Upload
nguyennhu
View
217
Download
1
Embed Size (px)
Citation preview
gšfiy¡fHf òÂa f©L¥Ão¥òfŸ k‰W« fUékakh¡fš ika«
gšfiy¡fHf MuhŒ¢Á g©iz
fhšeil c‰g¤Â¡ fšé ika«
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
br‹id - 600 051
2016
g©izahs®fS¡fhd
òÂa bjhêšE£g§fŸ
m¿Kf« k‰W« btëpL
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
Kidt® R. Âyf®
Jizntªj®
khjtu« ghšg©iz tshf«
br‹id - 600 051
mâªJiu``RH‹W«V®¥ ËdJ cyf« mjdhš
cHªJ« cHnt jiy”
vD« th‹òfœ tŸStç‹ th¡»‰»d§f cy»š Kj‹ikahd bjhêš
cHΤbjhêny MF«. cHΤbjhêY¡F mL¤jgoahf fhšeil bjhêš ÁwªJ
és§F»wJ.
cHΤ bjhêY« fhšeil ts®¥ò« ntsh© k¡fë‹ ÏU f©fshf
és§F»wJ. fhšeil bjhêèš fwit khL ts®¥ò, btŸshL ts®¥ò, br«k¿ahL
ts®¥ò, g‹¿ ts®¥ò k‰W« nfhê ts®¥ò Kjèa bjhêšfŸ K¡»a¤ bjhêyhF«.
ϪÂahé‹ K£il c‰g¤Âæš jäHf« Kjèl¤ÂY«, ghš c‰g¤Âæš 10tJ Ïl¤ÂY«,
Ïiw¢Á c‰g¤Â 6tJ Ïl¤ÂY« cŸsJ. nkY«, fhšeilfë‹ c‰g¤Â Âwid
nk«gL¤j jäHf muR gšntW ey¤Â£l§fis brašgL¤Â tU»wJ. éiyæšyh
fwit khLfŸ k‰W« MLfis tH§» g©izahs®fë‹ thœthju¤ij ca®¤j
jäHf muR Kid¥òl‹ brašg£L tU»wJ. nkY«, ts®ªJ tU« k¡fŸ bjhif¡F
V‰gΫ, òuj¤njitia ó®¤Â brŒaΫ, Ïyhg« jU« Ïiw¢Á nfhê k‰W«
eh£L¡nfhê ts®¥ò Kjèa nfhêts®¥ò bjhêšfS¡F khåa« më¤J ÁW k‰W«
FW étrhæfis C¡f¥gL¤ÂtU»wJ. jäHf muÁ‹ ey¤Â£l§fS¡F, jäœehL
fhšeil kU¤Jt m¿éaš gšfiy¡fHf« gšntW bjhêšE£g cjéfisÍ« k‰W«
MnyhridfisÍ« g©izahs®fS¡F tH§» tU»wJ. Ï¥gšfiy¡fH¤Â‹
fhšeil c‰g¤Â fšé ika Ïa¡ff¤Â‹ gšfiy¡fHf MuhŒ¢Á¥ g©izæš
Ïa§»tU« gšfiy¡fHf¥ òÂa f©LÃo¥òfŸ k‰W« fUékakh¡fš ika¤Âš
g©izahs®fS¡F¤ njitahd cgfuz§fis Fiwªj éiyæš eÅd¤
bjhêšE£g¤Jl‹ cUth¡»tU»wJ.
ntsh© g©iz cgfuz§fŸ, gRªÔtd§fë‹ c‰g¤Âia mÂf¥gL¤j
efU« ghrd¥ g‹Kf Ú®¤ bjë¥gh‹, efU« g‹Kid Ú®¤bjë¥gh‹, j©Ù®
k‰W« Ôtd¤ bjh£ofŸ, fhšeilfis vëjhf milahs« fhz cjΫ fUéfŸ,
Fëiu¤ jL¡f¡Toa F뮤 jL¥gh‹, elkhL« kU¤Jt t©o, g‹Kf¥
ga‹gh£L ÏUr¡fu¥ g©iz t©o, bt©g‹¿fS¡fhd g¢iræL« rhjd«,
Ã.é.Á-Mš Md Fiwªj éiy gy mL¡F¡ T©L, fhšeilfS¡fhd Fë®rhjd
ä‹éÁ¿, Fiwªj éiy cy®Ôtd« eW¡F« rhjd« k‰W« bfh£oš Kiwæš
ML ts®¥ò Kjèa òÂa bjhêšE£g§fŸ g©izahs®fë‹ ntiy¥gSit
Fiw¤J fhšeilfë‹ c‰g¤Â Âwid mÂf¥gL¤ÂL« v‹gš v›éj IaK«
Ïšiy. gšfiy¡fHf¥ òÂa f©LÃo¥òfŸ k‰W« fUékakh¡fš ika¤Âš
Ϥjifa cgfuz§fis g©izahs®fS¡fhf ga‹gL« tifæš mikªJŸsJ
m¿ªJ ä¡f k»œ¢Áail»nw‹. Ï¥òÂa bjhêš E£g§fis cUth¡»a mid¤J
tšYe®fS¡F« vdJ kdkh®ªj e‹¿.
11.01.2016 (R. Âyf®)
br‹id Jizntªj®
bghUsl¡f«t.v© bjhêšE£g« g¡f«
fhšeil¥ g©izfS¡fhd rhjd§fŸ, cgfuz§fŸ k‰W« bjhêšE£g§fŸ
1. MLfS¡fhd efU« c©âfŸ Ú¡f Fëaš bjh£o 1
2. efU« ghrd¥ g‹Kf Ú®¤bjë¥gh‹ 3
3. KašfS¡fhd jhåa§» j©Ù®¤ bjh£o 5
4. btŸshLfS¡fhd ku¤Âdhyhd Ôtd¤ j£L 7
5. rhz tu£o rhjd« 9
6. elkhL« kU¤Jt t©o 11
7. efU« g‹Kid Ú®¤bjë¥gh‹ 13
8. g‹¿fS¡fhd bt¥g_£L« fUéÍl‹ Toa Ãu¤Ânaf F£o <D«
bfh£oš
15
9. ghèÍnu¤nj‹ Kaš T©L 17
10. Ãwªj M£L¡ F£ofS¡fhd Fë®jL¥gh‹ rhjd« 19
11. g‹Kf¥ ga‹gh£L ÏUr¡fu¥ g©iz t©o 21
12. bt©g‹¿fS¡fhd g¢iræL« rhjd« 23
13. PVCMš Md Fiwªj éiy gymL¡F Kaš T©L 25
14. fhšeilfS¡fhd Fë®rhjd ä‹éÁ¿ 27
15. Fiwªj éiy cy®Ôtd« eW¡F« rhjd« 29
16. btŸshL ts®¥ò¡ bfh£oš 31
17. f‹W¡ F£o¡fS¡fhd bfh£lif 37
18. g‹¿¡ F£ofë‹ ey‹ fh¡F« rhjd« 39
19. g‹¿fis tê el¤J« rhjd« 41
20. M£L¡ F£ofS¡F ghš òf£l cgfuz« 43
21. M£L¡F£ofS¡fhd ghšò£o 45
22. g‹¿fS¡fhd cUis tot jhåa§» j©Ù® bjh£o 47
23. g‹¿¡ F£ofS¡fhd Fiwªj éiy Ôtd bjh£o 49
24. g‹Kf ga‹gh£L M£L¡ »£o 51
25. MLfis¤ ö¡F« iA£uhè¡ ÏaªÂu« 53
26. Fiwªj éiy iA£nuhnghå¡ gRik¡Foš 55
nfhê¥ g©izfS¡fhd rhjd§fŸ, cgfuz§fŸ k‰W« bjhêšE£g§fŸ
27. Ïs§FŠRfŸ mil¡fh¥gh‹ 59
28. M tot Fiwªj éiy nfhê¡ T©L 61
29. òw¡fil nfhê¡ bfh£lif 63
30. Cuf efU« nfhê¡ T©L 65
31. vëa K£il¡ fU nrhÂ¥gh‹ 67
32. nfhêfS¡fhd Á¿a FoÚ® bfhÂfy‹ j£L 69
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
1g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� 9 mo Ús«, 3 mo mfy«, 3 mo cau« bfh©l, 80 »nyh vilÍl‹
Rkh® 800 è£l® j©Ù® Ão¡F«. c©â, bjŸSó¢Á ngh‹w òw
x£L©âfis mê¥gj‰fhf, òÂajhf totik¡f¥g£l efU«
kUªJ¡ Fëaš bjh£o ÏJthF« .
� Ϫj efU« bjh£oia M£L¡ bfh£lif mU»š ãW¤Â MLfS¡F
c©â Ú¡f« brŒayh«.
� Á¿a k‰W« bgça M£L¥ g©izahs®fS¡F äfΫ gaDilaJ.
� xU neu¤Â‰F X® ML v‹w é»j¤Âš 50 ML Kjš 500 ML tiu
c©â Ú¡f« brŒayh«.
� kUªJ fy¡f¤ njit¥gL« j©Ùiu äf vëjhf ãu¥òtj‰F«,
btëna‰Wtj‰F« VJthf mik¡f¥g£LŸsJ.
� kUªJ¡ Fëaš KoªjÎl‹ bjh£oia¢ R¤j« brŒtJ« vëJ.
� X® ML Rkh® 30 beho kUªJ¤ bjh£oæš ÏUªjhš nghJkhdJ.
� éiy %.19,200/-
TANUVAS – URF - MLfS¡fhd efU«
c©âfŸ Ú¡f Fëaš bjh£o
UIIC 001
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
2
� TANUVAS – URF - Movable dipping tank for small ruminants is designed to reduce the cost of erection of conventional dipping tank to a considerable extent.
� The dipping tank is 9 feet length, 3 feet width and 3 feet height and weighs 80 kg and capacity is 800 litres of water.
� The tank is movable and hence can be wheeled to animal shed and thereby reducing labour and stress to animals.
� The dipping solution after dipping can be drained and sprayed in the animal sheds.
� Cost effective and user friendly for small, medium and large farmers. � Since the movable dipping tank is fabricated using light weight
materials and cost is less when compared to construction of conventional dipping tanks.
� The movable dipping tank is self contained in the towing configuration and is equipped with new rims and tires.
� It can be fixed in any convenient location. � Up to 500 goats can be dipped one by one at a time. � Price Rs.19,200/-
TANUVAS – URF- Movable Dipping Tank for Small Ruminants
Innovators : Dr. T. Muthuramaligam and Dr. P. Tensingh Gnanaraj
UIIC 001
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
3g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� gæ®fS¡F¥ ghrd tr brŒa¥ gy Ú®¤ bjë¥gh‹fis¡ bfh©l,
gwitæ‹ Ïw¡if ngh‹w mik¥òila, efU« ghrd¥ g‹Kf
Ú®¤bjë¥ghdhf totik¡f¥g£LŸsJ.
� gæ®fS¡F¡F«, gRªÔtd§fS¡F« ghrd tr brŒa 16 Ú®¤
bjë¥gh‹fŸ bfh©lJ.
� jiu k£l¤Âš Ú®¤ bjë¥gh‹ efu VJthf ghij totik¡f¥g£LŸsJ.
� 90 mo mfy¤Âš, jiuæèUªJ 6 mo cau¤Âš 4 mo¡F t£l toéš
Ú® ghŒ¢Á¤ bjë¡f¡Toa 16 bjë¥gh‹fis¡ bfh©LŸsJ.
� Ϫj Ú®¤ bjë¥gh‹ xU ãäl¤Âš x›bthU bjë¥gh‹fëèUªJ
Rkh® 13 è£l® Úiu¤ bjë¡F«. bkh¤j« 208 è£l® j©Ùiu
bjë¤J Rkh® 30 ãäl¤Âš xU V¡f® ãy¤Â‰F¥ ghrd« brŒÍ«
tifæš totik¡f¥g£LŸsJ.
� ghrd¤Â‰F njitahd j©Ù®, ä‹rhu«, ntiyah£fŸ k‰W« neu«
M»at‰iw¡ fåfkhf¡ Fiw¡»‹wJ.
� g©izahs®fS¡F mt®j« ãy§fS¡F¥ ghrd tr g©Qtj‰F
VJthf ÏU¡F«.
� Ϫj Ú®¤ bjë¥ghid vëš, Rygkhf cgnah»¡fyh«.
� éiy %.1,17,000/-
TANUVAS – URF - efU« ghrd¥ g‹Kf Ú®¤bjë¥gh‹
UIIC 002
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
4
� The movable sprinkler system is designed like wing shape with multiple sprinklers for effective irrigation of agricultural crops.
� This sprinklers system rotates on a vertical axis and sprinkles water over a circular area.
� It is 6 feet high and 90 feet width with 12 sprinklers.
� Each sprinkler covers about 4 feet diameter area and sprinkles 13 litres of water per minute.
� It irrigates 30 cents of land in 10 minutes i.e. an acre in 30 minutes with about 4700 litres of water.
� Save water, electricity, labour and time.
� Suitable for farmers who has long stretch of cultivable land with a minimum of 120 feet width.
� It is a simple and efficient tool to irrigate fodder field.
� Price Rs.1,17,000/-
TANUVAS – URF- Movable Multiple Sprinkler System
Innovators : Dr. P. Tensingh Gnanaraj and Dr. T. Muthuramaligam
UIIC 002
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
5g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� gšfiy¡fHf MuhŒ¢Á¥ g©izæš òÂajhf totik¡f¥g£l
mYäåa¤jyhd jhåa§» j©Ù®¤ bjh£o, KašfS¡F 24 kâ
neuK« R¤jkhd FoÚ® më¡F«.
