BR 850SC SBG SPECIAL - Interline Brands · 2016-02-23 · 18 56009052 1 WSH, INT SHPRF 5/16 NI 56477613 9 Cable Tie E00549 Re409S Not shown NI 56478246 5 Cable Tie E00549 Re438B Not

Part List English

19-12-2014

Model: NILFISK BR850S C SBG

BR 850SC SBG SPECIAL

Table of ContentsBR 850SC SBG SPECIAL

Chassis system 3Decal system 5Drive and brake pedal assemblies 7Electrical Panel Assembly 9Front wheel assembly 11Motor, front drive wheel 13Recovery system 15Scrub system-cylindrical (BR 850S) 18Service part 56407431 21Scrub system - Disk 23Skirt assemblies-cylindrical 26Skirt assemblies-Disk 28Solution system (standard) 30Squeegee assembly 33Squeegee system 35Steering column assembly 37Wiring diagram 39Optional kits and accessories 42Brush Selector Guide-Cylindrical 44DRIVE WHEEL HARNESS KIT 56316637 46CONTROL BOARD KIT 56390780 48

Chassis system BR 850SC SBG SPECIAL

19-12-2014

3

Part List IDBR85003

Chassis system 19-12-2014

BR 850SC SBG SPECIAL 4BR85003

Part List ID

Pos Qty DescriptionPart no.1 156478246 Cable Tie E00549 Re438B

2 256001879 Washer f lat Sae 1/2

3 156002461 SCR,HEX THD TO HD 5/16-18

4 156002959 Pin Cot Hair SS.125x.5dia

5 256003412 SCR, HEX NYL LOC M12-1.75

6 256003442 Screw

7 156009086 5/16-18 JAM NUT

8 256009122 WASHER, FLT .344X.938X.12

9 256367117 Washer

10 256367206 Bushing Cv 32G

11 456412122 TRIM EDGE

12 156009062 SCR PHIL THD1/4-20X-20X.5

13 256420160 Bearing Flange

14 456111531 BEARING BALL

14 256382693 EACH ASSEMBLY INCLUDES TWO BEARINGSWHEEL

15 156314152 PIN ACTUATOR

16 156314495 LINKAGE ARM WELDMENT

17 156390803 WELDMENT CHASSIS

18 156009052 WSH, INT SHPRF 5/16

NI 956477613 Not shownCable Tie E00549 Re409S

NI 556478246 Not shownCable Tie E00549 Re438B

Decal systemBR 850SC SBG SPECIAL

19-12-2014

5

Part List IDBR850SBG05

Decal system 19-12-2014

BR 850SC SBG SPECIAL 6BR850SBG05

Part List ID

Pos Qty DescriptionPart no.1 156014450 DECAL PATENT

2 156014601 DECAL, CAUTION

3 156016348 DECAL LOGO

4 156015179 DECAL EMERGENCY

5 256380638 DECAL-BR850S SBG SPECIAL

6 156015242 DECAL-BATTERY WIRING

7 156016328 DECAL CIRCUIT BREAKER

8 156016401 DECAL, PARKING BRAKE

9 156015445 DECAL SOLUTION FLOW

10 156016421 DECAL LOGO 2 INCH

12 156016455 DECAL ECO SOLUTION

13 156314875 FLOOR MAT

Drive and brake pedal assemblies BR 850SC SBG SPECIAL

19-12-2014

7

Part List IDBR85009

Drive and brake pedal assemblies 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 156314676 2-9BRAKE PEDAL ASSEMBLY


3 156003174 SCR, HEX THD/HD M6-1.0 X

4 556003403 Nut

5 356003428 SCR HEX M6-1.0 X 75MM

6 156316657 LOCK-BRAKE

7 156314138 MAT, PEDAL

8 156316658 BRACKET-BRAKE

9 156316659 PEDAL WELDMENT

10 756003119 1/4-20 X 1/2 SS SCREW

11 156601052 FOOT PEDAL ASSY

12 156316660 PEDAL MOUNTING PLATE

13 256002708 Nut Hex Ny loc 1/4-20

14 256003086 SCR FLT PHIL SS1/4-20X.88

15 156002292 Screw

16 456002989 SCR PAN PHIL SS 1/4-20 X

Electrical Panel AssemblyBR 850SC SBG SPECIAL

19-12-2014

9


Electrical Panel Assembly 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 156314668 ELECTRICAL PANEL

2 956002462 SCR PAN PHIL 1/4-20X0.38 replaced by 56002145

3 156009051 Screw Pan Phil thd Form

4 156412177 (H1)HORN / BACKUP ALARM

5 356469858 Insulated Standof f

6 356009020 1/4-20 X 7/8 STUD

7 156412089 FUSE 150 AMP

8 456001862 Bolt 5/16-18 x1/2

9 456009052 WSH, INT SHPRF 5/16

10 356002561 NUT KEPS 1/4-20

11 156407193 GASKET

12 156395455 (Vac Motor / K2)contactor 36v 100 amp

13 456002989 SCR PAN PHIL SS 1/4-20 X

14 156109534 COVER ELECTRICAL

15 656002098 Washer f lat Sae 1/4

16 256003119 1/4-20 X 1/2 SS SCREW

17 156459369 BOOT,RESET BUTTON__E00586

18 156459367 Boot reset button

19 156395453 (Brush Drive / K1)CONTACTOR 36V 200 AMP

20 156395453 (Wheel Drive / K3)CONTACTOR 36V 200 AMP

21 456009086 5/16-18 JAM NUT

22 356001993 Screw

23 156390856 SPEED CONTROLLER

24 156387316 Control Circuit / F3)Circuit Breaker 10A

25 156454429 (Wheel Drive / F2)Circuit Breaker 70A

Front wheel assembly BR 850SC SBG SPECIAL

19-12-2014

11

Part List IDBR85013

Front wheel assembly 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 156002158 SCR SOC HD 5/16-18 X .88

