Upload
devi-renewable-energies
View
165
Download
5
Embed Size (px)
DESCRIPTION
Module 6: Basic design parameters for commercially viable on-grid biomass gasification heat and power plants (Training on "On-Grid Applications of Biomass, Biogas and Waste-to-Energy Power Plants for " in HN on December 10-12, 2013)
Citation preview
1
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 1
Ứng dụng nối lưới của năng lượng sinh kh ối, khí sinh h ọc và ch ất th ải
cho nhà máy điện Việt Nam
Đào tạo ngắn hạn
10/11, Tháng 12, 2013, Hà Nội
(Mirko Barz)
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 2
On-Grid Applications of Biomass, Biogas and Waste-t o-Energy Power Plants for Vietnam
Short Term Training Seminar
December 10th – 11th, 2013, Hanoi
(Mirko Barz)
2
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 3
Nội dung
- Cơ sở khí hóa- Các khái ni ệm khí hóa quy mô l ớn- Các khái ni ệm khí hóa quy mô nh ỏ
Module VICác thông số thiết kế cơ bản (kỹ thuật và kinh tế) cho các nhà máy nhiệt và điệnnối lưới thương mại (90 phút)Chuyên gia kỹ thuật.
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 4
Content:
- Gasification basics- Large scale gasification concepts- Small scale gasification concepts
Module VIBasic design parameters (technical and economic) for commercially viable on-grid biomass gasification heat and power plants (90 minutes)Technical Expert.
3
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 5
Tổng quan các Công ngh ệ chuy ển đổi Nhi ệt Hóa
Nhiệt phân Khí hóa Đốt nhiệt
Chuyển đổi nhiệt hóa các nhiên liệu rắn
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 6
Overview Thermo chemical conversion Technologies
4
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 7
Nhiệt hóa sinh kh ối
Giới thi ệu
Định ngh ĩaKhí hóa là chuyển hầu như hoàn toàn nhiên liệu rắn ở nhiệt độ cao sang dạng nhiên liệu
khí (thứ cấp) (được gọi là khí đốt hay khí tổng hợp)
Khí hóa – cũng như phân ly nhiệt phân – là một bước trung gian để hoàn thiện quá trình ô xi hóa hoàn toàn các loại nhiên liệu rắn sinh học.
Trong thực tế, khí hóa được sử dụng như một quá trình đặc biệt để sản xuất ra khí có thể đốt cháy, khí này được sử dụng chẳng hạn như để phát điện trong ICE hoặc nhiên liệu sinh học thứ cấp cho ngành sản xuất di động or secondary biofuels for the mobility sector.
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 8
Gasification of Biomass
Introduction
Definition:
Gasification is targeted to convert a solid fuel at high temperatures most probably completely into a gaseous (secondary) fuel (called burning gas or synthesis gas).
The gasification is - same as the pyrolytic decomposition - an intermediate step towards to the complete oxidation of biogenic solid fuels.
In practice, gasification is used as an special process to produce burnable gases, which can be used e.g. to generate power in ICE or secondary biofuels for the mobility sector. ,
5
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 99
Sản phẩm của khí hóa = Khí nhiên li ệu hay khí có th ể đốt cháy
Để phát điện bằng các động cơ chạy bằng khí nhiên liệu, tuabin khí, pin nhiên liệu.
Mục tiêu: khí sạch, khả năng đốt cao, giá trành thấp.
Khí tổng hợp (hỗn hợp từ CO và H2)
Để sản xuất các chất hóa học trong sử dụng năng lượng, dự trữ năng lượng, vận chuyển nhiên liệu, các chất hóa học cơ bản.
Mục đích: Khí tổng hợp sạch ở các điều kiện thích hợp để tổng hợp khí cótính xúc tác hơn.
