209
A0 A0 (V2776) Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred. Indoor unit PC board replacement. Actuation of external protection device. Change the second code No. to "01" or "02" . YES NO NO YES Caution External protection device is connected to terminals T1 and T2 of the indoor unit terminal block. ON/OFF input from outside (mode No. 12, first code No. 1) has been set to external protection device input (second code No. 03) by remote control.

igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

  • Upload
    others

  • View
    1

  • Download
    0

Embed Size (px)

Citation preview

Page 1: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��)

�# � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

�#� CA0D���! ��*���2���� �� $��3�����/��� ��"�� ��B�L�"���� ���& ��� /�B�'�/�%

A0

-��/�"�5/��. !�/'

����������������"����

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������&������ *���������������5���������������&������"���� ����������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*�������&���������������� ����5���������������&������"���� �5��*��*����"������������ ������S���������$!#$������"����S�

���� '�!�&��'�'

� ���������������������&����������������� �"&��&�������� ��� >��������������������������

� �5/�'6 ���)

(V2776)

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Indoor unit PC board replacement.

Actuation of external protection device.

Change the second code No. to "01" or "02" .

YES

NO

NO

YES

Caution

External protection device is

connected to terminals T1 and T2 of the indoor

unit terminal block.

ON/OFFinput from

outside (mode No. 12, first code No. 1) has

been set to external protection device input

(second code No. 03) by remote

control.

Page 2: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��2 ������� *�����-

�#� CA1D���! ��*���2��&�� ��!�B�$�"���� ���& ��� /�B�'�/�%

A1

-��/�"�5/��. !�/'

����������������"����

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8��������"�����$ �

.�/$��"�� ��B�"�'� ��& �!��� �'

7*������������������������������������������"��*���a��$ �a��$ �E���&����������������"�"����� ������� �"�"����������� ������5*����*��&�5��� �&&���� ����������

���� '�!�&��'�'

� >��������������������������

� �5/�'6 ���)

Turn power supply OFF, then power ON again.

Does the system return to normal?

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.Caution

YES

Replace the indoor unit PC board.

The indoor unit PC board is normal.External factor other than malfunction (for example, noise etc.).

(V2777)

NO

Page 3: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��+

�#� CA3D���! ��*���2�.�/$��"�� �� $�B�����+�L�/�& ��� /��%'����=��+>

��� ���& ��� /�B�'�/�%

A3

-��/�"�5/��. !�/'

����������������"����

.��6 !� $�

.�/$��"�� ��B���"�� �

4������� 5���*�$�������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����� ����5������������ ����������������������*������� 5���*�-�� �$����

���� '�!�&��'�'

� ��,F�(,=�&�5��� �&&���� ������&�������� >������������ 5���*���� *���������������������� >�������������&�"&� >��������--��-1��&5���� ��&�1������� >��������������������������� 3�� ������������������������

Page 4: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��/ ������� *�����-

� �5/�'6 ���)

(V2778)

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.Caution

Replace float switch.

Modify the float switch's connection and turn on again.

Connect the drain pump and turn on again.

Check the drain piping for clogging or upward slope, etc.

Replace indoor unit PC board.

Replace the drain pump or check for dirt, etc.

Connect either a short circuit connector or float switch and turn on again.

Defect of indoor unit PC board.

Loose connection of connector.

Provide 220~240V power supply.

Is power supply 220~240V provided?

The float switch is connected

to X8A of the indoor unit PC board.

Thedrain pump

works when the power supply is reset for the

indoor unit.

Thedrain pump is

connected to X25A or terminals Y1 and Y2 of

the indoorunit PC board.

The voltage of

terminals Y1 and Y2 or X25A is

220~240V (within 5 minutes of resetting

the power supply).

Water builds up in the drain pan.

Thefloat switch

contact is forming a short circuit (continuity check with X8A or X15A

disconnected)

YES

YES

YES

YES

YES

YES

YES

YES

NO

YES

YES

YES

The float switch functions normally.

A short circuit connector is

connected to X8A.

Becomesnormal when X8A of

the indoor unit PC board is short circuited

NO

NO

NO

NO

NO

NO

NO

NO

NO

Page 5: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��<

�#� CA6D���! ��*���2�,���. � ��=.�,>�+ "ID�1L��/ �!��� ���& ��� /�B�'�/�%

A6

-��/�"�5/��. !�/'

�J�.�,F2' �=�1��J�.�)F��) =�

.��6 !� $�

.�/$��"�� ��B���"�� �

�����"���������������� ������������������� �-�������&�����"��*�����"�����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*��������������� �������������� �

���� '�!�&��'�'

� 4��8���5��� ���1� *�������������1������ ���������������������� ���"��*�����"�����*���� � ����������"����:4��8���5��� ������������ �������;

� �����"��� �-�������&�����"��*�����"�����:��������������;� ��������������� �� ��������� ��� �������������*��&�5��� �&&��������-�� ����"��������8:>������"�������������������� � ;

� �*�������� �����������������������-��"����� �����8��-��*������ >� ��������������*���������������5�����*��*�-*?&�5�����������:���;������*����5?&�5�����������:���;�

Page 6: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��, ������� *�����-

� �5/�'6 ���)

Properly connect the connector.NO

Replace the fan motor.NO

YES

Remove the foreign matters.

YES

YES

NO

YES

NOReplace the fan motor.

FG

Vsp

Vcc

GND

Vdc

Vdc1

GND2

—3

� �

�� � ��

3FG

4Vsp

1—

2—

5Vcc

Measuring pointFG-GNDVsp-GNDVcc-GNDVdc-GND

CriteriaNot less than 1MΩNot less than 100kΩNot less than 100ΩNot less than 100kΩ

FXAQ20~63MAVE

Disconnect the connector from the fan motor, and then make measurement of resistance between pins.(*2)

Turn OFF the power supply, and then wait for a period of 10 minutes.

Replace the indoor unit PC board.

*1. If any junction connector is provided between the connector (X20A) on the indoor unit PC board and the fan motor, also check whether or not the junction connector is properly connected.

*2. All resistance measuring points and judgment criteria

FXFQ25~125MVE

Judgment Criteria

Are there any foreign matters

around the fan?

Is the connector (X20A) for

the fan motor properly connected to the indoor unit PC

board? (*1)

Bydisconnecting the

connector (X20A) for the fan motor from the indoor unit PC board,

the fan can be lightly rotated by hand.

Is the resistance

between the pins not less than the judgment

criteria?

1 White

2 Orange

3 Brown

4 Blue

5

6

7 Red

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 7: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ���

CA6D���! ��*���2�.�/$��"�� �� $���! ��*����,���. � ���� ���& ��� /�B�'�/�%

A6

-��/�"�5/��. !�/'

�J9.'�F�,, �=�1��J>.�,F2'!=��1��J>.�,F2'!�=�

.��6 !� $�

.�/$��"�� ��B���"�� �

�*� �"����������� �������������*����� �������������� ����������� �-�������&�����"��*�����"�����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*���������������� ��������������������������*��"���"�"����&��������-������*����

���� '�!�&��'�'

� �����������������"����� 4��8���5��� � ��������������

� �5/�'6 ���)

YES

NO

NO

YES

Check the indoor unit fan motor and the wiring circuits of the motor.

Replace the indoor unit PC board.

Properly connect the connectors.(At this time, check for any faulty connector contact or broken wires.)

Are the X4A and X27A

connectors securely connected?

Is the power of approx.

12VDC supplied between the Pins1 and 3 when the X27A is disconnected and the power

supply turns ON?

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 8: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��� ������� *�����-

CA6D���! ��*���2�1L��/ �!�0�1L��"�������0�+ "I� $���! ��*����,���. � �

��� ���& ��� /�B�'�/�%

A6

-��/�"�5/��. !�/'

�J .(,F��) �=�

.��6 !� $�

.�/$��"�� ��B���"�� �

�*� �"����������� ���������������������-��*����*�������������&�5��� �&&�������*��������� �$���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*������� ���������������*����*�������������&�5��� �&&�������*��������������������� �$!�5*��������&��������

���� '�!�&��'�'

� �������&�5��� �&&�������*�����������������"����� ��--���������&�&��-� �������������*�������������� ������������ �������������������*�����5����-��������

� �5/�'6 ���)

NO

NO

YES

YES

Properly connect the cable.

It is supposed that the indoor unit fan motor stops running due to overload, overcurrent, or lock.

Replace the indoor unit PC board.

Is the power supply

cable of the indoor unit fan properly connected?

Restart the fan.

Is the fan normally running?

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 9: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��'

�#� CA7D���! ��*���2�.�/$��"�� �� $��8��)�,/���. � ��=.��>��� ���& ��� /�B�'�/�%

A7

-��/�"�5/��. !�/'

�J.1��J9.1��JA.

.��6 !� $�

.�/$��"�� ��B���"�� �

%����@� �$!#$������*����"��� 5���*�5*����*��"��������� ��

.�/$��"�� ��B�"�'� ��& �!��� �'

7*���$!#$������*��"���� 5���*����&� �������-���������������� ���������*��-*��*�� 5��-���&�"������ �����-�@�������� &��������"���������"��:������',� ����� ;��� ������������ ��� &�����������*�� � ��"��&����� ���������� ���

���� '�!�&��'�'

� >������� 5��-�"����� >������������������������:&�5��� �&&���������"��� 5���*;� >�������������5�������������H� ���-���&?��"� >��������������������������

Page 10: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��( ������� *�����-

� �5/�'6 ���)

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Provide 220~240V power supply.

Replace the limit switch connecting cable.

Replace indoor unit PC board.

Replace the power supply connecting cable.

Replace swing motor.

Take the cam mechanism apart, reassemble and turn on again.

Connect the connector to X9A and turn on again.

Replace indoor unit PC board.

Replace swing motor.

(V2780)

The connecting cable is short-circuited or

disconnected.

Indoor unit is a model equipped with a swing flap

function

The swing motor works when the power supply is turned off and then

back on.

Afterturning

theswing-flap ON

and then stopping with the remote

control, the voltage of X6A of the indoor unit PC

board is 220 ~ 240 VAC (60 Hz) / 220 VAC(50 Hz) when turned on again

(within 30 seconds of turning on

again).

The connector is connected to X9A of the indoor unit

PC board.

The limit switch functions normally.

The connecting cable has no continuity.

Whenthe air flow

direction flap's cam mechanism is

disconnected from the swing motor,operation is normal when

turned on again.

Is power supply 220~240V provided?

Caution

NO

NO

NO

NO

NO

NO

NO

NO

NO

YES

YES

YES

YES

YES

YES

YES

YES

YES

Page 11: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��)

�#; CA9D���! ��*���2��/�"�� ��"��3���'� ��4�/L��.�/$��"�� ��0�B�'��&/ ))��)

��� ���& ��� /�B�'�/�%

A9

-��/�"�5/��. !�/'

�J�.�)F��)

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8�������������������������������&�� �������������� ��-�"������"&�����*��8��� �����--��-��������������������������&�� ����������"������������� ��-�"������"&�����

.�/$��"�� ��B�"�'� ��& �!��� �'

������&�������������������&�� ���������������� ������"���5*�����������@��-�"������"&��������*������*������5��-���������� �� � ���#��� ��#������ �5*�����*������� ��& ��&��������� ��"&���������� �����������:���;�Q���"&������������B����&�&����*�������*��-���:���;Y/U�� ��"&������������B����&�&����*�������*��-���:���;� *�5 ��������-��� ��������5�

���� '�!�&��'�'

� >�����������������������������&�� ���������� >������������������������������ >�������������������

Page 12: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��2 ������� *�����-

� �5/�'6 ���)

NO

NO

NO

YES

YES

Shut the power supply off after connection and then restart.

Replace coil of electronic expansion valve.

Replace relay cables.

When restarting the operation after shutting the power supply off does not work, replace indoor unit PC board.

NO Replace electronic expansion valve main body.

YES

YES

Electronicexpansion valve is

connected to X7A of indoor unit PC board.

Coil check (∗1) of electronic

expansion valve drive indicates normal.

Relay cables short circuit or disconnected.

When power is supplied.

∗1: How to check the coil of electronic expansion valve driveRemove the connector for electronic expansion valve (X7A) from PC board. Measure the resistance value between pins and check the continuity to judge the condition.

φ1

φ3

Yellow(2)

Brown(6)

Blue(4)

φ2 φ4

M

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

1) White

2) Yellow

3) Orange

4) Blue

5) Red

6) Brown

The normal products will show the following conditions:1 No continuity between (1) and (2)2 Resistance value between (1) and (3) is approx. 300 Ω3 Resistance value between (1) and (5) is approx. 150 Ω4 Resistance value between (2) and (4) is approx. 300 Ω5 Resistance value between (2) and (6) is approx. 150 Ω

White (1)

Red (5)

Orange (3)

Page 13: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��+

CA9D���! ��*���2�.�/$��"�� �� $��/�"�� ��"��3���'� ��4�/L��& �/

��� ���& ��� /�B�'�/�%

A9

-��/�"�5/��. !�/'

����������� �����&���J�.�"����

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8�������������������������������&�� �������������� ��-�"������"&�����

.�/$��"�� ��B�"�'� ��& �!��� �'

������&�������������������&�� ���������������� ������"���5*�����������@��-�"������"&�����

���� '�!�&��'�'

� >�����������������������������&�� ���������� >������������������������������ >�������������������

Page 14: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

��/ ������� *�����-

� �5/�'6 ���)

NO

NO

NO

YES

YES

Shut the power supply off after connection and then restart.

Replace coil of electronic expansion valve.

Replace relay cables.

When restarting the operation after shutting the power supply off does not work, replace indoor unit PC board.

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Electronicexpansion valve is

connected to X7A of indoor unit PC board.

Coilcheck (∗1) of

electronic expansion valve drive indicates

normal.

Relaycables short circuit or

disconnected.

YES

∗1: How to check the coil of electronic expansion valve driveRemove the connector for electronic expansion valve (X7A) from PC board. Measure the resistance value between pins and check the continuity to judge the condition.

φ1

φ3

Yellow(2)

Brown(6)

Blue(4)

φ2 φ4

M

The normal products will show the following conditions:1 No continuity between (1) and (2)2 Resistance value between (1) and (3) is approx. 300 Ω3 Resistance value between (1) and (5) is approx. 150 Ω4 Resistance value between (2) and (4) is approx. 300 Ω5 Resistance value between (2) and (6) is approx. 150 Ω

White (1)

Red (5)

Orange (3)

1) White

2) Yellow

3) Orange

4) Blue

5) Red

6) Brown

Page 15: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ��<

�#@ CAFD���! ��*���2�B�����+�L�/��5 L��+������� ���& ��� /�B�'�/�%

AF

-��/�"�5/��. !�/'

�J.1��J�.1��J�.1��JA.1��J .1��J>.1��J .? �

.��6 !� $�

.�/$��"�� ��B���"�� �

7��������8�-��� ������������ ����������� 5���*�$!#$����&��������5*�����*����"&�� ���� �������?�&��������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*������� 5���*��*��-� ���"�$!����$���5*�����*����"&�� ���� �������?�&��������� ������������ ��� &�����������*�� � ��"��&����� ���������� ���

���� '�!�&��'�'

� 9�"������������:�&����������� ���;����8��-� >�������������&�&��:�&5���� ��&�1�����;� >��������������������������

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Defect of indoor unit PC board.

Modify the drain piping.YES

NO

NO

Check if the humidifier unit is leaking.

YES

(V2782)

Field drain piping has a defect such as upward

sloping.

Ahumidifier unit

(optional accessory) is installed on the indoor unit.

Page 16: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�', ������� *�����-

�# CAJD���! ��*���2�.�/$��"�� �� $�&���"��%�B���������� ��B�L�"�

��� ���" ��� /�!�'�/�%

AJ

-��/�"�5/��. !�/'

����������������"����

.��6 !� $�

.�/$��"�� ��B���"�� �

�&������� ������"�������������-������ � ���������*����&������ �����-����&���������*��"�"������ �����*����"�"��������*���������������������1�����5*��*����*��������� ����"�����������"���� ������"�����

.�/$��"�� ��B�"�'� ��& �!��� �'

�� 7*����*����&������������ �������������������*���������G �"�"���1������*����&������ �����-����&����� ���������������

�� ������&�������*���� ������������������*�����������"������ � ���

���� '�!�&��'�'

� �*����&������ �����-����&����5� ������� �������� >��������������������������

� �5/�'6 ���)

(V2783)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Install a capacity setting adapter.

Replace the indoor unit PC board.NO

YES

YES

NO

Replace the indoor unit PC board.

The indoor unit PC board was

replaced with a replacement PC board.

Was the capacity setting

adapter mounted when replacing the PC board?

Page 17: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �'�

�#N CC4D���! ��*���2�.�/$��"�� �� $� 6����'� ��=�� >�$ ��������3"6��)��

��� ���& ��� /�B�'�/�%

C4

-��/�"�5/��. !�/'

����������������"���� �

.��6 !� $�

.�/$��"�� ��B���"�� �

��������������������� ������������������"&��������������������*�������*��-����*��"� �����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*��*�������*��-����*��"� ��������"� ��� ������������� *������5*�����*�������� �������-��

���� '�!�&��'�'

� >��������*��"� ����:���;������B����&�&��� >��������������������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Normal (The malfunction is caused by faulty contact.)

Replace the indoor unit PC board.

Replace the thermistor (R2T).

Remove the thermistor from the indoor unit PC board, and then make resistance measurement of the thermistor using a multiple meter.

YESIs the thermistor normal?

∗5 kΩ to 90 kΩ

Caution

Remove the thermistor from the indoor unit PC board, and then insert it again.

YES

NO

NO

Page 18: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�'� ������� *�����-

�#�� CC5D���! ��*���2�.�/$��"�� �� $� 6����'� ��=�� >�$ ��H�'�����'

��� ���& ��� /�B�'�/�%

C5

-��/�"�5/��. !�/'

����������������"���� �

.��6 !� $�

.�/$��"�� ��B���"�� �

��������������������� ������������������"&��������������������-� �&�&���*��"� �����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*��-� �&�&���*��"� ��������"� ��� ������������� *������5*�����*�������� �������-��

���� '�!�&��'�'

� >��������������������*��"� ����:�'�;����-� �&�&��� >��������������������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Normal (The malfunction is caused by faulty contact.)

Replace the indoor unit PC board.

Replace the thermistor (R3T).∗5 kΩ to 90 kΩ

Remove the thermistor from the indoor unit PC board, and then insert it again.

Remove the thermistor from the indoor unit PC board, and then make resistance measurement of the thermistor using a multiple meter.

YESIs the thermistor normal?

Caution

YES

NO

NO

Page 19: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �''

�#�� CC9D���! ��*���2�.�/$��"�� �� $� 6����'� ��=�� >�$ ����"�� ��-��

��� ���& ��� /�B�'�/�%

C9

-��/�"�5/��. !�/'

����������������"���� �

.��6 !� $�

.�/$��"�� ��B���"�� �

��������������������� ������������������"&�������������������� �������������"&���������*��"� �����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*�� �������������"&���������*��"� ��������"� ��� ������������� *������5*�����*�������� �������-��

���� '�!�&��'�'

� >��������������������*��"� ����:���;�������������� >��������������������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.Caution

Remove the thermistor from the indoor unit PC board, and then insert it again.

Remove the thermistor from the indoor unit PC board, and then make resistance measurement of the thermistor using a multiple meter.

YES

Is the thermistor normal?*

*5 kW to 90 kW

YES

NO

NO

Normal (The malfunction is caused by faulty contact.)

Replace the indoor unit PC board.

Replace the thermistor (R1T).

Page 20: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�'( ������� *�����-

�#�� CCAD���! ��*���2�.�/$��"�� �� $� 6����'� ��=�� >�$ ��B�'"6��)��-��

��� ���& ��� /�B�'�/�%

CA

-��/�"�5/��. !�/'

����������������"���� �

.��6 !� $�

.�/$��"�� ��B���"�� �

��������������������� ������������������"&�������������������� �������������"&���������*��"� �����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*�� �������������"&���������*��"� ��������"� ��� ������������� *������5*�����*�������� �������-��

���� '�!�&��'�'

� >��������������������*��"� ����:�(�;�������������� >��������������������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Normal (The malfunction is caused by faulty contact.)

YES

NO

Replace the indoor unit PC board.YES

Replace the thermistor (R4T).NO5 kΩ to 90 kΩ

Remove the thermistor from the indoor unit PC board, and then insert it again.

Is the thermistor normal?∗

Remove the thermistor from the indoor unit PC board, and then make resistance measurement of the thermistor using a multiple meter.

Page 21: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �')

�#�� CCJD���! ��*���2�.�/$��"�� �� $� 6��� '�������' �������� ���& ��� /

��� ���& ��� /�B�'�/�%

CJ

-��/�"�5/��. !�/'

����������������"���� �

.��6 !� $�

.�/$��"�� ��B���"�� �

��������������������� ������������������"&����������������������"������������������"&���������*��"� �����:!���E;

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����"������������������"&���������*��"� ��������"� ��� ������������� *������5*�����*�������� �������-��

���� '�!�&��'�'

� >���������"�������������*��"� ���� >���������"�������������������

� �5/�'6 ���)

� ��2 ∗�E�9�5�����������C�*�����������"�������������� D���� ��*��C$&�����#����&D�����������(� ����� �����"����5*�����*��"���������������� ��� &����������*���� &�������"����

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Replace remote control.

External factor other than equipment malfunction.(for example, noise etc.)

(V2787)

Caution

NO

Clear the malfunction code history. (While in inspection mode, press and hold the “ON/OFF” button for a period of five seconds or more.)

Is "CJ" displayed on the remote control?

YES

Page 22: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�'2 ������� *�����-

�#�� CE1D�1��! ��*���2��&�� ��!�B�$�"���� ���& ��� /�B�'�/�%

E1

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�����"������� �����������������*����""������������������� �����*��*���5���� ����������5�����*�����������������������������������������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����""������������������� �����*��*���5���� ����������5�����*�������������������*�������������������*��������������������������"���

���� '�!�&��'�'

� >����������������������������:���;� >����������������������������:���;� >����������������������� ���#���� ����������5���

� �5/�'6 ���)

NO

Replace outdoor main PC board (A1P).

Connect the inside/ outside relay wires correctly.

(V3064)

NO

YES

Turn off the power once and turn on again.

Return to normal? YES

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

External factor other than malfunction (for example, noise etc.).

While in monitor mode, check the outdoor unit and the function unit concerned

Check if inside /

outside relay wires of outdoor main PC board

is disconnected.

Page 23: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �'+

�#�� CE3D�1��! ��*���2�-"����� �� $���)6����''�����8��"6��� ���& ��� /�B�'�/�%

E3

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�����"������� ����������5*����*�������������*��*�-*�&�� ����&���������� 5���*��&�� �

.�/$��"�� ��B�"�'� ��& �!��� �'

������� �-���������5*����*��9������������������������*� ��*����"���� &����������*���&��������"����:��������;�$&������-�&�� ������*�-*�&�� ���� 5���*$&������-�&�� ���E(�, ���� ���&�� ���E '�, ��

���� '�!�&��'�'

� �������������������������*�-*�&�� ���� 5���*� >�������9�-*�&�� ���� 5���*� >��������������������"������������:���;� �� ��������� �&�5���������� �������*�-*�&�� ���� �� ��

Page 24: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�'/ ������� *�����-

� �5/�'6 ���)

NO

YES

YES

YES

NO

NO

YES

NO

Check for the points shown below.1 Is the stop valve open?2 Is the HPS connector properly connected to the

main PC board?3 Does the high pressure switch have continuity?

Are the three points above OK?

Rectify defective points, if any.

NO

YES

Check if the “high pressure” value and

the actual measurement value by pressure sensor are the

same.

Replace main PC board ( A1P).

1 Mount a pressure gauge on the high-pressure service port.2 Reset the operation using the remote controller, and then restart the

operation.

Does the stopdue to malfunction (E3)

recur?

Isthe HPS

operating value normal (i.e., 4.0MPa)?

Are the characteristics of the

high pressure sensor normal?(See *1.)

Replace the HPS.

Replace the high pressure sensor.

· The high pressure sensor is normal, and the pressure detected with the PC board is also normal.· The high pressure has really become high.

CHECK 5Referring to information on P335, remove the causes by which the high pressure has become high.

*1: Make a comparison between the voltage of the pressure sensor and that read by the pressure gauge.(As to the voltage of the pressure sensor, make measurement of voltage at the connector, and then convert it to pressure according to information on P401.)

*2: Make measurement of voltage of the pressure sensor.+5V

(4)

(3)

(2)

(1)

Connector for high pressure sensor (Red)

Highpressuresensor

Micro controllerA/D input

Make measurement of DC voltage between these wires.

Red

Black

White

Connect the service checker to compare the “high pressure” value and the actual measurement value by pressure sensor (Refer to *1) by using the service checker.

Service Checker

While in monitor mode, check the outdoor unit and the function unit concerned.

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 25: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �'<

�#�; CE4D�1��! ��*���2�-"����� �� $�+ 8����''�������' ���� ���& ��� /�B�'�/�%

E4

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�����"������� ��������������*��&�� ����������5��*��*����5�&�� ���� �� ���

.�/$��"�� ��B�"�'� ��& �!��� �'

������� �-���������5*����*����5�&�� ����� ����&&�����������"&�� ����&��������$&������-�&�� ���E,�,+ ��

���� '�!�&��'�'

� �����"������&�����5�&�� ����:3�5����*���,�,+ ��;� >���������5�&�� ���� �� ��� >���������������������������� ���&�������� ������&�����

Page 26: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�(, ������� *�����-

� �5/�'6 ���)

NO

YES

NO

YES

YES

CHECK 6

Is the stop valve open?

Open the stop valve.

1 Mount a pressure gauge on the low-pressure service port.

2 Reset the operation using the remote control, and then restart the operation.

Are the characteristics of the

low pressure sensor normal?(See ∗1.)

Check if the “low pressure” value and

the actual measurement value by pressure sensor are the

same.

Replace the low pressure sensor.

· The low pressure sensor is normal, and the pressure detected with the PC board is also normal.

· The low pressure has really become low.

Referring to information on P336, remove the causes by which the low pressure has become low.

∗1: Make a comparison between the voltage of the pressure sensor and that read by the pressure gauge.(As to the voltage of the pressure sensor, make measurement of voltage at the connector, and then convert it to pressure according to information on P401.)

∗2: Make measurement of voltage of the pressure sensor.

Caution or parts damage may be occurred.

Replace main PC board (A1P).

NO

Connect the service checker to compare the “low pressure” value and the actual measurement value by pressure sensor (Refer to ∗1) by using the service checker.

Service Checker

+5V

(4)

(3)

(2)

(1)

Connector for low pressure sensor

Micro controller A/D input

Make measurement of DC voltage between these wires.

(Blue)

Red

Black

White

Low pressuresensor

Page 27: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �(�

�#�@ CE5D�1��! ��*���2���L������& ����'' ��. � ��+ "I��� ���& ��� /�B�'�/�%

E5

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�������������������8� ��*��&� ������ �-������"�%=7�������������������5�����*�����������������"&�� ��1������*��"����������� ����������5*������������"������� ��� ����������*��&*� �?��������5�����"�

.�/$��"�� ��B�"�'� ��& �!��� �'

�*� �"����������5����������&���5*����*�������������"&�� ���"�������� ����� ������&��������������� �����&�"����

���� '�!�&��'�'

� �����������"&�� ������8� 9�-*������������&�� ����:,�) ������"���;� ����������%=7�5����-� ������������������������ ���&�������� ����������� ���

Page 28: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�(� ������� *�����-

� �5/�'6 ���)

Ensure correct connection.

Replace the compressor (M1C).

NO

NO

NO

YES

NO

YES

NO

YES

NO

NO

NO

NO

YES

YES

Check if the stop valve is

open.

Power OFF

Power ON

Check if the connection of UVW

phase order is correct.

The compressor coil has disconnection

of wires.

Restart and check the operation.

Check if the condition occurs again.

Check if the inverter

output voltage between 3 phases is within

± 5V.

The insulation resistance of the compressor

is low (not more than 100kW).

YES

YES

U

V

W

Remove the connection between the compressor and inverter. Set the power transistor check mode ON using “Setting mode 2” of the outdoor unit PC board.

Measure the inverter output voltage (*2).Note: Measurement should be made while the frequency is stable.

Replace the inverter PC board (A3P).

Replace the inverter compressor.

While in monitor mode, check the outdoor unit and the function unit concerned.

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

*1: Pressure difference between high pressure and low pressure before starting.*2: The quality of power transistors/ diode modules can be judged by executing Check 4 (P334). (Check it shutting the power supply off.)

Defect of pressure equalizing Check the refrigerant circuit.

Conclude the workThere is a possibility of defect of pressure equalizing.Check the refrigerant circuit.

Replace the connecting wires and ensure right connection of the connector.

Local factorOpen the stop valve.

Check if the start mode is in

the high differential pressure (not less than

0.5 MPa).

Check if the relay wires to the

compressor are correct.

Page 29: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �('

�#� CE6D�1��! ��*���2�� B�& ����'' ��. � ��1L��"������0+ "I

��� ���& ��� /�B�'�/�%

E6

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>����� ��*��������������5��*��������� �� ���:�;�

.�/$��"�� ��B�"�'� ��& �!��� �'

����������� ���������5*����*������������������������������� ��*������5�"�������������������� ����� �� (,,�=������E��)�,��

���� '�!�&��'�'

� �� ��� ��&������� $� ����� �����*������������� �"&��&���&�5��������-�� �������"�-������ 5���*� ���������"&�� ��� ��������������� �� ���:�2�1��+�;

� �5/�'6 ���)

� ��2 ∗��$������*��&� ���������� �"�������*�������-�����������-*� -����������∗�������"����� �� �*���������� �� ���������� �,������-���>���"&�� ����&��������� �*���������� �� ���������� �"�����*����)�,�������-���>���"&�� ��� ��&�

Is the stop valve open?

Obstacle exists around the air outlet.

Isthe power supply voltage normal?

Isthe magnetic

switch (K2M, K3M) normal?

Is above wiring correct?

Is current sensor correct? ∗1

Check the wiring from power supply ~ current sensor (A6P, A7P) ~ MgS (K2M, K3M) ~ compressor

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.Caution

YES

NO

NO

NO

YES

YES

YES

YES

YES

NO

NO

NO

Open the stop valve.

Remove the obstacle.

Correct the power voltage.

Replace the magnetic switch.

Correct wiring.

Replace the corresponding current sensor(A6P or A7P).

Replace compressor.(V3051)

Page 30: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�(( ������� *�����-

�#�N CE7D�1��! ��*���2�.�/$��"�� �� $�1��! ��*����,���. � ���� ���& ��� /�B�'�/�%

E7

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>��������"������������ �������*��������������������*���!=��������������:� ����"������1�������������������*������������;�>��������"��������������*�����"��������������� �������*����"���������������������������*�����������-��*�����"������&��������

.�/$��"�� ��B�"�'� ��& �!��� �'

� $������������ ��������������!=��������������:�(�;��������!=��������������:�)�;�:�� ��"���5��� ���� ������(���"� �������������;

� ����*�����������������"�������������1��*����"���������������� �����5��*���������"�������"�����*���2� ����� ��:�� ��"���5��� ���� ������(���"� �������������;�

���� '�!�&��'�'

� �������������"����� >�����������������������������*����������� #�*���� ����5�����*�����"����������������� �*�����������������������������������-�� �� ����� ������-����� ��������������E������������"����&�����������)�"�����

Page 31: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �()

� �5/�'6 ���)

YES

YES

YES

NO

NO

NO

Check in the monitor modeRTSQ14-16P class models have 2 fans.Check electric motor (electric motor 1 or 2) corresponding to malfunction code “E7” in the monitor mode of outdoor unit PC board. (Refer to P226 - P227 for how to check)

Check the connection status of the connectors� Fan motor 1: relay connector or X1A, X2A of compressor

inverter PC board.� Fan motor 2: relay connector or X1A, X2A of fan inverter

PC board.

Check the color of relay connectors� Fan motor 1: Both power supply wire and signal wire are

all white.� Fan motor 2: Both power supply wire and signal wire are

red in the PC board side and white in the motor side.

Cut the power supply OFF and wait for 10 minutes.

A

Check if any foreign

substances around the fan.

Check if any connector is disconnected.

Relay connectors have any connection

error.

Remove the foreign substances.

Insert the connector.

Correct the connection of the relay connectors.

8HP

12HP

~

14HP

16HP

~

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 32: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�(2 ������� *�����-

� �5/�'6 ���)

YES

YES

NO

NO

NO

YES

NO

YES

NO

YES

NO

YES

Check 1Check fan motor connector (power supply wire)

Check 2Check fan motor connector (signal wire)

Put the power supply ON to check the following LED lamps.1) HAP lamp on the compressor PC board (A4P)2) HAP lamp on the fan inverter PC board (A5P)

(Referring to the information on P347)

(Referring to the information on P347)

A

Replace fan inverter PC board.

Replace the corresponding fan motor.

Replace the corresponding fan motor.

Replace the corresponding fan motor.

Replace the corresponding fan motor.

Replace fan inverter PC board.

Replace fan motor 2.

Nocontinuity of fuse

(FIU) on the fan inverter PC board.

Unable to rotate the fan

manually with ease when removing the connector of

the fan motor.

Resistancevalue between the

power supply wire terminal of fan motor and the motor frame

(metal) is 1MΩ andbelow.

Thesignal wire short

circuits between Vcc and GND and between UVW

and GND.

HAPlamp for the A5P

does not blink on the condition that HAP lamp for

A4P is blinking.

Theresistance value

between UVW phases of fan motor is out of balance, or short

circuit between UVW phases.

Page 33: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �(+

�#�� CE9D�1��! ��*���2�.�/$��"�� �� $�. L��)������ $��/�"�� ��"��3���'� ��4�/L��=���E���>

��� ���& ��� /�B�'�/�%

E9

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������������� �������������������� �������������:0��;����������������&�� ���������

.�/$��"�� ��B�"�'� ��& �!��� �'

!����������� ��������������*����""���:$ �]P^;�5*���&�5��� �&&���� �$!�

���� '�!�&��'�'

� >� ���������������������� �����������������&�� ����������:0��;� >�������"����-�&�������������������&�� ���������� >��������������������"������������:���;

Page 34: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�(/ ������� *�����-

� �5/�'6 ���)

(V3067)

(Orange) 1

Measuring points

1 - 62 - 6

3 - 6

4 - 6

Judgment criteria

40~50Ω

(Red) 2

(Yellow) 3

(Black) 4

5

COM[+] (Gray) 6

(V3067)

∗ Make measurement of resistance between the connector pins, and then make sure the resistance falls in the range of 40 to 50Ω.

YES

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Return to normal?

Turn power supply off, and turn power supply on again.

Theconnector

of outdoor unit PC board for electronic

expansion valve is connected.

Replace the connecting cable.

Replace outdoor unit PC board (A1P).

YES

YES

NO

Ensure correct connection.

External factor other than malfunction (for example, noise etc.).

NO

The coil resistance of electronic

expansion valve is normal.(Refer to ∗1)

NO

Check the electronic expansion valve corresponding to the malfunction code “E9” in the monitor mode. (Refer to Page 211~214 for how to check.) � When Check 4 shows as follows:

→ Electronic expansion valve for main use (Y1E) or electronic expansion valvefor liquid injection (Y1E)

� When Check 4 shows as follows:→ Electronic expansion valve for refrigerant charge (Y2E) or 2 stage selection 1

electronic expansion valve (Y2E1)� When Check 4 shows as follows:

→ Electronic expansion valve for subcooling (Y3E) or 2 stage selection 2electronic expansion valve (Y2E2)

� Explanation of “ ” Master unitSlave unitFunction unit

Page 35: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �(<

�#�� CF3D�1��! ��*���2�-5� ���/�B�'"6��)������� ����������

��� ���& ��� /�B�'�/�%

F3

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�����"������� ������������������-�����*����"&���������������������*���� �*��-��&�&����"&�������� �� ���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*���� �*��-��&�&����"&���������� � ������������"�����*�-*�������:�')�U����������;7*����*���� �*��-��&�&����"&���������� � � ��������:��,�U��������������,� ���� ����"����� ;

���� '�!�&��'�'

� ��������� �*��-��&�&����"&�������� �� ��� ���������������������� �*��-��&�&����"&�������� �� ��� ����������������������������:���;

Page 36: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�), ������� *�����-

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

NO

NO

Replace discharge pipe thermister.

Replace main PC board ( A1P).

YES

· Discharge pipe thermister is normal and the temperature detection of the main PC board is also normal.

· Actually the temperature of discharge pipe is high.

Check 3 Remove the factor of overheat operation referring to P333.

Service CheckerConnect the service checker to compare the temperature of discharge pipe by using service checker with actual measurement value of discharge pipe thermister (Refer to ∗1).

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

While in monitor mode, check the outdoor unit and the function unit concerned.

Check if temperature of

discharge pipe by using service checker is the same with actual

measurement value of discharge pipe

thermister.

∗1: Compare the resistance value of discharge pipe thermister and the value based on the surface thermometer.

Check if discharge pip

thermister property is normal.

(∗1)

Connect the service checker. Press reset and start operation again.

Page 37: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �)�

�#�� CF6D�1��! ��*���2���$��)������1L��"6��)�!��� ���& ��� /�B�'�/�%

F6

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

���� �����*��-��-�������-������� �������������� ��-��*����� ����������"&�������1�*�������*��-��-����������"&��������������B����&�&����"&�������������-����*��8������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*���"�����������-�����1�5*��*�� ���������������� ��-��*����� ����������"&�������1�*�������*��-��-����������"&��������������B����&�&����"&�������������-����*��8����1������� ��*�� ��������

���� '�!�&��'�'

� ����-�����������*��-�� � ���-�"�������*����� ���������*��"� ���� � ���-�"�������*��*�������*��-��-���������*��"� ���� � ���-�"�������*����B����&�&���*��"� ���

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V2797)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Are the above thermistor installed on pipes

correctly?

Check the mounting condition of the temperature sensors of the outside air thermistor, heat exchanging deicer thermistor and liquid pipe thermistor in the piping.

Remove the outside air thermistor, heat exchanging deicer thermister and the liquid pipe thermistor from the outdoor PC board and measure resistance with a tester.

Is the characteristic of the

above thermistor normal?

Refrigerant overcharged.YES

NO

NO

Replace thermistor.

Install thermistor correctly.

YES

Page 38: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�)� ������� *�����-

�#�� CH7D�1��! ��*���2�-5� ���/�1��! ��,���. � ����)��/��� ���& ��� /�B�'�/�%

H7

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>����������������"��� �-������"����"�����

.�/$��"�� ��B�"�'� ��& �!��� �'

����� ���������������������"��� �-������� ������-����"�����

���� '�!�&��'�'

� �����"������"����� �-����:��������"���������;� 4��8��1� *��������� ��������������������������"���������������������� ������������������������:�(�;� ���������������������"����������:�)�;

Page 39: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �)'

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Ensure correct connection.NO

YES

Replace fan motor.NO

YES

Cut the power supply off.

Check the fan motor corresponding to the malfunction code “H7” in the monitor mode.(Refer to Page 211~214 for how to check)When check 3 shows as follows:

→ Fan motor 1 (M1F)When check 3 shows as follows:

→ Fan motor 2 (M2F)Identify outdoor unit based on Check 4.

Explanation for “ ” Master unitSlave unit 1Slave unit 2System

Check if signal wire connector for the

corresponding fan motor is normal.

Check the connector of the fan motor (∗1).

Check if the resistance of the

fan motor lead wire between Vcc and UVW and between GND

and UVW are balanced.

∗1. Check procedure for fan motor connector(1) Power OFF the fan motor.

(2) Remove the connector (X2A or X4A) on the PC board to measure the following resistance value. Judgment criteria: resistance value between each phase is within ±20%

Replace inverter PC board.With single systems�For fan motor 1: replace

inverter PC board (A4P) �For fan motor 2: replace fan

inverter PC board (A5P) With multi systems

�For fan motor 1: replace fan inverter PC board (A4P)

Connector for signal wires (X2A or X4A)

X2A

(V2799)

5 Gray

4 Pink

3 Orange

2 Blue

1 Yellow

GND

Vcc

W

V

U

Measure the resistancebetweenVcc-UVW and GND-UVW.

Page 40: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�)( ������� *�����-

�#�� CH9D�1��! ��*���2�.�/$��"�� �� $� 6����'� ��=�� >�$ ��1��! ��-��

��� ���& ��� /�B�'�/�%

H9

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"��*����"&���������������������*���������������*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����� ����������"&���������*��"� ����*� � *����������������&�����������

���� '�!�&��'�'

� >���������*��"� ��������������� >��������*��"� ����:���;���������������� >����������������������������:���;

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3070)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Resistanceis normal when measured after

disconnecting the thermistor (R1T) from the outdoor

unit PC board.(1.8kΩ to 800kΩ)

Connector is connected to X18A of

outdoor PC board (A1P).

Replace outdoor unit PC board (A1P).

Connect the connector and turn on again.

NO

NO

Replace the thermistor (R1T)

YES

YES

Page 41: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �))

�#�� CJ2D�1��! ��*���2�&����������' ��.�/$��"�� ���� ���& ��� /�B�'�/�%

J2

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������������-�����*������������������������������������ �� ���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*������������������������������������ �� �������"� �)�������5��1����(,�����"���������-� ����������"&�� ����&��������

���� '�!�&��'�'

� ��������������� �� ���:�2�1��/�;� ���������������������������� >����������"&�� ���: �1� ';

� �5/�'6 ���)

(V3071)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Is the current sensor

mounted on the T-phase (A6P) wire?

Are the current sensors inversely

connected to two STD compressors?

Is the connector for

current sensor connected to X25A, X26A

on outdoor unit PC board

(A1P)?

Replace current sensor or outdoor unit PC board.

Connect the connector, and operate unit again.

NO

NO

Mount the current sensor correctly, and operate unit again.

YES Correct the connections between the current sensors and the STD compressors.

Applicable compressor coil wire is

broken.

YES Replace compressor.(STD compressor 1 or 2)

NO

NO

YES

YES

Check the current sensor corresponding to the malfunction code “J2” in the monitor mode.(Refer to Page 211~214 for how to check)� Check 4 shows as follows:

→ Current sensor for constant rate compressor 1� Check 4 shows as follows:

→ Current sensor for constant rate compressor 2

Page 42: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�)2 ������� *�����-

�#�; CJ3D�1��! ��*���2�.�/$��"�� �� $�B�'"6��)������� 6����'� ��=��� D��� D��� >

��� ���& ��� /�B�'�/�%

J3

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"��*����"&���������������������� �*��-��&�&����"&���������*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����� *�������������������&���������������*���� �*��-��&�&����"&���������*��"� ����� ����������

���� '�!�&��'�'

� >��������*��"� ����:�'��1��'��1��''�;������������������� �*��-��&�&�� >����������������������������:���;� >��������*��"� ��������������

� �5/�'6 ���)

�*������"������������ ��� &������5*����*������ �����-�� ����� ���

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,'�

(V3072)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Resistanceis normal when measured after

disconnecting the thermistor R31, 32T or R33T from the outdoor

unit PC board. (2.5kΩ to 1.3kΩ)

Replace outdoor unit PC board (A1P).