2 156002826 Nut Hex Ny loc Thin (s/s) replaced by 56002701

3 456003040 SCR HEX HD LOC 3/8-16 X 0

4 456003273 SCR, FLAT SOC M8-1.25 X 7

5 456003274 SCR, FLAT SOC M8-1.25 X 5

6 156009122 WASHER, FLT .344X.938X.12

7 156158143 BEARING TR CP 2.44 E00135

8 156158151 BEARING TR CN 1.250V51Y_E

9 156171081 SEAL SHAFT 1.750 PE202S

10 156378380 Ball Bearing .9843 Cr25D

11 156481699 SPRING

12 156003220 NUT,HEX NYL THIN 1-14 UNF

13 356003263 RIVET, NYLON TREE PUSH-IN

14 156314032 BLOCK BEARING

15 156314116 PLATE, STEERING

16 156314157 ROD, BRAKE

17 156316637 NOT SHOWNKIT DRIVE WHEEL HARNESS

17 156380506 NOT SHOWN, including brake pedal 56314676KIT MOTOR/DRIVE

17 156381533 NOTE 1FRONT WHEEL SERVICE KIT

17 156390817 M3MOTOR DRIVE WHEEL

18 156314278 PLATE, SPLASH GUARD

19 156314283 SPLASH GUARD

20 156314085 WELDMENT, SPINDLE

21 156305317 CLAMP, P

22 156003653 STUD

23 156003611 SCREW PAN

24 156009293 NUT,HEX MACHINE SS 10-24

25 156002006 Washer f lat Sae 6

NOTE 1: Kit includes 1 Connection Box, 2 Curved Brushes, 1 Brush Holder and Hardw are.

Motor, front drive wheelBR 850SC SBG SPECIAL

19-12-2014

13

Part List IDBR85050

Motor, front drive wheel 19-12-2014


Part List ID

Pos Qty DescriptionPart no.A 156314289 BRAKE BAND

B 156390814 DRIVE WHELL

C 156412325 BRUSH KIT

D 156412320 BRUSH COVER KIT

E 156412321 SEALING RING

F 156412322 BALL BEARING GEARBOX SIDE

G 156412323 BALL BEARING BRUSH SIDE

H 156383091 BRAKE BAR

I 156109589 CONNECTION BOX

J 156109590 COVER CONNECTION BOX

17 156390817 NOTE 1MOTOR DRIVE WHEEL

NOTE 1: Kit includes 1 Connection Box, 2 Curved Brushes, 1 Brush Holder and Hardw are.

Recovery systemBR 850SC SBG SPECIAL

19-12-2014

15


Recovery system 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 856002043 Scr Pan Hd Phil 10-24 x .


3 656002108 SCR PAN HD PHIL 1/4-20 X

4 456002507 SCR PAN PHIL 1/4-20X0.75

5 1256002760 SCR FLT PHIL 1/4-20

6 156002793 SCR PAN PHIL 5/16-18 X 0.

7 556002896 Scr Pan Phil SS 10-24 x 0

8 256009191 SCR PAN PHIL PLASTITE10-1 4X.50

9 256324497 Cage

10 156385599 Hose 2 x 8in_E00191in

11 156314704 GASKET

12 156385564 CLAMP CABLE .625 E00129

13 156391690 Ball Float

14 156407361 Clamp plastic

15 356440213 Clamp hose Sae #32E00047

16 156212236 CLAMP, PLASTIC

17 256314098 FOAM CYLINDER

19 156314100 MUFFLER TOP PANEL

20 156314101 MUFFLER BOTTOM PANEL

21 156413846 GASKET STRIP

22 156314115 PIN COVER PIVOT

23 156382619 COVER EXHAUST

24 156391807 Foam Accoustical

25 156314201 COVER, VAC MOTOR

26 156314203 LID, RECOVERY TANK

27 256314220 BRACKET, TANK MOUNT


29 156314371 GASKET

30 156314372 SCREEN, FILTER

31 156314373 FILTER

32 156314376 PLATE SEPARATOR

33 156314400 WIRE ROPE 9 INCH

34 156316639 VAC FILTER LID ASSY

35 356314484 MOUNT, VIBRATION

36 156314488 MUFFLER, VAC

37 156477613 Cable Tie E00549 Re409S

38 156314509 SPRING

39 156390862 VAC HOSE ASSY

40 156390832 RECOVERY TANK ASSY

41 156381921 TSB-US 2011-0015 - Suction Hose ImprovementDRAIN HOSE RIBBED

41 156601410 Not shownDRAIN HOSE EXTENSION

41 156601411 Not shownDRAIN HOSE CAP KIT

42 256316641 BUMPER-REAR

Recovery system 19-12-2014


Part List ID

Pos Qty DescriptionPart no.43 156316642 BUMPER-REAR MIDDLE

44 156314760 GASKET VACUUM DUCT

45 156314706 FOAM SOUND

46 156212223 Not shownCARBON BRUSH SET

46 156314251 Not shownHARNESS, VACUUM

46 156410065 M5VAC MOTOR

47 156314705 FOAM SOUND

48 156109695 STRAINER BASKET

49 156390848 TUBE RECOVERY TANK

Scrub system-cylindrical (BR 850S) BR 850SC SBG SPECIAL

19-12-2014

18

Part List IDBR85017

Scrub system-cylindrical (BR 850S) 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 256001841 Scr Soc Set 1/4-20 x .25

