Upload
advocate
View
216
Download
0
Embed Size (px)
Citation preview
7/30/2019 082853
1/1045
*TM 55-1925-273-24&P-2
TECHNICAL MANUAL
FIELD AND SUSTAINMENT MAINTENANCE MANUALINCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST
FOR
INLAND AND COASTAL LARGE TUG (LT)
NSN 1925-01-509-7013 (EIC XAG)
MGANTHONY WAYNE
18
17
16
15
14
13
1514131211109
USARMY
LT - 803
*SUPERSEDURE NOTICE - This manual supersedes TM 55-1925-273-24&P-2, dated 30 November 2005, including all changes.
DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited.
HEADQUARTERS, DEPARTMENT OF THE ARMY
31 JANUARY 2013 0 3/1 5/2 01 1R el(1 .8 )ro ot( frn tc ove r) wp no(F 0 000 1)
7/30/2019 082853
2/1045
7/30/2019 082853
3/1045
WARNING SUMMARY
This warning summary contains general safety warnings and hazardous materials warnings that must be understoodand applied during operation and maintenance of this vessel and its equipment. Failure to observe these precautions
could result in serious injury or death to personnel. Also included are explanations of safety and of hazardousmaterials used within the technical manual.
FIRST AID DATA
Although the 128 ft Large Tug is normally assigned a medic, first aid is still an important skill for all crewmembers.The ability to promptly administer first aid to another crewmember could mean the difference between life and deathfor that crewmember. First aid procedures for soldiers are contained in FM 4-25.11.
EXPLANATION OF SAFETY WARNING ICONS
EAR PROTECTION - Headphones over ears show that noise level will harm ears.
ELECTRICAL - Electrical wire to arm with electricity symbol running through human body shows thashock hazard is present.
ELECTRICAL - Electrical wire to hand with electricity symbol running through hand shows that shochazard is present.
FALLING PARTS - Arrow bouncing off human shoulder and head shows that falling parts present adanger to life or limb.
FLYING PARTICLES - Arrows bouncing off face shows that particles flying through the air will harmface.
FLYING PARTICLES - Arrows bouncing off face with face shield show that particles flying through theair will harm face.
HEAVY OBJECT - Human figure stooping over heavy object shows physical injury potential fromimproper lifting technique.
TM 55-1925-273-24&P-2
a0 3/1 5/2 011 R el(1 .8 )ro ot(w a rns um)w pn o(F 00 00 2)
7/30/2019 082853
4/1045
WARNING SUMMARY - Continued
EXPLANATION OF SAFETY WARNING ICONS - Continued
HEAVY PARTS - Hand with heavy object on top shows that heavy parts can crush and harm.
HEAVY PARTS - Foot with heavy object on top shows that heavy parts can crush and harm.
HEAVY PARTS - Heavy object on human figure shows that heavy parts present a danger to life orlimb.
HEAVY PARTS - Heavy object pinning human figure against wall shows that heavy, moving partspresent a danger to life or limb.
HELMET PROTECTION - Arrow bouncing off head with helmet shows that falling parts present adanger.
HOT AREA - Hand over object radiating heat shows that part is hot and can burn.
LASER LIGHT - Laser light hazard symbol indicates extreme danger for eyes from laser beams andreflections.
MOVING PARTS - Human figure with arm caught between gears shows that the moving parts of theequipment present a danger to life or limb.
MOVING PARTS - Hand with fingers caught between gears shows that the moving parts of theequipment present a danger to life or limb.
TM 55-1925-273-24&P-2
b03 /15 /20 11 Re l(1 .8) roo t(w arn s um)w pn o(F 00 002 )
7/30/2019 082853
5/1045
WARNING SUMMARY - Continued
EXPLANATION OF SAFETY WARNING ICONS - Continued
MOVING PARTS - Hand with fingers caught between rollers shows that the moving parts of theequipment present a danger to life or limb.
SHARP OBJECT - Pointed object in hand shows that a sharp object presents a danger to limb.
SHARP OBJECT - Pointed object in hand shows that a sharp object presents a danger to limb.
SHARP OBJECT - Pointed object in foot shows that a sharp object presents a danger to limb.
SLICK FLOOR - Wavy line on floor with legs prone shows that slick floor presents a danger for falling
GENERAL SAFETY WARNINGS DESCRIPTION
WARNING
CONFINED SPACE ENTRY
Only properly trained personnel may enter confined spaces, or act as entry supervisors and/or attendants for those working in confined spaces. Before entering into a confined space,the space must be cleared for entry and a Confined Space Entry Permit must be secured. Allentry into confined spaces must be in accordance with the Organizational Confined SpaceEntry Standard Operating Procedure and FM 4-01.502. Entry into an uninspected confinedspace may result in death or serious injury to personnel.
TM 55-1925-273-24&P-2
c0 3/1 5/2 011 R el(1 .8 )ro ot(w a rns um)w pn o(F 00 00 2)
7/30/2019 082853
6/1045
WARNING SUMMARY - Continued
GENERAL SAFETY WARNINGS DESCRIPTION - Continued
WARNING
ELECTRICAL
Replace or repair components only after the affected circuit has been secured, lockedout, and tagged out IAW FM 4-01.502. Performing replacement or repair with the circuitenergized may result in serious injury or death.
Take great care when working around energized electrical equipment. Contact betweenunprotected body parts and electrical conductors can cause serious injury or death. Donot wear jewelry or other conductive items while servicing energized electrical equipment.Failure to comply with these precautions can cause serious injury or death.
WARNING
GALLEY NOISE HAZARD
All crewmembers working in the galley area must wear Army Hearing Protection Devices(HPDs) and ensure that the galley doors remain closed. Failure to comply could result ininjury.
WARNING
LIFTING OPERATIONS AND HEAVY LOADS
All personnel in the vicinity of lifting operations should wear appropriate safety equipmentincluding gloves, hard hat, and safety shoes. Death or serious injury can result from failureto heed this warning.
Heavy loads can crush. Do not allow any body parts to come under the load or betweenthe load and a stationary object. Death or serious injury can result.
Heavy loads can crush. Use a minimum of two crewmembers to lift and hold heavy loads.Do not allow any body parts to come under the load or between the load and a stationaryobject. Failure to comply can result in serious injury or death.
TM 55-1925-273-24&P-2
d03 /15 /20 11 Re l(1 .8) roo t(w arn s um)w pn o(F 00 002 )
7/30/2019 082853
7/1045
WARNING SUMMARY - Continued
GENERAL SAFETY WARNINGS DESCRIPTION - Continued
WARNING
LOCKING HARDWARE
Never reuse locking hardware. Reuse of locking hardware such as lockwashers, locking nuts,cotter pins, and lockwire can result in undetected loosening of fastening hardware causingcatastrophic component failure resulting in death, injury, or damage to equipment. Ensurethat all locking hardware is discarded upon removal and replaced with new.
WARNING
MACHINE GUN NOISE HAZARD
During M2 caliber 0.50 weapons firing, all personnel standing outside on deck must wearArmy Hearing Protection Devices (HPDs). Failure to comply with this warning could result inserious injury.
WARNING
PRESSURIZED LINES
Hydraulic hoses and lines may be under pressure. Relieve pressure by operating theappropriate control valve, if possible. Loosen fittings on hose lines slowly. Allow oil to runaround threads of fitting, releasing pressure before disconnecting fitting. Releasingpressurized oil suddenly may cause death or severe personal injury.
WARNING
ROTATING EQUIPMENT
Use extreme caution when working around rotating components. Do not allow hands or toolsto come in contact with the rotating components. Do not wear loose clothing, jewelry, oranything else which might become entangled in the rotating components. Failure to complycan result in death or serious injury.
WARNING
SAFETY HARNESS
Ensure that a safety harness is worn when inspecting antennas. Failure to comply could resultin injury or death.
TM 55-1925-273-24&P-2
e0 3/1 5/2 011 R el(1 .8 )ro ot(w a rns um)w pn o(F 00 00 2)
7/30/2019 082853
8/1045
WARNING SUMMARY - Continued
EXPLANATION OF HAZARDOUS MATERIALS ICONS AND DESCRIPTIONS
BIOLOGICAL - Abstract symbol bug shows that a material may contain bacteria or viruses that presenta danger to life or health.
CHEMICAL - Drops of liquid on hand shows that the material will cause burns or irritation to humanskin or tissue.