Connect the connector and turn on again.

NO

NO

Replace the thermistor (R31, 32T or R33T)

YES

YES

Connectoris connected to

X29A of outdoor unit PC board (A1P).

Confirm which discharge thermistor is abnormal using outdoor unit "monitor mode". (Refer to P226~227)

Page 43: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �)+

�#�@ CJ4D�1��! ��*���2�.�/$��"�� �� $� ��������������' ��$ ��������3"6��)���H�'�=�� >

��� ���& ��� /�B�'�/�%

J4

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>������"������������ �������*����"&�����������������������*��*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

����&�������1�5*������*��"� ����� ��� ������������� *����������� �

���� '�!�&��'�'

� >����������������������*��"� ���� >���������*��"� ���� >����������������������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3070)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Resistanceis normal when measured after

disconnecting the thermistor (R2T) from the outdoor

unit PC board. (1.8kΩ to 800kΩ)

Connector is connected to X30A of

outdoor PC board (A1P).

Replace outdoor unit PC board (A1P).

Connect the connector and turn on again.

NO

NO

Replace the thermistor (R2T)

YES

YES

Page 44: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�)/ ������� *�����-

�#� CJ5D�1��! ��*���2�.�/$��"�� �� $� 6����'� ��=� >�$ ����"�� ������

��� ���& ��� /�B�'�/�%

J5

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"��*����"&���������������������*�� �������&�&����"&���������*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����� *�������������������&���������������*�� �������&�&����"&���������*��"� ����� ����������

���� '�!�&��'�'

� >��������*��"� ����:�/�;����������������� �������&�&�� >����������������������������:���;� >��������*��"� ��������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3073)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Resistanceis normal when measured after

disconnecting the thermistor (R8T) from the outdoor

unit PC board. (1.8kΩ to800kΩ)

Replace outdoor unit PC board (A1P).

Connect the connector and turn on again.

NO

NO

YES

YES

Connectoris connected to

X11A, of outdoor unit PC board.

(A2P)

Replace the thermistor R8T.

Page 45: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �)<

�#�N CJ6D�1��! ��*���2�.�/$��"�� �� $� 6����'� ��=�� >�$ ��1��! ��*����������3"6��)��

��� ���& ��� /�B�'�/�%

J6

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"��*����"&���������������������*��*�������*��-����*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����� *�������������������&���������������*��*�������*��-���*��"� ����� ����������

���� '�!�&��'�'

� >��������*��"� ����:�(�;���������������������� >����������������������������:���;� >��������*��"� ��������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3074)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Resistanceis normal when measured after

disconnecting the thermistor R4T from the indoor

unit PC board. (1.8kΩ to 800kΩ)

Replace outdoor unit PC board (A1P).

Connect the connector and turn on again.

NO

NO

Replace the thermistor R4T.

YES

YES

Connectoris connected to X30A

of outdoor unit PC board (A1P).

Page 46: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�2, ������� *�����-

�#�� CJ7D�1��! ��*���2�.�/$��"�� �� $�+�F��!������ 6����'� ����=�; � ���N >

��� ���& ��� /�B�'�/�%

J7

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������������-�����*����"&����������������������B����&�&���*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����B����&�&���*��"� ����� � *������������������&���

���� '�!�&��'�'

� ���������B����&�&���*��"� ������:�2������<�;� ���������������������������� >��������*��"� ��������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3075)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Is the resistance

measured after removing the thermistor

(R6T or R9T) from outdoor unit PC board normal?

(1.8kΩ to 800kΩ)

Replace outdoor unit PC board (A1P).

Connect the connector and operate unit again.

NO

NO

Replace thermistor (R6T or R9T).

YES

YES

Isthe connector for liquid pipe

thermistor connected to correct outdoor unit

PC board?

Page 47: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �2�

�#�� CJ8D�1��! ��*���2�.�/$��"�� �� $�+�F��!������ 6����'� ����=�@ >

��� ���& ��� /�B�'�/�%

J8

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������������-�����*����"&����������������������B����&�&���*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����B����&�&���*��"� ����� � *������������������&���

���� '�!�&��'�'

� ���������B����&�&���*��"� ������:�+�;� ���������������������������� >��������*��"� ��������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3075)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Is the resistance

measured after removing the thermistor (R7T) from outdoor unit

PC board normal? (1.8kΩ to 800kΩ)

Replace outdoor unit PC board (A1P).

Connect the connector and operate unit again.

NO

NO

Replace thermistor (R7T).

YES

YES

Isthe connector for liquid pipe

thermistor connected to X30A on outdoor

unit PC board (A1P)?

Page 48: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�2� ������� *�����-

�#�� CJ9D�1��! ��*���2�.�/$��"�� �� $���5" /��)�������3"6��)���H�'������ 6����'� ��=�� >

��� ���& ��� /�B�'�/�%

J9

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������������-�����*����"&�������������������� ��������-�*�������*��-���-� �&�&���*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*�� ��������-�*�������*��-���-� �&�&���*��"� ����� � *������������������&���

���� '�!�&��'�'

� ������� ��������-�*�������*��-���-� �&�&���*��"� ����:�)�;� ���������������������������

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

(V3075)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Is the resistance

measured after removing the thermistor (R5T) from outdoor unit

PC board normal? (1.8kΩ to 800kΩ)

Replace outdoor unit PC board (A1P).

Connect the connector and operate unit again.

NO

NO

Replace thermistor (R5T).

YES

YES

Isthe connector

for subcooling heat exchanger gas pipe

thermistor connected to X30A on outdoor

unit PC board (A1P)?

Page 49: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �2'

�#�� CJAD�1��! ��*���2�.�/$��"�� �� $���)6����''�������' ���� ���& ��� /�B�'�/�%

JA

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"��*��&�� �����������������*��*�-*�&�� ���� �� ���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*��*�-*�&�� ���� �� ���� � *����������������&�����������:!����� ��*���(��� ��1����,�,� �����������5;

���� '�!�&��'�'

� >�������*�-*�&�� ���� �� ��� � ��"� ��������������5�&�� ���� �� ���5��*�5���-�������������� >����������������������������:���;�� >���������������������*�-*�&�� ���� �� ��

� �5/�'6 ���)

(V2806)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

∗1: Pressure sensor subject to malfunction code

Malfunction code

JA High pressure sensor S1NPH

Electric symbolPressure sensor subject to malfunction code

Replace the main PC board (A1P).

Replace the high pressure sensor.

YES

NO

Replace the main PC board (A1P).NO

Replace the high pressure sensor.

YES

NO

Arethe characteristics

of the high pressure sensor normal? (Make a comparison

between the voltage characteristcs (∗2) and the gauge

pressure.)

YES

Ifthe PC board

pressure detection normal? (Make a comparison between the

checker pressure data and the voltage characteristics

(∗2).)

1.Set the high pressure gauge upright.

2.Connect the checker for VRV to the gauge.

Confirm which high pressure sensor is abnormal using outdoor unit "monitor mode". (Refer to page 211~214)

Reset the operation, and then restart the outdoor unit.

Are the characteristics of the high

pressure sensor normal?

Page 50: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�2( ������� *�����-

∗�E�=����-��"�� ���"����&����

∗�E���������C��� ������� ��1���� ����#�=����-��*�������� ��� D�����������(,(�

Outside unit PC board A2P+5V

X32A

Red

Black

White

GND

*2 Measure DC voltage here.

Low

pre

ssur

e se

nsor4

3

2

1

(V2807)

MicrocomputerA/D input

Page 51: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �2)

�#�� CJCD�1��! ��*���2�.�/$��"�� �� $�+ 8����''�������' ���� ���& ��� /�B�'�/�%

JC

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"�&�� ������������������5�&�� ���� �� ���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����5�&�� ���� �� ���� � *����������������&�����������:!����� ��*�����++ ��1����?,�,� �����������5;

���� '�!�&��'�'

� >���������5�&�� ���� �� ��� � ��"� ������������*�-*�&�� ���� �� ���5��*�5���-�������������� >����������������������������� >�����������������������5�&�� ���� �� ��

� �5/�'6 ���)

(V2808)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Replace the main PC board.

Replace the low pressure sensor.

YES

NO

Replace the main PC board. (A1P)NO

Replace the low pressure sensor.

YES

NO

Are the characteristics

of the low pressure sensor normal? (Make a

comparison between the voltage characteristics (∗1) and

the gauge pressure.)

YES

Ifthe PC

board pressure detection normal?

(Make a comparison between the checker pressure data and

the voltage characteristics

(∗1).

1.Set the low pressure gauge upright.

2.Connect the checker for VRV to the gauge.

Confirm which low pressure sensor is abnormal using outdoor unit "monitor mode". (Refer to Page 226~227)

Reset the operation, and then restart the outdoor unit.

Are the characteristics of the low

pressure sensor normal?

Page 52: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�22 ������� *�����-

∗�E�=����-��"�� ���"����&����

∗�E���������C��� ������� ��1���� ����#�=����-��*�������� ��� D�����������(,(�

+5V

X31A

(V2809)

GND

Outdoor unit PC board A1P

MicrocomputerA/D input

*2 Measure voltage here.

Low

pre

ssur

e se

nsorRed

Black

White

Page 53: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �2+

�#�� CL1D�1��! ��*���2�B�$�"��L����L�������&�� ��!��� ���& ��� /�B�'�/�%

L1

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������ �������*���������������������-�5�����"����&��������� ������-���"&�� ��� ����������� ������������ �������*����������"��������� �� ��������-� ���*����� ��&��������5*��� ������-��*�������

.�/$��"�� ��B�"�'� ��& �!��� �'

$�����������:$�;���5 ������-�5�����"����&��� �������������������� �� ��������-� ���*����� ��&���������� ��������

���� '�!�&��'�'

� �����������������:�(�;� �� �������� ������� �� ���������� >�������������������

Page 54: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�2/ ������� *�����-

� �5/�'6 ���)

Z���3� �������������������� ���� !�"� ��������� �"���

���.�/1��,1�����"&�� ������������������� �(��������������������� �)�

���.��(1��2��"&�� ������������������� �(��������������������� �)�1��/�

4��.�,� �"&�� ������������������� �'�

Do the lead wires have any

disconnection, broken wire, short circuit, or ground

fault?

Check 4Check if the power

transistor is normal.

YES

Check if insulation resistance of

the compressor is 100kΩand above.

NO

YES

Check 4Check if the power transistor of the fan

driver is normal.

NO

NO

YES

YES

NO

Replace the lead wires.

Replace the compressor and compressor inverter PC board (A4P) at the same time.

Replace the inverter PC board (A4P).

Replace the compressor inverter PC board (A4P) and fan inverter PC board (A5P).

Replace the inverter PC board (A4P).

Does the power supply normally

come back ON?

YES

NO

It is supposed that the malfunction results from external causes other than failures (e.g. exogenous noises or thunder).

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

∗ Check 4 : Referring to the information on P334.

Turn OFF the power supply once, and then check the compressor lead wires.

Turn ON the power supply again.

While in monitor mode, check the unit concerned.

Page 55: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �2<

�#�; CL4D�1��! ��*���2�.�/$��"�� �� $���L��������!�����)�,��� �������������'�

��� ���& ��� /�B�'�/�%

L4

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

������"&��������� ��������������*���*��"� �������*���������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����"&�����������*������������������������������ � �������/+U�

���� '�!�&��'�'

� ����������������*��"���:������� �������/+U;� >������������������������ >�����������*��"� ���

Page 56: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�+, ������� *�����-

� �5/�'6 ���)

∗���������C�*��"� ������ � ������#���"&��������*�������� ��� D�����������(,��

The radiation fin of the inverter PC board

concerned exceeded a temperature of

87°C.

YESFaulty radiation from the power unit• Blocked air suction port• Stained radiation fin• High outdoor temperature

NO

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Is the thermistor resistance normal?

NO

YES

Replace the thermistor.

Doesthe malfunction

recur when the power supply turns ON to start

the compressor?

NO

Replace the compressor inverter PC board.

Continue operation.� It is supposed that the radiation

fin temperature became high due to some field factors. In this connection, check the following points:• Stained radiation fin• Air flow obstructed with dirt or

foreign matters• Damage to fan impellers• Too high outdoor temperature

Turn OFF the power supply, and then make measurement of resistance of the radiation fin thermistor.

While in monitor mode, check the unit concerned.

Connect and disconnect the connector (X111A) for the fin thermistor, and then properly connect it.

YES

Page 57: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �+�

�#�@ CL5D�1��! ��*���2�. ������%�1L��"������� $���L������& ����'' �

��� ���& ��� /�B�'�/�%

L5

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� ������������"�����������5��-�����*��&�5������� � �����:'��'��;

.�/$��"�� ��B�"�'� ��& �!��� �'

7*���������� ��������������5 �����*��&�5������� � ����:�� ��������� ��������������� ����� � ������������;

���� '�!�&��'�'

� >���������"&�� ��������:�� ���������1������������ �������;� �"&�� ��� ����?�&�"����������:"��*����������8;� >�����������������������

Page 58: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�+� ������� *�����-

� �5/�'6 ���) �"&�� ����� &������

Continue operation. Momentary power failure is possible.

Open the stop valve.NO

NO

NO

YES

YES

NO

NO

YES

YES

YES

YES

NO

NO

Power OFF

Check if the wiring and connection to

the compressor are normal.

Insulationresistance of the compressor

is 100 kΩ or below.

Check 4Check if the power transistor

is normal.

Failure occurs again after restarting

the unit.

Compressorcoils are disconnected.

YES

Replace inverter compressor (M1C).

( (

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Check if the stop valve is

open.

Check if the compressor lead

wires are normal.

Replace inverter PC board (A4P).

Replace inverter compressor (M1C).

Replace inverter compressor (M1C).

Correct the wiring and connection.

Replace compressor lead wires.

∗ Check 4 : Referring to the information on P334.

Page 59: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �+'

�#� CL8D�1��! ��*���2�. ������%�1L��"������� $���L������& ����'' �

��� ���& ��� /�B�'�/�%

L8

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

����������� �����������������������5��-�����*��&�5������� � ����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����������������*����"&�� ���� �����������:��������� ������������������2���;:�;��<�,������������������� ����)� ����� �:�;��2��������������������� �����2,� ����� �

���� '�!�&��'�'

� �"&�� ������������ �"&�� ���������� ���������� >������������������������ ���������"&�� ��

Page 60: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�+( ������� *�����-

� �5/�'6 ���) $��&������������*��8

NO

NO

NO

YES

YES

NO

NO

NO

YES

Power OFF

YES

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Check if the stop valve is open.

Check if the compressor lead wires

are normal.

Check if the wiring and connection to

the compressor are normal.

Insulationresistance of the

compressor is 100 kΩ or below.

Compressor coils are disconnected.

Connect the compressor lead wires then restart the operation.

Check 4Check if the power transistor

is normal.

Malfunction code “L8” is displayed again.

Check if the pressure difference between

high pressure and low pressure before restarting is 0.2MPa or

below.

YES

YES

∗ Check 4 : Referring to the information on P349.

Open the stop valve.

Replace compressor lead wires.

Correct the wiring and connection.

Replace inverter compressor. (M1C)

Replace inverter compressor. (M1C)

Replace inverter PC board (A4P).

Continue operation.

Defective pressure equalizing in the refrigerant circuit.

Inspection of the compressor.

Page 61: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �+)

�#�N CL9D�1��! ��*���2���L������& ����'' ���������)�,��/������ ���& ��� /�B�'�/�%

L9

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*����������� �������*�� �-����5�����"����*����"&�� ���

.�/$��"�� ��B�"�'� ��& �!��� �'

�������-��*����"&�� ������ �������"&�����

���� '�!�&��'�'

� ������������&����*�� ��&������� >����������"&�� ��� 7����-����������������������*����"&�� ��� 3��-��&�� ������������������� ������-��*����"&�� ��� >������������������������

Page 62: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�+2 ������� *�����-

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Check if it is the first time to start

after installation.

Check if a right amount of refrigerant

is charged.

Check if the stop valve is open.

Refrigerant is sleeping. ( The unit is out of power supply for more than

6 hours.)

Check if the insulation resistance of the compressor is more than

100kΩ.

Check if the compressor lead wires are

disconnected.

Go on to the next page.( Starting failure due to aged operation.)

Charge a right amount of refrigerant.

Open the stop valve.

Cancel the sleeping state of refrigerant.

Cancel the sleeping state of refrigerant.

Fix the compressor lead wire.

Correct the wiring then supply power to restart.

NO

NO

NO

YES

NO

YES

NO

YES

YES

YES

NO

YES

While in monitor mode, check the unit concerned.

Page 63: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �++

� �5/�'6 ���)

Continued from the previous page. (Start failure due to aged operation.)

Refrigerant is sleeping. ( The unit is out of power supply for more

than 6 hours.)

Check if the insulation resistance of the compressor is 100kΩ or

over.

Broken inside the compressor

Cancel the sleeping state of refrigerant.

Replace the inverter compressor.

Replace the inverter compressor. (M1C)

Replace the compressor inverter PC board. (A4P)

Recheck the compressor/ refrigerant circuit.

NO

NO

NO

YES

NO

YES

YES

YES

Check 4Check if the power transistor is normal.

∗ Check 4

: Referring to the information on P349.

Page 64: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�+/ ������� *�����-

�#�� CLCD�1��! ��*���2�.�/$��"�� �� $� ���'��''� ��5��8������L��������!�& ��� /��&�� ��!

��� ���& ��� /�B�'�/�%

LC

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8��*����""���������� ��������5��������������������������������������������"����?��"&�����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*������������""����������� ��������������������������&������

���� '�!�&��'�'

� ��������������������������5�����*�������������������������������"������������ >���������������"������������:���� "� ���� ������;� >������������������������ >���������� �������� ������������������� ������������&��������������������� ������������������"&�� ��� ����������"����� ���������������:��� ������;

Page 65: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �+<

� �5/�'6 ���)

Z���3� �������������������� �&&�������� ����

,),<?����./�F��2�4��.�,�

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Are the connectors of

the inverter PC board, main PC board, and sub PC

board all securely connected?

Isthe type of the

inverter PC board correct?(*1)

The INV compressor has

insulation resistance of not more than

100kΩ.

The fan motor has insulation resistance

of not more than 1MΩ.

Replace it with a correct PC board.

Properly connect the connectors.

Replace the compressor (M1C).

Replace the fan motor.

NO

NO

NO

YES

YES

NO

YES

YES

YES

NO

Make correct model setting.(For setting procedure, refer to information on P184~.)

NOYESWas the PC

board (A1P) replaced with a spare PC board?

Does the model setting of the substitute PC board

match the system?

A

Page 66: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�/, ������� *�����-

� �5/�'6 ���)

NO

YES

NO

YES

NO

NO

YES

Isany malfunction

code other than "LC"displayed?

The LC malfunction recurs.

Themicrocomputer normal

monitor (green) of the main PC board (A1P)is blinking.

Themicrocomputer normal

monitor (green) of the main PC board (A4P) is blinking.

Take countermeasures following the displayed malfunction code.

Not the LC malfunction. Check the malfunction code again.

Replace the main PC board (A1P).

Continue operation.(It is supposed that the malfunction results from causes such as instantaneous power failure.)

Replace the inverter PC board (A4P).* If the replaced PC board has

significant damage, the compressor is probably get faulty. In this case, carry out inspections on the compressor again.

Disconnect the sensor connector (X2A or X4A) from the fan motor,

and then turn ON the power supply.

YES

A

Page 67: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �/�

�#�� CP1D�1��! ��*���2���L������1L������/���� ��"�� ���� ���& ��� /�B�'�/�%

P1

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�"����������� �&&��������-��� ���������������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*���� � ���������������*��"� ��������"� ����������B�������������&������ *�������������� ���� �� ����������� �������������5*�����*��������&��������� �����������S�S�5��������� &���������&�� ��-��*���� &��������������

���� '�!�&��'�'

� $&���&*� �� =����-���"�����������5����&*� � � >�������"��������������&������� >������������������������ >�������A���������������������������� �"&��&���"������������5����-

Page 68: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�/� ������� *�����-

� �5/�'6 ���)

(V2816)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Isthe voltage

imbalance applied to the inverter in excess of

14 V (Y1)? ∗2

NO

Part or wiring defectAfter turning the power supply OFF, check and repair the main circuit wiring or parts.(1) Loose or disconnected

wiring between power supply and inverter

(2) K2 contact disposition, fusion or contact is poor.

(3) Loose or disconnected noise filterUsing a device capable of

constant recording of power supply voltage record power supply voltage between 3 phases (L1 ~ L2, L2 ~ L3, L3~L1) for about one continuous week.

Open phaseNormalize field cause.

Power supply voltage imbalanceEven if the power supply voltage is not unbalanced when measuring it, there are many cases where it gets unbalanced during nighttime (around 6:00PM to 10:00PM).

No abnormalities are observed in the power supply, but the imbalance in voltage recurs.

Explanation for users

Fix power supply voltage imbalance.

Replace the inverter PC board.

YES

YES

NO

Imbalance in supplied voltage is in excess of 14 V (Y1).

∗1

Open phase?

<When voltage monitoring is possible:>

∗1. Measure voltage at the X1M power supply terminal block.

Give the user a copy of "notification of inspection results"and leave it up to him to improve the imbalance.

Be sure to explain to the user that there is a "power supply imbalance" for which DAIKIN is not responsible.

measure

YES

NO

∗In accordance with "notification of inspection results" accompanying spare parts.

Page 69: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �/'

�#�� CP4D�1��! ��*���2�.�/$��"�� �� $���L��������!�����)�,��� �������������'�����' �

��� ���& ��� /�B�'�/�%

P4

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�� � ����������������������*��"� ����� ����������5*����*����"&�� ���� ������&������-�

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*���� � ���������������*��"� ��������"� ����������B�������������&������ *�������������� ���� �� ����������� �������������5*�����*��������&��������� �����������S�(S�5��������� &���������&�� ��-��*���� &��������������

���� '�!�&��'�'

� >���������������������"&�������� �� ��� >������������������������ ������������������"&�� ��� ����������"����

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Replace the inverter PC board.

NO

YES

NO

NO

YES

NO

Measure resistance value of the radiation fin thermistor.

Isthe thermistor

resistance value normal?

Replace the fan motor.

Replace the inverter PC board.

Continue operation.

Replace the compressor (M1C).

YESThe fan

motor's insulation resistance is not more

than 1MΩ.

Does the malfunction recur when the power supply turns

ON?

YESThe INV compressor's insulation resistance is not more

than 100kΩ.

* Disconnect the connector (X111A) from the fin thermistor, and then check the thermistor.

*

Page 70: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�/( ������� *�����-

�#�� CPJD�1��! ��*���2�,��/�%�,��/!�������)��$�������/�"��)�.�����&�� ��!� ��,��/�%�& �5����� �� $��&�� ��!

��� ���& ��� /�B�'�/�%

PJ

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�*� �"����������� ������������������-������""��������� �5��*��*�����������

.�/$��"�� ��B�"�'� ��& �!��� �'

�8��H��-"������������-������""������������������5*��*�����������*����&�����*�������������������� ���������

���� '�!�&��'�'

� �������:�����;������ �����-��������&�����-�"������������ � "���*��-�����&�����������

Page 71: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �/)

� �5/�'6 ���)

Z���3� �����"&�� �������������������

Z���3� �����������������������

���� �&&�������� ����

�,),<?����./�F��2�4��.�,�

���� �&&�������� ���� �,)��?� ���./�O��,�O�����,)��?'�,)��?( ���.�(�

�,)��?��,)��?�� ���.�2�

YES

Replace outdoor unit PC board.

YES

YES

YES

YES

NO

NO

NO

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Make correct setting of DIP switch.(For setting procedure, refer to information on page 184~.)

Replace it with the correct compressor inverter PC board.

Was the PC board (A1P) replaced with a

substitute PC board?

Isthe type of the

compressor inverter PC board correct? (*1)

NO Replace it with the correct fan inverter PC board.

Isthe type of the

fan inverter PC board correct? (*2)

NO Rectify the connection wiring.

Does the Preparation indication

lamp on the main PC borad turn OFF?

Isthe model

setting of the substitute PC board correct?

Page 72: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�/2 ������� *�����-

�#�� CU0D�1��! ��*���2�H�'��6 ���)��-/������ ���& ��� /�B�'�/�%

U0

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>������-� � *����-���� �������*����"&��������������������5������5�&�� ������� �������&�&������*�������*��-���

.�/$��"�� ��B�"�'� ��& �!��� �'

]���������-�"���^3�5�&�� ��������"� �,�� ����������5�]���*�����-�"���^�*����-������ �&��*������ �������-� �����"� ��,���-��� �����������9V�� ��Q��� �E���������&�&����"&���������������������*��"� ����� E�������������"&������������� &�����-������5�&�� ���� ����������� ����������"�������*��������������� ��&��������

���� '�!�&��'�'

� 6� � *����-���������-���������--��-�:&�&��-������;� >���������*��"� ����:�(�1��/�;� >����������5�&�� ���� �� ��� >�����������������������������:���;�

Page 73: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �/+

� �5/�'6 ���)

Check if the temperature difference between the

suction pipe and the heat exchanger is 20 °C and over.

Check if the property of suction pipe

thermister (A7T) and heat exchanger thermister (R4T) are normal.

(*3)

Check if the low pressure is

0.1MPa or below. (∗1)

Check if the property of low

pressure sensor is normal.(∗2)

Replace the low pressure sensor.

Replace the main PC board (A1P).

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

NONO

YES YES

Remove the factor of decreasing low pressure by referring to Check 6 .

Remove the factor of superheating by referring to Check 3 .

Replace the thermister.

Replace the main PC board.

NONO

YES

∗3: Compare the thermister resistance value with the value on the surface thermometer.

∗1: Check the low pressure value by using pressure gauge in operation.∗2: Compare the actual measurement value by pressure sensor with the

value by the pressure gauge. (To gain actual measurement value by pressure sensor, measure the voltage at the connector [between (2)-(3)] and then convert the value into pressure referring to P419.)

In heating mode

In cooling mode

Check 6

Check 3

∗1

∗2

∗1

∗2

1 Set up a pressure gauge at the service port on the low pressure side.

2 Reset the operation using the remote control then restart.

Reset the operation using the remote control then restart.

: Referring to the information on P351.

: Referring to the information on P348.

Page 74: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�// ������� *�����-

�#�� CU1D���L��'���6�'�D�1�����6�'���� ���& ��� /�B�'�/�%

U1

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

�*��&*� �������*�&*� ����������������������� ��&*� ��������������������������-*��&*� ���������� ��&*� ������H��-���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����� �-��������&*� ������������ �"�������5����&*� � �

���� '�!�&��'�'

� ��5��� �&&�������� ��&*� �� ��5��� �&&����&���&*� �� >�����������������������:���;

� �5/�'6 ���)

(V2820)

Operation is normal if one

place of power supply line phase is replaced.

Fix the open phase. Requires inspection of field power supply section.

Reverse phaseCounter measure of the problem is completed by phase replacement.

Replace outdoor unit PC board (A1P).

YES

YES

NO

NO

There is an open phase at

the power supply terminal section (X1M) of the

outdoor unit.

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 75: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �/<

�#�; CU2D�1��! ��*���2�� 8�������/%���'�$$�"����� ����'������� �'�,��/���

��� ���& ��� /�B�'�/�%

U2

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;1�4��.�,��:���������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>����������������-����"��������������&�����������������*���������������&�5��� �&&��������-��

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*�������-������"���������� ������� ��*���+/,=��������"�����*���'�,=1����5*����*���������?��"����-������-����� ���������*��,,=����"������������� �+(,=�

���� '�!�&��'�'

� ��5��� �&&����� �������� �� ��������� �&�5���������� $&���&*� �� >������������������������ >������������������������������� ������������5����-������� ���������"&�� ��� ����������"����� �������������������� �-���������

Page 76: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�<, ������� *�����-

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Rectify the defect.

Replace the compressor.

Replace the fan motor.� If the motor significantly gets

damaged, the inverter PC board will need to be replaced.

Replace the inverter PC board.

Replace the inverter PC board.� If the inverter PC board

significantly gets damaged, the compressor or the fan motor may have caused a failure.

YES

YES

YES

NO

YES

NO

NO

The insulation resistance of the

compressor is not more than 100kΩ.

NO

Theinsulation

resistance of the fan motor is not more than

1MΩ.

YES

NO

The inverter PC board gets damaged.

Check for power supply conditions.1 Is the power supply voltage

200VAC±10%?2 Does the power supply have any

open phase or erroneous wiring?3 Does the power supply imbalance

fall within 6V?

Connect and disconnect the following connectors.1 X4A (A2P) ⇔ X20A (A1P)2 X6A (A2P) ⇔ X28A (A1P)

To the following page

Check 4 ∗1Is the power transistor

normal?

A

There is a defect in the power

supply aforementioned.

∗1 Check 4 : Referring to the information on P334.

Page 77: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �<�

� �5/�'6 ���)

A

The system enters standby mode

before the outdoor unit fan starts rotating.

The system enters standby mode

before the compressor completes startup

sequence.

The malfunction "U2" recurs.

Replace the inverter PC board.(Faulty noise filter)

Replace the inverter PC board.� If the inverter PC board

significantly gets damaged, check for the compressor.

Check for all wirings.

Continue operation.External factors such as instantaneous power failure are supposed.

Yes

Yes

Yes

NO

NO

NO

Turn ON the power supply, and then press the ON button.

From the preceding page

Page 78: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�<� ������� *�����-

�#�@ CU3D�1��! ��*���2�&6�"I�1������ ��� ���3�"���!��� ���& ��� /�B�'�/�%

U3

-��/�"�5/��. !�/'

���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8��&��������� ����������������

.�/$��"�� ��B�"�'� ��& �!��� �'

����������� ���������5*����*������� ���� ��&��������5��*�����*��8��&��������

���� '�!�&��'�'

� *��8��&��������� ��������������

� �5/�'6 ���)

(V3052)

Performs the check operation again and completes the check operation.

Has the check operation

performed on Outdoor unit PC board?

Press and hold BS4 on the outdoor master PC board for 5 seconds or more, or turn ON the local setting mode 2-3 to conduct a check operation.

NO

YES

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 79: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �<'

�#� CU4D�.�/$��"�� �� $� ���'��''� ��5��8������! ��*���'��� ���& ��� /�B�'�/�%

U4

-��/�"�5/��. !�/'

����"���������������������./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8����*������ "� �������5���������������������������������� ��������������������� ��-�"������"&�����

.�/$��"�� ��B�"�'� ��& �!��� �'

7*������� "� ����� ��������������������"�������������������"���������"�

���� '�!�&��'�'

� �����������������1������������������������ "� ����5����-���1������ ����������1� *���������������5���-�5����-

� $������������&�5��� �&&���� �$��� �� ��"������ ���� �G��"���*� >��������������������������� >���������������������������

Page 80: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�<( ������� *�����-

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

YES

NO

NO

YES

NO

YES

YESYES

YES

YES

NO

NO

NO

NO

YES

NO

NO

NO

YES

YES

Reset the power supply here.

Check if indoor unit PC board

or outdoor unit PC board has been replaced. Or check if indoor/

outdoor, outdoor/ outdoor connecting wires are

normal.

Check if all the indoor

remote controls within the same refrigerant circuit

display “U4”.

Check if the indoor/ outdoor, outdoor/

outdoor connecting wires are normal.

Check if the voltage between RS

terminals on the outdoor unit PC board is 200V.

The fuse on the outdoor unit PC

board is blown.

Check if the normal condition

monitor for the microcomputer (HAP) on the outdoor unit

PC board blinks.

Check if the LED in preparation

mode (H2P) on the outdoor unit PC board

blink.

Lights do not go out for 12 minutes

or more.

Check if the indoor/ outdoor,

outdoor/ outdoor connecting wires are normal.

Check if the operation is normal

with 1 circuit after outdoor/outdoor connecting wires are

removed.

Press the rewiring button on the main PC board of the master outdoor unit. Keep pressing for 5 seconds or more. (Operation does not start for a maximum 12 minutes.)

Replace indoor unit PC board.

Correct the connecting wires.

Correct the voltage (200V).

Replace the fuse.

Replace the outdoor unit PC board.

Press the rewiring button on the main PC board of the outdoor unit. Keep pressing for 5 seconds or more.

Correct the connecting wires.

Replace the main PC board of outdoor unit.

Fix DIII Net extension adaptor.

Page 81: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �<)

�#�N CU5D���! ��*���2�.�/$��"�� �� $� ���'��''� ��5��8������� ���& ��� /���!���! ��*���

��� ���& ��� /�B�'�/�%

U5

-��/�"�5/��. !�/'

����"���� ��������������

.��6 !� $�

.�/$��"�� ��B���"�� �

����� ��������������-�5��*��?��"�����������1��*��8��*�� � ��"�� ��-�"������"&������ � �-�������� "� �������5����������������������"������������:"�������� ��;�� ����"���

.�/$��"�� ��B�"�'� ��& �!��� �'

!��"������� "� ������� ����������������� &�������&������

���� '�!�&��'�'

� ��������������������������"���������������� "� ����� �������������5��"������"����������� �:5*���� ��-�����"����������� ;� >��������������������������� >���������"�������������������� ���������������� "� ������� ��������� �

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

(V2823)

NO

NO

NO

YES

NO

Replace indoor unit PC board.

Set one remote control to "SUB"; turn the power supply off once and then back on.

There is possibility of malfunction caused by noise. Check the surrounding area and turn on again.

There is possibility of malfunction caused by noise. Check the surrounding area and turn on again.

Normal

Normal

NO NO

Using 2 remote controls control.

Allindoor PC

board microcomputer monitors blink.

Operation returns to normal

when the power is turned off momentarily.

YES YES

YES

SS1 of both remote controlsis set to "MAIN."

Replace the remote control

Normal

YES

Replace the indoor unit PC board.

Normal

YES

Page 82: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�<2 ������� *�����-

�#�� CU7D�1��! ��*���2� ���'��''� ��,��/����=-"� ''�1��! ��*���'>

��� ���& ��� /�B�'�/�%

U7

-��/�"�5/��. !�/'

����"���� ��������������� �����������������

.��6 !� $�

.�/$��"�� ��B���"�� �

������"&������*��8 ������� "� �������5���������������� �

.�/$��"�� ��B�"�'� ��& �!��� �'

7*������� "� ����� ��������������������"�������������������"���������"�

���� '�!�&��'�'

� ����������������������������-�5��� ����5������������������������������������� ���������������&���

� ����������������������������-�5��� ����� ������������� � ������-���������� 5���*��-�������-#�*�����-� ����-����������� � �����-����������������-#�*�����-�:������������1����������������� ���������������&���;

� >�����������������������������:��������'�;� >������������������������ ���������������&���

Page 83: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �<+

� �5/�'6 ���)

Go on to the Diagnosis Flow 1(Faulty transmission caused when the external control adaptor for outdoor unit is mounted)

Go on to the Diagnosis Flow 2(Transmission alarm given when the external control adaptor for outdoor unit is mounted)

Go on to the Diagnosis Flow 3(Abnormal transmission between the master unit and the slave unit 1)

Go on to the Diagnosis Flow 4(Abnormal transmission between the master unit and the slave unit 2)

Go on to the Diagnosis Flow 5(Multi-connection REYQ units)

Go on to the Diagnosis Flow 6(Erroneous manual address settings of the slave units 1 and 2)

Go on to the Diagnosis Flow 7(Connection of four or more outdoor units to the same circuit)

Go on to the Diagnosis Flow 8(Faulty auto address of the slave units 1 and 2)

Check the LED lamps for “Check 3” corresponding to the malfunction code “U7” and for Check 4 in the monitor mode. (Refer to Page 211~214 for how to check)

Check 3

Check 3

Check 3

Check 3

Check 3

Check 3

Check 3

Check 3

Check 4

Check 4

Check 4

Check 4

Check 4

Check 4

Check 4

Check 4

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Go on to the Diagnosis Flow 9(Disconnection of Function Unit)

Check 3 Check 4

YES

Was the PC board

(A1P) replaced with a substitute PC

board?

Make correct model setting.NO

NO

YES

Is the model setting of the substitut

PC board correct?

Go on to the Diagnosis Flow 10(Over connection of Function Unit)

Check 3 Check 4

Go on to the Diagnosis Flow 11(Malfunction in installation of RTSYQ20P)

Check 3 Check 4

Page 84: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

�</ ������� *�����-

� �5/�'6 ���)

NO

NO

YES

YES

NO

YES

YES

Connect the power supply wire for the outside control adapter to 5V supply line.

Replace the outdoor unit main PC board. (A1P)

Check if the power supply

wire for the outside control adapter is connected

to 5V supply line.

Replace the PC board of the outside control adapter.

Replace the outdoor unit main PC board. (A1P)

NO

YES

NO

Correct the connecting wiring with the outside control adapter.

Diagnosis Flow 1

Supply power to the outdoor unit.

Check if power is supplied to the

outdoor units.

Check if the normal condition

monitor LED for the outdoor unit PC board

blinks.

Check if the normal condition

monitor LED for the outside control adapter

blinks.

Check 3 Check 4

Check if any disconnection or

connection error is detected in connecting wires with

outside control adapter.

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 85: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- �<<

� �5/�'6 ���)

NO

NO

YES

YES

NO

NO

YES

Connect the power supply wire for the external control adapter for outdoor unit to 5V supply line.

Replace the main PC board of the outdoor unit. (A1P)

YES

Replace the main PC board of the outdoor unit. (A1P)

NO

NO

YES

Set the cooling/heating switch of the external control adapter for outdoor unit to “individual”.

Switchcooling/heating in a

lump.

Setting of cooling/heating switch for

the external control adapter for outdoor unit is “Master

in a lump”.

Setting of cooling/heating switch for

the external control adapter for outdoor unit is “Slave in

a lump”.

Check if the normal condition

monitor LED for the outdoor unit main PC board

blinks.

Check if the outdoor unit is powered

on.

Check if the power supply wire for the

external control adapter for outdoor unit is connected to 5V

supply line.

Check if the normal condition

monitor LED for the external control adapter for outdoor

unit blinks.

Setthe cooling/heating

switch of the external control adapter for outdoor unit to “individual”.

Then check if the failure occurs again.

YES

NO

The integrated addresses for cooling/heating within the outdoor/outdoor transmission are duplicated. Set the address again.

NO

YES

Replace the main PC board of the outdoor unit. (A1P)

Diagnosis Flow 2

YES

Replace the PC board of the external control adapter for outdoor unit.

Supply power to the outdoor unit.

Check 3 Check 4

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 86: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

',, ������� *�����-

� �5/�'6 ���)

NO

YES

NO

YES Correct the connecting wires of the outdoor multi and then reset the power supply.

Replace the main PC board (A1P) of the outdoor unit.

Remove the connecting wires of the outdoor multi and then reset the power supply.

NO

YES

Check 3

Check 3 Check 4

Check 4

Diagnosis Flow 3

Diagnosis Flow 4

Diagnosis Flow 5

Check the connection status of

connecting wires of Multi Slave 2 with outdoor multi. Check if the wiring is

disconnected or is about to be disconnected.

Check if the outdoor unit

REYQ8~16PY1 is connected to multi-system.

Check 3

Check the connection status of

connecting wires of Multi Slave 1 with outdoor multi.Check if the wiring is

disconnected or is about to be disconnected.

Replace the outdoor unit main PC board (A1P) of the Multi Slave 1.

Correct the connecting wires of the outdoor multi and then reset the power supply.

Replace the outdoor unit main PC board (A1P) of the Multi Slave 2.

Check 4

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 87: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ',�

� �5/�'6 ���)

NO

YES

NO

YES

NO

YES

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Diagnosis Flow 6

Replace the main PC board of the outdoor unit. (A1P)

Correct the connecting wires of the outdoor multi and then reset the power supply.

Replace the main PC board of the outdoor unit. (A1P)

Correct the connecting wires of the outdoor multi and then reset the power supply.

Replace the main PC board of the outdoor unit. (A1P)

Correct the connecting wires of the outdoor multi and then reset the power supply.

Diagnosis Flow 7

Diagnosis Flow 8

Check the connection status of one of

the connecting wires of Outdoor Multi. Check if the wiring is broken or

disconnected.

YES

NOCorrect the manual address settings.(For detail, refer to information in the "AirNet Installation Manual".)

Aremanual address

settings (of the slave units 1 and 2) correct in order to connect the

AirNet?

Inthe connection

status of the outdoor multi, check if more than 4 outdoor

units are connected.

Check the connection status of the

connecting wires of outdoor multi. Check if the wiring has any connection error

or broken, or is about to be disconnected.

Check 3

Check 3

Check 3 Check 4

Check 4

Check 4

Page 88: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

',� ������� *�����-

� �5/�'6 ���)

NO

YES

YES

NO

YES

NO

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Diagnosis Flow 9

Replace the main PC board of the outdoor unit.

Replace the main PC board of the outdoor unit.

Check for the connection.Only one function unit can be connected.

Replace the main PC board of the outdoor unit.

Replace the main PC board of the outdoor unit.

Diagnosis Flow 10

Diagnosis Flow 11

YES

NOConnect the function unit.Is a function unit connected?

Two or more function units are connected.

Model name is RTSYQ20P.

Connect them correctly.RTSQ8P and

RTSQ12P are multi connected.

Check 3

Check 3

Check 3 Check 4

Check 4

Check 4

Page 89: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ','

�#�� CU8D���! ��*���2�.�/$��"�� �� $� ���'��''� ��5��8����.������!���5���� ���& ��� /'

��� ���& ��� /�B�'�/�%

U8

-��/�"�5/��. !�/'

����"���� ��������������

.��6 !� $�

.�/$��"�� ��B���"�� �

����� ��������������-�5��*��?��"�����������1��*��8��*�� � ��"�� ��-�"������"&������� �-�������� "� �������5����������������������"������������:"�������� ��;�� ����"���

.�/$��"�� ��B�"�'� ��& �!��� �'

!��"������� "� ������� ����������������� &�������&������

���� '�!�&��'�'

� ���������������� "� �������5����"�������� �����"������������ �������������5���� �����"����������� � >���������"�������������������

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

(V2825)

SS1 of both remote controls is set to

"SUB."

Set SS1 to "MAIN"; the power supply off once and then back on.

Set one remote control to "MAIN"; the power supply off once and then back on.

Turn the power off and then back on. If a malfunction occurs, replace the remote control PC board.

YES

YESYES

NO

NO

NOUsing2-remote controls control.

SS1 of remote control PC boards is set to

"MAIN."

