8/12/2019 Zoeller 295
1/2
SECTION: 2.30.050
FM0450
0308
Supersede
0706
COMPARE THESE FEATURES Non-clogging vortex impeller design. Bronze class
84-8-0-4.
Durable cast construction. Cast iron switch case, base,
motor and pump housing. No sheet metal parts to rust
or corrode. All cast iron class 25-30 25000# tensile
strength.
Stainless steel screws, bolts, float rod, handle, guard,
arm and seal assembly.
20 ft. UL Listed 3-wire neoprene cord and plug. Extra
cord lengths available in 25-35-50 foot lengths only.
3 phase models available (292, 115V/1Ph only).
Motor - 60 Hz, 3450 RPM, oil-filled, hermetically
sealed, automatic reset, thermal overload protected (1
Ph only).
Maximum temperature for sewage or dewatering
130F (54C), 120F (49C) for WD295. If over 130F,
consult Factory.
Shaft Seal - Stainless steel carbon & ceramic rotary.
Corrosion resistant powder coated epoxy finish.
Upper sleeve bearing and lower ball bearing running in
bath of oil.
Square Ring & Gasket - Neoprene.
All models pass 2" spherical solids.
Major width 127
/8" Height 189
/16" (Single sealpumps).
Automatic units available with float operated,
submersible (NEMA 6) 2-pole mechanical switch. On
point 143/4" - Off point 5".
Specify 2" or 3" NPT female flanged vertical discharge.
100% computerized testing.
MODELS 4292-4293-4294-4295DOUBLE SEAL PUMPS (Nonauto only)
Gives motor extra protection from seal leaks.
Improved bearing lubrication.
Helps eliminate seal and bearing damage from dry
runs.
Major width 12 7/8". Height 20 7/16".
Note: The sizing of effluent systems normally requires
variable level float(s) controls and properly sized
basins to achieve required pumping cycles or dosing
timers with nonautomatic pumps.
Product information presentedhere reflects conditions at timeof publication. Consult factoryregarding discrepancies orinconsistencies. MAIL TO: P.O. BOX 16347 Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road Louisville, KY 40211-1961
(502) 778-2731 1 (800) 928-PUMP FAX (502) 774-3624
visit our web site:
www.zoeller.com
Copyright 2008 Zoeller Co. All rights reserved.
292 - 293 - 294 - 295 Single Seal Series4292 - 4293 - 4294 - 4295 Double Seal Series
(For Pump Prefix Identification see News & Views 0052)
HIGH HEAD
WASTE-MATESUBMERSIBLE
SEWAGEOR DEWATERING PUMP
Double
Seal
Pump
Nonautomatic
models for
variable level
systems
Automatic units
available in
single phase 292,
293, 294 & 295
series
WD295 controlled
by variable level
float switch
*See back page for UL & CSA listings
Tested to UL
Standard UL778
R *
*
R
Certified to CSA
Standard C22.2 No.108
8/12/2019 Zoeller 295
2/2
SK1415
SELECTION GUIDE
1. Integral float operated mechanical switch, no external control
required.
2. For automatic use single piggyback variable level float switch or
double piggyback variable level float switch. Refer to FM0477.
3. See FM1228 for correct model of simplex control panel.
4. See FM0712 for correct model of duplex control panel.
Single Seal Automatic Design
Weight 86-89 lbs.
* No Molded Plug.
** Single piggyback switch included.
(1) UL Listed unit available with 20 Amp plug.
(2) CSA Approval with 20 Amp plug.
RESERVE POWERED DESIGNFor unusual conditions a reserve safety factor is engineered into the design of every Zoeller pump.
For information on additional Zoeller products refer to catalog on Explosion
Proof Models, FM1702; Simplex controls, FM1596; Piggyback Variable Level
Float Switches, FM0477; Electrical Alternator, FM0486; Mechanical Alternator,FM0495; Sump/Sewage Basins, FM0487; Alarm Systems, FM0732; Disconnect/Rail
Systems, FM0787; and Junction Boxes FM1597.
All installation of controls, protection devices and wiring should be done by a quali fied
licensed electrician. All electrical and safety codes should be followed including the
most recent National Electrical Code (NEC) and the Occupational Safety and Health
Act (OSHA).
Copyright 2008 Zoeller Co. All rights reserved.