CRYOGENIC - Hand in block of ice shows that the material is extremely cold and can injure humanskin or tissue.
EXPLOSION - Rapidly expanding symbol shows that the material may explode if subjected to hightemperatures, sources of ignition, or high pressure.
EYE PROTECTION - Person with goggles shows that the material will injure the eyes.
FIRE - Flame shows that a material may ignite and cause burns.
POISON - Skull and crossbones shows that a material is poisonous or is a danger to life.
RADIATION - Three circular wedges shows that the material emits radioactive energy and can injurehuman tissue.
VAPOR - Human figure in a cloud shows that material vapors present a danger to life or health.
TM 55-1925-273-24&P-2
f 03 /15 /20 11 Re l(1.8 )ro o t(w arn su m) wp no (F0 00 02)
7/30/2019 082853
9/1045
WARNING SUMMARY - Continued
HAZARDOUS MATERIALS DESCRIPTIONS
WARNING
BATTERIES
Batteries produce hydrogen gas. This gas is explosive. Keep the work area free ofsparks, open flame, and excessive heat. Take care to prevent conductive metal toolsfrom arcing between the positive and negative terminals. Failure to comply with theseprecautions can result in death or serious injury.
Batteries are filled with a sulfuric acid based electrolyte. This electrolyte is extremelycorrosive to human tissue and to many other materials. Chemical protective gloves,
goggles, faceshield, and an apron must be worn at all times when batteries are beingserviced. If electrolyte comes in contact with clothing or other material, wash theaffected area with large volumes of fresh water. If electrolyte comes in contact withthe skin, flush the area with large volumes of water. If the electrolyte comes in contactwith the eyes, flush them with large volumes of water. Continue flushing the affectedarea until medical assistance arrives. Failure to comply can result in death or seriousinjury.
WARNING
CHLORINE AND BROMINE STORAGE AND HANDLING
Chlorine and the Water Demineralizer Cartridge (NSN 4610-01-022-9970) which containsthe chemical Bromine may not be stored together. Both chemicals, Chlorine and Bromine,must follow the Federal HAZCOM standard (29 CFR 1910.1200) along with the MaterialSafety Data Sheet (MSDS) for each chemical. Failure to comply could result in injury or death.
TM 55-1925-273-24&P-2
g0 3/1 5/2 01 1R el(1 .8 )ro ot(w a rns um)w pn o(F 00 00 2)
7/30/2019 082853
10/1045
WARNING SUMMARY - Continued
HAZARDOUS MATERIALS DESCRIPTIONS - Continued
WARNING
DIESEL FUEL
Fuel vapors are explosive. Fuel is flammable. Before fueling the tanks or transferringfuel, ensure that firefighting equipment is immediately available for use in case of fireemergency. Do not smoke or allow smoking, or any other open flame in the vicinityof the fueling operation. Wipe clean any fuel spillage and dispose of spilled fuel inaccordance with the appropriate local regulations. A fueling watch supervisor shallbe stationed to ensure compliance with fueling safety procedures. Failure to comply
can result in death or serious injury. Avoid prolonged exposure of the skin to diesel fuel. Chemical protective gloves and
goggles must be worn whenever handling diesel fuel or parts which are saturatedwith diesel fuel. Failure to comply can result in death or serious injury.
WARNING
GAYLORD VENTILATION AND FIRE SUPPRESSION SYSTEM
In the event that the Gaylord Ventilation and Fire Suppression system is activated andexposure to the fire suppressant occurs, all personnel exposed should immediately wash outthe eyes and shower to remove residual material. Failure to comply could result in injury ordeath.
TM 55-1925-273-24&P-2
h03 /15 /20 11 Re l(1 .8) roo t(w arn s um)w pn o(F 00 002 )
7/30/2019 082853
11/1045
WARNING SUMMARY - Continued
HAZARDOUS MATERIALS DESCRIPTIONS - Continued
WARNING
HOT WORK AND GRINDING
Removing components by means of grinding or cutting produces hot, flying particles.These particles can cause serious injury to personnel. These hot particles can alsoignite fires in the work area and in adjacent spaces. During and after removal, thework area will be very hot. Wear protective goggles, gloves, and/or apron at all timesduring cutting and grinding operations. A fire watch must be posted whenevergrinding or cutting operations re taking place. Failure to comply with this warning canresult in serious injury or death to personnel.
Grinding, needling, and chipping operations produce high velocity flying debris whichcan become lodged in the skin or in the eyes. Grinding, needling, and chipping inconfined spaces can result in debris flying from unexpected directions. All personnelworking in the area must wear protective eyewear, gloves, and long sleeves whenperforming grinding, needling and chipping operations. Failure to comply can resultin death or serious injury to personnel.
Removing components by means of wire brushing produces flying particles. Theseparticles can cause serious injury to personnel. Protective goggles, gloves, and longsleeves must be worn at all times during wire brushing operations. Failure to complywith this warning can result in serious injury to personnel.
WARNING
WELDING
Unprotected exposure to arc welding rays can cause serious eye damage and radiation burnsto the skin. Never perform arc welding operations without using appropriate eye and skinprotection. Failure to comply can result in death or serious injury.
TM 55-1925-273-24&P-2
i 03 /15 /20 11 Re l(1 .8) roo t(w arn s um)w pn o(F 00 002 )
7/30/2019 082853
12/1045
WARNING SUMMARY - Continued
HAZARDOUS MATERIALS DESCRIPTIONS - Continued
WARNING
OILS AND CLEANING SOLVENT
Cleaning solvent is flammable and its vapor is potentially explosive. Do not usecleaning solvent in the vicinity of spark, open flame, or excessive heat. Do not usecleaning solvent in unventilated spaces. Failure to comply can result in death orserious injury.
Do not allow hydraulic fluid, engine oil, or cleaning solvents to come in contact withunprotected skin or eyes. Prolonged skin contact can cause illness or injury. Eye
contact can cause serious injury. Always wear chemical protective gloves andgoggles when handling hydraulic fluid, engine oil, and cleaning solvents. Failure tocomply can result in death or serious injury.
WARNING
RADIATION, RADIO ANTENNAS
Inspecting antennas with the INSA, radars, transceivers and receiver-transmitters turned onpresents a radiation hazard. Ensure all transceivers and receiver-transmitters are turned offprior to inspecting antennas. Ensure that the appropriate circuit breaker has been secured,locked out, and tagged out (WP0008) in accordance with FM 4-01.502. Failure to complycould result in injury or death.
TM 55-1925-273-24&P-2
j 03/1 5 /20 11 Re l(1.8 )ro o t(w arn su m) wp no (F0 00 02)
7/30/2019 082853
13/1045
WARNING SUMMARY - Continued
HAZARDOUS MATERIALS DESCRIPTIONS - Continued
WARNING
SEWAGE
Sewage is a common mode of transmission for parasitic organisms that may havethe capability of causing communicable diseases. Chemical protective gloves and aprotective apron should be worn to help prevent contact with sewage. After comingin contact with sewage or contaminated equipment, be sure to clean yourself with adisinfectant soap. Avoid sewage contact with skin abrasions, punctures, cuts, andother open wounds. Wipe up and clean any spills and/or contaminated equipmentusing a disinfectant soap. Failure to comply can result in death or serious illness.
Toxic and flammable vapors are generated in the sewage system. Provide ventilationfrom outside source. Avoid open flames and prolonged breathing of fumes. Failureto comply can result in death or serious injury.
TM 55-1925-273-24&P-2
k/l blank0 3/1 5/2 011 R el(1 .8) ro ot(w a rns um)w pn o(F 00 00 2)
7/30/2019 082853
14/1045
7/30/2019 082853
15/1045
LIST OF EFFECTIVE PAGES/WORK PACKAGES
NOTE: This manual supersedes TM 55-1925-273-24&P-2, dated 30 November 2005, including all changes. Zeroin the "Change No." column indicates an original page or work package.
Date of issue for the original manual is:Original 31 January 2013
TOTAL NUMBER OF VOLUMES IS 3, TOTAL NUMBER OF PAGES FOR FRONT AND REAR MATTER
AND TOTAL NUMBER OF WORK PACKAGES IS 163, CONSISTING OF THE FOLLOW
Page/WP No. Change No.