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 1010
Product of gasification = Fuel gas or combustible gas
For generation of electricity by fuelling gas engines, gas turbines, fuel cells
objective : clean gas, high heating value, low cost
Synthesegas /synthesis gas (mixture from CO and H 2)
For production of chemicals for energetic utilization, energy storage, transportation fuels, base chemicals
Aim : clean synthesis gas at right conditions for further catalytic gas synthesis
6
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 11
Giới thiệu
Trong quá trình khí hóa, các sản phẩm nhiệt phân của một nhiên liệu sẽ được chuyển thành các thành phần là khí có thể đốt cháy (H2, CO, CH4) bằng phản ứng tiếp nối với một trung gian khí hóa (như không khí, hơi nước, ô xi) Tỷ lệ khí thừa sẽ là >0 và <1 (0.25 là giá trị thực tế)
Source: Kaltschmitt, Energie aus Biomasse
Khí hóa sinh kh ối H
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 12
Introduction
During gasification the products of the pyrolytic decomposition of a fuel will be transferred in burnable gaseous components (H2, CO, CH4) by further reaction with a gasification media (e.g. air, steam, oxygen).
The excess air ratio will be > 0 and < 1 (0.25 as a practical value)
Quelle: Kaltschmitt, Energie aus Biomasse
Gasification of Biomass
7
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 13
Thành phần khí nhiên liệu phụ Thuộc vào tỷ lệ không khí thừa
Thành ph ần chính c ủa khí tổng hợp
CxHyH2CO
Các thành phần khác-CO2 (và nếu không khí được sử dụng Như chất trung gian khí hóa N2)
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 14
Fuel gas composition dependingon the excess air ratio
Main components of a Syngas:
CxHyH2CO
Further components -CO2 (and if air is used as gasification media N2)
8
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 15
Lịch sử của khí hóa biogas bắt đầu từ thế kỷ thứ 17 (nỗ lực đầu tiên trong việc khí hóa than và vật liệu hữu cơ, như than bùn)
The first patents (by Robert Gardner and John Berber) in the 18 Century.
1792 William Murdock developed a gasifier using coal
năm 1812, hội khí hóa than bùn đầu tiên được thành lập ở London.
Cuối thế kỷ thứ 18, Leben thực hiện những thử nghiệm đầu tiên về khí hóa gỗ. � Các ứng dụng thương mại bắt đầu từ khoảng 1830 (lò trục để khí hóa than bùn (bởi Carl
Bishop Mägdesprung – Germany
Siemens bắt đầu bán lò khí hóa năm 1857
Ứng dụng lớn đầu tiên là sản xuất khí cho thành phố từ than để thắp sáng cho phố xá ở các thành phố lớn.
History of biomass gasification Lịch sử của khí hóa biogas
Bild rechts: Stahlofen zur Kohlevergasung
Bild links: Gaswerke zur StadtgaserzeugungH
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 16
The history of biomass gasification goes back to the 17th Jarhundert(first attempts to gasification of coal and organic material, eg peat).
The first patents (by Robert Gardner and John Berber) in the 18 Century.
1792 William Murdock developed a gasifier using coal.
In 1812 the first society of coal gasification was founded in London.
At the end of the 18th century Lebon carried out first experiments on wood gasification� first commercial applications from about 1830 (e.g. 1839 ... of the shaft furnace
for gasification of peat (by Carl Bishop in Mägdesprung – Germany)
Siemens started in 1857 to the sale gasifiers.
The first major application was the production of town gas from coal for street lighting in big Cities.
History of biomass gasification
Bild rechts: Stahlofen zur Kohlevergasung
Bild links: Gaswerke zur Stadtgaserzeugung
9
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 17
Khí ga đô thị.... Sử dụng khí có thể đốt được sản xuất từ than để thắp sáng, nấu và gia nhiệt ở nhiều thành phố châu Âu và bắc Mỹ cho đến khoảng 1980....... Sau đó sử dụng khí tự nhiên.
