPF

IC11MCU

BU

SY

MU

TE

AFC

O

TI

IC8SP

Figure 3. AF amplifier and squelch circuit


- 11 -

6) Receive signaling CTCSS/CDCSS Audio frequencies over 300Hz of the output signal from IC1 is cut off by a low-pass filter. The resulting signal enters the microprocessor IC11. IC11 determines whether the CTCSS/CDCSS matches the preset value and controls the MUTE and AFCO and the speaker sound output according to the squelch results.

3. PLL Frequency Synthesizer

PLL circuit generates the first local oscillator signal for reception and the RF signal for

transmission.

1) PLL Circuit

The step frequency of PLL circuit is 2.5KHz or 6.25 KHz. A12.8MHz reference oscillator signal is divided at IC2 by a fixed counter to produce a 2.5 KHz or 6.25 KHz reference frequency. Output signal from voltage control oscillator (VCO) passes through buffer amplifier Q14 and is divided at IC2 by the dual-module programmable counter. The divided signal is compared in the phase comparator IC2 with the 2.5 KHz or 6.25 KHz reference signal. The output signal from phase comparator is filtered through a low-pass filter and passed to the VCO to control the oscillator frequency. (See figure 4)

Figure 4 PLL circuit

2) VCO

The operating frequency is generated by Q16 in transmit mode and by Q8 in receive mode. The operation frequency generates a voltage through the phase comparator to control the varactor diodes, so as to keep the oscillator frequency consistent with the preset frequency in CPU (D2 and D3 in transmit mode and D7 and D8 in receive mode). T/R pin is set high in receive mode causing Q6 to turn off Q16 and turn Q7 on. The T/R pin is set low in transmit mode. The output from Q8 and Q16 is amplified by Q14 and sent to the buffer amplifier.


- 12 -

4. Transmitter

1) Transmit audio The audio signal from microphone is amplified through IC3, and then pre-emphasized , and then filtered by another low-pass filter（separate filter）(Q25 and Q24) to eliminate the frequencies over 3KHz. The resulting signal enters the VCO for direct FM modulation. (See figure 5)

2) CTCSS/CDCSS Encoder The necessary frequency for CTCSS/CDCSS encoder is generated by IC11 and FM-modulated to the PLL reference signal. Since the reference OSC does not modulate the loop characteristic frequency or higher, modulation is performed at the VCO side by splitter. (See figure 5)

Figure 5 transmit CTCSS 3) RF amplifier

The transmit signal obtained from VCO buffer amplifier Q14 is amplified by Q15 and Q17. This amplified signal is passed to power amplifier Q32 and Q31, and is capable of producing a 4.0W RF power.

4) Antenna Switch and LPF The RF amplifier output signal is passed through a low-pass filter network and a transmit/receive switch circuit before it is passed to the antenna terminal. The transmit/receive switch circuit is comprised of D11 and D12. D11 and D12 is turned on in transmit mode and off in receive mode.

5. Power

The 5V reference power supply for the control circuit is derived from an internal battery. The reference power provides a 5V supply in transmit mode [T_V], a 5V supply in receive mode [R_V], and a 5V supply shared in both modes based the control signal from the microprocessor.

6. Control System

The IC11 CPU operates at 7.3728MHz.


- 13 -

CPU Pins PIN No. PIN NAME I/O DESCRIPTION

1 TI I CTCSS/CDCSS input

2 BUSY I Input busy signal

3 BATT I Detect battery voltage

4 TIBI I CTCSS/CDCSS exterior circuit central point input

5 NC

6 SAVE O Power saving control H: OFF L: ON

7 TXLow O Transmitter power control H: Low power L: High power

8 NC

9 DAT O data output

10 CLK O clock output

11 LE O PLL IC enable

12 BEEP O Beep output

13 SCL O E2PROM clock cable

14 SDA I/O E2PROM data cable

15 MUTE O MIC mute control H: Mic mute L: Mic enable

16 MS1 I Model set

17 GREEN O Green light control H: light

18 RED O Red light control H: light

19 TXD O RS-232C output

20 RXD I RS-233C input

21 PTTK I PTT key input

22 MS2 I Standard model select H: Non-standard L: Standard

23 RXC O Receiver power control L: power on

24 NC

25 RESET I Reset input

26 SELF I Self-program L: on

27 TXC O Transmitter power control H:on

28 XIN I Oscillator input

29 XOUT O Oscillator output

30 Vss I Grounding

31 R/T O TX/RX control H：RX L： TX

32 UL I PLL unlock detector H: Lock L: unlock

33 IF-SELECT I IF select H: 21.4MHz L: 45.05MHz

34 MONIK I MONI key input

35 ENC0 I

36 ENC1 I

37 ENC2 I

Channel selector knob encode input


- 14 -

38 ENC3 I

39 AFMUTE O Audio muting control

40 AFP O Audio power control

41 TONE5 O CTCSS code output






47 WNTC O W/N L: Wide H: Narrow

47-70 NC

71 Vcc I Power input: 5V

72 VREF I A-D converse reference voltage

73 Avss I A-D GND

74-77 NC

78 NC

79 NC

80 NC


- 15 -

TC-500U Part List 1 No. Ref. No. Address Material No. Material Description Remark1 R1 B4B 3001066840000 Resistor 0603　680KΩ　 J

2 R2 B3C 3001062740010 Resistor 0603　270KΩ　J

3 R3 B4B 3001062220000 Resistor 0603　2.2KΩ　J

4 R4 T2B 3001064730000 Resistor 0603　47KΩ　J

5 R5 B4E 3001063310010 Resistor 0603　330Ω　J

6 R6 T2B 3001062220000 Resistor 0603　2.2KΩ　J

7 R7 B4B 3001061040010 Resistor 0603　100KΩ　J

8 R8 B2E 3001061040010 Resistor 0603　100KΩ　J

9 R9 B1D 3001061040010 Resistor 0603　100KΩ　J

10 R10 B4C 3001061040010 Resistor 0603　100KΩ　J

11 R11 B3B 3001061240010 Resistor 0603　120KΩ　J

12 R12 B4B 3001061040010 Resistor 0603　100KΩ　J

13 R13 B3D 3001061040010 Resistor 0603　100KΩ　J

14 R14 B3D 3001061540000 Resistor 0603　150KΩ　J

15 R15 B3D 3001061040010 Resistor 0603　100KΩ　J

16 R16 B3D 3001062740010 Resistor 0603　270KΩ　J

17 R18 T2C 3001061040010 Resistor 0603　100KΩ　J

18 R22 T1D 3001064740010 Resistor 0603　470KΩ J

19 R24 T2G 3001063330010 Resistor 0603　33KΩ　J

20 R25 B4B 3001063320000 Resistor 0603　3.3KΩ　J

21 R26 B4D 3001063320000 Resistor 0603　3.3KΩ　J

22 R27 B2F 3001063320000 Resistor 0603　3.3KΩ　J

23 R28 B1F 3001063320000 Resistor 0603　3.3KΩ　J

24 R29 B2D 3001063320000 Resistor 0603　3.3KΩ　J

25 R30 B2E 3001063320000 Resistor 0603　3.3KΩ　J

26 R31 B3G 3001063320000 Resistor 0603　3.3KΩ　J

27 R32 B5E 3001063320000 Resistor 0603　3.3KΩ　J

28 R33 T5F 3001063320000 Resistor 0603　3.3KΩ　J

29 R34 B2D 3001063320000 Resistor 0603　3.3KΩ　J

30 R35 T2C 3001061040010 Resistor 0603　100KΩ　J

31 R36 B4B 3001061030010 Resistor 0603　10KΩ　J

32 R37 T2E 3001061030010 Resistor 0603　10KΩ　J

33 R38 B2A 3001061030010 Resistor 0603　10KΩ　J

34 R39 B3B 3001061020010 Resistor 0603　1KΩ　J

35 R40 B3F 3001061030010 Resistor 0603　10KΩ　J

36 R41 T5F 3001061030010 Resistor 0603　10KΩ　J

37 R42 T5E 3001061030010 Resistor 0603　10KΩ　J

38 R43 T2A 3001063340000 Resistor 0603　330KΩ　J

39 R44 B2I 3001061030010 Resistor 0603　10KΩ　J

40 R45 B2I 3001061030010 Resistor 0603　10KΩ　J

41 R47 B4D 3001068210010 Resistor 0603　820Ω　J

42 R48 B3E 3001061520000 Resistor 0603　1.5KΩ　J

43 R49 B4D 3001062720000 Resistor 0603　2.7KΩ　J

44 R50 T5F 3001061520000 Resistor 0603　1.5KΩ　J


- 16 -

No. Ref. No. Address Material No. Material Description Remark45 R51 B1F 3001061020010 Resistor 0603　1KΩ　J