VOLUME 2Front Cover (2 pages) 0Warning Summary (12 pages) 0
i-xxiv (24 pages) 0Chapter 5 Title Page 0WP 0083 (2 pages) 0WP 0084 (4 pages) 0WP 0085 (10 pages) 0WP 0086 (22 pages) 0WP 0087 (2 pages) 0WP 0088 (4 pages) 0WP 0089 (6 pages) 0WP 0090 (4 pages) 0WP 0091 (8 pages) 0WP 0092 (12 pages) 0WP 0093 (4 pages) 0
WP 0094 (6 pages) 0WP 0095 (6 pages) 0WP 0096 (6 pages) 0WP 0097 (6 pages) 0WP 0098 (8 pages) 0WP 0099 (2 pages) 0WP 0100 (2 pages) 0WP 0101 (4 pages) 0WP 0102 (4 pages) 0WP 0103 (6 pages) 0WP 0104 (6 pages) 0WP 0105 (4 pages) 0WP 0106 (2 pages) 0WP 0107 (6 pages) 0WP 0108 (6 pages) 0WP 0109 (4 pages) 0WP 0110 (4 pages) 0WP 0111 (10 pages) 0WP 0112 (4 pages) 0WP 0113 (4 pages) 0WP 0114 (4 pages) 0WP 0115 (4 pages) 0WP 0116 (12 pages) 0
Page/WP No. Change No.
WP 0117 (8 pages) 0WP 0118 (6 pages) 0WP 0119 (6 pages) 0WP 0120 (4 pages) 0
WP 0121 (10 pages) 0WP 0122 (4 pages) 0WP 0123 (6 pages) 0WP 0124 (8 pages) 0WP 0125 (6 pages) 0WP 0126 (16 pages) 0WP 0127 (8 pages) 0WP 0128 (20 pages) 0WP 0129 (4 pages) 0WP 0130 (4 pages) 0WP 0131 (4 pages) 0WP 0132 (4 pages) 0WP 0133 (4 pages) 0
WP 0134 (4 pages) 0WP 0135 (4 pages) 0WP 0136 (4 pages) 0WP 0137 (4 pages) 0WP 0138 (6 pages) 0WP 0139 (4 pages) 0WP 0140 (4 pages) 0WP 0141 (4 pages) 0WP 0142 (6 pages) 0WP 0143 (4 pages) 0WP 0144 (6 pages) 0WP 0145 (4 pages) 0WP 0146 (4 pages) 0WP 0147 (4 pages) 0WP 0148 (4 pages) 0WP 0149 (4 pages) 0WP 0150 (4 pages) 0WP 0151 (4 pages) 0WP 0152 (6 pages) 0WP 0153 (4 pages) 0WP 0154 (8 pages) 0WP 0155 (10 pages) 0WP 0156 (8 pages) 0
TM 55-1925-273-24&P-2
A 03/1 5 /20 11 Re l(1.8 )ro o t(lo ep wp )w pn o(F 10 003 )
7/30/2019 082853
16/1045
LIST OF EFFECTIVE PAGES/WORK PACKAGES - Continued
Page/WP No. Change No.
WP 0157 (20 pages) 0WP 0158 (4 pages) 0
WP 0159 (6 pages) 0WP 0160 (14 pages) 0WP 0161 (4 pages) 0WP 0162 (6 pages) 0WP 0163 (6 pages) 0WP 0164 (2 pages) 0WP 0165 (6 pages) 0WP 0166 (8 pages) 0WP 0167 (8 pages) 0WP 0168 (4 pages) 0WP 0169 (4 pages) 0WP 0170 (4 pages) 0WP 0171 (8 pages) 0
WP 0172 (4 pages) 0WP 0173 (4 pages) 0WP 0174 (8 pages) 0WP 0175 (16 pages) 0WP 0176 (2 pages) 0WP 0177 (8 pages) 0WP 0178 (4 pages) 0WP 0179 (14 pages) 0WP 0180 (4 pages) 0WP 0181 (12 pages) 0WP 0182 (4 pages) 0WP 0183 (4 pages) 0WP 0184 (4 pages) 0WP 0185 (6 pages) 0
WP 0186 (8 pages) 0WP 0187 (6 pages) 0WP 0188 (8 pages) 0WP 0189 (6 pages) 0WP 0190 (4 pages) 0WP 0191 (6 pages) 0WP 0192 (4 pages) 0WP 0193 (10 pages) 0WP 0194 (6 pages) 0WP 0195 (8 pages) 0WP 0196 (12 pages) 0WP 0197 (6 pages) 0WP 0198 (4 pages) 0
WP 0199 (4 pages) 0WP 0200 (2 pages) 0WP 0201 (6 pages) 0
Page/WP No. Change No.
WP 0202 (10 pages) 0WP 0203 (6 pages) 0
WP 0204 (6 pages) 0WP 0205 (4 pages) 0WP 0206 (8 pages) 0WP 0207 (4 pages) 0WP 0208 (8 pages) 0WP 0209 (4 pages) 0WP 0210 (6 pages) 0WP 0211 (6 pages) 0WP 0212 (6 pages) 0WP 0213 (4 pages) 0WP 0214 (10 pages) 0WP 0215 (6 pages) 0WP 0216 (6 pages) 0
WP 0217 (6 pages) 0WP 0218 (6 pages) 0WP 0219 (4 pages) 0WP 0220 (8 pages) 0WP 0221 (4 pages) 0WP 0222 (4 pages) 0WP 0223 (4 pages) 0WP 0224 (4 pages) 0WP 0225 (8 pages) 0WP 0226 (6 pages) 0WP 0227 (4 pages) 0WP 0228 (8 pages) 0WP 0229 (10 pages) 0WP 0230 (6 pages) 0
WP 0231 (8 pages) 0WP 0232 (4 pages) 0WP 0233 (8 pages) 0WP 0234 (4 pages) 0WP 0235 (12 pages) 0WP 0236 (6 pages) 0WP 0237 (6 pages) 0WP 0238 (6 pages) 0WP 0239 (4 pages) 0WP 0240 (4 pages) 0WP 0241 (4 pages) 0WP 0242 (4 pages) 0WP 0243 (4 pages) 0
WP 0244 (6 pages) 0WP 0245 (4 pages) 0Back Cover 0
TM 55-1925-273-24&P-2
B0 3/1 5/2 01 1R el(1 .8 )ro ot( loe pw p) wp no (F1 00 03)
7/30/2019 082853
17/1045
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 31 JANUARY 2013
FIELD AND SUSTAINMENT MAINTENANCE MANUAL
INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST
FOR
INLAND AND COASTAL LARGE TUG (LT)
NSN 1925-01-509-7013 (EIC XAG)
REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS
You can help improve this publication. If you find any errors, or if you would like to recommend anyimprovements to the procedures in this publication, please let us know. The preferred method is to
submit your DA Form 2028 (Recommended Changes to Publications and Blank Forms) through theInternet on the TACOM Unique Logistics Support Applications (TULSA) Web site. The Internet addressis https://tulsa.tacom.army.mil. Access to all applications requires CAC authentication, and you must
complete the Access Request form the first time you use it. The DA Form 2028 is located under theTULSA Applications on the left-hand navigation bar. Fill out the form and click on SUBMIT. Using this
form on the TULSA Web site will enable us to respond more quickly to your comments and to bettermanage the DA Form 2028 program. You may also mail, e-mail, or fax your comments or DA Form
2028 directly to the U.S. Army TACOM Life Cycle Management Command. The postal mail addressis U.S. Army TACOM Life Cycle Management Command, ATTN: AMSTA-LCL-MPP/ TECH PUBS,MS 727, 6501 E. 11 Mile Road, Warren, MI 48397-5000. The e-mail address is
[email protected]. The fax number is DSN 786-1856 or Commercial(586) 282-1856. A reply will be furnished to you.
*SUPERSEDURE NOTICE - This manual supersedes TM 55-1925-273-24&P-2, dated 30 November 2005, including all changes.
DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited.