► 1926 Winkler-Wirbelschichtvergaser, ► 1931 Lurgi-Festbettvergaser,► 1940er Koppers-Totzek-Flugstromvergaser
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 18
Town gas …. Use of a burnable gas produced from coal for lighting, cooking and heating in many European and Northamerican Cities until approx. 1980 ….…. later use of natural gas
► 1926 Winkler-Wirbelschichtvergaser, ► 1931 Lurgi-Festbettvergaser,► 1940er Koppers-Totzek-Flugstromvergaser
10
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 19
Ví dụ về khí hóa than ở Berlin (Prenzlauer Berg)
Kế hoạch được thực hiện năm 1871. Chỉ 2 năm sau (1873), việc sản xuất gas được bắt đầu.
Nhu cầu gia tăng dẫn tới mở rộng sản xuất. Sản lượng khí năm 1898 là 300000 m3/ngày.
Năm 1979, cung cấp gas ở đông Berlin thay đổi từ ga đô thị sang ga tự nhiên. Đóng cửa nhà máy vào tháng 5/1981
Phá nhà máy vào tháng 7/1984
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 20
Example coal gasification in Berlin (Prenzl. Berg)
Planning's to construct the IV. Städtischen Gasanstalt started 1871 Only 2 years later (1873) gas production started.
Increased demand resulted in extension of the production. The daily gas production 1898 was 300 000 cbm.
1979 the gas supply in eastern Berlin changed from town gas to natural gas. Shut down of the plantstarted in May 1981.
Blasting of the plant July 1984
11
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 21
Khí hóa sinh khối
Lịch sử• Khí hóa không phải là một công nghệ mới, nó được bắt đầu vào những năm 1800 và sử dụng ga đô thị để thắp sáng và nấu nướng từ than.
• Lò khí đốt loại nhỏ được sử dụng cho các loại xe có động cơ đốt trong khi khan hiếm nhiên liệu trong Thế chiến thứ hai.
• Vào những năm 1920, bếp khí hóa từ gỗ dùng cho các loại xe là thịnh hành nhất vào cuối Thế chiến thứ hai, khi nhiên liệu hóa thạch khan hiếm (500.000 lò khí đốt được sản xuất mỗi năm)
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 22
Biomass Gasification
History
• Gasification is not a new technology, it was origin ally developed inthe 1800s and used to make town gas for lighting an d cooking from coal.
• Small scale gasifier were also used to power intern al combustion engine vehicles during fuel shortages during the Second Wo rld War.
• The in the 1920s developed by Imbert wood gasifier to powerMotor vehicles had Its peak at the end of the secon d world war, when fossil fuels were rare. (500.000 gasifier produced per year)
12
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 23
Do nhiên liệu hóa thạch có nhiều ưu thế và gas không được sử dụng rộng rãi, chủ yếu là do chất lượng gas (gas sản xuất ra không đáp ứng yêu cầu cho các động cơ), khí hóa từ gỗ đánh mất vai trò quan trọng.
Vào những năm 70, mối quan tâm về khí hóa sinh khối lại tăng lên.
Nguyên nhân� Khủng hoảng dầu năm 1973...-> phát triển các loại năng lượng thay thế ở nhiều
quốc gia không có nguồn năng lượng hóa thạch. � Phát triển kiến thức kỹ thuật về năng lượng thay thế và các quá trình chuyển đổi
nhiệt hóa� Nhiều nhiên cứu về lĩnh vực khí hóa sinh khối
Lịch sử Khí hóa sinh kh ối
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 24
Caused by the more advantageous fossil fuels and the lack of broad acceptance,mainly due to the problem of gas qualities (The produced gas did not meet the requirements of the engines ) wood gasification lost again importance.
In the seventies, there was again a growing interest in the biomass gasification.
reasons:
� Oil crisis 1973 … � Development of alternative energies in countries that have no ownfossil energy resources,
� Development of technical knowledge about alternative energies and thermochemical conversion processes
� Increased research in the field of biomass gasification
History of Biomass Gasification
13
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 25
Khí hóa sinh kh ối ngày nay
Mục tiêu thay đổi theo thời gian:
Vào những năm 2000, nhiên liệu dùng cho xe cộ
Mục tiêu ngày nay: chuyển sinh khối có thể khôi phục thành điện năng để có thể thay thế nhiên liệu hóa thạch
Picture: Khí hóa sinh khối để cung cấp nhiệt và điện ở Güssing (Austria)
Since 2001
Bio SNG
Power
Heat
BtL fuel
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 26
Biomass gasification today
Modified objective over time :
In the 20’s � fuels to drive vehicles
Aim today � convert the renewable source biomass into electrical energy to have alternatives to fossil fuels .