2 256001861 1/4-20 X 3/8 SCREW

3 256002918 WSH FLT SAE SS 1/2

4 456002910 Washer f lat

5 456002086 Scr Soc Set 5/16-18 x .25

6 256003937 SCR-HEX SS 1/2-13 X 4.50

7 256002561 NUT KEPS 1/4-20

8 456002854 Nut Hex Ny l (s/s) replaced by 56002770

9 256112771 Clamp hose Sae 10 E00047

10 656003221 SCR, HEX LOC SS 1/4-20 X


12 256316552 MANIFOLD,PVC 32 ADVENGER

12 256316553 MANIFOLD PVC 28 ADVENGER

14 256003438 NUT HEX NYL LOC SS M10- 1 .50

15 1056003426 NUT HEX NYL LOC SS M6-1.0

16 256003431 SCR HEX HD SS M6-1.0 X 16 MM 16 pieces in a pack

17 256003938 SCR-HEX SS M10-1.5 X 40MM

18 256003939 SCR-HEX SS M6-1 X 95MM

19 256009019 Screw

20 256009020 1/4-20 X 7/8 STUD

21 456009062 SCR PHIL THD1/4-20X-20X.5

22 456009086 5/16-18 JAM NUT

23 256152811 COLLAR PC9A

24 156262549 Tee

26 256330391 Wire Rope Ass`Y 12.00

27 156388520 NOT SHOWNNut Plastic

27 156393303 M1Actuator

28 256401783 Lev eller, one inch

29 256407391 BLADE

30 256407431 M7 & M8MOTOR 36 DC :75HP

30 156407489 NOT SHOWNARMATURE

30 156410183 NOT SHOWNBEARING, F.E.

31 256407432 IDLER BELT

32 256407433 SHEAVE

33 156407434 GUARD

34 156407435 GUARD LEFT BELT

35 156407465 BELT PLY V OIL RESISTANT

36 156407466 BELT POLY V OIL RESISTANT

37 156409462 Hose, spiral

38 156412071 COMPRESSION SPRING

39 256412176 BUSHING

40 156412262 HOUSING SPRING

41 156420018 SPRING COMPRESSION 140498

NOTE: See BRUSH SELECTOR GUIDE at back of manual for available scrub brushes.NOTE 2: See SKIRT ASSEMBLIES-CYLINDRICAL.

Scrub system-cylindrical (BR 850S) 19-12-2014


Part List ID

Pos Qty DescriptionPart no.42 156420019 Nut retainer

43 156420020 NUT RETAINER WELDMENT 140498

44 256469858 Insulated Standof f

45 256493357 INSULATOR BOOT

47 856003603 SCR,PAN PHILTHDFORM 1/4-2

48 256003671 PIN, RING .50 X 1.25

49 1 ACCESSORY PLATE DATA PLATE, NOT AVAILABLENOTE COMMENT

50 156316670 HOUSING WELDT-32

51 156314254 NOT SHOWNHARNESS BRUSH MOTOR

52 156314294 PIN, COTTERLESS .375 X 3.

53 156407558 WASHER, BEARING

54 256009060 Washer

55 256314445 61-65IDLER END ASSEMBLY

56 156314648 NOTE 2SKIRT ASSEMBLY LEFT

57 156314649 NOTE 2SKIRT ASSEMBLY RIGHT

58 156397443 HOPPER WELDT

59 256407559 53, 66-72DRIVE END ASSY

60 256412459 WHEEL

61 156106070 Ball Bearing Z22

62 156407303 Knob

63 156315447 IDLER BEARING PLATE

64 156407551 HUB

65 156407558 WASHER, BEARING

66 256002119 Screw Soc Set

67 156003237 KEY SQ 19 X .62

68 256106070 Ball Bearing Z22

69 156407389 SPACER

70 156407442 SHEAVE POLY-V

71 156381765 BEARING PLATE

72 156109527 SPINDLE

NOTE: See BRUSH SELECTOR GUIDE at back of manual for available scrub brushes.NOTE 2: See SKIRT ASSEMBLIES-CYLINDRICAL.

Service part 56407431BR 850SC SBG SPECIAL

19-12-2014

21

Part List IDBR850S50

Service part 56407431 19-12-2014

BR 850SC SBG SPECIAL 22BR850S50

Part List ID

Pos Qty DescriptionPart no.A 156383546 NOTE 1END CAP-BRUSH-BRUSH CAP KIT

B 156383565 NOTE 2END CAP ASSY-EXT THD BRSH CAP

C 456407493 NOTE 3BRUSH ASSEMBLY

D 456383529 NOTE 2CAP-BRUSH EXT THD

E 156383547 NOTE 2BRUSH-BRUSH CAP KIT

F 456383528 NOTE 4CAP-BRUSH INT THD

NOTE 1: Used on all generations of 56407431 (Includes B-D).NOTE 2: Used on Scott model 4BC-3145.NOTE 3: Used on all generations of 56407431.