� vëš »il¡f¡Toa bghU£fis¡ bfh©L totik¡f¥g£lJ.
� Rkh® K¡fhš mo Ús«, miu mo gu¥gsÎ bfh©l FoÚ®¥ gFÂiaÍ«
k‰W« fhš mo¡F, fhš mo mfy¥ gu¥gsÎ bfh©l FoÚ® gh£oš
bghU¤J« mik¥igÍ« bfh©lJ.
� Fiwªj Ïltr k£Lnk njit¥gL«.
� j©Ù® ÅzhtJ jL¡f¥gL«.
� vªneuK« R¤jkhd Ú® KašfS¡F¡ »il¡F«.
� kUªJ k‰W« lhå¡ ngh‹wt‰iw¤ j©Ùçš fyªJ bfhL¡fyh«.
� éiy %.400/-
TANUVAS – URF - KašfS¡fhd jhåa§»
j©Ù®¤ bjh£o
UIIC 003
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
6
� Designed to provide easy and comfort to rabbit for drinking water.
� Thick aluminum material - 10cm long and 6cm diameter in drinking side and 3cm long and 3cm diameter in another side to attach water bottle.
� Minimize wastage of water.
� Reduces space required for providing water.
� Ensure hygienic availability of water at any given point of the time.
� Vitamin supplements / medications shall be mixed with water and easily administered.
� Price Rs. 400/-
TANUVAS – URF- Automatic Waterer for Rabbit
Innovators : Dr. P. Tensingh Gnanaraj, Dr.T.R. Pugazhenthi and P. Pothiappan
UIIC 003
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
7g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� gšfiy¡fHf MuhŒ¢Á¥ g©izæš cUth¡f¥g£l MLfS¡fhd
Ôtd¤j£L, gRªÔtd§fŸ éiuakhtij¤ jL¥gnjhL k£Lä‹¿
MLfŸ Ôtd« c£bfhŸS« Fzeyid btë¥gL¤j cjλ‹wJ.
� Fiwªj éiy.
� v§F« »il¡f¡Toa ku¥gyifahš cUth¡f¥g£lJ.
� njitahd Ïl¤Â‰F Rygkhf kh‰¿ it¡fyh«.
� gRªÔtd§fŸ éiuakhtJ jL¡f¥gL»wJ.
� MLfë‹ rhz« k‰W« ÁWÚuhš gRªÔtd§fŸ mR¤j¥gLtJ
K‰¿Y« jL¡f¥gL»wJ.
� MLfŸ brsfçakhf gRªÔtd§fis c£bfhŸS«.
� 8 MLfS¡F xU Ôtd¢ r£l« nghJkhdjhF«.
� MLfŸ M®tKl‹ mÂf Ôtd« c£bfh©LéLtjhš mÂf
vilÍl‹ ts®»‹wJ.
� Fiwªj éiyæš »il¡f¡ToaJ k£Lä‹¿ ML ts®¥nghuhš
vëš V‰W¡bfhŸs¡Toa tifæš ÏU¥gjhš mid¤J M£L¥
g©izahs®fS¡F« V‰wJ.
� éiy %.6,000/-
TANUVAS – URF - btŸshLfS¡fhd
ku¤Âdhyhd Ôtd¤j£L
UIIC 004
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
8
� Low cost wooden feeding rack for goats reared under intensive system of rearing to maintain their browsing nature (habitat).
� Easily to carry and transport and prevents wastage of fodder.
� Prevent soiling of fodder with dung and urine.
� Increases the feed intake level among goats.
� One rack is sufficient to feed 8 goats.
� Ideal for intensive system of goat rearing.
� Price Rs.6,000/-
TANUVAS – URF- Low Cost Feeding Rack for Goats
Innovators : Dr. P. Tensingh Gnanaraj and Dr. T. Muthuramaligam
UIIC 004
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
9g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� g©izfëš »il¡F« kh£L¢ rhz« k‰W« it¡nfhš cŸë£l
éuakhd gRªÔtd§fŸ M»at‰iw vçbghUshf¥ ga‹gl¢
brŒÍ« tifæš totik¡f¥g£l rhz tu£o rhjd« ÏJthF«.
� ÏJ cUis tot¤Âš Rkh® x‹wiu mo ÚsK«, fhš mo é£lK«
bfh©lJ.
� ÅzhF«, F¥igæš nghL« cy® Ôtd§fis¢ rhz¤njhL
nr®¤J Ϫj vëa rhjd¤Âš mil¤J mG¤J«nghJ rhz tu£o
»il¡»‹wJ. Ëd® mjid btæèš cy®¤Â vçbghUshf
cgnah»¡fyh«.
� Ï›tu£oia vç¡F«nghJ òif Fiwthf ÏU¡F«. nkY«
vçbghUë‹ M‰wš mÂfkhfΫ ÏU¡F«.
� mL¥Ãš it¤J vç¥gj‰F VJthf ÏJ cUis toéš ÏU¥gJ
Ïj‹ Áw¥g«rkhF«.
� éiy %.850/-
TANUVAS – URF - rhz tu£o rhjd«
UIIC 005
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
10
� Designed to convert the farm wastes like dung, left over fodder and paddy straw into solid fuel.
� It is made up of a metallic cylindrical body of 1.3 feet long and 3 inch diameter and a pressing tool.
� Cow dung and farm wastes have to be filled in the cylinder and pressed to make it into a cylindrical form.
� The pressed dung etc. can be dried and used as a fuel.
� This type of dried cylindrical dung forms burn with less smoke and burn for a longer time, thus conserving energy.
� Price Rs.850/-
TANUVAS – URF - Cow Dung Lounge
Innovators : Dr. P. Tensingh Gnanaraj and Dr. T. Devi
UIIC 005
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
11g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� ML, f‹W, Kaš, g‹¿¡F£ofŸ, nfhê ngh‹witfëš kU¤Jt¢
Á»¡ir nk‰bfhŸs bfh£lif¡FŸns vL¤J¢ br‹W Á»¢ir brŒa
cjΫ tifæš totik¡f¥g£l kU¤Jt t©o ÏJthF«.
� cWÂahfΫ, ÏyFthfΫ, efU« tifæY« ÏJ totik¡f¥g£LŸsJ.
� CÁ, kUªJfŸ, lhå¡FfŸ ngh‹w bghUŸfŸ it¡f¤ jå¤jå
ÏU«ò k‰W« Ãsh°o¡fhyhd mykhçfS« Ïš cŸsJ.
� E© miy (Ultrasound) neh¡», E©nzh¡» ngh‹wt‰iw¡
bfh©LbršY« tifæY«, mt‰iw Ïa¡f ä‹rhu Ïiz¥ò«
bfh©L totik¡f¥g£LŸsJ.
� M¡ì#‹ Áè©l®, Âut ie£u#‹ Áè©l® M»at‰iw¡
bfh©LbršY« tifæY« totik¡f¥g£LŸsJ.
� cgnahf¥gL¤Âa CÁfŸ, fhèahd kUªJ gh£ošfŸ, ga‹gL¤j¥g£l
gŠR, JâfŸ ngh‹wt‰iw¢ nrfç¡f F¥ig¤ bjh£oÍ« Ïš cŸsJ.
� fhšeilfS¡F vëš Á»¢ir më¡f¡Toa tifæY« fhšeil
kU¤Jt®fS¡F«, fhšeilfS¡F« brsfçakhf mikÍ« tifæš
brŒa¥g£LŸsJ.
� éiy %.12,000/-
TANUVAS – URF - elkhL« kU¤Jt t©o
UIIC 006
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
12
� Movable Multifunction Veterinary wheel cart made up aluminum and steel.
• Features of the device:• Pull out trays or side plastic trays that provide additional
space for staff to work.• Oxygen cylinder holder• LN2 container holder• Height adjustable pole with utility hooks• Wash basin holder• Plastic trays • Adjustable ball-bearing, extension drawer.• Power points for connecting equipments for diagnostics e.g.
Ultrasound machine.• The top platform is for animal.
� It is a simple and efficient device for health care activity. � Comfortable for animals as well as doctors. � Price Rs. 12,000/-
TANUVAS – URF - Portable Multipurpose Medicine Wheel Cart
Innovators : P. Pothiappan, Dr. T. Muthuramalingam and Dr. T. Devi
UIIC 006
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
13g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� Fiwªj ãy¤ÂèUªJ Mu«Ã¤J äf mÂf¥ goahd gu¥gséY« ghrd
trÂia¡ bfhL¡f¡Toa Ú®¤bjë¥gh‹ ÏJthF«.
� äf vëjhd mik¥ig¡ bfh©lJ
� xU ãäl¤Â‰F Rkh® 50 è£l® Úiu¤ bjë¡F«
� 20 ãäl¤Âš 10 g‹Kid Ú®¤ bjë¥gh‹fis¡ bfh©L 1 V¡f®
ãy¤Â‰F¥ ghrd tr bfhL¡fyh«.
� 1-2 Ú®¤ bjë¥ghD¡F 1 v¢.à ڮ_œ» nkh£lh® njit¥gL«.
� 3-20 Ú®¤ bjë¥gh‹fis Ïa¡f 3 v¢.à Kjš 10 v¢.à M‰wš bfh©l
nkh£lh® njit¥gL«.
� xU Ïl¤ÂèUªJ k‰bwhU Ïl¤Â‰F Ïjid äf vëjhf kh‰¿
mik¡fyh«.
� Ïjid cgnah»¥gjhš rhjuz ghrd¤Â‰F njit¥gL« j©Ùçš
g¤Âš xU msit njit. neu« FiwÎ.
� g‹Kid Ú®¤ bjë¥gh‹ éiy - %.1,800/-
� r¡fu¤Jl‹ Toa g‹Kid Ú®¤ bjë¥ghå‹ éiy - %.2,700/-
TANUVAS – URF - efU« g‹Kid Ú®¤bjë¥gh‹
UIIC 007
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
14
� Designed to irrigate lands of varying sizes from few cents to many hectares. � It consists of four rain gun attached to pipeline which is further mounted on
a movable trolley. � Can be easily moved from one place to another. � The height of the rain gun can be adjusted according to the height of the
crop. � Water emitted by each rain gun is 12.5 liters/minute i.e. 50 liters/ movable
multiple rain gun / minute. � One submersible motor (1 HP) is enough to run four rain gun and one 3 -10
HP motor is needed to run 3-20 movable multiple rain gun. � Each rain gun emits 12.5 liters of water/ minute and the total quantity of
water in 50 liters/minute � One rain gun will irrigate 3.5 cents of land /5 minutes. i.e. 10 trolleys
irrigates1 acres of land in 30 minutes. � This technology is highly useful for small, marginal and large scale livestock
farmers especially l for backyard fodder cultivation � Save water, electricity, time and labour. � It is a simple and efficient tool to irrigate agriculture field. � It can be purchased from University Research Farm, TANUVAS by placing
order. � Cost of one movable multiple rain gun without trolley is Rs.1800/- and with
trolley is Rs.2,700/-
TANUVAS – URF - Movable Multiple Rain Gun
Innovators : Dr. T. Muthuramalingam, Dr. P. Tensingh Gnanaraj and P. Pothiappan
UIIC 007
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
15g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� g‹¿ F£o <D« bfh£oyhdJ g‹¿¡ F£ofŸ elkhl¤ njitahd
ÏltrÂia¡ bfh©L x›bthU bfh£oèY« jå¤jåahf¤ j©Ù®
k‰W« Ôtd¤bjh£o bghU¤j¥g£LŸsJ.
� bghJthf¤ jhŒ g‹¿fS¡F Rkh® 275 »nyh clš vil ÏU¡F«. nkY«
mt‰¿‹ fhšfë‹ cau« clY¡F V‰wjhf Ïšyhkš r‰W Á¿ajhf
ÏU¥gjhš gL¡F«nghJ bkJthf Kiwahf¥ g‹¿fshš gL¡f Koahkš
nghF«. Ï¢Nœãiyna jhŒ gL¡F«nghJ mj‹ F£ofŸ eR§»¢ rhF«
ãiyia V‰gL¤J»‹wJ.
� Ãu¤Ânaf bfh£oš 6 mo ÚsK«, 7 mo mfyK« bfh©ljhfΫ, bfh£oè‹
nk‰òw mfyK«, mo¥òw mfyK« Rkh® Ïu©L moÍ«, cau« _‹wiu
moÍ« bfh©ljhfΫ mik¡f¥g£lJ. bfh£oš jiuæèUªJ xU moÍ«
cau¤ÂY«, RtçèUªJ xU mo Ïilbtë é£L« bghU¤j¥g£LŸsJ.
� jiu¥gFÂæèUªJ bfh£oè‹ mo¥gFÂ xU mo Ïilbtë ÏU¥gjhš
jhŒ g‹¿ gL¡F«nghJ g‹¿¡ F£ofŸ btëna Xo éL»‹wd. Ïjdhš
g‹¿¡ F£ofŸ eR§» Ïw¥gJ K‰¿Y« jL¡f¥gL»‹wJ.
� F£o <Dtj‰F xU thu¤Â‰F K‹ng bg£il¥ g‹¿fis bfh£oY¡F¡
bfh©L tu nt©L«. K‹d® bfh£oiy¢ R¤jkhd j©Ùçš
bgh£lhÁa« bg®kh§fnd£ fyªJ jiuia¢ R¤j¥gL¤j nt©L«.
� Ϫj bfh£oè‹ cgnahf¤jhš br‹w tUl§fëš Ïªj MuhŒ¢Á¥
g©izæš <‹w Ë xU F£oÍ« eR§» Ïw¡féšiy.