Bild: Biomass gasification for heat and power supplyGüssing (Österreich)
Since 2001
Bio SNG
Power
Heat
BtL fuel
14
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 27
Sơ đồ trình t ự quá trình khí hóa sinh kh ối ở nhà máy Güssing
Công suất nhiên liệu 8 MW Nhu cầu nhiên liệu: Khoảng 2.2t/h (bào gỗ, 20% hàm lượng nước)Điện luơngj: 2 MWel
Công suất nhiệt: 4,5 MWth
Nguồn: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Báo cáo DA, Trung tâm năng lượng Güssing, HT năng lượng cho tương lai
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 28
Flow chart of the Biomass Gasification PP in Güssin g
Total fuel capacity: 8 MW
Fuel demand: approx. 2,2 t/h (woodchips, 20 % water content)
Power: 2 MWel
Thermal capacity: 4,5 MWth
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
15
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 29
Mục tiêu d ự án mới (Ứng dụng nối lưới cho sinh kh ối hơn là điện)
Sinh khối
Khí hóa Làm sạch khí
Động cơ dùng
khí
Làm sạch khí + tạo điều kiện
Nhiệt Điện
FT fuel (BtL)Bio SNG
Nhà máy hiện tạiNhà máy mới đang được xây dựng
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 30
New project target(On grid Application for Biomass is more than power )
Biomass
Gasification Gas cleaning
Gas engine
Pure gas cleaning + conditioning
Heat Power
FT fuel (BtL)Bio SNG
Existing plant New plant in preparation
16
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 31
Sơ đồ cho nhà máy hi ện đại mới
Nguồn: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Báo cáo DA, Trung tâm năng lượng Güssing, HT năng lượng cho tương lai
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 32
Flow chart for the advanced new plant
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
17
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 33
Hoạt động ở nhà máy hi ện tại
Nguồn: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Báo cáo DA, Trung tâm năng lượng Güssing, HT năng lượng cho tương lai
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 34
Demonstration at the existing plant
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
18
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 35
Thông s ố để tính toán chi phí c ủa nhà máy m ới
� Giá nhiên liệu (bào gỗ) : 16 €/MWh (tương đương 70 €/t) � Lợi tức từ điện : 130–160 €/MWh (tương ứng với “Ökostromgesetz 2002” và
“Ökostromverordnung 2002” (phụ thuộc vào quy mô nhà máy)) � Lợi tức từ nhiệt 20 €/MWh� Thời gian hoạt động kinh tế của nhà máy: 15 năm. � Vốn tín dụng: 5 %
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 36
Parameter for the cost calculation of the new plant
� Fuel Price (wood chips): 16 €/MWh (respectively: 70 €/t) � Revenues Power : 130–160 €/MWh (corresponding to “Ökostromgesetz 2002” and
“Ökostromverordnung 2002” (depending on the plant scale))
� Revenues Heat: 20 €/MWh� useful economic life time of the plant: 15 years� credit capital: 5 %
19
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 37
Kịch b ản thương m ại
Plant typ CHP CHP + FTS CHP + partlyBio SNG
CHP + full Bio SNG
Tổng Đầu tư [€] 25.000.000 35.000.000 33.000.000 35.000.000
Công suất nhiên liệu[MW]
30 30 30 30
Nhiên liệu sản xuất[MW]
- 7.9 8.2 16.7
Điện sản xuất[MW]
10 5.7 5.7 1.5