Page 90: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

',( ������� *�����-

�#�� CU9D���! ��*���2�.�/$��"�� �� $� ���'��''� ��5��8������! ����!�1��! ��*���'�����6��������%'���

��� ���& ��� /�B�'�/�%

U9

-��/�"�5/��. !�/'

����"���� �������������� ���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>������"���������� �-��������*����*�������������� �5��*����*����������������������������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*��"�������������� ����� �"�������������*���������������5��*����*�� � ��"�����������

���� '�!�&��'�'

� ���������������� "� ����5��*��������� ��������*��� � ��"� �������������������������&�� �����������������������������*��� � ��"� >����������������������������������*��� � ��"� �"&��&�������������������� "� ����5����-����5���������������������������

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

The outdoor unit PC board indicated by the malfunction code U9 is normal.Check for the indoor unit of other system, and then conduct troubleshooting by diagnosis according to the Malfunction Code Flowchart.

Re-diagnose by display after passage of 2 minutes or more.

Continue operation.

NO“U9” has been displayed for 2 minutes or

more.

NOAll

the units are indicating “U9”.

Turn on all indoor units.

YES

YES

Page 91: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ',)

�#�� CUAD����� ����& �5����� �� $���! ����!�1��! ��*���'D���! ��*���'���!���� ���& ��� /

��� ���& ��� /�B�'�/�%

UA

-��/�"�5/��. !�/'

����"���� �����������������./�F�2��:$�������%���;�����������������

.��6 !� $�

.�/$��"�� ��B���"�� �

7*����*��"����������� ������������5�����*������������� 1������������� ����������������� �7*����*����"������������������� ��������*��&��"� ��������-��

.�/$��"�� ��B�"�'� ��& �!��� �'

�*��"�������������� ����� �"����� � ����� ����*������*�������"������ �����"���������� ����������

���� '�!�&��'�'

� ���� ������������������������ � >����������������������������:���;� � "���*��-����*������-��������&����������������������������� ������-�������������������5� ����������������������&�����-���� &����&��� ���������

Page 92: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

',2 ������� *�����-

� �5/�'6 ���)

To Diagnosis Flow 1(Excessive number of indoor units connected)

Check the LED lamps for “Check 3” corresponding to the malfunction code “UA” and for Check 4 in the monitor mode. (Refer to Page 211~214 for how to check.)

Check 3 Check 4

To Diagnosis Flow 2(Connection of erroneous models of indoor units)

Check 3 Check 4

To Diagnosis Flow 3(Faulty combination of outdoor units)

Check 3 Check 4

Check 3 Check 4

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

To Diagnosis Flow 4(Faulty wiring in units dedicated to multi connections)

Page 93: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ',+

� �5/�'6 ���)

NO

YESReplace the main PC board of the outdoor unit.

NO

YES

The number of indoor units exceeds the standard. Check the connection to correct.

Replace the main PC board of the outdoor unit.• With single systems, replace the

control PC board 1 (A1P).• With multi systems, replace the

main PC board (A1P).

Match the refrigerant types of the outdoor unit and the indoor unit.

Check 3 Check 4Diagnosis Flow 1

Check 3 Check 4Diagnosis Flow 2

The number of indoor units connected to

the same refrigerant circurt system should not be more than

64 units.

Check if the refrigerant type of the

outdoor unit corresponds to that of the indoor unit.

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Page 94: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

',/ ������� *�����-

� �5/�'6 ���)

NO

YES

YES

YES

NO

NO

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Diagnosis Flow 3

Replace the main PC board of the outdoor unit.

Check the model of the outdoor unit.

Correct the setting to reset the power.

Replace the spare parts PC board.

Check if the unit is not

connected to outdoor units of different

models.

Check if the outdoor unit PC

board is replaced with PC board for spare

parts.

Check if the spare parts PC

board setting is correct.

Check 3 Check 4

NO

YES

Isa correct

substitute PC board procured?

Replace it with the correct substitute PC board.

NO

YES

Diagnosis Flow 4

Connect the indoor units correctly.

Replace the outdoor unit PC board.

Is the model BP connected?

Check 3 Check 4

Page 95: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- ',<

�#�� CUCD�-!!��''�B��/�"��� �� $�&�����/�:�!�& ��� //����� ���& ��� /�B�'�/�%

UC

-��/�"�5/��. !�/'

����"���� ��������������

.��6 !� $�

.�/$��"�� ��B���"�� �

�*��&�����&��������������������� ��*�� �"������� �� ��*������� ��5�����������*���������������

.�/$��"�� ��B�"�'� ��& �!��� �'

�*��"�������������� ����� �"����� � ����� ��*�������"����������"���������� ����������

���� '�!�&��'�'

� ����� ���&�������������������@�������������

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Make setting change so that the centralized address will not be duplicated.

The centralized address is duplicated.

Page 96: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

'�, ������� *�����-

�#�� CUED�.�/$��"�� �� $� ���'��''� ��5��8����&�����/�:�!�& ��� //�����!���! ��*���

��� ���& ��� /�B�'�/�%

UE

-��/�"�5/��. !�/'

����"���� �������������� �����������������-��������*�����������������@���������������*��������"��

.��6 !� $�

.�/$��"�� ��B���"�� �

������"&������*��8 ������� "� �������5����������������������������@��������������� ����"���

.�/$��"�� ��B�"�'� ��& �!��� �'

7*������� "� ����� ��������������������"�������������������"���������"�

���� '�!�&��'�'

� ���������������� "� �������5�����&����������������� ������������@��������������������������

� ������������ �����-�"� ���������������� ��� ����������:����� ������������������������������&�������#���"������� ���*��-������ 5���*�;

� �������������������������������"������������ >��������������������������

Page 97: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- '��

� �5/�'6 ���)

(V2822)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

For VRV systems, can the

setting of central controlgroup No. be made in one and

the same refrigerant system?

Wasthe central

control group No. for indoor unit

changed?

Make correct setting of the central control group No.

Check outdoor units to which the refrigerant system is connected.

Check whether or not there are no problems with the transmission wiring length, types of cables and wires, number of units connected, and others. If no problems, replace the indoor unit PC board.

NO

YES

Continued to A(on the following page)

YES

Checkthe indoor

unit for which “ ” is displayed.

Is the the transmission malfunction (UE)

caused on all indoor

units?

Is the power supply of

the indoor unit, on which the “ ” occurred,

turned ON?

Hasthe setting of

central control group No.been made with the indoor unit on which

the “ ”occurred?

NO

NO

YESCan

the setting of central control group

No be made?

Make sure there are no hazardous situations, and then turn ON the power supply.

NO

NO

YES

YES

NO

YES

Reset the power supplies of every central equipment.For the intelligent Touch controller, register the air conditioner again while in DIII-NET test run menu.

Page 98: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

'�� ������� *�����-

� �5/�'6 ���)

Is the voltage between

the terminals F1 (+) and F2 (-) in the range of

15.2 to 17.6 VDC?

Replace the central equipment.

Central equipment: Normal

Normal

Normal

Correct the wiring.Abnormal

Check the transmission

wiring between central equipment for any broken wire. For details, refer to information in the “Procedure

for checking broken wires” section.

(Refer P.337)

A

Has the master unit central

setting connector been connected?

NO

Correct the wiring.Abnormal

Correct the connection of the connector.

NO

YES

YES

Check the transmission

wiring with the master unit central equipment for

any broken wire. For details, refer to information in the

“Procedure for checking broken wires”

section.(Refer P.337)

Disconnect the transmission wiring of the master unit central equipment, and then check the voltage between the transmission terminals (F1 and F2) of the master unit transmission equipment using a multiple meter.

It is supposed that the malfunction results from external factors (e.g. noises) from other equipment.

Page 99: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- '�'

�#�; CUFD��%'�����'�� ������%����� ���& ��� /�B�'�/�%

UF

-��/�"�5/��. !�/'

����"���� �������������� ���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

$���*��8��&�������1��*����"����������������� �������" ������� "� ����� ���������� &�����-�����*���������������� ��*���*����"�����*��-� ������"&��������

.�/$��"�� ��B�"�'� ��& �!��� �'

�*��"����������� ������"������ � ����� ��*�������"����������"���������� �����������*���-*��*��8��-��*�� � ��"���������������� ������������������ �����*���*��8��&��������

���� '�!�&��'�'

� �"&��&�������������������� "� ����5����-����5����������?������������ ������������?������������

� ��������������������*��8��&�������� >��������������������������� ���&�������� ����������� ��

� �5/�'6 ���)

� ��2 7����-��*��8��&��������"���������� ���� �����������������������*���������������*� �����������"�����*������*��� 1���������� ����������������������������-�������������������������� �����*�����"������������� �����*�����

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

(V2830)

Isindoor - outdoor

and outdoor - outdoor unit transmission wiring

normal?

Replace indoor unit PC board.

Wiring check operation may not have been carried out successfully.

After fixing incorrect wiring, push and hold the RESET button on the master outdoor unit PC board for 5 seconds.∗ The unit will not run for up to

12 minutes.YES

NOYES

NO

NO

YESIs the check operation

carried out?

Isindoor -outdoor

and outdoor-outdoor unit transmission wiring

normal?

Open stop valve.

YES

NOAre the stop valves openned?

Page 100: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� / ����������

'�( ������� *�����-

�#�@ CUHD�.�/$��"�� �� $��%'���D���$��)�������%'����-!!��''�*�!�$���!

��� ���& ��� /�B�'�/�%

UH

-��/�"�5/��. !�/'

����"���� �������������� ���./�F�2��:$�������%���;

.��6 !� $�

.�/$��"�� ��B���"�� �

>���������������������5��*��������� � �����-�

.�/$��"�� ��B�"�'� ��& �!��� �'

�*��"�������������� ����� �"����� � ����� ��*�������"����������"���������� ����������

���� '�!�&��'�'

� �"&��&�������������������� "� ����5����-����5����������?������������ ������������?������������

� >��������������������������� >��������������������"������������:��������'�;

Page 101: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�5%���!�"��� �� ���6����� ���& ��� /

������� *�����- '�)

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

(V2831)

NO

YES

YES

After fixing incorrect wiring, push and hold the RESET button on the master outdoor unit PC board for 5 seconds.

Normal

NO

Iselectricity

being introduce for the first time after

installation or after an indoor or outdoor unit PC

board has been replaced?

Isindoor - outdoor and

outdoor - outdoor unit transmission wiring

normal?

YES

NO

NormalNO

Does a malfunction occur?

Mount the DIII NET extension adapter.

YES

Disconnectthe outdoor-outdoor

unit transmission wiring to create the

one-system status, and then check whether or

not the system is normal.

NODoes

a “UH” malfunction occur for all indoor units in

the system?

YES NO

Doesa malfunction

occur even after 12 minutes elapses from the

time when electricity is introduced to indoor

and outdoor units?

YES

Replace indoor unit PC board.

Replace outdoor unit PC board (A1P or A3P).

Push and hold the RESET button on the outdoor unit PC board for 5 seconds

∗ The unit will not run for up to 12 minutes.

∗1: Check the correct wiring “indoor-outdoor” and “outdoor-outdoor” by Installation Instruction.∗2: What is Auto Address?

This is the address automatically assigned to indoor units and outdoor units after initial power supply upon installation, or after executing rewiring (Keep pressing the rewiring button for more than 4 seconds).

Page 102: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=1�2�&�����/���� ���& ��� /> ����������

'�2 ������� *�����-

�# � �5/�'6 ���)�=1�2�&�����/���� ���& ��� />�#� CM1D��&�� ��!�B�$�"���� ���& ��� /�B�'�/�%

M1

-��/�"�5/��. !�/'

���������"����������� �������-��������*������������*��������"��

.��6 !� $�

.�/$��"�� ��B���"�� �

>��������������"����������*��>���?!���&����������������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*���P�&������������?�&�������������������������*�� �"����"��

���� '�!�&��'�'

� >�����������������"�������������������� >��������������-��������*������������������� >���������*��������"����������

� �5/�'6 ���) ��&������*������������"�������������

Be sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.Caution

Is the M1 displayed again? Replace the central equipment.

Central equipment: Normal

It is supposed that the malfunction results from external factors (e.g. noises) from other equipment.

Turn ON the power supply of the central equipment with M1

displayed once again.

With M1 displayed

Without M1 displayed

Page 103: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=1�2�&�����/���� ���& ��� />

������� *�����- '�+

�#� CM8D�.�/$��"�� �� $� ���'��''� ��5��8����1��� ��/�& ��� //��'�$ ��&�����/�:�!�& ��� /

��� ���& ��� /�B�'�/�%

M8

-��/�"�5/��. !�/'

���������"����������������������������-��������*������������*��������"��

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*��"������������������-����>���?!������� "� ����������:�*�� � ��"�5�����������"����������� ���;

.�/$��"�� ��B�"�'� ��& �!��� �'

7*������"� ���������������� �&�� ��������*����"�����*�� �����&��� ����������������7*����*����������@�������������1�5*��*�5� ���������������1� *�5 ������ &�� ��

���� '�!�&��'�'

� ���������������� "� �������5�����&����������������� ������������@����������� >������������������&����������������� ������������@����������

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

YES

Turn ON the power supply of the central equipment.

Replace intelligent Touch controller.

Set the Reset switch (located inside of equipment) SS1 been set to the Normal side.

Replace the central equipment.

Correct the wiring.

Some central equipment gets faulty. Conduct RUN/STOP operations on every central equipment, and then replace the central equipment that cannot control the indoor unit.

NOHave power supplies to every central

equipment been turned ON?

Is the display of LCD OK?NO YESNothing is

displayed on the LCD by operating intelligent Touch controller.

(∗1)

NOHas the Reset

switch (located inside of equipment) SS1 been set

to the Normal side?

Reset the power supplies of every central equipment.

YES

Abnormal

Were any changes

made to the number of units of central

equipment? (The central equipment was connected once,

and then disconnected, or additional central equipment was

installed.)

NO

YES

Normal

NO

YES

Check 7Check if the unit indicating

“A8” has no broken of wiring.

∗1: Display screen control using Ve-Up controller:When the screen displays nothing by touching the screen, adjust the contrast volume.Check 7 : Referring to the information on P337.∗2

∗2

Page 104: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=1�2�&�����/���� ���& ��� /> ����������

'�/ ������� *�����-

�#� CMAD����� ����& �5����� �� $�1��� ��/�& ��� //��'�$ ��&�����/�:�!�& ��� /

��� ���& ��� /�B�'�/�%

MA

-��/�"�5/��. !�/'

���������"����������������������������-��������*�������������*��������"��

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*��"������������������-����>���?!������� "� ���������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*�� �*��������"���� � ������������������ ��"���1���*�������������"&������� �&�� ����7*���"����&���"� �������������������&�� ����7*����*����"���������������&����� �&�� ����

���� '�!�&��'�'

� �"&��&�����"������������&����������������� ������������@����������� �����*�������"� ���������������� ����������� >������������������&�����������������������������@����������

Page 105: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=1�2�&�����/���� ���& ��� />

������� *�����- '�<

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

NO

NO

Not available for combined use with the remote control adapter. Dismount the remote control adapter, and then reset power supplies of every central equipment.

Not available for combined use of the schedule timer and the Interface for BACnet®.Dismount either of them, and then reset power supplies of every central equipment.

Not available for combined use of the schedule timer and the DMS-IF. Dismount either of them, and then reset power supplies of every central equipment.

Not available for combined use of the schedule timer and the parallel interface. Dismount either of them, and then reset power supplies of every central equipment.

Dismount the Independent/ Combined use connector(CN1/X1A) of the schedule timer, and then reset power supplies of every central equipment.

Integrate every central equipment to which the master unit central connector is connected, and then reset power supplies of every central equipment.

Disconnect the master unit central setting connector and connect this connector to different central equipment, and then reset power supplies of every central equipment. Central equipment, to which the master unit central setting connector is connected at the time when the malfunction code is cleared, is faulty. Replace this equipment.

YES

YES

YES

NO

YES

Has the remote control adapter (KRP2A series) been

connected?

Has the schedule timer been

connected?

Are there two or more units

of central equipment with master unit setting

connectors (CN1/X1A) connected?

Reset the power supplies of every

central equipment.

Has the Interface for BACnet®

been connected?

NONO

YESHas the DMF-IF been connected?

NO

YESHas the parallel interface been

connected?

NO

YES

Has the Independent/

Combined use connector (CN1/X1A) of the schedule

timer been connected?

Central equipment: Normal

The List of Setting of Master Unit Central Setting Connector

Check 8

The MA malfunction code is displayed again.

It is supposed that the malfunction results from external factors (e.g. noises) from other equipment.

Check 8 : Referring to the information on P338.∗1

∗1

The "MA" error code has been cleared.

Page 106: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=1�2�&�����/���� ���& ��� /> ����������

'�, ������� *�����-

�#� CMCD�-!!��''�B��/�"��� �D����� ����������)��� ���& ��� /�B�'�/�%

MC

-��/�"�5/��. !�/'

���������"����������������������������-��������*������������*��������"��

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*��"������������������-����>���?!������� "� ���������

.�/$��"�� ��B�"�'� ��& �!��� �'

� �5�����"�������� �������������"����������� ������������-��������*���������� ��������������1������������*�"����� ������"� ����������������� �����-���� ������������������ �����-�

� �5������ ��� �*��������"�� ���������������

���� '�!�&��'�'

� ����� ���&�������������������@�������������

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

NO

Correct the setting of the combination of master and slave units, and then reset the power supplies of every central equipment.

Reset the power supplies of every central equipment.

Replace the central equipment.

Central equipment: Normal

It is supposed that the malfunction results from external factors (e.g. noises) from other equipment.

NO

YES YES

NO

With "MC"displayed

Without "MC"displayed

YES YES

If the intelligent Touch controller is used, correct the setting of the combination of master and slave units again

while in DIII-NET test run mode, referring to the

Master/Slave setting table.(Refer P183.)

NO

Turn ON the power supply of the central equipment with "MC" displayed once again.

Reset the power supplies of every central equipment.

Check 9 : Referring to the information on P354.∗1

∗1

Did the malfunction occur while

in the first test run using the intelligent Touch

controller?

Is the Master/Slave setting of the central equipment correct?

Is the Master/Slave setting

of the central equipment correct?

Was the central equipment

connected once, and then disconnected, or was additional

central equipment installed?

Is the "MC" displayed again?

Be sure to refer to the

Master/Slave settingtable.

Check 9

Page 107: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��>

������� *�����- '��

;# � �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��>;#� 1������ ��+�����/��I'��� ���& ��� /�B�'�/�%

$&����������"&�����8

-��/�"�5/��. !�/'

����"������������������ %������$!#$�������������

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*��"������������������-����>���?!������� "� ���������

.�/$��"�� ��B�"�'� ��& �!��� �'

���� '�!�&��'�'

� ���������������� "� �������5�����&������������������������������������������ ������������ �����-�"� ���������������� ��� ���������� >��������������$!#$���������������������� >��������������������������� ���������������������������

Page 108: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��> ����������

'�� ������� *�����-

� �5/�'6 ���)

(V2841)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

Set the group No. correctly.

Replace the central PC board.

Fix the wiring correctly.

Fix the wiring correctly.

Connect the connector correctly.

Replace the central PC board.

Reset power supply for all optional controllers for centralized control simultaneously.

NO

YES

NO

YES

NO

NO

NO

Turn the power supply of the indoor unit on.

YES

NO

YES

YES

YES

YES

NO

Diagnose the cause with the air conditioner's failure diagnosis manual.

NO

YES

Is transmission with all indoor units

malfunctioning?

Is the power supply

for the indoor unit displaying a malfunction

turned on?

Istransmission wiring

disconnected or wired incorrectly?

Isthe transmission

wiring with the master controller disconnected or

wired incorrectly?

Has a once connected

indoor unit been removed or its address

changed?

Is a malfunction code

displayed on the remote control?I

Is the master controller's

connector for setting master controller

disconnected.

Is the group No. of malfunctioning

indoor units set?

Page 109: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��>

������� *�����- '�'

;#� B�'�/�%�Q*�!���&�����/�:�!�& ��� /R��/��I'�=������'����)/���/��I>

��� ���& ��� /�B�'�/�%

C��������������@����������D�:��&��� � ��-�������8;

-��/�"�5/��. !�/'

%������$!#$����������������������"�����������1���*��������"��

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*��"������������������-����>���?!������� "� ����������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����*����������@�������������1�5*��*�5� ���������������1� *�5 ������ &�� ���*�������������-� �����������&&���7*���"����&���"� ���������������������������&�� ����7*����*�� �*��������"���� � ������������������ ��"���1���*����������������������� �&�� ����7*����*��5����-����&�������������������&&������ �� �&�� ����

���� '�!�&��'�'

� ����� ���&������������&����������������� ������������@����������� �"&��&�����"������������&����������������� ������������@����������� ������������"�����*�������"� ���������������� ���������������� "� �������5�����&����������������� ������������@����������� >������������������&����������������� ������������@����������

Page 110: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��> ����������

'�( ������� *�����-

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

(V2842)

Is the reset switch of

all optional controllers for centralized control

set to "normal"?

Istransmission wiring

disconnected or wired incorrectly?

Correct the setting of the unified ON / OFF controller's switch for setting each address and reset the power supply of the unified ON / OFF controller.

Refer to failure diagnosis for central remote control or schedule timer.

NO

YES

YES

NO

NO

Fix the wiring correctly.

Set reset switch to "normal."

NO

NO

YES

YES

YES

Is the power supply

turned on for all optional controllers for

centralized control?

Reset power supply simultaneously for all optional controllers for centralized control.

NO

YES

Has a once connected

optional controller for centralized control been

disconnected or its address

changed?

Isthe central

remote control or schedule timer displaying

a malfunction?

Is a central remote

control or schedule timer connected?

Turn on power supply for all optional controllers for centralized control.

NO

YES NO

Isthe setting of

the unified ON / OFF controller's switch for setting

each address duplicated?

Aretwo or more unified

ON / OFF controllers connected?

YES

A

Page 111: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��>

������� *�����- '�)

NO

NO

Cannot be used in combination with a wiring adaptor for electrical appendices. Remove the wiring adaptor for electrical appendices and reset the power supply for all optional controllers for centralized control simultaneously.

Schedule timer and parallel interface cannot be used in combination. Disconnect either the schedule timer or parallel interface and reset the power supply for all optional controllers for centralized control simultaneously.

Disconnect the schedule timer's individual / combined connector and reset the power supply for all optional controllers for centralized control simultaneously.

Arrange so that the connector for setting master controller is connected to one controller for centralized control and reset the power supply for all optional controllers for centralized control simultaneously.

Disconnect the connector for setting master controller from the master controller, connect to another optional controller for centralized control and simultaneously reset all optional controllers for centralized control again. The controller connected by the connector for setting master controller when the malfunction is cleared is defective and must be replaced.

Reset the power supply for all optional controllers for centralized control simultaneously.

YES

YES

YES

Is the wiring adaptor for

electrical appendices connected?

Is a schedule timer connected?

Arethere two

or more optional controllers for centralized control connected with the

connector for setting master controller?

YESIs a parallel interface connected?

NO

YESIs the

schedule timer's individual/combined

connectorconnected?

NO

NO

If the malfunction is still not cleared:

A

(V2843)

Page 112: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=1�2�*��$��!�1�01,,�& ��� //��> ����������

'�2 ������� *�����-

;#� B�'�/�%�Q*�!���&�����/�:�!�& ��� /R��/��I'�=������'�B �5/���/��I>

��� ���& ��� /�B�'�/�%

C��������������@����������D�:��&��� ������������8;

-��/�"�5/��. !�/'

%������$!#$�������������

.��6 !� $�

.�/$��"�� ��B���"�� �

>�������*��"������������������-����>���?!������� "� ���������

.�/$��"�� ��B�"�'� ��& �!��� �'

7*��������������������������� � ����� ����������������� �7*����������������� ���������������5��*����*�������������-��

���� '�!�&��'�'

� �������������������� �:-���&�!��;�� ����� ������������������� �"&��&��������������-�� �����-� 5���*� �"&��&���5����-������� "� ����5����-

� �5/�'6 ���)

CautionBe sure to turn off power switch before connect or disconnect connector, or parts damage may be occurred.

(V2844)

Is the control range

setting switch set correctly?

Is the transmission wiring

disconnected or wired incorrectly?

Replace the unified ON/OFF controller.

Fix the wiring correctly.

Set by remote control the central control address for all indoor units connected to the central control line.

YES

YES

Set the control range setting switch correctly and simultaneously reset the power supply for all optional controllers for centralized control.

NO

NO

NO

YES

Is the central control

address (group No.) set for the indoor

unit?

Page 113: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '�+

@# � �5/�'6 ���)�=�������"/����4����/��� �>@#� C60D���� �� $��3�����/��� ��"�� ��B�L�"���� ���& ��� /�+&B�B�'�/�%

����������60��� &�������$���%����!���4���8��-

-��/�"�5/��. !�/'

9����������"������������

.��6 !� $�

.�/$��"�� ��B���"�� �

>�����������"������&�����"��*����������� ������������5��*�����������&���:���5����X������X;�

.�/$��"�� ��B�"�'� ��& �!��� �'

�����"������&���: *�����������;� �-����� �� ������"��*����������� ������������

���� '�!�&��'�'

� ���������������������� ������������ ���������������������*�������"������&��� �-��������� �*������������� ����� *�������*�������"������&��� �-��������� ����������������������

� �5/�'6 ���)

Pc > 3.47MPa

Pc > 3.64MPaHPS (4.0MPa) is activa

Compressor step=Max · step

Normal operation

INV compressor (see *1):3 steps down per 10 sec.

INV compressor (see *1):1 step up per 15 sec.

STD compressor 2:OFF

STD compressor 1:OFF

INV compressor:52 Hz

Restart standby(2 times per 30 min. at maximum)

Stop due to malfunction(E3 displayed)

• Pc > 3.55MPa • A lapse of 10 sec.

& • Pc > 3.55MPa • A lapse of 10 sec.

• Pc > 3.55MPa • A lapse of 10 sec.

• Pc > 3.47MPa • A lapse of 10 sec.

• Pc < 3.24MPa • A lapse of 15 sec.

&

&

&

&

Page 114: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

'�/ ������� *�����-

@#� C64DD�C65D���! ��-��� 6����'� ����� ���� ���& ��� /�+&B�B�'�/�%

����������64����65��� &�������$���%����!���4���8��-

-��/�"�5/��. !�/'

9����������"������������

.��6 !� $�

.�/$��"�� ��B���"�� �

��"&���������������������� ����������"&�������� �� ���� �� ������������������ �

.�/$��"�� ��B�"�'� ��& �!��� �'

7*����������������������� ����������"&�������� �� ���� �?(,U��������5�:�&����������;����+,U����*�-*���: *���?�������;�

���� '�!�&��'�'

� >��������*��"� ��������������� >��������*��"� ���� ����������������������

� �5/�'6 ���)

� ��2 � ����2�.�/$��"�� ��" !����!��6����'� �

� ����2���������*���*��"� ������"&��������?��� � ������������ ����������5*���"�� ����-��� � ������

YES

YES

NO

Replace indoor air thermistor.NO

Check for the connector

Remove the thermistor from outdoor PC board, and measure resistance.

Connect the connector correctly.

If there is no faulty contact, replace control PC board.

(HF003)

Is thermistor normal?Note 2

Is connector connected correctly?

�������������� �*��"� ��� ��"���

� ������������*��"� ��� ���

� $������������*��"� ��� ���

Page 115: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '�<

@#� C6AD�B�������%'������� ��=-/���>��� ���& ��� /�+&B�B�'�/�%

����������6A��� &�������$���%����!���4���8��-

-��/�"�5/��. !�/'

9����������"������������

.��6 !� $�

.�/$��"�� ��B���"�� �

�� ���"��������"&���"�������"���$!#$�����"��

.�/$��"�� ��B�"�'� ��& �!��� �'

� 7*�����"&���"�������"��� 5���*���:����;���"��� �$!�:���$��;����"�����*���������������"����������������������������"����� ��*��-���

� 7*�����"&���"�������"��� 5���*���:����;���&��� �$!#$����&������� ��������"&���"�������:����;� ��& �

���� '�!�&��'�'

� ���������"&���"����������"��� 5���*� 4��8���5������������� ����������������������������:��������-����������������;� ������������������������ �"���

� �5/�'6 ���)

� ��2 � ����2� �������� ����&���� ������������� �����"��� 5���*�� ���� 5���*����*���������*��8����������������� ������������ �,�5*�����"��� 5���*����� ���1�������������5*���������� ��1���"��� 5���*�� ����"���

� �������� ����&���� ������������� �����"&���"����������*��8��� � ����������� ������������ ��&&������+�8�����,,?=�"����1���"&���"������ ����"���

Check connectors (X3A or X4A) (X5A or X6A) on PC board assembly of damper motor unit.

Isdamper

motor unit operating normally?

Note 1

YES

YES

YES

Connect relay connector.

Connect connectors.

Replace damper motor unit.

Replace control PC board assembly.

Isrelay

connector of damper motor unit

connected?

NO

(HF005)

NO

Are connectors connected?

NO

Check resistance and voltage

(HL029)

Page 116: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

'', ������� *�����-

@#� C6AD�B�������%'������� ��=-/���>��� ���& ��� /�+&B�B�'�/�%

����������6A��� &�������4���8��-�%����!���4���8��-

-��/�"�5/��. !�/'

9����������"������������

.��6 !� $�

.�/$��"�� ��B���"�� �

�� ���"��������"&���"�������"��� 5���*�$!#$�����"��������"&������� �������������������������������������*��"� ����

.�/$��"�� ��B�"�'� ��& �!��� �'

� 7*�����"&��� � ��"�������:����";������������:����������;��*��"� ��������������-�������������*�� �"����"��

� 7*�����"&��� � ��"�������:����";������ ���������� ���������������������������*��"� ����"������ ����������� �

���� '�!�&��'�'

� ���������"&���"����������"��� 5���*� �������������������*��"� ���� ��������������������*��"� ���� ��� ���-� 4��8���5������������� ����������������������������:��������-����������������;� ������������������������ �"���

� �5/�'6 ���)

Check error record on malfunction history display in service mode.

Is "64" recorded?

YES

YES

YES

Take corrective measures specified for damper system error (alarm).(Remove the cause of problem, and reset display.)

Take corrective measures specified for damper system error (alarm) and indoor and outdoor air thermistor errors.

Take corrective measures specified for damper system error (alarm) and outdoor air thermistor error.

Take corrective measures specified for damper system error (alarm) and indoor and outdoor air thermistor error.

Are"6A" and "64"

or 65" recorded?NO

(HF006)

NO

Are"64" and "65"

recorded?

NO

Page 117: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- ''�

@#� C6FD�.�/$��"�� �� $�����/����� ���& ��� /��� ���& ��� /�+&B�B�'�/�%

����������6F��� &�������$���%����!���4���8��-

-��/�"�5/��. !�/'

9����������"������������

.��6 !� $�

.�/$��"�� ��B���"�� �

*��8�5��*��*��"����������������5*��*�����������*�� �-�������5�����*�� �"&�����"�����������������*������������������� ���������&��&�������������*��"����������

.�/$��"�� ��B�"�'� ��& �!��� �'

�*�� �-����������������������������&��������-�������"��������-���

���� '�!�&��'�'

� >� �������������������������"� �"&�����"������������������ 4��8���5��������"������������������ ������� �"&�����"������������ ����������������������

� �5/�'6 ���)

YESProperly connect the connector.

NO

NO

Replace the remote control cable.

The simple remote control or the control PC board gets faulty.

Replace either one.

YES

Is any cable connector

disconnected from the simple remote control (on both

remote control side and the control PC board

side)?

Theremote control

cable has broken wires.

Page 118: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

''� ������� *�����-

J&��&C��K &6�"I� ��" ���"� �� $�$���� � ��=� 8���'���/%�"�5/�>:�; ��������*��&�5��� �&&��� �� �����*���� � ���������5����&*� � ���%1=17�����*��"����� ������������� �:�*���?�����5���;�����*��8��*����*������� �������������������*����� ���� *�������������-1�5*���������������������������������� ��� ����������

J&��&C��K :�; ��������*��&�5��� �&&���:�; �� �����*���� � ���������5����=����������*�&*� ����%1=171�����6!>��������*�&*� ������*��"����� ������������� �:���?�����5���;�����*��8��*����*������� ��������������5��*����*�����-����_��,�R1�5*���������������������������������� ��� ��������������*��"���1����� ����"����&���"��������"�� ���"���1����������*��&���������-������&�������=��������*�����&� ������&�������6!>�

Red

White

Black

U

V

W

Measure the resistance values between phases U,V,W.

5 Gray

4 Pink

3 Orange

2 Blue

1 Yellow

GND

Vcc

W

V

U

Measure the resistance values between Vcc and U,V,W, and GND and U,V,W.

Page 119: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '''

J&��&C��K�&6�"I��6��,�"� �'� $�1L��6����1������ ����������*�����������&���� ��������-�����*�������������������� � �:���;�� �����5 �

Faulty dischargepipetemperature control

Faulty hot gas bypass control

Hot gas circuit clogging

Defective solenoid valve coilDefective solenoid valve body

Defective control PC board

Defective control PC board

Defective valve coil

Defective low pressure sensorDefective subcool heat exchange outlet thermister

Defective valve body

Faulty subcoolingmotorized valve control (EV2)

Superheat due to shaft damage

Superheat due to defective compressor

Indoor unit motorized valve failure

Faulty control

Faulty control

Outdoor unit motorized valve failure

Faulty of 4 way switch valve operation

[In cooling mode only]

(∗1)

(∗2)

Compressoroverheat

Refrigerant gas shortage

Large resistance of piping

Faulty superheateddegree control.

[In cooling mode] When indoor unit electronicexpansion valve becomes too narrow (∗3)

[In heading mode]Whenoutdoor unit electronicexpansion valve becomes too narrow (∗4)

Temperature increase of dischargepipe

← Check if coil resistance and insulation are normal.

Subcoolingmotoroperated valve failure

Controlfailure

← Check if coil resistance and insulation are normal.

← Check if the voltage property is normal.

← Check if the connector is connected properly.

Check if the thermister resistance property is normal.

← Check if the pressure value given by the service checker corresponding to actual measurement value by the sensor.

← Check if the piping temperature connected to the 4 way switch valve is normal.

Defective valve coil

Defective valve body

Defective thermister for indoor unit gas pipe

Defective thermister for indoor unit liquid pipe

Defective control PC board

Defective valve coil

Defective valve body

Defective low pressure sensorDefective thermister for suction pipe

Defective control PC board

← Check if coil resistance and insulation are normal.

← Check if the connector is connected properly. Check if the thermister resistance property is

normal.

← Check if the connector is connected properly. Check if the thermister resistance property is

normal.

← Check if coil resistance and insulation are normal.

← Check if the voltage property is normal.

← Check if the connector is connected properly. Check if the thermister resistance property is normal.← Check if the pressure value given by the

service checker corresponding to actual measurement value by the sensor.

← Refer to [Check 7]

← Does the piping length fall in the permissible range?

← Corduet visual checks.

← Remove the moisture by vacuum break. (Refer to [Check 8])

← Check if the stop valve is open.

Irregular piping length

Bend/collapse

(Including moisture choke)

Stop valve is closed.

∗1: Refer to “Low pressure protective control” (P99) for hot gas bypass control.∗2: Refer to P93 for subcooling electronic expansion valve control. ∗3: “Superheating temperature control” in cooling mode is conducted by indoor unit electronic expansion valve. (Refer to P125)∗4: Superheating temperature control in heating mode is conducted by outdoor unit electronic expansion valve (EVM).∗5: Judgment criteria of superheat operation:

1 Suction gas superheating temperature: 10 degrees and over. 2 Discharge gas superheating temperature: 45 degrees and over, except for immediately after starting and drooping control, etc.. (Use the above stated values as a guide. Depending on the other conditions, the unit may be normal despite the values within the above scope.)

4 way switch valve is in the middle position.Leak from hot gas bypass valve

Page 120: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

''( ������� *�����-

J&��&C��K�� 8��� ���'�'� ��&6�"I

Perform the following procedures prior to check.

[Preparation]· Tester

[Point of Measurement and Judgment Criteria]· Measure the resistance value using a tester at each point of measurement below, 10 minutes later after power OFF.

Point of MeasurementJudgment Criteria Remarks+ –No.

15kW and above (including )

2 ~ 15kW

2 ~ 15kW

P2P2P2UVWN3N3N3UVW

123456789101112

P2P2P2

UVW

UVWN3N3N3

Point of MeasurementJudgment Criteria Remarks+ –No.

0.3 ~ 0.7V

1.2V and over

1.2V and over

P2P2P2UVWN3N3N3UVW

123456789

101112

P2P2P2

UVW

UVWN3N3N3

[PC board and Circuit Diagram]

P3U V WN3

J1

J2

J3

P1

P1 P2IGBT

X11A

U V W

L1

L2

L3

X10A

DM

K2

P3

N3

(V2895)

J1

J2

J3

Due to condenser charge and so on, resistance measurement may require some time.

Due to condenser charge and so on, resistance measurement may require some time.

Due to condenser charge and so on, resistance measurement may require some time.

To use analog tester:Measurement in the resistance value mode in the range of multiplying 1kW.

To use digital tester: Measurement is executed in the diode check mode. ( )

* Preparing a tester in the analog system is recommended. A tester in the digital system with diode check function will be usable.

(1) Power Off.(2) Remove all the wiring connected to the PC board where power transistors are mounted on.

Page 121: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '')

J&��&C��K�&6�"I�$ ��"��'�'� $���'�����6�)6����''����������-�����*������������������ � �:���;� *�5������51�&������*��������&���� �

Short circuit

Rise in highpressure

Localpressurerise

High pipe resistance

Stop valve closed

Bent or crashed pipe

Clogging of foreign particles

←Check to be sure the stop valve is open.

←Conduct visual checks for pipe conditions.

←Is there any temperature difference caused before and after the filter or branch pipe.

[In cooling]If the outdoor unit electronic expansion valve is throttled:(See *1.)

Faulty outdoor unit motorized valve

Faulty valve coil

Faulty valve body

←Are the coil resistance and insulation normal?

A temperature difference in excess of 10°Cbetween the inlet and the outlet is deemed to be abnormal.

Faulty control

Faulty high pressure sensor

Faulty control PC board

←Are the electrical characteristics normal?

←Is the pressure value checked with the Service Checker corresponding to the measurement of the pressure sensor?

←Are the coil resistance and insulation normal?Faulty high pressurecontrol Faulty indoor

unit motorized valve

Faulty valve coil

Faulty valve body

[In heating]If the indoor unit electronic expansion valve excessively throttled:(See *2.)

Faulty control

Faulty high pressure sensor

Faulty indoor unit liquid pipe thermistor

Faulty control PC board

←Are the electrical characteristics normal?

←In the connector properly connected?Are the thermistor resistance characteristics normal?

←Is the pressure value checked with the Service Checker corresponding to the measurement of the pressure sensor?

[In cooling]

High suction airtemperature of the condenser

[In heating]

High suction air temperature of outdoor unit

Short circuit

High ambient temperature

←Is the suction air temperature not more than 43°C?

←Is the outdoor temperature not more than 43°C?

High suction air temperature of indoor unit High ambient temperature

←Is the suction air temperature not more than 27°C?

←Is the indoor temperature not more than 27°C?

Faulty suction air thermistor of indoor unit

High suction air temperature of outdoor unit

Faulty outdoor temperature thermistor of outdoor unit

←Is the connector properly connected?Are the thermistor resistance characteristics normal?

←Is the outdoor temperature not more than 16°CWB?

←Is the connector properly connected?Are the thermistor resistance characteristics normal?

Degradationin condensing capacity

Dirty condenser

Mixing of non-condensable gas

←Is the heat exchanger clogged? (In cooling)

←Is air or else mixed in the refrigerant system?

Decreasedfan airflow rate

Decreasedfan output

Faulty fan motor

←Can the fan motor be rotated with hands?Are the motor coil resistance and insulation normal?

←If a spare PC board is mounted, is the capacity setting properly made?

Faulty control PC board(Includingcapacity setting)

High air passageresistance

Dirty filter ←Is the air filter clogged?

Obstacle ←Is there any obstacle in the air passage?

Excessive refrigerant charging

Improper model selection [In heating]

←Refer to P341.

←Is the indoor unit too small compared to the large-sized outdoor unit?

*1: In cooling, it is normal if the outdoor unit electronic expansion valve (EVM) is fully open.*2: In heating, the indoor unit electronic expansion valve is used for “subcooled degree control”.

(For details, refer to “Control of Electronic Expansion Valve” on P125.)

SDK04009

Page 122: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

''2 ������� *�����-

J&��&C�;K�&6�"I�$ ��"��'�'� $�!� �����/ 8����''����������-�����*������������������ � �:���;� *�5������51�&������*��������&���� �

Abnormally low low-pressure

(Low evaporatingtemperature)

[In cooling](See *1.)

Faulty low pressurecontrol

Faulty compressorcapacitycontrol

Faulty low pressure sensor ←Are the electrical characteristics normal?

Faulty control PC board ←Is the pressure value checked with the Service Checker corresponding to the measurement of the pressure sensor?

Faulty low pressureprotectioncontrol

Faulty low pressure sensor ←Are the electrical characteristics normal?

Faulty hot gas solenoid valve ←Are the coil resistance and insulation normal?

Faulty control PC board←Is the pressure value checked with the Service Checker

corresponding to the measurement of the pressure sensor?

[In both cooling and heating] (See *2.)[In cooling]If the indoor unit electronicexpansion valve is throttled too much:(See *3.)

Faulty indoor unit electronic expansion valve

Faulty valve coil

Faulty valve body

←Are the coil resistance and insulation normal?

Faulty control

Faulty gas pipe thermistor of indoor unit

Faulty liquid pipe thermistorof indoor unit

Faulty control PC board

←Check for the thermistor resistance and connection.

←Check for the thermistor resistance and connection.

←Is the pressure value checked with the Service Checker corresponding to the measurement of the pressure sensor?

Faulty outdoor unit electronic expansion valve

Faulty valve coil

Faulty valve body

←Are the coil resistance and insulation normal?

[In heating]If the outdoor unit electronicexpansion valve excessively throttled:(See *4.)

Faulty control

Faulty low pressure sensor

Faulty suction pipe thermistor

Faulty control PC board

←Are the electrical characteristics normal?

←Check for the thermistor resistance and connection.

[In cooling]

Low suctionair temperature of the evaporator

[In heating]

Low suction air temperature of indoor unit

Short circuit ←Is the suction air temperature not less than 14°C

←Is the indoor temperature not more than 14°CLow ambient temperature

Faulty suction air thermistor of indoor unit ←Is the connector properly connected?Are the thermistor resistance characteristics normal?

Low suction air temperature of outdoor unit ←Is the outdoor temperature not less than -20°C

Faulty outdoor temperature thermistor of outdoor unit←Is the connector properly connected?

Are the thermistor resistance characteristics normal?

High pipe resistance

Bent or crashed pipe

Clogging of foreign particles

Stop valve closed

←Does the piping length fall in the permissible range?

←Conduct visual checks for pipe conditions.

←Is there any temperature difference caused before and after the filter or branch pipe?

←Check to be sure the stop valve is open.Lesscirculationquantity of refrigerant

Degradation in condensing capacity

Inadequate refrigerant quantity ←Refer to P342.