*TM 55-1925-273-24&P-2
i/ii blank03/1 5/2 01 1 Rel( 1.8 )ro o t(tit leb lk ) wp no (F 000 04 )
0 3/1 5/2 01 1R el( 1.8 )ro ot( titl eb lk ) wp no (F0 00 04)
TECHNICAL MANUAL
7/30/2019 082853
18/1045
7/30/2019 082853
19/1045
TABLE OF CONTENTS
Page NoWP Sequence No
Volume 2
Chapter 5 - FIELD MAINTENANCE INSTRUCTIONS FOR LT-800 SERIES
SERVICE UPON RECEIPT............................................................................................................... WP 0083
HULL STRUCTURE SERVICE.......................................................................................................... WP 0084
Figure 1. Deck Drain.................................................................................................................... 0084-2
PILOTHOUSE REPLACE.................................................................................................................. WP 0085
Table 1. Windshield Wipers and Motors...................................................................................... 0085-2
Figure 1. Windshield Wiper Motor............................................................................................... 0085-2
Figure 2. Windshield Wiper Motor Junction Box.......................................................................... 0085-3
Figure 3. Windshield Wiper Components (Exploded View)......................................................... 0085-4
Table 2. Heater Switch Circuit Breakers...................................................................................... 0085-6
Figure 4. Heater Switch Bank...................................................................................................... 0085-7
Figure 5. Heater Switch............................................................................................................... 0085-8
PILOTHOUSE REPAIR...................................................................................................................... WP 0086
Figure 1. 120 V Exterior Emergency Lighting Panel No. 2.......................................................... 0086-2
Figure 2. Wiper Blade.................................................................................................................. 0086-3
Figure 3. Toggle Latch................................................................................................................. 0086-4
Figure 4. 01 & 02 Level Reheater 120 V Fuse Box No. 1............................................................ 0086-5
Figure 5. Pilothouse Wing Console (Starboard Shown, Port Opposite Hand)............................. 0086-6
Figure 6. Pilothouse Wing Console Thermostat.......................................................................... 0086-8
Figure 7. Pilothouse Wing Console Heater................................................................................ 0086-11
Figure 8. Navigator's Seat......................................................................................................... 0086-12
Figure 9. General Alarm and Emergency Lighting Distribution Panel....................................... 0086-13
Figure 10. Pilothouse Console Illumination Light....................................................................... 0086-14
Figure 11. Pilothouse Alarm Panel............................................................................................ 0086-16
Figure 12. Pilothouse Alarm Panel (Back Side)......................................................................... 0086-17
Figure 13. LED........................................................................................................................... 0086-17
TM 55-1925-273-24&P-2
iii03/1 5/2 01 1R el( 1.8 )ro ot( co nte nts )w p no(F 0 000 5)
7/30/2019 082853
20/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
Figure 14. Pilothouse Alarm Panel Pushbutton......................................................................... 0086-19
Figure 15. Pilothouse Alarm Panel Buzzer................................................................................ 0086-20
HYDRAULIC WATERTIGHT DOORS ADJUST................................................................................ WP 0087
Figure 1. Hydraulic Watertight Door............................................................................................ 0087-2
HYDRAULIC WATERTIGHT DOORS REPAIR................................................................................. WP 0088
Figure 1. Hydraulic Watertight Door............................................................................................ 0088-2
HYDRAULIC CYLINDER ASSEMBLY REPLACE............................................................................. WP 0089
Figure 1. Valve Assembly............................................................................................................ 0089-3
Figure 2. Hydraulic Cylinder........................................................................................................ 0089-5
HYDRAULIC CYLINDER ASSEMBLY REPAIR................................................................................ WP 0090
Figure 1. End View of Cylinder.................................................................................................... 0090-2
Figure 2. Cylinder Assembly........................................................................................................ 0090-3
CONTROL VALVE ASSEMBLY REPLACE....................................................................................... WP 0091
Figure 1. AMS 1 and AMS 2 Control Valve Assemblies.............................................................. 0091-3
Figure 2. Control Valve Assembly............................................................................................... 0091-4
Figure 3. Hydraulic Cylinder Vent................................................................................................ 0091-5
Figure 4. Control Valve Assembly Pressure Setting.................................................................... 0091-7
CONTROL VALVE ASSEMBLY REPAIR.......................................................................................... WP 0092
Figure 1. Remote Valve Assembly.............................................................................................. 0092-3
Figure 2. Single Check Valve...................................................................................................... 0092-5
Figure 3. Dual Relief Valve.......................................................................................................... 0092-7
Figure 4. Quad Check Valve........................................................................................................ 0092-9
Figure 5. Shuttle Valve.............................................................................................................. 0092-11
HAND PUMPS LOCAL/REMOTE REPLACE.................................................................................... WP 0093
Figure 1. Hydraulic Watertight Door System............................................................................... 0093-3
Figure 2. Hand Pump................................................................................................................... 0093-4
HAND PUMPS LOCAL/REMOTE REPAIR........................................................................................ WP 0094
TM 55-1925-273-24&P-2
iv0 3/1 5/2 01 1R el(1 .8 )ro ot(c o nte nts )w pn o(F 00 005 )
7/30/2019 082853
21/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 1. Local Hand Pump......................................................................................................... 0094-3
Figure 2. Remote Hand Pump..................................................................................................... 0094-4
WATERTIGHT DOORS REPAIR....................................................................................................... WP 0095
Figure 1. Watertight Door............................................................................................................ 0095-3
Figure 2. Watertight Door (Typical).............................................................................................. 0095-4
WATERTIGHT HATCHES REPAIR................................................................................................... WP 0096
Figure 1. Watertight Hatch........................................................................................................... 0096-2
Figure 2. Watertight Hatch........................................................................................................... 0096-4
WATERTIGHT SCUTTLES REPAIR................................................................................................. WP 0097
Figure 1. Watertight Scuttle......................................................................................................... 0097-3
Figure 2. Watertight Scuttle......................................................................................................... 0097-4
WATERTIGHT MANHOLES REPAIR................................................................................................ WP 0098
Figure 1. Manhole (Raised)......................................................................................................... 0098-3
Figure 2. Manhole (Flush)............................................................................................................ 0098-4
Figure 3. Raised Manhole Cover (Typical).................................................................................. 0098-5
Figure 4. Flush Manhole (Typical)............................................................................................... 0098-7
MAST SERVICE................................................................................................................................ WP 0099
MAST REPAIR................................................................................................................................... WP 0100
PORTLIGHT REPAIR........................................................................................................................ WP 0101
Figure 1. Window Cover and Glass Frame.................................................................................. 0101-2
ROTARY CLEAR-VIEW SCREEN REPLACE................................................................................... WP 0102
Figure 1. Clear-view Screen Control Box.................................................................................... 0102-2
Figure 2. Clear-view Screen........................................................................................................ 0102-3
ROTARY CLEAR-VIEW SCREEN REPAIR...................................................................................... WP 0103
Figure 1. Clear-view Screen Control Box.................................................................................... 0103-2
REDUCTION GEAR COOLING PUMP REPLACE............................................................................ WP 0104
Figure 1. Electrical Junction Box................................................................................................. 0104-2
TM 55-1925-273-24&P-2
v0 3/1 5/2 01 1R el(1 .8 )ro ot(c o nte nts )w pn o(F 00 005 )
7/30/2019 082853
22/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
Figure 2. Reduction Gear Cooling Pump Assembly.................................................................... 0104-3
Figure 3. Reduction Gear Cooling Pump Assembly (Mounting Hardware)................................. 0104-4
REDUCTION GEAR COOLING PUMP REPAIR............................................................................... WP 0105
Figure 1. Reduction Gear Cooling Pump..................................................................................... 0105-3
PROPELLER INSPECT..................................................................................................................... WP 0106
KEEL COOLERS INSPECT............................................................................................................... WP 0107
Figure 1. Keel Cooler Piping........................................................................................................ 0107-3
FUEL SYSTEM VALVES REPLACE................................................................................................. WP 0108