� éiy %.28,000/-
TANUVAS – URF - g‹¿fS¡fhd bt¥g_£L« fUéÍl‹
Toa Ãu¤Ânaf F£o <D« bfh£oš
UIIC 008
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
16
� Specially designed to reduce mortality in newborn piglets. � It is made of poly vinyl slatted floor � Advantages: � Instant draining of urine and faeces to the ground.
• Soling of sow and piglet is prevented.• Maintenance of very good hygiene preventing mortality due to
diarrhea in piglets.• Reduction of bacterial load especially E.coli.• Healthy accelerated growth in piglets.• The crate is dry and free from dampness.
� Slatted floor is elevated from the floor level which facilitates very little or no contact of piglets with urine and faeces.
� The crate is 6 ft long and 7 ft wide. The width of the rail is 22 inches at the top and 25 inches at the bottom. The distance of the crate from ground level and from the side wall is about 1 foot.
� It is provided with creep area for piglets to escape from crushing by the mother.
� Heater and lamp is provided for warmth and light piglets during night and winter.
� Semi automatic feeder and waterer is provided. � The nearing parturient gilt/sow should be placed inside the crate before a
week farrowing after disinfection with 0.2% KMnO4 solution. � Very useful for commercial farms to reduce mortality in piglets and to sell
more piglets. � Price Rs. 28,000/-
TANUVAS – URF - Piglet comfort crate
Innovators : Dr. P. Tensingh Gnanaraj and Dr. T. Muthuramalingam
UIIC 008
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
17g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� ghèÍnu¤nj‹ (Ãsh°o¡) Kaš T©lhdJ 2 mo Ús«, 2 mo mfy¥
gu¥gsÎ bfh©l KašfŸ guhkç¥ò¥ gFÂiaÍ«, x‹wiu mo Ús«,
1 mo mfy¥ gu¥gsÎ bfh©l F£o <D« gFÂiaÍ« bfh©lJ.
� KGtJ« PVC Mš Ëd¥g£l Ãokhd§fshš MdJ.
� Ãsh°o¡ jiuahf ÏU¥gjhš äf vëjhf¢ R¤j« brŒayh«. nkY«
rhz¡fiu goahkš ÏU¥gjhš, gh¡Oçah, itu° ngh‹wt‰whš
V‰gL« tæ‰W¥ngh¡F k‰W« Óœ¡ f£o M»a nehŒfŸ V‰glhkš
Rfhjhukhf Kašfis¥ guhkç¡fyh«.
� MuhŒ¢Áæš Ãsh°o¡ jiuæš nehŒ jh¡f« äfäf¡ Fiwthf
ÏUªjJ.
� vªneuK« R¤jkhf, cy®ªj ãiyæš T©Lfis¥ guhkç¡f VJthf
cŸsJ.
� vëš »il¡f¡Toa bghUŸfshš totik¡f¥g£lJ.
� MuhŒ¢Á¥ g©izæš Ïªj T©oš Kašfis ts®¤jjhš br‹w
tUl§fëš F£ofŸ Ïw¥ò fårkhf FiwªjJ. clš vil Rkh® 15
rjéj« TLjyhf »il¤jJ. Kašfëš nehŒ¤ jh¡f« fårkhf
FiwªjJ.
� éiy %. 4,200/-
TANUVAS – URF - ghèÍnu¤nj‹ Kaš T©L
UIIC 009
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
18
� Polyurethane slatted floor cage fabricated, tested and found to be ideal for rabbit.
� This slatted floor drains the urine and faeces of the rabbit to the ground.
� This slatted floor is 3 1/2 feet above the ground.
� The cage is 2 feet length, 2 feet width and 4.5 feet height.
� Inside 1 foot X 1 foot nest box for kindling is provided.
� The cage is clean which ensures healthy growth for adult and young rabbits.
� Slat floor prevents diarrhea in bunnies and also reduced bacteria especially E. coli.
� The cage unit is easy to clean and wash.
� The cage can be maintained dry and damp free all the time.
� It is observed that bunnies grow comfortably healthy and attains satisfactory body weight with high livability in the cage.
� Price Rs. 4,200/-
TANUVAS – URF - Slatted Floor (polyurethane) cage for Rabbit
Innovators : Dr. P. Tensingh Gnanaraj, Dr. T.R. Pughazenthi Dr. A. Sundaresan
UIIC 009
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
19g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� Nœãiy khWgh£lhš Ãwªj btŸshL k‰W« br«k¿ah£L¡ F£ofëš
Ïw¥ò é»j« mÂfkhf¡ fhz¥gL»wJ. Ï¢rhjd¤Âš cŸs bt¥g«
M£L¡ F£ofis¡ Fë®fhy§fëš V‰gL« FëçèUªJ ghJfh¤J clš
bt¥gãiyia¢ rkãiy¥gL¤Â¡ F£ofëš V‰gL« Ïw¥ig Fiw¡»‹wJ.
� ϧF Ãu¤Ânafkhf totik¡f¥g£l rhjdkhdJ Ãwªj M£L¡
F£ofS¡fhd, brsfçakhd Nœãiyia V‰gL¤Â¡ bfhL¡»‹wJ.
� F£ofŸ fê¡F« rhz« k‰W« ÁWÚ® ÑnH jiuæš clnd éGªJéLtjhš
T©lhdJ vªneuK« R¤jkhf ÏU¡F«.
� M£L¡F£ofS¡F Fëçdhš V‰gL« mH‰Áia jL¤J V‰w brsfçakhd
Nœãiyia jªJ Mnuh¡»akhf tsu cjλ‹wJ.
� Ïš ts®¥gjhš Ãwªj M£L¡F£ofëš Ïiw¥ig¡ fåfrkhf¡
Fiw¡»‹wJ.
� Rkh® 8 M£L¡ F£ofS¡F xU rhjd« nghJkhdJ.
� cgnah»¡f vëjhfΫ, éiy Fiwthf ÏU¥gjhš, Ãwªj M£L¡
F£ofë‹ Ïw¥ig fårkhf Fiw¥gjhš, M£L¥ g©izahs®fshš
vëš V‰W¡bfhŸs¡Toa tifæš mikªJŸsJ. M£L¥
g©izahs®fS¡F« ÏJ njit¥gL« x‹whF«. Ϫj MuhŒ¢Á¥
g©izæš Ïš Ãwªj F£ofis ts®¤jjhš, F£ofë‹ Ïw¥ò fårkhf
mjhtJ 80 rjéj« FiwªjJ. F£ofŸ Mnuh¡»akhf ts®ªjJ.
� éiy %.12,500/-
TANUVAS – URF - Ãwªj M£L¡ F£ofS¡fhd
Fë®jL¥gh‹ rhjd«
UIIC 010
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
20
� The nest box is designed to provide ideal warmth and clean environment to the newly born lams and kids especially in winter.
� The wooden slatted floor in the nest box quickly drains the urine and dung voided by the lambs and kids.
� The nest box is 4 feet length, 3 feet width, 4 feet height at the centre with the curved top.
� The sides and the top is covered with transparent acrylic sheet. � Required ventilation is provided by sufficient holes/windows on the
supporting wooden plank on sides. � This nest box is mounted on a 1 1/2 feet height wooden frame with
a ramp and door. � Filament lamp of V is provided in the nest box. � The nest box of the set dimension is for lambs or kids or lambs
and kids. � It is observed that this nest box has substantially reduced the mortality
in lambs and kids by providing warmth, light, clean and dry slatted floor and also improved body weight gain.
� Will be very useful for sheep and goat farmers and also rural household.
� Price Rs.12,500/-
TANUVAS – URF - Nest Box for New Born Lambs and Kids
Innovators : Dr. P. Tensingh Gnanaraj, Dr. P. Pothiappan and Dr. T. Devi
UIIC 010
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
21g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� g©izfëš Âdrç F¥ig k‰W« fhšeil¡ fêÎfŸ M»at‰iw¢
nrfç¤J¡ F¥ig¡ »l§»š bfh£Ljš Ãuhjd ntiyahF«.
� fhšeilfS¡F¤ njitahd Ôtd§fis¢ nrä¥ò¡ »l§»èUªJ
bfh£lif¡F¡ bfh©LtUjš, bt£oa gRªÔtd§fis¡
bfh©L bršYjš k‰W« gy bghU£fis xU Ïl¤ÂèUªJ
k‰bwhU Ïl¤Â‰F¡ bfh©L bršYjš ngh‹w ntiyfS¡F¥
ga‹gL« tifæš g‹Kf¥ ga‹gh£L ÏUr¡fu¥ g©iz t©o
cUth¡f¥g£LŸsJ.
� Iªnj K¡fhš mo Ús«, Ïu©nl K¡fhš mo mfy« k‰W« cau«
v‹w mséš mik¡f¥g£l Ϫj t©o, 125 è£l® mšyJ 125 »nyh
vil bfh©l bghUŸfis¡ bfh©Lbršy cjt¡ToaJ.
� t©oæèUªJ bghUŸfis V‰WtJ«, Ïw¡FtJ« äf vëaJ.
� äf cWÂahd, vëš Ïa¡f¡Toa totik¥igÍ«, ÏyFthf¢
R‰w¡Toa r¡fu§fisÍ« bfh©lJ.
� k©, j©Ù® Kjš Ôtd¥ bghU£fŸ, fêÎ czÎ¥ bghU£fŸ,
fhšeil¢ rhz« M»at‰iw¢ nrfç¤J vL¤J¢ bršy¥
ga‹gL»wJ.
� éiy %.9,600/-
TANUVAS – URF - g‹Kf¥ ga‹gh£L
ÏUr¡fu¥ g©iz t©o
UIIC 011
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
22
� Made of plastic mounted on a rectangular metal frame of 5.75 feet length and 2.65 feet width and 2.60 feet height with the capacity of 125 litres.
� This unit is movable through a pair of wheels (pneumatic tyres) fixed at the centre for mobility.
� The plastic container could be rotated to 1800 angle to unload the farm waste.
� This wheel barrow is convenient to load the farm waste, transport easily and quick unloading.
� This saves labour, prevents spillage and easy to clean.
� Wheel barrow is light in weight durable and proved to be of great use in farm waste disposal and also transport of goods within the farm.
� Price Rs.9,600/-
TANUVAS – URF - Wheel Barrow for Farm Waste Removal
Innovators : Dr. P. Tensingh Gnanaraj, Dr. D. Balasubramanyam and Dr. T. Muthuramalingam
UIIC 011
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
23g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� bt©g‹¿fS¡fhd g¢iræL« rhjd« _y« bt©g‹¿fS¡F milahs
v©iz mt‰¿‹ clèš g¡fyh«. ÏJ _‹W tUl§fS¡F mêahJ.
� bghJthf¥ bt©g‹¿ia milahs« fhz fhJ klèš bt£L¡ F¿, fhš
milahs¡ F¿æLjš M»ait fil¥Ão¡f¥gL»‹wd. Ï›éu©L
brašfS¡F« mÂf ntiyah£fŸ k‰W« neu« njit.
� vdnt, fhšeil gšfiy¡fHf MuhŒ¢Á¥ g©izæš g£ilahdR¤Âaš
ngh‹w clèš g¢iræL« rhjd« totik¡f¥g£lJ. Ïj‹ _y«
bt©g‹¿æ‹ clèš milahsälyh«. ÏJ äfΫ vëa k‰W« ãuªju
milahsäL« Kiw.
m«r§fŸ tH¡fkhd Kiw òÂa bjhêšE£g Kiw
njit¥gL« ntiyah£fŸ mÂf« FiwÎ
g‹¿ia¡ ifahSjš k‰W«
f£L¥gL¤jš
mtÁa« mtÁaäšiy
Ïu¤j« tojš fhz¥gL« fhz¥gLtšiy
brašKiw¡F cfªj
bt©g‹¿fŸ
Ãwªj F£ofŸ Ãwªj F£o, ts®ªj F£o
k‰W« bgça g‹¿fŸ
milahs« fhQjš g‹¿¡ F£ofis¥
Ão¤J äf mU»š
ÏUªJ milahs«
fhzyh«
äf¤ bjhiyéš ÏUªJ
g‹¿fis¥ Ão¡fhkš
milahs« fhzyh«
� éiy %.5,500/-
TANUVAS – URF - bt©g‹¿fS¡fhd
g¢iræL« rhjd«
UIIC 012
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
24
� Pigs are identified for selection for breeding.
� Pigs are identified by tattooing and ear notching methods which involves restraining the animal which is difficult, time consuming and labour intensive.
� The new tattooing device, the tattoo hammer can be used for tattooing pigs without restraining them.
� The tattoo made by this tattoo hammer can be easily be identified from at a distance without restraini8ng the animal
� Tattooing using this tattoo hammer substantially minimize bleeding.
� This tattoo hammer can be used in animals of all age groups.
� The tattoo mark created by this tattoo hammer can be easily be identified up to 2 years.
� Price Rs.5,500/-
TANUVAS – URF - Tattoo Hammer for Pigs
Innovators : Dr. P. Tensingh Gnanaraj, Dr. T. Muthuramalingam, Dr. S. Rangasamy and Dr. M. Babu
UIIC 012
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
25g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� rªijfëš »il¡fF« Kaš T©LfŸ ÏU«ò tiy k‰W« ÏU«ò¤
jofis¡ bfh©lJ. Ï›éU«ò¡ T©LfŸ fh‰W k‰W« Úçš gL«bghGJ
vëš JU¥Ão¤J, mj‹ bghèit ÏHªJ mo¡fo kh‰W« ãiy¡F
cŸshF»‹wd.