Moisture choke←Eliminate moisture by vacuum operation.

Dirty evaporator

Decreasedfan airflow rate

Decreasedfan output

Faulty fan motor ←Can the fan motor be rotated with hands?Are the motor coil resistance and insulation normal?

←Is the heat exchanger clogged?

Faulty control PC board(Including capacity setting)

←If a spare PC board is mounted, is the capacity setting properly made?

High air passageresistance

Dirty filter

←Is there any obstacle in the air passage?

←Is the air filter clogged?

*1: For details of the compressor capacity control while in cooling, refer to “Compressor PI Control” on P90.*2: The “low pressure protection control” includes low pressure protection control and hot gas bypass control. For details, refer to P99.*3: In cooling, the indoor unit electronic expansion valve is used for “superheated degree control”. (For details, refer to P125.)*4: In heating, the outdoor unit electronic expansion valve (EVM) is used for “superheated degree control of outdoor unit heat exchanger”.

Faulty electronic expansion valve control

Obstacle

Abnormal piping length

Page 123: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- ''+

J&��&C�@K��� I���(����&6�"I� $��6��& ���"���)�(���'�� ��������������*��8��-��������?����������������� "� ����5����-�������8���5��� $���*�� � ��"� *�5������51������$����*��&�5��� �&&�����������B��&"���1� *���?�����������5�����*���������?����������������"�����&��� ���������������*��S$�������%�����S��*���� ����*� ����"��*������������"�����������1������*�����������������������*��8 ����5�����*������ "� ����5����-����"���������8 ��������������*������������"������������� ��-���"����&���"���������*����� ���������������5�����*�� �������"���������8 1��*���������?����������������� "� ����5����-�*� �������8���5��� ����������*����� ��������������1��*������ "� ����5����-�"���*�������8���5��� ��7��*��*���������?����������������"�����&��� ����*��S$�������%�����S� *���?���������1���������������������*��8 ����5�����*������ "� ����5����-����"���������8 ��������������*���������$!#$������������������*����� ���������������� �5���1���������������������*��8 ����5�����*���������?����������������"�����&��� ����*��S$�������%�����S1����5�����*���������?����������������"�����&��� ����*��S$�������%����>S1����5�����*���������?����������������"�����&��� ����*��S$�������%����S1�b�����*���������� ������1��*� ����������-��*��&�����5��*���������������*��&�����5��*����������������������������1��*����"���������8���5��� ����&���� ��������*�� ����&�����5��*������������

�� ��������������*��8��-�������?����������������� "� ����5����-�������8���5��� �:����*��8��-��*��������?����������������� "� ����5����-����*��S$�������%����S�������8���5��� ;�����$����*��&�5��� �&&�����������B��&"���1� *���?�����������5�����*��������?����������������"�����&��� ���������������*��S$�������%����1������*�����������������������*��8 ����5�����*������ "� ����5����- ��������������*��S�������%�����S��*���� ����*� ����"��*��S$�������%����S�� ��-���"����&���"���������*����� ���������������5�����*�� �������� "� ����5����- 1��*��������?����������������� "� ����5����-�*� �������8���5��� ����������*����� ��������������1��*������ "� ����5����-�"���*�������8���5��� ��7��*��*��������?����������������"�����&��� ����*��S$�������%����S� *���?���������1����������*��&�����5��*����������������*������ "� ����5����-����*��S�������%�����S1����� "� ����5����-����*��S�������%�����S1��������� "� ����5����-����*��S�������%�����S�����*���������� ����������*��&�����5��*����������������������������1��*����"���������8���5��� ����&���� ��������*�� ����&�����5��*������������

1 Short-circuit between the outdoor-outdoorunit terminal parts.

Outdoor-outdoor Unit Transmission Wiring

2 Check the transmission wiring for continuity.If there is continuity, the indoor-outdoor unit transmission has no broken wires in it.

Indoor-outdoor Unit Transmission Wiring

2 Short-circuit between the indoor-outdoor unit terminal parts.

1 Check the transmission wiring for continuity.If there is continuity, the outdoor-outdoor unit transmission has no broken wires in it.

Unified ON/OFF control Central remote control

Page 124: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

''/ ������� *�����-

J&��&C�K�.�'����*����&�����/�& ���"� ��������)� �5/��*��"� ����������������� �����-�����������:!�#J��;�� �"�����������*���������[ �������&���������� ���� ��-�����������*���������-��������*����������������� ��-�����������*������������"�����������1���������� "������*��"� ����������������� �����-�����������:����1�� ���*������������5��*��*��������� �����-����*��-��;�

[ �������&���������� ���*�� �*��������"��1��� �����������&������?� �� �����-�����������!������&������?� �� �����-�����������*� ������"�����������*������������ �����*�����������1�5*��*�� ������*�������*���� ��-����*��"��������1�����*����������:!�#J��;��:����&������?� �����������V � ����������������� �����-����������;

[ ���� ���5�����"�������������B��&"���������"��������1�"�8�� �����- ���������-�����*�������� *�5������5�

:Z�;��*���������-��������*�����������������*�� �*��������"��������������������������"������� ��:Z�;��*���������-��������*�����������1�����������"�����������1������*���������$!#$��������������*��������� ������S���������5��*��*��"� ����

������������� �����-����������S�����*�����������*�� �*��������"���*� ������ ������S!���&��������5��*��*��"� ����������������� �����-����������S�����*��������1�5*��*�� ������*�������*���� ��-����*��"���������

1

2

3

4

5

6

7

8

9

AT

AK

Pattern

Central equipment connection pattern Setting of master unit central setting connector(*2)

IntelligentTouch control

Central remotecontrol

UnifiedON/OFFcontrol

Scheduletimer

IntelligentTouch control

Central remotecontrol

UnifiedON/OFFcontrol

Scheduletimer

1 to 2 units

1 to 2 units

1 to 4 units

1 to 16 units

1 to 16 units

1 to 8 units

1 unit 1 unit

× (*1)

× (*1)

× (*1)

× (*1)

Only a single unit:

"Provided", Others: "Not

provided

Only a single unit:

"Provided", Others: "Not

provided

Only a single unit:

"Provided", Others: "Not

provided

Only a single unit:

"Provided", Others: "Not

provided

Provided Not provided

All “Not provided”

Not provided

Not provided

Not provided

Provided

All “Not provided”

1 unit

1 unit

1 unit

1 unit

Page 125: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- ''<

J&��&C�NK�.�'����/�L��*����������)� �5/��"������������������-��������*������������������������"����������

�E����������"������������W>�',��2�Y�������-��������*�����������E�W Y∗�*��&������ �"��8���5��*�C∗D�*�������*��-�������5��*��*� ���� �����������*���� ����������-���"� ����������������� �����-�����������

∗ c� c� c' c(������� �?,,F(?�) � ���#

������ )?,,F/?�) � ���#������ �?,,F(?�) � ���#

������ )?,,F/?�) � ���#������

1 � � ��� � � ��� � ����� � �����2 � � ��� L L � ����� L L

3�������-��������*�����������

� ��� L L�������-��������*�����������

����� L L

4 � � ��� L L�������-��������*�����������

����� L L

5�������-��������*�����������

� ��� L L � ����� L L

6 � � ��� L L L L L L

7�������-��������*�����������

� ��� L L L L L L

#1 #2 #3 #4

Master Slave

Page 126: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

'(, ������� *�����-

J&6�"I���K�&6�"I�$ ��"��'�'� $�8��� ������ �#�������-�����*������������������ � �:���;� *�5������51���������������&���� �

Refrigerant accumulation

Overcharge of refrigerant

Faulty crankcase heater

Frequent ON/OFF of compressor

[Cooling]Indoor unit motorized valve opens too much. (*1)

[Heating]Outdoor unit motorized valve opens too much. (*2)

Faulty control of superheated degree

Faulty indoor unit motorized valve

Faulty outdoor unit motorized valve

Faulty control

Faulty control

←Refer to information in the [Check 6] section.

←Does the valve coil have normal resistance and insulation?(Refer to information in the [Check 11] section.)

←Is the connector correctly connected?Are the thermistor resistance characteristics normal?

←Is the connector correctly connected?Are the thermistor resistance characteristics normal?

←Does the valve coil have normal resistance and insulation?(Refer to information in the [Check 11] section.)

←Are the voltage characteristics normal?

←Is the connector correctly connected?Does the thermistor have normal resistance characteristics?

←Is the pressure reading of the service checker corresponding to the actual measurement of the sensor?

←Can the fan motor be rotated by hand?Does the fan motor coil have normal resistance and insulation?

←Does the air filter get clogged?

←Are there any obstacles in the air passage?

Degraded evaporation capacity

Increasedresistancein air passage

Dirty evaporator

Reducedair quantity

Reducedfan output

*1: "Superheated degree control" in cooling operation is exercised with the indoor unit motorized valve. (Refer to information on P141.)

*2: "Superheated degree control" in heating operation is exercised with the outdoor unit motorized valve (EV1). (Refer to information on P108.)

*3: Guideline of superheated degree to judge as wet operation1Suction gas superheated degree: Not more than 3°C; 2Discharge gas superheated degree: Not more than 15°C, except immediately after compressor starts up or is running under drooping control.(Use the values shown above as a guideline. Even if the superheated degree falls in the range, the compressor may be normal depending on other conditions.)

Faulty valve coil

Faulty valve body

Faulty indoor unit gas pipe thermistor

Faulty indoor unit liquid pipe thermistor

Faulty control PC board

Faulty valve coil

Faulty valve body

Faulty power pressure sensor

Faulty suction pipe thermistor

Faulty control PC board

←Does the heat exchanger get clogged?

Faulty fan motor

Faulty control PC board (including faulty capacity setting)

Dirty filter

Obstacles

Wet operation

Page 127: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '(�

J&6�"I���K�&6�"I�$ �� L��"6��)�� $���$��)�����#����� ����=�=��� ��" 1��*�������5������H��-��� ��*�������*��-��������-������� �5��*��&������-���������� ���������*���������� *�&����&�� �����������������������������&�� ������������������� �����"���������"�8��-���H��-"���1�������������"������&������������5�

>��-�� � ��������*��-��������-������� 9�-*�&�� ������ � ���� �B������1������������������� ������� ��������� �� �����������-���&������

�� �*�� �&��*��������-������ �������-� ���5�� �:����*��5����&��������� �&����"��;���� �B������1��*����"&�� �������"� ���5�������� �*��-��&�&����"&���������� &������&�� �������� �

'� �*�� �&�����������-������������ ������ � ���� �B������1����*�����-��&�������1��*����"&���������������������&� ��-��*���-*��*�� �&��������� �����������"� ���5���

Cooling

High pressure

Low pressure

Frequency

High-pressuredrooping control

(LP is maintained at a constant level.)

To maintain LP, frequency increases under the capacity control.

HP gradually rises with increase in frequency.

Frequency comes to the minimum level.

Supercooled degree becomes higher.(Liquid connection pipe temperature lowers.)

LP rises due to reduced compressor output.

High pressure

Low pressure

Frequency

HeatingThe outdoor unit motorized valve is closed due to the overload control.

Frequency comes to the minimum level.

(HP is maintained at a constant level.)

LP rises due to reduced frequency.

To maintain HP, frequency reduces under the capacity control.

HP drops or rises immediately after the overload control is complete.

LP drops due to closed outdoor unit motorized valve.Hot gas bypass is activated for LP protection, i.e., hunting at LP.

Higher degree of overcharge

(Degree of overcharge)

Proper quantity

Page 128: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

'(� ������� *�����-

J&6�"I���K�&6�"I�$ ��'6 ���)�� $���$��)�����#����� ����=�=��� ��" 1��*�������5������H��-��� ��*�� *����-��������-������� �5��*��&������-���������� ���������*���������� *�&����&�� �����������������������������&�� ������������������� �����"���������"�8��-���H��-"���1�������������"������&������������5�

>��-�� � ��� *����-��������-������� �*�� �&��*��������-������ �������-� ��� � ���� �B������1��*����"&�� ����� �*��-��-� ���"&������������"� �*�-*���

�� �*�� �&��*��������-������ �������-� ��� � ���� �B������1��*���������������&�� �������������� ��&���

'� 3�5�&�� �������& ������� ���*����������������"�� ������������-���&������:*�����-���&�����;�

Cooling

High pressure

Low pressure

Frequency

Frequency comes to the minimum level.

To maintain LP, frequency drops due to the capacity control.

Heating

High pressure

Low pressure

Frequency

The opening degree of the outdoor unit motorized valve becomes larger.

The outdoor unit motorized valve fully opens and frequency increases.

Discharge pipe or LP drooping control

(HP is maintained at a constant level.)

(Degree of refrigerant shortage)

Higher degree of shortageProper quantity

(LP is maintained at a constant level.)

The opening degree of the indoor unit motorized valve becomes larger.

Either of the motorized valves becomes fully open.

Fan control is activated for HP protection under cooling control at low outdoor temperature, i.e., the fan is hunting at HP.

If frequency comes to the minimum level, LP cannot be maintained.

LP rises as the opening degree of the indoor unit motorized valve becomes larger. Frequency slightly increases under the capacity control.

HP drops with decrease in compressor capacity.

Frequency comes to he minimum level.

Frequency drops due to the drooping control.

To maintain LP, frequency drops due to the capacity control.

Page 129: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '('

J&6�"I���K�4�"�����)���!�!�6%!���� ���� "�!���������������"��-�������*�������������*��&�&��-� � ��"�����5��-��*��&������������W!��"��������"��-�������*��������Y��� �����������5�����*��"���1���"�� �����"���-���"���������*��&�&��-� � ��"1�����5��*��&������������W�&�����������"��-�������*��������Y��� �����������5�

W!��"��������"��-�������*��������Y1 =����"��-�������*��������[ % ���������"�&�"&��*��������� ������"��-��&�����,,�+8���:)�����1�?+))�""9-;�[ �������"�������-��-� �����*�� �������&��� �����B����&�&������-� �&�&�����������*�������"�&�"&������&���������5�����"����*��� ��������������������������?�,,�+8�������� �[ ���*����-�����������"���� ���������*�?�,,�+8�������� �������*��-*������������� ����������������&���������5��*��� 1�"�� �����5����*�������������*�� � ��"��������-���������8�-��5����*������������ ��������*� ��� �1�������������������������&������������*�������*����[ ���*����-�����������"���� ���������*�?�,,�+8�������� �������*��-*������������� ����������������&���������*����*��� 1������������8��� � �

2 3�����-���������"� ����[ 3������*����"&�� �������*����-�����������"���?�,,�+8�������� ������&������������*�������"���1������*����*��8������� �����*����*�������"�-��-��������-���� ������� ���:���*��������-��� � 1�"�� �����"���*������"����������*�� � ��"��������-���������8�-��"���*������������ ���;

3 ����-�������*��-�[ ���-��������"��*��"�������-��-�������������*� � 1������*����*��-�������� ����B��������������-������

W�&�����������"��-�������*��������Y�?������ ��"�� �����"���-���"���������*��&�&��-Z1 =����"��-�������*��������[ �����5��*�� �"��&���������� ��*�������;�!��"��������"��-�������*����������� �������������

2 =����"�����8[ ��� ���@��5��*������-���-� ��&����,�,) ���

3 =����"��-�������*��������[ ������������"��-�������*��������������&������������*�������"��������*����-�����������"���� ���������*�?�,,�+8�������� �������*��-*������������� ����������������&���������5��*��� ����"���1���&���������"�����8�?������"��-�������*���������

4 3�����-���������"� ����[ 3������*����"&�� �������*����-�����������"���?�,,�+8�������� ������&������������*�������"���1������*����*��8������� �����*����*�������"�-��-��������-���� ������� ��

5 ����-�������*��-�[ ���-��������"��*��"�������-��-�������������*� � 1������*����*��-�������� ����B��������������-������

∗ ����� ������� ��������������-���������� ��1�����5������� ����������� �����*��&�&��-�������������������� ���������&�����1��������5���������� ��"����������*��&�&��-������-���� ���������5��8E

Page 130: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

'(( ������� *�����-

J&6�"I���K�+�'�� $���L�������/���!���/$��"�� ��" !�'��� !�"� �����������������"����-�"��������� �H������ �

�"&�� ���������� 3) �� ��������� ���������������

�����������"&�� ��[ ������������&����������������� �'��'��������� ��������� ���

[ 3�B���� �����-[ ���������"&�� ��[ �����������������������

3/ $������������������������"&�� ���:������������*��"��;

[ �"&�� ������������������-������������������<�,�����"������������ ������&��������)���� �������� ����� �����*������2�������"������������ ������&���������2,���� �������� ����� �[ �*������������� � � ���*����@������

[ 4��8��5�����"&�� �����B���[ ��������*��-� �������� [ >� ������������"&�� ���5����-[ �����������������������

������������������������*��

3� ����������������������� [ !�����&���� �-����� [ �������*�������������&��������"&�� ��

3< ������� �����&��������������"&�� ��

[ �*����"&�� ���"�������� ���� ������&� [ 3�B���� �����-������������"&�� ��[ ���� ���������������-�����[ �����������������������

�) �����������"&�� ������8 [ �*����"&�� ���� �����*�����8��� ���� �:��� �����������;�

[ ���������"&�� ��

3( ��������������"&���������� � [ �*����������������"&������������*� �/+U����"����:5*��������&�������;�

[ ��������������[ ������-����������������������������&����������"�[ �����������������������

%� ��5��� �&&��������-������� [ �*�����������&�5��� �&&��������-��� �*�-*������5�

[ ��5��� �&&��������[ �����������������������

�� �"���������&�5��� �&&�� [ ��5��� �&&��������-� �-��� �-�����������"����������"��-��*����&*� � �

[ ��5��� �&&���������:�"��������������-� ����R����"���;[ �����������������������[ >��������������������

3 ���� "� ����������:���5����������������������������������������;

[ 7��*��*����������������������1������""��������� ��������������������� �����������������?������������������?������������

[ 4��8���5���������""��������������[ ����������������������[ �����������������������[ �����������������

�X ��������"� "���*��- [ �������������� &���������������������"��*������*��&�������� �����������

[ ������������������ &�����������"������

�( �����������*��"� ��� [ �*������*��"� ����-�� � *���?��������������&��� [ �����������*��"� ���

Page 131: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� � �5/�'6 ���)�=�������"/����4����/��� �>

������� *�����- '()

J&6�"I���K�& �"���� $���L�������/���!���/$��"�� ��" !�'

32.3A

19.0A

16.1A 260 consecutive sec.

5 consecutive sec.

P4L1 L4U2 P1 PJ E5 L9

L5 L8

LC

L5

L8

L8

Inverter compressor lock(Compressor does not run at all.)

PC board mismatchingWhen incorrect inverter PC board is connected

Imbalanced power supply voltageWhen imbalance in voltages among three phases comes to 2% or more

Transmission errorWhen transmissions between the main PC board and the inverter PC board are not normal

When the radiator fin temperature reached 93°C or more

When the power supply voltage falls out of the range of 400VAC±10% When the fin thermistor resistor detects

an open circuit (-30°C or less) or a short circuit (120°C or more)

When the heavy current part of inverter gets faulty (gives no output)

Instantaneous overcurrent of inverter compressor(When inverter output current exceeds 32.3A even instantaneously)

1An overcurrent of 19.0A or more continues for a period of 5 consecutive seconds2An overcurrent of 16.1A or more continues for a period of 260 consecutive seconds.

Faulty startup of inverter compressor(Compressor stops running immediately after it starts up.)

Weak-current part

Inverter PC board

Heavy-current part (Power

transmission etc.)

Power supply (3 phase, 400VAC)

Main (Control) PC board

Radiator fin temperature rise

Faulty fin thermistor

Power supply voltage error

Faulty inverter

Overcurrent of inverter compressor

Com

pres

sor

Time

Compressor overcurrent(Electronic thermal 1)

Malfunction codes related to compressor current Instantaneous

overcurrent

Compressor overcurrent(Electronic thermal 2)

Max. control

Cur

rent

Page 132: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

� �5/�'6 ���)�=�������"/����4����/��� �> ����������

'(2 ������� *�����-

Page 133: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

�&&����� '(+

����%����+�,

�� ��&��-�>��-��" ����������������������������������������������������������������������������������'(/��� $�������%��� �����������������������������������������������������������������������������������������'(/��� �������%�����������������������������������������������������������������������������������������������')'

�� 7����-�>��-��" �����������������������������������������������������������������������')+��� $�������%��� �����������������������������������������������������������������������������������������')+��� ������7����- ������������������������������������������������������������������������������������������'2���' �������%�����������������������������������������������������������������������������������������������'2'

'� 3� ���������������������������������� �������������������������������������������������'/�'�� $�������%��� �����������������������������������������������������������������������������������������'/�'�� ����������� �������������������������������������������������������������������������������������������'/2

(� $&�����3� � �������������������������������������������������������������������������������������������'<�(�� $&�����3� ������������� ����������������������������������������������������������������������'<�(�� $&�����3� � �:$�������%���;�������������������������������������������������������������������'<(

)� ���"&���������������:�?(�,����&�; ����������������������������������������������'<)2� �*��"� ������ � ������#���"&��������*�������� ��� ������������������������'<<+� ��� ������� �� ���������������������������������������������������������������������������������(,�/� ��*�����*��8��-��*����������G ���5������� � ��� �����>����� ����� ������������������������������������������������������������������������������������(,�/�� ��*�����*��8��-��*����������G ���5������� � ��� �����

>����� ����� �������������������������������������������������������������������������������������(,�

Page 134: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�����)�B��)���' ����������

'(/ �&&�����

�# �����)�B��)���'�#� 1��! ��*���� �����

3D05

9203

Capi

llary

tu

be

Filte

r

Pres

sure

regu

latin

g va

lve

(abs

olut

e pr

essu

re ty

pe)

Elec

troni

cex

pans

ion

valv

e

Heat

exch

ange

r

Chec

kva

lve

Stra

iner

HPS CO

MPR

ESSO

RIN

V

SENP

L

High

pres

sure

switc

h

Low

pres

sure

sens

or

Sole

noid

valv

e

Capi

llary

tu

be

Filte

r

Filte

r

Sole

noid

valv

e

Filte

rStop

val

ve (w

ith s

ervi

ce p

ort �

7.9

mm

flar

e co

nnec

tion

SV

SENPH

Sole

noid

valv

e

Sole

noid

valv

e

Sole

noid

valv

e

SV

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

OIL

SEPE

RATO

R

Sole

noid

valv

eCa

pilla

ry

tube

Chec

kva

lve

Chec

kva

lve

Elec

troni

cex

pans

ion

valv

e

High

pres

sure

sens

orPr

essu

rere

gula

ting

valv

e(C

heck

val

ve ty

pe)

Stra

iner

Liqu

idpi

pe

Equa

lizer

pipe

Gas

pipe

Caug

epo

rt

Refri

gera

ntre

gula

tor

Capi

llary

tu

be

Chec

k va

lve

Four

way

val

ve

Four

way

val

ve

Serv

ice

port

Elec

troni

cex

pans

ion

valv

e

SV

SV

SV

SV

Page 135: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �����)�B��)���'

�&&����� '(<

� �������

3D05

9204

Capi

llary

tu

be

Filte

r

Pres

sure

regu

latin

g va

lve

(abs

olut

e pr

essu

re ty

pe)

Elec

troni

cex

pans

ion

valv

e

Heat

exch

ange

r

Chec

kva

lve

Stra

iner

HPS CO

MPR

ESSO

RIN

V

SENP

L

High

pres

sure

switc

h

Low

pres

sure

sens

or

Sole

noid

valv

e

Capi

llary

tu

be

Filte

r

Filte

rSole

noid

valv

e

Filte

rStop

val

ve (w

ith s

ervi

ce p

ort �

7.9

mm

flar

e co

nnec

tion

SV

SENPH

Sole

noid

valv

e

Sole

noid

valv

e

Sole

noid

valv

e

SV

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

OIL

SEPE

RATO

R

Sole

noid

valv

eCa

pilla

ry

tube

Chec

kva

lve

Chec

kva

lve

Elec

troni

cex

pans

ion

valv

e

High

pres

sure

sens

orPr

essu

rere

gula

ting

valv

e(C

heck

val

ve ty

pe)

Stra

iner

Liqu

idpi

pe Gas

pipe

Caug

epo

rt

Refri

gera

ntre

gula

tor

Capi

llary

tu

be

Chec

k va

lve

Four

way

val

ve

Four

way

val

ve

Serv

ice

port

Elec

troni

cex

pans

ion

valv

e

SV

SV

SV

SV

COM

PRES

SOR

STD

1Ca

pilla

ry

tube

High

pres

sure

switc

h

OIL

SEPE

RATO

R

Filte

r

Chec

kva

lve

HPS

Filte

r

Page 136: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�����)�B��)���' ����������

'), �&&�����

� �������

3D05

9205

Capi

llary

tu

be

Filte

r

Pres

sure

regu

latin

g va

lve

(abs

olut

e pr

essu

re ty

pe)

Elec

troni

cex

pans

ion

valv

e

Heat

exch

ange

r

Chec

kva

lve

Stra

iner

HPS CO

MPR

ESSO

RIN

V

SENP

L

High

pres

sure

switc

h

Low

pres

sure

sens

or

Sole

noid

valv

e

Capi

llary

tu

be

Filte

r

Filte

r

Sole

noid

valv

e

Filte

rStop

val

ve (w

ith s

ervi

ce p

ort �

7.9

mm

flar

e co

nnec

tion

SV

SENPH

Sole

noid

valv

e

Sole

noid

valv

e

Sole

noid

valv

e

SV

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

OIL

SEPE

RATO

R

Sole

noid

valv

eCa

pilla

ry

tube

Chec

kva

lve

Chec

kva

lve

Elec

troni

cex

pans

ion

valv

e

High

pres

sure

sens

orPr

essu

rere

gula

ting

valv

e(C

heck

val

ve ty

pe)

Stra

iner

Liqu

idpi

pe Gas

pipe

Caug

epo

rt

Refri

gera

ntre

gula

tor

Capi

llary

tu

be

Chec

k va

lve

Four

way

val

ve

Four

way

val

ve

Serv

ice

port

Elec

troni

cex

pans

ion

valv

e

SV

SV

SV

SV

COM

PRES

SOR

STD

1Ca

pilla

ry

tube

High

pres

sure

switc

h

OIL

SEPE

RATO

R

Filte

r

Chec

kva

lve

HPS

Filte

r

Equa

lizer

pipe

Page 137: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �����)�B��)���'

�&&����� ')�

� �������D��;���

3D05

9206

A

Capi

llary

tu

be

Filte

r

Pres

sure

regu

latin

g va

lve

(abs

olut

e pr

essu

re ty

pe)

Elec

troni

cex

pans

ion

valv

e

Heat

exch

ange

r

Chec

kva

lve

Stra

iner

HPS CO

MPR

ESSO

RIN

V

SENP

L

High

pres

sure

switc

h

Low

pres

sure

sens

or

Sole

noid

valv

e

Capi

llary

tu

be

Filte

rFi

lterSo

leno

idva

lve

Filte

rStop

val

ve (w

ith s

ervi

ce p

ort �

7.9

mm

flar

e co

nnec

tion

SV

SENPH

Sole

noid

valv

e

Sole

noid

valv

e

Sole

noid

valv

e

SV

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

Filte

r

OIL

SEPE

RATO

R

Sole

noid

valv

e

Capi

llary

tu

be

Chec

kva

lve

Chec

kva

lve

Elec

troni

cex

pans

ion

valv

e

High

pres

sure

sens

orPr

essu

rere

gula

ting

valv

e(C

heck

val

ve ty

pe)

Stra

iner

Liqu

idpi

pe Gas

pipe

Caug

epo

rt

Refri

gera

ntre

gula

tor

Capi

llary

tu

beChec

k va

lve

Four

way

val

ve

Four

way

val

ve

Serv

ice

port

Elec

troni

cex

pans

ion

valv

e

SV

SV

SV

SV

COM

PRES

SOR

STD

1Ca

pilla

ry

tube

High

pres

sure

switc

h

OIL

SEPE

RATO

R

Filte

r

Chec

kva

lve

HPS

Filte

r

Chec

kva

lve

Filte

r

OIL

SEPE

RATO

R

HPS

Filte

rHi

ghpr

essu

resw

itch CO

MPR

ESSO

RST

D 2

Capi

llary

tu

be

Page 138: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�����)�B��)���' ����������

')� �&&�����

� �������

3D05

9154

Capi

llary

tu

be

Elec

troni

cex

pans

ion

valv

e

To

outd

oor u

nit

Chec

kva

lve

COM

PRES

SOR

INV

High

pres

sure

switc

h

Sole

noid

valv

e

Filte

r

Sole

noid

valv

e

Filte

r

Sole

noid

valv

e

Sole

noid

valv

e

SP

Filte

r

Filte

r

Filte

r

Filte

r

Sole

noid

valv

e

Capi

llary

tu

be

Chec

kva

lve

Chec

kva

lve

Stra

iner

Chec

kva

lve

Serv

ice

port

Elec

troni

cex

pans

ion

valv

e

SV

SV

High

pres

sure

switc

h

Chec

kva

lve

Filte

r

Chec

kva

lve

OIL

SEPE

RATO

R

HPS

Elec

troni

cex

pans

ion

valv

e

Chec

kva

lve

Accu

mul

ator

Gas

side

pip

ing

conn

ectio

n(B

razin

g co

nnec

tion)

To

indo

or u

nit

Liqu

id s

ide

pipi

ng

conn

ectio

n(B

razin

g co

nnec

tion)

SV SV

Gas

side

pip

ing

conn

ectio

n(B

razin

gco

nnec

tion)

Liqu

id s

ide

pipi

ng

conn

ectio

n(B

razin

gco

nnec

tion)

Serv

ice

port

Page 139: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �����)�B��)���'

�&&����� ')'

�#� ��! ��*���,?&�D�,?,�D�,?C�D�,?��D�,?.�D�,?��D�,?-�D�,?+�D�,?��

DU220-602J

Heat exchanger

Electronicexpansion valve

FilterFilter

Gas piping connection port

(Flare connection

Liquid piping connection port

(Flare connection)

(1)

M

Th2

Th1

Th3

Th1: Thermistor for sunction air temp.Th2: Thermistor for liquid line temp.Th3: Thermistor for gas line temp.

��� !�"� ��� �����������

:�; �������������&�� ��������� 0��% ������-� � �&��*��������-������������5*�������������-��&����������� �����������-������������5*�������*�����-��&��������

:�; ��������������"&���������*��"� ��� ��� % �������*��"� ������������

:'; 3�B����&�&� ���% ������-� � �&��*��������-������������5*�������������-��&����������� �����������-������������5*�������*�����-��&��������

:(; 6� �&�&� �'� % ������-� � �&��*��������-������������5*�������������-��&��������

:"";�&����� 6�� 3�B���

�,�#��)�#�'��#�(,�#�), :�; φ���+ φ2�(2'�#�/,�#��,,�#���) :�; φ�)�< φ<�)

�,, :�; φ�<�� φ<�)�), :�; φ���� φ<�)

Page 140: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�����)�B��)���' ����������

')( �&&�����

,?��

� ��$��)�����������" ���"�� ��� ���!�������'

DU220-602J

Heat exchanger

Electronicexpansion valve

FilterFilter

Gas piping connection port

(Flare connection

Liquid piping connection port

(Flare connection)

(1)

M

Th2

Th1

Th3

Th1: Thermistor for sunction air temp.Th2: Thermistor for liquid line temp.Th3: Thermistor for gas line temp.

:""; ���� 6� 3�B���

�JN.�, �#��) �#�'� �#�(, �#�), φ���+ φ2�(

Page 141: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �����)�B��)���'

�&&����� '))

,?B�

� ��$��)�����������" ���"�� ��� ���!�������'

,?.����.,�0����.,�0����.,4�

� ��$��)�����������" ���"�� ��� ���!�������'

4D043864H

Gas side

Liquid side

Electronic expansion valve

FilterFilter

Fan

Indoor heat exchanger

:""; ���� 6� 3�B���

�J>.�,!:�;1���#��)!:�;1���#�'�!:�;1���#�(,!:�;�#�),!:�;=�:�; φ���+ φ2�(

�J>.2'!:�;=�:�; φ�)�< φ<�)

4D018650B

Th4

Th3

Th2

Th1

A

B

C

Heat exchanger

Distributeur

Filter Filter

Filter

Capillary tube

Liquid pipe connection port

Gas pipe connection port

Solenoidvalve

Check valve

Electronicexpansion valve

Fan

:""; ���� 6� 3�B���

�J .��) �=� φ�)�< φ<�)�J .�,, �=� φ�<�� φ<�)�J .�), �=� φ���� φ<�)

Page 142: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�����)�B��)���' ����������

')2 �&&�����

,?*��<���4�

��! ������

& ���"�� ��*���

4D037995F

Indoor heat exchanger

Field piping �9.5 C1220T-0

Field piping �15.9 C1220T-0Filter

Indoor unit

To outdoor unit

4D034127B

Liquid pipe connection port

Liquid pipe connection port

Gas piping connection port

Gas piping connection port

Electronicexpansion valve

Filter Filter

Page 143: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� ')+

�# (����)�B��)���'�$ ����$����"��#� 1��! ��*���� �����

3D06

0116

Prin

ted

circ

uit b

oard

(Mai

n)P

rinte

d ci

rcui

t boa

rd (S

ub)

Prin

ted

circ

uit b

oard

(Noi

se fi

lter)

Prin

ted

circ

uit b

oard

(IN

V)

Prin

ted

circ

uit b

oard

(FA

N)

Pus

h bu

tton

switc

h(M

ode,

set

, ret

urn,

test

, res

et)

Cap

acito

rC

apac

itor

Cra

nkca

se h

eate

rE

l, co

mbo

, box

, hea

ter

Fuse

(T, 3

.15A

, 250

V) (

A1P

)Fu

se (T

, 3.1

5A, 2

50V

) (A

2P)

Fuse

(T, 6

.3A

, 250

V)

Pilo

tlam

p (S

ervi

ce m

onito

r-or

ange

)[H

2P] P

repa

re, t

est -

----

--Fl

icke

ring

Mal

func

tion

dete

ctio

n---

-Lig

ht u

pP

ilotla

mp

(Ser

vice

mon

itor-

gree

n)M

agne

tic re

lay

Mag

netic

con

tact

or (M

1C)

Mag

netic

rela

yM

agne

tic c

onta

ctor

(M1C

)M

agne

tic re

lay

(E4H

C)

Mag

netic

rela

y (Y

6S)

Mag

netic

rela

y (Y

1S) (

A1P

)M

agne

tic re

lay

(Y8S

) (A

2P)

Mag

netic

rela

y (Y

2S)

Mag

netic

rela

y (Y

3S) (

A1P

)M

agne

tic re

lay

(Y5S

) (A

2P)

Mag

netic

rela

y (Y

7S)

Mag

netic

rela

y (E

1HC

)M

agne

tic re

lay

(Y4S

)R

eact

orM

otor

(Com

pres

sor)

Mot

or (F

an)

Sw

itchi

ng p

ower

sup

ply

(A1P

,A3P

)P

hase

reve

rsal

det

ect c

ircui

t (A

1P)

Res

isto

r (C

urre

nt s

enso

r)R

esis

tor

Term

inal

stri

p (P

ower

sup

ply)

Term

inal

stri

p (C

ontro

l) (A

1P)

Ele

ctro

nic

expa

nsio

n va

lve

(Mai

n)El

ectro

nic

expa

nsio

n va

lve

(Cha

rge)

Elec

troni

c ex

pans

ion

valv

e (S

ubco

ol)

Sol

enoi

d va

lve

(RM

TG)

Sol

enoi

d va

lve

(4 w

ay v

alve

) (pi

pe)

Solen

oid va

lve (4

way

valve

) (H

eat e

xc.)

Sol

enoi

d va

lve

(RM

TI)

Sol

enoi

d va

lve

(Hot

gas

)S

olen

oid

valv

e (E

V b

ypas

s)S

olen

oid

valv

e (R

MTO

)S

olen

oid

valv

e (R

MTT

)N

oise

filte

r (Fe

rrite

cor

e)N

oise

filte

r (W

ith s

urge

abs

orbe

r)

A1P

A2P

A3P

A4P

A5P

BS

1~5

C1

C63

,C66

E1H

CE

4HC

F1U

,F2U

F1U

F1U

F400

UH

1P~8

P

HA

PK

1

K2

K3

K4

K1R

K2R

K3R

K3R

K4R

K5R

K5R

K6R

K7R

K11

RL1

RM

1CM

1FP

SQ

1RP

R10

R50

,

X1M

X1M

Y1E

Y2E

Y1S

Y2S

Y3S

Y4S

Y5S

Y6S

Y7S

Y8S

Z1C~

6CZ1

F

Res

isto

r (C

urre

nt li

miti

ng)

Res

isto

r (C

urre

nt li

miti

ng)

Ther

mis

tor (

Air)

(A1P

)Th

erm

isto

r (Fi

n) (A

4P)

Ther

mis

tor (

Hea

t exc

. gas

)Th

erm

isto

r (M

1C d

isch

arge

)Th

erm

isto

r (H

rat e

xc. d

eice

r)Th

erm

isto

r (S

ub c

ool h

eat e

xc. g

as)

Ther

mis

tor (

Sub

coo

l hea

t exc

. gas

)Th

erm

isto

r (H

eat e

xc. l

iqui

d)Th

erm

isto

r (S

uctio

n)Th

erm

isto

r (Li

quid

)P

ress

ure

sens

or (h

igh)

Pre

ssur

e se

nsor

(low

)P

ress

ure

switc

h (h

igh)

Saf

ety

devi

ces

inpu

tD

iode

brid

ge (A

4P)

Pow

er m

odul

e (A

5P)

Pow

er m

odul

eC

onne

ctor

(M1F

)

R90

R95

R1T

R1T

R2T

R31

TR

4TR

5TR

6TR

7TR

8TR

9TS

1NP

HS

1NP

LS

1PH

3V

1CP

V1R

V1R

V2R

X1A

~4A

Con

nect

or fo

r op

tiona

l par

tsP

ower

sup

ply

(ada

pter

) (A

2P)

X9A

NO

TE)5

Out

door

(F1)

(F2)

Out

door

(Q1)

(Q2)

Is c

onne

ctor

col

or fo

r prin

ted

circ

uit b

oard

.Is

con

nect

or c

olor

for c

ompo

nent

.Is

dis

crim

inat

ion

colo

r for

com

pone

nt le

ad w

ire.

(BA

CK

)

(FR

ON

T)

EL.

CO

MP

O.B

OX

PO

WE

R S

UP

PLY

3N ~

380

-415

V

50H

z

TER

MIN

AL

OF

M1C

Indo

or (F

1) (F

2)

Not

es1.

Thi

s w

iring

dia

gram

is a

pplie

d on

ly to

the

outd

oor u

nit.

2.

: Fie

ld w

iring

.3.

: T

erm

inal

stri

p,

: Con

nect

or

:Ter

min

al

:Pro

tect

ive

earth

(scr

ew)

4. W

hen

usin

g th

e op

tiona

l ada

pter

, ref

er to

the

inst

alla

tion

man

ual o

f the

opt

iona

l ada

pter

.5.

For

con

nect

ion

wiri

ng to

indo

or-o

utdo

or tr

ansm

issi

on F

1 • F

2, o

utdo

or-o

utdo

or tr

ansm

issi

on F

1 • F

2, O

utdo

or-M

ulti

trans

mis

sion

Q1

• Q2

, re

fer t

o th

e in

stal

latio

n m

anua

l.6.

How

to u

se B

S1~

5, re

fer t

o “s

ervi

ce p

reca

utio

n” la

bel o

n E

L. C

OM

PO

. BO

X C

OV

ER

.7.

Whe

n op

erat

ing,

don

’t sh

ortc

ircui

t the

pro

tect

ion

devi

ce (S

1PH

).8.

Col

ors

(BLK

: Bla

ck, R

ED

: red

, BLU

: blu

e, W

HT:

whi

te, G

RN

: gre

en.

Page 144: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

')/ �&&�����

� �������D������

3D06

0117

Prin

ted

circu

it bo

ard

(Main

)Pr

inte

d cir

cuit

boar

d (S

ub)

Prin

ted

circu

it bo

ard

(Noi

se fi

lter)

Prin

ted

circu

it bo

ard

(INV)

Prin

ted

circu

it bo

ard

(FAN

)Pr

inte

d cir

cuit

boar

d (C

urre

nt s

enso

r)Pu

sh b

utto

n sw

itch

(Mod

e, s

et, r

etur

n, te

st, r

eset

)Ca

pacit

orCa

pacit

orCr

ankc

ase

heat

erEl

, com

bo, b

ox, h

eate

rFu

se (T

, 3.1

5A, 2

50V)

(A1P

)Fu

se (T

, 3.1

5A, 2

50V)

(A2P

)Fu

se (T

, 8A,

DC6

50V)

(A5P

)Fu

se (T

, 6.3

A, 2

50V)

(A3P

)Pi

lotla

mp

(Ser

vice

mon

itor-o

rang

e)[H

2P] P

repa

re, t

est -

------

Flick

erin

g M

alfun

ctio

n de

tect

ion-

---Li

ght u

pPil

otlam

p (Se

rv. m

onito

r-gree

n)(A

1P)(A

2P)

Mag

netic

relay

Mag

netic

con

tact

or (M

1C)

Mag

netic

relay

Mag

netic

con

tact

or (M

1C)

Mag

netic

con

tact

or (M

2C)

Mag

netic

relay

(K2M

),(A1

P)M

agne

tic re

lay (E

4HC)

,(A2P

)M

agne

tic re

lay (Y

6S)

Mag

netic

relay

(Y1S

) (A1

P)M

agne

tic re

lay (Y

8S) (

A2P)

Mag

netic

relay

(Y2S

)M

agne

tic re

lay (Y

3S) (

A1P)

Mag

netic

relay

(Y5S

) (A2

P)M

agne

tic re

lay (Y

7S)

Mag

netic

relay

(E1H

C)M

agne

tic re

lay (E

2HC)

Mag

netic

relay

(Y4S

)Re

acto

rM

otor

(Com

pres

sor)

Mot

or (F

an)

Switc

hing

powe

r sup

ply (A

1P,A

3P)

Phas

e rev

ersa

l dete

ct cir

cuit

(A1P

)

Powe

r mod

ule

Conn

ecto

r (M

1F)

Term

inal

strip

(Pow

er s

uppl

y)Te

rmin

al st

rip (C

ontro

l) (A

1P)

Elec

troni

c ex

pans

ion

valve

(Main

)Ele

ctron

ic ex

pans

ion va

lve (C

harg

e)Ele

ctron

ic ex

pans

ion va

lve (S

ubco

ol)So

lenoi

d va

lve (R

MTG

)So

lenoid

valve

(4 w

ay va

lve) (

pipe)

Solen

oid va

lve (4

way

valve

) (He

at ex

c.)So

lenoi

d va

lve (R

MTI

)So

lenoi

d va

lve (H

ot g

as)

Solen

oid

valve

(EV

bypa

ss)

Solen

oid

valve

(RM

TO)

Solen

oid

valve

(RM

TT)

Noise

filte

r (Fe

rrite

cor

e)No

ise fi

lter (

With

sur

ge a

bsor

ber)

A1P

A2P

A3P

A4P

A5P

A6P

BS1~

5

C1 C63,

C66

E1HC

,E2HC

E4HC

F1U,

F2U

F1U

F1U

F400

UH1

P~8P

HAP

K1

K2 K3 K4 K2M

K1R

K1R

K2R

K3R

K3R

K4R

K5R

K5R

K6R

K7R

K8R

L11R

L1R

M1C

,M2C

M1F

PS Q1RP

V2R

X1A~

X2A

X1M

X1M

Y1E

Y2E

Y3E

Y1S

Y2S

Y3S

Y4S

Y5S

Y6S

Y7S

Y8S

Z1C~

8CZ1

F

Resis

tor (

Curre

nt s

enso

r)Re

sisto

rRe

sisto

r (Cu

rrent

sen

sor)

Resis

tor (

Curre

nt li

miti

ng)

Ther

mist

or (A

ir) (A

1P)

Ther

mist

or (F

in) (

A4P)

Ther

mist

or (H

eat e

xc. g

as)

Ther

mist

or (M

1C d

ischa

rge)

Ther

mist

or (H

rat e

xc. d

eicer

)Th

erm

istor

(Sub

cool

heat

exc.

gas)

Ther

mist

or (S

ub co

ol he

at ex

c. ga

s)Th

erm

istor

(Hea

t exc

. liq

uid)

Ther

mist

or (S

uctio

n)Th

erm

istor

(Liq

uid)

Pres

sure

sen

sor (

high

)Pr

essu

re s

enso

r (lo

w)Pr

essu

re s

witc

h (h

igh)

Curre

nt s

enso

rSa

fety

dev

ices

inpu

tDi

ode

brid

ge (A

4P)

Powe

r mod

ule

(A5P

)

R10

R50,

R59

R90

R95

R1T

R1T

R2T

R31T

,R32

TR4

TR5

TR6

TR7

TR8

TR9

TS1

NPH

S1NP

LS1

PH,S2

PHT1

AV1

CPV1

RV1

R

Con

nect

or fo

r op

tiona

l par

tsPo

wer s

uppl

y (a

dapt

er) (

A2P)

X9A

NO

TE)5

Out

door

(F1)

(F2)

Out

door

(Q1)

(Q2)

Is c

onne

ctor

col

or fo

r prin

ted

circ

uit b

oard

.Is

con

nect

or c

olor

for c

ompo

nent

.Is

disc

rimin

atio

n co

lor f

or c

ompo

nent

lead

wire

.