Figure 1. Typical Threaded Ball Valve......................................................................................... 0108-3
Figure 2. Typical Two-Way Ball Valve......................................................................................... 0108-5
FUEL SYSTEM VALVES REPAIR..................................................................................................... WP 0109
Figure 1. Flanged Gate Valve...................................................................................................... 0109-3
FUEL OIL TRANSFER PUMP, PUMP END REPLACE..................................................................... WP 0110
Figure 1. Fuel Oil Transfer Pump................................................................................................ 0110-3
FUEL OIL TRANSFER PUMP, PUMP END REPAIR........................................................................ WP 0111
Figure 1. Fuel Oil Transfer Pump (Exploded View)..................................................................... 0111-4
Figure 2. Fuel Oil Transfer Pump................................................................................................ 0111-5
Figure 3. Rotor/Vane Orientation................................................................................................. 0111-6
Figure 4. Mechanical Seal........................................................................................................... 0111-7
Figure 5. Vane............................................................................................................................. 0111-8
FUEL OIL TRANSFER PUMP ELECTRIC MOTOR REPLACE........................................................ WP 0112
Figure 1. Electrical Junction Box................................................................................................. 0112-2
Figure 2. Coupling Guard............................................................................................................ 0112-3
Figure 3. Alignment of Pump Coupling Flange and Motor Coupling Flange................................ 0112-4
FUEL OIL FILTER/WATER SEPARATOR (ENGINES) SERVICE.................................................... WP 0113
Figure 1. Fuel Oil Filter/Water Separator..................................................................................... 0113-3
FUEL OIL FILTER/WATER SEPARATOR (ENGINES) REPAIR....................................................... WP 0114
TM 55-1925-273-24&P-2
vi0 3/1 5/2 01 1R el(1 .8 )ro ot(c o nte nts )w pn o(F 00 005 )
7/30/2019 082853
23/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 1. Fuel Oil Filter/Water Separator..................................................................................... 0114-3
ENGINE INTAKE/EXHAUST SYSTEM COMPONENTS REPLACE................................................. WP 0115
Figure 1. Air Box Drain Valve (Typical)........................................................................................ 0115-2
LUBE OIL SYSTEM VALVES REPLACE.......................................................................................... WP 0116
Figure 1. Typical Ball Valve (Flanged)......................................................................................... 0116-3
Figure 2. Typical Ball Valve (Threaded)...................................................................................... 0116-5
Figure 3. Typical Angle Hose Globe Valve (Flanged).................................................................. 0116-7
Figure 4. Typical Globe Stop Check Valve (Flanged).................................................................. 0116-9
Figure 5. Typical Swing Check Valve (Flanged)........................................................................ 0116-11
LUBE OIL SYSTEM VALVES REPAIR.............................................................................................. WP 0117
Figure 1. Flanged Ball Valve........................................................................................................ 0117-3
Figure 2. Flanged Globe Valve.................................................................................................... 0117-5
Figure 3. Flanged Check Valve................................................................................................... 0117-7
LUBE OIL TRANSFER PUMP REPLACE......................................................................................... WP 0118
Figure 1. Electrical Junction Box................................................................................................. 0118-2
Figure 2. Electric Motor................................................................................................................ 0118-3
Figure 3. Lube Oil Transfer Pump............................................................................................... 0118-4
Figure 4. Alignment of Pump Coupling Flange and Motor Coupling Flange................................ 0118-5
LUBE OIL TRANSFER PUMP REPAIR............................................................................................. WP 0119
Figure 1. Lube Oil Transfer Pump............................................................................................... 0119-3
PRELUBRICATION OIL PUMP, PUMP END REPLACE................................................................... WP 0120
Figure 1. Main Engine Prelubrication Pump................................................................................ 0120-3
PRELUBRICATION OIL PUMP, PUMP END REPAIR...................................................................... WP 0121
Figure 1. Main Engine Prelubrication Pump (Exploded View)..................................................... 0121-4
Figure 2. Mechanical Seal........................................................................................................... 0121-6
Figure 3. Locknut Adjustment...................................................................................................... 0121-8
PRELUBRICATION OIL PUMP ELECTRIC MOTOR REPLACE...................................................... WP 0122
TM 55-1925-273-24&P-2
vii03 /15 /20 11 Re l(1.8 )r oo t(c on ten ts)w p no (F0 00 05)
7/30/2019 082853
24/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
Figure 1. Electrical Junction Box................................................................................................. 0122-2
Figure 2. Electric Motor................................................................................................................ 0122-3
Figure 3. Alignment of Pump Coupling Flange and Motor Coupling Flange................................ 0122-4
ELECTRICAL POWER SYSTEM TEST............................................................................................ WP 0123
Table 1. Normal Power Interlocks................................................................................................ 0123-2
Figure 1. Main Switchboard......................................................................................................... 0123-3
Figure 2. Emergency Switchboard............................................................................................... 0123-4
Table 2. EDG Power Interlocks (No Feedback)........................................................................... 0123-4
Table 3. EDG Power, Interlocks (with Feedback)........................................................................ 0123-5
ELECTRICAL POWER SYSTEM ADJUST........................................................................................ WP 0124
Table 1. EDG Circuit Breaker Setting Information....................................................................... 0124-2
Figure 1. EDG Circuit Breaker Location...................................................................................... 0124-3
Table 2. SSDG 1 and SSDG 2 Circuit Breaker Setting Information............................................ 0124-4
Figure 2. SSDG 1 and SSDG 2 Circuit Breaker Location............................................................ 0124-5
Table 3. Shore Power Circuit Breaker Setting Information.......................................................... 0124-6
Figure 3. Shore Power Circuit Breaker Location......................................................................... 0124-7
ELECTRICAL POWER SYSTEM REPAIR........................................................................................ WP 0125
Figure 1. Shore Power Receptacle.............................................................................................. 0125-3
Figure 2. Shore Power Cable Connector..................................................................................... 0125-5
MAIN SWITCHBOARD REPLACE.................................................................................................... WP 0126
Figure 1. Main Switchboard Top Left Panel................................................................................. 0126-3
Figure 2. Main Switchboard Top Left Aft Panel (Rear)................................................................ 0126-5
Figure 3. Main Switchboard Middle Left Panel............................................................................ 0126-7
Figure 4. Main Switchboard Top Center Panel............................................................................ 0126-9
Figure 5. Main Switchboard, Top Center Panel (Rear).............................................................. 0126-11
Figure 6. Main Switchboard Bottom Center Panel..................................................................... 0126-15
MAIN SWITCHBOARD REPAIR........................................................................................................ WP 0127
TM 55-1925-273-24&P-2
viii03 /15 /20 11 Re l(1.8 )ro o t(c onte n ts)w p no (F0 00 05)
7/30/2019 082853
25/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 1. Main Switchboard......................................................................................................... 0127-3
Figure 2. Main Switchboard Back Panel Layout.......................................................................... 0127-5
EMERGENCY SWITCHBOARD REPAIR.......................................................................................... WP 0128
Figure 1. Emergency Switchboard Top Panel............................................................................. 0128-3
Figure 2. Emergency Switchboard Middle Panel......................................................................... 0128-7
Figure 3. Emergency Switchboard Back Panel Layout.............................................................. 0128-10
Figure 4. Emergency Switchboard............................................................................................. 0128-13
Figure 5. Bus Tie Circuit Breaker............................................................................................... 0128-14
Figure 6. Bus Tie Circuit Breaker Bus Bar and Wire Connections............................................ 0128-15
Figure 7. SSDG 1, SSDG 2, and EDG Circuit Breaker Front Panel (Typical)........................... 0128-17
Figure 8. EDG Circuit Breaker................................................................................................... 0128-18
DISTRIBUTION AND FUSE PANELS (TYPICAL) REPLACE........................................................... WP 0129
Figure 1. Load Center.................................................................................................................. 0129-2
LIGHTING FIXTURE JUNCTION BOX (TYPICAL) REPAIR............................................................. WP 0130
Figure 1. Junction Box Lighting................................................................................................... 0130-3
LIGHTING FIXTURE BRACKET (TYPICAL) REPAIR....................................................................... WP 0131
Figure 1. Lighting Fixture Bracket................................................................................................ 0131-3
RECESSED FLUORESCENT FIXTURE REPLACE......................................................................... WP 0132
Figure 1. Fluorescent Fixture (Recessed)................................................................................... 0132-2
SURFACE MOUNT FLUORESCENT LIGHT REPLACE................................................................... WP 0133