Scrub system - DiskBR 850SC SBG SPECIAL

19-12-2014

23


Scrub system - Disk 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 256002768 Nut Hex Ny loc 10-24

2 1856002938 5/16 SS FLAT WASHER


4 256003246 KEY, 25 X 1.62

4 156315721 BLADE KIT DISC RED GUM SD

4 156315722 BLADE KIT

5 256003335 SCREW HEX LOC SS 5/16-18 X .88

6 656003405 NUT HEX NYL LOC M8X1.25



10 656003477 Scr Hex loc SS M8 1 x 25mm

11 256009019 Screw

12 656009030 SCR PAN PHIL THD FOM 10-2

13 256009057 WSHFLTHARD .344X1.000X .120

14 456009062 SCR PHIL THD1/4-20X-20X.5

15 456009086 5/16-18 JAM NUT

16 256009096 Washer f lat .193x.875x.06

17 256249280 TEE,BARB 3/8X3/8__E00455

18 256366455 Plate Cv 24B

19 256366463 Spring Retainer Cv 24C

20 256385564 CLAMP CABLE .625 E00129

21 156388520 Nut Plastic

21 156393303 Actuator

22 456383238 BRUSH DRIVE DISC

23 456380149 KNOB M12 1.75

24 456601578 KNOB

25 156412071 COMPRESSION SPRING

26 156412262 HOUSING SPRING

27 156420018 SPRING COMPRESSION 140498

28 156420019 Nut retainer

29 156420020 NUT RETAINER WELDMENT 140498

30 656002885 SCR HEXD SS 3/8 1

30 1656003211 RING, RET EXT SS

31 1856003263 RIVET, NYLON TREE PUSH-IN

32 656003639 SCR, HEX SS M8-1.25 X 30M

33 456003657 NUT, HEX JAM M12-1.75

34 456003658 SCR THD TO HD SS M12-1.75

35 256003671 PIN, RING .50 X 1.25

37 156249682 Tube_E00603

38 156262180 HOSE SPIRAL .50 x 7" E006

39 256314030 BRUSH HOLDER

40 256314108 HUB DRIVE

41 256316680 BRACKET-MOTOR

Scrub system - Disk 19-12-2014


Part List ID

Pos Qty DescriptionPart no.42 156316681 WELDT-DISK DECK 32

43 156314335 MOTOR GEARBOX ASSY 32"

43 256314359 KEY, 6MM SQUARE

43 256314499 COVER GEARBOX

43 256314560 MOTOVARIO GEARBOX

43 156314580 BALL BEARING OUTPUT SIDE

43 156314582 BRUSH RING

43 456314583 BRUSH

43 156314584 SAFETY HOOK

43 156412323 BALL BEARING BRUSH SIDE

44 256314218 SHAFT, HUB MOUNT

45 156315704 Gearbox Assembly

45 256315711 GEARBOX

46 256315705 SPACER

47 156314294 PIN, COTTERLESS .375 X 3.

48 1 See Disk Deck Blade Kits belowNOTE COMMENT

49 256314359 KEY, 6MM SQUARE

50 256314499 COVER GEARBOX


52 156412189 HOSE SOLUTION AIR BLEED

53 156314898 SKIRT ASSEMBLY LEFT 32 LINATEX

54 156314896 SKIRT ASSEMBLY RIGHT LINA TEX

55 156392277 TUBE VINYL E00603

56 156397300 TEE BARB

57 256401783 Lev eller, one inch

58 256412187 SOLUTION DRAIN HOSE

60 156314914 BLADE RUBBER GUM 32in KIT

60 156314918 BLADE KIT LINATEX 32 DIS

Skirt assemblies-cylindricalBR 850SC SBG SPECIAL

19-12-2014

26


Skirt assemblies-cylindrical 19-12-2014


Part List ID

Pos Qty DescriptionPart no.156314648 SKIRT ASSEMBLY LEFT

156314649 SKIRT ASSEMBLY RIGHT

1 256001939 Washer f lat Sae 5/16

2 156003178 SCR HEX THD TO HD M8-1.25X16MM

3 156003179 Screw

4 156003389 NUT HEX NYL LOC M*-1.25



7 156003441 SCREW HEX NYL LOC M6-1*15

8 256185263 Bearing Sleav e E00202

9 256320595 Bushing .31x.50x.28Hc18M

10 156314860 STANDARD, NOTE 2BLADE KIT-CYL RED GUM

10 156390791 OPTIONAL, NOTE 2KIT CYL BLADE 1050SC GUM

10 156407447 OPTIONALSCRUB DECK SKIRT SIDE BR 700/800 CYLINDRICAL

10 156410335 STANDARDSKIRT, LINATEX

11 156470672 Spring ext..75 x 3

12 156314435 ARM MOUNT

13 156314437 RETAINER, SKIRT

14 156314439 WELDMENT SKIRT BRACKET

15 156314440 BRACKET MOUNT

14A 156314438 WELDMENT SKIRT BRACKET

15A 156314441 BRACKET, MOUNT

NOTE: All quantities are for one skirt assembly only, there are tw o skirt assemblies on the machine.