(BA

CK

)

(FR

ON

T)

EL.

CO

MP

O.B

OX

PO

WE

R S

UP

PLY

3N ~

380

-415

V

50H

z

TER

MIN

AL

OF

M1C

, M2C

Indo

or (F

1) (F

2)

Not

es1.

Thi

s w

iring

dia

gram

is a

pplie

d on

ly to

the

outd

oor u

nit.

2.

: Fie

ld w

iring

.3.

: T

erm

inal

stri

p,

: Con

nect

or

:Ter

min

al

:Pro

tect

ive

earth

(scr

ew)

4. W

hen

usin

g th

e op

tiona

l ada

pter

, ref

er to

the

inst

alla

tion

man

ual o

f the

opt

iona

l ada

pter

.5.

For

con

nect

ion

wiri

ng to

indo

or-o

utdo

or tr

ansm

issi

on F

1 • F

2, o

utdo

or-o

utdo

or tr

ansm

issi

on F

1 • F

2, O

utdo

or-M

ulti

trans

mis

sion

Q1

• Q

2 , r

efer

to th

e in

stal

latio

n m

anua

l.6.

How

to u

se B

S1~

5 an

d D

S1~

3 sw

itch,

refe

r to

“ser

vice

pre

caut

ion”

labe

l on

EL.

CO

MP

O. B

OX

CO

VE

R.

7. W

hen

oper

atin

g, d

on’t

shor

tcirc

uit t

he p

rote

ctio

n de

vice

(S1P

H~S

2PH

).8.

Col

ors

(BLK

: Bla

ck, R

ED

: red

, BLU

: blu

e, W

HT:

whi

te, G

RN

: gre

en.

EL.

CO

MP

O.B

OX

LAY

OU

T O

F M

1C, M

2C, M

1F

OU

TER

SH

ELL

Page 145: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� ')<

� �������D��;���

3D06

0118

Prin

ted

circu

it bo

ard

(Main

)Pr

inte

d cir

cuit

boar

d (S

ub)

Prin

ted

circu

it bo

ard

(Noi

se fi

lter)

Prin

ted

circu

it bo

ard

(INV)

Prin

ted

circu

it bo

ard

(FAN

)Pr

inte

d cir

cuit

boar

d (C

urre

nt s

enso

r)Pu

sh b

utto

n sw

itch

(Mod

e, s

et, r

etur

n, te

st, r

eset

)Ca

pacit

orCa

pacit

orCr

ankc

ase

heat

erEl

, com

bo, b

ox, h

eate

rFu

se (T

, 3.1

5A, 2

50V)

(A1P

)Fu

se (T

, 3.1

5A, 2

50V)

(A2P

)Fu

se (T

, 8A,

DC6

50V)

(A5P

, A7P

)Fu

se (T

, 6.3

A, 2

50V)

(A3P

)Pi

lotla

mp

(Ser

vice

mon

itor-o

rang

e)[H

2P] P

repa

re, t

est -

------

Flick

erin

g M

alfun

ctio

n de

tect

ion-

---Li

ght u

pPil

otlam

p (Se

rv. m

onito

r-gree

n)(A

1P)(A

2P)

Mag

netic

relay

Mag

netic

con

tact

or (M

1C)

Mag

netic

relay

Mag

netic

con

tact

or (M

1C)

Mag

netic

con

tact

or (M

2C,M

3C)

Mag

netic

relay

(K2M

,K3M

),(A1

P)M

agne

tic re

lay (E

4HC)

,(A2P

)M

agne

tic re

lay (Y

6S) (

A2P)

Mag

netic

relay

(Y1S

) (A1

P)M

agne

tic re

lay (Y

8S) (

A2P)

Mag

netic

relay

(Y2S

)M

agne

tic re

lay (Y

3S) (

A1P)

Mag

netic

relay

(Y5S

) (A2

P)M

agne

tic re

lay (Y

7S)

Mag

netic

relay

(E1H

C)M

agne

tic re

lay (E

2HC)

Mag

netic

relay

(E3H

C)M

agne

tic re

lay (Y

4S)

Reac

tor

Mot

or (C

ompr

esso

r)M

otor

(Fan

)Sw

itchin

g po

wer s

upply

(A1P

,A4P

)

Powe

r mod

ule

(A5P

,A8P

)Po

wer m

odul

eCo

nnec

tor (

M1F

,M2F

)Te

rmin

al st

rip (P

ower

sup

ply)

Term

inal

strip

(Con

trol)

(A1P

)El

ectro

nic

expa

nsio

n va

lve (M

ain)

Electr

onic

expa

nsion

valve

(Cha

rge)

Electr

onic

expa

nsion

valve

(Sub

cool)

Solen

oid

valve

(RM

TG)

Solen

oid va

lve (4

way

valve

) (pip

e)So

lenoid

valve

(4 w

ay va

lve) (

Heat

exc.)

Solen

oid

valve

(RM

TI)

Solen

oid

valve

(Hot

gas

)So

lenoi

d va

lve (E

V by

pass

)So

lenoi

d va

lve (R

MTO

)So

lenoi

d va

lve (R

MTT

)No

ise fi

lter (

Ferri

te c

ore)

Noise

filte

r (W

ith s

urge

abs

orbe

r)

A1P

A2P

A3P

A4P

A5P,

A8P

A6P,

A7P

BS1~

5

C1 C63,

C66

E1HC

,E2HC

E4HC

F1U,

F2U

F1U

F1U

F400

UH1

P~8P

HAP

K1

K2 K3 K4 K2M

,K3M

K1R,

K2R

K1R

K2R

K3R

K3R

K4R

K5R

K5R

K6R

K7R

K8R

K9R

K11R

L1R

M1C

,M3C

M1F

,M2F

PS

V1R

V2R

X1A~

4AX1

MX1

MY1

EY2

EY3

EY1

SY2

SY3

SY4

SY5

SY6

SY7

SY8

SZ1

C~10

CZ1

F

Phas

e re

vers

al de

tect

circ

uit

Resis

tor (

Curre

nt s

enso

r) (A

5P,A

7P)

Resis

tor

Resis

tor (

Curre

nt s

enso

r)Re

sisto

r (Cu

rrent

lim

iting

)Th

erm

istor

(Air)

(A1P

)Th

erm

istor

(Fin

) (A4

P)Th

erm

istor

(Hea

t exc

. gas

)Th

erm

istor

(M1C

~3C d

ischa

rge)

Ther

mist

or (H

rat e

xc. d

eicer

)Th

erm

istor

(Sub

cool

heat

exc.

gas)

Ther

mist

or (S

ub co

ol he

at ex

c. liq

uid)

Ther

mist

or (H

eat e

xc. l

iqui

d)Th

erm

istor

(Suc

tion)

Ther

mist

or (L

iqui

d)Pr

essu

re s

enso

r (hi

gh)

Pres

sure

sen

sor (

low)

Pres

sure

swi

tch

(hig

h)Cu

rrent

sen

sor

Safe

ty d

evice

s in

put

Diod

e br

idge

(A4P

)

Q1RP

R10

R50,

R59

R90

R95

R1T

R1T

R2T

R31T

~R33

TR4

TR5

TR6

TR7

TR8

TR9

TS1

NPH

S2NP

LS1

PH,S3

PHT1

AV1

CPV1

RC

onne

ctor

for

optio

nal p

arts

Powe

r sup

ply

(ada

pter

) (A2

P)X9

A

NO

TE)5

Out

door

(F1)

(F2)

Out

door

(Q1)

(Q2)

Is c

onne

ctor

col

or fo

r prin

ted

circ

uit b

oard

.Is

con

nect

or c

olor

for c

ompo

nent

.Is

disc

rimin

atio

n co

lor f

or c

ompo

nent

lead

wire

.

(BA

CK

)

(FR

ON

T)

EL.

CO

MP

O.B

OX

PO

WE

R S

UP

PLY

3N ~

380

-415

V

50H

z

TER

MIN

AL

OF

M1C

~M

3C

Indo

or (F

1) (F

2)

Not

es1.

Thi

s w

iring

dia

gram

is a

pplie

d on

ly to

the

outd

oor u

nit.

2.

: Fie

ld w

iring

.3.

: T

erm

inal

stri

p,

: Con

nect

or

:Ter

min

al

:Pro

tect

ive

earth

(scr

ew)

4. W

hen

usin

g th

e op

tiona

l ada

pter

, ref

er to

the

inst

alla

tion

man

ual o

f the

opt

iona

l ada

pter

.5.

For

con

nect

ion

wiri

ng to

indo

or-o

utdo

or tr

ansm

issi

on F

1 • F

2, o

utdo

or-o

utdo

or tr

ansm

issi

on F

1 • F

2,

Out

door

-Mul

ti tra

nsm

issi

on Q

1 • Q

2 , r

efer

to th

e in

stal

latio

n m

anua

l.6.

How

to u

se B

S1~

5, re

fer t

o “s

ervi

ce p

reca

utio

n” la

bel o

n E

L. C

OM

PO

. BO

X C

OV

ER

.7.

Whe

n op

erat

ing,

don

’t sh

ortc

ircui

t the

pro

tect

ion

devi

ce (S

1~S

3PH

).8.

Col

ors

(BLK

: Bla

ck, R

ED

: red

, BLU

: blu

e, W

HT:

whi

te, G

RN

: gre

en.

EL.

CO

MP

O.B

OX

LAY

OU

T O

F M

1C, M

2C, M

1F

OU

TER

SH

ELL

Page 146: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'2, �&&�����

� �������

3D06

0119

Prin

ted

circu

it bo

ard

(Main

)Pr

inte

d cir

cuit

boar

d (N

oise

filte

r)Pr

inte

d cir

cuit

boar

d (IN

V)Pu

sh b

utto

n sw

itch

(Mod

e, s

et, r

etur

n, te

st, r

eset

)Ca

pacit

orCr

ankc

ase

heat

erEl

com

po b

ox h

eate

rFu

se (T

, 3.1

5A, 2

50V)

Fuse

(T, 6

.3A,

250

V)Pi

lotla

mp

(Ser

vice

mon

itor-o

rang

e)[H

2P] P

repa

re, t

est -

------

Flick

erin

g M

alfun

ctio

n de

tect

ion-

---Li

ght u

pPi

lot l

amp

(Sev

ice m

onito

r: Gr

een)

Mag

netic

relay

Mag

netic

con

tact

orM

agne

tic re

lay (Y

1S)

Mag

netic

relay

(Y2S

)

Mag

netic

relay

(Y5S

)M

agne

tic re

lay (E

1HC)

Mag

netic

con

tact

or (Y

3S)

Mag

netic

con

tact

or (E

2HC)

Mag

netic

relay

(M1F

)M

agne

tic re

lay (Y

4S)

Reac

tor

Mot

or (C

ompr

esso

r)M

otor

(Coo

ling

Fan)

Switc

hing

powe

r sup

ply (A

1P,A

3P)

Phas

e rev

ersa

l dete

ct cir

cuit

(A1P

)Re

sisto

rRe

sisto

r (Cu

rrent

sen

sor)

Resis

tor (

Curre

nt li

miti

ng)

Ther

mist

or (F

in)

Ther

mist

or (M

1C d

ischa

rge)

Ther

mist

or (l

iqui

d)Pr

essu

re s

enso

r (hi

gh)

Pres

sure

swi

tch

(hig

h)Sa

fety

dev

ices

inpu

tDi

ode

brid

gePo

wer m

odul

eTe

rmin

al st

rip (P

ower

sup

ply)

Term

inal

strip

(Con

trol)

(A1P

)El

ectro

nic

expa

nsio

n va

lve (L

iqui

d in

jectio

n)Ele

ctron

ic ex

pans

ion va

lve (C

hang

e mod

e)Ele

ctron

ic ex

pans

ion va

lve (C

hang

e mod

e)So

lenoi

d va

lve (H

ot g

as)

Solen

oid va

lve (R

educ

tion)

Solen

oid va

lve (B

ypas

s)So

lenoi

d va

lve (B

ypas

s)So

lenoi

d va

lve (C

hang

e liq

uid

line)

Solen

oid

valve

(Fer

rite

core

)No

ise fi

lter (

With

sur

ge a

bsor

ber)

A1P

A2P

A3P

BS1~

5

C63,

C66

E1HC

E2HC

F1U,

F2U

F400

UH1

P~8P

HAP

¨K1,

K3K2

,K4

K3R

K4R

K6R

K7R

K8R

K9R

K10R

K11R

LR M1C

M1F

PS Q1 R

PR5

0, R

59R9

0R9

5R1

TR3

TR4

TS1

NPH

S1PH

V1CP

V1R

V2R

X1M

X1M

X1E

Y2E1

Y2E2

Y1S

Y2S

Y3S

Y4S

Y5S

Z1C,

Z2C

Z1F

Is c

onne

ctor

col

or fo

r prin

ted

circ

uit b

oard

.

Is c

onne

ctor

col

or fo

r com

pone

nt.

Is d

iscrim

inat

ion

colo

r for

com

pone

nt le

ad w

ire.

PO

WE

R S

UP

PLY

3N ~

380

-415

V

50H

z

Not

es1.

Thi

s w

iring

dia

gram

is a

pplie

d on

ly to

the

outd

oor u

nit.

2.

: Fie

ld w

iring

, : C

onne

ctor

:T

erm

inal

:T

erm

inal

: P

rote

ctiv

e ea

rth (s

crew

).3.

For

con

nect

ion

wiri

ng to

out

door

-mul

ti tra

nsm

issi

on Q

1 • Q

2, re

fer t

o th

e in

stal

latio

n m

anua

l.4.

How

to u

se B

S1~

5, re

fer t

o “s

ervi

ce p

reca

utio

n” la

bel o

n E

L. C

OM

PO

. BO

X C

OV

ER

.5.

Whe

n op

erat

ing,

don

’t sh

ortc

ircui

t the

pro

tect

ion

devi

ce (S

1PH

).6.

Col

ors

(BLK

: Bla

ck, R

ED

: red

, BLU

: blu

e, W

HT:

whi

te, G

RN

: gre

en, O

RG

: ora

nge.

To mul

tiun

it

Out

door

(Q1

- Q2)

Not

e 3

EL.

CO

MP

O.B

OX

TER

MIN

AL

OF

M1C

Page 147: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '2�

�#� ,��/!�(����)� �������0�����0��;���

3D05

9326

1)

All w

iring

, com

pone

nts

and

mat

eria

ls to

be

proc

ured

on th

e si

te m

ust c

ompl

y w

ith th

e ap

plic

able

loca

l and

na

tiona

l cod

es.

2)

Use

copp

er c

ondu

ctor

s on

ly.3)

As

for d

etai

ls, s

ee w

iring

dia

gram

.4)

In

stal

l circ

uit b

reak

er fo

r saf

etyu

.5)

Al

l fie

ld w

iring

and

com

pone

nts

mus

t be

prov

ided

by

lic

ense

d el

ectri

cian

.

NOTE

S

OUTD

OOR

UNIT

S

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)2

Wire

s ca

ble

(pow

er li

ne)2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)

2 W

ires

cabl

e (p

ower

line

)

INDO

OR U

NITS

2 W

ires

cabl

e (p

ower

line

)

Switc

h

Fuse

Switc

h

Switc

h

Fuse

Fuse

Switc

h

Fuse

Switc

h

Fuse

Switc

h

Fuse

Switc

h

Fuse

Switc

h

Fuse

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)

2 W

ires

cabl

e (p

ower

line

)

Pow

er s

uppl

y

Mai

nsw

itch

6) U

nit s

hall

be g

roun

ded

in c

ompl

ianc

e w

ith th

e ap

llica

ble

loca

l and

nat

iona

l cod

es.

7) W

iring

sho

wn

are

gene

ral p

oint

s-of

-con

nect

ion

guid

es o

nly

and

are

not i

nten

ded

for o

r to

incl

ude

all

de

tails

for a

spe

cific

inst

alla

tion.

8) B

e su

re to

inst

all t

he s

witc

h th

at c

an in

terr

upt a

ll th

e po

wer

line

of e

ach

equi

pmen

t.9)

Ins

tall

the

mai

n sw

itch

that

can

inte

rrup

t all

the

pow

er s

ouce

s in

an

inte

grat

ed m

anne

r bec

ause

this

syst

em c

onsi

sts

of th

e eq

uipm

ent u

tilizi

ng th

e m

ultip

le p

ower

sou

rces

.10

) The

cap

acity

of U

NIT1

mus

t be

larg

er ta

n UN

IT2

whe

n th

e po

wer

sou

rce

is c

onne

cted

in s

erie

s be

twee

n un

its.

11) I

f the

re e

xist

s th

e po

ssib

ility

of r

ever

sed

phas

e, lo

se p

hase

, mom

enta

ry b

lack

out o

r the

pow

er g

oes

on

and

off w

hile

the

prod

uct i

s op

erat

ing,

atta

ch a

reve

rsed

pha

se p

rote

ctio

n ci

rcui

t loc

ally.

Ru

nnin

g th

e pr

oduc

t in

rver

sed

phas

e m

ay b

reak

the

com

pres

sor a

nd o

ther

par

ts.

Switc

h

Fuse

2 W

ires

cabl

e (p

ower

line

)

Switc

h

Fuse

2 W

ires

cabl

e (p

ower

line

)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)

Pow

er s

uppl

y

Mai

nsw

itch

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

[OUT

DOOR

UNI

T]

Switc

h

Fuse

Pow

er s

uppl

y

Mai

nsw

itch

Pow

er s

uppl

y

OUTD

OOR

UNIT

S

INDO

OR U

NITS

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

Mai

nsw

itch

[OUT

DOOR

UNI

T][F

UNCT

ION

UNIT

][F

UNCT

ION

UNIT

]

Whe

n th

e po

wer

sou

rce

is s

uppl

ied

to e

ach

outd

oor u

nit i

ndiv

idua

llyW

hen

the

pow

er s

ourc

e is

con

nect

ed in

ser

ies

betw

een

the

units

.

Page 148: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'2� �&&�����

� ��������

3D05

9327

1)

All w

iring

, com

pone

nts

and

mat

eria

ls to

be

proc

ured

on th

e si

te m

ust c

ompl

y w

ith th

e ap

plic

able

loca

l and

na

tiona

l cod

es.

2)

Use

copp

er c

ondu

ctor

s on

ly.3)

As

for d

etai

ls, s

ee w

iring

dia

gram

.4)

In

stal

l circ

uit b

reak

er fo

r saf

ety.

5)

All f

ield

wiri

ng a

nd c

ompo

nent

s m

ust b

e pr

ovid

ed b

y

licen

sed

elec

trici

an.

NOTE

S6)

Uni

t sha

ll be

gro

unde

d in

com

plia

nce

with

the

aplli

cabl

e lo

cal a

nd n

atio

nal c

odes

.7)

Wiri

ng s

how

n ar

e ge

nera

l poi

nts-

of-c

onne

ctio

n gu

ides

onl

y an

d ar

e no

t int

ende

d fo

r or t

o in

clud

e al

l

deta

ils fo

r a s

peci

fic in

stal

latio

n.8)

Be

sure

to in

stal

l the

sw

itch

and

the

fuse

to th

e po

wer

line

of e

ach

equi

pmen

t.9)

Ins

tall

the

mai

n sw

itch

that

can

inte

rrup

t all

the

pow

er s

ouce

s in

an

inte

grat

ed m

anne

r bec

ause

this

syst

em c

onsi

sts

of th

e eq

uipm

ent u

tilizi

ng th

e m

ultip

le p

ower

sou

rces

.10

) The

cap

acity

of U

NIT1

mus

t be

larg

er ta

n UN

IT2

whe

n th

e po

wer

sou

rce

is c

onne

cted

in s

erie

s be

twee

n un

its.

11) I

f the

re e

xist

s th

e po

ssib

ility

of r

ever

sed

phas

e, lo

se p

hase

, mom

enta

ry b

lack

out o

r the

pow

er g

oes

on

and

off w

hile

the

prod

uct i

s op

erat

ing,

atta

ch a

reve

rsed

pha

se p

rote

ctio

n ci

rcui

t loc

ally.

Ru

nnin

g th

e pr

oduc

t in

reve

rsed

pha

se m

ay b

reak

the

com

pres

sor a

nd o

ther

par

ts.

OUTD

OOR

UNIT

S

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)2

Wire

s ca

ble

(pow

er li

ne)2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)

2 W

ires

cabl

e (p

ower

line

)

INDO

OR U

NITS

2 W

ires

cabl

e (p

ower

line

)

Switc

h

Fuse

Switc

h

Switc

hFuse

Fuse

Switc

h

Fuse

Switc

h

Fuse

Switc

h

Fuse

Switc

h

Fuse

Switc

h

Fuse

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)

2 W

ires

cabl

e (p

ower

line

)

Pow

er s

uppl

y

Mai

nsw

itch

Switc

h

Fuse

2 W

ires

cabl

e (p

ower

line

)

Switc

h

Fuse

2 W

ires

cabl

e (p

ower

line

)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (p

ower

line

)

Pow

er s

uppl

y

Mai

nsw

itch

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

[OUT

DOOR

UNI

T A]

Switc

h

Fuse

Pow

er s

uppl

y

Mai

nsw

itch

Pow

er s

uppl

y

OUTD

OOR

UNIT

S

INDO

OR U

NITS

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

Mai

nsw

itch

[OUT

DOOR

UNI

T][F

UNCT

ION

UNIT

][F

UNCT

ION

UNIT

]

Whe

n th

e po

wer

sou

rce

is s

uppl

ied

to e

ach

outd

oor u

nit i

ndiv

idua

llyW

hen

the

pow

er s

ourc

e is

con

nect

ed in

ser

ies

betw

een

the

units

.

Switc

hFu

se

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

2 W

ires

cabl

e (tr

ansm

issi

on li

ne)

[OUT

DOOR

UNI

T B]

[OUT

DOOR

UNI

T B]

Page 149: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '2'

�#� ��! ��*���,?,�����0�����0�����0�����0�����0�;���0����0������0�����4��

20~125-class (22~140-class)

control box 220-240/220V~50/60Hz

20~63-class(22~71-class)

80~125-class(90~140-class)

receiver/display unit

Input from outside (note 4)Central remote control (note 2)

wiredremotecontrol

indoor

INDOOR UNITA1P Printed circuit boardA2P Printed circuit boardC1 CapacitorF1U Fuse (T, 5A, 250V)F2U Field FuseHAP Light emitting diode (service monitor green)KPR Magnetic relay (M1P)L1 CoilM1F Motor (indoor fan)M1P Motor (drain pump)

M1S Motor (swing flap)PS Power supply circuitQ1DI Earth leak detectorR1T Thermistor (air)R2T Thermistor coilR3T Thermistor (Header)S1L Float switchX1M Terminal stripX2M Terminal stripY1E Electronic expansion valveZ1C Ferrite core

RECIEVER/DISPLAY UNIT (ATTACHED TO INFRARED REMOTE CONTROL)

A3P Printed circuit boardA4P Printed circuit boardBS1 Push button (on/off)H1P Light emitting diode (on-red)H2P Light emitting diode (timer-green)H3P Light emitting diode (filter sign-red)H4P Light emitting diode

(defrost -orange)SS1 Selector switch (main-sub)

SS2 Selector switch (wireless address set)CONNECTOR FOR OPTIONAL PARTS

X24A Connector (infrared remote control)X33A Connector (adapter for wiring)X35A Connector (group control adapter)

WIRED REMOTE CONTROLR1T Thermistor (Air)SS1 Selector switch (main/sub)

NOTES

1. : Terminal strip : Connector : Field Wiring2. In case of using a central remote control, connect it to the unit in accordance with the attached installation manual.3. X24A, X33A and X35A are connected when the optional accesories are being used.4. When connecting the input wires from outside, forced off or on/off control operation can be selected by the remote control.

See installation manual for more details.5. Confirm the method of setting the selector switch (SS1, SS2) by installation manual and engineering data, etc.6. Color legend: RED: RED BLK:BLACK WHT:WHITE YLW: YELLOW GRN:GREEN ORG: ORANGE BRN: BROWN GRY: GREY BLU:BLUE PNK: PINK

,

3TW28836-1B

Page 150: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'2( �&&�����

,?,���.�0���.�0���.�0���.�0�;�.�0��.�0����.�0����.4�

3D03

9600

A

Note

s1.

: Ter

min

al b

lock

, ,

: Con

nect

or

: F

ield

Wiri

ng2.

In

cas

e us

ing

cent

ral r

emot

e co

ntro

l, co

nnec

t it t

o th

e un

it in

acc

orda

nce

with

the

atta

ched

inst

alla

tion

man

ual.

3.

X23A

is c

onne

cted

whe

n th

e in

frare

d re

mot

e co

ntro

l kit

is b

eing

use

d.4.

W

hen

conn

ectin

g th

e in

put w

ires

from

out

side

, for

ced

off o

r on/

off c

ontro

l ope

ratio

n ca

n be

sel

ecte

d by

rem

ote

cont

rol.

In

det

ails

, ref

er to

the

inst

alla

tion

man

ual a

ttach

ed th

e un

it.

5.

Rem

ote

cont

rol m

odel

var

ies

acco

rdin

g to

the

com

bina

tion

syst

em,

conf

irm e

ngin

eerin

g da

ta a

nd c

atal

ogs,

etc

. bef

ore

conn

ectin

g.6.

Co

nfirm

the

met

hod

of s

ettin

g th

e se

lect

or s

witc

h (S

S1, S

S2) o

f wird

e re

mot

e co

ntro

l and

infra

red

rem

ote

cont

rol b

y in

stal

latio

n m

anua

l and

en

gine

erin

g da

ta, e

tc.

7.

Sym

bols

sho

ws

as fo

llow

s:

RED:

Red

, BLK

: Bla

ck, W

HT: W

hite

, YLW

: Yel

low

, GRN

: Gre

en, O

RG:

Oran

ge,

BRN:

Bro

wn,

PNK

: Pin

k, G

RY:G

ray,

BLU

: Blu

e

Pow

er s

uppl

y

Rece

iver

/dis

play

uni

t(In

frare

d re

mot

e co

ntro

l)

Note

4In

put f

rom

out

side

Note

3

Switc

h bo

x(In

door

uni

t)

Wire

d re

mot

e co

ntro

l

Note

2Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

220-

240V

~50

Hz

220-

V~

60Hz

Indo

or u

nit

A1P

Prin

ted

circ

uit b

oard

(P

ower

sup

ply)

A2P

Prin

ted

circ

uit b

oard

(C

ontro

l)A4

P Pr

inte

d ci

rcui

t boa

rd(T

empe

ratu

re s

enso

r kit)

F1U

Fuse

(�, 5

A, 2

50V)

HAP

Ligh

t em

ittin

g di

ode

(S

ervi

ce m

onito

r-gr

een)

KPR

Mag

netic

rela

y (M

1P)

M1F

M

otor

(Ind

oor f

an)

M1P

M

otor

(Dra

in p

ump)

M1S

M

otor

(Sw

ing

flap)

R1T

Ther

mis

tor (

Air)

R2T

Ther

mis

tor (

Coil

liqui

d)

R3T

Ther

mis

tor (

Coil

gas)

S1L

Floa

t sw

itch

X1M

Te

rmin

al b

lock

X2M

Te

rmin

al b

lock

Y1E

Elec

troni

c ex

pans

ion

valv

e

Z1F

Nois

e fil

ter

PC

Pow

er c

ircui

t

Rece

iver

/Dis

play

uni

t(A

ttach

ed to

infra

red

rem

ote

cont

rol)

A5P

Prin

ted

circ

uit b

oard

A6P

Prin

ted

circ

uit b

oard

BS1

Push

but

ton

(On/

Off)

H1P

Ligh

t em

ittin

g di

ode

(O

n-Re

d)H2

P Li

ght e

mitt

ing

diod

e

(Tim

er-G

reen

)H3

P Li

ght e

mitt

ing

diod

e

(Filt

er s

ign-

red)

H4P

Ligh

t em

ittin

g di

ode

(D

efro

st-O

rang

e)SS

1 Se

lect

or s

witc

h

(Mai

n/Su

b)SS

2 Se

lect

or s

witc

h

(Wire

less

add

ress

set

)Co

nnec

tor f

or o

ptio

nal p

arts

X24A

Co

nnec

tor

(In

frare

d re

mot

e co

ntro

l)X3

3A

Conn

ecto

r

(Ada

pter

for w

iring

)X3

5A

Conn

ecto

r

(Gro

up c

ontro

l ada

pter

)W

ired

rem

ote

cont

rol

R1T

Ther

mis

tor (

Air)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)

Page 151: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '2)

,?����.�0���.�0���.�0���.�0���.4�20,25,32,40,50 class

(22,28,36,45,56 class)Power supply

220-240V~

50Hz

(see note 3)

Input from outside (see note 4)Transmission wiring central remote control (see note 2)

wired remote control

Switch box

(seenote 3)

A1P Printed circuit boardC1 Capacitor (M1F)F1U Fuse ( B , 5A, 250V)F2U Field fuseHAP Light emitting diode (service monitor green)KPR Magnetic relay (M1P)M1F Motor (indoor fan)M1P Motor (drain pump)M1S Motor (swing flap)Q1DI Field earth leak detector (max. 300mA)Q1M Thermal protector (M1F embedded)R1T Thermistor (Air)R2T Thermistor (Coil-Liquid)R3T Thermistor (Coil-Gas)S1L Float switch

T1R Transformer (220-240/22V)V1TR TriacX1M Terminal stripX2M Terminal stripY1E Electronic expansion valveWired remote controlR1T ThermistorSS1 Selector switch (main/sub)Infrared remote control(receiver/display unit)A3P Printed circuit boardA4P Printed circuit boardBS1 Push button (on/off)H1P Light emitting diode (On-red)H2P Light emitting diode (Timer-green)

H3P Light emitting diode (Filter sign-red)H4P Light emitting diode (defrost-orange)SS1 Selector switch (main/sub)SS2 Selector switch (wireless address set)Connector for optional partsX16A Connector (adapter for wire)X18A Connector (on/off) (wiring adapter for

electrical appendices)

RED: RED PNK: PINKBLK: BLACK ORG: ORANGEWHT: WHITE GRN: GREENYLW: YELLOW BLU: BLUE

: Terminal

: Connector

: Wire clamp

: Field wiring

NOTES

1. In case of using a central remote control, connect it to the unit in accordance to the attached installation manual.2. X23A is connected when the infrared remote control kit is being used.3. When connecting the input wires from outside, forced off or on/off control operation can be selected by the remote control.

In details, refer to the installation manual attached to the unit.4. Confirm the method of setting the selector switch (SS1, SS2) by installation manual and engineering data, etc.5. Remote control model varies according to the combination system.

See technical data and catalogs, etc. before connecting.3TW28836-1B

Page 152: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'22 �&&�����

,?&���.�0���.�0���.�0�;�.4�

20,25,32,63 class(22,28,36,71 class)

indoor

Switch box

Input from outside (note 3)

To central remote control (note 1)

Wired remote control(Note 2)

Note 2 Receiver / display unit

Field wiring

L : LiveN : Neutral : Connector : Wire clamp : Protective earth

(screw)

ColorsBLK : BLACKBLU : BLUEBRN : BROWNORG : ORANGEPNK : PINKRED : REDWHT : WHITEYLW : YELLOW

NOTES

1. When using a central remote control, see manual for connection to the unit.2. X23A is connected when the infrared remote control kit is used.3. When connecting the input wires from outside, “forced off” or “on/off” control operation can be selected by the remote control.

For more details see installation manual.4. Use copper conductors only.

2TW23776-1D

33H Float switch33S Limit switch (swing flap)A1P Printed circuit boardC1R Capacitor (M1F)F1T Thermal fuse (152°C) (M1F embedded)F1U Fuse (250V, 5A)F2U Field fuseHAP Light emitting diode (service monitor-green)M1F Motor (indoor fan)M1S Motor (swing flap)M1P Motor (drain pump)R1T Thermistor (air)

R2T, R3T Thermistor (coil)Q2E Earth leak detectorRyA Magnetic relay (M1S)RyF1-3 Magnetic relay (M1F)RyP Magnetic relay (M1P)T1R Transformer (220-240V/22V)X1M Terminal strip (power)X2M Terminal strip (control)Y1E Electronic expansion valve

Receiver / display unit (attached to infrared remote control

A2P, A3P Printed circuit boardBS On/off button

H1P Light emitting diode (on-red)H2P Light emitting diode (timer-green)H3P Light emitting diode (filter sign-red)H4P Light emitting diode (defrost-orange)SS1 Selector switch (main/sub)SS2 Selector switch (wireless address set)Connector for optional partsX18A Connector (wiring, adapter for

electrical appendices)X23A Connector (infrared remote control)

Page 153: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '2+

,?&���.�0���.�0��.�0����.4�

40,50,80,125 class45,56,90,140 class)

indoor

Switch box

Input from outside (note 3)

To central remote control (note 1)

Wired remote control(Note 2)

Note 2 Receiver / display unit

ColorsBLK : BLACKBLU : BLUEBRN : BROWNORG : ORANGEPNK : PINKRED : REDWHT : WHITEYLW : YELLOW

NOTES

1. When using a central remote control, see manual for connection to the unit.2. X23A is connected when the infrared remote control kit is used.3. When connecting the input wires from outside, “forced off” or “on/off” control operation can be selected by the remote control.

For more details see installation manual.4. Use copper conductors only.

2TW23806-1D

Field wiring

L : LiveN : Neutral : Connector : Wire clamp : Protective earth

(screw)

33H Float switch33S Limit switch (swing flap)A1P Printed circuit boardC1R Capacitor (M1F)F1T Thermal fuse (152°C) (M1F embedded)F1U Fuse (250V, 5A)F2U Field fuseHAP Light emitting diode (service monitor-green)M1F Motor (indoor fan)M1S Motor (swing flap)M1P Motor (drain pump)R1T Thermistor (air)

R2T, R3T Thermistor (coil)Q2E Earth leak detectorRyA Magnetic relay (M1S)RyF1-3 Magnetic relay (M1F)RyP Magnetic relay (M1P)T1R Transformer (220-240V/22V)X1M Terminal strip (power)X2M Terminal strip (control)Y1E Electronic expansion valve

Receiver / display unit (attached to infrared remote control

A2P, A3P Printed circuit boardBS On/off button

H1P Light emitting diode (on-red)H2P Light emitting diode (timer-green)H3P Light emitting diode (filter sign-red)H4P Light emitting diode (defrost-orange)SS1 Selector switch (main/sub)SS2 Selector switch (wireless address set)

Connector for optional partsX18A Connector (wiring, adapter for

electrical appendices)X23A Connector (infrared remote control)

Page 154: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'2/ �&&�����

,?C���.-�0���.-�0���.-�0�;�.-4�

3D03

9564

C

1.

: T

erm

inal

blo

ck,

, : C

onne

ctor

, : T

erm

inal

2.

: F

ield

Wiri

ng3.

In

cas

e us

ing

cent

ral r

emot

e co

ntro

l, co

nnec

t it t

o th

e un

it in

acc

orda

nce

with

the

atta

ched

in

stru

ctio

n m

anua

l.4.

W

hen

conn

ectin

g th

e in

put w

ires

from

out

side

, for

ced

off o

r on/

off c

ontro

l ope

ratio

n ca

n be

se

lect

ed b

y re

mot

e co

ntro

l.

In d

etai

ls, r

efer

to th

e in

stal

latio

n m

anua

l atta

ched

the

unit.

5.

In c

ase

high

E.S

.P. o

pera

tion,

cha

nge

over

the

wiri

ng c

onne

ctio

n fro

m X

2A to

X3A

.6.

Sy

mbo

ls s

how

s as

follo

ws:

PNK

: Pin

k, W

HT: W

hite

, YLW

: Yel

low

, ORG

: Ora

nge,

BLU

: Blu

e,

BLK:

Bla

ck, R

ED: R

ed, B

RN: B

row

n, G

RY: G

ray

7.

Use

copp

er c

ondu

ctor

s on

ly.

Note

s

Pow

er s

uppl

y

Note

5

Note

4In

put f

rom

out

side

Elec

tric

parts

box

Note

4

Wire

d re

mot

e co

ntro

l(O

ptio

nal a

cces

sory

)

Note

3Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

220-

240V

~50

Hz

220-

V~

60Hz

Indo

or u

nit

A1P

Prin

ted

circ

uit b

oard

A2P

Term

inal

boa

rd

C1

Capa

cito

r (M

1F)

F1U

Fuse

(�, 5

A, 2

50V)

HAP

Ligh

t em

ittin

g di

ode

(S

ervi

ce m

onito

r-gr

een)

K1R-

K3R

Mag

netic

rela

y (M

1F)

KAR

Mag

netic

rela

y (M

1S)

KPR

Mag

netic

rela

y (M

1P)

M1F

M

otor

(Ind

oor f

an)

M1P

M

otor

(Dra

in p

ump)

M1S

M

otor

(Sw

ing

flap)

Q1M

Th

erm

o sw

itch

(M

1F e

mbe

dded

)

R1T

Ther

mis

tor (

Air)

R2T•

R3T

Ther

mis

tor (

Coil)

S1L

Floa

t sw

itch

S1Q

Lim

it sw

itch

(Sw

ing

flap)

T1R

Tran

sform

er (2

20-2

40V/

22V)

X1M

Te

rmin

al b

lock

(Pow

er)

X2M

Te

rmin

al b

lock

(Con

trol)

Y1E

Elec

troni

c ex

pans

ion

va

lve

Wire

d re

mot

e co

ntro

l

R1T

Ther

mis

tor (

Air)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)

Conn

ecto

r for

opt

iona

l par

ts

X16A

Conn

ecto

r (Ad

apte

r for

wiri

ng)

X18A

Co

nnec

tor (

Wiri

ng a

dapt

er

for e

lect

roni

cal a

ppen

dice

s)

Page 155: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '2<

,?B�����0�����0����,?B����-�0����-�0����-�0����-�0����-�0�;��-4��=8��6�B���������>

3D04

5500

C

A1P

Pr

inte

d ci

rcui

t boa

rd

C1

Capa

cito

r (M

1F)

F1U

Fuse

(F5A

/250

V)HA

P Li

ght e

mitt

ing

diod

e(s

ervi

ce m

onito

r-gr

een)

KPR

Mag

netic

rela

y (M

1P)

M1F

Mot

or (I

ndoo

r fan

)M

1PM

otor

(Dra

in p

ump)

Q1M

Ther

mal

prot

ecto

r (M

1F) e

mbe

dded

)R1

T Th

erm

isto

r (Ai

r)R2

T Th

erm

isto

r (Co

il 1)

R3T

Ther

mist

or (C

oil-2

)S1

L Fl

oat s

witc

hT1

R Tr

ansf

orm

er (2

20V/

22V)

V1TR

Ph

ase c

ontro

l circ

uit

X1M

Te

rmin

al b

lock

X2M

Te

rmin

al b

lock

Y1E

Elec

toni

c ex

pans

ion

valv

e Z1

C-Z2

C No

ise

filte

r (Fe

rrite

cor

e)W

IRED

REM

OTE

CONT

ROL

R1T

Ther

mis

tor (

Air)

SS1

Selec

tor s

witc

h (M

ain/S

ub)

CONN

ECTO

R FO

R OP

TION

AL P

ARTS

X16

A

Conn

ecto

r (Ad

apter

for w

iring)

X18A

Conn

ecto

r (W

iring

ada

pter

for

elec

toric

al a

ppen

dice

s)

1.

: Ter

min

al b

lock

2.

: Con

nect

or

3 :

: Fie

ld w

iring

3.

In c

ase

usin

g ce

ntra

l rem

ote

cont

rol,

conn

ect i

t to

the

unit

in a

ccor

danc

e w

ith th

e at

tach

ed in

stal

latio

n m

anua

l.4.

Rem

ote

cont

rol m

odel

var

ies

acco

rdin

g to

the

com

bina

tion

syst

em, c

onfir

m

engi

neer

ing

mat

eria

ls a

nd c

atal

ogs,

etc

. bef

ore

conn

ectin

g.5.

Whe

n co

nnec

ted

the

inpu

t wire

s fr

om o

utsi

de, f

orce

d of

f or

on/o

ff co

ntro

l ope

ratio

n ca

n be

sel

ecte

d by

rem

ote

cont

rol.

In d

etai

ls, r

efer

to th

e in

stal

latio

n m

anua

l atta

ched

the

unit.