Nhiệt sản xuất[MW]
14.9 10.7 12.2 7.2
Nguồn: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Báo cáo DA, Trung tâm năng lượng Güssing, HT năng lượng cho tương lai
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 38
Scenario for the commercial implication
Plant typ CHP CHP + FTS CHP + partlyBio SNG
CHP + full Bio SNG
Total Investment cost [€]
25.000.000 35.000.000 33.000.000 35.000.000
Fuel capacity[MW]
30 30 30 30
Produced Fuels[MW]
- 7.9 8.2 16.7
Produced Power[MW]
10 5.7 5.7 1.5
Produced Thermal En.[MW]
14.9 10.7 12.2 7.2
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
20
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 39
Tính toán th ương m ại với khái ni ệm mới
Plant type CHP CHP + BtL CHP +
partl. SNG
CHP + full
SNG
Kinh phí
Chi phí nhiên liệu 3,360,000 3,360,000 3,360,000 3,360,000
V.liệu hoạt động(€/năm) 656,000 1,988,000 1,494,000 2,313,000
Nhu cầu điện cho NM (€/năm) 840,000 2,030,000 1,750,000 2,030,000
Chi phí nhân sự (€/năm) 400,000 400,000 400,000 400,000
Chi phí bảo dưỡng (€/năm) 688,000 572,000 552,000 350,000
Chi phí vốn(€/năm) 2,409,00 3,372,000 3,279,000 3,372,000
Lợi nhuận
Điện (€/năm) 7,140,000 5,976,000 5,985,000 1,680,000
Nhiệt (€/năm) 2,086,000 1,496,000 1,708,000 1,008,000
From selling fuels [€/y] – Từ bán nhiên liệu - 5,121,000 3,915,000 10,010,00
0
Chi phí sản xuất nhiên liệu với lợi nhuận hàng năm là 873,000 € (cơ bản của CHP)
Chi phí sản xuất nhiên liệu 1,03 €/l 0,68 €/m³ 0,86 €/lSource: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 40
Financial calculation for the new concepts
Plant typ CHP CHP + BtL CHP + partl. SNG CHP + full SNG
Costs
Fuel cost 3,360,000 3,360,000 3,360,000 3,360,000
Operarion material [€/y] 656,000 1,988,000 1,494,000 2,313,000
Plant power demand [€/y] 840,000 2,030,000 1,750,000 2,030,000
Personal cost [€/y] 400,000 400,000 400,000 400,000
Maintanance cost [€/y] 688,000 572,000 552,000 350,000
Capital cost [€/y]
(pay back, interest)
2,409,00 3,372,000 3,279,000 3,372,000
Revenues
Power [€/y] 7,140,000 5,976,000 5,985,000 1,680,000
Heat [€/y] 2,086,000 1,496,000 1,708,000 1,008,000
From selling fuels [€/y] - 5,121,000 3,915,000 10,010,000
Fuel production cost assuming a anual revenue of 873,000 € (baseline CHP)
Fuel production cost 1,03 €/l 0,68 €/m³ 0,86 €/l
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
21
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 41
Các k ịch b ản – Cơ cấu chi phí
CHP + FTS
Chi phí vốn
Chi phí nhiên liệu
Nguồn vận hành
Chi phí nhânsự
Chi phí bảo dưỡng
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 42
Scenarios – cost structure
CHP + FTS
Capital cost
Fuel cost
Operating ressources
Personal cost
Maintanance cost
Source: Hofbauer, Rauch, Fürnsin, (TU Wien) Aichernig (Repotec), Project Report „Energy centre Güssing, Energy systems for the future)
22
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 43
Khu vực sấy khô
KV nhiệt phân
Fuel
KV giảm s
KV ô xi hóaKV giảm sút
KV nhiệt phân
KV sấy khô
Fuel
Khí tổng hợp
Syngas
Lò khí đốt hỗn hợpLò khí đốt dòng ng ược
Các ứng dụng quy mô nh ỏH
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 44
Drying zone
Pyrolysis z.
Fuel
Reduction z
Oxidation z. Reduction z.
Pyrolysis z.