� fhšeil¥ gšfiy¡fHf MuhŒ¢Á¥ g©izæš cUth¡f¥g£l Kaš
T©L ÏU«ò¤ jofS¡F¥ gÂyhf PVC FHhŒfshš MdJ. Ïj‹ _y«
JU¥Ão¤jèèUªJ éLgLtJ k£Lä‹¿¡ T©o‹ vilÍ« Fiw»‹wJ.
� Ï«Kaš T©L 12 ÃçÎfis cŸsl¡»aJ. x›bthU ÃçΫ 3 rJu mo
ÏltrÂia¡ bfh©lJ.
� Kaš g©iz k‰W« ÅLfëš Kaš ts®¥nghU¡F cfªjJ.
� X® Ïl¤ÂèUªJ k‰bwhU Ïl¤Â‰F vëjhf bfh©L bršyyh«.
� KašfŸ brsfçfkhd Nœãiyæš tsU«. éiuéš, vëa Kiwæš
R¤j¥gL¤jyh«.
� rªijfëš »il¡f¡Toa gymL¡F¡ Kaš T©o‹ éiy njhuhakhf
%.22,000/- (%ghŒ ÏUg¤J Ïu©lhæu«) MF«. rªijfëš »il¡F«
T©Lfis él PVCMš cUth¡f¥g£l gymL¡F Kaš T©L éiyæY«,
Kašfë‹ eyåY« nk«g£L ÏU¥gjhš tâfßÂahd Kaš ts®¥Ã‰F ÏJ
äfΫ V‰wJ.
� Ïš ãôÁyhªJ xŒ£, XŒ£ b#a©£ k‰W« nrhéa¤ Á‹Áyh ngh‹w gšntW
tifahd Kašfis ts®¡fyh«.
� éiy %.5,200/-
TANUVAS – URF - PVCMš Md Fiwªj éiy
gymL¡F Kaš T©L
UIIC 013
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
26
� The conventional rabbit cage is made up of metal and prone for rusting.
� The low cost PVC inclined battery cages for rabbit designed in TANUVAS is light and hence can be moved from one place to another.
� One unit of 3 tires each of 3 sq. ft. area is sufficient to rear one adult.
� This cage is made of PVC frame is portable easy to clean and provides comfort to the rabbit.
� Price Rs.5,200/-
TANUVAS – URF - Low Cost PVC Inclined Battery Cages for Rabbit
Innovators : Dr. P. Tensingh Gnanaraj, Dr. A. Sundaresan and Dr. T. Muthuramalingam
UIIC 013
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
27g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� btæš fhy§fëš fwit khLfëš, F¿¥ghf mÂf ghš jU« khLfëš
ghš c‰g¤ÂÍ«, fy¥Ãd¥ gR¡fë‹ Ïd¥bgU¡f¤ j‹ikÍ« btFthf
Fiw»‹wJ. ÏJ btæè‹ mH‰Áahš V‰gL»‹wJ.
� fhšeil¥ gšfiy¡fHf MuhŒ¢Á¥ g©izæš totik¡f¥g£l
fhšeilfS¡fhd Fë® rhjd ä‹éÁ¿ khL k‰W« kh£L¡bfh£lifæš
bt¥gãiyia¡ Fiw¤J F뮢Áahd xU Nœãiyia cUth¡F»‹wJ.
bfh£lifæ‹ btë¥òw¤ij¡ fh£oY«, Ϫj cgnahf¤jhš bfh£lifæ‹
c£òw¤ÂY«, fhšeilfëY« Rkh® 3 Kjš 5 o»ç cZz« Fiw»‹wJ.
� btæš fhy§fëš 20 ãäl¤Â‰F xU Kiw Ïilbtëæš Rkh® IªJ
ãäl§fŸ bjhl®ªJ Fë%£L« ä‹éÁ¿ia Ïa§f¢ brŒa nt©L«.
bghJthf btæš fhy§fëY« mÂf cZz« cŸsnghJ« Ïij
cgnah»¡fyh«.
� bt¥gãiy mÂfç¥ghš khLfëš V‰gL« ÏH¥ò, cäœÚ® bfh£Ljš,
Ôtd Fiwthf c£bfhŸSjš, ghš c‰g¤Â FiwªJnghjš ngh‹w
m¿F¿fëèUªJ éLgLtj‰F cWJizahf ÏU¡»‹wJ.
� khLfS¡F brsfça¤ij më¤J mt‰¿‹ c‰g¤Â k‰W« Ïd¥bgU¡f¤
j‹ikia guhkç¡f cjΫ
� Fiwªj éiyæš cUth¡f¥g£l Ï›tif¡ Fë%£L« ä‹éÁ¿ Á¿a,
eL¤ju k‰W« bgça kh£L¥ g©izahs®fŸ ga‹bgW« tifæY«
totik¡f¥g£LŸsJ.
� éiy %.8,400/-
TANUVAS – URF - fhšeilfS¡fhd
Fë®rhjd ä‹éÁ¿
UIIC 014
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
28
� In summer the productivity is reduced in livestock due to heat stress.
� The misting device for livestock is designed in TANUVAS discharges water into mist and spray it over the animal.
� This device is fit in front of pedestal fan thus the mist is sprayed over 3 – 4 animals by rotation.
� In summer this device can be used for about 5 minutes for every 20 minutes during high temperature.
� The cooling of livestock using this device helps to alleviate the heat stress and helps to overcome anorexia, panting and reduced milk yield.
� For dairy farms it proved to maintain the milk yield by alleviating heat stress on milch animals.
� One misting device can be used for up to 20 milch animals.
� Price Rs.8,400/-
TANUVAS – URF - Misting Device to Cool Livestock
Innovators : Dr. P. Tensingh Gnanaraj, Er. M. Siddharth and Dr. E. Rachel Jemimah
UIIC 014
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
29g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� fhšeilfS¡F cy®Ôtd§fis Rkh® 3 Kjš 4 m§Fy« Ús«
cŸsthW Á¿ajhf eW¡» më¡fnt©L«.
� eW¡fhkš bfhL¡F«nghJ Ôtd« mÂfkhf éuakh»wJ.
fhšeilfŸ éuakhtij M®tKl‹ c©Qtšiy.
� Ï›éaªÂu¤Â‹ _y« cy®Ôtd§fis¢ ÁW ÁW J©Lfshf
bt£o¡ fhšeilfS¡F¡ bfhL¡fyh«.
� 5 mo cau ÏU«ò¤joÍl‹ cy®Ôtd« bt£L« f¤Â Ïiz¡f¥g£L,
äf vëa Kiwæš cy®Ôtd§fis eW¡» më¡fyh«.
� ÁW ÁW J©Lfshf eW¡f¥g£l cy®Ôtd§fis c£bfhŸS«nghJ
fhšeilfë‹ brçkhd r¡Â mÂfç¡»‹wJ. ghš msÎ
mÂfkhF«. Ôtd« ÅzhtJ FiwÍ«. bkh¤j¤Âš tUthŒ bgUF«.
� eW¡»a Ôtd¤ij xU Ãsh°o¡ Tilænyh mšyJ mf‹w
_§»š Tilænyh më¤jhš R¤jkhd Ôtd¤ij fhšeilfŸ
c©z VJthF«.
� éiy %.6,000/-
TANUVAS – URF - Fiwªj éiy cy®Ôtd«
eW¡F« rhjd«
UIIC 015
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
30
� Dry fodder to livestock is usually fed as such.
� Chaffing of dry fodder reduces wastage and encourage animal to consume more.
� This low cost dry fodder cutter designed in TANUVAS, for cutting dry fodder into small pieces of 4 – 5 inches quickly, easily and manually.
� This device is made of metal, measuring 5 feet length attached at the bottom to a long curved fixed knife.
� It will be useful for cattle, sheep, and goat to feed chaffed dry fodder.
� Price Rs 6,000/-
TANUVAS – URF - Low Cost Dry Fodder Cutter
Innovators : Dr. P. Tensingh Gnanaraj, Er. M. Siddharth and Dr. E. Rachel Jemimah
UIIC 015
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
31g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
MLfis¤ Âwªj btëæš élhkš bfh£lif¡FŸnsna
MLfis it¤J¥ guhkç¡F« Kiw MF«. Ï›tif ML ts®¥Ãš
MLfS¡F¤ njitahd gRªjÔtd§fŸ, ml®Ôtd§fŸ k‰W« cy®
Ôtd§fŸ ngh‹wit KGikahf¡ »il¡f¢ brŒa nt©L«.
Ϥjifa ML ts®¥Ãš gRªÔtd«, ml®Ôtd« k‰W«
cy®Ôtd« M»a _‹¿š VnjD« x‹W Ïšyhkny mšyJ KGikahf¡
»il¡f¥ bgwhknyh ÏU¡Fkhæ‹ m¤jifa g©izfëš gy
Ãu¢ridfis v®bfhŸs nt©otU«. cjhuzkhf cy®Ôtd§fŸ
»il¡f¥ bgwéšiy våš MLfë‹ brçkhd¢ r¡Â k‰W«
clšts®¢Á ngh‹wit xG§fhf mika¥bgwhJ. gRªÔtd§fŸ
»il¡f¥bgwéšiybaåš MLfë‹ Ïd¥bgU¡f¤ j‹ikæš
FiwghL V‰gL«.
bfh£lif mik¤jš
MLfS¡F¡ bfh£lif mik¡F«nghJ ÑœtUtdt‰iw¡
fU¤Âš bfhŸs nt©L«.
� MLfS¡F vªjbthU NœãiyæY« mitfë‹ clš eyid¥
gh¡fhj t©z« bfh£lif mika¥bgw nt©L«.
� Fë®fhy§fëš Fëiu¤ jL¥gdthfΫ, btæš fhy§fëš
bt¥g¤Â‹ jh¡f¤ij¡ Fiw¥gdthfΫ mika¥bgw nt©L«.
� MLfë‹ v©â¡if¡F V‰wh‰ ngh‹W x›bthU MLfS¡F«
njitahd jFªj ÏltrÂfnshL mika¥bgw nt©L«.
� b f h £ l i f
m i k ¥ g h d J
v ¡ f h u z «
b f h © L «
Ú ® ã i y f S ¡ F
äf mUfhikæš
ÏU¡f¡ TlhJ.
V b d å š
Ú ® ã i y f s h š
MLfŸ Rthr
n e h Œ f S ¡ F
cŸsh»‹wd.
TANUVAS – URF - btŸshL ts®¥ò¡ bfh£oš
UIIC 016
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
32
� bfh£lifæ‹ Ústh¡F mik¥ghdJ »H¡F-nk‰F¤ Âir neh¡»
ÏU¡f nt©L«. g©iz ÏU¡F« ÏlkhdJ »H¡F-nk‰F neh¡»
mÂfkhf Ïšyhj nghJ«, v¡fhuz§fŸ bfh©L bfh£lifæ‹
Ústh¡F mik¥ig kh‰¿ mik¡f¡ TlhJ.
� bfh£lif mik¡F«nghnj Fë®fhy§fëš V‰gL« FëçèUªJ
MLfis¥ ghJfh¡f mik¡f¥gL« jh®ghè‹, rh¡F¡ig, Jâ
ngh‹witfis f£o¤ bjh§f él¤ njitahd mik¥igÍ«
cUth¡f nt©L«.
bfh£oš Kiw
jiuæèUªJ 3-4 mo cau¤Â‰F ku¥gyifahš gu© mik¡f¥gl
nt©L«. x›bthU ku¥gyif¡F« cŸs Ïilbtë 1/2 m§Fy« (inch)
ÏU¡f nt©L«. Ïjdhš rhz«, k‰W« ÁWÚ® bfh£lif¡FŸ j§fhkš
ÑnH éGªJ éL»‹wd.
gyh, gidku«, bj‹id, _§»š k‰W« ntWVnjD«
ku¥gyiffŸ nghJkhditahF«. ku¥gyifahdJ cWÂahfΫ,
MLfë‹ bkh¤j vilia¤ jh§f¡ ToadthfΫ ÏU¡f nt©L«.
x›bthU ku¥gyifæ‹ mfy« Rkh® 2-2½ m§Fy« ÏU¡f
nt©L«. gyifæ‹ mfy« mÂfç¡F«nghJ rhz« k‰W« ÁWÚ®
ÑnH éHhkš bfh£lif¡FŸns j§» éLtj‰fhf thŒ¥Ãid
mÂf¥gL¤ÂéL«.
ku¥gyif k£lÂèUªJ bfh£lifæ‹ mÂfg£r cau« 10
moahfΫ, Fiwªjg£r cau« 7 moahfΫ mik¡fyh«. bfh£lifæ‹
btë¥òw¥ gF c£gFÂia¥ ngh‹nw ÏU kl§fhf mika¥bgw
nt©L«. bfh£lifia¢ R‰¿ 3½-4 mo cau¤Â‰F¡ f«Ã ntè
mik¡f nt©L«.
M£L¡ bfh£lif v‹gJ c£gF k‰W« btë¥gFÂahf
Ïu©L mik¥ig¡ bfh©ljhf ÏU¡f nt©L«. Mdhš bgU«ghyhd
tâfßÂæš mik¡f¥gL« M£L¡ bfh£liffëš btë¥gFÂ
mik¡f¥gLtnj Ïšiy.
MLfŸ bfh£lifæ‹ btë¥òw¥ gFÂæš RjªÂukhf
elkhLtj‹ _y« njitahd msÎ cl‰gæ‰Á »il¥gnjhL
k£Lä‹¿¥ gÁiaÍ« ö©o éLtjhš Ôtd§fis mÂfkhf
c£bfhŸS«. nkY« njitahd msÎ fh‰nwh£l« »il¥gjhš Rthr
nehŒ tUtj‰fhd thŒ¥òfS« FiwªJ éL»‹wd.