6. S

ymbo

ls s

how

s as

follo

ws:

RED:

RED

BLK

:BLA

CK W

HT:W

HITE

YLW

:YEL

LOW

PRP

:PUR

PLE

GRY

:GRA

Y B

LU:B

LUE

PN

K:PI

NK R

G:OR

ANGE

GRN

:GRE

EN

NO

TE

S

Note

5In

put f

rom

out

side

Note

3Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

Wire

d re

mot

e co

ntro

l

Pow

ersu

pply

Cont

rol b

ox

Page 156: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'+, �&&�����

,?B���.�0���.4�

L : Live N : Neutral : Connector : Wire clamp : Protective earth (screw)

Field wiring

indoor

Term

inal

s op

erat

ion

indi

cato

r

Ada

ptor

for

wiri

ng

Compressoroperation

Fan operation

Note 3 input from outside

central remote control note 1

Switch box

Switch box cover

Wiredremotecontrol

20,25 class(22,28 class)

A1P Printed circuit boardC1R Capacitor (Fan)F1U Fuse (250V, 10A)F2U Field fuseHAP Light emitting diode (service monitor-green)M1F Motor (fan)Q1E Earth leak detectorR1T Thermistor (air)R2T, R3T Thermistor (refrigerant)

RyF1-3 Magnetic relay (fan)T1R Transformer (220-240V/22V)X1M Terminal strip (power)X2M Terminal strip (control)Y1E Electronic expansion valve

Optional partsJ1EH Electric heaterK1R Magnetic relay (J1EH)

Adapter for wiringRyC, RyF Magnetic relayRyH Magnetic relay (J1EH)F1U, F2U Fuse (250V, 5A)X1A, X2A Connector (wiring adapter)

X1M Terminal stripConnector for optional parts

X16A Connector (wiring adapter)X18A Connector (wiring adapter for

electrical appendices

Colors:BLK : BLACK BLU : BLUE BRN : BROWN ORG : ORANGEPNK : PINK WHT : WHITE YLW : YELLOW RED : RED

NOTES1. Use copper conductors only.2. When using the central remote control, see manual for connection to the unit.3. When installing the electric heater, change the wiring for the heater circuit. The main power supply has to be supplied independently.4. When connecting the input wires from outside, “forced off” or “on/off” operation can be selected by the remote control. See installation manual for details.

2TW23666-1E

Page 157: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '+�

,?����.�0���.�0���.�0���.�0���.�0�;�.4�

COLORS:

BLK : BLACKBLU : BLUEBRN : BROWNORG : ORANGEPNK : PINKRED : REDWHT : WHITEYLW : YELLOW

NOTES1. Use copper conductors only.2. When using a central remote control, see manual for connection to the unit.3. When installing the electric heater, change the wiring for the heater circuit. The main power supply has to be supplied

independently.4. For high E.S.P. operation, change the wiring connection of x4A as shown on the wiring diagram.5. When connecting the input wires from outside, “forced off” or “on/off” control operation can be selected by the remote control.

See installation manual.

33H Float switchA1P Printed circuit boardA2P Therminal boardC1R Capacitor (M1F)F1U Fuse (250V, 5A)F2U Field fuseHAP Light emitting diode (service monitor-green)M1F Motor (fan)M1P Motor (drain pump)

Q2E Earth leak detector

R1T Thermistor (air)R2T,R3T Thermistor (refrigerant)RyF1-3 Magnetic relay (Fan)RyP Magnetic relay (Drain pump)T1R Transformer (220V-27V)X1M Terminal strip (power)X2M Terminal strip (control)Y1E Electronic expansion valve

Optional partsF3-5U Fuse (250V, 16A)J1EH Electric heater

K1R Magnetic relay (J1EH)Adapter for wiring

RyC,RyF Magnetic relayRyH Magnetic relay (J1EH)F1U,F2U Fuse (250V,5A)X1A,X2A Connecter (wiring adaptor)X1M Terminal strip

Connector for optional partsX16A Connector (wiring adapter)X18A Connector (wiring adapter for

electronical appendices)

NOTE 5 Input from outside

Central remote control NOTE 2

Wiredremotecontrol

SWITCH BOX

NOTE 3 Seperate power supply 1N~50Hz 230V

20~63 CLASS(22~71 CLASS)

Term

inal

s fo

r op

arat

ion

indi

cato

r

1N~50Hz230V

Indoor Fan operation

Compressoroperation

Adapter for wiring

(20~32 CLASS)(22~36 CLASS)

(40~62 CLASS)(45~71 CLASS)

NOTE 4

High E.S.P. Operation

Field wiringL : LiveN : Neutral : Connector : Wire clamp : Protective earth (screw)

Low E.S.P. Operation

Page 158: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'+� �&&�����

,?���.�0����.�0����.4�

COLORS:

BLK : BLACKBLU : BLUEBRN : BROWNORG : ORANGEPNK : PINKRED : REDWHT : WHITEYLW : YELLOW

NOTES

1. Use copper conductors only.2. When using a central remote control, see manual for connection to the unit.3. When installing the electric heater, change the wiring for the heater circuit. The main power supply has to be supplied independently.4. For high E.S.P. operation, change the wiring connection of x4A as shown on the wiring diagram.5. When connecting the input wires from outside, “forced off” or “on/off” control operation can be selected by the remote control.

See installation manual.

Field wiring

L : LiveN : Neutral : Connector : Wire clamp : Protective earth (screw)

33H Float switchA1P Printed circuit boardA2P Therminal boardC1R Capacitor (M1F)F1U Fuse (250V, 5A)F2U Field fuseHAP Light emitting diode (service monitor-green)M1F Motor (fan)M1P Motor (drain pump)Q2E Earth leak detectorR1T Thermistor (air)

R2T, R3T Thermistor (refrigerant)RyF1-3 Magnetic relay (Fan)RyP Magnetic relay (Drain pump)T1R Transformer (220V-27V)X1M Terminal strip (power)X2M Terminal strip (control)Y1E Electronic expansion valve

Optional partsF3-5U Fuse (250V, 16A)J1EH Electric heaterK1R Magnetic relay (J1EH)

Adapter for wiringRyC,RyF Magnetic relayRyH Magnetic relay (J1EH)F1U,F2U Fuse (250V,5A)X1A,X2A Connecter (wiring adaptor)X1M Terminal strip

Connector for optional partsX16A Connector (wiring adapter)X18A Connector (wiring adapter for

electronical appendices)

NOTE 5Input from outside

To central remote control NOTE 2

Wired remote control

SWITCH BOX

NOTE 3Seperate power supply1N~50Hz 230V

NOTE 4High E.S.P. operation

80,100,125 CLASS(90,112,140 CLASS)

Term

inal

s fo

r op

arat

ion

indi

cato

r

1N~50Hz230V

Indoor Fan operation

Compressoroperation

Adapter for wiring

2TW23776-1D

Page 159: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '+'

,?.�����0�����0�;���0����0������0�����4�

NO

TE

S)

1.

: TE

RM

INA

L

:

CO

NN

EC

TOR

: F

IELD

WIR

ING

2. IN

CA

SE

US

ING

CE

NT

RA

L R

EM

OT

E C

ON

TR

OLL

ER

, CO

NN

EC

T IT

TO

T

HE

UN

IT IN

AC

CO

RD

AN

CE

WIT

H T

HE

AT

TAC

HE

D IN

STA

LLAT

ION

M

AN

UA

L.3.

WH

EN

CO

NN

EC

TIN

G T

HE

INP

UT

WIR

ES

FR

OM

OU

TS

IDE

, FO

RC

ED

OF

F

OR

ON

/OF

F C

ON

TR

OL

OP

ER

ATIO

N C

AN

BE

SE

LEC

TE

D B

Y R

EM

OT

E

CO

NT

RO

LLE

R. I

N D

ETA

ILS

, RE

FE

R T

O T

HE

INS

TALL

ATIO

N M

AN

UA

L AT

TAC

HE

D T

HE

UN

IT.

4. C

OLO

RS

BLK

: B

LAC

K R

ED

: R

ED

BLU

: B

LUE

WH

T :

WH

ITE

PN

K :

PIN

K Y

LW :

YE

LLO

W B

RN

: B

RO

WN

GR

Y :

GR

AY G

RN

: G

RE

EN

O

RG

: O

RA

NG

E.

BLU

BLU

RE

D

YLW

X9A

A3P

R1

R1T

RE

D

BLU

GR

Y

GR

N

X2M

P1

N=

1

-

R1T

YLW

BLK

X6A

F1U

N

BR

N

60H

z~

220V

Z1F

MS

3~

-B

LK

Z2C

TO X

70A

(A

1P)

Y1E

R3T

X3A

HA

P

X35

A

50H

z~

220-

240V

GR

N

F3U

C3

K1R

X28

A

F2U

MS

3~

PN

K

TO X

1MX

33A

X17

A

V2R

V1R

M

BLU

OR

G

F4U

BLK

X10

A

RE

DC

1

X18

A

5

RE

D

HA

P

R1

+

X13

A

A2P

A1P

L1R

SS

1

WH

T

KP

R

WH

T

X7A

X27

A X70

A

R2T

R4

t°t°

t°t°

YLW

K1R

*ON

LY F

XM

Q50

PV

E •

63P

VE

• 8

0PV

E •

100

PV

E •

125

PV

E

X30

A

X25

A

-

OR

G

Z1C

P2

S1L

X6A

EL.

CO

MP

O. B

OX

(IN

DO

OR

)

L

R2

V1R

OR

G

M1F

C1

GR

N

L

L1R

R2

+R

3

M ~

X8A

C2

A2P

-

Z1F

BLK

X10

A

N

M1F

F2

T1

P2

P1

T2

F1

R4T

/YLW

HA

P

X3A

WH

T

+

X15

AX

16A

YLW

BLU

X1A

M1P

PN

K

+

BLU

X1M

X2A

RE

D

FOR

FXM

Q50P

VE •

63PV

E • 8

0PVE

• 10

0PVE

• 12

5PVE

FOR

FXMQ

20PV

E • 2

5PVE

• 32

PVE

• 40P

VE

PS

PS

PS

X33

A

X35

A

X28

A

Z 1 C

A 3 P

X1M

A2P

Z2C

L1P

X2M

A 1 P*

IND

OO

R U

NIT

C1, C

2, C

3

KP

RK

1RL1

RM

1FM

1P

A1P

A2P

A3P

HA

P

F1U

F3U

F2U

F4U

Y1E

R1T

SS

1

X28

A

X33

A

X35

A

Z1F

Z1C

, Z2C

R1T

R3T

R4T

R2T

S1L

V2R

X1M

X2M

V1RPS

R1

R2

R3,

R4

WIR

ED

RE

MO

TE

CO

NT

RO

L

PR

INT

ED

CIR

CU

IT

BO

AR

DP

RIN

TE

D C

IRC

UIT

B

OA

RD

(FA

N)

PR

INT

ED

CIR

CU

IT

BO

AR

D (

CA

PAC

ITO

R)

CA

PAC

ITO

RF

US

E (

T, 3

.15A

, 250

V)

FU

SE

(T,

5A

, 250

V)

FU

SE

(T,

6.3

A, 2

50V

)F

US

E (

T, 6

.3A

, 250

V)

LIGH

T EM

ITTI

NG D

IODE

(SER

VICE

MON

ITOR

-GRE

EN)

(A1P

, A2P

)M

AG

NE

TIC

RE

LAY

MA

GN

ET

IC R

ELA

YR

EA

CTO

RM

OTO

R (

FAN

)M

OTO

R (

DR

AIN

PU

MP

)

SW

ITC

HIN

G P

OW

ER

S

UP

PLY

(A

1P, A

2P)

RE

SIS

TOR

(C

UR

RE

NT

LI

MIT

ING

)C

UR

RE

NT

SE

NS

ING

D

EV

ICE

RES

ISTO

R (E

LEC

TRIC

D

ISC

HAR

GE)

THER

MIS

TOR

(SUC

TION

AIR

)T

HE

RM

ISTO

R (

LIQ

UID

)T

HE

RM

ISTO

R (

GA

S)

TH

ER

MIS

TOR

(DIS

CH

AR

GE

AIR

)F

LOAT

SW

ITC

HD

IOD

E B

RID

GE

PO

WE

R M

OD

ULE

TE

RM

INA

L S

TR

IP(P

OW

ER

SU

PP

LY)

TE

RM

INA

L S

TR

IP

(CO

NT

RO

L)

ELE

CT

RO

NIC

E

XPA

NS

ION

VA

LVE

NO

ISE

FIL

TE

R(F

ER

RIT

E C

OR

E)

NO

ISE

FIL

TE

RC

ON

NE

CTO

R O

PT

ION

AL

AC

CE

SS

OR

YCO

NNEC

TOR

(POW

ER S

UPPL

Y FO

R W

IRIN

G)C

ON

NE

CTO

R(F

OR

WIR

ING

)C

ON

NEC

TOR

(AD

APTE

R)

TH

ER

MIS

TOR

(A

IR)

SE

LEC

TOR

SW

ITC

H(M

AIN

/SU

B)

INP

UT

FR

OM

O

UT

SID

E N

OT

E)

3

TR

AN

SM

ISS

ION

WIR

ING

CE

NT

RA

L R

EM

OT

E

CO

NT

RO

LN

OT

E)

2

WIR

ED

RE

MO

TE

C

ON

TR

OL

(OP

TIO

NA

L A

CC

ES

SO

RY

)

PO

WE

R

SU

PP

LY

3D05

8783

Page 160: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'+( �&&�����

,?.���.-�0���.-�0�;�.-�0��.-�0����.-�0����.-4�

3D03

9620

B

Pow

er s

uppl

y

Elec

tric

parts

box

Note

4In

put f

rom

out

side

Note

5

Wire

d re

mot

e co

ntro

l(O

ptio

nal a

cces

sory

)

Note

3Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

220-

240V

~50

Hz

220-

V~

60Hz

Indo

or u

nit

A1P

Prin

ted

circ

uit b

oard

A2P

Term

inal

boa

rdC1

R Ca

paci

tor (

M1F

)F1

U Fu

se (�

, 5A,

250

V)

40 •

50 •

63 •

80 ty

peF1

U Fu

se (�

, 5A,

250

V)

100

• 125

type

HAP

Ligh

t em

ittin

g di

ode

(S

ervi

ce m

onito

r-gr

een)

K1R-

K3R

Mag

netic

rela

y (M

1F)

KPR

Mag

netic

rela

y (M

1P)

M1F

M

otor

(Ind

oor f

an)

Q1M

Th

erm

o sw

itch

(M

1F e

mbe

dded

)

R1T

Ther

mis

tor (

Air)

R2T•

R3T

Ther

mis

tor (

coil)

S1L

Floa

t sw

itch

T1R

Tran

sfor

mer

(2

20-2

40V/

22V)

X1M

Te

rmin

al b

lock

(Pow

er)

X2M

Te

rmin

al b

lock

(Con

trol)

Y1E

Elec

troni

c ex

pans

ion

valv

eOp

tiona

l par

tsM

1P

Mot

or (D

rain

pum

p)W

ired

rem

ote

cont

rol

SS1

Sele

ctor

sw

itch

(M

ain/

Sub)

R1T

Ther

mis

tor (

Air)

Conn

ecto

r for

opt

iona

l par

tsX1

8ACo

nnec

tor (

Wiri

ng a

dapt

er

for e

lectro

nica

l app

endi

ces)

Note

s:1.

: Ter

min

al b

lock

, ,

: Con

nect

or,

: Ter

min

al2.

: Fie

ld W

iring

3.

In c

ase

usin

g ce

ntra

l rem

ote

cont

rol,

conn

ect i

t to

the

unit

in a

ccor

danc

e w

ith th

e at

tach

ed in

stru

ctio

n m

anua

l.4.

W

hen

conn

ectin

g th

e in

put w

ires

from

out

side

, for

ced

off o

r on/

off c

ontro

l ope

ratio

n ca

n be

sel

ecte

d by

rem

ote

cont

rol.

In

det

ails

, ref

er to

the

inst

alla

tion

man

ual a

ttach

ed th

e un

it.5.

In

cas

e hi

gh E

.S.P

. ope

ratio

n, c

hang

e th

e w

iring

con

nect

ion

of X

2A a

s sh

own

uppe

r fig

ure.

6.

Sym

bols

sho

ws

as fo

llow

s: P

NK: P

ink,

WHT

: Whi

te, Y

LW: Y

ello

w, O

RG: O

rang

e, B

LU: B

lue,

BL

K: B

lack

, RED

: Red

, BRN

: Bro

wn

7.

Use

copp

er c

ondu

ctor

s on

ly.

Page 161: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '+)

,?.����.-�0����.-4�

3D03

9621

B

Pow

er s

uppl

y

Elec

tric

parts

box

Note

4In

put f

rom

out

side

Wire

d re

mot

e co

ntro

l(O

ptio

nal a

cces

sory

)

Note

3Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

220-

240V

~50

Hz

220-

V~

60Hz

Indo

or u

nit

A1P

Prin

ted

circ

uit b

oard

C1R•

C2R

Capa

cito

r (M

1F•2

F)F1

U Fu

se (�

, 5A,

250

V)HA

P Li

ght e

mitt

ing

diod

e

(Ser

vice

mon

itor-

gree

n)K1

M

Mag

netic

con

tact

or (M

1F•2

F)K2

M

Mag

netic

con

tact

or (

M1F

•2F)

K3M

M

agne

tic c

onta

ctor

(M

1F•2

F)K1

R-K3

R M

agne

tic re

lay

(M1F

•2F)

KPR

Mag

netic

rela

y (M

1P)

M1F

•M2F

M

otor

(Ind

oor f

an)

Q1M

•Q2M

The

rmo

switc

h

(M1F

•2F

embe

dded

)

R1T

Ther

mis

tor (

Air)

R2T•

R3T

Ther

mis

tor (

coil)

SS

Sele

ctor

sw

itch

(S

tatic

pre

ssur

e)T1

R Tr

ansf

orm

er (2

20-2

40V/

22V)

X1M

Te

rmin

al b

lock

(Pow

er)

X2M

-X3M

Ter

min

al b

lock

X4M

Te

rmin

al b

lock

(Con

trol)

Y1E

Elec

troni

c ex

pans

ion

valv

eOp

tiona

l par

tsM

1P

Mot

or (D

rain

pum

p)W

ired

rem

ote

cont

rol

R1T

Ther

mis

tor (

Air)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)Co

nnec

tor f

or o

ptio

nal p

arts

X8A

Conn

ecto

r (Fl

oat s

witc

h)X1

8A

Conn

ecto

r (W

iring

ada

pter

for

elec

troni

cal a

ppen

dice

s)

Note

s:1.

: Ter

min

al b

lock

, : C

onne

ctor

: Sho

rt ci

rcui

t con

nect

or

: T

erm

inal

2.

: F

ield

Wiri

ng3.

In

cas

e us

ing

cent

ral r

emot

e co

ntro

l, co

nnec

t it t

o th

e un

it in

acc

orda

nce

with

the

atta

ched

in

stru

ctio

n m

anua

l.4.

W

hen

conn

ectin

g th

e in

put w

ires

from

out

side

, for

ced

off o

r on/

off c

ontro

l ope

ratio

n ca

n be

sel

ecte

d by

rem

ote

cont

rol.

In

det

ails

, ref

er to

the

inst

alla

tion

man

ual a

ttach

ed th

e un

it.5.

In

cas

e in

stal

ling

the

drai

n pu

mp,

rem

ove

the

shor

t circ

uit c

onne

ctor

of X

8A a

nd e

xecu

te

the

addi

tiona

l wiri

ng fo

r flo

at s

witc

h an

d dr

ain

pum

p.6.

Sy

mbo

ls s

how

s as

follo

ws:

PNK

: Pin

k, W

HT: W

hite

, YLW

: Yel

low

, OR

G: O

rang

e, B

LU: B

lue,

BLK

: Bla

ck, R

ED: R

ed, B

RN: B

row

n7.

Us

e co

pper

con

duct

ors

only.

8.

In

cas

e hi

gh E

.S.P

. ope

ratio

n, c

hang

e th

e sw

itch(

ss) f

or “

H”.

Page 162: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'+2 �&&�����

,?����.-�0�;�.-�0����.-4�

3D03

9801

D

Pow

er s

uppl

y

Elec

tric

parts

box

Note

5In

put f

rom

out

side

Note

6

Note

4Re

ceiv

er/d

ispl

ay u

nit

(Infra

red

rem

ote

cont

rol)

Wire

d re

mot

e co

ntro

l(O

ptio

nal a

cces

sory

)

Note

3Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

220-

240V

~50

Hz

220-

V~

60Hz

Indo

or u

nit

A1P

Prin

ted

circ

uit b

oard

C1R

Capa

cito

r (M

1F)

F1U

Fuse

(�, 5

A, 2

50V)

HAP

Ligh

t em

ittin

g di

ode

(S

ervi

ce m

onito

r-gr

een)

KAR

Mag

netic

rela

y (M

1S)

KPR

Mag

netic

rela

y (M

1P)

M1F

M

otor

(Ind

oor f

an)

M1S

M

otor

(Sw

ing

flap)

Q1M

Th

erm

o sw

itch

(M1F

em

bedd

ed)

R1T

Ther

mis

tor (

Air)

R2T

Ther

mis

tor (

Coil

liqui

d)R3

T Th

erm

isto

r (Co

il ga

s)S1

Q Li

mit

switc

h (S

win

g fla

p)T1

R Tr

ansf

orm

er (2

20-2

40V/

22V)

X1M

Te

rmin

al b

lock

(Pow

er)

X2M

Te

rmin

al b

lock

(Con

trol)

Y1E

Elec

troni

c ex

pans

ion

valv

e P

C Ph

ase

cont

rol c

ircui

tOp

tiona

l par

tsM

1P

Mot

or (D

rain

pum

p)W

ired

rem

ote

cont

rol

R1T

Ther

mis

tor (

Air)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)Re

ceiv

er/d

ispl

ay u

nit

(Atta

ched

to in

frare

d re

mot

e co

ntro

l)A2

P Pr

inte

d ci

rcui

t boa

rdA3

P Pr

inte

d ci

rcui

t boa

rdBS

1 Pu

sh b

utto

n (O

n/Of

f)H1

P Li

ght e

mitt

ing

diod

e (O

n-Re

d)H2

P Li

ght e

mitt

ing

diod

e (T

imer

-Gre

en)

H3P

Ligh

t em

ittin

g di

ode

(F

ilter

sig

n-re

d)H4

P Li

ght e

mitt

ing

diod

e

(Def

rost

-ora

nge)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)SS

2 Se

lect

or s

witc

h (W

irele

ss a

ddre

ss

set)

Conn

ecto

r for

opt

iona

l par

tsX8

A Co

nnec

tor (

Floa

t sw

itch)

X18A

Co

nnec

tor (

Wiri

ng a

dapt

er fo

r el

ctric

al a

ppen

dice

s)X2

3A

Conn

ecto

r (In

frare

d re

mot

e co

ntro

l)

Note

s:1.

: Ter

min

al b

lock

,

: Con

nect

or

: S

hort

circ

uit c

onne

ctor

2.

: F

ield

Wiri

ng3.

In

cas

e us

ing

cent

ral r

emot

e co

ntro

l, co

nnec

t it t

o th

e un

it in

acc

orda

nce

with

th

e at

tach

ed in

stru

ctio

n m

anua

l.4.

X2

3a is

con

nect

ed w

hen

the

infra

red

rem

ote

cont

rol k

it is

bei

ng u

sed.

5.

Whe

n co

nnec

ting

the

inpu

t wire

s fro

m o

utsi

de, f

orce

d of

f or o

n/of

f con

trol

oper

atio

n ca

n be

sel

ecte

d by

rem

ote

cont

rol.

In

det

ails

, ref

er to

the

inst

alla

tion

man

ual a

ttach

ed th

e un

it.6.

In

cas

e in

stal

ling

the

drai

n pu

mp,

rem

ove

the

shor

t circ

uit c

onne

ctor

of X

8A a

nd

exec

ute

the

addi

tiona

l wiri

ng fo

r flo

at s

witc

h an

d dr

ain

pum

p.7.

Sy

mbo

ls s

how

s as

follo

ws:

PNK

: Pin

k, W

HT: W

hite

, YLW

: Yel

low

, OR

G: O

rang

e, B

LU: B

lue,

BLK

: Bla

ck, R

ED: R

ed8.

Us

e co

pper

con

duct

ors

only.

Page 163: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '++

,?-���.-�0���.-�0���.-4��0���.-�0���.-�0�;�.-4�

3D03

4206

D

INDO

OR U

NIT

A1P

Prin

ted

circ

uit b

oard

F1

U Fu

se (�

3A,

250

V)HA

P Li

ght e

mitt

ing

diod

e

(ser

vice

mon

itor-

gree

n)M

1F M

otor

(Ind

oor f

an)

M1S

Mot

or (S

win

g fla

p)R1

T T

herm

isto

r (Ai

r)R2

T Th

erm

isto

r (Co

il liq

uid

pipe

)R3

T Th

erm

isto

r (Co

il ga

s pi

pe)

X1M

Ter

min

al b

lock

(Con

trol)

X2M

Ter

min

al b

lock

(Pow

er)

Y1E

Elec

troni

c ex

pans

ion

valv

e

Pow

er c

ircui

tRE

CEIV

ER/D

ISPL

AY U

NIT

(ATT

ACHE

D TO

INFR

ARED

REM

OTE

CONT

ROL)

A2P

Prin

ted

circ

uit b

oard

A3P

Prin

ted

circ

uit b

oard

BS1

Push

but

ton

(on/

off)

H1P

Ligh

t em

ittin

g di

ode

(on-

red)

H2P

Ligh

t em

ittin

g di

ode

(T

imer

-gre

en)

H3P

Ligh

t em

ittin

g di

ode

(F

ilter

sig

n-re

d)H4

P Li

ght e

mitt

ing

diod

e

(Def

rost

-ora

nge)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)SS

1 Se

lect

or s

witc

h

(Wire

less

add

ress

set

)

1.

: Ter

min

al b

lock

: C

onne

ctor

: Fie

ld w

iring

: c

onne

ctor

2. In

cas

e us

ing

cent

ral r

emot

e co

ntro

l, co

nnec

t it t

o th

e un

it in

ac

cord

ance

with

the

atta

ched

inst

alla

tion

man

ual.

3. S

ymbo

ls s

how

s as

follo

ws:

RED

:RED

WHT

:WHI

TE G

RN:G

REEN

PNK:

PINK

YLW

:YEL

LOW

ORG

:ORA

NGE

BLU

:BLU

E B

LK:B

LACK

BRN

:BRO

WN

4.

:sho

ws

shor

t circ

uit c

onne

ctor

5.

:Whe

n co

nnec

ting

the

inpu

t wire

s fr

om o

utsi

de, f

orce

d

Note

-5:

Inpu

t fro

m o

utsi

deNo

te-2

: Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

Rece

iver

/dis

play

uni

t (In

frare

d re

mot

e co

ntro

l)

Pow

er s

uppl

y

Note

-8

WIR

ED R

EMOT

E CO

NTRO

LR1

R Th

erm

isto

r (Ai

r)SS

1 Se

lect

or s

witc

h (M

ain/

sub)

CONN

ECTO

R FO

R OP

TICA

L PA

RTS

X15A

Co

nnec

tor (

Floa

t sw

itch)

X35A

Conn

ecto

r (Gr

oup

cont

rol a

dapt

er)

off o

r on

/off

cont

rol o

pera

tion

can

be s

elec

ted

by r

emot

e co

ntro

l. In

det

ails

, ref

er to

the

inst

alla

tion

man

ual

atta

ched

the

unit.

6. R

emot

e co

ntro

l mod

el v

arie

s ac

cord

ing

to th

e co

mbi

natio

n sy

stem

, con

firm

eng

inee

ring

data

an

d ca

talo

gs, e

tc. b

efor

e co

nnec

ting.

7. C

onfir

m th

e m

etho

d of

set

ting,

the

sele

ctor

sw

itch

(SS

1, S

S2)

of w

ired

rem

ote

cont

rol a

nd

infr

ared

rem

ote

cont

rol b

y in

stal

latio

n m

anua

l an

d en

gine

erin

g da

ta e

tc.

8. X

24A

is c

onne

cted

whe

n th

e in

frar

ed r

emot

e co

ntro

l kit

is b

eing

use

d.

Wire

d re

mot

e co

ntro

l

Note

-8

Cont

rol b

ox

(In

door

uni

t)NO

TES

Side

Fron

t

Page 164: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'+/ �&&�����

,?+���.-�0���.-�0���.-�0���.-�0���.-�0�;�.-4�,?����.-�0���.-�0���.-�0���.-�0���.-�0�;�.-4�

3D03

9826

D

Pow

er s

uppl

y

Cont

rol b

ox

Note

4In

put f

rom

out

side

Wire

d re

mot

e co

ntro

l(O

ptio

nal a

cces

sory

)

Note

3Tr

ansm

issi

on w

iring

ce

ntra

l rem

ote

cont

rol

220-

240V

~50

Hz

220-

V~

60Hz

Indo

or u

nit

A1P

Pr

inte

d ci

rcui

t boa

rdC1

Ca

paci

tor (

M1F

)F1

U Fu

se (�

, 5A,

250

V)HA

P Li

ght e

mitt

ing

diod

e

(Ser

vice

mon

itor-

gree

n)K1

R-K3

R M

agne

tic re

lay

(M1F

)M

1F

Mot

or (I

ndoo

r fan

)Q1

M

Ther

mo

switc

h

(M1F

em

bedd

ed)

R1T

Ther

mis

tor (

Air)

R2T•

R3T

Ther

mis

tor (

Coil)

T1R

Tran

sfor

mer

(220

-240

V/22

V)X1

M

Term

inal

blo

ck (P

ower

)

X2M

Te

rmin

al b

lock

(Con

trol)

Y1E

Elec

troni

c ex

pans

ion

valv

eW

ired

rem

ote

cont

rol

R1T

Ther

mis

tor (

Air)

SS1

Sele

ctor

sw

itch

(Mai

n/Su

b)Co

nnec

tor f

or o

ptio

nal p

arts

X18A

Co

nnec

tor (

Wiri

ng a

dapt

er fo

r ele

trica

l ap

pend

ices

)

Note

s:1.

: Ter

min

al b

lock

,

: Con

nect

or,

: Ter

min

al2.

: Fie

ld W

iring

3.

In c

ase

usin

g ce

ntra

l rem

ote

cont

rol,

conn

ect i

t to

the

unit

in a

ccor

danc

e w

ith

the

atta

ched

inst

ruct

ion

man

ual.

4.

Whe

n co

nnec

ting

the

inpu

t wire

s fro

m o

utsi

de, f

orce

d of

f or o

n/of

f con

trol

oper

atio

n ca

n be

sel

ecte

d by

rem

ote

cont

rol.

In

det

ails

, ref

er to

the

inst

alla

tion

man

ual a

ttach

ed th

e un

it.5.

Sy

mbo

ls s

how

s as

follo

ws:

PNK

: Pin

k, W

HT: W

hite

, YLW

: Yel

low

, OR

G: O

rang

e, B

LU: B

lue,

BLK

: Bla

ck, R

ED: R

ed, B

RN: B

row

n6.

Us

e co

pper

con

duct

ors

only.

Page 165: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '+<

,?*�@�.-�0����.-�0����.-4�

3D04

4973

A

Pow

er s

uppl

yCo

ntro

l box

Note

5

Indo

or u

nit

Note

3BE

V un

it

Rece

iver

/Dis

play

uni

t

Wire

dre

mot

eco

ntro

l

Cont

rol b

ox

220-

240V

~50

Hz

Indo

or u

nit

A1P

Prin

ted

circ

uit b

oard

A2P

Prin

ted

circ

uit b

oard

(Tra

nsfo

rmer

220

~240

V/16

V)C1

Ca

paci

tor (

M1F

)HA

P Li

ght e

mitt

ing

diod

e

(Ser

vice

mon

itor-

gree

n)HB

P Li

ght e

mitt

ing

diod

e

(Ser

vice

mon

itor-

gree

n)M

1S

Mot

or (S

win

g fla

p)M

1F

Mot

or (I

ndoo

r fan

)M

1P

Mot

or (D

rain

pum

p)Q1

MTh

erm

o sw

itch

(M1F

embe

dded

)R1

T Th

erm

isto

r (Ai

r)R2

T Th

erm

isto

r (Co

il)Ry

A M

agne

tic re

lay

(M1A

)Ry

P M

agne

tic re

lay

(M1P

)S1

Q Li

mit

switc

h (S

win

g fla

p)S1

L Fl

oat s

witc

hSS

1 Se

lect

or s

witc

h (E

mer

genc

y)V1

TR P

hase

con

trol c

ircui

tX1

M

Term

inal

blo

ckX2

M

Term

inal

blo

ck R

C Si

gnal

rece

iver

TC

Sign

al tr

ansm

issi

on c

ircui

t

Wire

d re

mot

e co

ntro

lR1

T Th

erm

isto

r (Ai

r)SS

1 Se

lect

or s

witc

h (M

ain/

Sub)

Rece

iver

/dis

play

uni

t(A

ttach

ed to

infra

red

rem

ote

cont

rol)

A3P

Prin

ted

circ

uit b

oard

A4P

Prin

ted

circ

uit b

oard

BS1

Push

but

ton

(On/

Off)

H1P

Ligh

t em

ittin

g di

ode

(O

n-Re

d)H2

P Li

ght e

mitt

ing

diod

e

(Tim

er-G

reen

)H3

P Li

ght e

mitt

ing

diod

e

(Filt

er s

ign-

Red)

H4P

Ligh

t em

ittin

g di

ode

(D

efro

st-O

rang

e)SS

1 Se

lect

or s

witc

h (M

ain/

Sub)

SS2

Sele

ctor

sw

itch

(Wire

less

add

res

set)

Conn

ecto

r for

opt

iona

l par

tsX2

4ACo

nnec

tor (I

nfrare

d rem

ote co

ntrol)

X30A

Con

nect

or (I

nter

face

ada

pter

fo

r sky

air

serie

s)X3

5aCo

nnec

tor (

Grou

p con

trol a

dapt

er)

Note

s:1.

: Ter

min

al b

lock

: Con

nect

or2.

: Fie

ld W

iring

3.

The

BEV

unit

show

s an

out

line.

Ple

ase

refe

r to

a w

iring

dia

gram

of B

EV

unit

past

ing

in d

etai

l.4.

In

cas

e us

ing

cent

ral r

emot

e co

ntro

l, co

nnec

t it t

o th

e un

it in

acc

orda

nce

with

the

atta

ched

inst

alla

tion

man

ual.

5.

X24A

is c

onne

cted

whe

n th

e in

frare

d re

mot

e co

ntro

l kit

is b

eing

use

d.6.

Re

mot

e co

ntro

l mod

el v

arie

s ac

cord

ing

to th

e co

mbi

natio

n sy

stem

.

Conf

irm e

ngin

eerin

g m

ater

ials

and

cat

alog

s, e

tc. b

efor

e co

nnec

ting.

7.

Conf

irm th

e m

etho

d of

set

ting

the

sele

ctor

sw

itch

(SS1

,SS2

) of w

ired

rem

ote

cont

rol

and

infra

red

rem

ote

cont

rol b

y in

stal

latio

n m

anua

l and

eng

inee

ring

data

, etc

.8.

Sy

mbo

ls s

how

s as

follo

ws:

RED

: Red

, BLK

: Bla

ck, W

HT: W

hite

, YLW

: Yel

low

, GR

N: G

reen

, BLU

: Blu

e

Page 166: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

(����)�B��)���'�$ ����$����"� ����������

'/, �&&�����

��4�@�.-�0����.-�0����.-4�

3D044901B

Power supply

To indoor unit

To indoor unit

Control box

220-240V~

50Hz

220V~

60Hz

BEV unitA1P Printed circuit board assyA2P Power supply printed circuit board

assy (220-240V/16V)F1U Fuse (�, 10A, 250V)HAP Light emitting diode (Service monitor-green)R3T Thermistor (Gas)SS1 Selector switch (M/S)X1M Terminal strip (Power)X2M Terminal strip (Transmission)Y1E Electronic expansion valveZ1C • Z2C Noise filterZ3C • Z4C

Notes:1. : Terminal, : Connector2. : Field Wiring3. This wiring diagram only shows the BEV unit. See the wiring diagrams and isntallation manuals for the wiring and setting for the indoor, outdoor,

and BS units.4. See the indoor unit’s wiring diagram when installing optional parts for the indoor unit.5. Only one indoor unit may be connected to the BEV unit. See the indoor unit’s wiring diagram for when connecting the remote control.6. Always use the sky air connectin adapter for the indoor unit when using a cenctral control unit. Refer to the manual attached the unit when connecting.7. Cool/heat changeover of indoor units connected to BEV unit cannot be carried out unless they are

connected to BS unit. In cas of a system with BEV unit only, cool/heat selector is required.8. Set the SS1 to “M” only for the BEV unit connected to the indoor unit which is to have cool/heat

switching capability, when connecting the BS unit. The “M/S” on the SS1 stands for “main/sub”. This is set to “S” when shipped from the factory.9. Connect the attached thermistor to the R3T.10. Symbols show as follows: BLU: Blue, RED: Red, WHT: White, BLK: Black

Page 167: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� (����)�B��)���'�$ ����$����"�

�&&����� '/�

,?.����.,�0����.,�0����.,4�

3D044996C

Power supply

Control box (Electric parts box)

In case of FXMQ200 • 250MFV1

In case of FXMQ125MFV1

Drain pump kit(Optional accessory)Note 3

Note 4Input from outsideNote 2Transmission wiring, central remote control

Note 5

Note 3

Wired remote control(Optional accessory)

Control box

220-240V ~ 50Hz

Indoor unitA1P Printed circuit boardC1,C2 Capacitor (M1F)F1U Fuse (�, 5A, 250V) (A1P)HAP Light emitting diode (Service monitor-green)K1M Magnetic relay (M1F)K1R Magnetic relay (M1F)KPR Magnetic relay (M1P)KSR Magnetic relay (Y1S)M1F Motor (Fan)Q1M Thermal protector (M1F embedded 135°C)R1T Thermistor (Suction air)R2T Thermistor (Coil, liquid)R3T Thermistor (Coil, gas)R4T Thermistor (Discharge air)T1R Transformar (220-240V/22V)

X1M Terminal block (Power)X2M Terminal block (Control)X3M Terminal blockX51A,X52A ConnectorY1E Electric expansion valveY1S Solenoid valve (Hot gas)

Optional partsM1P Motor (Drain pump)S1L Float switch (Drain pump)

Wired remote controlSS1 Select switch (Main/Sub)

Connector for optional partsX18A Connector (Wiring adapter for

electrical appendices)

Notes:1. : Terminal block, , : Connector, : Terminal. : Short circuit connector, : Field Wiring2. In case using central remote control, connect it to the unit in accordance

with the attached instruction manual.3. In case installing the drain pump kit, remove the short circuit connector of X8A and

execute the additional wiring for float switch and drain pump.4. In case connecting the input wires from outside, forced off or on/off control

operation can be selected by remote control. In details, refer to the installation manual attached to the unit.5. Do not remove short circuit connector of X9A.