Skirt assemblies-DiskBR 850SC SBG SPECIAL

19-12-2014

28


Skirt assemblies-Disk 19-12-2014


Part List ID

Pos Qty DescriptionPart no.0 156314896 SKIRT ASSEMBLY RIGHT LINA TEX

0 156314898 SKIRT ASSEMBLY LEFT 32 LINATEX

1 156324499 Wheel 3.00 x.781 Hc315

2 156016163 DECAL NO STEP

3 156471220 Bushing .25x.37x1.0Re185L

4 256002859 Washer f lat Sae SS 1/4

5 156003935 SCR-HEX SS M6-1 X 40MM


7 256003454 SCREW

8 656003693 RIVET NYLON TREE PUSH IN

9 256003696 WSH FLAT SS. 33X1.00 X .060

10 256009045 Washer


12 156316649 FRAME-SKIRT RH

13 156316650 FRAME-SKIRT LH

14 156316651 RETAINER-BLADE


20 156314914 BLADE RUBBER GUM 32in KIT

21 156314918 BLADE KIT LINATEX 32 DIS

22 156315722 BLADE KIT

23 156315721 BLADE KIT DISC RED GUM SD

Solution system (standard) BR 850SC SBG SPECIAL

19-12-2014

30


Solution system (standard) 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 456001939 Washer f lat Sae 5/16


3 456009206 SCR,TRUSS PHIL BLK 10-24X.50

4 456002035 Scr Hex Hd 5/16-18 x .62

5 356002043 Scr Pan Hd Phil 10-24 x .

6 356002066 1/4-20 X 5/8 SCREW

7 1156002098 Washer f lat Sae 1/4

8 156002108 SCR PAN HD PHIL 1/4-20 X

9 256002507 SCR PAN PHIL 1/4-20X0.75

10 156002589 Scr Hex Wsh Hd 6-32 x .50

11 556002674 SCR PAN HD PHIL 10-24 X 1

12 156316655 BUMPER-FRONT MIDDLE

13 256002793 SCR PAN PHIL 5/16-18 X 0.

14 156002826 Nut Hex Ny loc Thin (s/s) replaced by 56002701

15 156002830 #6-32 NYL LOC NUT


17 556002900 SCR PAN PHIL SS 10-24 X 0

18 356002997 SCR PAN PHIL 1/4-20 X 1.7

19 17-82-00050 S2SWITCH SEAT

20 356003178 SCR HEX THD TO HD M8-1.25X16MM

21 256003268 Ring

22 356003389 NUT HEX NYL LOC M*-1.25


24 456009122 WASHER, FLT .344X.938X.12


26 456219932 Clamp hose Sae 6 E00047

27 156255076 Cap Pipe Ght Ny lon Fa33K

28 156344265 CLAMP CABLE AS510A

29 156368776 Washer f lat rubb.625Cv 80L

30 256372673 NOTE 1Boot battery post

31 156314757 ELBOW,90BARBMALE1/2-14,.7 5HOSE

32 156314973 HINGE

33 156900273 Barb_E00072

34 156468553 BUSHING .27X.37X1.3RE651D

35 156469380 CLAMP, CABLE .75

36 256478246 Cable Tie E00549 Re438B

37 156003003 SCR PAN PHIL 5/1

38 256046309 SPACER PHENOLIC

39 156050872 SPACER, PHEN.

40 156314899 VALVE, SOLUTION

41 156262180 HOSE SPIRAL .50 x 7" E006

42 156383187 SEAT

43 156390853 SOLUTION TANK

Solution system (standard) 19-12-2014


Part List ID

Pos Qty DescriptionPart no.44 156314066 COVER, SOLUTION TANK

45 156314069 GASKET

46 156314713 TSBUS2006-932, NOT SHOWNPANEL ASSY,SCRUBBER

46 156390867 CONTROL PANEL ASSY SCRUBBER

46 156396188 NOT SHOWNSWITCH KEY

46 156396189 NOT SHOWNKEY f or BA850/br600s

47 156314758 TEE BARB 1/2-14 0 .75 HO

48 156314881 BRACKET VALVE

49 556314155 CLAMP CABLE 1 GAUGE

50 256316656 BUMPER-FRONT

51 156314975 COVER,ACTUATOR CLOSED

52 156314292 BAR DISCONNECT

53 156316526 BRACKET TANK MOUNT

54 156316666 WELDT-SEAT MOUNT

55 156314223 PROP ROD

56 156390854 NOT SHOWNHARNESS MAIN

57 156314253 CABLE ASSEMBLY

58 156314264 HINGE BRACKET

59 156314904 TUBE

60 156314882 BRACKET WATER VALVE

61 156314532 PANEL, BATTERY BOX

62 156314756 STRAINER

63 156386182 HOSE_E00604

64 156397189 SPACER

65 156397215 L1SOLUTION VALVE ASSY.

66 156397508 CONNECTOR ASSY

67 156263218 HOSE 17in E00521

68 156442003 CLAMP CABLE .677 CV437S

69 456314608 CLAMP CABLE

70 456002171 Screw pan phil 10.20.x 2.

71 1256002760 SCR FLT PHIL 1/4-20

72 156410162 HOSE, 17in SPIRAL

73 156314755 VALVE SOLUTION

74 456112771 Clamp hose Sae 10 E00047

75 256001993 Screw

76 456002221 Scr Hex Hd 5/16-18x1(s/s) replaced by 56001834

Squeegee assemblyBR 850SC SBG SPECIAL

19-12-2014

33


Squeegee assembly 19-12-2014


Part List ID

Pos Qty DescriptionPart no.0 156390866 NOTE 2SQUEEGEE ASSEMBLY 34

1 256002851 Nut Hex Ny l Loc Thin SS5/ use 56002856

2 256002884 SCR HEX HD SS 5/16-18 X 1

3 256002907 (before May 2012)Nut Hex Ny l Loc SS 6-32

4 256002909 (before May 2012)Scr Pan Phil SS 6-32 x 0.