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
33g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
MLfS¡F ¤njitahd ÏltrÂ
M£L¡ F£o : 4 rJu mo
bg£il ML : 10 rJu mo
»lh ML : 20 rJu mo
bfh£lifæ‹ mfy« 16-20 moÍ«, Ús« nt©Lksé‰F«
mik¡fyh«. nkY« bfh£lifia¥ gy gFÂfshf¥ Ãç¡fyh«.
MLfis mj‹ taJ, clš vil, Áid MLfŸ v‹w tiffëš Ãç¤J
x›bthU gFÂfëY« ts®¡fyh«.
»lh MLfis k‰w MLfnshL nr®¡fhkš jåahfnt ts®¡f
nt©L«. ghš bfhL¡F« MLfŸ k‰W« M£L¡F£ofŸ M»at‰iw¤
jåahf ts®¡f nt©L«. Ï›thW ts®¡F«nghJ M£L¡ F£ofŸ
njitahd msÎ ghèid jhæläUªJ mUªÂ¡ bfhŸ»‹wd.
Áid¡F é£l MLfŸ, Áid¥gUt¤Â‰F tuhj MLfŸ
M»at‰iw¤ jå¥ ÃçÎfshf ts®¡f nt©L«. Ï›thW ts®¡F«nghJ
eh« vëajhf MLfŸ Áid¡F tUtij¡ f©l¿ayh«.
Áidahd MLfis¤ jåahf ts®¡f nt©L«. m›thW
ts®¡f¥gL«nghJ k‰w MLfŸ r©ilæ£L V‰gL« fU¢ÁijéèUªJ
Áid MLfis¡ fh¥gh‰WtnjhL k£Lä‹¿, mt‰¿‰F¤ njitahd
C£l¢r¤J äFªj Ôtd§fis¡ bfhL¤J¡ fUéš cŸs M£L¡
F£ofë‹ ts®¢Áia C¡Fé¡fyh«.
x›bthU ÃçÎfS¡bf‹W jå¤jå¡ fjÎfŸ mika¥bgw
nt©L«. btëna tUtj‰F« cŸns brštj‰F« xU tê k£Lnk
ÏU¡f nt©L«. fjé‹ mfy« 3 mo mséš ÏU¡f nt©L«.
F£ofis¡ FëçèUªJ fh¥gh‰w ÏuÎ neu§fëš F£ofë‹
v©â¡if k‰W« mt‰¿‹ Ïltr M»at‰iw¥ bghW¤J ä‹
és¡FfŸ bghU¤j nt©L«. ä‹és¡FfŸ bghU¤Jtj‹ _y«
mt‰¿èUªJ tU« bt¥gnk bfh£lifæ‹ Nœãiy bt¥g¤ij
mÂfç¡F«. Ïj‹ _y« M£L¡F£ofŸ Fëçdhš gh¡f¥gLtJ
jL¡f¥gL»‹wJ.
jiufëš ts®¡f¥gL« MLfëš fê¢rš, ãnkåah ngh‹w
nehŒfŸ V‰g£L mt‰¿š cæ® ÏH¥ò V‰gL¤J»‹wJ. Mdhš bfh£oš
Kiw ML ts®¥Ãš nk‰T¿a Ãu¢ridfŸ tUtšiy. nkY«
MLfë‹ clš ts®¢Á¤ Âw‹ nk‹gL»‹wJ.
éiy : xU rJuo¡F %. 300 /- (gyif)
xU rJuo¡F %.900/- (ghèÍnu¤Ô‹)
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
34
It is an intensive method of rearing goats in which the goats are not allowed for browsing in to open field, instead green fodder, dry fodder and concentrate were fed to them within the housing system itself.
It is important to provide concentrate, green and dry roughages in an adequate quantity to goats in this system of housing. Lack or insufficiency of any one of the above feed will result in decreased body weight and overall performance like inadequate dry fodder will result in indigestion and poor growth rate in goats and inadequate green fodder will result in poor reproductive performance.
Construction of slatted floor house
The following points should kept in mind before constructing shed for goats.
� The shed should provide ideal micro and macro environment to goats during all types of climatic condition.
� The shed should protect the goats from the cold weather during winter and from the heat stress during summer.
� The shed should provide adequate space for kids, does and the bucks.
� The shed should be constructed away from any water resources as they tend to induce respiratory illness in goats if possible
� The ideal shed length should be in east – west orientation. � It should have provision for hanging tarpaulin / gunny bags /
screen cloth in order to protect animal from cold weather during winter
TANUVAS – URF - Slatted Floor House for Goats
UIIC 016
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
35g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
Shed design
� Distance of the slatted floor of the shed from the ground level shall be about 4 feet
� The centre height of the roof from the slatted floor shall be 10 feet and at the end of the roof on either side shall be 7 feet.
� The size of the run area of the house should be twice the size of the slatted floor house.
� The height of the fence around the shed is 4 feet.
� The width of the shed is 16 – 20 ft and the length can be according to the requirement.
Floor space requirement for goats
Type Area (sq. ft.)
Kid (3- 6 months of age) 04Doe (>6 months of age) 10Buck (>10 months of age) 20
� The shed area can be divided into multiple compartments with separate gate for each.
� However there should be only one entrance and one exit gate for the entire shed.
� Common woods used for construction of slatted floor are woods of
� Jack fruit tree � Coconut tree � Bamboo � Palmyrah tree
� Distance between woods in the slatted floor is half inch which facilitates draining of dung and urine from the animals to the ground level and prevent their stagnation / accumulation in the shed.
� The optimum wood width should be about two and half inches. Higher the width should be avoided as it will result in stagnation of dung and urine.
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
36
� The wood should be strong and durable to bear the weight of all the goats.
� The housing system consists of run area in addition to slatted floor house. This facilitates free movement and exercise to goats which further improves their appetite and feed intake. The pen and the run is connected by a (sloppy) ramp.
� As the system provides adequate air movement and circulation it tends to reduce respiratory illness in goats to certain extent.
Managemental tips � Goats can be grouped according to the age /body weight/pregnant
status and can be reared in separate compartments within the same shed for effective management.
� Bucks should always be kept in separate compartment and should not be mixed with females or kids.
� Lactating does and their kids should should be kept and reared in separate compartment to facilitate adequate suckling of milk by the kids.
� Does which are crossed for breeding should ber kept in separate compartment to facilitate easy identification and confirmation of pregnancy status.
� Non cyclical goats should be kept in separate compartment to facilitate easy identififcation of estrous signs.
� Pregnant does should be reared in separate compartments in order to protect them from abortion due to trauma and also to provide extra ration to meet their demand.
� Brooding lights should be fit in the kids comparments to protect them from cold weather during night especially in winter and to provide enough warm to protect from hypothermia.
� As the slatted floor housing system provides better hygienic environment to goats, mortality due to diarrhoea and pneumonia is considerably low when compared to conventional system of goat rearing.
� Cost : RS.300/sq. ft – Wood RS.900/sq. ft – Plastic crate
Innovators : Dr. P. Tensingh Gnanaraj and Dr. T. Muthuramalingam
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
37g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� Ãwªj f‹WfŸ R¤jkhfΫ, brsfçakhfΫ ÏU¥gj‰fhf
mik¡f¥g£l bfh£lif ÏJthF«.
� 10.5 mo ÚsK«, 4.5 mo mfyK« bfh©lJ. bfh£lifahdJ 4.5
mo Ús« bfh©l Tiu nkŒa¥g£l c£gFÂ, 6 mo Ús« bfh©l
btëgF vd Ïu©L ÃçÎfshf Ãç¡f¥g£LŸsJ.
� bfh£lifæ‹ Ã‹òw cau« 5 mo, K‹òw cau« 6 mo v‹w mséY«,
bfh£liffë‹ btë¥òw gF 5 mo cau« bfh©ljhfΫ
cŸsJ.
� f‹W¡ F£o cŸns k‰W« btëna bršYtj‰F bfh£lifæ‹
Ëòw¤Âš, nkny ÑnH Ïw§f¡Toa fjtik¥òŸsJ.
� Ôtd¤ bjh£o, j©Ù® bjh£o k‰W« ghšòf£L« ghš C£o M»a
mik¥òfŸ cŸsd.
� f‹W Ôtd« c©gij f£L¥gL¤J« tifæš Ôtd¤bjh£oæ‹
K‹gFÂ totik¡f¥g£LŸsJ.
� ÏJ fh‰nwh£l« tU« tifæš brsfçakhd trÂfis¡
bfh©ljhf ÏU¥gjhš Rthr nehŒfŸ, bjh‰W nehŒfŸ tuhkš
ghJfh¡F«.
� f‹WfŸ RjªÂukhf elkhL« tifæš mik¡f¥g£LŸsJ.
� Fiwªj vil bfh©l bfh£lif mik¥ghF«. vëš R¤j«
brŒayh«.
� éiy %.15,000/-
TANUVAS – URF - f‹W¡ F£o¡fS¡fhd
bfh£lif
UIIC 017
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
38
� TANUVAS – URF – Calf hutch is designed to improve health and growth of calves prior to weaning.
� Total length of calf hutch is 10.5 feet and width of the hutch is 4.5 feet. It has two division, pen and run. Length of pen is 4.5 feet, length of run is 6 feet.
� Rear height of pen is 5 feet, front height of pen is 6 feet and front height run is 5 feet.
� Calf enter into the calf hutch through upside down inlet door. � Neck lock in calf hutch allows controlled feed and water to calf. � Neck lock helps to provide clean feed and water to the calf at required time. � Installed detachable milk bottle. � Unlocking neck lock at night allows the calf to move itself into the pen. So
calf hutch provide night shelter to calf. � Calf hutch help to prevent the spread of contagious disease, reduce calf
mortality. � It is inexpensive. Properly designed calf hutch provides excellent natural
ventilation which further reduce incidence of respiratory disease. � It is light weight and portable making them easy to clean. � If calf becomes ill, you can move susceptible calves further away from other
calves. It can also easily move to different areas of the lot or pasture. � Calf hutch provide more space allow more freedom for the calf to exercise
and roam outside. � Calf hutch allow greater control and management. A clean, dry, well
ventilated hutch provides the best opportunity for a calf to stay health & growing.
� Cost Rs.15,000/-
TANUVAS – URF - Calf Comfort Hutch
Innovators : Dr. P. Tensingh Gnanaraj, Dr. T. Geetha and Er. M. Siddharth
UIIC 017
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
39g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� g‹¿¡ F£ofŸ Fëçdhš V‰gL« Ïw¥igÍ« k‰W« jhŒ g‹¿fŸ ä¤J
F£ofëš V‰gL« Ïw¥igÍ« Fiw¥gj‰fhf cUth¡f¥g£l g‹¿¡ F£ofŸ
ey‹ fh¡F« rhjd« ÏJthF«.
� g‹¿¡ F£ofŸ jhæläUªJ ghš mUªÂa ÃwF ghJfh¥ghd Ïl¤Âš
it¥gj‰fhf mik¡f¥g£l R¤jkhf Ïl« ÏJthF«
� jhŒ g‹¿fë‹ rhz« k‰W« ÁWÚçdhš g‹¿¡F£ofëš V‰gL« clš ey¡
nfhshW j鮡f cUth¡f¥g£l rhjd« ÏJthF«.
� Fëçdhš g‹¿¡F£ofëš V‰gL« M‰wš ÏH¥ig j鮤J mt‰¿‹ clš
vilia mÂfç¡F« tifæš totik¡f¥g£l rhjd« ÏJthF«
� g‹¿¡F£ofŸ Ãwªj _‹W thu§fS¡F Ϫj rhjd¤Âš it¡f¥gL»wJ
� 3 mo ÚsK«, 2 mo mfyK«, 2 mo cauK« bfh©lJ
� Ï¢rhjd¤Â‹ nkny bghU¤j¥g£l ä‹ és¡»‹ _y« g‹¿¡ F£ofS¡F
ÏuÎ k‰W« Fë® fhy§fëš njitahd bt¥gãiy btë¡ bfhzu¥gL»wJ.
� Ï¢rhjd¤Â‹ jiu jskhdJ Ïu©L mL¡fhf, x‹W g‹¿¡ F£ofS¡F
äUJthd j‹ikiaÍ«, mrÂa‰w ãiyiaÍ« bfhL¡f¡ Toa Ïu¥guyhd
jiujs«, k‰bwh‹W ÁWÚ® k‰W« rhz« btënaW« tifæš cŸs ÏU«ò
tiyahš M¡f¥g£l jiujs« MF«
� Ï¢rhjdkhdJ g‹¿ <D« bfh£oèš njit¡nf‰w vªj xU Ïl¤ÂY«
bghUªJ« tifæš mik¡f¥g£LŸsJ
� Ïš 12-15 g‹¿¡ F£ofis mil¡fyh«
� Á¿a, eL¤ju k‰W« bgça g©izahs®fŸ midtU« ga‹gL« tifæš
cUth¡f¥g£LŸsJ.
� éiy %. 3,000/-
TANUVAS – URF - g‹¿¡ F£ofë‹
ey‹ fh¡F« rhjd«
UIIC 018
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
40
� TANUVAS – URF – piglet soothe snooze deck is designed to reduce the mortality in piglets due to hypothermia and crushing injury by the dam
� Piglets after suckling from the dam can be kept in this deck to provide them ideal hygienic environment.
� Incidences of illness can be reduced by minimizing the contact of piglets with the faeces and urine of the dam.