46 R52 T3F 3001061020010 Resistor 0603　1KΩ　J

47 R53 B2D 3001061020010 Resistor 0603　1KΩ　J

48 R54 T3G 3001064730000 Resistor 0603　47KΩ　J

49 R55 T2E 3001061520000 Resistor 0603　1.5KΩ　J

50 R56 B2B 3001061020010 Resistor 0603　1KΩ　J

51 R57 B5B 3001061020010 Resistor 0603　1KΩ　J

52 R58 T4B 3001061020010 Resistor 0603　1KΩ　J

53 R59 T3B 3001061020010 Resistor 0603　1KΩ　J

54 R60 T2D 3001061020010 Resistor 0603　1KΩ　J

55 R61 T2D 3001061020010 Resistor 0603　1KΩ　J

56 R62 B2I 3001064710000 Resistor 0603　470Ω　J

57 R64 B2G 3001062720000 Resistor 0603　2.7KΩ　J

58 R65 B2G 3001062720000 Resistor 0603　2.7KΩ　J

59 R66 B1F 3001068210010 Resistor 0603　820Ω　J

60 R67 B2D 3001062210000 Resistor 0603　220Ω　J

61 R68 B2E 3001061510000 Resistor 0603　150Ω　J

62 R69 B2C 3001061510000 Resistor 0603　150Ω　J

63 R70 B3F 3001066810010 Resistor 0603　680Ω　J

64 R72 B2D 3001061240010 Resistor 0603　120KΩ　J

65 R74 B2C 3001061010000 Resistor 0603　100Ω　J

66 R75 B4J 3001061010000 Resistor 0603　100Ω　J

67 R76 B5E 3001061010000 Resistor 0603　100Ω　J

68 R77 T2H 3001080000000 Resistor 1206　0Ω　J

69 R79 B2D 3001065620010 Resistor 0603　5.6KΩ　J

70 R80 B2D 3001061000000 Resistor 0603　10Ω　J

71 R81 B3F 3001063020000 Resistor 0603　3.0KΩ　J

72 R82 B4G 3001061000000 Resistor 0603　10Ω　J

73 R84 B2C 3001064720000 Resistor 0603　4.7KΩ　J

74 R85 T4F 3001066820000 Resistor 0603　6.8KΩ　J

75 R87 T2A 3001064720000 Resistor 0603　4.7KΩ　J

76 R88 T1C 3001064720000 Resistor 0603　4.7KΩ　J

77 R89 T4I 3001061020010 Resistor 0603　1KΩ　J

78 R90 T5H 3001061010000 Resistor 0603　100Ω　J

79 R93 T2F 3001064730000 Resistor 0603　47KΩ　J

80 R94 T3F 3001064740010 Resistor 0603　470KΩ J

81 R96 B2B 3213306102000 Inductor 0603 1uH

82 R97 B3C 3001068230010 Resistor 0603　82KΩ　J

83 R98 B3D 3001062030000 Resistor 0603　20KΩ　J

84 R99 T1B 3001064720000 Resistor 0603　4.7KΩ　J

85 R100 T4B 3001061030010 Resistor 0603　10KΩ　J

86 R101 B4H 3001064730000 Resistor 0603　47KΩ　J

87 R102 B3H 3001063330010 Resistor 0603　33KΩ　J

88 R103 B4G 3001065630000 Resistor 0603　56KΩ　J

89 R104 B3H 3001062230000 Resistor 0603　22KΩ　J

90 R105 B1E 3001064730000 Resistor 0603　47KΩ　J


- 17 -

No. Ref. No. Address Material No. Material Description Remark91 R106 T3F 3001060000000 Resistor 0603　0Ω　 J

92 R107 B3B 3001060000000 Resistor 0603　0Ω　 J

93 R108 B3E 3001060000000 Resistor 0603　0Ω　 J

94 R109 T2B 3001061050010 Resistor 0603　1.0MΩ　J

95 R110 T4G 3001060000000 Resistor 0603　0Ω　 J

96 R111 B4E 3101064710000 Capacitor 0603　470P K 50V

97 R112 T3E 3001061000000 Resistor 0603　10Ω　J

98 R113 T5J 3001061000000 Resistor 0603　10Ω　J

99 R114 B1B 3001063920000 Resistor 0603　3.9KΩ　J

100 R115 B2A 3001064700000 Resistor 0603　47Ω　J

101 R116 T3B 3001061050010 Resistor 0603　1.0MΩ　J

102 R117 B2B 3001066820000 Resistor 0603　6.8KΩ　J

103 R118 B2I 3001064710000 Resistor 0603　470Ω　J

104 R120 T4G 3001062230000 Resistor 0603　22KΩ　J

105 R121 T1B 3001064720000 Resistor 0603　4.7KΩ　J

106 R122 B3G 3001063310010 Resistor 0603　330Ω　J

107 R123 B3G 3001064700000 Resistor 0603　47Ω　J

108 R124 T3F 3001061240010 Resistor 0603　120KΩ　J

109 R125 B3H 3001064700000 Resistor 0603　47Ω　J

110 R127 B5F 3001061010000 Resistor 0603　100Ω　J

111 R128 B3B 3001063330010 Resistor 0603　33KΩ　J

112 R130 B4B 3001065620010 Resistor 0603　5.6KΩ　J

113 R131 T4E 3001061820000 Resistor 0603　1.8KΩ　J

114 R132 B3C 3001062730010 Resistor 0603　27KΩ　J

115 R133 T2C 3001068230010 Resistor 0603　82KΩ　J

116 R134 B3C 3001066840000 Resistor 0603　680KΩ　 J

117 R135 B4B 3001063320000 Resistor 0603　3.3KΩ　J

118 R136 B4A 3001063320000 Resistor 0603　3.3KΩ　J

119 R137 B4B 3001063320000 Resistor 0603　3.3KΩ　J

120 R138 B5A 3001063320000 Resistor 0603　3.3KΩ　J

121 R139 B4B 3001061540000 Resistor 0603　150KΩ　J

122 R140 B4A 3001061540000 Resistor 0603　150KΩ　J

123 R141 B4A 3001061540000 Resistor 0603　150KΩ　J

124 R142 B4A 3001061540000 Resistor 0603　150KΩ　J

125 R144 B3C 3001061820000 Resistor 0603　1.8KΩ　J

126 R145 T5F 3001062240010 Resistor 0603　220KΩ　J

127 R146 B4D 3001063310010 Resistor 0603　330Ω　J

128 R147 B4E 3001061010000 Resistor 0603　100Ω　J

129 R148 B4D 3001065640000 Resistor 0603　560KΩ　J

130 R149 B3E 3001065630000 Resistor 0603　56KΩ　J

131 R150 B5F 3101064710000 Capacitor 0603　470P K 50V

132 R151 B5E 3001060000000 Resistor 0603　0Ω　 J

133 R152 T5F 3001063930010 Resistor 0603　39KΩ　J

134 R153 T5F 3001063930010 Resistor 0603　39KΩ　J

135 R154 T4F 3001064730000 Resistor 0603　47KΩ　J

136 R155 T5G 3001061850000 Resistor 0603　1.8MΩ　J


- 18 -

No. Ref. No. Address Material No. Material Description Remark137 R156 T5F 3001061850000 Resistor 0603　1.8MΩ　J

138 R157 T4F 3001065630000 Resistor 0603　56KΩ　J

139 R158 T5F 3001063930010 Resistor 0603　39KΩ　J

140 R159 T5E 3001063930010 Resistor 0603　39KΩ　J

141 R160 T4G 3001067540000 Resistor 0603　750KΩ　J

142 R161 T4F 3001061530010 Resistor 0603　15KΩ　J

143 R162 T4G 3001061530010 Resistor 0603　15KΩ　J

144 R163 T4F 3001061530010 Resistor 0603　15KΩ　J

145 R164 B2C 3001061000000 Resistor 0603　10Ω　J

146 R165 B4F 3001062220000 Resistor 0603　2.2KΩ　J

147 R166 B4F 3001064710000 Resistor 0603　470Ω　J

148 R167 T1D 3001062240010 Resistor 0603　220KΩ　J

149 R169 B1D 3001068220000 Resistor 0603　8.2KΩ　J

150 R170 B1D 3001061230000 Resistor 0603　12KΩ　J

151 R171 B1D 3001068200000 Resistor 0603　82Ω　J

152 R172 T2H 3001080000000 Resistor 1206　0Ω　J

153 R173 T2I 3001080000000 Resistor 1206　0Ω　J

154 R174 T4H 3001062220000 Resistor 0603　2.2KΩ　J

155 R175 T2B 3001061040010 Resistor 0603　100KΩ　J

156 R176 T2B 3001061040010 Resistor 0603　100KΩ　J

157 R177 T2A 3001064720000 Resistor 0603　4.7KΩ　J

158 R191 B2B 3001064700000 Resistor 0603　47Ω　J

159 R192 B4E 3001060000000 Resistor 0603　0Ω　 J

160 R194 B3F 3001060000000 Resistor 0603　0Ω　 J

161 R196 B4G 3001061000000 Resistor 0603　10Ω　J

162 R197 B4F 3001060000000 Resistor 0603　0Ω　 J

163 R198 T4E 3001066830000 Resistor 0603　68KΩ　J

164 R200 B2B 3101061040010 Capacitor 0603　0.1uF K 16V

165 R202 B2B 3001063310010 Resistor 0603　330Ω　J

166 R203 T2E 3001061020010 Resistor 0603　1KΩ　J

167 R204 T2G 3001061230000 Resistor 0603　12KΩ　J

168 R508 B5B 3001060000000 Resistor 0603　0Ω　 J

169 R601 B1E 3001063320000 Resistor 0603　3.3KΩ　J

170 R602 B3C 3001060000000 Resistor 0603　0Ω　 J

171 R606 T3I 3001064730000 Resistor 0603　47KΩ　J

172 R607 T3I 3001064730000 Resistor 0603　47KΩ　J

173 R608 T3I 3001064730000 Resistor 0603　47KΩ　J

174 R609 T3I 3001064730000 Resistor 0603　47KΩ　J

175 R610 T2C 3001064730000 Resistor 0603　47KΩ　J

176 R615 B3B 3001064730000 Resistor 0603　47KΩ　J

177 R616 T3E 3001061510000 Resistor 0603　150Ω　J

178 R617 B4H 3001063930010 Resistor 0603　39KΩ　J

179 R618 B5F 3001066830000 Resistor 0603　68KΩ　J

180 R619 B4D 3001068210010 Resistor 0603　820Ω　J

181 R622 B3B 3001054730000 Resistor 0402　47KΩ　 J

182 R623 B4E 3001061040010 Resistor 0603　100KΩ　J


- 19 -

No. Ref. No. Address Material No. Material Description Remark183 R624 B4F 3001061040010 Resistor 0603　100KΩ　J