5 256002938 5/16 SS FLAT WASHER

6 156003302 Bolt BR1000 Squeegee

7 156003792 SCR THUMB SS 5/1

8 156009141 NUT, HEX JAM SS 5/16-18

9 256111444 BUTTON PLUG 1.25

10 256370711 Nut Thumb 5/16-18 Cv 211F

11 156471194 (before May 2012)Latch Assy Re32

12 256601450 WHEEL 4.00 OD

13 156601495 FRONT STRAP WELD

14 156382698 (BR 850S after April 2012)CLAMP BAND 34" ASSY

15 256601499 BUSHING NYLON

16 156382739 NOTE 1BLADE KIT SQUEEGEE RED GUM 34

17 156601496 BR 850S Models before May 2012)STRAP REAR

20 156382738 NOTE 1BLADE KIT SQUEEGEE GUM 34

20 156382739 NOTE 1BLADE KIT SQUEEGEE RED GUM 34

20 156382740 NOTE 1BLADE KIT SQUEEGE

NOTE 1: Squeegee Blade Kits include both front & rear squeegee blades.NOTE 2: This squeegee assembly includes red gum rubber blades. The squeegee tool casting is not available for sale separately. If you need to replace the

Squeegee system BR 850SC SBG SPECIAL

19-12-2014

35


Squeegee system 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 156412088 PIN

2 256412248 SPACER

3 156453691 SPACER

4 156002491 Nut Greer 1/4-20

5 156002856 Nut Hex Ny l Loc SS 5/16-1

6 156002883 Scr Hex Hd Ss 1/4-20 x 1.

7 256002663 Bolt 3/8-16 x 1


9 156002938 5/16 SS FLAT WASHER

10 256002951 NUT HEX NYL LOC 3/8-24 Use 56009103

11 256003219 NUT HEX NYL LOC SS 3/8-16

12 356003222 PIN,COT HAIR. 125 X DIA.5

13 156003223 PIN,COT HAIR.148 X DIA.62

14 256003262 Ring Ret Ext. Ty pe E-

15 156003264 RING RET EXT TYPE E

16 156003486 HEX THD TO HD SS5/16

17 256003656 CLEVIS PIN, .375 X 2.25

18 256003696 WSH FLAT SS. 33X1.00 X .060

19 256003713 PIN CLEVIS .38 X 3.75

20 256009103 NUT, HEX JAM 3/8-24

21 156009141 NUT, HEX JAM SS 5/16-18

22 656324505 Bearing Flange .376_E0020

23 156381818 BUSHING

24 156316668 BRKT SQEEGEE

25 156316667 NOTE 3BRKT-SQUEEGEE PIVOT WELDT

26 156390857 M2ACTUATOR MOTOR 36V

27 156390866 Note 1SQUEEGEE ASSEMBLY 34

28 156407303 Knob

29 256412124 WHEEL

30 156412208 ROLLER

31 256412216 SPRING

32 156390818 CABLE ASSY

33 156601442 SHAFT

34 256601460 BAR WELDMENT

35 156601463 WASHER POLYURETHANE

36 256601469 ROD END

37 256601512 HOSE

38 156390799 BRACKET CABLE

39 456382624 NOTE 2NUT-SPRING

40 256382637 NOTE 2ROD-THREADED .25 X 1.25

41 156390851 NOTE 4BRACKET SQUEEGEE

NOTE 1: These squeegee assemblies include Red Gum Rubber blades.NOTE 2: These parts w ere implemented in production as of November 2011 to increase squeegee dow n pressure. Order Squeegee Spring Kit 56382634 toupgrade your machine to include this improvement. Only used before May 2012.

Steering column assembly BR 850SC SBG SPECIAL

19-12-2014

37


Steering column assembly 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 356001879 Washer f lat Sae 1/2

2 256001939 Washer f lat Sae 5/16

3 256001958 3/8-16 X 1/2 SOC HD BOLT


5 356002086 Scr Soc Set 5/16-18 x .25

6 156002093 Scr Hex Hd 1/4-20 x 1.00

7 256002523 NOTE 1#8-32 X 3/8 SCREW


9 156002843 Nut (obsolete)