Drying zone
Fuel
Syngas
Syngas
Co-current gasifier Counter-current gasifier
Small scale applications
23
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 45
4 quy trình phân biện xảy ra trong lò:
• Sấy khô nhiên liệu• Nhiệt phân• Đốt một phần (các quá trình • Giảm sút
Khí hóa sinh kh ối – Thí dụ về lò khí đốt H
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 46
4 distinct processes take place in a gasifier:
• Drying of the fuel • Pyrolysis• Partly Combustion
(autotherm processes)• Reduction.
Biomass Gasification – Example downdraftgasifier
24
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 47
Ankur downdraft gasifier (Indian Product)Lò đốt hướng xu ống (sản ph ẩm của Ấn độ)
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 48
Ankur downdraft gasifier (Indian Product)
25
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 49
Khí hóa sinh kh ối sử dụng ch ất th ải từ tre ở Thái Lan [70kW]
Product of a community owned fabric:
Sản xuất: Đũa, que xiên nướng
Phần dư
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 50
Example Biomass gasification [70 kW] using Bamboowaste in Thailand
Product of a community owned fabric:
Chopsticks, grill spits.
The residue:
26
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 51
Gasifier typ: downdraft (Ankur system)
Loại lò nung: Hướng xuống (hệ thống Ạnkur)
Khí hóa sinh kh ối sử dụng ch ất th ải từ tre ở Thái Lan [70kW]H
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 52
Gasifier typ: downdraft (Ankur system)
Example Biomass gasification [70 kW] using Bamboowaste in Thailand
27
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 53
Động cơ gas (đơn giản, khỏe)
Khí hóa sinh kh ối sử dụng ch ất th ải từ tre ở Thái Lan [70kW]H
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 54
Gas engine (simple, robust)
Example Biomass gasification [70 kW] using Bamboowaste in Thailand
28
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 55
Cần phải làm sạch khí, quá trình phức tạp
Khí hóa sinh kh ối sử dụng ch ất th ải từ tre ởThái Lan [70kW]
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 56
Complex gas cleaning required
Example Biomass gasification [70 kW] using Bamboowaste in Thailand
29
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 57
Downdraft gasifier - duel fuel engine in Prachuabkirikan province
Lò nung hướng xuống – động cơ nhiên liệu kép ở tỉnh Prachua
Các thí dụ khác ở Thái Lan
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 58
Downdraft gasifier - duel fuel engine in Prachuabkirikan province
Other examples from Thailand
30
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 59
Động cơ với Lò nung hướng xuống – tỉnh Nakor
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 60
Downdraft gasifier - engine in Nakornrachasima province
31
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 61
Các thí d ụ khác ở Thái Lan: Các gi ải pháp r ất đơn gi ảnH
TW
–U
T/R
E
GIZ Training RE Vietnam_Dec. 2013 - 62
Other examples from Thailand: extreme simple soluti ons
32
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 63
Các thí d ụ khác ở Thái Lan: Các gi ải pháp r ất đơn gi ản
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 64
Other examples from Thailand: extreme simple soluti ons
33
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 65
Thảo lu ận nhóm
Vấn đề này sinh từ việc sử dụng các biện pháp đơn giản như vậy?
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 66
Group discussion
What are the problems of using such simple solutions?
34
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 6767
Synthesis gas utilization
Tình tr ạng khí hóa c ố định đế ở Đức
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 6868
Synthesis gas utilization
Status of fixed bed gasification in Germany
35
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 6969
Synthesis gas utilizationTình tr ạng khí hóa c ố định đế ở Đức
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 7070
Synthesis gas utilization
Status of fixed bed gasification in Germany
36
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 71
Nhà máy điện khí hóa ở Urugoay
Direct Combustion of gases / Application in thermal power plants
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 72
ERK Gasification Power Plant in Uruquay
Direct Combustion of gases / Application in thermal power plants
37
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 73
Thảo lu ận nhóm cu ối cùng
Giải pháp phù hợp nhất ở Việt Nam là gì?
HT
W –
UT
/RE
GIZ Training RE Vietnam_Dec. 2013 - 74
Final group discussion
What could be the most appropriate solution for Vietnam?