184 R625 B3E 3001061040010 Resistor 0603　100KΩ　J

185 R626 B3F 3001061040010 Resistor 0603　100KΩ　J

186 R627 B3F 3001065630000 Resistor 0603　56KΩ　J

187 R628 T2E 3001068220000 Resistor 0603　8.2KΩ　J

188 C1 B4B 3104081060080 Ta-capacitor 1206 10uF 10V.M

189 C2 B4B 3101051030020 Capacitor 0402　0.01uF K 16V


191 C4 B4C 3101051030020 Capacitor 0402　0.01uF K 16V

192 C5 B1F 3101051030020 Capacitor 0402　0.01uF K 16V


194 C8 B4A 3101051030020 Capacitor 0402　0.01uF K 16V

195 C9 T5F 3101051030020 Capacitor 0402　0.01uF K 16V


197 C11 T1B 3101051030020 Capacitor 0402　0.01uF K 16V

198 C12 B3I 3101051030020 Capacitor 0402　0.01uF K 16V

199 C13 B4B 3101052210010 Capacitor 0402　220P J 50V


201 C15 B2A 3101051010030 Capacitor 0402　100P J 50V




205 C19 B5H 3101061800000 Capacitor 0603　18P J 50V

206 C20 B4B 3101054710010 Capacitor 0402　470P K 50V

207 C21 B2E 3101054710010 Capacitor 0402　470P K 50V

208 C22 B2D 3101054710010 Capacitor 0402　470P K 50V

209 C23 B3F 3001060000000 Resistor 0603　0Ω　 J

210 C24 B4G 3101054710010 Capacitor 0402　470P K 50V




214 C28 B4H 3101054710010 Capacitor 0402　470P K 50V

215 C29 B3I 3101054710010 Capacitor 0402　470P K 50V




219 C33 B5F 3101054710010 Capacitor 0402　470P K 50V

220 C34 T5G 3101055610000 Capacitor 0402　560P K 50V





225 C39 B4D 3101051040040 Capacitor 0402　0.1uF K 10V





- 20 -

No. Ref. No. Address Material No. Material Description Remark229 C44 B4B 3101053330000 Capacitor 0402　0.033uF K 16V



232 C47 B3D 3101055620000 Capacitor 0402　5600PF K 25V

233 C48 T4G 3101061040010 Capacitor 0603　0.1uF K 16V






239 C54 B4C 3101053300000 Capacitor 0402　33P J 50V

240 C55 B3I 3101054700010 Capacitor 0402　47P J 50V


242 C58 B4C 3101058200000 Capacitor 0402　82PF J 50V







249 C65 B1C 3101051020010 Capacitor 0402　1000P K 50V

250 C66 T1E 3101051020010 Capacitor 0402　1000P K 50V




254 C70 B4A 3101051020010 Capacitor 0402　1000P K 50V





259 C75 T4F 3101051020010 Capacitor 0402　1000P K 50V



262 C78 T2D 3101051020010 Capacitor 0402　1000P K 50V



265 C81 T1C 3101051020010 Capacitor 0402　1000P K 50V



268 C84 T2E 3101051040040 Capacitor 0402　0.1uF K 10V

269 C85 B1G 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M

270 C86 B1F 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M

271 C87 B2G 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M

272 C88 B2E 3101051000000 Capacitor 0402　10P D 50V

273 C90 B1E 3101050800000 Capacitor 0402　8P B 50V

274 C91 B2D 3101050590020 Capacitor 0402　0.5P B 50V


- 21 -

No. Ref. No. Address Material No. Material Description Remark275 C92 B2C 3101060100010 Capacitor 0603　1P B 50V


277 C94 B4E 3101050590020 Capacitor 0402　0.5P B 50V

278 C95 B1E 3101050100000 Capacitor 0402 1P C 50V

279 C96 B2D 3101050600010 Capacitor 0402　6P B 50V


281 C98 B3G 3101050600010 Capacitor 0402　6P B 50V

282 C100 B2D 3101052200010 Capacitor 0402　22P J 50V

283 C101 B4I 3101050800000 Capacitor 0402　8P B 50V

284 C103 B2B 3101050300000 Capacitor 0402　3P B 50V

285 C104 B4G 3101050100000 Capacitor 0402 1P C 50V

286 C105 B4G 3101050300000 Capacitor 0402　3P B 50V







293 C112 T2G 3104081550000 Ta-capacitor 1206 1.5uF 10V.M



296 C115 B2C 3104081560019 Ta-capacitor 1206 15uF 6.3V.M

297 C117 B1B 3104084750000 Ta-capacitor 1206 4.7uF 16V.K

298 C118 T2E 3104082260020 Ta-capacitor 1206 22uF 10V

299 C120 B2G 3104204760000 Ta-capacitor 2512 47uF 16V.M



302 C123 B1B 3101052240010 Capacitor 0402　0.22uF Z 10V

303 C124 B1B 3104081550000 Ta-capacitor 1206 1.5UF 10V.M

304 C125 B4F 3104081060080 Ta-capacitor 1206 10uF 10V.M

305 C126 B1B 3101053340000 Capacitor 0402　0.33uF K


307 C133 B4G 3101053340000 Capacitor 0402　0.33uF K

308 C134 B5H 3101050200010 Capacitor 0402　2P B 50V

309 C135 B3F 3101051000000 Capacitor 0402　10P D 50V


311 C137 T2I 3101051030020 Capacitor 0402　0.01uF K 16V



314 C140 B4I 3101050100000 Capacitor 0402 1P C 50V

315 C141 B4J 3101050800000 Capacitor 0402　8P B 50V



318 C144 T4F 3101051000000 Capacitor 0402　10P D 50V




- 22 -

No. Ref. No. Address Material No. Material Description Remark321 C147 B4I 3101051020010 Capacitor 0402　1000P K 50V






327 C155 B4A 3104081060080 Ta-capacitor 1206 10uF 10V.M




331 C159 B3B 3104081060080 Ta-capacitor 1206 10uF 10V.M

332 C160 B3D 3101053330000 Capacitor 0402　0.033uF K 16V

333 C161 T2C 3101054730000 Capacitor 0402　0.047uF K 10V


335 C163 B4F 3101050590020 Capacitor 0402　0.5P B 50V

336 C164 B4G 3101050590020 Capacitor 0402　0.5P B 50V

337 C165 T5F 3104082250020 Ta-capacitor 1206 2.2uF 16V K







344 C173 T4F 3104084750000 Ta-capacitor 1206 4.7uF 16V.K

345 C174 T3F 3104081050000 Ta-capacitor 1206 1.0uF 16V

346 C175 T2B 3101053300000 Capacitor 0402　33P J 50V


348 C177 T1D 3104081560019 Ta-capacitor 1206 15uF 6.3V.M






354 C186 B2C 3101050400010 Capacitor 0402　4P B 50V

355 C187 B2C 3101051000000 Capacitor 0402　10P D 50V


357 C189 B2C 3101050500010 Capacitor 0402　5P B 50V



360 C194 T4H 3101071040000 Capacitor 0805　0.1uF K 25V


362 C196 B3E 3101051590000 Capacitor 0402　1.5P B 50V



365 C200 T4E 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M

366 C202 B3B 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M


- 23 -

No. Ref. No. Address Material No. Material Description Remark367 C203 T5G 3104201070000 Ta-capacitor 2220 100uF 6.3V.M



370 C208 B4J 3101054710010 Capacitor 0402　470P K 50V



373 C233 B4E 3101051040040 Capacitor 0402　0.1uF K 10V



376 C239 T5I 3101052210010 Capacitor 0402　220P J 50V

377 C240 T3J 3101051030020 Capacitor 0402　0.01uF K 16V










387 C253 B3A 3101051000000 Capacitor 0402　10P D 50V


389 C255 B3B 3101051000000 Capacitor 0402　10P D 50V


391 D2 B2E 3303210200009 Diode　MA2S37600L

392 D3 B2D 3303210200009 Diode　MA2S37600L

393 D4 B1D 3399990000169 Diode　MAZ36000L

394 D5 B3F 3303020100089 Diode　MA2S07700L

395 D6 B3F 3303020100089 Diode　MA2S07700L

396 D7 B1C 3303210200009 Diode　MA2S37600L

397 D8 B1C 3303210200009 Diode　MA2S37600L

398 D9 B2C 3303020100029 Diode　MA2S11100L

399 D10 B2B 3399990000229 Diode　UDZ3.0B

400 D11 B4I 3303020100079 Diode　MA2Z07700L

401 D12 B5H 3303020100089 Diode　MA2S07700L

402 D18 T4F 3303010500029 Diode　1SS372(TE85L)

403 D19 T4G 3303030100019 Diode　DAN222（TL）

404 D20 T1D 3001060000000 Resistor 0603　0Ω　 J

405 D22 T3J 3307110100019 LED 　KPT1608-SGC

406 D24 T3J 3307110100029 LED 　KPT-1608SRC

407 D25 T2C 3303020100029 Diode　MA2S11100L

408 Q1 B1F 3403009000019 Transisitor　UMG3N(N-TR)

409 Q2 B2F 3403009000019 Transisitor　UMG3N(N-TR)

410 Q3 B2G 3503040000009 Transisitor　UPA572T

411 Q4 B1F 3499000000189 Transisitor　UFMMT717

412 Q5 B1F 3499000000189 Transisitor　UFMMT717


- 24 -

No. Ref. No. Address Material No. Material Description Remark413 Q6 B1C 3503010000019 FET　2SJ243-T1