10 256003039 Scr Hex Hd Loc

11 256003145 NUT HEX JAM SS

12 456003186 SCR HEX THD TO HD M10-1.5 X 25MM

13 456003228 KEY WOODRUF

14 156003261 RING, RET EXT TYPE E

15 156003342 WSH, FLT STD 7/8

16 256003389 NUT HEX NYL LOC M*-1.25

17 256003436 SCREW

18 956009062 SCR PHIL THD1/4-20X-20X.5

19 356250414 Bearing Flange .752Fa1J_E

20 156305072 SPRING EXTENSION .075

21 156314195 SHAFT, LOWER STEERING

22 156314295 SHROUD LOWER COLUMN

23 156314296 SHROUD UPPER COLUMN

24 256320595 Bushing .31x.50x.28Hc18M

25 356367095 Collar Shaf t .750 Cv 31A

26 156412198 CHAIN ROLLER

27 156412281 NOTE 1SOLUTION CONTROL CABLE

28 256413211 BEARING FLANGE 625X 500X 250

29 156413657 COLUMN UPPER

30 156413658 RATCHET,STEERING COLUMN

31 156413659 LOWER COLUMN WELDMENT

32 156413661 STEERING PAWL WELDMENT

33 156413664 ROD

34 156420059 UPPER STEERING SHAFT

35 156440817 KNOB 1.00X1/4-20 CV429C

36 156454081 Univ ersal joint

37 156471148 Sprocket H40B11 Re188C

38 156497306 Steering Wheel

39 156497308 Cup

40 156497543 Cap

41 156497560 Wheel adaptor

42 156900041 PLUG CAP E00046

Wiring diagram BR 850SC SBG SPECIAL

19-12-2014

39


Wiring diagram 19-12-2014


Part List ID

Pos Qty DescriptionPart no.51 156396188 SWITCH KEY

51 156396189 KEY f or BA850/br600s

52 17-82-00050 SWITCH SEAT

55 156372088 Switch,Waterproof

A1 156314667 CONTROLLER, SPEED

E1 156314713 TSBUS2006-932 NOT SHOWNPANEL ASSY,SCRUBBER

E1 156390867 CONTROL PANEL ASSY SCRUBBER

E1 156396188 NOT SHOWNSWITCH KEY

E1 156396189 NOT SHOWNKEY f or BA850/br600s

E2 156316110 DETERGENT INJECTION ONLY, NOTE 1CONTROL ASSEMBLY

F1 156412089 FUSE 150 AMP

F2 156387316 CONTROL CIRCUITCircuit Breaker 10A

F3 156454429 WHEEL DRIVECircuit Breaker 70A

F4 1 FUSE, 1 AMP, NOT AVAILABLENOTE COMMENT

F5 1 FUSE, 5 AMP (L), SIDE BROOM / OPTIONALNOTE COMMENT

H1 156412177 HORN / BACKUP ALARM

H2 156409239 OPTIONALHeadlight

H3 156416433 OPTIONALStrobe

K1 156395453 CONTACTOR 36V 200 AMP

K2 156395455 contactor 36v 100 amp

K3 156395453 CONTACTOR 36V 200 AMP

L1 156397215 SOLUTION VALVE ASSY.

M1 156388520 NOT SHOWNNut Plastic

M1 156393303 Actuator

M2 156390857 ACTUATOR MOTOR 36V

M3 156390817 MOTOR DRIVE WHEEL

M4 156109587 NOT SHOWNPUMP HEAD ASSY

M4 156109588 NOT SHOWNCHECK VALVE ASSY

M4 156212014 OPTIONALPUMP, DC--36V, BY-PASS

M5 156212223 NOT SHOWNCARBON BRUSH SET

M5 156410065 VAC MOTOR

M6 156212223 NOT SHOWNCARBON BRUSH SET

M6 156410065 OPTIONALVAC MOTOR

M7 156314335 BR 850S / DISKMOTOR GEARBOX ASSY 32"

M7 256314359 NOT SHOWNKEY, 6MM SQUARE

M7 256314499 NOT SHOWNCOVER GEARBOX

M7 256314560 NOT SHOWNMOTOVARIO GEARBOX

M7 156314580 FAN END, NOT SHOWNBALL BEARING OUTPUT SIDE

M7 156314582 NOT SHOWNBRUSH RING

M7 456314583 NOT SHOWNBRUSH

M7 156314584 NOT SHOWNSAFETY HOOK

M7 156314784 NOT SHOWNMOTOR REPLACEMENT 36V 450W

M7 156314785 NOT SHOWNGEARBOX REPLACEMENT

NOTE 1: Potentiometer is part of 56601052.

Wiring diagram 19-12-2014


Part List ID

Pos Qty DescriptionPart no.M7 156314786 NOT SHOWNKIT CARBON BRUSH REPLACEMENT

M7 156314789 BR 1050S DISKMOTOR BRUSH DRIVE ASSY

M7 156407431 ALL CYLINDRICALMOTOR 36 DC :75HP

M7 156407489 FOR 56407431, NOT SHOWNARMATURE

M7 156407492 FOR 56407431, NOT SHOWNBRUSH CAP ASSY

M7 456407493 FOR 56407431, NOT SHOWNBRUSH ASSEMBLY

M7 456407494 BRUSH COVER CAP

M7 156410183 FOR 56407431, NOT SHOWNBEARING, F.E.

M7 156412323 BRUSH END, NOT SHOWNBALL BEARING BRUSH SIDE

M8 156314784 MOTOR REPLACEMENT 36V 450W

M8 156314785 GEARBOX REPLACEMENT

M8 156314786 KIT CARBON BRUSH REPLACEMENT

M8 156314789 BR 1050S DISKMOTOR BRUSH DRIVE ASSY

M8 156407431 ALL CYLINDRICALMOTOR 36 DC :75HP

M8 156407489 FOR 56407431, NOT SHOWNARMATURE

M8 156407492 FOR 56407431, NOT SHOWNBRUSH CAP ASSY

M8 456407493 FOR 56407431, NOT SHOWN)BRUSH ASSEMBLY

M8 456407494 FOR 56407431, NOT SHOWNBRUSH COVER CAP

M8 156410183 FOR 56407431, NOT SHOWNBEARING, F.E.