Figure 1. Fluorescent Light, Surface Mount................................................................................. 0133-2
WATERTIGHT INCANDESCENT EXPLOSION PROOF (TYPICAL) LIGHTING FIXTUREREPAIR.................................................................................................................................. .. WP 0134
Figure 1. Explosion Proof Lighting Fixture................................................................................... 0134-2
FLOODLIGHTS REPLACE................................................................................................................ WP 0135
Figure 1. Metal Halide Floodlight................................................................................................. 0135-3
FLOODLIGHTS REPAIR................................................................................................................... WP 0136
Figure 1. Metal Halide Floodlight................................................................................................. 0136-3
TM 55-1925-273-24&P-2
ix03/1 5/2 01 1R el( 1.8 )ro ot( co nte nts )w p no(F 0 000 5)
7/30/2019 082853
26/1045
TM 55-1925-273-24&P-2
x
0270 MOTOR CONTROLLER: REDUCTION GEAR COOLING PUMP; SEWAGE DISCHARGE
PUMP 1 & 2; LUBE OIL TRANSFER PUMP; POTABLE WATER PUMP 1 & 2; GALLEYSUPPLY FAN; GALLEY EXHAUST FAN; SANITARY SPACE EXHAUST FAN; CREW
MESS FAN COIL UNIT; 01, 02, 03 LEVELS FAN COIL UNIT; AIR COMPRESSOR 1 & 2;
FUEL OIL TRANSFER PUMP; AFFF PUMP REPLACE.......................................................... WP 0137
0271 Figure 1. Motor Controller Type 1 (Typical) ..................................................................................0137-3
0272 MOTOR CONTROLLER: REDUCTION GEAR COOLING PUMP; SEWAGE DISCHARGE
PUMP 1 & 2; LUBE OIL TRANSFER PUMP; POTABLE WATER PUMP 1 & 2; GALLEY
SUPPLY FAN; GALLEY EXHAUST FAN; SANITARY SPACE EXHAUST FAN; CREW
MESS FAN COIL UNIT; 01, 02, 03 LEVELS FAN COIL UNIT; AIR COMPRESSOR 1 & 2;
FUEL OIL TRANSFER PUMP; AFFF PUMP REPAIR............................................................... WP 0138
0273 Figure 1. Motor Controller Type 1 (Typical) ..................................................................................0138-3
0274 MOTOR CONTROLLER: LUBE OIL PRIMING PUMP 1 & 2 REPLACE ........................................... WP 0139
0275 Figure 1. Motor Controller Type 6 (Typical) ..................................................................................0139-2
0276 Figure 2. Motor Controller Type 6 Cover Removed...................................................................0139-3
0277 MOTOR CONTROLLER: LUBE OIL PRIMING PUMP 1 & 2 REPAIR............................................... . WP 0140
0278 Figure 1. Motor Controller Type 6 (Typical) ..................................................................................0140-2
0279 Figure 2. Motor Controller Type 6 Cover Removed ...................................................................0140-3
0280 MOTOR CONTROLLER: AMS 1 & 2 SUPPLY FAN; BOATSWAINS STORE ROOM SUPPLY
FAN; ARMS LOCKER EXHAUST FAN; ENGINE ROOM SUPPLY FAN 1 & 2; ENGINEROOM EXHAUST FAN 1 & 2 REPLACE.................................................................................. WP 0141
0281 Figure 1. Motor Controller Type 2 (Typical) ..................................................................................0141-3
0282 MOTOR CONTROLLER: AMS 1 & 2 SUPPLY FAN; BOATSWAINS STORE ROOM SUPPLY
FAN; ARMS LOCKER EXHAUST FAN; ENGINE ROOM SUPPLY FAN 1 & 2; ENGINE
ROOM EXHAUST FAN 1 & 2 REPAIR...................................................................................... WP 0142
0283 Figure 1. Motor Controller Type 2 (Typical)...................................................................................0142-3
0284 MOTOR CONTROLLER: BILGE & BALLAST PUMP 1 & 2; FIRE & GENERAL SERVICE
EMERGENCY PUMP #1 & #2 REPLACE ................................................................................ WP 0143
0285 Figure 1. Type 3 Motor Controller .................................................................................................0143-3
0286 MOTOR CONTROLLER: BILGE & BALLAST PUMP 1 & 2; FIRE & GENERAL SERVICE
EMERGENCY PUMP #1 & #2 REPAIR ................................................................................... WP 0144
0287 Figure 1. MotorController Type 3 (Typical) ..................................................................................0144-3
0288 MOTOR CONTROLLER: HOT POTABLE WATER RECIRCULATING PUMP REPLACE................ WP 0145
TABLE OF CONTENTS - Continued
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Page No
WP Sequence No- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
7/30/2019 082853
27/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 1. Type 4 Motor Controller................................................................................................ 0145-3
MOTOR CONTROLLER: HOT POTABLE WATER RECIRCULATING PUMP REPAIR................... WP 0146
Figure 1. Motor Controller Type 4................................................................................................ 0146-3
MOTOR CONTROLLER: WELD HOOD EXHAUST FAN REPLACE................................................ WP 0147
Figure 1. Motor Controller Type 5 (Typical)................................................................................. 0147-2
Figure 2. Interior of Motor Controller Type 5................................................................................ 0147-3
MOTOR CONTROLLER: WELD HOOD EXHAUST FAN REPAIR................................................... WP 0148
Figure 1. Motor Controller Type 5 (Typical)................................................................................. 0148-2
BATTERY POWER SUPPLY SYSTEM TEST................................................................................... WP 0149
Figure 1. Batteries and Refractometer......................................................................................... 0149-3
BATTERY POWER SUPPLY SYSTEM SERVICE............................................................................ WP 0150
Figure 1. Battery Bank Power Supply System............................................................................. 0150-4
BATTERY POWER SUPPLY SYSTEM REPLACE........................................................................... WP 0151
Figure 1. Battery.......................................................................................................................... 0151-2
Figure 2. Battery, Power Supply System..................................................................................... 0151-4
BATTERY POWER SUPPLY SYSTEM REPAIR............................................................................... WP 0152
Figure 1. Battery.......................................................................................................................... 0152-3
Figure 2. Battery Bank................................................................................................................. 0152-3
Figure 3. Battery Box Fan............................................................................................................ 0152-5
BATTERY CHARGER REPLACE...................................................................................................... WP 0153
Figure 1. Battery Charger............................................................................................................ 0153-2
Figure 2. Battery Charger Internal Components.......................................................................... 0153-3
BATTERY CHARGER REPAIR......................................................................................................... WP 0154
Figure 1. Battery Charger............................................................................................................ 0154-2
Figure 2. Battery Charger Internal Components.......................................................................... 0154-3
Figure 3. Typical Wire Terminal................................................................................................... 0154-5
Figure 4. Battery Charger............................................................................................................ 0154-7
TM 55-1925-273-24&P-2
xi 03/1 5/2 01 1R el( 1.8 )ro ot( co nte nts )w p no(F 0 000 5)
7/30/2019 082853
28/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
SEARCHLIGHTS SERVICE.............................................................................................................. WP 0155
Figure 1. Searchlight Lamp.......................................................................................................... 0155-3
Table 1. Lubrication Points (Refer to Figure 2)............................................................................ 0155-4
Figure 2. Searchlight.................................................................................................................... 0155-5
Figure 3. Searchlight.................................................................................................................... 0155-7
Figure 4. Lamp Starter................................................................................................................. 0155-8
SEARCHLIGHTS REPLACE............................................................................................................. WP 0156
Figure 1. 500 W Xenon Searchlight............................................................................................. 0156-3
Figure 2. 500 W Xenon Searchlight Rear Cover Removed......................................................... 0156-5
Figure 3. Searchlight Base Assembly.......................................................................................... 0156-7
SEARCHLIGHTS REPAIR................................................................................................................. WP 0157
Figure 1. Searchlight Lamp.......................................................................................................... 0157-3
Figure 2. 500 W Xenon Searchlight............................................................................................. 0157-4
Figure 3. Searchlight Side View................................................................................................... 0157-5
Figure 4. 500 W Xenon Searchlight Rear Cover Removed......................................................... 0157-6
Figure 5. Searchlight Base Assembly.......................................................................................... 0157-9
Figure 6. Searchlight Lamp Starter Assembly........................................................................... 0157-12
Figure 7. Searchlight Control Station......................................................................................... 0157-14
SEARCHLIGHT POWER SUPPLY TEST.......................................................................................... WP 0158
Figure 1. Exterior Searchlight Power Supply............................................................................... 0158-2
Figure 2. Interior Searchlight Power Supply................................................................................ 0158-3
SEARCHLIGHT POWER SUPPLY REPLACE.................................................................................. WP 0159
Figure 1. Searchlight Power Supply (External)............................................................................ 0159-3
Figure 2. Searchlight Power Supply (Internal)............................................................................. 0159-4
SEARCHLIGHT POWER SUPPLY REPAIR..................................................................................... WP 0160
Figure 1. Searchlight Power Supply............................................................................................ 0160-3
Figure 2. Searchlight Power Supply Internal Door Components................................................. 0160-4
TM 55-1925-273-24&P-2
xii 03/1 5/2 01 1R el( 1.8 )ro ot( co nte nts )w pn o(F 00 00 5)
7/30/2019 082853
29/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 3. Searchlight Power Supply Internal Components.......................................................... 0160-9
NAVIGATION LIGHTS (RUNNING LIGHTS) REPLACE................................................................... WP 0161