� Improves the daily body weight gain of the piglets as less amount of energy is lost for thermoregulation.
� Piglets can be kept for 3 week of age in this deck. � The piglet soothe snooze deck is 3 feet length, 2 feet width and 2
feet height. � It is fabricated using plywood on three sides and with acrylic door in
the front. � A lamp is mounted on the top to provide light and warmth to the
piglets during night and winter. � The floor is made up of two layers Viz. rubber mat on which the
piglets rest and iron mesh beneath it to provide rigidity and to drain the excreta of the piglets.
� The deck can be fixed at convenient location near the farrowing pen. � The holding capacity is 12 – 15 piglets. � Cost effective and user friendly for small, medium and large farmers. � Price Rs. 3,000/-
TANUVAS – URF - Piglet Soothe Snooze Deck
Innovators : Dr.T. Muthuramalingam, Dr. E. Rachel Jemimah, Dr.P.Tensingh Gananaraj
UIIC 018
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
41g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� g‹¿fis Xçl¤ÂèUªJ k‰bwhU Ïl¤Â‰F äf ÏyFthf
kh‰w cjΫ xU têel¤J« rhjd« ÏJthF«.
� bghJthf g‹¿fis vil fh©gj‰F bfh£lifæèUªJ vil
kâ¡F x£o bršY« nghJ«, Ïd¢nr®¡ifæ‹ nghJ bg©
g‹¿fis Ïl« kh‰Wtj‰F« k‰W« gy fhuz§fS¡fhf
bfh£lif¡FŸ xU ÃçéèUªJ k‰bwhU Ãçé‰F kh‰Wtj‰F
cjt¡ ToajhF«.
� 3 mo ÚsK«, 2 mo mfyK«, 3 mo cauK« bfh©L, Fiwªj
vil bfh©l jf£lhš totik¡f¥g£LŸsJ.
� vëjhf midtU« ga‹gL¤J« tifæš mik¡f¥g£L,
g‹¿fis Ïl« kh‰W« bghGJ ãfG« neu¢ bryÎ, mÂf ntiy
gS M»at‰iw¡ Fiw¡»‹wJ.
� Á¿a, eL¤ju k‰W« bgça g©izahs®fŸ ga‹gL¤J«
tifæš Fiwªj éiyæš cUth¡f¥g£LŸsJ.
� x‰iw¢ rhjd« éiy %. 600/-
� Ïu£il¢ rhjd« éiy %. 1,200/-
TANUVAS – URF - g‹¿fis tê el¤J« rhjd«
UIIC 019
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
42
� Designed to guide or direct pigs to desired destination/place/sty/pen with ease for relocation, weighment, etc.
� Can be used to transfer pig /group of pigs from one place to another.
� Made of thick board of 4 ft length and 3 ft height.
� Provided with two oval holes at the top for holding the guiding pad and one in the middle for pig vision.
� Minimize labour and time.
� Easy to handle.
� Available in two different models one for guiding single pig and other for guiding group of pigs.
� Cost effective and user friendly for small, medium and large farmers.
� Single pad price Rs.600/-
� Double pad price Rs. 1,200/-
TANUVAS – URF - Guiding Pad for Pigs
Innovators : Dr. P. Tensingh Gananaraj, , Dr.T. Muthuramalingam, Dr. E. Rachel Jemimah
UIIC 019
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
43g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� xnu neu¤Âš Ïu©L M£L¡F£ofS¡F xnu neu¤Âš k‰W«
rçahd mséš ghš òf£l cjt¡Toa tifæš mik¡f¥g£l
cgfuz« ÏJthF«.
� ghš g‰wh¡FiwnahL M£L¡F£o k‰W« jhæšyh M£L¡ F£ofŸ
M»at‰iw ts®¥gj‰fhf totik¡f¥g£lJ.
� Ï›ÎgfuzkhdJ ghš Fo¡F« x›bthU M£L¡F£oæ‹ Fo¡F«
msit Jšèakhf fh©Ã¡f¡Toa tifæš Ïu©L ÃçÎfshf
Ãç¡f¥g£L totik¡f¥g£LŸsJ.
� x›bthU ÃçÎfëš äf äUJthd u¥guhyhd fh«òfŸ mik¡f¥g£L
njit¡nf‰g fH£o R¤j« brŒJ kWgoÍ« bghU¤Jtj‰F VJthf
mik¡f¥g£LŸsJ.
� Ús«, mfy«, cau« Kiwna 30 x 20 x 20 br.Û. v‹w mséš 4 è£l®
bfhŸsÎ bfh©ljhf cŸsJ.
� vªj xU Ïl¤ÂY« bghU¤j VJthf totik¡f¥g£LŸsJ.
� äf Fiwªj éiyæš Á¿a, eL¤ju k‰W« bgça g©izahs®fŸ
cgnahf¥gL¤j¡Toa tifæš totik¡f¥g£LŸsJ.
� éiy %.5,700/-
TANUVAS – URF - M£L¡ F£ofS¡F
ghš òf£l cgfuz«
UIIC 020
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
44
� TANUVAS – URF – compartment lamb/kid milk feeder is specially designed to feed milk to two lambs/kids at a time and to ensure that the right quantity of milk is available to each lamb/kid.
� It is very useful for hand raising abandoned, weak or newborn lamb/kid by feeding correct quantity of milk to individual animal.
� The compartments help us to ensure the quantity of milk fed by each lamb/kid.
� The compartment milk feeder is made up of two individual plastic boxes fitted with removable teat made up of latex.
� The teats can be easily removed for cleaning and replacement. � The compartments are mounted on a metallic frame with sand
and clamp in a view to either place the feeder at desired height and location or to simply clamp the feeder to a frame at a desired height.
� Each compartment can hold up to 4 litres of milk. � The length, breadth and height of the feeder are 30cm X 20 cm X
20 cm respectively. � Cost effective and user friendly for small, medium and large
farmers. � It can be fixed in any convenient location. � Up to two lambs/kids can be fed milk at a time. � Price Rs.5,700/-
TANUVAS – URF - Compartmental Lamb/Kid Milk Feeder
Innovators : Dr. P. Tensingh Gananaraj, , Dr.T. Muthuramalingam, Dr. E. Rachel Jemimah
UIIC 020
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
45g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
TANUVAS – URF - M£L¡F£ofS¡fhd ghšò£o
� clš bkèªj k‰W« Ãwªj M£L¡F£ofS¡F ghš òf£l
totik¡f¥g£l cgfuzkhF«.
� äf äUJthd u¥guhš totik¡f¥g£l fh«ò, Ãsh°o¡ FLitæš
rçahf bghUªJkhW mik¡f¥g£LŸsJ.
� miu è£l® k‰W« xU è£l® gh£oš v‹w Ïu©L msÎfëš
totik¡f¥g£LŸsJ
� g©izahs®fŸ vëjhf ifahS« tifæš totik¡f¥g£LŸsJ
� Ï¥gh£ošfis f«Ãahš brŒa¥g£l mik¥Ãš g©izfëš
njitahd Ïl¤Âš njitahd cau¤Â‰F bghUªJkhW
totik¡f¥g£LŸsJ
� vëjhf R¤j« brŒa¥gl¡ ToaJ
� äf¡ Fiwªj éiyæš Á¿a, eL¤ju k‰W« bgça g©izahs®fŸ
cgnahf¥gL¤JkhW cUth¡f¥g£LŸsJ.
� Ãç¢rh®£ Ãs£l® ghš ò£o éiy %.950/-
� gh£oš nf¥ ghš ò£o éiy %.1,500/-
UIIC 021
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
46
� The TANUVAS – URF topper pop bottle milk feeder is specially designed for hand raising of weak or newborn lambs and kids.
� The topper pop bottle milk feeder is made up of recyclable plastic screw top soft drink bottle with a 28 mm neck fitted with nipple at the cap.
� The nipple is made up of compression molded rubber and latex.
� The topper pop bottle milk feeder is available in two different quantities viz. one litre and half litre capacity.
� It can be easily handled by children and women.
� It can also be mounted at desired height and location using frame.
� Easy to clean and hygienic.
� Cost effective and user friendly for small, medium and large farmers.
� Price Rs. 950/- (Pritchard flutter nipple)
� Price Rs. 1,500/- (Bottle cap nipple)
TANUVAS – URF - Topper pop bottle Milk feeder for lambs and kids
Innovators : Dr. P. Tensingh Gananaraj, , Dr.T. Muthuramalingam, Dr. E. Rachel Jemimah
UIIC 021
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
47g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
TANUVAS – URF - g‹¿fS¡fhd cUis tot
jhåa§» j©Ù® bjh£o
� 120 è£l® bfhŸssÎ bfh©l Ãsh°o¡ cUisæš 4-6 j©Ù®¡
bfhL¥gh‹ bghU¤j¥g£LŸsJ.
� j©Ù® bfhL¥gh‹ JUÃo¡fhj v~»dhš M¡f¥g£LŸsJ.
g‹¿fŸ j©Ù® bfhL¥ghid mG¤J« nghJ j©Ù® btë¡
bfhzu¥gL»wJ.
� j©Ù® bfhL¥ghåš c£gFÂæš ršyil bghU¤j¥g£LŸsjhš
njita‰w öRfŸ òfh t©z« j©Ù® ghJfh¡f¥gL«.
� j©Ù®¡ bfhL¥gh‹ vëjhf kh‰W« tifæš mik¡f¥g£LŸsjhš
R¤j« brŒtJ vëJ.
� jhåa§» j©Ù®¤ bjh£oia vëjhf R¤j« brŒayh«.
� lhå¡ k‰W« kUªJfis j©Ùçš fyªJ g‹¿fS¡F bfhL¡f
VJthdJ.
� g‹¿¡F£o, tsU« g‹¿ k‰W« bgça g‹¿ M»aitfS¡F V‰wthW
_‹W éj§fëš mik¡f¥g£LŸsJ.
� T£lkhf ts®¡f¥gL« g‹¿fS¡F äfΫ gaDŸsjhf ÏU¡F«.
� mojs¤Âš ÏU«ò jf£odhš jiujs« mik¡f¥g£LŸsjhš
njitahd Ïl¤Âš bghU¤jyh«.
� éiy %. 5,300/- (bgça g‹¿)
� éiy %. 5,900/- (tsU« g‹¿)
� éiy %. 6,000/- (g‹¿¡ F£o)
UIIC 022
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
48
� Designed to provide easy and comfort to pigs for drinking water. � Provide clean and hygienic water to pigs round the day. � Made up of thick plastic cylindrical drum with lid of 120 litres capacity fitted with
mechanical nipple. � The mechanical nipple is made up of stainless steel and let animal drink water
by bitting action in order to eliminate water waste from play and accidental operation.
� The nipple is also provided with screen filter to keep out unwanted debris. � The nipples can be easily removed for cleaning and replacement. � Minimize wastage and contamination of water. � Reduces space required for providing water. � Ensure hygienic availability of water at any given point of the time. � Easy to clean. � Vitamin supplements / medications shall be mixed with water and easily
administered. � Available in three different ranges separately for piglets, growers and finishers. � For piglets the drum is fitted with 6 nipplers for grower the drum is fitted with 5
nipplers and fro finishers/adult the drum is fitted with 4 nipplers to provide equal space for individual piglets for accessing the nipplers for drinking water and to avoid fighting among pigs.
� Ideal for pig sties where group of animals are housed together. � Provided with plates at the bottom so that they can be fixed at any desired
location. � Cost effective and user friendly for small, medium and large farmers. � Price Rs.5,300 (Adult pig) Price Rs.5,900 (Pig grower) Price Rs.6,000 (Piglets)
TANUVAS – URF - Barrel type Automatic Drinker for Pigs
Innovators : Dr. E. Rachel Jemimah, Dr.T. Muthuramalingam and Dr. P. Tensingh Gananaraj
UIIC 022
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
49g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
TANUVAS – URF - g‹¿¡ F£ofS¡fhd
Fiwªj éiy Ôtd bjh£o
� g‹¿ <D« j©lths¡ bfh£oY¡FŸ g‹¿¡ F£ofS¡F
njitahd Ôtd§fis më¡F« tifæš totik¡f¥g£l Ôtd¤
bjh£o ÏJthF«.
� Ïj‹_y« g‹¿¡ F£ofS¡F njitahd msÎ Ôtd§fŸ
bfhL¤J Ôtd§fŸ éiuakhtij jL¡fyh«.
� X›bthU Ôtd¤ bjh£oæY« 6 Ãsh°o¡ bjh£ofŸ ÏU¡FkhW
totik¡f¥g£LŸsJ.
� f«Ã tiyahš éz¥g£l mik¥Ãš Ôtd¤ bjh£ofŸ
bghU¤j¥g£LŸsjhš g‹¿¡ F£ofŸ vëjhf Ôtd§fis
vL¤J¡bfhŸS« tifæš njitahd Ïl¤Âš njitahd
cau¤Âš bghU¤Â¡ bfhŸsyh«.
� Ôtd§fŸ, rhz« k‰W« ÁWÚ® ngh‹wt‰whš khRglhkš ÏU¡f
têtif brŒ»‹wJ.
� vëjhf R¤j« brŒayh«
� xU Ôtd¤ bjh£o 10 g‹¿¡ F£ofS¡F nghJkhdJ.
� äf¡ Fiwªj éiyæš Á¿a, eL¤ju k‰W« bgça g©izahs®fŸ
ga‹gL« tifæš cUth¡f¥g£LŸsJ.
� éiy %.900/-
UIIC 023
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
50
� TANUVAS – URF Creep feeder for piglets is specially designed to provide creep feed to piglets in the creep area of the farrowing pen.