M9 156469530 OPTIONALMotor Assy 24Volt

R1 1 NOTE 1Potentiometer 5K

S1 156396188 SWITCH KEY

S1 156396189 NOT SHOWNKEY f or BA850/br600s

S2 17-82-00050 SWITCH SEAT

S3 1 SWITCH, PUMP (PART OF M4) - NOT AVAILABLENOTE COMMENT

S4 1 SWITCH, HEADLIGHT (PART OF H2) - NOT AVAILABLENOTE COMMENT

S5 156372088 OPTIONALSwitch,Waterproof

S6 1 SWITCH, PUMP (PART OF M11), NOT AVAILABLENOTE COMMENT

BT1 1 BATTERY - NOT AVAILABLENOTE COMMENT

M10 1 NOT SHOWNMOTOR REPLACEMENT 36V 450W

M10 1 NOT SHOWNGEARBOX REPLACEMENT

M10 1 NOT SHOWNKIT CARBON BRUSH REPLACEMENT

M10 156314789 MOTOR BRUSH DRIVE ASSY

M11 156212014 PUMP, DC--36V, BY-PASS

M12 156314984 PUMP, DETERGENT

NOTE 1: Potentiometer is part of 56601052.

Optional kits and accessoriesBR 850SC SBG SPECIAL

19-12-2014

42


No Drawing For Part List

Optional kits and accessories 19-12-2014


Part List ID

Pos Qty DescriptionPart no.1 1146 2112 000 BATTERY CHARGER KIT BR600S,BRX,BR850S

2 1146 2113 000 CHARGER BATTERY 36V 25A A

3 17-03-04249 ARM REST LH & RH

4 156383188 ARM REST KIT R/H + L/H

5 156314306 BROOM RIGHT SIDE KIT

6 156314308 ADVENGER SCRUB-N-VAC TOOL

7 156412223 VACUUM WAND CADDY KIT

8 156314312 SEAT BELT KIT

9 1 Squeegee Blade KitsNOTE COMMENT

10 156382738 BLADE KIT SQUEEGEE GUM 34

11 156382739 BLADE KIT SQUEEGEE RED GUM 34

12 156382740 BLADE KIT SQUEEGE

14 156383571 PROGRAMMER-USER

15 156383572 PROGRAMMER CABLE-MOLEX

17 1 BR 850S Cylindrical Scrub BrushesNOTE COMMENT

18 256407473 CYLINDRICAL BRUSH 790MM 31in NYLON SOFT BR 800C

19 256407474 CYLINDRICAL BRUSH 790MM 31in NYLON HARD BR 800C

20 256407475 CYLINDRICAL BRUSH 790MM 31in PROLENE RED BR 800C

21 256407476 CYLINDRICAL BRUSH 790MM 31in MIDLITE 180 BR 800C

22 256407477 CYLINDRICAL BRUSH 790MM 31in DYNA GRIT BR 800C

23 256407478 CYLINDRICAL BRUSH 790MM 31in MAGNA GRIT 46 BR 800

24 1 BR 850S Disk Scrub BrushesNOTE COMMENT

25 256505830 PAD HOLDER - 16 3 LUG

26 256505195 PAD RETAINER DEVICE SNAP LOCK

27 256505835 BRUSH PROLITE 16in

28 256505834 BRUSH PROLENE 16in

29 256505836 BRUSH UNION MIX 16in

30 256505833 BRUSH AGLITE 16in

31 256505837 BRUSH MIDGRIT 240 16in

32 256505838 BRUSH MIDLITE 180 16in

33 256505832 BRUSH DYNAGRIT 16in

34 256505831 BRUSH MAGNAGRIT 16in

NOTE 1: Squeegee Blade Kits include both front & rear squeegee blades.

Brush Selector Guide-CylindricalBR 850SC SBG SPECIAL

19-12-2014

44


No Drawing For Part List

Brush Selector Guide-Cylindrical 19-12-2014


Part List ID

Pos Qty DescriptionPart no.0 156390867 CONTROL PANEL ASSY SCRUBBER




156407473 CYLINDRICAL BRUSH 790MM 31in NYLON SOFT BR 800C

156407474 CYLINDRICAL BRUSH 790MM 31in NYLON HARD BR 800C

156407475 CYLINDRICAL BRUSH 790MM 31in PROLENE RED BR 800C

156407476 CYLINDRICAL BRUSH 790MM 31in MIDLITE 180 BR 800C

156407477 CYLINDRICAL BRUSH 790MM 31in DYNA GRIT BR 800C

156407478 CYLINDRICAL BRUSH 790MM 31in MAGNA GRIT 46 BR 800

Soft Nylon: Least aggressive brush available. Used on soft-f nish f oors w here a more aggressive brush w ould leave scratch marks, or in applications requiring very light cleaning.Stiff Nylon: Cleaning action similar to

DRIVE WHEEL HARNESS KIT 56316637BR 850SC SBG SPECIAL

19-12-2014

46

Part List IDIS5609000802

DRIVE WHEEL HARNESS KIT 56316637 19-12-2014

BR 850SC SBG SPECIAL 47IS5609000802

Part List ID

Pos Qty DescriptionPart no.0 156316637 KIT DRIVE WHEEL HARNESS

1 156316636 HARNESS DRIVE WHEEL

2 156477613 Cable Tie E00549 Re409S

CONTROL BOARD KIT 56390780BR 850SC SBG SPECIAL

19-12-2014

48

Part List IDIS5609001802

CONTROL BOARD KIT 56390780 19-12-2014

BR 850SC SBG SPECIAL 49IS5609001802

Part List ID

Pos Qty DescriptionPart no.0 156390780 KIT CONTROL BOARD

B 156390867 CONTROL PANEL ASSY SCRUBBER

Documents

BR 850SC SBG SPECIAL - Interline Brands · 2016-02-23 · 18 56009052 1 WSH, INT SHPRF 5/16 NI 56477613 9 Cable Tie E00549 Re409S Not shown NI 56478246 5 Cable Tie E00549 Re438B Not