414 Q7 B1D 3499000000159 Transisitor　UMC4(NTR)

415 Q8 B2C 3503020000109 FET　2SK508NV(K52)

416 Q9 T2B 3403007000029 Transisitor　DTA114YE(TL)

417 Q10 B4D 3403007000009 Transisitor　DTA114EE(TL)

418 Q12 T2F 3403008000079 Transisitor　DTC144EE(TL)

419 Q13 B2B 3401002000099 Transisitor　2SC5108-Y(TE85L)

420 Q14 B2D 3401002000099 Transisitor　2SC5108-Y(TE85L)

421 Q15 B2D 3408002000039 Transisitor　2SC4226-R24

422 Q16 B1D 3404002000009 Transisitor　PRF957

423 Q17 B3G 3406001000009 Transisitor　2SC4988FRTR

424 Q18 B2D 3411002000009 2SC5343EG

425 Q19 B4A 3411002000009 2SC5343EG

426 Q20 B4A 3411002000009 2SC5343EG

427 Q21 B5B 3503020000039 FET　2SK1824-T1

428 Q22 B4D 3401002000099 Transisitor　2SC5108-Y(TE85L)

429 Q23 B3E 3501020000019 FET　3SK318YB

430 Q24 T5F 3411002000009 2SC5343EG

431 Q25 T5F 3411002000009 2SC5343EG

432 Q26 T4G 3411002000009 2SC5343EG

433 Q27 B5E 3501020000019 FET　3SK318YB

434 Q28 B2J 3403008000019 Transisitor　DTC114EE(TL)

435 Q30 B2J 3403008000019 Transisitor　DTC114EE(TL)

436 Q31 B3I 3599000000029 FET　RD07MVS1

437 Q32 B3G 3599000000019 FET　RD01MUS1

438 Q34 T2B 3403007000029 Transisitor　DTA114YE(TL)

439 Q35 T2B 3403008000019 Transisitor　DTC114EE(TL)

440 Q40 T3F 3401001000039 Transisitor　2SA1362(GR)

441 Q41 T3F 3001060000000 Resistor 0603　0Ω　 J

442 Q46 B2E 3503020000039 FET　2SK1824-T1

443 Q47 B3B 3403007000029 Transisitor　DTA114YE(TL)

444 Q50 B4I 3503020000039 FET　2SK1824-T1

445 TC1 B1D 3102992000049 Trimmer Capacitor 10P

446 TC2 B1C 3102992000049 Trimmer Capacitor 10P

447 TC3 B4G 3102992000049 Trimmer Capacitor 10P

448 TC4 B5F 3102992000049 Trimmer Capacitor 10P

449 TC5 B4E 3102992000049 Trimmer Capacitor 10P

450 VR2 T5E 3002994730009 Trimmer resistor 47KΩ


452 VR4 T1B 3002996830009 Trimmer resistor 68KΩ

453 VR5 B3B 3002996830009 Trimmer resistor 68KΩ

454 IC1 B4C 3603002005419 IC　TA31136FN（EL）

455 IC2 B2A 3604002005509 IC　TB31202FN（EL）

456 IC3 T4F 3605008005019 IC　NJM2100V

457 IC4 T1D 3608015000000 XC6201P502R

458 IC5 T5B 3612031004409 IC　AT24C08N-10S1-2.7


- 25 -

No. Ref. No. Address Material No. Material Description Remark459 IC7 B3C 3603008005049 IC　NJM2902V

460 IC8 T3E 3602028004599 IC　KIA6278F

461 IC9 T2A 3609004005179 IC PST9140NR

462 IC11 T3C 3610004000659 M38223M4A-137HP

463 X1 B2H 3802209540009 Crystal 20.945MHZ

464 X3 T3B 3701737230020 Crystal 7.3728MHZ DSX530GA

465 X4 B3A 3701012850019 Crystal 12.8MHZ

466 CP1 T1B 3005991030019 Array resistor 10KΩ*4

467 CP3 T1B 3005994720019 Array resistor 4.7KΩ*4



470 CP6 T4A 3005991030019 Array resistor 10KΩ*4

471 L1 B4B 3001064710000 Resistor 0603　470Ω　J

472 L2 B3H 3231321050009 E2-0.32-1.0-5TR

473 L3 B3H 3001060000000 Resistor 0603　0Ω　 J

474 L4 B4J 3210107221009 Inductor 0805 220nH

475 L5 B2E 3213306332000 Inductor 0603 3.3uH

476 L6 B2D 3221506601009 BLM18AG601SN1D

477 L7 B2D 3221506601009 BLM18AG601SN1D

478 L8 B2A 3221506601009 BLM18AG601SN1D

479 L10 B3J 3221507600000 BLM21PG600SN1D

480 L11 B3H 3221507221009 BLM21PG221SN1D

481 L12 B3G 3221506601009 BLM18AG601SN1D

482 L13 B2B 3221506601009 BLM18AG601SN1D

483 L14 T4H 3213306102000 Inductor 0603 1uH

484 L15 B2G 3221507600000 BLM21PG600SN1D

485 L16 B2B 3210108230019 Inductor 1206 23nH

486 L17 B1C 3212105101000 Inductor 0402 100nH

487 L18 B2D 3210305220009 Inductor 0402 22nH

488 L19 B2D 3210305220009 Inductor 0402 22nH

489 L21 B3G 3210305150010 Inductor 0402 15nH

490 L22 B4H 3231351630000 E2-0.35-1.6-3TR

491 L23 B4I 3231351630000 E2-0.35-1.6-3TR

492 L24 B4I 3231351630000 E2-0.35-1.6-3TR

493 L25 B3E 3210305220009 Inductor 0402 22nH

494 L26 B2B 3210305180009 Inductor 0402 18nH

495 L28 B4J 3231351630000 E2-0.35-1.6-3TR

496 L29 B3H 3212106339009 Inductor 0603 3.3nH

497 L30 B3I 3231351680000 E2-0.35-1.6-8TR

498 L31 B4F 3231351640009 E2-0.35-1.6-4TL

499 L32 B4G 3231351640009 E2-0.35-1.6-4TL

500 L33 B4G 3231351630000 E2-0.35-1.6-3TR

501 L34 B5E 3231351630000 E2-0.35-1.6-3TR

502 L35 B4E 3231351630000 E2-0.35-1.6-3TR

503 L36 B4E 3231351630000 E2-0.35-1.6-3TR

504 L38 B5F 3231351630000 E2-0.35-1.6-3TR


- 26 -

No. Ref. No. Address Material No. Material Description Remark505 L39 B5E 3212105470000 Inductor 0402 47nH

506 L40 B5E 3212105101000 Inductor 0402 100nH

507 L41 T2E 3213306221019 Inductor 0603 0.22uH

508 L43 B5J 3210209102019 Inductor 1210 1uH

509 L44 B1E 3210108230019 Inductor 1206 23nH

510 L45 B2D 3212105470000 Inductor 0402 47nH

511 L46 B2C 3213306332000 Inductor 0603 3.3uH

512 L47 B2C 3212105101000 Inductor 0402 100nH

513 L48 B1C 3212105101000 Inductor 0402 100nH

514 L49 B3E 3213212331000 Inductor 1008 330nH

515 L50 B3A 3213212102009 Inductor 1008 1uH

516 F1 T4G 3001080000000 Resistor 1206　0Ω　J

517 CF1 B1H 3801045530109 Ceramic fileter 455KHz

518 CD1 B1G 3920455300009 Demodulator

519 XF1 B2G 3702021450009 Crystal filter 21.4MHz


- 27 -

TC-500V Part List 1 No. Ref. No. Address Material No. Material Description Remark1 R1 B2I 3001066840000 Resistor 0603　680KΩ　 J