� It is designed to ensure the availability of correct quantity of feed to piglets.
� It enhances concentrate feed intake among nursing piglets thereby improving daily weight gain and early weaning.
� It is made up of 6 small plastic trays mounted on a metallic frame which is elevated at one side to provide easy access to piglet and to avoid wastage due to non accessibility.
� Easily to carry and transport and prevents wastage of feed. � Prevent contamination of feed with faeces and urine thereby
minimizes the health issues. � Easy to clean. � One feeder is enough for up to 10 piglets. � Cost effective and user friendly for small, medium and large
farmers. � Price Rs.900/-
TANUVAS – URF - Creep Feeder for Piglets
Innovators : Dr. E. Rachel Jemimah, Dr.T. Muthuramalingam and Dr. P. Tensingh Gananaraj
UIIC 023
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
51g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
TANUVAS – URF - g‹Kf ga‹gh£L M£L¡ »£o
� kU¤Jt ßÂahd gçnrhjid¡F c£gL¤jΫ, Á»¢ir nk‰bfhŸsΫ
k‰W« gy guhkç¥ò brašKiwfis MLfëš nk‰bfhŸs totik¡f¥g£l
g‹Kf ga‹gh£L M£L¡»£o ÏJthF«.
� ÏJ ÏU«ghyhdJ. M£L¡»£oæ‹ g¡fth£L mik¥ghdJ efU«
tifæš, MLfë‹ clyik¥ò¡F V‰wthW rçahf bghUªJkhW
totik¡f¥g£LŸsJ.
� MLfis vëjhf gçnrhjid brŒÍ« tifæš, Ëòw¤Âš cŸs ÏU«ò
if¥Ão _y« MLfë‹ Ã‹d§fhšfis nkny caU«go brŒayh«.
� K‹òw¤ÂYŸs gŠR bghU¤Âa jiy–ó£L (head lock) mik¥Ã‹ _y«
MLfë‹ Ïa¡f¤ij f£L¥gL¤jyh«.
� ÏlJòw¤ÂYŸs nkir ngh‹w mik¥ghdJ Á»¢iræ‹ nghJ njit¥gL«
kU¤JfŸ mšyJ k‰w cgfuz§fis it¤J¡ bfhŸs cjΫ.
� 4 mo ÚsK«, 2 ¼ mo mfyK« 4 ½ mo cauK« bfh©ljhF«.
� Ït‰¿‹ xU gFÂæš vilkhå bghU¤j¥g£LŸsjhš MLfë‹
viliaÍ« f©l¿ayh«.
� Ïj‹ mo¥gFÂæš r¡fu« mik¡f¥g£LŸsjhš, xU Ïl¤ÂèUªJ
k‰bwhU Ïl¤Â‰F vëjhf kh‰wyh«.
� fhšeil kU¤JtkidfŸ, eL¤ju k‰W« bgça g©izahs®fŸ
ga‹gL« tifæš äf¡ Fiwªj éiyæš cUth¡f¥g£LŸsJ.
� éiy %.15,000 /-
UIIC 024
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
52
� It is specially designed multipurpose trevis attached with table on wheels for restraint, clinical examination and treatment of sheep and goat.
� It is made up of iron and provided with animal and operator friendly features.
� It is provided with sponge coated movable sides which can be adjusted according to the size of the animal for its restraint.
� The rear end is fitted with adjustable handle to lift the hind limbs of the animal to desired height for clinical examination and artificial insemination.
� The front end is provided with sponge coated head lock for proper restraint of animal and its clinical examination.
� A table is fitted to the left side of the trevis for placing equipments/and materials needed for treatment and examination of the animal.
� The tretab - SG is 4 ft long, 2 ¼ ft wide and 4 ½ ft high. � It is also provided with weighing balance in order estimate the weight
of the animal for medication. � Easy to transport from one place to another as it is provided with
wheels. � It is an important device which is indispensable for all veterinary
hospitals and for medium and large farms. � Cost Rs. 15,000 /-
TANUVAS – URF - Tretab - SG
Innovators : Dr. S. Balasubramanian, Dr. S. Thilagar and Dr. P. Tensingh Gananaraj
UIIC 024
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
53g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
TANUVAS – URF - MLfis¤ ö¡F«
iA£uhè¡ ÏaªÂu«
� MLfëš fhš FH«òfis bt£Ltj‰F«, br«k¿ MLfëš
nuhk§fis bt£Ltj‰F«, Á»¢ir k‰W« gçnrhjid¡F
c£gL¤J« nghJ MLfis ãW¤Â njitahd msÎ cau¤Â‰F
bfh©L tu¢ brŒa cjΫ fUé ÏJthF«.
� ÏU«ghyh¡f¥g£l jiu jskhdJ nkY«, ÑG« bršy¡Toa
tifæš mik¡f¥g£LŸsjhš MLfns nkny vëjhf ca®¤jyh«/
� jiu jskhdJ ÏU«ò tiyahš totik¡f¥g£LŸsJ.
� Ï¡fUéæ‹ K‹gFÂ MLfSila jiyæ‹ Ïa¡f¤ij
f£L¥gL¤J« tifæš jiy¥ó£L (Head Lock) trÂia bfh©ljhf
totik¡f¥g£LŸsJ. ÏJ _‹wiu mo ÚsK« Ïu©liu mo
mfyK«, _‹wiu mo cauK« bfh©lJ.
� ML jiu js¤Â‰F tªjÎlnd K‹gFÂæYŸs jiy ó£L
gFÂæš f£l¥g£L Rkh® eh‹fo cau¤Â‰F iA£uhå¡ ö¡»æ‹
_y« bfh©L bršy¥gL»‹wJ.
� Ï¡fUé, fhšeil kU¤Jtkid, eL¤ju k‰W« bgça
g©izahs®fS¡F cgnahfkhf ÏU¡F«.
� éiy %. 11,000/-
UIIC 025
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
54
� It is specially designed hydraulic lifting device to lift small ruminants for wool shearing, hoof trimming, clinical examination and treatment.
� It is made up of iron and provided with a lever for lifting.
� The platform frame is designed in the form of see saw so that the animal can be easily walked on to it from the ground.
� The platform is made up of iron mesh for animal standing.
� The fore end is fitted with head lock for restraining the animal.
� The length, breadth and height of the device are 3 ½ ft, 2½ ft and 3 ½ ft respectively.
� Once the animal is walked o n to the platform and head locked the platform can be raised to desired height up to 4 ft with the help of hydraulic lift for easy examination and operation.
� It is an important device which is indispensable for all veterinary hospitals and medium and large scale commercial farms.
� Cost Rs. 11,000/-
TANUVAS – URF - Lifting device for sheep and goat
Innovators : Dr. P. Tensingh Gananaraj, Dr. S. Balasubramanian and Dr. S. Thilagar
UIIC 025
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
55g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
TANUVAS – URF - Fiwªj éiy
iA£nuhnghå¡ gRik¡Foš
� k© Ïšyhkš äf¡ Fiwªj ãy¥gu¥Ãš ML, khL, FÂiu ngh‹wt‰¿‹
ts®¥Ã‰F¤ njitahd gRªÔtd§fis iA£nuhnghå¡ gRik Å£o‹ _y«
c‰g¤Â brŒayh«. Ï«Kiwæš Fiwªj msnt ãy«, Ú®, k‰W« gâahs®fŸ
njit¥gL»‹wd®.
� Ϫj ÏaªÂu¤Âš 4 gFÂfshf x›bthU gFÂæY« 8 éij¤ j£LfŸ ÏU¡FkhW
mik¡f¥g£LŸsJ. mjhtJ 8 eh£fS¡F ehŸ x‹W¡F 4 éij¤j£LfŸ v‹w
mséš x›bthU ehS« kh‰¿ mik¡f¥g£LŸsJ.
� 1.65 ».». éij ga‹gL¤J«nghJ mÂèUªJ 8 »nyh msé‰F¥ gRªÔtd§fŸ
»il¡»‹wd. nkY« éijahf Ï£l 1 »nyh jhåa§fS« gRªÔtd¤njhL
»il¡»‹wd. k¡fh¢nrhs« (m) nrhs« mšyJ bfhŸS (m) rz¥ig ngh‹wt‰iw
iA£nuhnghå¡ Kiwæš c‰g¤Â brŒayh«.
brašKiw
� nj®ªbjL¡f¥gL« jhåa§fŸ e‹F K‰¿ Kis él¡ ToajhfΫ, <u¥gj« 12
rjé»j¤Â‰FŸshfΫ, fhça¤JfŸfŸ m‰wjhfΫ ÏU¡f nt©L«.
� xU bjh£oš k¡fh¢nrhs« éijfis Ï£L mjDŸ j©Ù® fyªJ Rkh® 24
kâ neu« Cwit¡f nt©L«. Ëd® j©Ùiu to¤J vL¤J é£L 15 ãäl«
njitahd msÎ j©Ù® C‰¿¡ fisa nt©L«. k¡fh¢nrhs éijfis
<ukhd rzš rh¡F¥ igfëš f£o it¡fnt©L«. _‹W kâ neu¤Â‰F xU
Kiw rh¡F¥ igfis Úçdhš eid¡f nt©L«. Ï›thW _‹wh« ehŸ fhiyæš
m›éijfŸ äf¢Á¿ajhf Kis é£L iA£nuhnghå¡ gRik Å£o‰FŸ
mL¡Ftj‰F¤ jahuhf ÏU¡F«.
� éijfis ½ m§Fy« cau¤Â‰F Ãsh°o¡ j£oš it¤J iA£nuhnghå¡
gRikÅ£oš it¡f nt©L«.
� Ïu©L kâneu¤Â‰F xU Kiw 5 ãäl¤Â‰F¤ jhåa§F Ú®¤bjë¥gh‹ _y«
Úiu éijfë‹ nkš bjë¡f¥gl nt©L«.
� x›bthU ehŸ KoéY« Kjš ehŸ mL¡» it¤j k¡fh¢nrhs éijfis mL¤j
ehS¡F kh‰w nt©L«. cjhuzkhf Kjš ehŸ mL¡»a Ãsh°o¡ j£Lfis
mj‰F nkYŸs Ïu©lh« ehŸ mL¡Ffëš it¡f nt©L«.
� bghJthf 8 ehŸ gRªÔtd ts®¢Á nghJkhdjhF«. Ϫeh£fëš 25- 35 br.Û.
cau¤Â‰F ts®ªJ éL»‹wd. bghJthf 1.65 »nyh »uh« éij¡F 7-8 »nyh
»uh« gRªÔtd§fŸ c‰g¤Âah»‹wd.
� éiy %.48,000/-
UIIC 026
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
56
� It is a soil less fodder production technology by which fodder can be grown to feed livestock such as cattle, buffalo, horse, pig, sheep, goat and poultry.
� It request only minimal land, water and labour � The low cost mode consist of 8 rows each with holding capacity of 4 trays � About 8 kg of fodder can be produced from 1.65 kg of maize seed � As a seed also comes along with fodder and sprout mat, the whole fodder along with
root and seed is utilize by the animals without wastage. � Different types of seeds the can be grown in to hydroponic fodder are maize, sun
hump, horse gram, jowar etc., Procedure
� The select seeds with high sprouting quality and moisture less the 12% � Place the seeds in to tub / tank and add water � Wash the seed by stirring with stick and drain the water � Add water and soak the seeds for 24 hours � Pack the soaked seeds in to gunny bags � Place these gunny bags under shade (avoid keeping near / under direct sun light) � Sprinkle water once in every 3 hours on to the gunny bags � Allow the seeds to sprout in the gunny bag itself for one day � Transfer the sprouted seeds from the gunny bags on to the trays and spread them
evenly upto a height of 1/2 inches within the tray � Rack the trays in to the lower section of the machine (i.e) in to the day 1 row. � Switch on the sprinklers in every two hours for sprinkling water daily. � Change / shift the trays to next row on every other day � After completion of 8th day (i.e.) 8th row the fodder can be utilized for feeding farm
animals. � Usually the growth period is 8 days in which the fodder grows to a maximum height
of 25 to 35 cm. � It can be purchased from University Research Farm, TANUVAS by placing order. � Cost Rs.48,000/-
TANUVAS – URF -Low Cost Hydroponic device
Innovators : Dr. P. Tensingh Gananaraj, Dr. E. Rachel Jemimah and Dr.T. Muthuramalingam
UIIC 026
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
59g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� milfh¥gh‹ v‹gJ nfhê, th‹nfhê, »å¡nfhê k‰W«
#¥ghåa¡fhil FŠRfS¡F nfhil¡fhy¤Âš Ïu©L
thuK«, Fë® fhy¤Âš _‹W thuK« bra‰if bt¥g« më¡F«
cgfuzkhF«.
� milfh¥ghåš bra‰if bt¥g« më¡f ä‹rhu gšò
bghU¤j¥g£LŸsJ. nkY«, nfhê¡FŠRfë‹ elto¡iffS¡F
V‰g ä‹rhu gšÃ‹ cau¤ij kh‰¿ mik¡f tr cŸsJ.
� Ï›tilfh¥gh‹ ghèònuh¥Ãè‹ _y¥bghUëdhš
cUth¡f¥g£lJ. ÏJ mÂf bt¥g¤ij jh§ftšyJ, Úiu c¿ŠR«
j‹ika‰wJkhF«. Ϥj‹ikahš, milfh¥ghid vëš »Uä
Ú¡f« brŒayh«.
� 1 mo cau« k‰W« 3 mo é£l« bfh©l Ï›tilfh¥ghåš Rkh®
100 nfhê¡FŠRfS¡F bra‰if bt¥g« më¡fyh«.