Figure 1. Navigation Light (Single Lens)...................................................................................... 0161-3
NAVIGATION LIGHTS (RUNNING LIGHTS) REPAIR...................................................................... WP 0162
Figure 1. Navigation Light (Single Lens)...................................................................................... 0162-3
Figure 2. Navigation Light (Double Lens).................................................................................... 0162-5
YARDARM BLINKER LIGHT AND KEY REPLACE........................................................................... WP 0163
Figure 1. Yardarm Blinker Light................................................................................................... 0163-3
Figure 2. Yardarm Blinker Key..................................................................................................... 0163-4
Figure 3. Blinker Key Wiring........................................................................................................ 0163-5
YARDARM BLINKER LIGHT AND KEY REPAIR.............................................................................. WP 0164
Figure 1. Yardarm Light............................................................................................................... 0164-2
NAVIGATION LIGHTING PANEL REPLACE.................................................................................... WP 0165
Figure 1. Navigation Lighting Panel............................................................................................. 0165-3
Figure 2. Internal Components of the Navigation Lighting Panel................................................ 0165-4
NAVIGATION LIGHTING PANEL REPAIR........................................................................................ WP 0166
Figure 1. Navigation Lighting Panel............................................................................................. 0166-2
Figure 2. Navigation Lighting Panel............................................................................................. 0166-4
Figure 3. Navigation Lighting Panel (OPEN)............................................................................... 0166-5
GENERAL ALARM SYSTEM REPLACE........................................................................................... WP 0167
Figure 1. General Alarm Bell Assembly....................................................................................... 0167-3
Figure 2. Bell Assembly............................................................................................................... 0167-4
Figure 3. Contactor Switch Cover................................................................................................ 0167-6
Figure 4. Contactor Terminal....................................................................................................... 0167-7
ROTATING BEACON REPLACE....................................................................................................... WP 0168
Figure 1. General Alarm Rotating Beacon................................................................................... 0168-3
ROTATING BEACON REPAIR.......................................................................................................... WP 0169
TM 55-1925-273-24&P-2
xiii03 /15 /20 11 Re l(1 .8)r o ot(c on ten ts )w pno (F 000 05 )
7/30/2019 082853
30/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
Figure 1. General Alarm Rotating Beacon................................................................................... 0169-3
BATTERY CHARGER REPLACE...................................................................................................... WP 0170
Table 1. Battery Charger Lock Out and Tag Out Guide.............................................................. 0170-1
Figure 1. Battery Charger............................................................................................................ 0170-2
Figure 2. Battery Charger Internal Components.......................................................................... 0170-3
BATTERY CHARGER REPAIR......................................................................................................... WP 0171
Figure 1. Typical Wire Terminal................................................................................................... 0171-2
Figure 2. Battery Charger............................................................................................................ 0171-4
Figure 3. Battery Charger Front Cover........................................................................................ 0171-6
Figure 4. Ammeter and Circuit Breaker....................................................................................... 0171-7
BATTERY BANK SERVICE............................................................................................................... WP 0172
Figure 1. Battery Bank Power Supply System............................................................................. 0172-4
BATTERY BANK REPLACE.............................................................................................................. WP 0173
Figure 1. Battery.......................................................................................................................... 0173-2
Figure 2. Battery Power Supply System...................................................................................... 0173-3
SIGNAL HORN REPLACE................................................................................................................. WP 0174
Figure 1. Signal Horn................................................................................................................... 0174-3
Figure 2. Signal Horn Power Supply............................................................................................ 0174-4
Figure 3. Oscillator....................................................................................................................... 0174-6
Figure 4. Timer............................................................................................................................ 0174-7
ALARM SYSTEM, ARMS STORAGE AND RADIO ROOM REPAIR................................................ WP 0175
Figure 1. Alarm Panel Components (Exterior View).................................................................... 0175-3
Figure 2. Alarm Panel Components (Internal View).................................................................... 0175-5
Figure 3. Thermostat Assembly................................................................................................... 0175-9
Figure 4. Arms Locker Water Switch Assembly......................................................................... 0175-11
Figure 5. Rotary Snap Switch Assembly................................................................................... 0175-12
Figure 6. Door Alarm Switch Assembly..................................................................................... 0175-13
TM 55-1925-273-24&P-2
xiv03 /15 /20 11 Re l(1.8 )ro o t(c onte n ts)w p no (F0 00 05)
7/30/2019 082853
31/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 7. Alarm Panel Assembly............................................................................................... 0175-15
INTERIOR COMMUNICATIONS REPLACE...................................................................................... WP 0176
Figure 1. Public Address System Amplifier.................................................................................. 0176-2
INTERIOR COMMUNICATIONS REPAIR......................................................................................... WP 0177
Figure 1. Volume Control Box...................................................................................................... 0177-3
Figure 2. Interior/Exterior Loudspeaker Depiction (Typical)........................................................ 0177-5
Figure 3. Electrical Wiring Terminal Depiction (Typical).............................................................. 0177-7
SOUND POWERED TELEPHONES REPLACE................................................................................ WP 0178
Figure 1. Sound Powered Telephone - Handset (Typical)........................................................... 0178-2
Figure 2. Sound Powered Telephone - Headset-Chestset (Typical)........................................... 0178-3
SOUND POWERED TELEPHONES REPAIR................................................................................... WP 0179
Figure 1. Sound Powered Telephone MWT-246J....................................................................... 0179-2
Figure 2. Sound Powered Telephone SW-23J............................................................................ 0179-5
Figure 3. Sound Powered Telephone SWLR-243J...................................................................... 0179-7
Figure 4. Sound Powered Telephone SW-243J........................................................................ 0179-11
Figure 5. Sound Powered Telephone Wiring (Typical).............................................................. 0179-13
INTERCOMMUNICATION SYSTEM REPLACE................................................................................ WP 0180
Figure 1. Intercommunication Station (Typical)........................................................................... 0180-2
INTERCOMMUNICATION SYSTEM REPAIR................................................................................... WP 0181
Figure 1. Intercommunication Station (Front View)..................................................................... 0181-2
Figure 2. Intercommunication Station (Rear View)...................................................................... 0181-4
Figure 3. Intercommunication Station (Front View)..................................................................... 0181-6
Figure 4. Intercommunication Station (Top View Inside of Faceplate)........................................ 0181-9
Figure 5. Intercommunication Station (Bottom View)................................................................ 0181-11
ENGINE ORDER TELEGRAPH (EOT) REPLACE............................................................................ WP 0182
Figure 1. EOT Panel Removed.................................................................................................... 0182-3
ENGINE ORDER TELEGRAPH (EOT) REPAIR............................................................................... WP 0183
TM 55-1925-273-24&P-2
xv03 /15 /20 11 Re l(1.8 )r oo t(c on ten ts)w p no (F0 00 05)
7/30/2019 082853
32/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
Figure 1. Engine Order Telegraph (EOT) Panel Repair (Typical)................................................ 0183-3
TANK LEVEL INDICATOR (TLI) INSPECT....................................................................................... WP 0184
Figure 1. 11 Channel TLI Control Panel...................................................................................... 0184-3
Figure 2. 7 Channel TLI Control Panel........................................................................................ 0184-3
Figure 3. TLI Remote Indicator.................................................................................................... 0184-4
Figure 4. Control Module Circuit Card......................................................................................... 0184-4
TANK LEVEL INDICATOR (TLI) TEST.............................................................................................. WP 0185
Figure 1. 11 Channel TLI Control Panel...................................................................................... 0185-2
Figure 2. 7 Channel TLI Control Panel........................................................................................ 0185-3
Figure 3. TLI Remote Indicator.................................................................................................... 0185-3
Figure 4. Control Module Circuit Card......................................................................................... 0185-4
TANK LEVEL INDICATOR (TLI) ADJUST......................................................................................... WP 0186
Figure 1. 11 Channel TLI Control Panel...................................................................................... 0186-2