2 R2 B3H 3001062740010 Resistor 0603　270KΩ　J

3 R3 B2I 3001062220000 Resistor 0603　2.2KΩ　J

4 R4 T2B 3001064730000 Resistor 0603　47KΩ　J

5 R5 B2F 3001061510000 Resistor 0603　150Ω　J

6 R6 T2B 3001062220000 Resistor 0603　2.2KΩ　J

7 R7 B2I 3001061040010 Resistor 0603　100KΩ　J

8 R8 B4F 3001061040010 Resistor 0603　100KΩ　J

9 R9 B5G 3001061040010 Resistor 0603　100KΩ　J

10 R10 B2H 3001061040010 Resistor 0603　100KΩ　J

11 R11 B4I 3001061240010 Resistor 0603　120KΩ　J

12 R12 B2I 3001061040010 Resistor 0603　100KΩ　J

13 R13 B3G 3001061040010 Resistor 0603　100KΩ　J

14 R14 B3G 3001061540000 Resistor 0603　150KΩ　J

15 R15 B3G 3001061040010 Resistor 0603　100KΩ　J

16 R16 B3G 3001062740010 Resistor 0603　270KΩ　J

17 R17 B2F 3001061040010 Resistor 0603　100KΩ　J

18 R18 T4B 3001061040010 Resistor 0603　100KΩ　J

19 R22 T1D 3001064740010 Resistor 0603　470KΩ J

20 R23 B3H 3001064730000 Resistor 0603　47KΩ　J

21 R25 B2I 3001063320000 Resistor 0603　3.3KΩ　J

22 R26 B2G 3001063320000 Resistor 0603　3.3KΩ　J

23 R27 B4E 3001063320000 Resistor 0603　3.3KΩ　J

24 R28 B5E 3001063320000 Resistor 0603　3.3KΩ　J

25 R29 B4G 3001063320000 Resistor 0603　3.3KΩ　J

26 R30 B4F 3001063320000 Resistor 0603　3.3KΩ　J

27 R31 B3D 3001063320000 Resistor 0603　3.3KΩ　J

28 R32 B1F 3001063320000 Resistor 0603　3.3KΩ　J

29 R33 T5F 3001063320000 Resistor 0603　3.3KΩ　J

30 R34 B4G 3001063320000 Resistor 0603　3.3KΩ　J

31 R35 T2C 3001061040010 Resistor 0603　100KΩ　J

32 R36 B2I 3001061030010 Resistor 0603　10KΩ　J

33 R37 T2E 3001061030010 Resistor 0603　10KΩ　J

34 R38 B4J 3001061030010 Resistor 0603　10KΩ　J

35 R39 B3I 3001061020010 Resistor 0603　1KΩ　J

36 R40 B3F 3001061030010 Resistor 0603　10KΩ　J

37 R41 T5F 3001061030010 Resistor 0603　10KΩ　J

38 R42 T5E 3001061030010 Resistor 0603　10KΩ　J

39 R43 T2A 3001063340000 Resistor 0603　330KΩ　J

40 R44 B4B 3001061030010 Resistor 0603　10KΩ　J

41 R45 B4B 3001061030010 Resistor 0603　10KΩ　J

42 R46 T2H 3001063330010 Resistor 0603　33KΩ　J

43 R47 B2G 3001066810010 Resistor 0603　680Ω　J

44 R48 B3F 3001061520000 Resistor 0603　1.5KΩ　J


- 28 -

No. Ref. No. Address Material No. Material Description Remark45 R49 B2G 3001062720000 Resistor 0603　2.7KΩ　J

46 R50 T5F 3001061520000 Resistor 0603　1.5KΩ　J

47 R51 B5E 3001061020010 Resistor 0603　1KΩ　J

48 R52 T3F 3001061020010 Resistor 0603　1KΩ　J

49 R53 B4G 3001061020010 Resistor 0603　1KΩ　J

50 R54 T3G 3001064730000 Resistor 0603　47KΩ　J

51 R55 T2E 3001061520000 Resistor 0603　1.5KΩ　J

52 R56 B4I 3001061020010 Resistor 0603　1KΩ　J

53 R57 B1I 3001061020010 Resistor 0603　1KΩ　J

54 R58 T4B 3001061020010 Resistor 0603　1KΩ　J

55 R59 T3B 3001061020010 Resistor 0603　1KΩ　J

56 R60 T2D 3001061020010 Resistor 0603　1KΩ　J

57 R61 T2D 3001061020010 Resistor 0603　1KΩ　J

58 R62 B4B 3001063310010 Resistor 0603　330Ω　J

59 R64 B4D 3001062720000 Resistor 0603　2.7KΩ　J

60 R65 B4D 3001062720000 Resistor 0603　2.7KΩ　J

61 R66 B5E 3001068210010 Resistor 0603　820Ω　J

62 R67 B4G 3001062710000 Resistor 0603　270Ω　J

63 R68 B4F 3001061510000 Resistor 0603　150Ω　J

64 R69 B4H 3001062710000 Resistor 0603　270Ω　J

65 R70 B3E 3001068210010 Resistor 0603　820Ω　J

66 R72 B4G 3001061240010 Resistor 0603　120KΩ　J

67 R74 B4G 3001061010000 Resistor 0603　100Ω　J

68 R75 B2A 3001061010000 Resistor 0603　100Ω　J

69 R76 B1F 3001061010000 Resistor 0603　100Ω　J

70 R79 B4G 3001065620010 Resistor 0603　5.6KΩ　J

71 R80 B4G 3001061000000 Resistor 0603　10Ω　J

72 R81 B3E 3001063920000 Resistor 0603　3.9KΩ　J

73 R82 B2D 3001061000000 Resistor 0603　10Ω　J

74 R84 B4H 3001064720000 Resistor 0603　4.7KΩ　J

75 R85 T4F 3001066820000 Resistor 0603　6.8KΩ　J

76 R86 B5J 3001064730000 Resistor 0603　47KΩ　J

77 R87 T2A 3001064720000 Resistor 0603　4.7KΩ　J

78 R88 T1C 3001064720000 Resistor 0603　4.7KΩ　J

79 R89 T4I 3001061020010 Resistor 0603　1KΩ　J

80 R90 T5H 3001061010000 Resistor 0603　100Ω　J

81 R91 T2F 3001064730000 Resistor 0603　47KΩ　J

82 R92 T3E 3001062710000 Resistor 0603　270Ω　J

83 R94 T3F 3001060000000 Resistor 0603　0Ω　 J

84 R95 B4I 3001061540000 Resistor 0603　150KΩ　J

85 R97 B3H 3001061840000 Resistor 0603　180KΩ　J

86 R98 B3G 3001062030000 Resistor 0603　20KΩ　J

87 R99 T1B 3001064720000 Resistor 0603　4.7KΩ　J

88 R100 T4B 3001061030010 Resistor 0603　10KΩ　J

89 R101 B2C 3001064730000 Resistor 0603　47KΩ　J

90 R102 B3C 3001062030000 Resistor 0603　20KΩ　J


- 29 -

No. Ref. No. Address Material No. Material Description Remark91 R103 B2D 3001061530010 Resistor 0603　15KΩ　J

92 R104 B3C 3001062230000 Resistor 0603　22KΩ　J

93 R105 B5F 3001064730000 Resistor 0603　47KΩ　J

94 R106 T3F 3001061000000 Resistor 0603　10Ω　J

95 R107 B3I 3001060000000 Resistor 0603　0Ω　 J

96 R108 B3F 3001060000000 Resistor 0603　0Ω　 J

97 R109 T2B 3001061050010 Resistor 0603　1.0MΩ　J

98 R110 T4G 3001060000000 Resistor 0603　0Ω　 J

99 R111 B2F 3101061020000 Capacitor 0603　1000P K 50V

100 R112 B3I 3101063330030 Capacitor 0603　0.033uF K 50V

101 R113 T5J 3001061000000 Resistor 0603　10Ω　J

102 R114 B5I 3001064720000 Resistor 0603　4.7KΩ　J

103 R115 B5J 3001061510000 Resistor 0603　150Ω　J

104 R116 T3B 3001061050010 Resistor 0603　1.0MΩ　J

105 R117 B5I 3001062720000 Resistor 0603　2.7KΩ　J

106 R118 B4B 3001063310010 Resistor 0603　330Ω　J

107 R119 B4J 3001061030010 Resistor 0603　10KΩ　J

108 R120 T4G 3001062230000 Resistor 0603　22KΩ　J

109 R121 T1B 3001064720000 Resistor 0603　4.7KΩ　J

110 R122 B3D 3001063310010 Resistor 0603　330Ω　J

111 R123 B3D 3001064700000 Resistor 0603　47Ω　J

112 R124 T3F 3001062240010 Resistor 0603　220KΩ　J

113 R125 B3C 3001064700000 Resistor 0603　47Ω　J

114 R126 B2G 3001066810010 Resistor 0603　680Ω　J

115 R127 B1E 3001061010000 Resistor 0603　100Ω　J

116 R128 B4I 3001060000000 Resistor 0603　0Ω　 J

117 R130 B2I 3001063320000 Resistor 0603　3.3KΩ　J

118 R131 T4E 3001061820000 Resistor 0603　1.8KΩ　J

119 R132 B3H 3001062730010 Resistor 0603　27KΩ　J

120 R133 T2C 3001068230010 Resistor 0603　82KΩ　J

121 R134 B3H 3001066840000 Resistor 0603　680KΩ　 J

122 R135 B2I 3001063920000 Resistor 0603　3.9KΩ　J

123 R136 B2J 3001063920000 Resistor 0603　3.9KΩ　J

124 R137 B2I 3001063920000 Resistor 0603　3.9KΩ　J

125 R138 B1I 3001063920000 Resistor 0603　3.9KΩ　J

126 R139 B2I 3001061540000 Resistor 0603　150KΩ　J

127 R140 B2J 3001061540000 Resistor 0603　150KΩ　J

128 R141 B2J 3001061540000 Resistor 0603　150KΩ　J

129 R142 B2J 3001061540000 Resistor 0603　150KΩ　J

130 R144 B3H 3001061820000 Resistor 0603　1.8KΩ　J

131 R145 T5F 3001061040010 Resistor 0603　100KΩ　J

132 R146 B2G 3001061020010 Resistor 0603　1KΩ　J

133 R147 B2F 3001061010000 Resistor 0603　100Ω　J

134 R148 B2G 3001065640000 Resistor 0603　560KΩ　J

135 R149 B3F 3001065630000 Resistor 0603　56KΩ　J

136 R150 B2F 3001061240010 Resistor 0603　120KΩ　J


- 30 -

No. Ref. No. Address Material No. Material Description Remark137 R151 B2F 3001060000000 Resistor 0603　0Ω　 J