� vëš R¤j¥gL¤Â vL¤J bršyyh«; gyKiw ga‹gL¤jyh«.
� c‰g¤, éiy %.800/-
TANUVAS – URF - Ïs§FŠRfŸ mil¡fh¥gh‹
UIIC 027
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
60
� Brooder is an equipment used to provide warmth to day-old chicken of broiler, layer, turkey, guineafowl , Japanese quail chicks, etc upto 2 weeks in summer and 3 weeks in winter.
� TANUVAS - URF - Portable mini poultry brooder consists of a heat source (incandescent bulb) with height adjustment to increase / decrease the temperature based on the behavior of the chicks.
� Brooder guard is made of up of polypropylene flute board sheets which can withstand the brooding temperature.
� It is washable and can be disinfected and reused.
� The brooder guard height is 1ft and 3 ft diameter
� It can accommodate 100 chicks
� It is portable
� Cost of production Rs.800
TANUVAS – URF - Portable Mini Poultry Brooder
Innovators : Dr. P. Tensingh Gananaraj, Dr. A. Sundaresan and Dr. S. Ezhilvalavan
UIIC 027
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
61g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� M tot nfhê¡ T©oš ts®nfhê k‰W« K£il¡ nfhêfis
ts®¡fyh«.
� Ïu©L mL¡Ffis¡ bfh©l Ï¡T©oš, nkš mL¡»š ts®
nfhêfisÍ«, Ñœ mL¡»š K£il¡ nfhêfisÍ« ts®¡fyh«.
� nkš mL¡»š, 8 T©LfŸ cŸsJ. x›bthU T©oY« 9 Kjš 18
thu taJila 5 ts® nfhêfŸ Åj« bkh¤j« 40 ts® nfhêfis
ts®¡fyh«.
� Ñœ mL¡»š 8 T©LfŸ cŸsJ. x›bthU T©oY« 19 Kjš
72 thu taJila 4 K£il¡ nfhêfŸ Åj«, bkh¤j« 32 K£il¡
nfhêfis ts®¡fyh«.
� K£il¡nfhê¡ T©oš K£ilfŸ cilahkš ÏU¥gj‰fhf
Ãsh°o¡»dhš Md tiy mik¥ò bghU¤j¥g£LŸsJ.
� ã¥Ãš FoÚ® mik¥ò k‰W« Ôtd¤ bjh£o Ï¡T©oš
bghU¤j¥g£LŸsJ.
� Ï›tif¡ T©L mÂf Ôtd ÏltrÂÍ« ešy fh‰nwh£l trÂÍ«
bfhL¡ftšyJ.
� Ï›tif¡ T©oid vëš vL¤J¢ bršyyh«.
� »uh¥kòw nfhêfis ts®¥gj‰F Ï›tif¡ T©L V‰wJ.
� c‰g¤Â éiy %.12,500/-
TANUVAS – URF - M tot Fiwªj éiy nfhê¡ T©L
UIIC 028
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
62
TANUVAS – URF -Low cost M-type chicken cage
� TANUVAS - URF - M-type cage is meant for rearing chicken grower cum layers
� Grower can be reared at upper row and layers can be reared at lower row
� Each grower cage can accommodate 5 birds of 9-18 weeks of age and totally 40 growers can be reared in 8 compartments.
� Each layer cage can accommodate 4 birds of 19-72 weeks of age and totally 32 layers can be reared in 8 compartments.
� A mesh is provided on the floor of the layer cage to avoid egg breakage
� A nipple drinker is installed inside the cage and a linear feeder is fixed outside
� More feeding space is available and better ventilation than conventional cages
� The cage can be easily dismantled and easy to carry � It is more suitable for rural poultry production � Cage specification:
Front feeding length : 18 inch Front height : 18 inch Back height : 15 inch Depth : 15 inch
� Cost of Production Rs.12,500
Innovators : Dr. S. Ezhilvalavan, Dr. P. Tensingh Gananaraj and Dr. A. Sundaresan
UIIC 028
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
63g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� òw¡fil nfhê¡ bfh£lifahdJ k‰w éy§FfëläUªJ
nfhêfis ghJfh¡F« mik¥ghF«.
� òw¡fil nfhê bfh£lifæš Ïu©L K£ilæL« bg£ofS«,
R‰¿ Âçtj‰F«, ã‰gj‰F« mik¥ò V‰gL¤j¥g£LŸsJ.
� Ï¡bfh£lifæ‹ Tiu Ãsh°o¡ _y¥bghUëdhš MdJ.
Ï¡bfh£lifæ‹ R‰W¥òu« Ãsh°o¡ tiy¥Ã‹dshš
MdJ.
� Ï¡bfh£lifæ‹ msÎ 12½ x 7 mo
� Ï¡bfh£lifæš ghJfh¥ghd Kiwæš R¤jkhd K£ilfis¥
bgwyh«
� c‰g¤Â éiy %.16,000/-
TANUVAS – URF - òw¡fil nfhê¡ bfh£lif
UIIC 029
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
64
TANUVAS – URF – Backyard Poultry Shelter (BPS) with nest box
� TANUVAS-URF-Backyard poultry shelter (BPS) is to protect the birds from predators
� BPS consists of two nest boxes, two perch and a run. The roof is made of wire netting. The perch is made up HDPE mat on which the chicken can stand. The run is fenced with net and net supported by PVC pipes. The roof is surrounded by a net.
� The size of the shelter is 12.5 X 7 ft.
� The nest box helps in production of safe and clean eggs
� Specification of the nest box
Length : 39 inch Width : 15 inch
Front height : 15 inch Back height : 23 inch
� Cost of Production Rs.16,000
Innovators : Dr. P. Tensingh Gananaraj, Dr. A. Sundaresan and Dr. S. Ezhilvalavan
UIIC 029
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
65g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� Cuf efU« nfhê¡ T©oš Kjš ehŸ nfhê¡ FŠR Kjš é‰gid
taJ tiu ts®¡fyh«.
� Ï¡nfhê¡ T©oš Ïu©L mL¡FfŸ cŸsJ. nkš mL¡»š cŸs
Ïu©L T©Lfëš ts®ªj nfhêfisÍ«, Ñœ mL¡»š cŸs
Ïu©L T©Lfëš nfhê¡ FŠRfisÍ« ts®¡fyh«.
� nkš mL¡»š cŸs x›bthU T©oY« 10 ts®ªj nfhêfŸ
Åj« bkh¤j« 20 ts®ªj nfhêfis ts®¡fyh«. Ñœ mL¡»š
cŸs x›bthU T©oY« 15 nfhê¡FŠRfŸ Åj« Åj« bkh¤j«
30 nfhê¡FŠRfis ts®¡fyh«.
� nkš mL¡»š ts®¡f¥gL« nfhêfë‹ v¢r« Ñœ mL¡»‹
nk‰Tiuæš rhŒthf mik¡f¥g£LŸs Ãsh°o¡ jf£oš
nrfç¡f¥gL»wJ.
� x›bthU T©o‹ msÎ 30” Ús« x 30” mfy«
� Ï¡T©L òw¡fil nfhê ts®¥ò¡F V‰wJ.
� c‰g¤Â éiy %.8,800/-
TANUVAS – URF - Cuf efU« nfhê¡ T©L
UIIC 030
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
66
TANUVAS – URF – Rural poultry cage
� TANUVAS- URF-Rural poultry cage (RPC) can be used for rearing day-old and adult desi-chicken
� RPC has two compartment; a top compartment meant for rearing adult birds and a bottom one is for rearing chicks
� Droppings of upper compartment will be collected on a sloped sheet fixed on top of the lower compartments
� Feeder and waterer can be kept inside the cage
� Each cage in upper row can accommodate 10 adult birds and totally 20 adult birds can be reared
� Each cage in lower row can accommodate 15 chicks cum grower and totally 30 chicks cum grower can be reared
� The size of the each compartment is 30” x 30”
� RPC is most suitable for backyard rearing
� Cost of Production Rs.8,800/-
Innovators : Dr. P. Tensingh Gananaraj, Dr. S. Ezhilvalavan and Dr. A. Sundaresan
UIIC 030
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
67g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� vëa K£il¡ fU nrhÂ¥gh‹ fUToa K£ilfis gçnrh¡f
cjΫ cgfuzkhF«.
� ÏJ ku¢r£l¤Âdhš brŒa¥g£l ÚŸ t£l tot« bfh©lJ.
� Ï›tif¡ fU nrhÂ¥gh‹ 6 nthš£ ä‹rhu¤Âš Ïa§F«. Ïj‰F 1.5
nthš£ Âw‹ bfh©l 4 ng£lçfŸ bghU¤j¥g£LŸsJ.
� Ï¡fUéæ‹ nk‰gu¥Ãš RHY« j‹ik bfh©l mik¥Ãš
K£ilfis gçnrh¡fyh«.
� Ïš bghU¤j¥g£LŸs vš.<.o. és¡F _y« K£ilfUit
gçnrh¡fyh«. Ï›és¡F K£ilæš tsU« fUéid
v›tifæY« gh¡fhJ.
� midtuhY« ga‹gL¤j¡Toa vëa tif fUéahF«.
� c‰g¤Â éiy %.1,100/-
TANUVAS – URF - vëa K£il¡ fU nrhÂ¥gh‹
UIIC 031
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
68
� TANUVAS - URF- portable egg candler is an oval shaped and handy device made up of wood with dimension of 14 cm length, 9.5 cm breath and 1.8 cm height
� Portable egg candler requires 6 voltage power can be provided with 4 numbers of 1.5 volt battery
� Light source is heat sink LED lamp � A rotating device is fixed on the oval platform, where the eggs can
be kept and viewed for embryonic growth � The growth of embryo will not be affected by this candler. � Embryonic development can be viewed with maximum accuracy
than conventional method. � Portable egg candler can be viewed with minimum care than
conventional method � It is easy to carry and requires minimum skill for the operator � Cost of production Rs.1,100/-
TANUVAS - URF - Portable Egg Candler
Innovators : Dr. P. Tensingh Gananaraj, Dr. A. Sundaresan and Dr. S. Ezhilvalavan
UIIC 031
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
69g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
� Á¿a FoÚ® bfhÂfy‹ j£L nfhêfS¡F tH§f¥gL« FoÚiu
Nlh¡f cjλwJ.
� Ãsh°o¡ _y¥bghUshš cUth¡f¥g£l Ï¡bfhÂfyå‹
bfhŸssÎ 2.5 è£l® MF«.
� Ï¡bfhÂfyåš bt¥g_£L« fUé bghU¤j¥g£LŸsJ. nkY«,
Ïš bghU¤j¥g£LŸs bt¥g« f£L¥gL¤J« fUé FoÚç‹
bt¥gãiy 80 o»ç bršÁa°¡F äfhkš f£L¥gL¤J»wJ.
� Nlh¡f¥g£l Ú® F뮪jÎl‹ nfhêfS¡F tH§f¥gL»wJ.
ϪÚçš »UäehÁå ga‹gL¤j¤ njitæšiy.
� vëš vL¤J bršyyh«.
� c‰g¤j éiy %.1,100/-
TANUVAS – URF - nfhêfS¡fhd Á¿a FoÚ®
bfhÂfy‹ j£L
UIIC 032
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
70
TANUVAS – URF - Poultry Waterer with Heater
� TANUVAS - URF - Poultry waterer with heater is used to heat the drinking water
� Poultry waterer with heater is made up of HDPE and 2.5 liter capacity
� Poultry waterer with heater consists of a heating element, thermostat and indicator
� The thermostat cut off temperature at 80o C, after reaching room temperature, the water will be given to chicks
� No need to add water sanitizer
� It is portable and washable
� Cost of production Rs.1,100
Innovators : Dr. P. Tensingh Gananaraj, Dr. A. Sundaresan and Dr. S. Ezhilvalavan
UIIC 032
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
71g©izahs®fS¡fhd òÂa bjhêšE£g§fŸ m¿Kf« k‰W« btëpL - 2016
nkY« étu§fS¡F
mŠrš Kftç
nguhÁça® k‰W« jiyt®
gšfiy¡fHf MuhŒÁ¥ g©iz
jäœehL fhšeil kU¤Jt m¿éaš gšfiy¡fHf«
khjtu« ghšg©iz, br‹id - 600 051
bjhiyngÁ k‰W« ä‹dŠrš
bjhiyngÁ : 044-2555 1571; ä‹dŠrš: [email protected]
tiunthiy vL¡f
The Professor and Head, URF, Chennai - 51
M‹iy‹ gçt®¤jid
t§»æ‹ bga® : ôåa‹ ng§¡ M¥ ϪÂah
»is : khjtu«
t§» fz¡F v© : 332902010726941Iv¥v°Á nfhL : UBIN0533297
F¿¥ò : cgfuz§fŸ 40 eh£fS¡FŸ tH§f¥gL«
ngh¡Ftu¤J¢ bryÎ g©izahs®fisna rhU«
New Technologies for livestock farmers - introduction and Release - 2016
Tamil Nadu Veterinary and Animal Sciences University
72
For more information please contact
Postal Address
The Professor and HeadUniversity Research FarmTamil Nadu Veterinary and Animal Sciences UniversityMadhavaram Milk Colony, Chennai - 600 051
Phone & Email
Phone : 044-2555 1571; e-mail : [email protected]
DD in favour of
The Professor and Head, URF, Chennai - 51
For online transaction
Bank Name : Union Bank of IndiaBranch : MadhavaramAccount No. : 332902010726941IFSC code : UBIN0533297
Remarks : Goods / item will be delivered about 40 days from the date of orderTransportation arrangements should be made at your own cost