Page 168: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

+�'�� $��/�"���"�/���!�,��"�� ��/�����' ����������

'/� �&&�����

�# +�'�� $��/�"���"�/���!�,��"�� ��/�����'�#� 1��! ��*����#�#� � �����

���" !�"� ��"��� ����

���./�0�

�"&�� ��

����������&�

�X��6�>A0�d�4

$�&���������������� �(�+�

��>����&�

�L

$�&���������������� L

��>����&�

'L

$�&���������������� L

����"���� $�&���������������� �� '�,�

�������������&�� ����������: ���; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:����-�������*��-�; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:�������; 0'� ��������� ���E�,&� �������&���E�(/,&�

��� ����&���������

9�-*�&�� ���� 5���*

���� � ���9 $���E�(�, �� $!�E�'�,_,��) ��

���� � ���9 L

���� ' �'�9 L

3�5�&�� ���� �� �� ��!�3 $���E�,�,+ ��

��"&��������&���������

>� �*��-��-� ���"&��������&���������:>� �*��-��&�&���*��"� ���;

�'�� $���E��')U

��������������"&��������&���������:�������������*��"� ���;

��� $���E�<'U

$�*�� �� �

����"�����������

��% ��"�?��-�'��)�����),=�#��),=����,���� �4��% ��"�?��-�'��)�����),=�#��),=����,���� �4

����!�� ��������������� ��% �),=���)���� �4

+,−,���

Page 169: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� +�'�� $��/�"���"�/���!�,��"�� ��/�����'

�&&����� '/'

�#�#� � �������D���������" !�"� ��"���

�������.�,�0� ���.���0�

�"&�� ��

����������&�

�X��6�>A0�d�4

$�&���������������� �(�+�

��>����&�

�X��+,6�A0�d�4

$�&���������������� �)�,�

��>����&�

'L

$�&���������������� L

����"���� $�&���������������� �� '�,�

�������������&�� ����������: ���; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:����-�������*��-�; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:�������; 0'� ��������� ���E�,&� �������&���E�(/,&�

��� ����&���������

9�-*�&�� ���� 5���*

���� � ���9 $���E�(�, �� $!�E�'�,_,��) ��

���� � ���9 $���E�(�, �� $!�E�'�,_,��) ��

���� ' �'�9 L

3�5�&�� ���� �� �� ��!�3 $���E�,�,+ ��

��"&��������&���������

>� �*��-��-� ���"&��������&���������:>� �*��-��&�&���*��"� ���;

�'�� $���E��')U

��������������"&��������&���������:�������������*��"� ���;

��� $���E�<'U

$�*�� �� �

����"�����������

��% ��"�?��-�'��)�����),=�#��),=����,���� �4��% ��"�?��-�'��)�����),=�#��),=����,���� �4

����!�� ��������������� ��% �),=���)���� �4

+,−,���+,−,���

Page 170: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

+�'�� $��/�"���"�/���!�,��"�� ��/�����' ����������

'/( �&&�����

�#�#� � �������D��;������" !�"� ��"���

�������.�(�0� ���.�2�0�

�"&�� ��

����������&�

�X��6�>A0�d�4

$�&���������������� �(�+�

��>����&�

�X��+,6�A0�d�4

$�&���������������� �)�,�

��>����&�

'X��+,6�A0�d�4

$�&���������������� �)�,�

����"���� $�&���������������� ��1� �� ����

�������������&�� ����������: ���; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:����-�������*��-�; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:�������; 0'� ��������� ���E�,&� �������&���E�(/,&�

��� ����&���������

9�-*�&�� ���� 5���*

���� � ���9 $���E�(�, �� $!�E�'�,_,��) ��

���� � ���9 $���E�(�, �� $!�E�'�,_,��) ��

���� ' �'�9 $���E�(�, �� $!�E�'�,_,��) ��

3�5�&�� ���� �� �� ��!�3 $���E�,�,+ ��

��"&��������&���������

>� �*��-��-� ���"&��������&���������:>� �*��-��&�&���*��"� ���;

�'� $���E��')U

��������������"&��������&���������:�������������*��"� ���;

��� $���E�<'U

$�*�� �� �

����"�����������

��% ��"�?��-�'��)�����),=�#��),=����,���� �4��% ��"�?��-�'��)�����),=�#��),=����,���� �4

����!�� ��������������� ��% �),=���)���� �4

+,−,���+,−,���

+,−,���

Page 171: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� +�'�� $��/�"���"�/���!�,��"�� ��/�����'

�&&����� '/)

�#�#� � ����������" !�"� ��"���

����4��.�,�0�

�"&�� ��

����������&�

�X��6�>A0�d�4

$�&���������������� �(�+�

��>����&�

�L

$�&���������������� L

��>����&�

'L

$�&���������������� L

����"���� $�&���������������� �� L

�������������&�� ����������:3�B������H������; 0�� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:�� ��-�� ��������?�; 0��� ��������� ���E�,&� �������&���E�(/,&� �������������&�� ����������:�� ��-�� ��������?�; 0��� ��������� ���E�,&� �������&���E�(/,&�

��� ����&���������

9�-*�&�� ���� 5���*

���� � ���9 $���E�(�, �� $!�E�'�,_,��) ��

���� � ���9 L

���� ' �'�9 L

3�5�&�� ���� �� �� ��!�3 L

��"&��������&���������

>� �*��-��-� ���"&��������&���������:>� �*��-��&�&���*��"� ���;

�'� $���E��')U

��������������"&��������&���������:�������������*��"� ���;

��� L

$�*�� �� �

����"�����������

��% ��"�?��-�'��)�����),=�#��),=����,���� �4��% ��"�?��-�'��)�����),=�#��),=����,���� �4

����!�� ��������������� ��% �),=���)���� �4

+,−,���

Page 172: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

+�'�� $��/�"���"�/���!�,��"�� ��/�����' ����������

'/2 �&&�����

�#� ��! ����!��#�#� ��! ��*���

���� �!�"� ��"���

����

��"��8�J�.�,�=�

�J�.�)�=�

�J�.'��=�

�J�.(,�=�

�J�.),�=�

�J�.2'�=�

�J�./,�=�

�J�.�,,�=�

�J�.��)�=�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�+�)'�

����

���� ���� �� �*��"��������������E�$���E��,/_)�:$!�E�<2_�);

>�������"& �����,?�(,=�:),9@;����,=�:2,9@;

�3>?���',> �*��"����� ���()U

�5��-� ���� �� �')9�]'�,,+(/�?�^���&&��-� �����>�2=

�*��"� ���

�*��"� ����:�����������; ��� ������������(�����5�������"������������*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?)�φ/�3�,,,

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?)�φ2�3�,,,

�,8Ω�:�)U;

$�*��

�������5���* ��3 ��?,���4�� � ��% �),=�)��φ)���*��"����� � ��� L���� ��"�� ��� L

���� �!�"� ��"��� ����

��"��8�J�.�) =�

�J�.'� =�

�J�.(, =�

�J�.), =�

�J�.2' =�

�J�./, =�

�J�.�,, =�

�J�.��) =�

��"����������

7�������"���������� 4��2�$&��������������"����

������ 4�+�2�7

����

���� ���� �� >'/,=�',7�/� >�'/,=���,7�/�

>�������"& �����,?�(,=�:),9@;����,=�:2,9@;

�3>?���',> �*��"����� ���()U

�5��-� ���� �� �')9�]'�,,+(/�?�^���&&��-� �����>�2=

�*��"� ���

�*��"� ����:�����������; ��� ������������(�����5�������"������������*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?)�φ/�3�,,,

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?)�φ2�3�,,,

�,8Ω�:�)U;

$�*��

�������5���* ��3 ��?,���4�� � ��% �),=�)��φ)���*��"����� � ��� L���� ��"�� ��� L

Page 173: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� +�'�� $��/�"���"�/���!�,��"�� ��/�����'

�&&����� '/+

���� �!�"� ��"���

����

��"��8�J.�, ='

�J.�) ='

�J.'� ='

�J.(, ='

�J.), ='

�J.2' ='

�J./, ='

�J.��) ='

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�+2�

����

���� ���� ��

����,F�(,=�),9@�φ�,7 �φ�)7 �φ�,7 �φ',7 �φ),7 �φ/)7

�*��"����� ���)�U L �*��"���&����������')U�E�$�������/+U�E�$!

>�������"& �����,?�(,=�:),9@;����,=�:2,9@;

�3>?���',> �*��"����� ���()U

�5��-� ���� �� �/?3]'��,+),<?�^��,,F�(,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?2�φ(�3��),�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?2�φ/�3��),

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?)�φ2�3�,,,

�,8Ω�:�)U;

$�*�� �������5���* ��3 ��?,���4�� � ��% �),=�)��φ)������ ��"�� ��� ����9���/

���� �!�"� ��"��� ����

��"��8�JN.�, =�

�JN.�) =�

�JN.'� =�

�JN.(, =�

�JN.), =�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�+�)',

����

���� ���� ������,F�(,=�),9@

�φ))7�(��*��"����� ��$���E��',_)�#�$!�E�/,_�,

�&������1����"���� � (�,μ � (,,=�

>�������"& �����,?�(,=�:),9@;�3>?���',>

�*��"����� ���()U

�5��-� ���� �� �')9��]'�,/,/,�?�^��,,F�(,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,��?��φ(�3�),�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?'�φ/�32',

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?'�φ2�32',

�,8Ω�:�)U;

$�*�� �������5���* ��3 ��?,����� � ��% �),=�)��φ)������ ��"�� ��� ����9���/

Page 174: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

+�'�� $��/�"���"�/���!�,��"�� ��/�����' ����������

'// �&&�����

∗���������J>.�,F2'!:�;=�1��J>.�,F'��=��:5��*�>�������"&���&�;

���� �!�"� ��"��� ����

��"��8�JA.�) �=�

�JA.'� �=�

�JA.(, �=�

�JA.2' �=�

��"����������

7�������"���������� 4��>)� $&��������������"���������� 4�(2�

����

���� ���� ��

����,F�(,=�),9@�φ�)7�(� �φ�,7�(� �φ()7�(�

�*��"����� ���(2U �*��"���&�����������,U�E�$��������,)U�E�$!

>�������"& ������,?�(,=�:),9@;�3>?���,,>

�*��"����� ���()U

�5��-� ���� �� �')9��]'�,/,/,�?�^��,,F�(,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?�'�φ(�32',�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?+�φ/�3�2,,

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?+�φ2�3�2,,

�,8Ω�:�)U;

$�*�� �������5���* ��3 ��?,���4�� � ��% �),=�)��φ)������ ��"�� ��� ����9���/

���� �!�"� ��"���

����

��"��8�J>.�,!�=�1��=�

�J>.�)!�=�1��=�

�J>.'�!�=�1��=�

�J>.(,!�=�

�J>.),!�=�

�J>.2'!�=�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�(2�

����

���� ���� ��

����,F�(,=�),9@�φ2�7 �φ�',7

�*��"���&���������',UE�$��1�/'UE�$!

>�������"& �����,?�(,=�:),9@;�3>?���',>

�*��"����� ���()U∗

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?��φ(�3V�),�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?(�φ/�3V/,,

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?(�φ2�3V/,,

�,8Ω�:�)U;

$�*�� �������5���* ��3 ��?,���� ∗�� � ��% �),=�)��φ)������ ��"�� ��� ����9���/

Page 175: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� +�'�� $��/�"���"�/���!�,��"�� ��/�����'

�&&����� '/<

���� �!�"� ��"���

����

��"��8�J�.�, /='

�J�.�) /='

�J�.'� /='

�J�.(, /='

�J�.), /='

�J�.2' /='

�J�./, /='

�J�.�,, /='

�J�.��) /='

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�(2�

����

���� ���� ��

����,F�(,=�),9@

�φ),7 �φ2)7 �φ/)7 �φ��)7 �φ��)7

�*��"����� ���)�U �*��"���&����������')U�E�$�������/+U�E�$!

>�������"& �����,?�(,=�:),9@;�3>?���',>

�*��"����� ���()U

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?(�φ(�3/,,�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?+�φ/�3�2,,

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?2�φ2�3��),

�,8Ω�:�)U;

$�*�� �������5���* ��3 ��?,���4�� � ��% �),=�)��φ)������ ��"�� ��� ����9���/

���� �!�"� ��"��� ����

��"��8�J .(, �=�

�J .), �=�

�J .2' �=�

�J ./, �=�

�J .�,, �=�

�J .��) �=�

�J .�,, �=�

�J .�), �=�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�(2�

���� ���� ���� ��

����,F�(,=�),9@�φ�,,7 �φ�2,7 �φ�+,7 �φ(',7 �φ'/,7M�

�*��"���&����������')U�E�$�������/+U�E�$!

�&�������������� ���� �� )�?(,,= +��(,,=

�,�(,,=

/�(,,=

�,�(,,=

��μ �(,,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,��?)�φ(�3�,,,�,8Ω�:�)U;

��/2,��?�'φ(�32',

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)�?(�φ/�3/,,

�,8Ω�:�)U;��/2,)�?)�φ/�3�,,,

�*��"� ����:9�������*��-��; ��� ��/2,��?(�φ2�3/,,

�,8Ω�:�)U;��/2,��?2�φ2�3��),

$�*�� ������ 5���* ��3 ��?,����� � ��% �),=�)��φ)�� �),=��,��φ)�� �),=�)��φ)������ ��"�� ��� ����9���/

Page 176: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

+�'�� $��/�"���"�/���!�,��"�� ��/�����' ����������

'<, �&&�����

���� �!�"� ��"��� ����

��"��8�J9.'� �=�

�J9.2' �=�

�J9.�,, �=�

��"����������

7�������"���������� 4��>)� $&����7����� ���������� 4�+�2'7

����

���� ���� ������,F�(,=#��,=�),9@#2,9@

�φ2'7 �φ�',7�*��"���&����������',U�E�$�������/,U�E�$!

�&�������������� ���� �� '�,�(,,= <�,�(,,=

�5��-� ���� �� �/?3]'�,)/+)�?�^��,,F�(,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,��?��φ(�3�),�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?2�φ/�3�V���),

�,8Ω�:�)U;��/2,)?2�φ/�3�V���),

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?2�φ2�3�V���),

�,8Ω�:�)U;��/2,��?2�φ2�3�V���),

�,8Ω�:�)U;

$�*�� �� � ��% �),=�)��φ)������ ��"�� ��� ����9���/

���� �!�"� ��"��� ����

��"��8�J�.�, �=�

�J�.�) �=�

�J�.'� �=�

�J�.(, �=�

�J�.), �=�

�J�.2' �=�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�+�2�/

���� ���� ���� ��

����,F�(,=�),9@�φ(,7 �φ('7�*��"���&����������',U�E�$�������/,U�E�$!

�5��-� ���� �� ��(�]'�4(,'''?�^��,,F�(,=

��4�,���]'�4(,)),?�^��,,F�(,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?��φ(�3(,,�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?��φ/�3(,,

�,8Ω�:�)U;�*��"� ����:���9�������*��-��; ��� ��/2,�?��φ2�3(,,

�,8Ω�:�)U;

$�*�� �������5���* ��3 $���$!

�� � ��% �),=�)��φ)��

���� �!�"� ��"��� ����

��"��8�J3.�, �=�

�J3.�) �=�

�J3.'� �=�

�J3.(, �=�

�J3.), �=�

�J3.2' �=�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�(2�

���� ���� ���� ��

����,F�(,=�),9@�φ�)7 �φ�)7 �φ')7

�*��"���&����������')U�E�$���������,U�E�$!�&�������������� ���� �� ��,�(,,= ,�)�(,,= ��,�(,,= ��)�(,,= ��,�(,,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?2�φ(�3��),�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?<�φ/�3�),,

�,8Ω�:�)U;�*��"� ����:���9�������*��-��; ��� ��/2,��?<�φ2�3�),,

�,8Ω�:�)U;

$�*�� �� � ��% ��),=�)����� ��"�� ��� ����9���/

Page 177: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� +�'�� $��/�"���"�/���!�,��"�� ��/�����'

�&&����� '<�

���� �!�"� ��"��� ����

��"��8�J!.�, �=�

�J!.�) �=�

�J!.'� �=�

�J!.(, �=�

�J!.), �=�

�J!.2' �=�

��"����������

7�������"���������� 4��>)�$&��������������"����

������ 4�(2�

���� ���� ���� ��

����,F�(,=�),9@�φ�)7 �φ�)7 �φ')7

�*��"���&����������')U�E�$���������,U�E�$!�&�������������� ���� �� ��,�(,,= ,�)�(,,= ��,�(,,= ��)�(,,= ��,�(,,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?2�φ(�3��),�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?<�φ/�3�),,

�,8Ω�:�)U;�*��"� ����:���9�������*��-��; ��� ��/2,��?<�φ2�3�),,

�,8Ω�:�)U;

$�*�� �� � ��% ��),=�)����� ��"�� ��� ����9���/

���� �!�"� ��"��� ����

��"��8�J%.+� �=� �J%.�,, �=� �J%.��) �=�

��"����������

7�������"���������� 4��2�$&��������������"����

������ 4�+)�/7

����

���� ���� ������,F�(,=�),9@

�φ()7 �φ<,7�*��"���&����������',U �*��"���&����������',U�E�$�������/'U�E�$!

>�������"& �� ���,?�(,=�:),9@;����,=�:2,9@;�X=?�(�2

�5��-� ���� �� �/?3]'��,+)+�?�^��,,F�(,=

�*��"� ��� �*��"� ����:�����������; ��� ��/2,�?��φ(�3V�),

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?(�φ2�3V/,,

�,8�:�)U;$�*�� �������5���* ��3 ��?,���4

���� �!�"� ��"��� ����

��"��8�J .��) �=� �J .�,, �=� �J .�), �=�

��"����������

7�������"���������� 4��2�$&��������������"����

������L

���� ���� ���� ��

��,,F�(,=�),9@�φ'/,7

�*��"���&����������')U�E�$�������/+U�E�$!

�&�������������� ���� �� �,�(,,=M�

�,�(,,=

�2μ �(,,=

��������������

��������������:9���-� ; 0�� 4���E�=�=?2,'>

���E�!�=? $�X)'������,?�(,=

�*��"� ���

�*��"� ����:�����������; ��� ��/2,�?�'�φ(�3V2',�,8Ω�:�)U;

�*��"� ����:���9�������*��-���9�-*���"&�; �'� ��/2,)?2�φ/�3V��),

�,8Ω�:�)U;�*��"� ����:9�������*��-��; ��� ��/2,��?��φ2�3V��),

�,8�:�)U;�*��"� ����:����� �*��-�����; �(� ��/2,)?/�3V�,,,

�,8Ω�:�)U;

$�*�� ������ 5���* ��3 $&������ � ��% �),=�)��φ)������ ��"�� ��� ����9���/

Page 178: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

1��� ��+�'� ����������

'<� �&&�����

�# 1��� ��+�'��#� 1��� ��+�'�� $�& ��� //��'1������ ��& ��� /��%'����1��� ��/�-""�'' ���'

� ��2�� �� �������������� �� ����� ����������*����&����"��8��� ��� %&���������&��� �������������������*��� ��������������'� $���������� ����������������������� �������������*�������������(� %&�������� �������������� ���������� �������������*�������������)� �� �������������� �� ����� ������� ���������&����2� �� �������������� �� ����� ����������*����&����

4��� �'��&�� ��!'

�%'����& �$�)����� �

� ��2�� �� ����������������� ����&����"� �����&����������� ����

!�� ��&����" �J.? / �J�.?� �JN.? �JA.? � �J>.?�

�J>.?!� �J�.? �J>.? �J .? � �J9.? � �J�.? � �J3.? ��J!.? � �J%.? �

� ��"�����������7����� 9#� 4�+2� 4�+�)'�� 4�+�)', 4�(2� 4�(2� 4�(2� 4�(2� 4�(2� 4�+�2' 4�+�2�/ 4�(2� 4�+)�/7

7���� 4��>)� 4��2�

� 7�������"������������5��*�5��8��� �*��������"�� 4��>)�/ 4��>2�

' ��"&��������"������������:��&� �����&�; L 4��)� L 4��)� L

( ��"���������������*������ ��:�����������&�; L 4�'�2� L 4�'�2� L

) ���&�������5����- �A���42� L �A���4)+ A���42� �A���4)2 L A���42� A���4' L A���42� L

2?� 7����-����&�������������������&&������ �:�; �A����2� �A����)�2 �A����)�2 A����2� �A����)' A����)�2 A����)� �A����2� �A����)� A����)� A����2�

2?� 7����-����&�������������������&&������ �:�;

�A��(�)� �A��(��)' �A��(�)'2 A��(�)� �A��(�)( A��(�)�2 A��(�)� �A��(�)� �A��(�)� A��(�)� A��(�)'

+ ��"���� �� �� A��,�?� A��,�?( A��,�?� A��,�?�

/ �� ��������������������&������������

!�����1'A���4<2

!�����1'A���9</

!����(12A���4��,� L !����(12

A���4��,�!����)A��(�<� L !����'

A���<'!�����1'A��(�<' L A���4<+

<��������������������&��������������������: � ������� ��������������������� ;

�>���,(�2� �>���,(�)� >���,(�2� �>���,(�)' >���,(�)� >���,(�2� �>���,(�2� �>���,(�)� >���,(�2� >���,��)�

!�� �������"� �����!�� ��������

� ���&�������5����-A���4)2A���4)+A���42�A���4'

� ��������5*����B��&&���5��*��������������������*����������*��������������

� >���?!�����&���������&��� >���,<�)�� %&�����1,�(����� ��������������������������������2(���������-���& �� 7����-��� �������� �:"�������-�*E��1,,,�"1�������5����-����-�*E��1,,,�"1�"������"�����������*� E��2;��&&���������*����&����

!�� �������"� �����!�� ��������

� ���������"�����������>�',�)�>�',��)�:�J�.?�;

[ %&����2(�-���& �������������� :��/����� ;�����������������1�����$!#$��1���"&�������� �����-�����"��������-������������"&�� *������������������� �"�������� ����������������&���������������� �������� � ��"�

�?� ���������������5��*�����*����"�����:'�����8 ; AX4'���

� %������$!#$�������������>�',�4)�>�',�4�)�:�J�.?�; [ %&�����2�-���& �������������� :��/����� ;��������������1�$!#$�������������������

�"�������� ��1������&������������"������������������� &�������������� ��������"���������5��*��&����/����������� ��?� ���������������5��*�����*����"�����

:������8 ; AX4����

�?� !�� ��������:����������"�-���������������� ������; A�A�2?�

' ��*��������"��>��',�4)�>��',�4�)�:�J�.?�;

[ ���-��""�����"��5��8��� �*����������������������������������������������&����2(�-���& �������������� �:��/����� ;�������������� �$!#$����5����&�������

( ������������&��������8����? ����

�?(,+#�?�� �>���,��)�[ ���&��� ���B�����������������&������ ���*����*����*� �����*��=�=��� ��"�����*��*�-*? &����>���?!�����""���������� � ��"����&��������*��=�=��� ��"�

Z ���� ���������*���������&����������������� 1�����&&��&���������&����"� ������� �����������*��&�����������������������������

�?(�,� �>�����4)�

) ������������������&����8��

����%��:0;?A:�;1�>?A �>���,+�))

2 7����-����&���������*������?����������� �>���,'�)�

+ >����?!����&���������&��� >���,<�)�

[ %&�����,�(����� ��������������������������������2(���������-���& �[ 7����-��� �������� �:"�������-*�E��1,,,"1�������5����-����-*�E��1,,,"1�"������"�����������*� �E��2;

� �&&���������*����&����

+?� ������-�&���� A��(�<� [ �����-�&��������>���,<�)�

EC

Page 179: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� 1��� ��+�'�

�&&����� '<'

���/!��)�.���)�������%'���

� ��'2��� 4����e�� �����-� �����������"��8����"�����������������9�����-1�����-������-��������?����������-���-����� �:��9���;�

��� 3$!7$�A�ef�� �����-� ������������"��8�����*�������&���������'� �� ����������������� ����&����"� �����&����������� ����

!�� �������"� �����!�� ��������

�������-��������*����������

4� �� 9���5��� �������-��������*���������� >�2,�)� [ ���?����������-�"���-�"���� � ��"��*��������������������������

��"&�������?��?���������

�?�

$&����

9���5��� >���?!���&�� ����&��� >�2,��)� [ �����������2(�-���& �:�,������������� ;�� �&� �����

�?����5���

������>� >�,,�)� [ ������>�E���5������&���������>� �����������������

�?' 7�� >�,,(�)� [ ������ ������������ ��*�����������������-� � ��"�� ��-��*�����������������7������5 ����&&����������������

�?( ���������������5��*�����*����"�����:(�����8 ; AX4(��� [ 7�����"������� 5���*�����

�������-���� ���-������

4� �� 9���5���!�"���������� ����������������

��/����� >� 2,�4)�

[ ����������������"���-�"���� � ��"��*������������������������&�� �������"&���� �

�)2����� >� 2,�4)�

)������� >� 2,�4)���

+2/����� >� 2,�4)��'

�,�(����� >� 2,�4)��(

�?�

$&���� ���5���

����>� >� ,,��)� [ ��5������&���������>� �����������������

�?� 7�� >� ,,(�)� [ ������ ������������ ��*�����������������-� � ��"�� ��-��*�����������������7������5 ����&&����������������

�?' ��� >� ,,'�)� [ �$�:����-�� ����-�������� �;

�?( $&�������>����������� >� �,��)� [ �����������"&�������� �� �������������-���� ���-�������

�?) >������ >��,��)� [ /�&��� ��� ��������&������$�#$���&������������"��������&���

�?2 >������� >��,��)� [ (�&��� ��� ��������&������$�#$���&������������"��������&���

'

�""�������������� Z��������������� �����4����e > �),�4)�

[ ���������������������5���""��������� ����5����=�=�����4 ���$&������������"��������-������?�����������-� � ��" ��*���-*�4����e���""����������

'?� $&�������>��������� >� (��4)� [ ��&�� ����8��1��� ����������> �),�4)�1����&���������"����>���?!�����""����������&��� ��!���� ���������&���������

'?� $&�������>������� >� (��4)� [ ��&�� ����8��1��� ����������> �),�4)�1����&��������2�"����5���"�����&�� ����&���&���� ��!���� ���������&���������

( Z��������������� �����3$!7$�A�e > �),(4)�[ ���������������������5���""��������� ����5����=�=�����4 ���$&������������"��������-�������?�����������-� � ��" ��*���-*�3$!7$�A�e���""����������

)

������#�����-

�-���

����������������������4� ������� >���,��)� [ ������ �$!#$�����""���1��&�������������� &������"���������K�

�������� ��������"���������5��*��&����(����� �

2 �������"&������������"�� ���"�������� >���,��)� [ ������ ���"&��������"�� ���"�������&������(�-���& K�,?)=>�

+ �������"&������������ �����-����� >���,��)' [ ������ ���"&�������� �����-���&�������2�-���& K�,?)=>�

/ %�������������&��������"&�����@���������� �>�',��)� [ ������������5�����*����������"��������-���������������������������

���� �

]

Page 180: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

1��� ��+�'� ����������

'<( �&&�����

�#� 1��� ��+�'�'�=1��! ��*���>� ������E������

� ���� $&����������� ���� ���0.�,�0� ���0.�(�0�

���0.�2�0� ���0.�,�0�

>� ����������&�&��- ������H����

A9���2 ��� A9���2 ��� A9���2 ���A9���2 ''� A9���2 ''� A9���2 ''�

L A9���2 +�� A9���2 +��L L A9���2 +'�

$������������"����������������&�&��-�8�� L L 49��',�)2

Page 181: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� 1��� ��+�'�

�&&����� '<)

Page 182: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�3���/�� $�& ���"�� ��=����-� %��> ����������

'<2 �&&�����

�# �3���/�� $�& ���"�� ��=����-� %��>

Actual pipe length from outdoor unit to function unit, that from first outEquivalent pipe length from outdoor unit to function unit, that from firs

Example of connection(Connection of 8 indoor units)

Branch with REFNET joint

1 ~ 8 : Indoor unit

1 ~ 8 : Indoor unit

H1

Outdoor unit

REFNET joint

(A~G)

Function unit

H4

c d e f g h

i j k m n p qH2

H1

1 2 3 4 5 6 7

8

H3

r a

bs

A B C D E F G

Outdoor unit

REFNET joint

(A~G)

Function unit

ab

c d e f g h

i j k m n p qH2

H1

1 2 3 4 5 6 7

8

H4

A B C D E F G

O

H1

H3

Maximumallowable

length

Allowableheight

difference

Total extention length Total piping length from outdoor unit (*2) to all indoor unit ≤

Allowable length after the branch

(*1) “ ” Indicate the Outdoor unit multi connection piping kit.

(*2) In case of multi outdoor system, re-read “outdoor unit” to “Outdoor unit multi connection piping kit” as seen from the indoor unit.

Between outdoor unit (*2) and indoor unit

Between outdoor unit and function unit Between outdoor unit and outdoor unit multi connection piping kit

Between outdoor and indoor unitsBetween indoor and indoor unitsBetween outdoor and outdoor unitsBetween outdoor unit and function unit

Actual pipe lengthEquivalent length

Actual and Equivalent pipe length

Difference in heightDifference in heightDifference in heightDifference in heightActual pipe length

Example 8 : a + b + c + d + e + f + g +h +q ≤ 165m ExPipe length between outdoor unit (*2) and indoor unit ≤ 165m

Equvalent pipe length between outdoor unit (*2) and indoor (Assume eqivalent pipe length of REFNET joint to be 0.5m, that of

Difference in height between outdoor unit and indoor unit (HDifference in height between indoor units (H2) ≤ 15mDifference in height between outdoor units (H3) ≤ 5mDifference in height between outdoor unit and function unit (Actual pipe length from first refrigerant branch kit (either REExample 8 : c + d + e + f + g + h + q ≤ 40m E

Singleoutdoorsystem

Multioutdoorsystem

Page 183: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �3���/�� $�& ���"�� ��=����-� %��>

�&&����� '<+

om first outdoor unit multi connection piping kit to outdoor unit 10mhat from first outdoor unit multi connection piping kit to outdoor unit 13m

Branch with REFNET joint and header Branch with REFNET header

1 ~ 8 : Indoor unit 1 ~ 8 : Indoor unit

1 ~ 8 : Indoor unit 1 ~ 8 : Indoor unit

REFNET joint

(A, B)

REFNETheader

Function unit

ab j

k

H2

d e f g h i

1 2 3 4 5 6

7 8

c

H4

H1

q

H1

8

H4

a

b

Outdoor unit

REFNET header

Function unit

H4

H1

1 2 3 4 5 6 78

H2

dc e f g h i j

r a

s

b

H3

q

H1

8

A B

H27 8

Outdoor unit

REFNET joint

(A, B)

REFNETheader

Function unit

k

d e f g h i

1 2 3 4 5 6

c

H4

H1

j

H3

r ab

sA B

REFNET header

Function unit

H1

1 2 3 4 5 6 78

H2

dc e f g h i j

oor unit ≤ 500m

s r a

Outdoor unitFunction unit

m Example 6 : a + b + c + i ≤ 165m, 8 : a + b + j + ≤ 165m Example 8 : a + b + j ≤ 165munit ≤ 165m

nd indoor unit ≤ 190m (Note 1)5m, that of REFNET header to be 1m, that of function unit to be 6m for calculation purposes)

oor unit (H1) ≤ 50m (Max 40m if the outdoor unit is below)5m5mction unit (H4) ≤ 1meither REFNET joint or REFNET header) to indoor unit ≤ 40m (Note 2)

Example 6 : c + i ≤ 40m, 8 : j + ≤ 40m Example 8 : j 40m

Outdoorunit

Outdoorunit

a ≤ 10m (Equivalent length ≤ 13m)r ≤ 10m (Equivalent length ≤ 13m)s ≤ 10m (Equivalent length ≤ 13m)

Page 184: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�3���/�� $�& ���"�� ��=����-� %��> ����������

'</ �&&�����

Pipe size selection

••

How to select the REFNET joint

Piping between outdoor unit (*2) and refrigerant branch kitChoose from the following table in accordance with the outdoor unit sys

Piping between outdoor unit multi connection piping kit and outdo

Temper grade and wall thickness for pipes(Temper grade, O type and 1/2H type indicate the material type s

Outdoor system capacity type10HP type14~20HP type

Refrigerant brancKHRP26A33TKHRP26A72T

Refrigerant brancKHRP26A22TKHRP26A33TKHRP26A72T

Example REFNET joint C : Indoor units 3 + 4 + 5 + 6 + 7 + 8EE

<In case of single outdoor unit system>

<In case of multi outdoor unit system>

Outdoor unit

Outdoor unit

Function unit

Function unit

Outdoor systemcapacity type10HP type14,16HP type20HP type

Piping size (O. D.)

Piping size (O. D.)

Gas pipeφ22.2

φ28.6

Liquiφ9

φ1φ1

Outdoor unitcapacity typeRTSP8 typeRTSP12 type

Copper tube O. D.Temper gradeWall thickness(Min. requirement)

Gas pipeφ22.2φ28.6

Liquiφ9

φ1

φ6.4

0.80

φ9.5

0.80

φ12.7

0.80

φ15.9

0.99

φ19.1

0.80

φ22.2

0.80

O type

Indoor unit total capacity indexx < 200200 ≤ x < 290290 ≤ x < 640

Equalizer pipe (part C)

• Refrigerant branch kits can only be used with R-410A.• When multi outdoor system are installed, be sure to use the

special separately sold Outdoor unit multi connection piping kit. (BHFP30A56).(For how to select the proper kit, follow the table at right.)

Outdoor unit multi connection piping kit and Refrigerant branch kit selection

Example for indoor units connected downstream

The thickness of the pipes in the table shows the requirements of Japanease High Pressure Gas Controll low. (As of Jan. 2003)The thickness and material shall be selected in accordance with local code.

Piping between outdoor unit and refrigerant branch kit (part A)

Piping between outdoor unit (*2) and refrigerant branch kit (part A)

Piping between outdoor unit and outdoor unit multi connection piping kit (part B)

When using REFNET joint at the first branch counted from tchoose from the following table in accordance with the outdotype. (Example : REFNET joint A)

Choose the REFNET joints other than the first branch from taccordance with the total capacity index of all the indoor unithe REFNET joint.

Choose from the following table in accordance with the capathe outdoor unit connected.

Page 185: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �3���/�� $�& ���"�� ��=����-� %��>

�&&����� '<<

ranch kit (part A)

How to select the REFNET header

oor unit system capacity type.

and outdoor unit (part B)

rial type specified in JIS H 3300.)

Choose from the following table in accordance with the number of outdoor units.

nt branch kit nameA33TA72T

nt branch kit nameA22TA33TA72T

Number of outdoor unit2 units

Connecting piping kit nameBHFP30AP56

7 + 8Example REFNET joint B : Indoor units 7 + 8Example REFNET header : Indoor units 1 + 2 + 3 + 4 + 5 + 6

Example REFNET header :Indoor units 1 + 2 + 3 + 4 + 5 + 6 + 7 + 8

D.)

D.)

Liquid pipeφ9.5

φ12.7φ15.9

Liquid pipeφ9.5

φ12.7

1

0

φ22.2

0.80

φ25.4

0.88

φ28.6

0.99

φ31.8

1.10

φ34.9

1.21

φ38.1

1.32

φ41.3

1.43

Piping between refrigerant branch kits

Piping between refrigerant branch kit, and indoor unit

Equalizer pipe (part D) (multi outdoor unit system only)

Match to the size of the connection piping on the indoor unit.

Indoor capacity index

x < 150150 ≤ x < 200200 ≤ x < 290290 ≤ x < 420420 ≤ x < 640

Gas pipeφ15.9φ19.1φ22.2

φ28.6

Liquid pipe

φ9.5

φ12.7φ15.9

Indoor unit capacity type

20 · 25 · 32 · 40 · 50 type63 · 80 · 100 · 125 type200 type250 type

Gas pipeφ12.7φ15.9φ19.1φ22.2

Liquid pipeφ6.4

φ9.5

Piping size (O. D.) φ19.1

(unit : mm)

(unit : mm)

Piping size (O. D.) (unit : mm)

Piping size (O. D.) (unit : mm)

(unit : mm)

1/2H type

Refrigerant branch kit nameKHRP26M22H or KHRP26A33HKHRP26M33HKHRP26M72HKHRP26M73H + KHRP26M73HP

Indoor unit total capacity indexx < 200200 ≤ x < 290290 ≤ x < 640640 ≤ x

ed from the outdoor unit side, the outdoor system capacity

ch from the following table in ndoor units connected below

Choose from the following table in accordance with the total capacity index of all the indoor units connected below the REFNET header. 250 type indoor unit can not be connected below the REFNET header.

How to select the outdoor unit multi connection piping kit (This is required when the system is multi outdoor unit system.)

● Choose from the following table in accordance with the total capacity type of all the indoor units connected downstream.

● Do not let the connection piping exceed the main refrigerant piping size (Part A). If the piping size selected from the following table exceeds the piping size of part A, decide the piping size in either of the following methods.(1) Reduce the size of the connection piping to the piping size of part A.(2) Replace the piping of part A with piping that is a size larger (see the table in Note 1) so that it will be the same as the size of the connection piping.

the capacity type of

Page 186: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

�3���/�� $�& ���"�� ��=����-� %��> ����������

(,, �&&�����

Required Conditions

R = 0.37

0.18

0.059

0.26

0.12

0.022

Note 1. SystemRTSYQ10 typeRTSYQ14 typeRTSYQ16 typeRTSYQ20 type

Gasφ22.2 → φ25.4 (*)

Not Increased

φ28.6 → φ31.8 (*)

Liquidφ9.5 → φ12.7

φ12.7 → φ15.9

φ15.9 → φ19.1

(*)

O

Additional refrigerant tobe charged : R(kg) R should be rounded off in units of 0.1 kg.

Total length(m) of liquid piping size at φ 22.2

Total length(m) of liquid piping size at φ 15.9

Total length(m) of liquid piping size at φ 9.5

Total length(m) of liquid piping size at φ 19.1

Total length(m) of liquid piping size at φ 12.7

Total length(m) of liquid piping size at φ 6.4

System : RTSYQ20PY1Independent outdoor unit : RTSQ8PY1, RTSQ12PY1Function unit : BTSQ20PY1

If available on the site, use this size. Otherwise, it can not be increased.

When the equivalent pipe length between outdoor (*2) and indoor units is 90m or more, the size of main pipes (figure on right) must be increased according to the right table.

1. It is necessary to increase the pipe size between the first branch kit and the final branch kit. (Reducers must be procured on site) However, the pipes that are same pipe size with main pipe must not be increased.

2. For calculation of Total extension length, the actual length of above pipes must be doubled. (except main pipe and the pipes that are not increased)

3. Indoor unit to the nearest branch kit ≤ 40 m

4. The difference between [Outdoor unit to the farthest indoor unit] and [Outdoor unit to the nearest indoor unit] ≤ 40 m

*If available on the site, use this size. Otherwise it can not be increased.

The farthest indoor unit 8 The nearest indoor unit 1 ( a + b + c + d + e + f + g + h + q ) - ( a + b + i

Example for refrigerant branch using REFNET joint and R

How to calculate the additional refrigerant to be charged

Example Drawings (In case of “Branch with

8 c + d + e + f + g + h + q ≤ 90 m increase the pipe size of c, d, e, f, g, h

a+b+c×2+d×2+e×2+f×2+g×+h×2+i+ j+k+ +m+n+p+q≤ 50

Note 2. Allowable length after the first refrigerant branch kit to indoor units is 40m or less, however it can be extended

Page 187: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� �3���/�� $�& ���"�� ��=����-� %��>

�&&����� (,�

a

b

i j k m n p

c d e f hq

gA B C D E F G

Outdoor unit Function unit

1 2 3 4 5 6 78

REFNET joint(A~G)

Indoor units ( 1 - 8 )

0.26

0.12

0.022

R = 40 × 0.18 + 25 × 0.12 + 50 × 0.059 + 80 × 0.022 = 14.91

a : φ15.9 × 10mb : φ15.9 × 30mc : φ12.7 × 20md : φ6.4 × 10m

e : φ6.4 × 10mf : φ6.4 × 20mg : φ6.4 × 20mh : φ6.4 × 10m

i : φ6.4 × 10mj : φ9.5 × 20mk : φ9.5 × 10m

: φ9.5 × 10m

r : φ12.7 × 5ms : φ9.5 × 10m

a, b c, r j, k, , s d~i

14.9kg

12.7

15.9

19.1

RTSYQ10PY1

RTSYQ14PY1

RTSYQ16PY1

RTSYQ20PY1

1.3kg

2.3kg

Outdoor unitFunction unit

In case of single outdoor unit system

Main pipes

Outdoor unitFunction unit

Main pipes

m)ng7

m)ng

TSQ12PY1

) - ( a + b + i ) ≤ 40 m

Increase the pipe size as follows

φ 9.5 → φ 12.7φ 12.7 → φ 15.9

φ 15.9 → φ 19.1φ 19.1 → φ 22.2

φ 9.5 → φ 12.7φ12.7 → φ 15.9

φ 22.2 → φ 25.4*φ 28.6 → φ 31.8*

φ 34.9 → φ 38.1*

In case of multi outdoor unit system

Inclease gas and liquid pipe size both.

First refrigerant branch kit

First refrigerant branch kit

Inclease gas and liquid pipe size both.

Indoorunit

T joint and REFNET header for the systems and each pipe length as shown below.

For the systemSystem name The amount of regrigerant

Branch with REFNET joint”)

90 m d, e, f, g, h

2+f×2+g×2n+p+q≤ 500 m

Indoorunit

be extended up to 90m if all the following conditions are satisfied.