138 R152 T5F 3001063930010 Resistor 0603　39KΩ　J

139 R153 T5F 3001063930010 Resistor 0603　39KΩ　J

140 R154 T4F 3001061040010 Resistor 0603　100KΩ　J

141 R155 T5G 3001061850000 Resistor 0603　1.8MΩ　J

142 R156 T5F 3001061850000 Resistor 0603　1.8MΩ　J

143 R157 T4F 3001066830000 Resistor 0603　68KΩ　J

144 R158 T5F 3001063930010 Resistor 0603　39KΩ　J

145 R159 T5E 3001063930010 Resistor 0603　39KΩ　J

146 R160 T4G 3001067540000 Resistor 0603　750KΩ　J

147 R161 T4F 3001061530010 Resistor 0603　15KΩ　J

148 R162 T4G 3001061530010 Resistor 0603　15KΩ　J

149 R163 T4F 3001061530010 Resistor 0603　15KΩ　J

150 R164 B4H 3001061000000 Resistor 0603　10Ω　J

151 R165 B2E 3001062220000 Resistor 0603　2.2KΩ　J

152 R166 B2E 3001064710000 Resistor 0603　470Ω　J

153 R167 T1D 3001062240010 Resistor 0603　220KΩ　J

154 R168 B1E 3001061040010 Resistor 0603　100KΩ　J

155 R171 B5G 3001061000000 Resistor 0603　10Ω　J

156 R172 B3E 3001063330010 Resistor 0603　33KΩ　J

157 R173 B3F 3001061040010 Resistor 0603　100KΩ　J

158 R174 T4H 3001062220000 Resistor 0603　2.2KΩ　J

159 R175 T2B 3001061040010 Resistor 0603　100KΩ　J

160 R176 T2B 3001061040010 Resistor 0603　100KΩ　J

161 R177 T2A 3001064720000 Resistor 0603　4.7KΩ　J

162 R178 B3F 3001061040010 Resistor 0603　100KΩ　J

163 R191 B4J 3001064700000 Resistor 0603　47Ω　J

164 R192 B2F 3001063930010 Resistor 0603　39KΩ　J

165 R194 B3E 3001060000000 Resistor 0603　0Ω　 J

166 R196 B2D 3001061800000 Resistor 0603　18Ω　J

167 R198 T4E 3101063320000 Capacitor 0603　3300P K 50V

168 R200 B4I 3001066830000 Resistor 0603　68KΩ　J

169 R202 B4I 3001061040010 Resistor 0603　100KΩ　J

170 R203 T2E 3001066810010 Resistor 0603　680Ω　J

171 R204 T2H 3001061030010 Resistor 0603　10KΩ　J

172 R508 B1I 3001060000000 Resistor 0603　0Ω　 J

173 R601 B5F 3001063320000 Resistor 0603　3.3KΩ　J

174 R602 B3H 3001062730010 Resistor 0603　27KΩ　J

175 R606 T3I 3001064730000 Resistor 0603　47KΩ　J

176 R607 T3I 3001064730000 Resistor 0603　47KΩ　J

177 R608 T3I 3001064730000 Resistor 0603　47KΩ　J

178 R609 T3I 3001064730000 Resistor 0603　47KΩ　J

179 R610 T2C 3001064730000 Resistor 0603　47KΩ　J

180 R628 T2E 3001068220000 Resistor 0603　8.2KΩ　J

181 C1 B2I 3104081060080 Ta-capacitor 1206 10uF 10V.M



- 31 -

No. Ref. No. Address Material No. Material Description Remark183 C3 B2I 3101051030020 Capacitor 0402　0.01uF K 16V

184 C4 B2H 3101051030020 Capacitor 0402　0.01uF K 16V

185 C5 B5E 3101051030020 Capacitor 0402　0.01uF K 16V


187 C8 B2J 3101051030020 Capacitor 0402　0.01uF K 16V







194 C15 B4J 3101051010030 Capacitor 0402　100P J 50V























217 C39 B2G 3101051040040 Capacitor 0402　0.1uF K 10V







224 C47 B3G 3101055620000 Capacitor 0402　5600PF






- 32 -

No. Ref. No. Address Material No. Material Description Remark229 C52 B2I 3101053300000 Capacitor 0402　33P J 50V



232 C56 B3F 3101053900000 Capacitor 0402　39P J 50V


234 C58 B2H 3101058200000 Capacitor 0402　82PF


























260 C85 B5D 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M

261 C86 B5F 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M

262 C87 B4D 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M




266 C91 B4G 3101050590020 Capacitor 0402　0.5P B 50V

267 C92 B4H 3199060758000 Capacitor 0603　0.75P B 50V

268 C94 B2F 3101060500010 Capacitor 0603　5P B 50V

269 C95 B5F 3101050590020 Capacitor 0402　0.5P B 50V

270 C96 B4G 3101053300000 Capacitor 0402　33P J 50V






- 33 -

No. Ref. No. Address Material No. Material Description Remark275 C103 B4I 3101051000020 Capacitor 0402　10P J 50V


277 C105 B2D 3101052000000 Capacitor 0402　20PF






283 C112 T2I 3104086850000 Ta-capacitor 1206 6.8uF 16V.M



286 C115 B4H 3104081560019 Ta-capacitor 1206 15uF 6.3V.M

287 C116 B2F 3101050500010 Capacitor 0402　5P B 50V

288 C117 B5I 3104084750000 Ta-capacitor 1206 4.7uF 16V.K

289 C118 T2E 3104081060080 Ta-capacitor 1206 10uF 10V.M


291 C120 B4D 3104204760000 Ta-capacitor 　47uF 16V




295 C124 B5I 3104084750000 Ta-capacitor 1206 4.7uF 16V.K

296 C125 B2E 3104081060080 Ta-capacitor 1206 10uF 10V.M

297 C126 B5I 3101053340000 Capacitor 0402　0.33uF K 6.3V









306 C137 T2I 3101051030020 Capacitor 0402　0.01uF K 16V


308 C139 B2B 3101052000000 Capacitor 0402　20PF




312 C143 B2A 3101050100000 Capacitor 0402　1P C 50V

313 C144 T4F 3101051000020 Capacitor 0402　10P J 50V






319 C151 B2J 3101052230000 Capacitor 0402　0.022uF K 16V



- 34 -

No. Ref. No. Address Material No. Material Description Remark321 C153 B2I 3101053330000 Capacitor 0402　0.033uF K 16V

322 C154 T2H 3101054710010 Capacitor 0402　470P K 50V

323 C155 B2J 3104081060080 Ta-capacitor 1206 10uF 10V.M




327 C159 B2I 3104081060080 Ta-capacitor 1206 10uF 10V.M


329 C161 T2C 3101053330000 Capacitor 0402　0.033uF K 16V




333 C165 T5F 3104082250020 Ta-capacitor 1206 2.2uF 16V K








341 C173 T4F 3104084750000 Ta-capacitor 1206 4.7uF 16V.K

342 C174 T3F 3104081050000 Ta-capacitor 1206 1.0uF



345 C177 T1D 3104081560019 Ta-capacitor 1206 15uF 6.3V.M









354 C194 T4H 3101071040000 Capacitor 0805　0.1uF K 25V




358 C200 T4E 3104071050000 Ta-capacitor 0805 1.0uF 6.3V.M


360 C202 B4I 3001070000000 Resistor 0805　0Ω　J

361 C203 T5G 3104201070000 Ta-capacitor 2220 100uF 6.3V.M







- 35 -

No. Ref. No. Address Material No. Material Description Remark367 C210 T2E 3101051040040 Capacitor 0402　0.1uF K 10V



370 C213 T3E 3101051010030 Capacitor 0402　100P J 50V


372 C233 B2F 3101051040040 Capacitor 0402　0.1uF K 10V





377 C239 T5I 3101052210010 Capacitor 0402　220P J 50V






383 D2 B4F 3304010100099 Diode 1SV282

384 D3 B4G 3304060300049 Diode　HVC362

385 D4 B5F 3399990000169 Diode　MAZ36000L

386 D5 B3E 3303020100089 Diode　MA2S07700L

387 D6 B3E 3303020100089 Diode　MA2S07700L

388 D7 B5H 3303210200009 Diode　MA2S37600L

389 D8 B5H 3304060300049 Diode　HVC362

390 D9 B4H 3303020100029 Diode　MA2S11100L

391 D10 B4I 3304010100069 Diode 1SV269(TPH2)

392 D11 B2A 3303020100079 Diode　MA2Z07700L

393 D12 B1C 3303020100089 Diode　MA2S07700L

394 D14 B2B 3303020100079 Diode　MA2Z07700L

395 D16 B3E 3001070000000 Resistor 0805　0Ω　J

396 D18 T4F 3303010500029 Diode　1SS372(TE85L)

397 D19 T4G 3303030100019 Diode　DAN222（TL）

398 D20 T1D 3001060000000 Resistor 0603　0Ω　 J

399 D22 T3J 3307110100019 LED 　KPT1608-SGC

400 D24 T3J 3307110100029 LED 　KPT-1608SRC

401 D25 T2C 3001060000000 Resistor 0603　0Ω　 J

402 L1 B2I 3001064710000 Resistor 0603　470Ω　J

403 L2 B3C 3213212331000 Inductor　330nH

404 L3 B3C 3215107180009 Inductor　18nH

405 L4 B2A 3213306332000 Inductor　3.3uH

406 L5 B5F 3213306682009 Inductor　6.8uH

407 L6 B4G 3213306682009 Inductor　6.8uH

408 L7 B4G 3221506601009 BLM18AG601SN1D

409 L8 B5J 3221506601009 BLM18AG601SN1D

410 L9 B3I 3001070000000 Resistor 0805　0Ω　J

411 L10 B3B 3221507600000 BLM21PG600SN1D

412 L11 B3C 3221507221009 BLM21PG221SN1D


- 36 -

No. Ref. No. Address Material No. Material Description Remark413 L12 B3D 3221506601009 BLM18AG601SN1D