292 MODELS 4292 MODELS Standard all models - 20 ft. cord - HP Control Selection Listings
Single Seal Double Seal Volts - Ph Mode Amps Simplex Duplex CSA UL
M292 --- 115 1 Auto 15.0 1 --- Y Y N292 N4292 115 1 Non 15.0 2 or 3 2 or 4 Y Y(1)
293 MODELS 4293 MODELS Standard all models - 20 ft. cord - 1 HP Control Selection Listings
Single Seal Double Seal Volts - Ph Mode Amps Simplex Duplex CSA UL
D293 --- 230 1 Auto 10.2 1 --- Y Y
E293 E4293 230 1 Non 10.2 2 or 3 4 Y Y
* H293 --- 200 1 Auto 12.0 1 --- Y N
* I 293 * I 4293 200 1 Non 12.0 2 or 3 4 Y N
* F293 * F4293 230 3 Non 7.6 3 4 Y Y
* J293 * J4293 200 3 Non 8.2 3 4 Y Y
* G293 * G4293 460 3 Non 4.0 3 4 Y Y
* BA293 --- 575 3 Non 3.3 3 4 N N
294 MODELS 4294 MODELS Standard all models - 20 ft. cord - 1 HP Control Selection Listings
Single Seal Double Seal Volts - Ph Mode Amps Simplex Duplex CSA UL
D294 --- 230 1 Auto 13.7 1 --- Y Y(1)
E294 E4294 230 1 Non 13.7 2 or 3 4 Y Y(1)
* H294 --- 200 1 Auto 17.8 1 --- N N
* I 294 * I 4294 200 1 Non 17.8 2 or 3 4 N N
* F294 * F4294 230 3 Non 9.5 3 4 Y Y
* J294 * J4294 200 3 Non 10.8 3 4 Y Y
* G294 * G4294 460 3 Non 4.8 3 4 Y Y
* BA294 --- 575 3 Non 3.8 3 4 Y N
295 MODELS 4295 MODELS Standard all models - 20 ft. cord - 2 HP Control Selection Listings
Single Seal Double Seal Volts - Ph Mode Amps Simplex Duplex CSA UL
D295 --- 230 1 Auto 17.1 1 --- Y(2) Y
E295 E4295 230 1 Non 17.1 2 or 3 4 Y
(2)
Y WD295 --- 230 1 Auto 17.1 ** 4 N N
* H295 --- 200 1 Auto 20.5 1 --- N N
* I 295 * I 4295 200 1 Non 20.5 2 or 3 4 N N
* F295 * F4295 230 3 Non 12.2 3 4 Y Y
* J295 * J4295 200 3 Non 14.3 3 4 Y Y
* G295 * G4295 460 3 Non 6.1 3 4 Y Y
* BA295 --- 575 3 Non 4.9 3 4 Y N
PUMP PERFORMANCE CURVE
MODEL 292/4292/293/4293/294/4294/295/4295
0 80 160 240 320 400 480
220140130120110100908070605040302010
0
2
4
6
8
10
12
14
16
18
20
80
65
60
55
50
45
40
35
30
25
20
15
10
5
LITERS
GALLONS
FEET
METERS
TOTALD
YNAMIC
HEAD
FLOW PER MINUTE
1 50 1 60 1 70 1 80 1 90 2 00 2 10
560 640 720 800
70
22
292/4292
293/4293
294/4294
295/4295
75
24
Model 293 should not
be subjected to less
than 15' TDH.
009919A
Double Seal Design / Weight 92-95 lbs.
294/4294
G al . L it ers
196 742
181 685
165 625
150 568
136 515
121 458
94 356
58 220
13 49
-- --
62 ft.(18.9m)
292/4292 293/4293
199 753
115
23
89
59
154
140
184
168
435
87
337
223
583
530
696
636
295/4295
Gal.
214 810
Liters
75 ft.(22.9m)
MODEL
Feet Meters Gal. Liters Gal . Li ters
5 1.5 530140 -- --
10 3.0 469124 -- --
4.6 409108 118 44715
6.1 34491 108 40920
7.6 28475 96 36325
9.1 21256 82 31030
12.2 3810 48 18240
15.2 ---- -- --50
18.3 ---- -- --60
21.3 ---- -- --70
Shut-of f Head: 42 f t. (12.8m) 50 f t. (15.2m)
18 9/16
6
4 1/8 8 3/4
6 1/2
4 1/8
6 11/32
2" NPT
OR3" NPT
AVAILABLE
IN A FLANGE
SK863
6
4 1/8 8 3/4
6 1/2
4 1/8
20 7/16
4 1/8
2" NPT
OR
3" NPT
AVAILABLE IN A FLANGE
Recommended