Page 188: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

6����'� ����'�'���"��0� �����������&6���"����'��"' ����������

(,� �&&�����

;# 6����'� ����'�'���"��0� �����������&6���"����'��"'

����������� �������� ������ ���������B����&�&�� �������-� �&�&� �'�

$����������� ��������������� ������������ ������� �������&�&� �(��������������-� �&�&� �)�����������������������B����&�&� �2�

:8Ω;�U ,�, ,�) �U ,�, ,�)?�, �<+�/� �<��,/ ', �2��, �)�+2?�< �/2�)' �/���2 '� �)�(' �)��,?�/ �+)�<+ �+,�<( '� �(�+< �(�(/?�+ �22�,+ �2��'2 '' �(��/ �'�//?�2 �)2�/, �)��'/ '( �'�)< �'�'�?�) �(/��, �('�<2 ') �'�,( ���++?�( �'<�<( �'2�,) '2 ���)� ����)?�' �'���/ ��/�2' '+ ���,� ���+2?�� ��)�,< ����22 '/ ���)� ����<?�� ��/�'( ��)��� '< ���,2 �,�/(?�, ����<< �,/�<2 (, �,�2' �,�(�?< �,2�,' �,'��/ (� �,��� �,�,,?/ �,,�(� <+�+' (� <�/� <�2�?+ <)��( <��2� (' <�(� <��(?2 <,��+ /+�+< (( <�,2 /�//?) /)�(< /'��) () /�+� /�)(?( /��,/ +/�<+ (2 /�'+ /���?' +2�<' +(�<( (+ /�,) +�<,?� +'�,� +���( (/ +�+) +�2,?� 2<�'� 2+�)2 (< +�(2 +�'�, 2)�/( 2(��+ ), +��/ +�,(� 2��)( 2,�<2 )� 2�<� 2�+/� )<�(' )+�<( )� 2�2) 2�)'' )2�(< ))�,/ )' 2�(� 2�)'( )'�+� )��'/ )( 2�2) 2�)') )��,< (<�/' )) 2�(� 2�)'2 (/�2� (+�(� )2 2��/ 2�,2+ (2��2 ()��( )+ )�<) )�/(/ ((�,) (��</ )/ )�+( )�('< (��<) (,�<( )< )��( )�,)�, '<�<2 '<�,� 2, (�<2 (�/+�� '/�,/ '+��/ 2� (�+< (�+,�� '2�', ')�() 2� (�2� (�)(�' '(�2� ''�/� 2' (�(2 (�'/�( ''�,� '���) 2( (�', (��'�) '��), ',�++ 2) (��2 (�,/�2 ',�,2 �<�'+ 22 (�,� '�<(�+ �/�+, �/�,) 2+ '�// '�/��/ �+�(� �2�+/ 2/ '�+) '�2/�< �2��/ �)�)< 2< '�2� '�)2�, �)�,� �(�() +, '�), '�((�� �'�<� �'�'+ +� '�'/ '�'��� ���/) ���') +� '��+ '����' ���/) ���'+ +' '��2 '����( �,�<, �,�() +( '�,2 '�,��) �,�,, �<�)2 +) ��<2 ��<��2 �<��( �/�+' +2 ��/2 ��/��+ �/�'� �+�<' ++ ��++ ��+��/ �+�)( �+��+ +/ ��2/ ��2(�< �2�/, �2�() +< ��2, ��))', �2��, �)�+2 /, ��)� ��(+

$�������������������*��"� �������

�U ,�,?�,?/?2?(?�

??//�,+<��+���

,�(2/

2(��)+�/)��'(+�'(��<

�,���(�2�/

'/�<')�''����<���2�2

�,���(�2�/

�(�'�����,�'�/�)�+�,

','�'('2'/

�)�2�(���'�����,����

(,(�(((2(/

�,�'<�)/�//��+�2

),)�)()2)/

+�,2�+2�,)�))��

2,2�2(222/

(�+<(�(2(��)'�/+'�2�

+,+�+(+2+/

'�'+'��)��<(��+)��)�

/,/�/(/2//

��(����2������<<��/+

<,<�<(<2</

��+2��2)��))��(2��'/

Page 189: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� 6����'� ����'�'���"��0� �����������&6���"����'��"'

�&&����� (,'

1��! ��*���� 6����'� �'�$ ��B�'"6��)�������=�� D����∼�� >

:8Ω;;�U ,�, ,�) �U ,�, ,�) �U ,�, ,�), 2(,�(( 2�(�2) ), +��'� +,�<2 �,, �'�') �'��)� 2,<�'� )<(�(' )� 2<�2( 2/�'( �,� ���<) ���+2� )+<�<2 )2)�+/ )� 2+�,2 2)�/� �,� ���)+ ���'/' ))��,, )'/�2' )' 2(�2, 2'�(� �,' ����, ���,�( )�)�2' )���<+ )( 2���( 2��,< �,( ���/( ���22) ),,�22 (//�2+ )) )<�<+ )/�/+ �,) ���(< ���'�2 (++�,� (2)�2) )2 )+�/, )2�+) �,2 ����) �,�<<+ ()(�2, (('�/( )+ ))�+� )(�+, �,+ �,�/' �,�2+/ (''�'+ (�'��+ )/ )'�+� )��/( �,/ �,�)� �,�'2< (�'��( (,'�)+ )< )��</ ),�<2 �,< �,��� �,�,2�, '<(��2 '/(�</ 2, (<�<2 (<�,2 ��, <�<� <�+/�� '+2�,) '2+�') 2� (/��< (+�'' ��� <�2( <�),�� ')/�// '),�2� 2� (2�(< ()�2+ ��� <�'2 <��'�' '(��)/ ''(�+( 2' ((�/2 ((�,+ ��' <��, /�<+�( '�+��, '�<�22 2( ('�', (��)( ��( /�/( /�+��) '���(� ',)�'' 2) (��+< (��,2 ��) /�)< /�(+�2 �</�() �<��+' 22 (,�') '<�2) ��2 /�') /��'�+ �/)��/ �+/�/, 2+ '/�<2 '/��< ��+ /��� /�,��/ �+��)/ �22�)� 2/ '+�2' '2�</ ��/ +�/< +�+/�< �2,�2, �)(�+� 2< '2�'( ')�+� ��< +�2/ +�)+�, �(<�,, �('�2� +, ')��� '(�)� ��, +�(+ +�'2�� �'/�'2 �''��( +� ''�<� ''�') ��� +��2 +��2�� ��/�,) ��'�,/ +� '��+/ '���' ��� +�,2 2�<+�' ��/��( ��'�)� +' '��2< '���) ��' 2�/+ 2�+/�( �,/�<, �,(�'< +( ',�2' ',��� ��( 2�2< 2�)<�) �,,�,, �<)�+� +) �<�2� �<��� ��) 2�)� 2�(��2 �<��)' �/+�(( +2 �/�2( �/��2 ��2 2�'' 2��)�+ �/'�(2 �+<�)+ ++ �+�2< �+��( ��+ 2��2 2�,/�/ �+)�++ �+��,2 +/ �2�+< �2�') ��/ 2�,, )�<��< �2/�(( �2(�<, +< �)�<� �)�(< ��< )�/( )�+2', �2��() �)/�,/ /, �)�,+ �(�22 �', )�2< )�2�'� �)(�+< �)��)+ /� �(��2 �'�/+ �'� )�)( )�(2'� �(/�(' �()�'+ /� �'�(/ �'��, �'� )�'< )�'�'' �(��'+ �'<�(( /' ���+' ���'2 �'' )��) )��/'( �'2�)< �''�+< /( ���,� ���2) �'( )��� )�,)') �'��,2 ��/�'< /) ���'� �,�<+ �') (�</ (�<�'2 ��)�+< ��'��( /2 �,�2' �,�'� �'2 (�/2 (�+<'+ ��,�+2 ��/�'� /+ �<�</ �<�2+ �'+ (�+' (�2+'/ ��)�<) ��'�2� // �<�'2 �<�,) �'/ (�2� (�))'< ����') �,<��' /< �/�+) �/�(2 �'< (�(< (�(((, �,2�<2 �,(�/( <, �/��+ �+�/< �(, (�'/ (�'�(� �,��+2 �,,�+' <� �+�2� �+�'( �(� (��+ (���(� </�+) <2�/� <� �+�,+ �2�/, �(� (��2 (���(' <(�<� <'�,2 <' �2�)( �2��< �(' (�,2 (�,�(( <���) /<�(+ <( �2�,( �)�+< �(( '�<2 '�<�() /+�+( /2�,( <) �)�)) �)�'� �() '�/2 '�/�(2 /(�'/ /��+) <2 �)�,/ �(�/) �(2 '�+2 '�+�(+ /���2 +<�2� <+ �(�2� �(�(, �(+ '�2+ '�2�(/ +/�,< +2�2, </ �(��/ �'�<+ �(/ '�)/ '�)((< +)��( +'�+� << �'�+2 �'�)) �(< '�(< '�()), +��'� +,�<2 �,, �'�') �'��) �), '�(� '�'+

Page 190: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���''�������' � ����������

(,( �&&�����

@# ���''�������' �

Low Pressure (PL)

High Pressure (PH)

PH : Detected Pressure [High Side] MPaPL : Detected Pressure [Low Side] MPaVH : Output Voltage [High Side] VDC

VL : Output Voltage [Low Side] VDC

PH = 1.38V-0.69PL = 0.57V-0.28PH : High pressure (MPa)VL : Low pressure (MPa)V : Voltage (V)

(V3053)

Output Voltage (VH, VL)

Detected Pressure

Page 191: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���������� .��6 !� $�&6�"I��)��6����L�����U'�� 8��� ���'�'� �'���!�B� !��. !�/�'

�&&����� (,)

# .��6 !� $�&6�"I��)��6����L�����U'�� 8��� ���'�'� �'���!�B� !��. !�/�'

#� .��6 !� $�&6�"I��)��6����L�����U'�� 8��� ���'�'� �'���!�B� !��. !�/�'

&6�"I��)�$��/���'����� 8���'���" �!�"� �'�� ����!� ����L�������&�5 ��!*��8��*��&�5��� �"���������� �"�����������*�����������������������*��� ������"����&����� ����7����'�� �5���������!91 ����&����� ����E ���&�����*�������-���&����"����&����� ����

�����*����-�������&����"����&����� ���1��*� ��5��*��������*��8���������������������������*���*��8��-�

7 �'��� ���'91 �����$����*��&�5��� �&&�����*��1����������& �����,�"����� ����"���1�"�8��"�� ���"�������� � ������

7��������� �91 ���"�8��"�� ���"���1��� ��������������������� ��������"���� ���

��L�������&�5 ��!���!�&��"����B��)���

� ��������-�����*���*��8��-�����"��������1����� �&�������*����*��"������������ ��� ���"��*������������������*������5��-� ��������� ����� � �&&� ������ � ����*�����������������

1 ���������"&�� ���:-���������8�-�;1 ����������"�����:-���������8�-�;1 �����������������������-��&������� 1 �����"��������-��:��-�����������-�1� ��-��:�*�����;1��������������������-�;��������������&������*����������������1���� ��������*��8�����*��&���� �����"���������

P3U V WN3

J1

J2

J3

P1

P1 P2IGBT

X11A

U V W

L1

L2

L3

X10A

DM

K2

P3

N3

(V2895)

J1

J2

J3

Page 192: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

.��6 !� $�&6�"I��)��6����L�����U'�� 8��� ���'�'� �'���!�B� !��. !�/�' ����������

(,2 �&&�����

�# � 8���� !�/��"6�"I��)

�# B� !��� !�/��"6�"I��)

7*���� ��-��*�������-���&����"����&����� ���1�"�8��"�� ���"��������� � ������"�� ���"����"��������*����8����-���

7*���� ��-��*����-�������&����"����&����� ���1�"�8��"�� ���"��������������*��8�"����:� ��;�

!�� �� ����-�&���� �������� ��"��8 !��

�� ����-�&���� �������� ��"��8

P ? P ?� �' %

������)8� �' % !����� �

�*�����=�

:��������-;

���"�����8����"����������"�����*�������-�����������&��������*��-������� ��

� �' = � �' =' �' 7 ' �' 7( % �'

!����� ��*���)8�

:��������-;

���"�����8����"����������"�����*���� � ���������������&��������*��-������� ��

( % �'

,�'����,�+=

) = �' ) = �'2 7 �' 2 7 �'+ !' % + !' %/ !' = / !' =< !' 7 < !' 7�, % !'

������)8�, % !' !����� �

�*�����=�

:��������-;

���"�����8����"����������"�����*�������-�����������&��������*��-������� ���

�� = !' �� = !'�� 7 !' �� 7 !'

7*���� ��-��*�������-���&����"����&����� ���1�"�8��"�� ���"��������� � ������"�� ���"����"��������*����8����-���

7*���� ��-��*����-�������&����"����&����� ���1�"�8��"�� ���"��������������*��8�"����:� ��;�

!�� �� ����-�&���� �������� ��"��8 !��

�� ����-�&���� �������� ��"��8

P ? P ?� �� X�

������)8� �� X� !����� �

�*�����=�

:��������-;

���"�����8����"����������"�����*�������-�����������&��������*��-������� ��

� �� X� � �� X�' �� X' ' �� X'( X� ��

!����� ��*���)8�

:��������-;

���"�����8����"����������"�����*���� � ���������������&��������*��-������� ��

( X� ��

,�'����,�+=

) X� �� ) X� ��2 X' �� 2 X' ��+ !' X� + !' X�/ !' X� / !' X�< !' X' < !' X'�, X� !'

������)8�, X� !' !����� �

�*�����=�

:��������-;

���"�����8����"����������"�����*�������-�����������&��������*��-������� ���

�� X� !' �� X� !'�� X' !' �� X' !'

Page 193: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

���������� ����!�5�����-������:�?(�,�; (,+

����- ��������������./����"�����0������1

�� ���������� ����!�5�����-������:�?(�,�; �����������������������������������������(,2��� $������ ��������������������������������������������������������������������������������������������������(,2��� ����-������������� ����������������������������������������������������������������������������(,/��' ������������ ����������������������������������������������������������������������������������������(,<

Page 194: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���"���� �'�$ ����8���$��)������=����-> ����������

(,/ ���������� ����!�5�����-������:�?(�,�;

�# ���"���� �'�$ ����8���$��)������=����->�#� 1��/����#�#� -5 �����$��)����������-

� *�������� ��� �����5�����-�����1��?(�,��� �����"������"� ���*�� �"��&����"������ ��?��������?(,+

�� ��� ���7��8��-�&�� ����� ��&&�������(���"� �"�����*����?��������?(,+�

'� ����-��������"&� �������5�&�����" ������"&� �������������1� ��������� ���.�� �?�@�����&���"�����������-������

��� !��?�@�����&���"�����������-�����E�"����������5�����"��������-����� �*����-���������������-�&���� �

���� .�� �?�@�����&���"�����������-�����E�"����������5�����"��������-����� �*����-� �"�����������-�&���� �

�'�� �*���� �-��&�� ����� ���������������*�&������������ �����������*���� ����������"������������*�&�������

:��������;��� ��������,��<+�2�8-�#��"�

9������ �:%��� �� ��-���5�����-����� ; 9������ ����-��������"� �?(,+ �?(�,� �?��

�"&� ��-� �� �����

!��?�@�����&���"���������9�'�1�9���)�����9��'(��:Z�;

.�� �?�@�����&���"���������9�'������X���)�:Z�;

���-��?��"&����������-�����

>� �-��&�� ���'��� ���:-��-��&�� ���;�V�'��2�8-#�"�

(�,� ���:-��-��&�� ���;�V�(,�/�8-#�"�

��+) ���:-��-��&�� ���;�V��/�,�8-#�"�

����-��������� ����*���������:��*��; �����������:���� �;$@������ ���������������:$>�; , , ,�,)

�"�� �������� !��� !��� !����������� !��� !��� !���

Pressure-Enthalpy curves of HFC-32/125 (50/50wt%)

Page 195: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������� ���"���� �'�$ ����8���$��)������=����->

���������� ����!�5�����-������:�?(�,�; (,<

� �*��"�����"����*�������� �������?(�,�

Temperature(°C)

Steam pressure (kPa)

Liquid Vapor

Density(kg/m3 )

Liquid Vapor

Specific heat at constantpressure (kJ/kgK)Liquid Vapor

Specific enthalpy(kJ/kg)

Liquid Vapor

Specific entropy(kJ/KgK)

Liquid Vapor

Page 196: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���"���� �'�$ ����8���$��)������=����-> ����������

(�, ���������� ����!�5�����-������:�?(�,�;

�#� ��$��)������&%/��!��'� �������� &���������� 2 �*������������ �&�����������-������������:&��8;�2 �*������������������ ��B��&&���5��*��� �&*��������

� 9������-����������� :�; 3�5 �������-������� �?(�,��� ���B������-� 1������*��9�-*?��� ����6� �������3�5�"� ������� ���������*������-��*�"��4������ ��-1����������*��9�-*?��� ����6� �������3�5��*��3�5� ��&����� � ������� �������-������� ��*���"� ���������5������&��������������� �5��*�*�-*?&�� ����-� � ��4�� �����������5��*����-������� �

:�; 9�����-����� �� �������?(�,��� �*�-*?&�� ����-� 1����� ��������������*�-*?&�� ������ �� ����*��-*��*� ���� �� ����������������� ����-1������� �*������-�������� ����"�-���*�������������������&�������������� ��>���������&��� �� 1������*�"����1��&&����"&�������������*�"�����*��-������

:'; �����-����*��-*��?(�,��� �������""����1����"� ����� �����������5���?����������1�����1��������8�&���������*�� �"��5���� �������*���*�-*?&�� ����-� � ���� *������� ������������*���*�-*?&�� ������ �� ������B��&&���5��*� ����������� ��*�������� � �-� �5*����*���"��������"&������������*� �"�����*�������������������:� �����&��-�"��� ;�����5*����*��&�� ���������� �����������������: &���-?��&�� ������������&����� ;�

Refrigerant can be charged in liquid state with cylinder in upright position.

Caution: Do not lay cylinder on its side during charging, since it cause refrigerant in gas state to enter the system.

Sip

hon

tube

Cylinder

Page 197: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������� ���"���� �'�$ ����8���$��)������=����->

���������� ����!�5�����-������:�?(�,�; (��

�#� ���L�"�� /'�?(�,��� �� ���������*�-*���5��8��-�&�� ���1���"&��������&������ �����-����� �:�?��1�?(,+;������*��"���1��*������-������-�"��*��������*� �������*��-�����"����� �����������*������1�����������"����-�� ���������1� ���-���� ��� �����*������-����� �������� � ���*���&�����" ���*������1�-��-��"������ ������*��-��*� � ��*�������� ���5��*���&������ �����-������:�?��1�?(,+;������������� ������&������ ��*���� ����5�����-����� �4�� �������� ���������������� ����������� �

� �������"&���������

� �����*���*��-��"���*&���������&��8��-1��#�%!��,�� ����� �������"���*&����� �@�����*��-��*� ��

� �&&��������"�������������*��8��

Z $E�����:��������;9E�9����:>��5�;

�����"&���������

��� �� �����*��-�9� 9��?(�,� �?(,+ �?��

6��-��"������*��-��*� � �

2>������� ���*�� �"������ �����?��������?(�,��

2�*����� &��������������� �����?(�,�������?(,+�

*��-��-��������� � � 27��-*���-��� ���"����� ������9� �6� ��������� � � 2�*�� �"��������������� ������9� �=����"�&�"&:&�"&�5��*������ ����5�&�����������������;

�2���� ����� ���-�&�"&����9� 1������"�&�"&����&����"� ������� �������

7��-*���-��� ���"��� �

*��-��"���*&���� �

2�����"��������� ������������5�����?�������9� �

2�*����� &������������ ������������5�����?(�,��������*�� �

������-������:����*���&�; � 2�����?(�,�1������-��-��� ����� �������B���5����* � 2���B��?�&�����#������)#/��&�������� �

��&����&����� �

��&�������� �

��&��� �"����-���� � 2>����������-������-�"��*���������*��-���:!������ �������������� ���;

����-��������������������� *��8����������������������

����-������&�&��- �����*���*��������5� 2$����φ�<���� ��*��-�������#�9�"��������5*�����*��&������ �"��������� �S$S�

Pipe size

φ6.4φ9.5

φ12.7φ15.9φ19.1φ22.2φ25.4φ28.6φ31.8φ38.1φ44.5

Ve-upR-407C

Material

OOOOO

1/2H1/2H1/2H1/2H1/2H1/2H

Ve-upIIR-410A

Material

OOOO

1/2H1/2H1/2H1/2H1/2H1/2H1/2H

Thicknesst (mm)

0.80.80.81.01.01.01.01.01.21.41.6

Thicknesst (mm)

0.80.80.81.01.01.01.01.01.11.41.6

Page 198: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���"���� �'�$ ����8���$��)������=����-> ����������

(�� ���������� ����!�5�����-������:�?(�,�;

�# ,/����)�� /

� �&���������� 2 >�"�� �����

� >������� 2 *��-������"�� �����

�����������������-����� ��������� ���5*����*��5��8�&���� �� ��*��-����:�*��-����5��8�&���� ;�������� ��1���&�&������� ����"��-�����,����,�)""�5� �&����������������-�������?(�,����������������� 1�&����"�&�&�������-�5��*���&�&������� ����"��-�������,������)""�:���������*���&������;������������������5��*�&�&������� ����"��-�����H� �"������������ ���

Flare gauge

Tube O.D.

Do

6.35

9.52

12.70

15.88

19.05

Class-2 (R-410A)

9.1

13.2

16.6

19.7

24.0

Class-1 (Conventional)

9.0

13.0

16.2

19.4

23.3

+0−0.4

Unit:mm

ANominal size

1/4

3/8

1/2

5/8

3/4

Dimension A

For class-1: R-407CFor class-2: R-410A

Page 199: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������� ���"���� �'�$ ����8���$��)������=����->

���������� ����!�5�����-������:�?(�,�; (�'

�# �F���8���"6

� �&���������� 2 >�"�� ����4 %���E""

!���*��-�������-*�����-����B��!���*��-�����&�&� �����*��� �@�

� >������� 2 *��-������"�� ����4$�����#�S1�)#/S�������������

�# 4�"���������8��6�"6�"I�L�/L�

� �&���������� 2 >� �*��-�� &��� � ���"�"���-�����������"),��#"���:),9@; ��������������"�&�"&�5*��*�� ���������8��&2,��#"���:2,9@; �*�������"���-�������*�� � ��"�������� ��

2 ��������&����%!�+#�2?�,:�#(������; Q�,,�+�8���:)�������Q�+))�""9-;�%!��#�?�,:)#�2������;�5��*����&���

� >������� 2 �B��&&���5��*������������&������������ ��������52 ������� ������"�&�"&��������� �������� ������-����&����

!�"����� �@� �� ?� �� ?� ������� �#� �( �2 �()#/ �+ �< �+

Dimension B

For class-1: R-407CFor class-2: R-410A

Vacuum pump adapterReverse flow preventive vacuum adapter

Page 200: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���"���� �'�$ ����8���$��)������=����-> ����������

(�( ���������� ����!�5�����-������:�?(�,�;

�# +��I���'���

� �&���������� 2 9����-�����������-���&�1�����2 �&&������������-����� �?(�,�1��?(,+1��?(,(�1��?),+�1��?�'(�1�����

� >������� 2 ������� ��� ��� �����������*��������������9� �����������������*������1���5��� ���������� �*����-���

�# ��$��)������ �/�=-���" ���/>

� �&���������� 2 ������ � ���*��������1��*������������������ ������&�&��-�5��8�������������-������������2 $�� �*�-*��� ���� � ���������� �����������������-�&����������"��

� >������� 2 ������� �������?(�,�������?������� �

;# H��)������$ /!�$ ������-

� �&���������� 2 9�-*�&�� ����-��-�?�,������)�'� ���:?+2��"9-����)'�8-#�"�;

2 3�5�&�� ����-��-�?�,������'�/� ���:?+2��"9-����'/�8-#�"�;

2 �#(S�→�)#�2S�:�"���→���)"��;2 !������� �� ������&�� ������ ����-��-� �

→ ����&�����������������"�������

Page 201: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������� ���"���� �'�$ ����8���$��)������=����->

���������� ����!�5�����-������:�?(�,�; (�)

2 ��"&�������� ������������� ��*���������� *�&����5����&�� ����������"&�����������-� � ��������� �����

� >������� 2 *��-�����&�� ���2 *��-����� �������&�������"����

@# &6��)��6 '��$ ������-

� �&���������� 2 7��8��-�&�� ����)�,/� ���:)��/�8-#�"�;2 ��&�����&�� �����)�(� ���:�)<�8-#�"�;2 ����������5��*�����5��*����*���?�&�������������*���&������ �����-��������"������5�

� >������� 2 ��� ����&����*� �2 *��-����� �������&�������"����2 % �����������������"�����������9���� � �����

# &6��)��)�"%/��!��

� �&���������� 2 % ��5��-*����������-�������*��-���� ��������5�����*��-�������������"�����-���������������

� >������� 2 �*����������������������� ������"���������-������ �����"����-�������� ��*��-��������-��*��-��-�

7*����?(�,��� ��*��-��������B���� ������ ��-��*��-��-���������1���"��-�&*���"������ �-����������� �����*��-��-����������

(Hose with ball valve)

Can not be used

Page 202: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

���"���� �'�$ ����8���$��)������=����-> ����������

(�2 ���������� ����!�5�����-������:�?(�,�;

N# (��)6���$ ����$��)������"6��)�

� �&���������� 2 9�-*������������,���:����,?8-���������;�V�_��-���,�4�:����,?8-���������;�V�_�)-

2 �B��&&���5��*�&�� ���?�� � ����� �-*��-�� �����*��8���B��������-�������*��-��-�2 ��"�������5��*� �&������&��� ����9� �����&������ �����-����� �� ��B��&&���� � ������������ ���� �

� >������� 2 �� ���"����� ��� ������5��-*�����&��������*��-����"����-������������-��*��-��-�

��#&6��)��� ��6���"�

� �&���������� 2 �����?(�,�1��#(S→�)#�2S�:�"���→���)"��;2 ��������� ��*��-�����"������9?!4��

� >������� 2 *��-�����*����� &��������������*� ������������� ����:�����*���?(�,��� �;2 *��-���� ������"������������*��9� �� ��

Page 203: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

����� (�+

��+,

�������������������������������������������������������������������������������2�2������������������������������������������������������������<1����1�����+����������������������������������������������������������������������������'�<��������������������������������������������������������������������)1���+�����"���>� �*��-����&����"&������������������������(<�����"���$����������� �������-���� ��������������������)�������������9�-*���� �����5���*�������������������������'+������������3�5���� ������� ���������������������������'<����� �>�&������������������@������������� �����',<����� �>�&��������1��"&��&���������-������������������'�,������������������������������������������������������������������������������<�X� ��������������������������������������������������������������������������',

44��8���7����*��8����*����������-�7��� ��������''+4��.�,�� ���������������������������������������������������������������22

#(���������������������������������������������������������������������������'�)���������������������������������������������������������������������������'�<���������������������������������������������������������������������������''�� �������������������������������������������������������������������������'(*��8��� ����������������������������������������������������������������''�*��8��,� ��������������������������������������������������������������'(,*��8���� ��������������������������������������������������������������'(�*��8���� ��������������������������������������������������������������'(�*��8��'� ��������������������������������������������������������������'('*��8��(� ��������������������������������������������������������������'((*��8��)� ��������������������������������������������������������������'()*��8��� ����������������������������������������������������������������''�*��8�'� ����������������������������������������������������������������'''*��8�(� ����������������������������������������������������������������''(*��8�)� ����������������������������������������������������������������'')*��8�2� ����������������������������������������������������������������''2*��8�+� ����������������������������������������������������������������''+*��8�/� ����������������������������������������������������������������''/*��8�<� ����������������������������������������������������������������''<*��8������ � ���>��&����3�5���� ���� ���������''2*��8������ � ����� �����9�-*���� �������������'')*��8������ � ���7���$&��������� �������������������'(,*��8����$����*��-��������-������� ������������������'(�*��8�����*����-��������-������� ����������������������'(�*��8������������������� �����:��5�����&&���

����;� �����������������������������������������������������������''�*��8�$&��������������������� �����������������������������<�*��8��*�������� ���$���*����$&�������� �����������'''X���������������������������������������������������������������������������')����&������������?�������� ������������� �����'()����#�9���� �����5���*��-�����������������������������������+(���������� ��� ���������� ����������������������������������))

2>�������������������4����� ���������������������������������2+>����������&�����������������-� ��� � �����������������)'

>� &����C%������������@���������D�4���8 �:��&��� �>������4���8;������������������������������������������������� '�2

>� &����C%������������@���������D�4���8 �:��&��� ����-���4���8;� ������������������������������������������������� '�'

>�����3�����������3�"������������������������������������������ ��<

5��������������������������������������������������������������������������� �'2�'� ������������������������������������������������������������������������ �'+�(� ������������������������������������������������������������������������ �'<�)� ������������������������������������������������������������������������ �(��2� ������������������������������������������������������������������������ �('�+� ������������������������������������������������������������������������ �((�<� ������������������������������������������������������������������������ �(+�������������&�� ����=����� ����������#�>� ��

��--��-� ������������������������������������������������������� ��)����������������������������>������ ��������������������� ��)

$�'� ������������������������������������������������������������������������ �(<�2� ������������������������������������������������������������������������ �)����� �����: ��;�3��81�$�������� ������������������������ ��<�������������������-��������&�����-� ������4��������

��������"�������������4����������������������� �/(������������-���"�$�������%���

3� ����������������-����" � ����������������������������� �2�������-����&� *������� 5���*� � �������������������� �22

��������������� �3������ ���������������������������������������� 2'���.�,�1����� ����������������������������������������������� 2(���.�(�1��2�� ����������������������������������������������� 2)���./�� ��������������������������������������������������������� 2'

�6� ��*����-������������������������������������������������������ �/2

9+������������������������������������������������������������������������� �)�9<������������������������������������������������������������������������� �)(

��"&��&����"����������������������$�������%��� 1�

�������%��� �������"��������������������������� ',)�"&��&����"�����������$&���������������� ����

�������@���������� �������������������������������������� '�/����������"&�� ��� �����3��8�������������������������� �(�����������"&�� ����������-��������� ������������������ �+)���������$���?��&&����������������������������������������� �/�

6X�� ������������������������������������������������������������������������ �))X/� ������������������������������������������������������������������������ �2�

73� ���������������������������������� � ����������������� '/�

�������%���� ���������������������������������������������������� '/2

Page 204: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

(�/ �����

$�������%���� ��������������������������������������������������'/�3� ������������?�������� ������������� � �����������'((3�����������-��5���*�����������������������������������������������(2

8 ����������������������������$�������%������

4����� ��������������������������������������������������������������� �������������&������>����"��������>������ �����', ������������>� �*��-����&���*��"� ����:�'��1�'��1�

''�;�����������������������������������������������������������������)2 ������������>�����3�������������� ��"�:��3;� ��+ �������������������������&�� ����=��������� �����+ ������������9�-*���� ������� �����������������������2' �������������������%�������� ��������������������������� �����������������������������-�������"&��������

�� ������������������������������������������������������������������2< �����������������������������-�������"&��������

�� ����� ��� ���������������������������������������������������/' ������������3�B������&���*��"� ������:�2������<�;�

������������������������������������������������������������������������2, ������������3�B������&���*��"� ������:�+�;�������2� ������������3�5���� ������� ��� ��������������������2) ������������ ����-���������������������&�� ����

=�����:0��F0)�;� �������������������������������������������(+ ������������$�������%�������� ����� �����������������(( ���������������������-�9�������*��-���6� ���&��

�*��"� ����:�)�;���������������������������������������������2� �������������5��-����&� �����: ��;� �����������������' �������������� ��"1�����-�������� ��"������ �

%��������������������������������������������������������������'�( ��������������"&����������� ������9����

���*��-���6� �:���;� ������������������������������������)+ �������������*��"� ����:���;��������������������'' �������������*��"� ����:���;����9�������*��-���

�'� �������������*��"� ����:�'�;����6� ���&� ������'� �������������*��"� ����:�(�;����>� �*��-�����������

�'( �������������*��"� ����:�(�;����$�������%����9����

���*��-���������������������������������������������������������)< �������������*��"� ����:�/�;��������������&�� �)/ �������������*��"� ������� ��������"����

���������� �������������������������������������������������������') ���������������� "� �������5�����������@���

���������������������%���� �����������������������������'�, ���������������� "� �������5���������������

$�������%��� �����*����"���� ��"����������������',( ���������������� "� �������5�����������%��� � ���

�<' ���������������� "� �������5�����������������

���������4������������������������������������������������+/ ���������������� "� �������5���� ������������

��"������������� � ���������������������������������������',' ���������������� "� �������5����$&�������

��������� �����������@��������������������������'�+ ���������������� "� �������5������"����

���������������������%���� ������������������������������<) � ����%��������������������������-������� ������''/ � ���?������%����������-������� ��������������������������''< ������"&�����!��"��� ������������������������������������(2 ����������-��5���*� ���������������������������������������������(2

�"�������$�����������������������"&�� ��� �+�1��+'

������� ���� ������������������������������������������������������ �+� ������������������ � ��������������������������������������� ''�

'$&��������3�"&�4���8 � ���������������������������������������� '��$�������%������4�����3������ ��������������������������� �(2$��������#�$�����������#�3��8����������%��������

����� ������������������������������������������������������������ ���

��4�����>����� ��������������������������������� ��21��'21�'�2��&��-�>��-��" � �������������������������������������������������� '(/

�������%���� ���������������������������������������������������� ')'$�������%���� ������������������������������������������������� '(/

��5�����&&����� ������������� ��������� ��������� ���/<

��5������� � ����*��8� �������������������������������������� ''(��������������$������� ���������������������������������������� ��<

�����-������������� ������������������������������������������������� )(

���������%����4��.�,�� ��������������������������������� 2,�������%��� � ���������������������������������������������������� 2����.�,�0�1����0�� �������������������������������������� )2���.�(�0�1��2�0�� �������������������������������������� )/���./�0�� ����������������������������������������������������� )(

����-���������5�������*�$&�������� ��������������� 2+���0.�,�1��(�1��2�� ������������������������������������ 2+���0.�,�� ����������������������������������������������������� +'

����-������$����*��-���������������������������������������� �)������ ���*� �1�$&����*� �������������������������������� �//

����� ����>� &����:3�>;��������������������������������������� �(2������-����&� *������� 5���*� ���������������������������� �22������-���3�5�!�� ��$&������������>�"����

$&�������� ����������������������������������������������������� �+<��>��"&�� ��� �����$����������#3��8����������� �('��"&��"?�� ���������� *�����-� ����������������������� �<2�� ��"�� ������������� ������������������������������������������ '�'

&���� "� ������������:���� �$�������%��� ;� ����� �<2������� *�����-�:$�E ���������"�������������;� ����

'�2������� *�����-�:$�E %������$!#$������������;�����

'��

9=����"��-�����>�*������������������� ������������� '('

:7����-�>��-��" ������������� ��������������������������� ')+

������7����-���������������������������������������������������� '2��������%���� ���������������������������������������������������� '2'$�������%���� ������������������������������������������������� ')+

Page 205: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

>��5��- �T����5�*��� (�<

2��/��"��3�$��/�#*����

������"���>� �*��-����&����"&������������������������(<�����"���$����������� �������-���� ��������������������)�������������9�-*���� �����5���*�������������������������'+������������3�5���� ������� ���������������������������'<����� �>�&������������������@������������� �����',<����� �>�&��������1��"&��&���������-������������������'�,

44��8���7����*��8����*����������-�7��� ��������''+4��.�,�� ���������������������������������������������������������������22

#���������"��-�����$&�������� ���������������������������//�������@����������6���&�!���������-�������������������)/

4�����&�� ��������������������������������������������������)/4�(���&�� ��������������������������������������������������)/4�+���&�� ��������������������������������������������������)/4�+����&�����������������������������������������������������)/6���&�!���������-����"&��� ����������������������������2,

*��8��� ����������������������������������������������������������������''�*��8��,� ��������������������������������������������������������������'(,*��8���� ��������������������������������������������������������������'(�*��8���� ��������������������������������������������������������������'(�*��8��)� ��������������������������������������������������������������'()*��8��� ����������������������������������������������������������������''�*��8�'� ����������������������������������������������������������������'''*��8�(� ����������������������������������������������������������������''(*��8�)� ����������������������������������������������������������������'')*��8�2� ����������������������������������������������������������������''2*��8�+� ����������������������������������������������������������������''+*��8�/� ����������������������������������������������������������������''/*��8�<� ����������������������������������������������������������������''<*��8������ � ���>��&����3�5���� ���� ���������''2*��8������ � ����� �����9�-*���� �������������'')*��8������ � ���7���$&��������� �������������������'(,*��8����$����*��-��������-������� ������������������'(�*��8�����*����-��������-������� ����������������������'(�*��8������������������� �����:��5�����&&���

����;� �����������������������������������������������������������''�*��8�$&��������������������� �����������������������������<�*��8��� � ���������������-�� ������������������������������'�<*��8��*�������� ���$���*����$&�������� �����������'''����&������������?�������� ������������� �����'()������ ���������� ��� � �����������������������������������2,

9�5�����������$&�������� ���������������������������2����������������-�$&�����������3�5�$�������

��"&�������� ���������������������������������������������������<(���������� ��� ���������� ����������������������������������))

2>�������������������4����� ���������������������������������2+>��������������-�������������3�5�!�� ��$&��������

����>�"�������������������������������������������������/'>� �*��-����&�������������������� ������������������������,�

>� &����C%������������@���������D�4���8 �:��&��� �>������4���8;������������������������������������������������� '�2

>� &����C%������������@���������D�4���8 �:��&��� ����-���4���8;� ������������������������������������������������� '�'

>�����3�����������3�"������������������������������������������ ��<>�������"&����������������������������������������������������� ��,

7*����*���������5���*�� ����&&�������C��D�� �>� &����������*����"�������������� ��,

7*����*���������5���*�� ����&&���5*�����*�������-��*��"� ����� �$����������������� ��,

7*����*���������5���*�� ����&&���7*�����*�������-��*��"� ����� �$!� ��������������� ��,

5�������������&�� ����=����� ����������#�>� ��

��--��-� ������������������������������������������������������� ��)�"��-�����$&�������� ����������������������������������������� �������������������������������>������ ��������������������� ��)

$���� �����: ��;�3��81�$�������� ������������������������ ��<�������������������-��������&�����-� ������4��������

��������"�������������4����� ����������������� �/(������������-���"�$�������%���

�����*��-��-�&����������� ������������������������� �22 �����*��-��-�&����������� ������������������������� �22������-����>�&��5���*� � �������������������������������� �2(

����@������������� ����������������������������������������������� ������������������ �3������ ���������������������������������������� 2'

���.�,�1����� ����������������������������������������������� 2(���.�(�1��2�� ����������������������������������������������� 2)���./�� ��������������������������������������������������������� 2'

�6� ��*����-������������������������������������������������������ �/2

9�-*���� ������������������������������������������������ <+

��"&��&����"����������������������$�������%��� 1�

�������%��� �������"�������������� ������������ ',)�"&��&����"�����������$&���������������� ����

�������@���������� �������������������������������������� '�/�� &������� ���� �������������������������������������������������� �,2����������"&�� ��� �����3��8�������������������������� �(�����������"&�� ����������-��������� ������������������ �+)���������$���?��&&����������������������������������������� �/���������������������������� ���������������������������������� �,�

73�5���� ���������������������� �������������������������� <<

8 ����������������������������$�������%������

Page 206: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

(�, >��5��- �T����5�*���

4����� ��������������������������������������������������������������� �������������&������>����"��������>������ �����', ������������>� �*��-����&���*��"� ����:�'��1�'��1�

''�;�����������������������������������������������������������������)2 ������������>�����3�������������� ��"�:��3;� ��+ �������������������������&�� ����=��������� �����+ ������������9�-*���� ������� �����������������������2' �������������������%�������� ��������������������������� �����������������������������-�������"&��������

�� ������������������������������������������������������������������2< �����������������������������-�������"&��������

�� ����� ��� ���������������������������������������������������/' ������������3�B������&���*��"� ������:�2������<�;�

������������������������������������������������������������������������2, ������������3�B������&���*��"� ������:�+�;�������2� ������������3�5���� ������� ��� ��������������������2) ������������ ����-���������������������&�� ����

=�����:0��F�0)�;� ������������������������������������������(+ ������������$�������%�������� ����� �����������������(( ���������������������-�9�������*��-���6� ���&��

�*��"� ����:�)�;���������������������������������������������2� �������������5��-����&� �����: ��;� �����������������' �������������� ��"1�����-�������� ��"������ �

%��������������������������������������������������������������'�( ��������������"&����������� ������9����

���*��-���6� �:���;� ������������������������������������)+ �������������*��"� ����:���;����$��������������)( �������������*��"� ����:���;��������������������'' �������������*��"� ����:���;����9�������*��-���

�'� �������������*��"� ����:�'�;����6� ���&� ������'� �������������*��"� ����:�(�;����>� �*��-�����������

�'( �������������*��"� ����:�(�;����$�������%����9����

���*��-���������������������������������������������������������)< �������������*��"� ����:�/�;��������������&���)/ �������������*��"� ������� ��������"����

���������� �������������������������������������������������������') ���������������� "� �������5�����������@���

���������������������%���������������������������������'�, ���������������� "� �������5���������������

$�������%��� �����*����"���� ��"����������������',( ���������������� "� �������5�����������%��� � ���

�<' ���������������� "� �������5�����������������

���������4������������������������������������������������+/ ���������������� "� �������5���� ������������

��"������������� � ���������������������������������������',' ���������������� "� �������5����$&�������

��������� �����������@��������������������������'�+ ���������������� "� �������5������"����

���������������������%����������������������������������<) � ����%��������������������������-������� ������''/ � ���?������%����������-������� ��������������������������''< ��*�����*��8��-��*����������G ���5������� � ��� �

����>����� ����� � ���������������������������������������(,) �"�������$�����������������������"&�� ��� �+���

������������������������������������������������������������������������+' ������� ���� ��������������������������������������������������������+� ������������������ � ����������������������������������������''�

'$&������-��������������������������"&�� �� � �� /)$&��������3�"&�4���8 � ���������������������������������������� '��$�������%������4�����3������ ��������������������������� �(2$���������������� ������������������������������������������������ ��'$��������#�$�����������#�3��8����������%��������

����� ������������������������������������������������������������ ���

��4�����>����� ��������������������������������� ��2���'2��'�2��&��-�>��-��" � �������������������������������������������������� '(/

�������%���� ���������������������������������������������������� ')'$�������%���� ������������������������������������������������� '(/

��5�����&&����� ������������� ��������� ��������� ���/<

��5������� � ����*��8� �������������������������������������� ''(��� ������� ��� ������������������������������������������������� (,(

�����-������������� ������������������������������������������������� )(

���������%������������������������������������������������������� 2,�������%��� � ���������������������������������������������������� 2����.�,�0�1����0�� �������������������������������������� )+���.�(�0�1��2�0�� �������������������������������������� )<���./�0�� ����������������������������������������������������� ))

����-���������5�������*�$&�������� ��������������� 2+���0.�,�1��(�1��2�� ������������������������������������ 2+���0.�,�� ����������������������������������������������������� +'

����-������$����*��-���������������������������������������� �)���"�����������������?>��-�� � ���������� �������� �,+��"���������������������� ���� ������������������������ �,(����� ���*� �1�$&����*� �������������������������������� �//

����?���-�� � ����7�������"�������������� �������� �,,���?���-�� � ����7����� ���"�������������� ���� �,�������-���3�5�!�� ��$&������������>�"����

$&�������� ����������������������������������������������������� �+<�"�-����$&������������*��� ������ ���� �/,���/��"�-����$&������������*��� ����������4� � �/,��

�/��"�-����$&������������*��� ����4� ���� �/,���/�

��"&��������"�������������� ������������������������������ �(<4���)�1�4��)�������������������������������������� �(<

��>��"&�� ��� �����$����������#3��8����������� �('�� ��"�� ������������� ������������������������������������������ '�'

&�� ��$&�������� ���������������������������������������������������� ��/�*��"� ������� ��������"�������������������������� ��2

�����-����������������������������������������������������������� ��29�����-� ��������������������������������������������������������� ��+

���� "� ������������:���� �$�������%��� ;� ����� �<2������� *�����-�:$�E ���������"�������������;� ����

'�2������� *�����-�:$�E %������$!#$������������;� ���

'��������� *�����-������"�������������� ��������������� �<<

:7�������"��������������������������������������������������� �(+

Page 207: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

>��5��- �T����5�*��� (��

7����� ���"��������������?��������%���4�(���&�� ��������������������������������������������������(/4�+���&�� ��������������������������������������������������(/4�+����&�����������������������������������������������������(/

7����-�>��-��" �����������������������������������������')+������7����-�����������������������������������������������������'2��������%���� �����������������������������������������������������'2'$�������%���� ��������������������������������������������������')+

Page 208: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������

(�� >��5��- �T����5�*���

Page 209: igclima.comigclima.com/dvd-daikin/2_VRV/Documents/4_+_VRV... · ˜ ˘5/ ’6 ˚) 5% ˛˚ !" ˚ ˚ 6 ˇ & ˚ ˜ / * - ˇ ) # ˜ ˘5/ ’6 ˚) 5% ˛˚!" ˚ ˚ 6 ˇ & ˚ ˜ / # CA0D

����������� �

��������� �� � �� �� ���� � ������� ������ � ����� �������� ������ ������� ��������� ������ �� � ������� ��� ����� �� � ��� ����� ������ ��� ���������� �� �������� ��� ���� � ��� ��� ��� ��������������������������� ������������� � ������� ���

�� ��� !���� � "�#�� �� ����� �� $�� %&'(� ���� ���'�����)�� � ��� ��� �� ��� ������� � *���� �� � ���+�������������+����� ������������������� �� ������� ������ � ���� �����������������* ������� ���� � �� ������� ����������

�� ��� ����� ������� *���� �� � !���� �� � �������� �������� ��� �� �������� ���������

��!"

,!-�

./��

�0��1

23��/

�0�4�

�����

���g��

� ��

5� �

� �

����, ��

����$�

�%��

����6**

*���

����

�����$

7��

�����

���*

��

�����

����

����

� ����

����

�����

����

��� �!

)(���

�����

�����

���

� ���

& �

���$

� �!�

����8��

� ���!

����

�"�#���9

���

����

����

-����

,.�/�

����

�� �

:� ��� �����$������������*�����$��*�������������������������� ������������ ������ ��$�������������� ���!���� �"�#����� ���!���� �"�#��������� �� �� � ���� ��� ��� ���� ��$�������� ��� �� � $ �� ��� ��� ��*� �� �� "� ;�� � ��� ����� �� *������ �� ��� �� ���� �� � ����� � � �� �������� ��$������������� ������������������� ����������� �������� ����������� ���� � �� �� �� �� � ���� �� ���������� � � �$< ��� ��� ���� � *����������������� ���� ���!���� �"�#�� ;���������� < ��������$���������������� ���������� ������ �������� �$��� �� � ����������������� �� ������� �� ��2������ ��� ���������������$���������(������� �������������� ��$���� ��!���� �"�#��

�� ��=� ����� � �������� � � �������� �� ��� ��������������� ����� ���� ����� ��� ��� ���� ���� �� � �� ��� ��� ��� � ������ � ��� �� ������� ���� �� �� >��� � ��� � �� �� ��� ������ ���� ��������$ ��� ��� � ������� ������������ �������� ���� �� � ����� �� ������ ��� �� ������� ����:������� �� �� ������ � ���� ������� � ���� �������*�� ���� ���������������� � ���� ��� � ��� �� ��� � ������� ��� � ������ ������������ �����������*� �

#&#� �������� � � ���� *������ �� � ��� � ��� �� � !���� ��� ������������������ �

!��"��@��=������ �*�&N��������� ������',,4?/(,,�$� ������?�4��-��"555����8�����4�7E�4��,(�����,�''2����$� �����