414 L13 B4I 3221506601009 BLM18AG601SN1D

415 L14 T4H 3213306102000 Inductor　1uH

416 L15 B4D 3221507600000 BLM21PG600SN1D

417 L16 B4H 3210108330009 Inductor　33nH

418 L17 B5H 3213306682009 Inductor　6.8uH

419 L18 B4G 3212105101000 Inductor　HK1005 100nH

420 L19 B4G 3212105101000 Inductor　HK1005 100nH

421 L21 B3D 3212105560009 Inductor　HK1005 56NJ

422 L22 B2C 3231351670009 E2-0.35-1.6-7TR

423 L23 B2B 3231351640009 E2-0.35-1.6-4TL

424 L24 B2B 3231351650000 E2-0.35-1.6-5TL

425 L25 B3F 3212105101000 Inductor　HK1005 100nH

426 L27 B5H 3213306682009 Inductor　6.8uH

427 L28 B2A 3231351660009 E2-0.35-1.6-6TR

428 L29 B3C 3001060000000 Resistor 0603　0Ω　 J

429 L30 B3B 3231351680000 E2-0.35-1.6-8TR

430 L31 B2D 3215107680009 Inductor　68nH

431 L32 B2F 3215007820009 Inductor　82nH

432 L33 B2D 3215107390009 Inductor　39nH

433 L34 B1F 3215107680009 Inductor　68nH

434 L35 B2F 3215107680009 Inductor　68nH

435 L36 B1E 3101061020000 Capacitor 0603　1000P K 50V

436 L37 B3F 3213212102009 Inductor　1008 1uH

437 L38 B2E 3215107680009 Inductor　68nH

438 L39 B1F 3215007820009 Inductor　82nH

439 L40 B1F 3213212181009 Inductor　180nH

440 L41 T2E 3213306221019 Inductor　0.22uH

441 L43 B1A 3213212181009 Inductor　180nH

442 L44 B5G 3210108270000 Inductor　27nH

443 L48 B5H 3213306682009 Inductor　6.8uH

444 L49 B3F 3213212331000 Inductor　330nH

445 Q1 B5E 3403009000019 Transistor　UMG3N(N-TR)

446 Q2 B4E 3403009000019 Transistor　UMG3N(N-TR)

447 Q3 B4D 3503040000009 Transistor　UPA572T

448 Q4 B5E 3499000000189 Transistor　UFMMT717

449 Q5 B5E 3499000000189 Transistor　UFMMT717

450 Q6 B5H 3503010000019 FET　2SJ243-T1

451 Q7 B5G 3499000000159 Transistor　UMC4(NTR)

452 Q8 B4H 3502010000009 FET　2SK1875-V(TE85L)

453 Q9 T2B 3403007000029 Transistor　DTA114YE(TL)

454 Q10 B2G 3403007000009 Transistor　DTA114EE(TL)

455 Q11 T2H 3503020000039 FET　2SK1824-T1

456 Q12 T2E 3403008000079 Transistor　DTC144EE(TL)

457 Q13 B4I 3401002000099 Transistor　2SC5108-Y(TE85L)

458 Q14 B4G 3401002000099 Transistor　2SC5108-Y(TE85L)


- 37 -

No. Ref. No. Address Material No. Material Description Remark459 Q15 B4G 3408002000039 Transistor　2SC4226-R24

460 Q16 B5G 3502010000009 FET　2SK1875-V(TE85L)

461 Q17 B3D 3406001000009 Transistor　2SC4988FRTR

462 Q18 B4G 3411002000009 2SC5343EG

463 Q19 B2J 3411002000009 2SC5343EG

464 Q20 B2J 3411002000009 2SC5343EG

465 Q21 B1I 3503020000039 FET　2SK1824-T1

466 Q22 B2G 3401002000099 Transistor　2SC5108-Y(TE85L)

467 Q23 B3F 3501020000019 FET　3SK318YB

468 Q24 T5F 3411002000009 2SC5343EG

469 Q25 T5F 3411002000009 2SC5343EG

470 Q26 T4G 3411002000009 2SC5343EG

471 Q27 B2F 3501020000019 FET　3SK318YB

472 Q28 B4A 3403008000019 Transistor　DTC114EE(TL)

473 Q29 B4E 3503020000039 FET　2SK1824-T1

474 Q30 B4A 3403008000019 Transistor　DTC114EE(TL)

475 Q31 B3B 3599000000029 FET　RD07MVS1

476 Q32 B3D 3599000000019 FET　RD01MUS1

477 Q33 B3H 3403007000029 Transistor　DTA114YE(TL)

478 Q34 T2B 3403007000029 Transistor　DTA114YE(TL)

479 Q35 T2B 3403008000019 Transistor　DTC114EE(TL)

480 Q37 T2F 3403008000079 Transistor　DTC144EE(TL)

481 Q40 T3F 3401001000039 Transistor　2SA1362(GR)

482 Q41 T3F 3001060000000 Resistor 0603　0Ω　 J

483 TC1 B5G 3102992000049 Trimmer Capacitor 10P

484 TC2 B5H 3102992000009 Trimmer Capacitor 6P

485 TC3 B2D 3102992000049 Trimmer Capacitor 10P

486 TC4 B1E 3102992000049 Trimmer Capacitor 10P

487 TC5 B2F 3102992000049 Trimmer Capacitor 10P

488 TC6 B3I 3102992000049 Trimmer Capacitor 10P



491 VR4 T1B 3002996830009 Trimmer resistor 68KΩ

492 IC1 B2H 3603002005419 IC　TA31136FN（EL）

493 IC2 B4J 3604002005509 IC　TB31202FN（EL）

494 IC3 T4F 3605008005019 IC　NJM2100V

495 IC4 T1D 3608015000000 XC6201P502R

496 IC5 T5B 3612031004409 IC　AT24C08N-10S1-2.7

497 IC7 B3H 3603008005049 IC　NJM2902V

498 IC8 T3E 3602028004599 IC　KIA6278F

499 IC9 T2A 3609004005179 IC PST9140NR

500 IC11 T3C 3610004003049 M38227ECHP






- 38 -

No. Ref. No. Address Material No. Material Description Remark505 CP6 T4A 3005991030019 Array resistor 10KΩ*4

506 F1 T4G 3001080000000 Resistor 1206　0Ω　J

507 X1 B2H 3802209540009 Crystal 20.945MHZ

508 X2 B3J 3702012850010 Crystal 12.8MHz

509 X3 T3B 3701737230049 Crystal 7.3728MHZ

510 CF1 B1H 3801045530109 Ceramic filter 455KHz

511 CD1 B1G 3920455300009 Demodulator

512 XF1 B2G 3702021450009 Crystal filter 21.4MHz


- 39 -

Adjustment Description

The radio can be adjusted with PC programming software or by manual adjustment. Manual adjustment procedure of TC-500 is as follow. (Refer to “model set mode” and “manual adjust mode” in the section Software Specification.) Instrument:

Radio Communication Test Set 1 set Scanner 1 set 3A/10V Power Supply 1 set Digital Voltmeter 1 set 3A Ammeter 1 set

Adjustment:

1. Initializing: It’s necessary to set the model and initialize the radio before alignment because there is no needed information in EEPROM when the radio is manufactured. Please refer to the “model set mode” in the section Software Specification for details.

2. Adjustment: Some items can be adjusted in conventional communication mode and the others in manual adjust mode. Turn on the power, the radio enters conventional communication mode. If manual adjust mode is enabled, turn on the power while holding down PTT and MONI simultaneously, the radio enters manual adjust mode after 2 seconds. (Refer to the section Software Specification.)

VCO

Measurement Adjustment Item Condition

Test Instrument Terminal Part Method

Specification

/Remarks

1.Power supply 1.power voltage DC 6V

1.TX High. Turn to CH15 in

manual adjust mode and press

PTT. 3.0V±0.2V 2.Transmit VCO

lock voltage 2.TX Low. Turn to CH14 in


PTT.

TC1

>0.8V

1.RX High. Turn to CH15 in

manual adjust mode. 2.6V±0.2V 3. Receive

VCO lock

voltage 2.RX Low. Turn to CH14 in

manual adjust mode.

Digital Voltmeter CV

TC2

>0.8V


- 40 -

RECEIVER: (Enter the manual adjust mode)

Measurement Adjustment Item Condition

Test Instrument Terminal Part Method

Specification

/Remarks

4. Band

Pass Filter

1.RX Center. Turn to

CH13 in manual adjust

mode.

Scanner ANT . TP2

TC3

TC4

TC5

Adjust the waveform to the

top, and the top is flat, the

bandwidth is about 20MHz,

the sign of RX central

frequency is at the middle

of the waveform.



mode (long press MONI

key to switch N/W).

2. RX Low. Turn to



key to switch N/W).

5.sensitivity

3.RX High. Turn to



key to switch N/W).