Figure 2. 7 Channel TLI Control Panel........................................................................................ 0186-3
Figure 3. TLI Remote Indicator.................................................................................................... 0186-4
Figure 4. Control Module Circuit Card......................................................................................... 0186-4
Figure 5. Float Simulator............................................................................................................. 0186-6
TANK LEVEL INDICATOR (TLI) CALIBRATE................................................................................... WP 0187
Figure 1. 11 Channel TLI Control Panel...................................................................................... 0187-2
Figure 2. 7 Channel TLI Control Panel........................................................................................ 0187-3
Figure 3. TLI Remote Receiver Module....................................................................................... 0187-3
Figure 4. Control Module Circuit Card......................................................................................... 0187-4
TANK LEVEL INDICATOR (TLI) REPLACE...................................................................................... WP 0188
Figure 1. Tank Level Indicator Panel........................................................................................... 0188-3
Figure 2. TLI Control Panel and Components............................................................................. 0188-4
Figure 3. Receiver Panel Interior................................................................................................. 0188-5
Figure 4. Panel Meter.................................................................................................................. 0188-6
TM 55-1925-273-24&P-2
xvi 03 /15 /20 11 Re l(1.8 )ro o t(c onte n ts)w p no (F0 00 05)
7/30/2019 082853
33/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 5. Alarm Horn Assembly................................................................................................... 0188-8
TANK LEVEL INDICATOR (TLI) REPAIR.......................................................................................... WP 0189
Figure 1. 120 V Emergency Distribution Panel No. 1.................................................................. 0189-2
Figure 2. TLI Control Panel and Components............................................................................. 0189-3
Figure 3. Control Panel Fuse Holder Assembly........................................................................... 0189-5
TLI FLUID LEVEL DETECTION DEVICES INSPECT....................................................................... WP 0190
Figure 1. Tank Level Indicator (TLI) Transmitter Mounting Brackets........................................... 0190-3
TLI FLUID LEVEL DETECTION DEVICES REPLACE...................................................................... WP 0191
Figure 1. TLI Transmitter Mounting Brackets and Transmitter.................................................... 0191-2
Figure 2. TLI Transmitter Mounting Bracket Top View................................................................ 0191-3
TLI TRANSMITTERS INSPECT........................................................................................................ WP 0192
Figure 1. TLI Indicator Transmitter.............................................................................................. 0192-3
TLI TRANSMITTERS REPLACE....................................................................................................... WP 0193
Figure 1. Connection Box (Typical)............................................................................................. 0193-2
Figure 2. TLI Transmitter Configuration and Components.......................................................... 0193-3
Figure 3. TLI Transmitter (Typical).............................................................................................. 0193-4
Figure 4. TLI Transmitter Mounts (Typical).................................................................................. 0193-5
Figure 5. Junction Box and Flange Mounted Transmitter (Typical)............................................. 0193-9
TLI CABLE ASSEMBLIES INSPECT................................................................................................. WP 0194
Figure 1. TLI Transmitter Configuration and Components.......................................................... 0194-3
Figure 2. Connection Box............................................................................................................ 0194-4
Figure 3. TLI Transmitter Tag...................................................................................................... 0194-5
TLI CABLE ASSEMBLIES REPLACE................................................................................................ WP 0195
Figure 1. Connection Box (Typical)............................................................................................. 0195-2
Figure 2. TLI Transmitter Configuration and Components (Typical)............................................ 0195-3
Figure 3. Cable Assembly Adapter and TLI Transmitter Connector (Typical)............................. 0195-4
Figure 4. TLI Transmitter Tag...................................................................................................... 0195-6
TM 55-1925-273-24&P-2
xvii0 3/1 5/2 01 1R el(1 .8 )ro ot(c o nte nts )w pn o(F 00 005 )
7/30/2019 082853
34/1045
TABLE OF CONTENTS - Continued
Page No.WP Sequence No.
DAY TANK HIGH LEVEL ALARM, ALARM PANEL REPAIR............................................................ WP 0196
Figure 1. Machinery DC Control Distribution Panel..................................................................... 0196-2
Figure 2. Day Tank High Level Alarm Panel................................................................................ 0196-3
Figure 3. Day Tank High Level Alarm Panel Components.......................................................... 0196-7
Figure 4. Relay Assembly............................................................................................................ 0196-9
Figure 5. Horn/Strobe Assembly................................................................................................ 0196-11
DAY TANK HIGH LEVEL ALARM LEVEL ALARM SENSOR REPLACE.......................................... WP 0197
Figure 1. Junction Box with Cover Removed............................................................................... 0197-3
Figure 2. Day Tank High Level Alarm Sensor Assembly............................................................. 0197-4
SEWAGE SYSTEM VALVES REPLACE........................................................................................... WP 0198
Figure 1. Flanged Scupper Gag Valve........................................................................................ 0198-3
SEWAGE SYSTEM VALVES REPAIR.............................................................................................. WP 0199
Figure 1. Ball Valve...................................................................................................................... 0199-3
SEWAGE DISCHARGE PUMP REPAIR........................................................................................... WP 0200
Figure 1. Sewage Discharge Pump............................................................................................. 0200-2
SEWAGE DISCHARGE PUMP, PUMP END REPLACE................................................................... WP 0201
Figure 1. Sewage Discharge Pump............................................................................................. 0201-3
Figure 2. Sewage Discharge Pump............................................................................................. 0201-4
SEWAGE DISCHARGE PUMP, PUMP END REPAIR...................................................................... WP 0202
Figure 1. Sewage Discharge Pump Assembly............................................................................ 0202-3
Figure 2. Impeller......................................................................................................................... 0202-4
Figure 3. Bearing Positioning....................................................................................................... 0202-7
Figure 4. Tightening the Impeller................................................................................................. 0202-8
Table 1. Impeller Clearance Settings........................................................................................... 0202-9
SEWAGE DISCHARGE PUMP ELECTRIC MOTOR REPLACE....................................................... WP 0203
Figure 1. Electrical Junction Box................................................................................................. 0203-2
Figure 2. Electric Motor................................................................................................................ 0203-3
TM 55-1925-273-24&P-2
xviii0 3/1 5/2 01 1R el(1 .8 )ro ot(c o nte nts )w pn o(F 00 005 )
7/30/2019 082853
35/1045
TABLE OF CONTENTS - Continued
Page NoWP Sequence No
Figure 3. Alignment of Pump Coupling Flange and Motor Coupling Flange................................ 0203-4
SEWAGE DISCHARGE PUMP ELECTRONIC MOTOR REPAIR..................................................... WP 0204
Figure 1. Sewage Discharge Pump Electric Motor...................................................................... 0204-3
OILY BILGE SYSTEM PIPING STRAINER SERVICE...................................................................... WP 0205
Figure 1. Duplex Strainer............................................................................................................. 0205-3
OILY BILGE SYSTEM VALVES REPLACE....................................................................................... WP 0206
Figure 1. Flanged Angle Valve.................................................................................................... 0206-3
Figure 2. Flanged Globe Valve.................................................................................................... 0206-5
Figure 3. Threaded Valve (Typical)............................................................................................. 0206-6
OILY BILGE SYSTEM, OILY PUMP REPLACE................................................................................ WP 0207
Figure 1. Oily Bilge Pump............................................................................................................ 0207-3
OILY BILGE SYSTEM OILY BILGE PUMP REPAIR......................................................................... WP 0208
Figure 1. Alignment Marks........................................................................................................... 0208-2
Figure 2. Oily Bilge Pump............................................................................................................ 0208-4
Figure 3. Oily Bilge Pump............................................................................................................ 0208-6
BALLAST SYSTEM PIPING/STRAINER SERVICE.......................................................................... WP 0209
Figure 1. Duplex Strainer............................................................................................................. 0209-3
BALLAST SYSTEM VALVES REPLACE........................................................................................... WP 0210
Figure 1. Threaded Vertical Check Valve (Typical)..................................................................... 0210-2
Figure 2. Flanged Angle/Stop Check Valve................................................................................. 0210-3
Figure 3. Flanged Globe/Gate Valve........................................................................................... 0210-5
BALLAST SYSTEM VALVES REPAIR.............................................................................................. WP 0211
Figure 1. Threaded Ball Valve..................................................................................................... 0211-3
Figure 2. Flanged Stop Check Valve..........................................................................................