Radio

Communication

Test Set

-118dBm

MOD:1KHz

DEV:±3kHz

(Wide)

±1.5kHz

(Narrow)

FILER:

0.3-3.4kHz

ANT

Speaker

Jack

Check SINAD: 12dB or

higher



mode. Adjust by

pressing PTT or MONI.

Radio

Communication

Test Set

SSG output:

-117dBm

Level 9

Adjust to just close the

squelch.

Adjust squelch

level 9

6.Squelch



mode. Adjust by


Radio

Communication

Test Set

SSG output:

-125dBm

ANT

Speaker

Jack

Level 3

Adjust to just close the

squelch.

Adjust squelch

level 3


- 41 -

Transmitter

Measurement Adjustment

Item Condition Test

equipment Terminal Parts Method

Specification

/Remarks

7.Transmit

frequency

1. TX Center. Turn to CH13 in


PTT.

Radio Communication

Test Set ANT TC6

Adjust it to center

frequency

Error

≤±250Hz

8.Max.

Deviation



PTT (long press MONI key to

switch N/W).

Radio Communication

Test Set

LPF: 15kHz AF:1kHz 120mV

ANT

MIC JackVR2

Adjust deviation to:

4.0kHz±200Hz (Wide)Check 2.0kHz±200Hz (narrow)

9. Modulation

Sensitivity




switch N/W).

Radio Communication

Test Set

FILTER:

FILER: 0.3-3.4kHz AF:1kHz 12±2mV

ANT

MIC Jack

Check deviation:

3.0kHz(Wide) 1.5 kHz(narrow)

1. TX Center. CTCSS: 67.0Hz.

Turn to CH4 in manual adjust

mode.

67.0Hz

CTCSS

10. CTCSS

Balance 2. TX Center. CTCSS: 250.3Hz.

Turn to CH16 in manual adjust

mode and press PTT.

Radio Communication

Test Set

LPF:300Hz

ANT VR3

Adjust VR3, deviation

tested on condition 1 and

condition 2 are

consistent, the difference

≤200Hz 250.3Hz

CTCSS

11. CTCSS

Deviation

1. TX Center. Turn to CH4

(wide) and CH4 (narrow) in

manual adjust mode. Adjust by


Adjust deviation to:

0.65kHz±100Hz(Wide)0.4kHz±100Hz(Narrow)

12. CDCSS

Deviation

1. TX Center. Turn to CH5

(wide) and CH7 (narrow) in

manual adjust mode. Adjust by


Radio Communication

Test Set

LPF:300Hz

ANT Adjust deviation to:

0.65kHz±100Hz(Wide)

0.4kHz±

100Hz(Narrow)

13. High/low

Power




switch N/W).

Radio Communication

Test Set ANT

Power

Supply:

6V

Check:

Low: 1.6—2.5W

High: above 3.5W

14.

Low Battery

Alert Level

1. Turn to CH1 in manual adjust

mode. Adjust the power supply

voltage at 5.3V. Adjust by


Digital Voltmeter Adjust the level to make

LED just flash.


- 42 -

Note: In manual adjust mode, when channel selector knob is positioned at channel 1-channel16, MIC jack can’t connect with external cables. After

adjustment is completed, short out the two SELF points and then turn the power on, the radio enters model set mode. Then press PTT to disable

the manual adjust mode.


- 43 -

Disassembly and Assembly

Remove the Battery 1. Turn the radio off. 2. Slide the battery latches upwards. 3. Pull the top part of the battery away from the radio’s body and lift the battery from the radio.

(See figure 1)

Figure 1

Disassemble main unit (aluminum chassis and PCB)

1. Remove the two screws at the base of the chassis. 2. Pull the volume knob and selector knob off. 3. Remove the antenna at top of the radio. 4. Remove the screw of the microphone jack cover and pull the jack cover off. (See figure 2)

Screw

Screw

Volume Knob

Jack Cover

Channel Selector Knob

Figure 2


- 44 -

Pull the chassis upwards and then pull the chassis away from the front cover. (See figure 3)

Figure 3

The disassembly is shown as the figure 4.

Figure 4

Disassemble PTT button

Push the PTT button in indicated direction until out of the cover. (See figure 5)

Figure 5


- 45 -

Assemble PTT button

Paste double-coated tape to the cover. And then press the PTT button into the corresponding opening in the cover. (See figure 6)

Figure 6

Attach the battery

1. Fit the extensions at the bottom of the battery into the slots on the radio chassis. 2. Press the top part of the battery towards the radio until a click is heard. (See figure 7)

Figure 7


- 46 -

Exploded View

2

3

3

1


- 47 -

Part List 2 No. Material No. Description Qty.A 7102506000029 TC500 Mic cover screw 2.5×6mm 1B 7102004020059 PTS2.0×4 Screw (cross) (low-carbon steel, color zinc plated) 11C 7102009001009 Machine screw M2×9 (color zinc) 2D 7102504000209 Machine screw, cross pan head　PMS2.5*4 carbon steel, color zinc plated 2E 7102505000109 Machine screw 2.5X5 (T9 cross recess head) 21 7400016000009 TC-500 Mic net 12 6100030000019 TC-500 PTT key 13 6000050100009 TC-500 Front case (main unit) (ABS) 14 6201006000009 TC2088-311A Liner (knob) 25 6000158000049 TC368S Channel selector knob 16 6000160000049 TC368S Volumn knob 17 5001010000029 Speaker 4Ω 0.5W (036S23) 18 7400034000009 TC370 Insulating mat (speaker) φ17*1 19 4301040000029 278.378 PTT switch SKHLLBA010 2

10 4302030000019 368 Channel switch RY-6933 111 7206002500019 TC-500 Nut (encoder) 112 7207002200009 278.378 Nut (switch) 113 4303020000039 1688 Switch (volumn) 114 6000046000009 TC2100 Positive connector bracket (black) 115 7500115000009 TC-500 Battery contact pad 216 6201030000009 TC-500 Battery positive terminal 117 7500013000009 TC2100 Water-proof sponge (positive terminal) 118 6100034000009 TC-500US Water-proof ring 119 7500114000009 TC-500 Heat sinking pad 120 6300007001009 TC-500 Aluminum chassis 121 4400100004009 368S Antenna pedestal (main unit) (SMA-B01) 122 6000051000009 TC-500 Rear cover 123 7000015000009 TC-500 Latch spring 124 6000039000009 TC2108 Battery latch (PC+ABS) 125 7400014000019 TC-500 Water-proof PVC sheet (battery) 126 6201022000009 TC2100 Negative terminal (battery) 127 7400133000009 TC-500 PVC Water-proof cushion 228 5205000000199 MIC JACK ISJ-2584-001 129 5205000000289 PHONE JACK 2SJ-2435-001 130 4210060000009 Lead 0.5×60 red 131 4210060000109 Connection cable ASTVR1　0.35×60MM　black 132 5002110000039 Mic rubber CZII-64AP 133 6100075000009 Cushion (Mic rubber) 134 7400075000009 TC-500　Speaker net (non-woven fabric) 135 6000054000009 TC-500 Mic cover 136 6000189000009 TC3000 Light guide 137 6201082000009 TC368 Battery charging connector 338 6201135000009 Planar washer 139 6000154100019 368 Belt clip (PC+ABS) 140 7000018000029 TC600 Belt clip sring (stainless steel) φ1.0mm 141 7000048000009 Shaft 142 6201035000019 TC-600 Belt clip shrapnel (stainless steel) 0.5mm 143 6300010000009 TC-600 Belt clip hardware bracket 144 6000052000059 TC-500 Battery front cover 145 5511100050009 1100mAh Ni-MH*5 battery cell (TC-500) 146 6000053000029 TC-500 Battery bottom cover 147 6201092000009 TC368 Battery positive/negtive pole piece (stainless steel) 248 7500017000019 TC-500 Battery sponge cushion 12.5x10x6.0mm 2


- 48 -

Packing

Owner`s Manual

Antenna

Strap

Belt Clip

Adapter

Gift Box

Owner`s Manual

Main Unit

Charger

Battery Pack


- 56 -

Specifications

Frequency range

400 MHz ~420 MHz

450 MHz ~470 MHz

136 MHz ~150 MHz

150 MHz ~174 MHz

Channel capacity (simplex) 16

Channel spacing 25KHz(wide)/12.5KHz(narrow)

Antenna impedance 50Ω

Microphone impedance 2KΩ

Operation voltage 6V DC

Frequency stability ±2.5×10-6

Transmitter

Carrier frequency error ±2.5×10-6

Carrier output power 4.0W (Hi)/2.0W(Lo)

Modulation sensitivity 12±2mV

Modulation distortion ≤5%

Modulation limiting ≤5KHz(wide)/2.5KHz(narrow)

Bandwidth ≤16 KHz(wide)/8.5KHz(narrow)

Audio response From 6 dB/oct. Pre-Emphasis ±3dB

Conducted spurious

emission ≤7.5μW

Adjacent channel power ≤-65 d B

Receiver

Reference sensitivity ≤0.25µV(wide)/0.35uV(narrow)

Unsquelch sensitivity ≤0.4µV

Audio power 400mW (4Ω)

Audio distortion ≤5%

Modulation acceptance ≥±7 KHz(wide)/ ±3.5KHz(narrow)

Audio response From 6 dB/oct. De-Emphasis +2dB -8dB

Co-channel rejection ≥-8 d B

Blocking ≥85d B

Adjacent channel selectivity ≥60 d B(wide)/50dB(narrow)

Spurious response rejection ≥60 d B

Intermodulation rejection ≥60 d B(wide)/50dB(narrow)

Documents

TC500 Service Manual